United States
Environmental Protection
Agency
Office of Water
(4203)
EPA833-B-93-005
October.1993
v>EPA NPDES Industrial
Permit Abstracts 1993
Recycled/Recyclable
Printed with Soy/Canola Ink on paper that
contains at least 50% recycled liber
-------
-------
NPDES INDUSTRIAL PERMIT ABSTRACTS 1993
Office of Wastewater Enforcement and Compliance
Permits Division
U.S. Environmental Protection Agency
Washington, D.C.
Sixth Edition
October 1993
-------
This sixth edition of the NPDES permit abstracts, NPDES Industrial Permit Abstracts 1993. was
prepared by Science Applications International Corporation (SAIC), Falls Church, Virginia, under
contract to the U.S. Environmental Protection Agency. The EPA Project Manager was Deborah
Nagle, Environmental Engineer.
-------
TABLE OF CONTENTS
INTRODUCTION iii
PERMIT ABSTRACTS 1
APPENDIX A - TREATMENT TECHNOLOGY ABBREVIATIONS A-l
APPENDIX B - PARAMETERS PRESENT IN THE PERMITS B-l
APPENDIX C - LIST OF PERMITS C-l
APPENDIX D - LIMITATIONS/MONITORING BASIS INDEX D-l
APPENDIX E - SPECIAL CONDITIONS INDEX E-l
APPENDIX F - EFFLUENT GUIDELINES INDEX F-l
APPENDIX G - POLLUTANT INDEX G-l
APPENDIX H - RECEIVING WATER INDEX H-l
APPENDIX I - INDUSTRY TYPE (SIC CODE) INDEX 1-1
-------
-------
INTRODUCTION
National Pollutant Discharge Elimination System (NPDES) permit abstracts are a valuable
tool for permit writers to use in determining creative solutions to pollutant problems, and in drafting
technically and legally substantiated permit conditions. This updated permit abstracts version was
compiled in recognition of the need for abstracts of recent permits to reflect NPDES program
progress and recent policies and initiatives. These abstracts were written based on voluntary
submissions of NPDES industrial wastewater permits, requested from States and EPA regional
permitting authorities. This edition of the abstracts includes permits from 37 states.
The permit abstracts are organized into five sections: general information, permit summary
information, outfall information, special conditions information, and dates. These abstracts are
indexed by the following subjects, to provide quick searches:
• Type of limitations/monitoring conditions, such as best professional judgement or
state water quality standards
• Type of special condition, such as requirements for a best management practices plan
or a storm water plan
• Effluent guidelines
• Pollutant
• Receiving water
• Type of industry, i.e., SIC code
The remaining discussion is on the contents of the five sections of the abstract.
GENERAL INFORMATION
The first two lines of the permit abstract provides general information on the permit. This
includes the facility name, the NPDES permit number, a description of what the facility does, and
the SIC code. The general information comprises a header for the permit abstract, and thus can be
found repeated on each page of a multiple page permit abstract. Exhibit 1 provides an example of
the general information section, as well as the summary information which is discussed in the next
section.
Efforts were made to record the facility name as uniquely as possible in order to differentiate
among facilities. This was particularly true where more than one facility was owned or operated by
the same corporation. For example, a permit issued to "Horatio Power and Light" may be abstracted
as "Horatio P&L, Radon Station." Since this approach was taken, the facility name recorded for
abstract purposes may not be spelled the same way as shown on the permit. The permit number was
in
-------
abstract purposes may not be spelled the same way as shown on the permit. The permit number was
taken from the permit; however, where additional numbers or letters were found on the permit, these
were not included.
A field for entering the facility description provides a simplified summary of the primary
operations at the facility and the representative SIC code.
SUMMARY INFORMATION
To provide the permit writer with a quick overview of the approach taken in a permit, a
summary of the bases for the permit limitations and the special conditions was created in checklist
format. This is displayed in the two "quick look" menu tables in Exhibit 1. The permit writer
should be able to find further information on those items flagged in the "quick look" tables by
reading the limitations basis discussion or the special conditions basis discussion.
For the limitations basis "quick look" table, the following basis types were included:
• Effluent limitations guidelines (ELGs) - If ELGs as cited in 40 CFR were referred
to as the basis for any limitation in the permit, this was flagged yes.
• Water quality standards (WQSs) - If State WQSs were cited as the basis for any
limitation in the permit, this was flagged yes.
EXHIBIT 1. General and Summary Information in the Abstract
Facility Name: Johnson & Johnson Advanced Mat Permit Number: GA0001791
Facility Description: Manufactures woven gauze products and film from polymers . SIC Code: 2833
Limit
Basis:
Special
Conditions:
ELGs
BHPs
I
WQSs
^
Storm
Water
BPJ
I
Sediment
Monitoring
T
WQ
Survey
WET
Limits
Bio
Survey
WET Testing
Only
T
Multiple
Categories
MOLs
I
Tiered
Limits '•
Monitoring
I
• Other
Other
I
Abstract Information:
Complete; Outfalls 001 (A and B created for abstracting purposes), and 002.
IV
-------
• Monitoring only - When this was flagged yes, the permit requires the permittee to
monitor for a specified parameter, with no limitation established.
• Whole effluent toxicity (WET) — If WET limits are in the permit, this field was
flagged yes.
• WET testing only - If WET testing only was flagged with a yes, it means that the
permittee is required to conduct WET testing, but no limitations were established.
• Multiple categories - If more than one ELG was cited as the basis for limitations, this
is flagged yes.
• Tiered production - If any limitation is variable due to varying production levels or
seasonal requirements, this was flagged with a yes.
• Other - If the basis for any limitation was cited as anything other than those described
above, such as previous permit limits (antibacksliding), then this was flagged with a
yes.
The special conditions selected to appear in the "quick look" table included:
• Best management practices (BMPs) and BMP plans - If BMPs are addressed in the
permit, or the permittee is required to develop a BMP plan, this was flagged with a
yes.
• Storm water pollution prevention plans - If the permit contains conditions which
specifically address storm water, this was flagged with a yes.
• Sediment sampling - If the permit contains conditions requiring the permittee to
analyze sediment samples, this was flagged with a yes.
• Water quality surveys - If the permit contains conditions requiring the permittee to
conduct water quality studies or surveys (i.e., analyze for priority pollutants in the
receiving stream annually), this was flagged with a yes.
• Biological surveys - If the permit contains conditions requiring the permittee to
conduct biological surveys (i.e., estimate populations of specified species), this was
flagged with a yes.
• Toxicity reduction evaluations (TREs) - If the permit contains the requirement to
conduct a TRE in the event that the facility is not compliant with the WET
limitation(s), this was flagged with a yes.
• Specific method detection levels (MDLs) - If the permit contains limitations that are
at or below the ability of analytical laboratories to measure, and provides instructions
for MDLs, this was flagged with a yes.
-------
• Monitoring as a special condition - If monitoring is established in Part III of the
permit, or elsewhere in the permit, apart from the limitations section, this was
flagged with a yes.
• Other special conditions - If other special conditions worth noting, such as sludge
conditions, are found in the permit, this was flagged with a yes.
The information summary section also contains two lines entitled "Abstract Information."
This is important information for two reasons. First, this field is used to note when the abstract lists
less than all of the outfalls. This was done to avoid redundancy and to minimize resources. A
partial abstract was developed only when the limitations and monitoring requirements and their bases
were identical for more than one outfall. A second purpose served by this field is to note when
artificial outfall designations were created for abstracting purposes. When tiered limits (seasonal or
production based) were included in a permit, separate outfall designations were created within the
abstract and noted in this field (i.e., Outfall 001 became Outfalls 001A and 001B). This field was
also useful when assigning a numerical designation to an outfall identified only by narrative in a
permit.
OUTFALL SPECIFIC INFORMATION
Information on each outfall is displayed in the abstract as shown in Exhibit 2. The Outfall
designation (number), the receiving water, the effluent treatment abbreviation(s), and the amount and
components of the discharge are followed by a table containing the limitations and monitoring
requirements for each parameter. This table is followed by a summary of the basis for the
limitations and monitoring conditions as provided in the permit fact sheet.
With the exception of the treatment technologies, the outfall-specific information in most
cases was literally recorded from the permit and the fact sheet. Each discharge from the facility is
represented by an outfall identification number. When an outfall identification number was not
included in the permit, it was assigned as part of the abstracts process and noted under "Abstract
Information" in the abstract summary. The outfall's receiving water was generally recorded literally.
In some cases the description of the receiving waters had to be shortened. This was accomplished
by including only the first proper name of the water. Where an internal outfall was abstracted, the
receiving water was identified as the receiving outfall (e.g., internal to Outfall 003). The description
of the discharge amount and components was usually found in the fact sheet. In many cases, the
quantity of discharge was not identified and this was signified by "Unspecified amount of .'...."
Where there were lengthy outfall component identifications, only the primary component(s) of the
discharge were summarized.
To summarize the treatment technologies used by the facilities, the familiar treatment
technology codes and symbols used as part of EPA's Risk Reduction Engineering Laboratory
(RREL) database were incorporated. Some additional codes were employed in order to incorporate
treatment descriptions literally and thus avoid ambiguities. Appendix A provides a list of the
abbreviations representing the treatment technologies and their corresponding term.
VI
-------
EXHIBIT 2. Outfall Information in the Permit Abstract
Outfall: 001A | Receiving Water: Redwine Creek 1 Treatment: Eq •+ AS + Dis
Amount/Components^ ^ ^ ^^ ^ consisting of process wastewater treatment plant effluent, effective 9/4/92 through
5/31/93
Parameter
BODS
COD
Cr (T)
Cu
FC
Flow
PH
Phenols
Sulfide
TSS
Zn
Limitations
Daily
Average
184.000000 Ib/d
N/A
1304.000000 Ib/d
N/A
2.000000 Ib/d
N/A
Report
N/A
N/A
N/A
N/A
Report
N/A
N/A
2.000000 Ib/d
N/A
4.000000 Ib/d
N/A
408.000000 Ib/d
N/A
Report
N/A
Dai ly
Maximum
368.000000 Ib/d
N/A
2607.000000 Ib/d
N/A
4.000000 Ib/d
N/A
Report
N/A
N/A
400.000000
N/A
Report MGD
N/A
N/A
4.000000 Ib/d
N/A
8.000000 Ib/d
N/A
816.000000 Ib/d
N/A
Report
N/A
Other
Units not specified
Units: #/100 ml
Between 6.0 su and 9
.0 su
Units not specified
Monitoring Requirements
Frequency
3/week
3/week
1 /quarter
1 /month
*•
1/week
continuous
3/week
1 /quarter
1 /quarter
3/week
1/year
Sample Type
24hr composite
24hr composite
24hr composite
24hr composite
grab
record
grab
grab
grab
24hr composite
24hr composite
LlmltThe°BOD5°"imitat1onsSare based on State water quality control regulations for the protection of fishing designated
uses and calibrated stream model calculations (assumed from information given in rationale). The remaining limits
are BPJ-based on "the plant's demonstrated performance." The basis of the monitoring conditions was not described.
treatment descriptions literally and thus avoid ambiguities. Appendix A provides a list of the
abbreviations representing the treatment technologies and their corresponding term.
The limitations and monitoring conditions table is composed of five columns: the parameter
name, the average limit with units, the maximum limit with units, other limits or information, the
frequency for monitoring conditions, and the sample type. Generally, the elemental form or
abbreviated common name has been used as the parameter name. No interpretation was made as to
the form of the parameter. If the metal "chromium" was limited in the permit, "Cr" was listed in
the abstract; thus, the reader of both the permit and abstract is faced with interpreting whether
chromium is intended to be limited in dissolved, total recoverable, or total form. Appendix B
contains a list of parameters together with the term that appears in the abstract.
VII
-------
The average and maximum limits columns may be titled daily or monthly or weekly,
depending on the permit. The third column, designated as "other," provides an area to list pH limits
or additional limits descriptors (e.g., instantaneous maximum annual average).
In recording data for any parameter, two lines are used, a top and bottom line. The mass-
based limits (and reporting requirements) are placed on the top line and other limits, typically
concentration, are placed on the second line. The amount of space allotted for entering units was
limited to 4 characters due to space constraints. This allowed for the more common units to be
entered including: for concentration — mg/1, ug/1, ng/1, and pg/1; for flow — MGD, gpd, and cfs;
and for mass — kg/d or Ib/d. However, by limiting this field to 4 characters, units such as #/100ml,
fibers/1, and pCi/1 could not fit and were therefore recorded in the "Other" column.
Fields for the frequency for monitoring and sample type were recorded in a fashion similar
to that found in NPDES permits. Accurately recording frequencies and sample types often required
reading additional permit conditions and footnotes, particularly when determining WET monitoring
requirements and the type of composite samples to be used. To assist in consistency between
recording monitoring frequencies, data was recorded as I/year rather than one per year, one/year
or modifications thereof. In some cases, information had to be shortened. For example, 24 hour
flow weighted composite was shortened to 24hr fw composite. This same type of abbreviation was
used for time weighted composites (i.e., 8hr tw composite). Generally, a time frame for the
composite was entered where it was contained in monitoring requirements or could be gathered from
definitions; otherwise, "composite" was specified with no time frame reference.
SPECIAL CONDITIONS
As the NPDES permit program matures, the need for the imposition of special conditions to
achieve the goals and intent of the Clean Water Act as well as to support Agency initiatives have
increased. In developing permit abstracts, an attempt has been made to provide as great a' level of
detail as possible in summarizing the special conditions and their basis. The special conditions which
have been flagged in the "quick look" table as being present in the permit should be discussed near
the end of the permit abstract under "Special Conditions Basis". An example of this is shown in
Exhibit 3.
vm
-------
EXHIBIT 3. Special Conditions and Dates in the Permit Abstract
Special Conditions Basis: .
The permit requires the implementation of baseline BMPs. Storm water discharges
-------
EXHIBIT 4. Considerations for Abstracting the Basis for Special Conditions
WQ Survey
,/
Bio-Survey
£
TREs
/
MDLs
*L
Monitoring
,/
Other
S
Dilution studies ;
Chemical-specific receiving stream water quality analyses
Receiving stream influent analyses, except where established to
determine a net technology-based limit
Criteria development support
Effluent dispersion models
Receiving stream benthic organism evaluations
Presence/absence of certain species
Ecosystem evaluations
Proliferation of certain organisms
Bioaccumulation studies
• Toxicity reduction evaluations
• Specified levels of detection or quantification during analysis
• Discharge-specific MDL development requirements
• Other chemical-specific monitoring not reported on DMRs and not listed
above
• Ground water monitoring requirements
• Miscellaneous studies not listed above
• Discharge restrictions not listed above
PERMIT AND ABSTRACT DATES
Fields for the effective date, expiration date, and abstract date were also provided as part of
the abstract summary. In the case where states sent draft permits, no date was entered'and the
program indicated "Not specified" for those blank dates. An example of these dates was shown in
Exhibit 3.
CONCLUSION
It is important to adequately substantiate conditions such that they are not considered arbitrary
and capricious, and are not challenged by permittees. Permit abstracts can be a strong permitting
tool when the abstracts have been developed in a thorough and technically correct manner. It is
hoped that this set of abstracts will be a useful reference to the permit writer.
-------
Facility Name: Tesoro Alaska Petroleum Co. Permit Number: AK0000841
Facility Description: Refining of crude oil to produce a variety of petroleum products SIC Code: 2911
Monitoring
Limit ELGs WQSs BPJ Only
Basis: III I
Storm WQ
Special BMPs Water Sediment Survey
Conditions: 2. - - -
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
L I - - I
Bio
Survey TRES MDLs Monitoring Other
Z I -11
Abstract Information:
Complete: Outfalls 001a, and 001b.
Outfall: 001A | Receiving Water: Cook Inlet Treatment: API, DAF, AerL, RBC, AerL
Amount/Components :
0.844 HGD; Non-contact cooling water, process water, GW remediation, tank draining, and stormwater.
Parameter
Acute WET
Aromatic hydrocar
bons
BODS
Chronic WET
COD
Cr (T)
Cr+6
Flow
NH3-N
O&G
PAHs
PH
Phenols
Sulfide
TPH
TSS
Limitations
Average
M/A
N/A
N/A
N/A
204.000000 Ib/d
N/A
N/A
N/A
1320.000000 Ib/d
N/A
1.290000 Ib/d
N/A
0.100000 Ib/d
N/A
N/A
N/A
85.900000 Ib/d
N/A
48.300000 Ib/d
N/A
N/A
N/A
N/A
N/A
0.620000 Ib/d
N/A
1.080000 Ib/d
N/A
N/A
N/A
166.300000 Ib/d
N/A
Maximum
N/A
Report
N/A
0.400000 mg/l
371.400000 Ib/d
N/A
N/A
Report
2464.900000 Ib/d
N/A
2.430000 Ib/d
N/A
0.190000 Ib/d
N/A
N/A
Report
190.100000 Ib/d
N/A
86.900000 Ib/d
N/A
N/A
Report
N/A
N/A
1.340000 Ib/d
N/A
2.420000 Ib/d
N/A
N/A
10.000000 mg/l
261.400000 Ib/d
N/A
Other
See below
Total; See below
See below
Between 6.5 su and 9
.0 su
Monitoring Requirements
Frequency
1/quarter
1 /month
1/week
1/quarter
1 /month
1/quarter
1/quarter
continuous
1 /month
1/week
1 /month
1/week
1/week
1 /month
1 /month
Sample Type
grab
grab
24hr composite
grab
grab
grab
grab
record
grab
24hr composite
grab
grab
grab
grab
grab
Limitations/Monitoring Basis:
Chronic testing is required during May, August, November and February. Acute testing is required in May and August.
Where Acute and Chronic testing are required in the same month, the tests must be performed on split samples. The
specific protocols are provided in the permit. The permit also requires that there be no discharge of floating
solids, visable foam, or oily wastes which produce a sheen on the surface of the receiving water. The limits for pH
are WQ-based and ensure compliance with State WQS. All other limits are a combination of BPJ and ELGs (40 CFR 419).
Historical BPJ limits were determined to be more stringent than ELGs for the older portion of the facility and were
Page:
-------
Facility Name: Tesoro Alaska Petroleum Co. Permit Number: AK0000841
Facility Description: Refining of crude oil to produce a variety of petroleum products SIC Code: 2911
retained. For more recent expansions, ELGs were utilized. The resultant final limits are a mathematical
combination of the BPand ELG limits. The permit also defines "Total aromatic hydrocarbons" as the summation of
aromatic hydrocarbons and PAH. Monitoring requirements are based on the Agency's determination of the minimum
necessary to adequately monitor plant performance. Quarterly toxicity testing for chronic toxicity is required
using one of the following species: purple sea urchin, green sea urchin, or sand dollar. Acute toxicity testing
must be conducted on juvenile salmonids at a frequency of 2 per year.
Outfall: 001B | Receiving Water: Cook Inlet | Treatment: HT, API, DAF
Amount/Components :
Unspecified; itermittant discharge from ballast treatment facility. Combines with 001a prior to discharge.
Parameter
Aromatic hydrocar
bons
BOOS
COD
Flow
OSG
PAHs
PH
TPH
TSS
Limitations
Monthly
Average
N/A
H/A
0.210000
N/A
2.000000
N/A
N/A
N/A
0.042000
N/A
N/A
N/A
N/A
N/A
N/A
N/A
0.170000
N/A
Dai ly
Maximum
N/A
0.400000 mg/l
0.400000
N/A
3.900000
N/A
N/A
Report
0.084000
N/A
N/A
Report
N/A
N/A
N/A
10.000000 mg/l
0.250000
N/A
Other
Total; See below
Units: lb/1000 gallo
ns
Units: lb/1000 gallo
ns
Units: lb/1000 gallo
ns
Between 6.5 su and 9
.0 su
Units: lb/1000 gall
ons
Monitoring Requirements
Frequency
1 /month
1 /quarter
1/quarter
cont i nuous
1/week
1 /month
1/week
1/month
1/quarter
Sample Type
grab
grab
grab
record
24hr composite
grab
grab
grab
grab
Limitations/Monitoring Basis:
Limits for this outfall are carried over from the previous permit and are BPJ-based. The existing limits are more
stringent than BAT and BCT limits for this type of discharge, and are therefore retained. The permit also requires
that there be no discharge of floating solids, visible foam, or oily wastes which produce a sheen on the surface of
the receiving water. The permit also defines "Total aromatic hydrocarbons" as the summation of aromatic
hydrocarbons and PAH. Monitoring requirements are based on the Agency's determination of the minimum necessary to
adequately monitor plant performance.
Special Conditions Basis:
A special condition is included which requires additional monitoring under specified circumstances. The permit
requires that when "catalyst is regenerated in the reformer unit, the permittee shall monitor chlorinated
dibenzodioxins (CDD), chlorinated dibenzofurans (CDF), total organic halides (TOX) and adsorbable organic halogen
(AOX) in the waste stream connected to the regeneration unit". The specific requirements for this testing are also
provided. This requirement is BPJ-based, in consideration of results from Canadian studies showing that these
pollutants were present in similar discharges. In addition, if WET testing indicates toxicity, the permittee must
perform a TIE and TRE. Specific conditions and requirements for TIE and TRE are included.
Effective Date: 04/18/91 Expiration Date: 04/17/96 Abstract Date: 06/11/93
Page:
-------
Facility Name: ARCO Alaska, Inc.- Prudhoe Bay Permit Number: AK0029840
Facility Description: Seawater treatment used in groundwater injection to extract crude oil. SIC Code: 1311
Limit
Basis:
Special
Conditions:
ELGs
BMPs
J.
WQSs
J.
Storm
Water
BPJ
J.
Sediment
I
Monitoring
Only
J.
WQ
Survey
J.
WET
Limits
Bio
Survey
J.
WET Testing
Only
TRES
Multiple
Categories
MDLs
Tiered '
Limits
Monitoring
J.
Other
Other
\bstract Information:
Complete: Outfalls 001, 002, and 003.
Outfall: 001
Receiving Water: Prudhoe Bay
Treatment: Not described.
mount/Components: . '
12.4 MGD (max); Discharge from seawater treatment system including seawater strainer and filter backwash.
Parameter
Flow
PH
Temp.
TRC
TSS
Limitations
Monthly
Average
9.000000 MGD
N/A
N/A
N/A
N/A
N/A
N/A
50.000000 ug/l
N/A
Report
Daily
Maximum
12.400000 MGD
N/A
N/A
Report
N/A
Report
N/A
150.000000 ug/l
N/A
Report
Other
Between 6.0 SU and 9
.0 SU
See below
See below
Monitoring Requirements
Frequency
continuous
See below
See below
6/day
1/week
Sample Type
record
See below
See below
grab
grab
Limitations/Monitoring Basis: . .
Flow limits are BPJ and are used to ensure that modeling assumptions are valid. TSS requirements are intended to
evaluate impact of the discharge. The permit further states that the TSS concentration shall be estimated on the
basis of intake and output concentrations. Limits were not deemed necessary. The limits for TRC are established on
a seasonal basis, dependent on ice cover, and include a monthly average and daily maximum concentrations for each
season. The limits shown above apply during the "open-water" season
-------
Facility Name: ARCO Alaska, Inc.- Prudhoe Bay
Permit Number: AK0029840
Facility Description: Seauater treatment used in groundwater injection to extract crude oil.
SIC Code: 1311
Outfall: 003 | Receiving Water: Prudhoe Bay
Treatment: AS
Amount/Components:
0.050 HGO (max); Effluent from sewage treatment plant.
Parameter
BOOS
FC
Flow
PH
TRC
TSS
Limitations
Monthly
Average
H/A
30.000000 mg/l
H/A
200.000000
H/A
H/A
H/A
H/A
H/A
0.500000 mg/l
H/A
30.000000 mg/l
Daily
Maximum
N/A
60.000000 mg/l
H/A
400.000000
50000.000000 gpd
N/A
N/A
Report
H/A
1.000000 mg/l
N/A
60.000000 mg/l
Other
45 mg/l Weekly Avera
ge
Units: #/100 ml
Between 6.5 su and 8
.5 su
45 mg/l Weekly Avera
ge
Monitoring Requirements
Frequency
3/week
5/month
continuous
1/day
1/day
3/week
Sample Type
grab
grab
record
grab
grab
grab
Limitations/Monitoring Basis:
The basis of the flow requirement is not described. The weekly and monthly average TSS and BODS limits are based on
BCT standards for secondary treatment of domestic wastewater. Daily maximum limits are based on State requirements.
In addition to the above limits for BODS and TSS, permit requires that "the monthly average percent removal of TSS
and BODS shall not be less than 85 percent". This requirement is also based on BCT for secondary treatment. The FC
limits are BPJ-based and ensure that State WQS are met. The TRC limits are BPJ-based using BAT as the standard.
The pH limits are based on BCT for secondary treatment, of domestic wastewater, and ensure compliance with State WQS.
Special Conditions Basis:
In addition to the specific limitations above, the permit contains several general discharge limitations, including:
A prohibition on the discharge of any constituents other than those listed in the permit above at concentrations
exceeding water quality standards or criteria; a prohibition on the discharge of diesel oil, halogenated phenolic
compounds, trisodiuro nitrilotriacetic acid, sodium chromate or sodium dichromate; a prohibition on the discharge of
floating solids or visible foam in other than trace amounts. Additionally, discharges shall not cause a film;
sheen, or discoloration on the surface or floor of the water body or adjoining shorelines; and a prohibition on the
discharge of surfactants, dispersants and detergents, except as necessary to comply with the safety requirements of
OSHA and the Minerals Management Service. The permit also requires that effective 80 days after the effective date
of the permit, an effluent sample shall be taken annually from the combined discharge and analyzed for all I
halogcntatcd compounds listed as priority pollutants. Specific monitoring and reporting conditions are included.
The permit also requires the development of a BMP Program to prevent or minimize the dishcarge of pollutants.
Specific content requirements of the BMP Plan are provided. The permit also includes specific "Environmental
Monitoring Requirements", this requires implementation of an environmental monitoring plan in years two and four of
the permit and includes study of WQ impacts, sediment impacts, and biological impacts of the discharge. Specific
content and reporting requirements are provided. The requirements for clarifying agents include acute and chronic
toxicity testing and BMPs. Specific protocols for toxicity testing are included.
Effective Date: 12/31/92
Expiration Date: 12/31/97
Abstract Date: 06/14/93
Page:
-------
Facility Name: Western Gold Exploration & Min Pe™»t Number: AK0043192
Facility Description: Offshore placer mining using a bucket-ladder dredge mining vessel SIC Code: 1041
Monitoring
Limit ELGs WQSs BPJ Only
Basis: -11 ±
Storm WQ
Special BMPs Water Sediment Survey
jnditions: j_ z. J- J-
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
Bio
Survey TRES MDLs Monitoring Other
1 - I J- -
Abstract Information:
Complete/Outfalls 001, 002, 003, 004, and 005.
Outfall: 001 | Receiving Water: Norton Sound Treatment: Not described.
Amount/Components:
Unspecified/discharge from dredge-ladder buckets.
Parameter
SS
Limitations
Monthly
Average
N/A
21.000000 m3/h
Daily
Maximum
N/A
N/A
Other
42 m3/hr inst. max.
Monitoring Requirements
Frequency
4/month
Sample Type
estimate
lm1 Limit8 foTWis based on guidelines developed for dredge and fill operations under Section 404 of the CWA. Limit
also ensures that BCT is used by permittee. Monitoring requirements are not discussed.
Outfall: 002 | Receiving Water: Norton Sound I Treatment: Not described.
Amount/Components:
Unspecified/discharge from Trommel Screen Rock Chute.
Parameter
SS
Limitations
Monthly
Average
N/A
N/A
Daily
Maximum
N/A
Report
Other
Units: m3/hr
Monitoring Requirements
Frequency
4/month
Sample Type
estimate
Limitations J^1.^1.1^ requirements are in two parts; one for the "large fraction" and one for the "small fraction". The
large fraction is defined as particles with size greater than 1.9 cm, and the small fraction consists of particles
less than or equal to 1.9 cm. See basis for Outfall 001
Outfall: 003 Receiving Water: Norton Sound Treatment: Not described.
Amount/Components :
56 MGD (max)/Process tailings launders.
Parameter
As (TR)
Cu (TR)
Flow
Hg (TR)
Ni (JR)
Pb (TR)
Limitations
Monthly
Average
N/A
234.000000 ug/l
N/A
52.200000 ug/l
N/A
45.000000 MGD
N/A
0.450000 ug/l
N/A
149.400000 ug/l
N/A
100.800000 ug/l
Maximum
N/A
N/A
N/A
N/A
N/A
56.000000 MGD
N/A
N/A
N/A
N/A
N/A
N/A
Other
1,242 ug/l inst. max
52.2 ug/l inst. max.
37.8 ug/l inst. max.
1,350 ug/L inst. max
2,520 ug/l inst. max
Monitoring Requirements
Frequency
4/month
4/month
1/day
4/month
4/month
4/month
Sample Type
grab
grab
estimate
grab
grab
grab
Page:
-------
Facility Name: Western Gold Exploration & Min Permit Number: AK0043192
Facility Description: Offshore placer mining using a bucket- ladder dredge mining vessel SIC Code: 1041
TSS
N/A
N/A
N/A
15000.000000 mg/t
N/A
Report
N/A
N/A
Units: m3/hr
30,000 mg/l inst. ma
X.
4/month
1/day
estimate
grab
Limitations/Monitoring Basis: - ..
The flow limits are WQ-based to ensure compliance with State WQS for turbidity at the edge of the mixing zone. The
SS requirements apply only to the "small fraction" (<1.9 cm), and are a combination of WQ and technology-based
limits. The SS limits ensure that the State WQS for turbidity is met and that BAT is applied to the wastestream.
The TSS requirements apply only to the "combination of silt and clay particles," and are WQ-based. The toxic metals •
limits ensure that State WQS are not exceeded, and are, therefore, WQ-based. Monitoring for all metals must provide
analyses for both "total recoverable" and "dissolved" fractions. EPA may modify this requirement if a relationship
between these fractions can be established. Minimum detection levels for the metals analyses are also specified A
requirement is also included which states that the average daily discharge of process tailings shall not exceed 10%
solids, of which the daily average fines content shall not exceed 25% and the maximum fines content shall not exceed
60». If these requirements are exceeded, the permittee must notify EPA and ADEC within 24 hours, and immediately
take steps to correct the problem.
Outfall: 004 | Receiving Water: Norton Sound | Treatment: Not described.
Amount/Components:
0.34 MGO
-------
Facility Name: Western Gold Exploration & Win
Permit Number: AK0043192
Facility Description: Offshore placer mining using a bucket-ladder dredge mining vessel
SIC Code: 1041
discharge SS to the area from which they were dredged; a requirement regarding the allowable_type and operat on of
the intake structure- and, a requirement to record the number and types of marine life entrained bythe dredging
process? ThTpermi? also'contains special conditions for: A "Quality Assurance/Quality Control Plan" to be
developed by the permittee; a "Best Management Practices Plan" to be developed by the permittee to minimize the
poten??al for release of pollutants; an "Environmental Monitoring Program" which requires the permittee to conduct a
batSric survey, evaluate water quality impacts, evaluate sediment impacts, and evaluate biological impacts in
thedredg ng area. The environmental monitoring program contains specific development, implementation, and
reporting requirements for each program element. The test methods and detection levels are specified for metals
analyses at outfall 003 and 004. The permit requires the permittee to conduct a bioaccumulation study of trace
11/23/90 ,
Expiration Date:
11/24/95
06/10/93
Page:
-------
FscfUty Home: Westward Seafoods, Inc., Dutch
Permit Number: AK0049786
Facility Description! Processing of seafoods, including finfish, crab, fishmeal, and Surimi.
SIC Code: 2092
limit
Basis:
ELGs
I
WQSs
I
BPJ
I
Monitoring
Only
•i
WET
Limits
WET Testing
Only
Multiple
Categories
Tiered
Limits
I
Other
Special
Conditions:
BHPs
i
Storm
Water
Sediment
J.
WQ
Survey
J.
Bio
Survey
J.
TRES
MDLs
Monitoring
J.
Other
Abstract Information:
nnt^rrc'nr"""^ O'"'002'003'004'^, and 006. Only Outfall 001 discharges to the receiving water, the other
outfalls represent internal process wastestreams
Outfall: 001 | Receiving Water: Captains Bay
Treatment: Scr
Amount/Components:
Unspecified/All process wastestreams including fish transport water.
Parameter
FloM
ptl
TRC
Limitations
Monthly
Average
N/A
M/A
N/A
M/A
N/A
N/A
Daily
Maximum
N/A
Report MGD
N/A
Report
N/A
Report
mg/l
Other
Between 6.5 su and 8
.5 su
Monitoring Requirements
Frequency
1/week
1/week
1/week
Sample Type
record
grab
grab
imitations/Monitoring Basis:
The final pH limit is based on protection of Alaska WQS. Monitoring frequencies are based on the Agency's
determination of the minimum sampling required to adequately monitor facility performance. Flows must be
thn°£?^e!"?,!!?"'t0rin9 eVTu,- •* L?aSt °ne half °f the TRC san)Ples must be taken durin9 or Mediately after
the plant sanitation process (chlorine is not used for wastewater treatment). The status of the waste handling
system must be recorded and made available to EPA upon request. N«IUHMS
Jutfall: 002 | Receiving Water: Internal outfall via 001
Treatment: Scr
tawunt/Components:
Unspecified/Wastestream from finfish processing.
Parameter
Flow
OSG
TSS
Limitations
Average
N/A
N/A
N/A
N/A
N/A
N/A
Maximum
N/A
Report MGD
N/A
Report mg/l
N/A
N/A
Other
See below
See below
Monitoring Requirements
Frequency
1/week
1/week
1/week
Sample Type
record
grab
24 hr fw comp
imitations/Monitoring Basis:~"~
ha! Tit0** afe bai!ed °" ^Pi1^? !LGs <4° CFR 408> and BPJ. Permit incorporates applicable
^ c.r o°Lth!-typf? °f flnflsh Processed- The production-based limits for salmon, halibut and
i«hrif .2F1 »?' ProdV=*lon limits for "bottomfish" are not applicable to Alaskan processors but are
included based on BPJ. Permittee must calculate the allowable mass-based limit based on actual production rate at
hi^£3212!r!n8- A" at*achment to the P6™* P^vides instruction on how limits should be calculated Flow must
ladings monitoring events. Monitoring results must be included on DMRs as both concentrations and mass
Page:
-------
Facility Name: Westward Seafoods, Inc., Dutch Permit Number: AK0049786
Facility Description: Processing of seafoods, including finfish, crab, fishmeal, and Surimi. SIC Code: 2092
Outfall: 003 | Receiving Water: Internal outfall via 001 Treatment: Not described
Amount/Components :
Unspecified/Wastestream from crab processing.
Parameter
Flow
Limitations
Average
N/A
N/A
Maximum
N/A
Report MGD
Other
Monitoring Requirements
, Frequency
1/week
Sample Type
record
Limitations/Monitoring Basis:
Limits are based on ELGs <40 CFR 408) for remote facilities in Alaska. In addition to flow monitoring, the
following requirements are included: (1.) No pollutants may be discharged with exceed 0.5 inch in any dimensions;
(2). All grinding equipment shall be maintained in operating condition at all times, (3.) All grinding equipment
installed shall be actively .used prior to discharging during crab processing activities; (4.) Grinding equipment may
not be modified without prior approval. The permit prohibiting the accumulation of crab processing wastes on the
bottom of the receiving water to an extent greater than 2 acres in size is water quality- based.
Outfall: 004 | Receiving Water: Internal outfall via 001 | Treatment: Not described
Amount/Components:
Unspecifed/Wastestream from fishmeal processing, including evaporator condensate, and scrubber. Does not include
stickwater.
Parameter
BODS
Flow
O&G
PH
TSS
Limitations
Monthly
Average
3.800000
N/A
N/A
N/A
0.760000
N/A
N/A
N/A
1.500000
N/A
Daily
Maximum
6.700000
N/A
N/A
Report MGD
1.400000
N/A
N/A
N/A
3.700000
N/A
Other
Units: lb/1000 Ib
Units: lb/1000 Ib
Units: lb/1000 Ib
Monitoring Requirements
Frequency
1/week
1/week
1/week
1/week
1/week
Sample Type
grab
record
grab
grab
grab
Limitations/Monitoring Basis:
Limitations on the non-stickwater discharges are based on the BPJ using the NSPS ELGs of 40 CFR 408.150. Basis of
pH limit was not discussed. Flow must be recorded during monitoring events.
Outfall: 005 Receiving Water: Internal outfall via 001 Treatment: Not described
Amount/Components :
Unspecified/Wastestream from Surimi processing.
Parameter
Flow
O&G
TSS
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
Report MGD
N/A
Report mg/l
N/A
Report mg/l
Other
Monitoring Requirements
Frequency
1/week
1/week
1/week
Sample Type
record
record
24hr fw composite
Limitations/Monitoring Basis:
In addition to the above monitoring requirements, a limit is included which prohibits pollutants which exceed 5 mm
in any dimension. This limit is based on BPJ considering available treatment technologies for this type of
wastestream. Flow must be recorded during monitoring events.
Page:
-------
Facility Harae: Westward Seafoods, Inc., Dutch
Permit Number: AK0049786
Facility Description: Processing of seafoods, including finfish, crab, fishmeat, and Surimi.
SIC Code: 2092
Outfall: 006 | Receiving Water: Internal outfall via 001
Treatment: None
Amount/Components:
Unspecified/Stickwater wastestream from fishmeal processing.
Parameter
BODS
Flow
TSS
Limitations
Average
N/A
N/A
N/A
N/A
N/A
N/A
Maximum
N/A
Report mg/l
N/A
Report MGD
N/A
Report mg/l
Other
Monitoring Requirements
Frequency
1/week
1/day
1/week
Sample Type
grab
continuous
grab
Limitations/Monitoring Basis:
In addition to the above monitoring requirements, a requirement to recover a minimum of 17 percent of the stickwater
is also included. This requirement is based on BPJ considering plant performance. Flow must be recorded during
monitoring events.
Special Conditions Basis:
Permit requires an "effluent characterization study" of outfall 001 (final effluent). The study will determine
levels of "Immediate Dissolved Oxygen Demand" (IDOD), BODS, BOD10, BOD15, and BOD20. The study must also be
conducted during periods of stickwater discharge and Jun-Oct 1991. Permit also requires "Dive Surveys" to be
conducted to determine the condition and extent of the waste pile generated by the discharge requirements for
thedive survey are also included. Permit also requires "Side Scan Sonar Monitoring" of the total areal extent of
the waste pile to determine compliance with the 2 acre zone of deposit (Outfall 003). Monitoring shall be annual in
the month of June and shall be reported in accordance with specific permit requirements. Permit also requires a
"Dissolved Oxygen Monitoring Program." Program requires monitoring of receiving water for DO, pH, salinity,
temperature, BOOS, BOD10, BOD15, and BOD20 at varying depth twice monthly during the first year of the permit, at
several locations and depths, in accordance with specific requirements. After the first year monitoriring reduced
to twice yearly. Permits also requires "Drouge Surveys" to be conducted in the vicinity of the outfall (001) once
per month beween June and October 1991. The specific requirements for these surveys are included in the permit.
Permits also requires a one year "Bay-wide Circulation Study" in accordance with specific conditions contained in
the^permit including a requirement to use at least three current meter stations. Permit also requires permittee to
assist in completion of "Harbor Management Study". Permit also requires permittee to make weekly visual inspections
of the shoreline and water surface for evidence of seafood waste accumulation, floating solids, garbage, grease,
foam, and visible oil. Permit also requires development of a BMP plan to prevent or minimize the amount of finfish
wastes passing through the 5 mn screening system. Specific requirements for this plan are included. Permit also
requires permittee to report specific production data. Permit also requires permittee to develop a "Stickwater
Recovery Plan" to reduce discharges of stickwater to the extent possible. The plan must be submitted within six
months and implemented within two years of the effective date of the permit. Permit requires notification of ADEC
Director if certain production rates are exceeded. Permit requires special waste handling in the event of
"unforeseen breakdown" of fish meal operations. Permit requires outfall 001 to be located at specific depth and
distance from shore.
Effective Date: 04/22/91
Expiration Date: Oft/22/96
Abstract Date: 06/09/93
Page: 10
-------
Facility Name: UOP - Molecular Sieve Plant . Permit Number: AL0002666
Facility Description: Manufacturer
Limit ELGs WQSs
asis: 2. J.
Storm
Special BMPs Water
Conditions: j. J.
Abstract Information:
Complete; Outfall 001 includes
for abstracting purposes.
Outfall: 001A Receiving Water:
of molecular sieve adsorbents and catalysts SIC Code: 2819
Monitoring
BPJ Only
1 J.
WQ
Sediment Survey
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
I - - - J-
Bio
Survey TRES MDLs Monitoring Other
1 L - - 4.
the combined discharge limits for 001 and 002. Ouffalls 001A and 001B have been created
Chickasaw Creek via Canal Treatment: Not described.
Amount/Components: .
Unspecified amount from combined outfalls 001 and 002, consisting of process wastewaters, cooling tower blowdown, and
boiler blowdown.
Parameter
Acute WET
Ag (TR)
Ba (T)
Br
Chloride
Co
Cr (TR)
Cu (TR)
Fl
Flow
Metals (rare eart
h)
Mn (T)
Mo
N (T)
NH3-N
Ni (TR)
P (T)
Pd (T)
• Limitations
Monthly
Average
N/A
N/A
Report
N/A
Ib/d
25.000000 ppd
N/A
1107.000000 ppd
N/A
Report
N/A
1.700000
N/A
4.100000
N/A
Report
N/A
150.000000
N/A
N/A
Report
245.000000
N/A
8.900000
N/A
20.000000
N/A
200.000000
N/A
Report
N/A
5.000000
N/A
25.000000
N/A
0.800000
N/A
Ib/d
ppd
ppd
ppd
ppd
MGD
ppd
PPd
Ib/d
Ib/d
Ib/d
ppd
ppd
ppd
Dai ly
Maximum
N/A
10.000000 %
Report Ib/d
N/A
50.000000 ppd
N/A
2213.000000 ppd
N/A
Report Ib/d
N/A
3.400000 ppd
N/A
8.200000 ppd
N/A
Report ppd
N/A
180.000000 ppd
N/A
N/A
Report MGD
368.000000 ppd
N/A
17.800000 ppd
N/A
40.000000 Ib/d
N/A
400.000000 Ib/d
N/A
Report Ib/d
N/A
10.000000 ppd
N/A
50.000000 ppd
N/A
1.600000 ppd
N/A
Other
Units: percent morta
lity
monitor when in use
monitor when in use
monitor when in use
monitor when in use
monitor when in use
monitor when in use
monitor when in use
monitor when in use
monitor when in use
monitor when in use
monitor when in use
monitor when in use
monitor when in use
Monitoring Requirements
Frequency
1 /quarter
1/week
1/week
1/day
1 /month
1/week
1/week
I/week
1/day
continuous
1/week
1/week
1/week
1/week
1/week
1/week
1/week
1/week
Sample Type
grab
composite
composite
composite
composite
composite
composite
composite
composite
recorder
composite
composite
composite
composite
composite
composite
composite
composite
Page: 11
-------
Facility Nome: UOP - Molecular Sieve Plant Permit Number: AL0002666
Facility Description: Manufacturer of molecular sieve adsorbents and catalysts SIC Code: 2819
pH
Pt
S
S04
70S
TSS
V (T)
W (T)
2n (TR>
H/A
N/A
0.800000 Ib/d
N/A
Report ppd
N/A
Report ppd
N/A
Report ppd
N/A
2000.000000 ppd
N/A
3.300000 ppd
N/A
20.000000 ppd
N/A
12.500000 ppd
N/A
Limitations/Monitoring Basis:
Outfall 001A represents limitations
for this manufacturing category. Po
ZC applications. WQ-based limits we
agricultural and industry. State po
for Hi, Cr, Ag, Cu, Hn, and Zn. The
discharge is tidal ly influenced. Th
dissolved portion of the metal cause
maximum for all parameters except so
absence of water quality standards,
shall be conducted on a specific IWC
procedures. The monitoring requirem
specifies that flow and pH be monito
as a combined discharge.
9.000000 su
N/A
1.600000 Ib/d
N/A
Report ppd
N/A
Report ppd
N/A
Report ppd
N/A
4000.000000 ppd
N/A
6.600000 ppd
N/A
40.000000 ppd
N/A
25.000000 ppd
N/A
and monitoring condi!
llutants of concern 1
re developed in accor
licy specifies consic
more conservative o1
e total metal standar
s toxicity. Monthly
luble fluoride. The
exisiting limits for
of 5% effluent tests
ents for all paramete
red separately for Ou
6.0 su, daily rain.
monitor when in use
monitor when in use
monitor when in use
monitor when in use
monitor when in use
3/day
1/week
1/week
1/month
1 /month
1/week
1/week
1/week
1/week
grab
composite
composite
composite
composite
composite
composite
composite
composite
ions effective through 4/3/93. ELGs have not been proposed
or this industry were identified from the past permit and
dance with State policy for the stream classification
eration of alternating and human health criteria only, and
fresh water and salt water criteria were used because the
d was adjusted to take into account the fact that only the
average limitaitons were determined as half the daily
basis of the acute WET limit was not described. In the
the remaining parameters were continued. Acute WET testing
performed in accordance with EPA guidance manual
rs were continued from the previous permit. The permit
tfalls 001 and 002, whle all other parameters are monitored
Outfall: 001B j Receiving Water: Chickasaw Creek via Canal | Treatment: Not described.
Amount/Components:
Unspecified amount from combined outfalls 001 and 002, consisting of process wastewaters, cooling tower blowdown, and
boiler blowdoun.
Parameter
Acute WET
Ag (TR)
Ba (T)
Br
Chloride
Co (T)
Cr
-------
1 . . - m » Permit Number: AL0002666
Facility Name: UOP - Molecular Sieve Plant
Facility Description: Manufacturer of molecular sieve adsorbents and catalysts SIC Code. 2819
Cu (TR)
Fl
Flow
Metals (rare eart
h)
Mn (T)
Mo
N (T)
NH3-N
Ni (TR)
P CT)
Pd (T)
pH
Pt (T)
S
S04
IDS
TSS
V CT)
U (T)
Zn (TR)
0.770000 ppd
N/A
150.000000 ppd
N/A
Report MGD
N/A
245.000000 ppd
N/A
. 8.900000 ppd
N/A
20.000000 Ib/d
N/A
200.000000 Ib/d
N/A
Report Ib/d
N/A
5.000000 ppd
N/A
25.000000 ppd
N/A
0.800000 ppd
N/A
N/A
N/A
0.800000 ppd
N/A
Report ppd
N/A
Report ppd
N/A
Report ppd
N/A
2000.000000 ppd
N/A
3.300000 ppd
N/A
20.000000 ppd
N/A
12.500000 ppd
N/A
1.540000 ppd
N/A
180.000000 ppd
N/A
Report MGD
N/A
368.000000 ppd
N/A
17.800000 ppd
N/A
40.000000 Ib/d
N/A
400.000000 Ib/d
N/A
Report Ib/d
N/A
10.000000 ppd
N/A
50.000000 ppd
N/A
1.600000 ppd
N/A
N/A
9.000000 su
1.600000 ppd
N/A
Report ppd
N/A
Report ppd
N/A
Report ppd
N/A
4000.000000 ppd
N/A
6.600000 ppd
N/A
40.000000 ppd
N/A
25.000000 ppd
N/A
monitor when in use
monitor when in use
monitor when in use
monitor when in use
monitor when in use
monitor when in use
monitor when in use
monitor when in use
6.0 su, daily rain
monitor when in use
monitor when in use
monitor when in use
monitor when in use
monitor when in use
1/day
continuous
1/week
1/week
1/week
1/week
1/week
1/week
1/week
1/week
3/day
1/week
1/week
1 /month
1 /month
1/week
1/week
1/week
1/week
composite
recorder
composite
composite
composite
composite
composite
composite
composite
composite
grab
composite
composite
composite
composite
composite
composite
composite
composite
L™"M™UM*™$£a£ limitations and monitoring conditions effective beginnins 4/3/94 The basis is the same as
that described at Outfall 001A. WQ-based limits are effective for Cu and Ag as of 4/3/94, by which time a new
treatment process should be installed and operational.
^^'The^e^ViTequfr^ the development within 6 months and implementation within 18 months of a BMP plan designed to
minimize or reduce the potential for contaminated storm water runoff. The permit: also requires the development of
BMP and SPCC plans to contain process liquids and solids. In accordance with coastal regulations, the permit
requires that the facility conduct discharge information zone (DIZ) monitoring. Should the results of DIZ
monitoring indicate biological damage has occurred at the perimeter or outside a 400 ft radius centered at the
discharge site, the permittee will be required to submit a plan to correct and eliminate biological damage caused by
the discharge. The permit contains a biocide clause to ensure that the Department reviews the biocides used in the
cooling or boiler systems. The use of biocides containing tributyl tin, zinc and chromium is prohibited based on
data indicating that these compounds are toxic at low concentrations. A compliance schedule is set forth which
requires: (1) the submittal of the DIZ study within 120 days; (2) develop a BMP plan withm6 months; (3) implement
Page: 13
-------
Facility Name: UOP - Molecular Sieve Plant
Permit Number:. AL0002666
Facility Description! Manufacturer of molecular sieve adsorbents and catalysts
SIC Code: 2819
8 m°ntS; ad() Comp^ Hith Cu a^ Ag (TR) limitations by 4/3/94. Reporting within 14
C0mphance is also rec'uired- other «»an set tut above, thS bas?s of these
Effective Date: 10/01/9
Expiration Date: 09/30/97
Abstract Date: 04/07/93
Page: 14
-------
Facility Name: West Point Pepperell Opelika ' Permit Number: AL0002968
Facility Description: Manufacturer of cotton/polyester sheeting SIC Code: 2262
Monitoring
Limit ELGs WQSs BPJ Only
Basis: 1 I J. ±
Storm UQ
Special BMPs Water Sediment Survey
Conditions: J. — - -
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
•L - - J. -
Bio
Survey TRES MDLs Monitoring Other
DStract Information: , . . . ...
Complete; Outfalls 001A and 001B were created for abstract purposes and represent summer and winter limits,
respectively.
Outfall: 001A | Receiving Water: Pepperell Branch I Treatment: Not described.
Amount/Components:
An average of 2.75 MGD of process wastewater, boiler blowdown, and noncontact cooling water
Parameter
Acute WET
BODS
COD
Color
Cr (T)
Cu
-------
Facility Homo: West Point Pepperell Opetika permit Number: AL0002968
Facility Description: Manufacturer of cotton/polyester sheeting SIC Code: 2262
cooling water in the discharge; the limitation's basis was not described. The ADMI color limit was BPJ-based in
accordance with best engineering judgement of pollutant treatability, and practices at similar facilities. The
liraits for Cu, Pb, and Zn were based on average instream hardness and freshwater acute UQ criteria equations in ADEM
Admin Code R 335-6-10-.07(1)(a)to protect designated uses (A & I). The basis of the acute WET limit was not
described. WET testing is to be conducted on an undiluted sample, test shall be performed in accordance with EPA
guidance manual procedures. The basis of the monitoring requirements was not provided.
Outfall: 001B | Receiving Water: Pepperell Branch | Treatment: Not described.
Amount/Components :
An average of 2.75 HGO of process wastewater, boiler blowdown, and noncontact cooling water
Parameter
Acute WET
BOOS
COO
Color
Cr (T)
Cu (TR)
DO
Flow
HII3-H
Pb (TR)
PH
Phenols
Sulfide
Twap.
TSS
Zn (TR)
Limitations
Monthly
Average
N/A
N/A
516.000000 ppd
N/A
17940.000000 ppd
N/A
N/A
Report ADMI
21. 300000 ppd
N/A
N/A
19.820000 ug/l
N/A
N/A
N/A
Report MGD
34.400000 Ib/d
N/A
N/A
56.550000 ug/l
N/A
N/A
21.300000 ppd
N/A
42.600000 Ib/d
N/A
N/A
N/A
3791.400000 ppd
N/A
N/A
167.270000 ug/l
Daily
Maximum
N/A
10.000000 %
1032.000000 ppd
N/A
35880.000000 ppd
N/A
N/A
300.000000 ADMI
42.600000 ppd
N/A
N/A
39.640000 ug/l
N/A
N/A
N/A
Report MGD
68.700000 Ib/d
N/A
N/A
113.100000 ug/l
8.500000 su
N/A
42.600000 ppd
N/A
85.200000 Ib/d
N/A
90.000000 F
N/A
7582.800000 ppd
N/A
N/A
334.550000 ug/l
Other
Units: % mort., see
below
6.0 mg/l daily min.
6.0 su, daily min
Monitoring Requirements
Frequency
1/quarter
1/day
1/day
1/week
1/week
2/year
continuous
continuous
1/week
2/year
1/day
1/week
1/week
1/day
1/day
2/year
Sample Type
grab
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
recorder
totalizer
24hr fw composite
24 hr composite
grab
grab
grab
grab
24hr fw composite
24hr fw composite
Limitations/Monitoring Basis:
This outfall represents winter limits effective Dec. through Apr. ELGs contained in 40 CFR Part 410 (Subpart D)
were used to determine the limits for COD, TSS, Sulfide, Phenol, and Cr (T). Monthly averages for BODS and NH3-N
Here determined based on WQSs and modeling performed by EPA; daily maximums were determined using a factor of 2 0
consistent with other industrial permits. Seasonal variations were developed using a factor of 1.5 times the summer
limitations, as recommended by EPA Region 4. No other limitations were changed to reflect seasonal variations pH
and DO limits are in accordance with State WQSs for A & I (agriculture and industry) designated uses. Temperature
Has limited due to the presence of boiler blowdown and cooling water in the discharge; the limitation's basis was
not described. The ADMI color limit was BPJ-based in accordance with best engineering judgement of pollutant '
treatability, and practices at similar facilities. The limits for Cu, Pb, and Zn were based on average instream
hardness and freshwater acute WQ criteria equations in ADEN Admin Code R 335-6-10-.07(1)(a) to protect designated
Page: 16
-------
Facility Name: West Point Pepperelt Opelika
Permit Number: AL0002968
Facility Description: Manufacturer of cotton/polyester sheeting
SIC Code: 2262
uses (A & I) The basis of the acute WET limit was not described. WET testing is to be conducted on an undiluted
sample. Test shall be performed in accordance with EPA guidance manual pocedures. The basis of monitoring
requirements was not provided. ____==_==_====_=_=^===_=
Conditions specified as BHPs in the permit include the requirement to prepare, implement, and maintain a spec Plan
' and to prepare, submit, and implement a BMP plan for the containment of any or all process liquids or solids. The
permit prohibits the use of biocides or additives containing tributyl tin, tributyl tin oxide, zinc chromium, or
related compounds in the cooling or boiler systems due to their toxicity at low concentrations. Other than set out
above, the basis of these special conditions were not described. ' .
Effective Date: 04/01/92
Expiration Date: 03/31/97
Abstract Date: 04/02/93
Page: 17
-------
Facility Name: Courtautds Fibers, Inc Permit Number: AL0003026
Facility Description: Manufactures cellulosic and noncellulosic fibers by viscose and solv. SIC Code- 2823
,,„,,. ,..„ Monitoring WET WET Testing Multiple
y?{*. EL,GS »s» BP,J Only Limits Only Categories
Basis. J. J. J. 1 I ^ I
Storm WQ Bio
Special BMPs Water Sediment Survey Survey TRES HDLs
conditions: J. J. - - J
Tiered
Limits Other
Monitoring Other
I
Abstract Information:
Complete; Outfalls 001 (001A and 001B were created for abstract purposes), 002, and 003.
Outfall: 001A | Receiving Water: Mobile River | Treatment: Not described.
Amount/Components :
and^tormewat™Unt °f pr°CeSS wastewater- cooling water, sanitary wastewater, boiler blowdown, hydrocyclone underflow.
Parameter
1,1,1-Trfchloroet
hane
1,1,2-Trichloroet
hane
1,1-Dichlorocthan
e
1,1-Dichloroethyl
eno
1,2,4-Trichlorobe
nzene
1,2-Dichlorobcnzc
ne
1,2-Dichloroethan
e
1,2-Dichloropropa
ne
1,H-Trans-Dichlor
oothylcno
1,3-Cfs-Dichlorop
ropy I one
1,3-Dichlorobenze
ne
1,4-Dfchlorobcnze
ne
2,4-Dichloropheno
2,4-Dimethylpheno
2,4-Dinitrophenol
2,4-Dfnitrotoluen
e
2,6-Dinitrotoluen
e
2-Chlorophcnol
Limitations
Monthly
Average
1.560000 Ib/d
N/A
1.560000 Ib/d
N/A
1.640000 Ib/d
M/A
1.190000 Ib/d
N/A
5.060000 Ib/d
N/A
5.720000 Ib/d
M/A
5.060000 Ib/d
N/A
11.370000 Ib/d
N/A
1.560000 Ib/d
M/A
2.160000 Ib/d
N/A
2.300000 Ib/d
N/A
1.120000 Ib/d
M/A
2.900000 Ib/d
N/A
1.340000 Ib/d
N/A
5.280000 Ib/d
M/A
8.400000 Ib/d
N/A
18.960000 Ib/d
N/A
2.300000 Ib/d
N/A
Daily
Maximum
4.010000 Ib/d
N/A
4.010000 Ib/d
N/A
4.390000 Ib/d
N/A
1.860000 Ib/d
N/A
10.410000 Ib/d
N/A
12.120000 Ib/d
N/A
15.690000 Ib/d
N/A
17.100000 Ib/d
N/A
4.010000 Ib/d
N/A
3.270000 Ib/d
N/A
3.270000 Ib/d
N/A
2.080000 Ib/d
N/A
8.330000 Ib/d
N/A
2.680000 Ib/d
N/A
9.140000 Ib/d
N/A
21.190000 Ib/d
N/A
47.650000 Ib/d
N/A
7.290000 Ib/d
N/A
Other
Monitoring Requirements
Frequency
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
Sample Type
grab
grab
grab
grab
composite
composite
grab
grab
grab
grab
composite
composite
composite
composite
composite
composite
composite
composite
Page: 18
-------
Facility Name: Courtaulds Fibers, Inc Permit Number: AL0003026
Facility Description: Manufactures cellulosic-and noncellulosic fibers by viscose and solv. SIC Code: 2823
2-Nitrophenol
3,4-Benzof luorant
hene
4,6-Dinitro-o-cre
sol
4-Nitrophenol
Acenaphthene
Acenaphthylene
Acrylonitrile
Acute WET
Anthracene
Benzene
Benzo
-------
Facility Name: Courtaulds Fibers, Inc Permit Number. ALo003026
Facility Description: Manufactures cellulosic and noncellulosic fibers by viscose and solv. SIC Code: 2823
Cu
Di-n-butyl phthal
ate
Oiethyl phthal ate
Dimethyl phthalat
G
Ethyl benzene
Flow
Fluoranthcne
Fluoreno
llexnch lorobonzcne
Hcxach lorobutodi e
nc
Hcxach lorocthane
Hg
Methyl chloride
Hethylcnc chlorid
e
Haphtholcnc
Hi
Nitrobenzene
Other
Pb (T)
P«
Phenanthrcnc
Phenol
Pyrene
S04
TDS
107.790000 Ib/d
N/A
2.010000 Ib/d
N/A
6.020000 Ib/d
N/A
1.410000 Ib/d
N/A
2.380000 Ib/d
N/A
Report MGD
N/A
1.860000 Ib/d
N/A
1.640000 Ib/d
N/A
0.790000 Ib/d
N/A
1.490000 Ib/d
N/A
1.560000 Ib/d
N/A
Report Ib/d
N/A
6.390000 Ib/d
N/A
2.970000 Ib/d
N/A
1.640000 Ib/d
N/A
125.630000 Ib/d
N/A
2.010000 Ib/d
N/A
2.160000 Ib/d
N/A
23.790000 Ib/d
N/A
N/A
N/A
1.640000 Ib/d
N/A
1.120000 Ib/d
N/A
1.860000 Ib/d
N/A
Report Ib/d
N/A
Report Ib/d
N/A
149.860000 Ib/d
N/A
4.240000 Ib/d
N/A
15.090000 Ib/d
N/A
3.490000 Ib/d
N/A
8.030000 Ib/d
N/A
Report MGD
N/A
5.060000 Ib/d
N/A
4.390000 Ib/d
N/A
1.580000 Ib/d
N/A
3.640000 Ib/d
N/A
4.010000 Ib/d
N/A
Report Ib/d
N/A
14.120000 Ib/d
N/A
6.620000 Ib/d
N/A
4.390000 Ib/d
N/A
295.870000 Ib/d
N/A
5.060000 Ib/d
N/A
3.270000 Ib/d
N/A
51.290000 Ib/d
N/A
N/A
9.000000 su
4.390000 Ib/d
N/A
1.930000 Ib/d
N/A
4.980000 Ib/d
N/A
Report Ib/d
N/A
Report Ib/d
N/A
1,3-dichloropropylen
e
6.0 su, daily min;see
below
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
continuous
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/day
1/6 months
1/6 months
1/6 months
1 /month
1 /month
'composite
: composite
composite
composite
grab
recorder
composite
composite
composite
composite
composite
composite
grab
. grab
composite
composite
composite
grab
composite
grab
composite
composite
composite
composite
composite
Page: 20
-------
Facility Name: Courtaulds Fibers, Inc
Permit Number: AL0003026
Facility Description: Manufactures cellulosic and noncellulosic fibers by viscose and solv.
SIC Code: 2823
Tetrachloroethyle
ne
Thiocarbamates
Toluene
Trichloroethylene
TSS
Vinyl chloride
Zn (T)
1.640000 Ib/d
N/A
Report Ib/d
N/A
1.930000 Ib/d
N/A
1.560000 Ib/d
N/A
3843.740000 Ib/d
N/A
7.730000 Ib/d
N/A
239.260000 Ib/d
N/A
4.160000 Ib/d
N/A
Report Ib/d
N/A •
5.950000 Ib/d
N/A
4.010000 Ib/d
N/A
7837.240000 Ib/d
N/A
19.920000 Ib/d
N/A
490.630000 Ib/d
N/A
1/6 months
1/6 months
1/6 months
1/6 months
3/week
1/6 months
3/week
grab
composite
grab
grab
composite
grab
composite
Limitations/Monitoring Basis: . -*.*.-*.,_
This outfall represents limits through 8/1/92. Except as described below, limitations are ELG-based consistent with
BAT and NSPS for OCPSF manufacturing (40 CFR Part 414, Subpart I). The highest SODS, TSS, anc COD monthly avgs.
over the past 3 years was considered the best engineering judgement of the treatability for these pollutants. With
additional ELG-based loadings for new sources, a BPJ-based monthly avg. limit was developed a daily max. limit was
calculated (equal to 2 times the monthly avg.). Metal bearing wastestreams are limited to zinc from rayon
manufacturing. CN-containing raw materials'are prohibited; monitoring for CN is required to ensure that CN
formation does not occur. UQ-based limits for hexachlorobenzene and the Cu (T) daily max., only, were established
in accordance with State rules. Data from reports and models on groundwater contamination caused by an adjacent
facility have resulted in the monitoring requirements for carbon tetrachloride, CS2, Hg (T), thiocarbamates, and
chlorides (T) since groundwater is used as process water feed. Monitoring for pollutants believed to be at
concentrations below concern is set at 1/6 months; monitoring may be decreased to 1/year where no compliance
problems occur. Monitoring for chlorides (T) and Zn (T) is set at an increased frequency due to process
contributions and levels of concern. By 8/1/92, continuous monitoring for pH is required. Acute WET testing shall
be conducted on a specific IWC of 1% effluent; tests must be performed in accordance with EPA guidance manual
procedures.
Outfall: 001B | Receiving Water: Mobile River | Treatment: Not described.
Amount/Components:
Unspecified amount of process wastewater, cooling water, sanitary wastewater, boiler blowdown, hydrocyclone underflow,
and storm water 8/1 - 4/30/92
Parameter
1,1,1-Trichloroet
hane
1,1,2-Trichloroet
hane
1,1-Dichloroethan
e
1,1-Dichloroethyl
ene
1,2,4-Trichlorobe
nzene
1 ,2-Dichlorobenze
ne
1,2-Dichloroethan
e
1,2-Dichloropropa
ne
1,2-Trans-Dichlor
oethylene
Limitations
monthly
Average
1 .560000 Ib/d
N/A
1.560000 Ib/d
N/A
1 .640000 Ib/d
N/A
1.190000 Ib/d
N/A
5.060000 Ib/d
N/A
5.720000 Ib/d
N/A
5.060000 Ib/d
N/A
11.370000 Ib/d
N/A
1.560000 Ib/d
N/A
dai ly
Maximum
4.010000 Ib/d
N/A
4.010000 Ib/d
N/A
4.390000 Ib/d
N/A
1.860000 Ib/d
N/A
10.410000 Ib/d
N/A
12.120000 Ib/d
N/A
15.690000 Ib/d
N/A
17.100000 Ib/d
N/A
4.010000 Ib/d
N/A
Other
Mom" tori ng Requi rements
Frequency
• 1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
Sample Type
grab
grab
grab
grab
composite
composite
grab
grab
grab
Page: 21
-------
Facility Name: Courtautds Fibers, Inc Permit Number: AL0003026
Facility Description: Manufactures cellulosic and noncellulosic fibers by viscose and solv. SIC Code: 2823
1,3-Dichlorobonze
no
1,4-Dichlocobenze
no
2,4-Dichlorophcno
2,4-Dimethylpheno
2,4-Dinitrophcnol
2,4-Dinitrotoluon
e
2,6-Dinitrotoluen
e
2-Chlorophenol
2-Nitrophenol
3,4-Benzofluorant
hene
4,6-Dinitro-o-cre
sol
4-Mitrophcnol
Accnaphthene
Accnaphthylcno
Acrylonitrile
Acute WET
Anthracene
Benzene
Bcnzo (a) anthrac
cne
Bcnzo (a) pyrcne
Bcnzo (k) fluoran
thane
Bis (2-cthylhexyl
) phthalatc
BOOS
Carbon tctrachlor
ido
Chloride
2.300000 Ib/d
N/A
1.120000 Ib/d
H/A
2.900000 Ib/d
N/A
1.340000 Ib/d
H/A
5.280000 Ib/d
N/A
8.400000 Ib/d
N/A
18.960000 Ib/d
N/A
2.300000 Ib/d
N/A
3.050000 Ib/d
N/A
1.710000 Ib/d
N/A
5.800000 Ib/d
N/A
5.350000 Ib/d
N/A
1.640000 Ib/d
N/A
1.640000 Ib/d
N/A
7.140000 Ib/d
N/A
N/A
N/A
1.640000 Ib/d
N/A
2.750000 Ib/d
N/A
1.640000 Ib/d
N/A
1.710000 Ib/d
N/A
1.640000 Ib/d
N/A
7.660000 Ib/d
N/A
1968.050000 Ib/d
N/A
1.340000 Ib/d
N/A
Report Ib/d
N/A
3.270000 Ib/d
N/A
2.080000 Ib/d
N/A
8.330000 Ib/d
N/A
2.680000 Ib/d
N/A
9.140000 Ib/d
N/A
21.190000 Ib/d
N/A
47.650000 tb/d
N/A
7.290000 Ib/d
N/A
5.130000 Ib/d
N/A
4.530000 Ib/d
N/A
20.590000 Ib/d
N/A
9.220000 Ib/d
N/A
4.390000 Ib/d
N/A
4.390000 Ib/d
N/A
17.990000 Ib/d
N/A
N/A
10.000000
4.390000 tb/d
N/A
10.110000 Ib/d
N/A
4.390000 tb/d
N/A
4.530000 Ib/d
N/A
4.390000 Ib/d
N/A
20.740000 Ib/d
N/A
3977.890000 Ib/d
N/A
2.820000 Ib/d
N/A
Report tb/d
N/A
Units: % mort.; see
below
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1 /month
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
5/week
1/6 months
1 /month
composite
composite
composite
composite
composite
composite
composite
composite
composite
composite
composite
composite
grab
composite
grab
grab
composite
grab
composite
composite
composite
composite
composite
grab
composite
Page:, 22
-------
Facility Name: Courtaulds Fibers, Inc Permit Number: AL0003026
Facility Description: Manufactures cellulosic and noncellulosic fibers by viscose and sotv. SIC Code: 2823
Chlorobenzene
Chloroethane
Chloroform
Chrysene
CN (T)
COD
Cr (T)
CS2 ,
CU (T)
Di-n-butyl phthal
ate
Diethyl phthalate
Dimethyl phthal at
e
Ethylbenzene
Flow
Fluoranthene
Fluorene
Hexachlorobenzene
Hexach I orobutadi e
ne
Hexach loroethane
Hg (T)
Methyl chloride
Methylene chlorid
e
Naphthalene
Ni (T)
Nitrobenzene
1.120000 Ib/d
N/A
7.730000 Ib/d
N/A
1.560000 Ib/d
N/A
1.640000 Ib/d
N/A
Report Ib/d
N/A
9841.000000 Ib/d
N/A
82.520000 Ib/d
N/A
Report Ib/d
N/A
107.790000 Ib/d
N/A
2.010000 Ib/d
N/A
6.020000 Ib/d
N/A
1.410000 Ib/d
N/A
2.380000 Ib/d
N/A
N/A
Report HGD
1.860000 Ib/d
N/A
1 .640000 Ib/d
N/A
0.790000 Ib/d
N/A
1.490000 Ib/d
N/A
1.560000 Ib/d
N/A
Report Ib/d
N/A
6.390000 Ib/d
N/A
2.970000 Ib/d
N/A
1.640000 Ib/d
N/A
125.630000 Ib/d
N/A
2.010000 Ib/d
N/A
2.080000 Ib/d
N/A
19.920000 Ib/d
N/A
3.420000 Ib/d
N/A
4.390000 Ib/d
N/A
Report Ib/d
N/A
19682.000000 Ib/d
N/A
205.920000 Ib/d
N/A
Report Ib/d
N/A
149.860000 Ib/d
N/A
4.240000 Ib/d
N/A
15.090000 Ib/d
N/A
3.490000 Ib/d
N/A
8.030000 Ib/d
N/A
N/A
Report MGD
5.060000 Ib/d
N/A
4.390000 Ib/d
N/A
1.580000 Ib/d
N/A
3.640000 Ib/d
N/A
4.010000 Ib/d
N/A
Report Ib/d
N/A
14.120000 Ib/d
N/A
6.620000 Ib/d
N/A
4.390000 Ib/d
N/A
295.870000 Ib/d
N/A
5.060000 Ib/d
N/A
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
3/week
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
continuous
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
composite
grab
grab
composite
grab
composite
composite
grab
composite
composite
composite
composite
grab
recorder
composite
composite
composite
composite
composite
composite
grab
grab
composite
composite
composite
Page: 23'
-------
Facility Home: Courtaulds Fibers, Inc Permit Number: AL0003026
Facility Description: Manufactures cellulosic and noncellulosic fibers by viscose and solv. ,SIC Code: 2823
Other
Pb
p«
Phonanthrono
Phenol
Pyreno
S04
TDS
Tetrachloroethyle
ne
Thiocarbamatcs
Toluene
Trichloroethylene
TSS
Vinyl chloride
Zn (T)
2.160000 Ib/d
N/A
23.790000 Ib/d
N/A
N/A
N/A
1.640000 Ib/d
N/A
1.120000 Ib/d
M/A
1.860000 Ib/d
N/A
Report Ib/d
N/A
Report Ib/d
N/A
1.640000 Ib/d
N/A
Report Ib/d
N/A
1.930000 Ib/d
N/A
1.560000 Ib/d
N/A
3843.740000 Ib/d
N/A
7.730000 Ib/d
N/A
239.260000 Ib/d
N/A
3.270000 Ib/d
N/A
51.290000 Ib/d
N/A
N/A
9.000000 su
4.390000 Ib/d
N/A
1.930000 Ib/d
N/A
4.980000 Ib/d
N/A
Report Ib/d
N/A
Report Ib/d
N/A
4.160000 Ib/d
N/A
Report Ib/d
N/A
5.950000 Ib/d
N/A
4.010000 Ib/d
N/A
7837.240000 Ib/d
N/A
19.920000 Ib/d
N/A
490.630000 Ib/d
N/A
1,3-dichloropropylen
e
6.0 su, dai ly min
1/6 months
1/6 months
cont i nuous
1/6 months
1/6 months
1/6 months
1 /month
1 /month
1/6 months
1/6 months
1/6 months
1/6 months
3/week
1/6 months
3/week
grab
composite
record
composite
composite
composite
composite
composite
grab
composite
grab
grab
composite
grab
composite
Limitations/Monitoring Basis:
Same basis for limitations and monitoring as shown for Outfall 001A. This outfall represents limits after 8/1/92.
The permit includes a schedule for the installation of continuous pH monitoring equipment. Once installed, pH
monitoring is required on a continuous basis, as shown in the limits for Outfall 001B.
Outfall: 002 | Receiving Water: Tributary to Carter Branch | Treatment: Not specified
Amount/Components :
Unspecified amount containing uncontaminated storm water runoff and plant water supply well water.
Parameter
Carbon totrnchlor
ide
Chloride
CS2
Cu
Flow
Limitations
Monthly
Average
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report MGO
Daily
Maximum
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/ 1
N/A
Report MGD
Other
Report MGD
Monitoring Requirements
Frequency
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
Sample Type
grab
grab
grab
grab
estimate
Page: 24
-------
Facility Name: Courtaulds Fibers, Inc Permit Number: AL0003026
Facility Description: Manufactures cellulosic and noncellulosic fibers by viscose and solv. SIC Code: 2823
Hg (T)
Pb (TR)
Thiocarbamates
Zn (TR)
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
1/6 months
1/6 months
1/6 months
1/6 months
grab
grab
grab
grab
Limitations/Monitoring Basis:
Monitoring is required for carbon tetrachloride, CS2, Hg(T), thiocarbonates, and chloride (T) because this
wastewater may potentially be used as process water feed. Form 2C does not indicate the presence of these
contaminates at levels of concern in the discharge. Based on the 2C data and the fact that concentrations in the
groundwater do not vary substantially over time, the monitoring frequency is set at once per 6 months for all
parameters. The Zinc, copper, and lead are indicated on the Form 2c to be present at levels above the instream
water quality standards assuming no available dilution instream. Because the discharge is intermittent and occurs
primarily during periods of high stream flow (i.e. storm events) no limitations are proposed at this time. The
permittee will be required to monitor the discharge for total recoverable copper, zinc, and lead once every six
months. It is believed that the best management practices requirements proposed by the permit will result in the
continued decline of these pollutants in the storm water.
Outfall: 003 | Receiving Water: Tributary to Cold Creek Treatment: Not specified
Amount/Components :
Unspecified amount containing storm water runoff, car wash water, and plant water supply well water.
Parameter
Carbon tetrachlor
ide
Chloride
CS2
Flow
Hg (T)
Thiocarbamates
Zn (TR)
Limitations
Monthly
Average
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report MGD
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
Daily
Maximum
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report MGD
N/A
Report mg/ I
N/A
Report mg/l
N/A
Report mg/l
Other
Monitoring Requirements
Frequency
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
Sample Type
grab
grab
grab
estimate
grab
grab
grab
Limitations/Monitoring Basis:
Monitoring is required for carbon tetrachloride, CS2, Hg(T), thiocarbonates, and chloride (T) because this
wastewater may potentially be used as process waster feed. Form 2C does not indicate the presence of these
contaminants at levels of concern in the discharge. Based on the 2C data and the fact that concentrations in the
groundwater do not vary substantially over time, the monitoring frequency is set at once per 6 months for all
parameters. The Zinc is indicated on the Form 2c to be present at levels above the instream water quality standard
assuming no available dilution instream. Because the data base is limited to only one analysis and the discharge is
intermittent no limitations are proposed at this time. The permittee will be required to monitor the discharge for
total recoverable zinc over six months. It is believed that the best management practices requirements coupled with
the prohibition of zinc as a cooling water additive will address mitigation of potential water quality impacts.
Special Conditions Basis:
The permit requires the development within 6 months and the implementation within 18 months of a BMP plan designed
to minimize or reduce the potential for contaminated storm water runoff. The permit also requires the development
of BMP and SPCC plans to contain process liquids and solids. In, accordance with coastal regulations, the permit
requires that the facility conduct discharge information zone (DIZ) monitoring. Should the results of DIZ
monitoring indicate biological damage has occurred at the perimeter or outside a 400 ft radius centered at the
discharge site, the permittee will be required to submit a plan to correct and eliminate the biological damage
caused by the discharge. The permit contains a biocide clause to ensure that the: Department reviews the biocides
used in the cooling or boiler systems. The use of biocides containing tributyl tin, zinc, and chromium is
Page: 25
-------
Facility Name: Courtaulds Fibers, Inc
Permit Number: AL0003026
Facility Description: Manufactures cellulosic and noncellulosic fibers by viscose and solv.
SIC Code: 2823
prohibited based on data indicating that these compounds are toxic at low levels. A compliance schedule is set
forth which requires the installation of a continuous pH monitor at 001 by 8/1/92; it also requires the submittal of
the DIZ study within 120 days. Reporting within 14 days of milestone,dates as to schedule compliance is also
required.
Effective Date: 05/01/92
Expiration Date: 04/30/97
Abstract Date: 04/06/93
Page: 26
-------
Facility Name: Degussa Corporation, AL Group ' Permit Number: AL0023272
Facility Description: Organic and inorganic chemical manufacturer SIC Code: 2819
Monitoring
Limit ELGs UQSs BPJ Only
iasis: J_ j_ J. J.
Storm WQ
Special BMPs Water Sediment Survey
Conditions: / J. .1 J.
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
J. - J. - J-
Bio
Survey TRES MDLs Monitoring Other
I - - - 1
Abstract Information:
Complete; Outfalls 001, 001A, 001B, 002, and 003.
Outfall: 001 I Receiving Water: Middle Fork of Deer via canal | Treatment: See 001A and 001B
Amount/Components :
Unspecified amount of cooling tower blowdown, boiler blowdown, once through cooling water, and treated process
wastewaters
Parameter
BODS
Chloride
Chronic WET
CN (T)
Cu (TR)
Flow
NH3-N
Ni (TR)
PAHs
Pb (TR)
PH
TDS
Temp.
TOC
TRC
TSS
Zn (TR)
Limitations
Monthly
Average
N/A
4.000000 mg/l
N/A
6100.000000 mg/l
N/A
N/A
N/A
0.003000 mg/l
N/A
0.008700 mg/l
N/A
Report MGD
68.000000 Ib/d
N/A
N/A
0.024900 mg/l
N/A
0.934000 ug/l
N/A
0,016800 mg/l
N/A
N/A
N/A
Report mg/l
N/A
N/A
Report ppd
N/A
N/A
0.022000 mg/l
1042.560000 ppd
N/A
N/A
0.258000 mg/l
Daily
Maximum
N/A
8.000000 mg/l
N/A
9000.000000 mg/l
N/A
N/A
N/A
0.003000 mg/l
N/A
0.008700 mg/l
N/A
Report MGD
68.000000 Ib/d
N/A
N/A
0.225000 mg/l
N/A
1.868000 ug/l
N/A
0.420000 mg/l
N/A
9.000000 su
N/A
Report mg/l
90.000000 F
N/A
Report ppd
N/A
N/A
0.039000 mg/l
2718.630000 ppd
N/A
N/A
0. 285 000 mg/l
Other
See below
Units: % mort.; see
below
6.0 su; daily rain.
degrees Fahrenheit
Monitoring Requirements
Frequency
1/day
1/week
1 /month
1/week
1/week
continuous
1/day
1/week
1/6 months
1/week
1/day
1 /month
1/day
3/week
1/week
3/week
1/week
Sample Type
24hr' fw composite
24hr fw composite
fw composite
grab
24hr fwcomposite
24hr fw totalized
composite
24hr fw composite
grab
24hr fw composite
grab
24hr fw composite
grab
24hr fw composite
grab
24hr fw composiste
composite
Limitations/Monitoring Basis:
Temp, limits are incorporated from past permit since the limit is protective of water quality as demonstrated by
past stream monitoring. pH limits should not cause receiving water to be adversely impacted. NH3-N and BODS limits
Page: 27
-------
Facility Name: Dcgussa Corporation, AL Group . Permit Number: AL0023272
Facility Description: Organic and inorganic chemical manufacturer Sic Code: 2819
arc adopted from the past permit; these have proven not to exert an oxygen demand above that of background. TSS
loading limitations are equal to the sum of ELG- and BPJ-based limitations from 001A and 001B, where "no additional
major sources of TSS are believed present". WQ-based limits were calculated by simple dilution using an available
dilution ratio of 3:1 as follows: (1) for TRC, EPA saltwater criteria were used; (2) for CN, State acute saltwater
criteria was used and, in absence of State chronic, the EPA chronic saltwater criteria was used; this same approach
was taken for Cu ; and (3) State acute and chronic saltwater criteria were used for Zn (TR), Pb (TR), Ni
-------
Facility Name: Degussa Corporation, AL Group Permit Number: AL0023272
Facility Description: Organic and inorganic chemical manufacturer SIC Code: 2819
4-Nitrophenol
Acrylonitrile
Benzene
Carbon tetrachlor
ide
Chlorobenzene
Chloroethane
Chloroform
CN (T)
Cr (T)
Cu (T)
Ethylbenzene
Flow
Hexach lorobenzene
Hexachlorobutadie
ne
Hexach loroethane
Methyl chloride
Hethylene chlorid
e
NH3-N
Hi (T)
Nitrobenzene
Other
Pb
-------
Facility Name: Degussa Corporation, AL Group Permit Number: AL0023272
Facility Description: Organic and inorganic chemical manufacturer SIC Code: 2819
Toluene
Trichloroethylene
Vinyl chloride
Zn
0.040000 ppd
H/A
0.040000 ppd
H/A
0.150000 ppd
N/A
3.150000 ppd
N/A
0.110000 ppd
H/A
0.100000 ppd
N/A
0.260000 ppd
H/A
7.840000 ppd
H/A
1/6 months
1/6 months
1/6 months
1/month
grab
grab
grab
24hr fw composite
Limitations/Monitoring Basis:
Except as described below ELG-based limitations are imposed in accordance with the OCPSF manufacturing (40 CFR Part
414; Subparts G and J). CN limits were calculated allowing for CN-bearing wastewaters from the cyanurfc chloride
process (regulated under OCPSF ELGs). Metals limits were calculated in consideration of best engineering judgement
allowing for metal -bear ing wastewaters from the cyanuric chloride process and aerosil/siltet processes. Monitoring
1/6 months is specified for pollutants below levels of concern. Because CN is used in the process, 1/month
monitoring is required. Zn is present at a significant level as indicated on the application Form 2F and therefore,
1/month monitoring is required. NH3-H monitoring is specified based on the previous permit with a reduction in
frequency and daily monitoring for pH and flow are specified; the basis of these monitoring requirements were not
described.
Outfall: 002 | Receiving Water: Middle Fork of Deer via canal [ Treatment: None.
Amount/Components :
Unspecified amount of storm water discharge (north)
Parameter
Flow
OSG
PH
TOC
TSS
Limitations
Monthly
Average
N/A
Report MGD
N/A
Report mg/l
N/A
N/A
N/A
Report mg/l
N/A
Report mg/l
Dai ly
Maximum
H/A
Report MGD
H/A
Report mg/l
Report su
N/A
N/A
Report mg/l
H/A
Report mg/l
Other
Report daily min. s
u
Monitoring Requirements
Frequency
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
Sample Type
estimate
grab
grab
grab
grab
Limitations/Monitoring Basis:
TOC monitoring requirements are maintained from the existing permit. O&G, COD, pH, and TSS are noted as pollutants
of concern based on organic and inorganic chemical manufacturing. Although monitoring (except for COD) is
specified, no limitations are imposed because it is believed that the pollutants of concern can be controlled by the
BHPs required by the permit. The monitoring basis was not provided.
Outfall: 003 | Receiving Water: Deer River via barge canal | Treatment: None.
Amount/Components :
Unspecified amount of storm water discharge (east)
Parameter
Cd (TR)
Flow
Mi
-------
Facility Name: Degussa Corporation, AL Group Permit Number: AL0023272
Facility Description: Organic and inorganic chemical manufacturer SIC Code: 2819
O&G
Pb (TR)
PH
TOG
TSS
Zn (TR)
N/A
Report mg/l
N/A
Report mg/l
N/A
N/A
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report su
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
Report daily min. su
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
grab
grab
grab
grab
grab
grab
Limitations/Monitoring Basis:
O&G, TOC, pH, and TSS are noted as pollutants of concern in this discharge. Additionally, application Forms 2C and
2F indicate the prescence of Cd, Pb, Mi, and Zn, Although monitoring is specified, no limitations are imposed
because it is believed that the pollutants of concern can be controlled by the BMPs required by the permit. The
monitoring basis was not provided.
Outfall: 001B | Receiving Water: Deer via canal | Treatment: Nitr, Denitr, Aer, Stab
Amount/Components :
Unspecified amount of bio. treatment sys. discharge (rock reed) which consists of treated process wastewaters from org.
and inorg.chem. manufacturing.
Parameter
1,1,1-Trichloroet
hane
1,1,2-Trichloroet
hane
1,1-Dichloroethan
e
1,1-DichloroethyL
ene
1,2,4-Trichlorobe
nzene
1 , 2-D i ch lorobenze
ne
1,2-Dichloroethan
e
1,2-Dichloropropa
ne
1,2-Trans-Dichlor
oethylene
1 ,3-Dichlorobenze
ne
1,4-Dichlorobenze
ne
2,4-Dichloropheno
I
2,4-Dimethylpheno
I
Limitations
monthly
Average
0.060000 ppd
N/A
0.060000 ppd
N/A
0.060000 ppd
N/A
0.050000 ppd
N/A
0.200000 ppd
N/A
0.220000 ppd
N/A
0.200000 ppd
N/A
0.440000 ppd
N/A
0.060000 ppd
N/A
0.090000 ppd
N/A
0.040000 ppd
N/A
0.110000 ppd
N/A
0.050000 ppd
N/A
daily
Maximum
0.160000 ppd
N/A
0.160000 ppd
N/A
0.170000 ppd
N/A
0.070000 ppd
N/A
0.410000 ppd
N/A
0.470000 ppd
N/A
0.610000 ppd
N/A
0.680000 ppd
N/A
0.160000 ppd
N/A
0.130000 ppd
N/A
0.080000 ppd
N/A
0.320000 ppd
N/A
0.100000 ppd
N/A
Other
Monitoring Requirements
Frequency
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
Sample Type
grab .
grab
grab
grab
fw composite
grab
grab
grab
grab
grab
fw composite
fw composite
fw composite
Page: 31
-------
Facility Homo: Degussa Corporation, AL Group Permit Number: AL0023272
Facility Description: Organic and inorganic chemical manufacturer SIC Code: 2819
2,4-Dinitrophenol
2,4-Dinitrotoluen
o
2,6-Dinitrotoluen
e
2-Chlorophcnol
2-Hitrophcnol
3,4-Bcnzofluorant
hone
4,6-Dinitro-o-cre
sol
4-Hitrophenol
Accnaphthcnc
Acenaphthyleno
Acrylonitrile
Anthracene
Benzene
Benzo (a) onthrac
cne
Bcnzo (a) pyrcne
Bcnzo (k> fluoran
thane
Bis (2-othylhexyl
) phthalate
Carbon tctrachlor
idc
Chlorobcnzcnc
Chlorocthane
Chloroform
Chryscne
CM (T)
CP (T>
Cu
-------
Facility Name: Degussa Corporation, AL Group
Facility Description: Organic and inorganic chemical manufacturer
Di-n-butyl phthal
ate
Diethyl phthalate
Dimethyl phthalat
e
Ethylbenzene
Flow
Fluoranthene
Fluorene
Hexachlorobenzene
Hexachlorobutadie
ne
Hexachloroethane
Methyl chloride
Hethylene chlorid
e
Naphthalene
NH3-N
Ni (T)
Nitrobenzene
Other
Pb (T)
PH
Phenanthrene
Phenol
Pyrene
Tetrachloroethyle
ne
TOC
Toluene
0.080000 ppd
N/A
0.230000 ppd
N/A
0.050000 ppd
N/A
0.090000 ppd
N/A
N/A
Report HGD
0.070000 ppd
N/A
0.060000 ppd
N/A
0.040000 ppd
N/A
0.060000 ppd
N/A
0.060000 ppd
N/A
0.250000 ppd
N/A
0.120000 ppd
N/A
0.060000 ppd
N/A
Report Ib/d
N/A
6.310000 ppd
N/A
0.080000 ppd
N/A
0.080000 ppd
N/A
1.200000 ppd
N/A
N/A
N/A
0.060000 ppd
N/A
0.040000 ppd
N/A
0.070000 ppd
N/A
0.060000 ppd
N/A
275.580000 ppd
N/A
0.070000 ppd
N/A
0.160000 ppd
N/A
0.590000 ppd
N/A
0.140000 ppd
N/A
0.310000 ppd
N/A
N/A
Report HGD
0.200000 ppd
N/A
0.170000 ppd
N/A
0.080000 ppd
N/A
0.140000 ppd
N/A
0.160000 ppd
N/A
0.550000 ppd
N/A
0.260000 ppd
N/A
0.170000 ppd
N/A
Report Ib/d
N/A
14.870000 ppd
N/A
0.200000 ppd
N/A
0.130000 ppd
N/A
2.580000 ppd
N/A
N/A
Report su
0.170000 ppd
N/A
0.070000 ppd
N/A
0.190000 ppd
N/A
0.160000 ppd
N/A
551.200000 ppd
N/A
0.230000 ppd
N/A
i
1,3-dichloropropylen
e
6.0 su; daily rain.
1/6 months
1/6 months
1/6 months
1/6 months
daily
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
3/week
1/6 months
1/6 months
1/6 months
1/6 months
1/day
1/6 months
1/6 months
1/6 months
1/6 months
3/week
1/6 months
fw composite
fw composite
fw composite
grab
totalized
fw composite
fw composite
fw composite
fw composite
fw composite
grab
grab
fw composite
fw composite
fw composite
fw composite
grab
fw composite
grab
fw composite
fw composite
fw composite
grab
fw composite
grab
Page: 33
-------
Facility Name: Degussa Corporation, AL Group Perm1t Number: AL0023272
Facility Description: Organic and inorganic chemical manufacturer SIC Code- 2819
Vinyl chloride
Zn
N/A
0.300000 ppd
N/A
3.920000 ppd
N/A
0.160000 ppd
N/A
0.780000 ppd
N/A
9.750000 ppd
N/A
1/6 months
1/6 months
1 /month
grab
grab
fw composite
fur°m C"™'n9l«*.««l "Created OCPSF manufacturing waste streams (regulated
' ' F' Hi and » and inorganic manufacturing waste streams (regulated under 40 CFR
hrf'c "I88" Ilml?at1on8,for each category were added to derive the effluent limits. pH limits are
based on ELGs from both categories. The manufacture of HCN by the Andrussow process is not regulated under ELGs-
'6^. the 40 CFR Part 415, Subpart AP regulations are applied since the ELGs
ail?wance for CM was Provided for the production of NaCN. The TOC daily avg.
0 7SX t the nth -- daJly/V9;uto2dJ?3 liml"t based on 40 CFR Part 415' SubPart I ("hich accounts for
i/i \h • remaining loads; the daily max. limit was derived by multiplying 2 times the daily avg
•{ T° ;S 1S sPec\fled for Pollutants below levels of concern. Because CN is used in the process
n\£ *% r^u!red: Zn i? P^sent at a significant level as indicated on the application Form 2F and
th» r« n {rm -i"9-1S 2**"?*^ I?C atld NH3'N mon'toring 's set forth at 3/week based on the nature of
dcscr bid monitoring for pH and flow are specified; the basis of these monitoring requirements were not
Special Conditions Basis- =—== =_=_=__-=_=__=_=_===^=_===_=
,L . . .. . '.opment within 6 months and the implementation within 18 months (set forth as a
*u 'J* i desl9ned to minimize or reduce the potential for contaminated storm water runoff
requires the development of BMP and SPCC plans to contain process liquids and solids. In accordance
regulations, the_permit requires taht the facility conduct discharge information zone (DIZ) monitoring.
' ? j- momt°ring indicate biological damage has occurred at the perimeter.;or outside a 400ft
the discharge site, the permittee will be required to submit a plan to correct and eliminate the
*k u- -. causedby the discharge. The permit contains a biocide clause to ensure that the Department
Jo oinh-h?! If!! '2 the cooling or boiler systems. The use of biocides containing tributyl tin, zinc,
is_prohibited based on data indicating that these compounds are toxic at low levels. Downstream DO
elc is specified in conjunction with NH3-N and BODS monitoring at 001;where DO results show
less than 5 nig/1, process water discharging must cease.
and
11/01/92
Expiration Date:
10/31/97
Abstract Date:
04/07/93
Page: 34
-------
Facility Name: Arkansas P&L, R.E. Ritchie Pi. Permit Number: AR0000388
Facility Description: Power plant SIC Code: 4931
Monitoring
Limit ELGs WQSs BPJ Only
3asis: J. £ - J.
Storm WQ
Special BHPs Water Sediment Survey
Conditions: -
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
- I - - *
Bio
Survey TRES MDLs Monitoring Other
I. I - - I
Abstract Information:
Partial; Outfall 001 (representative of 002), 003, 004, and 005.
Outfall: 001 Receiving Water: Mississippi River I Treatment: None.
Amount/Components :
202 MGD of once through cooling water from Unit 1.
Parameter
Acute WET
Flow
Temp.
TRC
Limitations
Monthly
Average
N/A
Report
N/A
Report MGD
N/A
125.000000 F
N/A
N/A
Dai ly
Maximum
N/A
Report
N/A
202.000000 MGD
N/A
N/A
28.000000 Ib/d
0.200000 mg/l
Other
Units not specified
130F inst. max. /see
below
See below
Monitoring Requirements
Frequency
1 /quarter
continuous
continuous
1/week
Sample Type
24hr fw composite
record
record
grab
Limitations/Monitoring Basis: . .
Except for Acute WET, limitations and monitoring requirements are retained from the previous permit. The limit
bases were further explained as follows: (1) TRC limitations are ELG-based consistent with the steam electric
category (40 CFR Part 423) where the mass limits are calculated based on a design flow of 202 MGD and 2 hrs/day of
ch 1 or i nation; (2) temp, limits are based on meeting State WQSs; and (3) the flow limit is based on the application
data. The daily avg. temp, must be calculated by summing the flow weighted temperatures taken over 2 hr increments
and dividing by the sum of the flows. In accordance with National policy. Region 6 strategy, and the need to
measure synergistic effects, WET testing is specified. WET testing is specified for all major industrial
facilities. Since the 7Q10 stream flow is more than 100 cfs and the stream to plant flow ratio is more than 100:1,
acute WET is specified. Acute WET testing is required in accordance with specified procedures; 5 dilutions
(including the critical dilution) and two species are specified. Testing for all outfall parametersmust be
conducted concurrent to acute WET testing. Testing may be reduced or discontinued dependent on findings of no
toxicity at the critical dilution and 1/2 the critical dilution; increased testing may also be specified if toxicity
is found. Specific forms are provided for recording acute WET results.
Outfall: 003 | Receiving Water: Mississippi River Treatment: Eq, Neut
Amount/Components:
0.058 MGD of demineralization system regeneration wastewater and sanitary wastewater
Parameter
BODS
Flow
O&G
PH
Limitations
Monthly
Average
N/A
30.000000 mg/l
N/A
Report MGD
N/A
10.000000 mg/l
N/A
Report
Daily
Maximum
N/A
45.000000 mg/l
N/A
Report MGD
N/A
15.000000 mg/l
N/A
Report
Other
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/week
continuous
1/week
1/week
Sample Type
grab
record
grab
grab
Page: 35
-------
1
FaciUty Name: Arkansas PSL, R.E. Ritchie PI. Perrajt number: AR0000388
Facility Description: Power plant SIC Code: 4931
TSS
N/A
30.000000 mg/l
N/A
100.000000 mg/l
1/week
grab
Limitations/Monitoring Basis:
The pH and OSG limits are WQ-based consistent with State Regulation No. 2. All other limits are continued from the
previous permit. The TSS limits were further explained to be ELG-based consistent with the steam electric category
(40 CFR Part 423). Monitoring for flow has been increased from 1/day, instantaneous to continuous, record due to
chart monitoring requirements for non-municipal permits. The bases of the remaining monitoring conditions were not
described.
Outfall: 004 Receiving Water: Unnamed ditch to Long Lake | Treatment: "p
Amount/Components :
0.3H5 HGO of low volume wastewater (boiler blowdown, boiler hopper seal, filter backwash, floor drains) and storm
water.
Parameter
Acute WET
As (T)
Flow
OSG
P«
SC
-------
Facility Name: Arkansas P&L, R.E. Ritchie PI. Permit Number: AR0000388
Facility Description: Power plant SIC Code: 4931
Cu (T)
Fe (T)
Flow
Hi (T)
O&G
Pb (T)
PH
S04
Tl (T)
TSS
Zn (T)
N/A
1.000000 mg/l
N/A
1.000000 mg/l
N/A
Report HGD
N/A
Report
N/A
10.000000 mg/l
N/A
Report
N/A
Report
N/A
42.000000 mg/l
N/A
Report
N/A
15.000000 mg/l
N/A
Report
N/A
1.000000 mg/l
N/A
1.000000 mg/l
N/A
Report HGD
N/A
Report
N/A
15.000000 mg/l
N/A
Report
N/A
Report
N/A
N/A
N/A
Report
N/A
23.000000 mg/l
N/A
Report
Units not specified
Units not specified
Between 6.0 su and 9
.0 su
See below
Units not specified
Units not specified
1/week
1/week
1/day
1/month
1/week
1/month
1/week
1/month
1/month
1/week
1/month
grab
grab
estimate
grab
grab
24hr fw composite
grab
grab
24hr fw composite
grab
24hr fw composite
The°Cu aTar^Fe (T) limits are ELG-based consistent with the steam electric category (40 CFR Part 423). pH and
O&G limits are WQ-based consistent with State Regulation No. 2. The TSS limits are WQ-based in accordance with the
Lakes Policy in State Regulation No. 6. A reasonable potential for Zn (T), Cd (T), Ag (T), Tl (T), Ni (T), and Pb
(T) exceedances exists based on the evaluation of data gathered from a priority pollutant scan. Since no numerical
State UQS have been developed for these parameters, no limitations have been placed in the permit. Monitoring
1/month is specified to ensure that levels are the same as reported by the facility. A limit for S04 has been
included due to data in the permit application being as high as 1110 mg/l; the limit is based on State Regulation 2
for the Delta Ecoregion. In accordance with National policy. Region 6 strategy, and the need to measure synergistic
effects WET testing is specified. Chronic WET monitoring is required based on the priority pollutant scan results.
Chronic'wET testing is required in accordance with EPA guidance manual procedures; 5 dilutions (including the
critical dilution) and two species are specified. Testing for all outfall parameters must be conducted concurrent
to WET testing. Testing may be reduced or discontinued dependent on findings of no toxicity at the critical
dilution and 1/2 the critical dilution; increased testing may also be specified if toxicity is found. Specific
forms are provided for recording chronic WET results.
Special Conditions Basis: . . .
Where toxicity is found in retests, a plan for the conduct of a TRE must be submitted within 60 days; the objectives
and minimum elements of a TRE are specified. The permittee is prohibited from discharging PCBs. TRC may not be
discharged more than 2hrs/day unless a demonstration is conducted; simultaneous chlorination is permitted. The
amperometric method for measuring TRC is specified. Notification to the State is required prior to beginning
discharge from Outfall 005. Other special conditions include reiteration of standard conditions and WQ-based
monitoring requirements at Outfalls 004 and 005; State operator licensing requirements; and miscellaneous
definitions. The bases of the special conditions were not discussed.
Effective Date: N/A Expiration Date: N/A Abstract Date: 05/28/93
Page: 37
-------
FacfUty Home: Tyson Foods, Grannis Permft Number. AR0003018
Facility Description: Poultry processing SIC Code: 2017
., , Monitoring WET WET Testing Multiple
Limit ELGs WQSs BPJ Only Limits Only Categories
Basis: r 1 -_ j_ z J. ' .
Storm WQ Bio
Special BHPs Water Sediment Survey Survey TRES HDLs
Conditions: - - - - - ^
Tiered
Limits Other
- J.
Monitoring Other
1 . i
Abstract Information:
Complete; Outfall 001 (A and B created for abstracting purposes).
Outfall: 001A | Receiving Water: Unnamed trib. to Rolling Fork | Treatment: AnL+EQ+AS+Sed+Dis
Amount/Components :
0.351 HGO of process wastewater and storm water.
Parameter
BOOS
CB005
Chronic WET
Cl
DO
FC
Fecal strcptococc
i
-------
Facility Name: Tyson Foods, Grannis
Permit Number: AR0003018
Facility Description: Poultry processing
SIC Code: 2017
compliance cannot be attained immediately; 3 years is provided in accordance with State regulations. TRC levels
are reported above goldbook values. However, since numerical State WQS have not been developed for TRC, no
limitations have been placed in the permit. Monitoring 2/week is specified for TRC; monitoring and reporting may be
discontinued after 2 years if no toxicity is evident. In accordance with National policy. Region 6 strategy, and
the need to measure synergistic effects, WET testing is specified,- chronic WET testing is required because the 7Q10
is less than 100 cfs and the dilution rate is less than 100. WET testing is required in accordance with EPA
guidance manual procedures; 5 dilutions (including the critical dilution) and two species are specified; the species
are indigenous to the area. Testing for all outfall parameters must be conducted concurrent to WET testing and
reported with the toxicity results. Testing may be reduced or discontinued dependent on findings of no toxicity at
the critical dilution; increased testing may also be specified if toxicity is found. Specific forms are provided
for recording chronic WET results.
Outfall: 001B | Receiving Water: Unnamed trib. to Rolling Fork | Treatment: AnL+EQ+AS+Sed+Dis
Amount/Components :
0.351 MGD of process wastewater and storm water
Parameter
BODS
CBOD5
Chronic WET
Cl
DO
FC
Flow
NH3-N
O&G
pH
S04
TDS
TRC
TSS
Limitations
Monthly
Average
132.000000 Ib/d
28.000000 mg/l
47.000000 Ib/d
10.000000 mg/l
N/A
N/A
N/A
15.000000 mg/l
N/A
6.000000 mg/l
N/A
200.000000
N/A
Report MGD
14.000000 Ib/d
3.000000 mg/l
47.000000 Ib/d
10.000000 mg/l
N/A
N/A
N/A
20.000000 mg/l
N/A
128.000000 mg/l
N/A
N/A
150.000000 Ib/d
15.000000 mg/l
Daily
Maximum
264.000000 Ib/d
57.000000 mg/l
70.000000 Ib/d
15.000000 mg/l
N/A
Report
N/A
Report
N/A
N/A
N/A
400.000000
N/A
Report MGD
21.000000 Ib/d
5.000000 mg/l
70.000000 Ib/d
15.000000 mg/l
N/A
Report
N/A
Report mg/l
N/A
Report mg/l
N/A
Report
299.000000 Ib/d
23.000000 mg/l
Other
See below
See below
See below
Units: #/100 ml
Seasonal; see below
Between 6.0 su and 9
.0 su
Units not specified
Units not specified
Units not specified
Monitoring Requirements
Frequency
2/week
2/week
1/quarter
1 /month
2/week
2/week
continuous
2/week
2/week
2/week
1 /month
1 /month
2/week
2/week
Sample Type
24hr fw composite
24hr fw composite
24hr fw composite
grab
24hr fw composite
grab
totalize
24hr fw composite
grab
grab
grab
grab
grab
24hr fw composite
Limitations/Monitoring Basis:
This outfall was created to represent those limitations effective from 09/30/95 through the expiration date.
Requirements and their bases are the same as Outfall 001A except for S04, TDS, and chloride, limits for these
parameters contained above become effective as described at Outfall 001A. The dai'ly maximum units of chloride are
not specified.
Special Conditions Basis:
Where toxicity is found in retests, a plan for the conduct of a TRE must be submitted within 60 days; the objectives
and minimum elements of a TRE are specified. The permittee must comply with 40 CFR Part 257 sludge disposal
requirements and specific sludge land application requirements itemized in the permit. These land application
specifications include application rate limitations, sludge monitoring and reporting requirements, sludge
application restrictions, recordkeeping requirements and other land management plan requirements. The permittee is
Page: 39
-------
Facility Marac: Tyson Foods, Grannis
Facility Description: Poultry processing
also required to maintain a sludge monitoring and reporting program, testing for
special conditions include reiteration of standard conditions and State operator
of the special conditions were not discussed.
Effective Date: N/A Expiration Date: N/A
Permit Number: AR0003018
SIC Code: 2017
specified parameters. Other
licensing requirements. The bases
Abstract Date: 05/28/93
Page: 40
-------
1 Permit Number: AR0035823
Facility Name: Potlack. Corporation
Facility Description: Bleached kraft pulp and paper mill
Monitoring
Limit ELGs WQSs BPJ Only
Basis: z. I - *-
Storm WQ
Special BMPs Water Sediment Survey
Conditions: z. z. - -
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
- J. . - - J-
Bio
Survey TRES MDLs Monitoring Other
2. J. J. — -
Abstract Information:
Complete; Outfalls 001, 002, 003, and 004.
Outfall: 001 | Receiving Water: Mississippi River I Treatment: PC, Aer, Sed
Amount/Components :
14 MGD daily avg. of process wastewater.
Parameter
2,3,7,8-TCDD
Acute WET
BODS
Flow
pH
TSS
procedures; 5 d
discontinued de
correspondence.
Outfall: 002
Limitations Monitoring Requirements
Monthly
Average
2702.000000 ug/d
51.000000 ppq
N/A
Report
9003.000000 Ib/d
N/A
N/A
Report
N/A
N/A
16357.000000 Ib/d
N/A
Daily
Maximum
2702.000000 ug/d
51.000000 ppq
N/A
Report
17308.000000 Ib/d
N/A
N/A
Report
N/A
N/A
30432.000000 Ib/d
N/A
Other Frequency
1 /quarter
See below 1/quarter
1/day
Units not specified continuous
Between 6.0 su and 9 1/day
.0 su
1/day
Sample Type
24hr fw composite
24hr fw composite
24hr fw composite
record
grab
24hr fw composite
^^^SS^plsIl^?^!*
Deceiving Water: Borrow Pit I Treatment: Not specified.
Amount/Components:
0 5 MGD daily avg. of water treatment tank bottoms discharge.
Parameter
Alkalinity
Clarifying agents
Flow
PH
ITOC
Limitations Monitoring Requirements
Monthly
Average
N/A
N/A
N/A
N/A
N/A
Report
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
Report mg/l
N/A
Report mg/l
N/A
Report
N/A
N/A
N/A
Report mg/l
Other Frequency
By Phenolpthalein me 2/month
thod
2/month
Units not specified continuous
Between 6.0 su and 9 2/month
.0 su
2/month
Sample Type
grab
grab
record
grab
grab
Page: 41
-------
Fief llty Name: Potlack Corporation Perm-t Number; AR0035823
Facility Description: Bleached kraft pulp and paper mill SIC Code- 2611
TSS
H/A
N/A
N/A
Report mg/l
2/month
Limitations/Monitoring Basis:
A discussion of the bases of the limitations and the monitoring requirements was not provided.
grab
Outfall: 003 | Receiving Water: Opossum Fork Creek | Treatment: Not specified.
Amount/Components :
0 MGD daily avg. (intermittent) of storm water runoff and cooling tower drainage.
Parameter
Flow
OSG
P«
TOC
Limitations
Monthly
Average
H/A
Report
H/A
10.000000 mg/l
N/A
N/A
H/A
N/A
Daily
Maximum
N/A
Report
N/A
15.000000 mg/l
N/A
N/A
N/A
55.000000 mg/l
Other
Units not specified
See below
Between 6.0 su and 9
.0 su
See below
Monitoring Requirements
Frequency
1/day
2/month
2/month
2/month
Sample Type
estimate
grab
grab
grab
Limitations/Monitoring Basis:
Monitoring must be conducted within the 1st hour of storm water discharge. A discussion of the bases of the
limitations and the monitoring requirements was not provided.
Outfall: 004 | Receiving Water: Canal 81 | Treatment: Fil
Amount/Components :
0.42 HGO of sand filter backwash water.
Parameter
Flow
P«
TSS
Limitations
Monthly
Average
H/A
Report
N/A
H/A
N/A
50.000000 mg/l
Daily
Maximum
N/A
Report
N/A
N/A
N/A
75.000000 mg/l
Other
Units not specified
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
continuous
2/month
2/month
Limitations/Monitoring Basis:
A discussion of the bases of the limitations and the monitoring requirements was not provided.
Sample Type
record
grab
grab
^rm!M™iJ;;it}' iS 1°"^ '""Detests, a plan for the conduct of a TRE must be submitted within 60 days; the objectives
o^BHP nV±^?-S ^ TRE are specified. If TRE results point to BHPs as a solution for toxicity, certif icltion
Mint tl^ S?« «,h T'^"9 "hlCh fubst?ntiate the elimination of toxicity must be submitted where resu Us
£l min«ion *,£ £ «SS>* T **%*' on 2PPllcatlon for a P^mit modification and a milestone schedule for toxicity
?MO Ana?vHr»I^Lth^ 1tted "''h'"90 days- A compliance threshold of 10 ppt has been established for 2,3,7,8-
bT^ed Chin I™ LM™? t+ t ?° thu Uuel ?f,the comPll'ance threshold. For reporting purposes, zero should
r? ^fcrl5n ana V6!03 results are below the threshold. Requirements to monitor 2,3,7,8-TCDD pursuant to EPA'C
«iS " stuj; .^^l^ protocol is set forth. 2,3,7,8-TCDD sludge monitoring is a so required I/quarter Other
re^S ^n^'to^tHv ^» sft6^'^5 ?f cl^"^"9 agent reporting requirements and several standard conditions;
r^iif^ y Jat? °f the lmPendlr|9 "se of biocides andinc hydrosulf ite; and a 2,3,7,8-TCDD pollutant-
specific reopener clause. The bases of these conditions were not discussed. ponutani:
Effective Date: M/A Expiration Date: 11/30/94 Abstract Date: 05/28/93
Page: 42
-------
Facility Name: Viskase Corporation Permlt Number: AR0036544
Facility Description: Manufacturers cellulosic food casing SIC Code: Z8Z3
Monitoring
Limit ELGs WQSs BPJ Only
Basis: i J. - -
Storm UQ
Special BMPs Water Sediment Survey
Conditions: - -
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
I. J. - - J-
Bio
Survey TRES MDLs Monitoring Other
Abstract Information: .
Partial; Outfalls 001, 101, and 002 (representative of 003).
Outfall: 001 | Receiving Water: Mississippi River Treatment: Neut+Sed or AS
Amount/Components:
1.06 MGD treated process wastestreams.
Parameter
Acute WET
BODS
COD
Flow
NH3-N
pH
TSS
Limitations
Monthly
Average
N/A
N/A
235.000000 Ib/d
N/A
784.000000 Ib/d
N/A
N/A
Report
470.000000 Ib/d
N/A
N/A
Report
314.000000 Ib/d
N/A
Daily
Maximum
N/A
Report
470.000000 Ib/d
N/A
1568.000000 Ib/d
N/A
N/A
Report
941.000000 Ib/d
N/A
N/A
Report
627.000000 Ib/d
N/A
Other
See below
Units not specified
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1 /quarter
2/week
2/week
continuous
2/week
1/day
2/week
Sample Type
24hr fw composite
24hr fw composite
24hr fw composite
record
24hr fw composite
grab
24hr fw composite
L imltThe0ll1 mi tat^ons" are3 continued from the previous permit based on the permit writer's judgement. The previous bases
of these limitations and the current bases of the monitoring requirements were not described on an individual limit
basis The sources cited for the development of the permit included: State WQSs, 40 CFR Part 122 and 125, and
EPA's'Gold Book. In accordance with National Policy, Region 6 strategy, and the need to measure synergistic
effects WET testing is specified; acute WET testing is required because the 7Q1CI is less than 100 cfs and the
dilution ratio is more than 100:1. WET testing is required in accordance with EPA guidance manual procedures; 5
dilutions (including the critical dilution) and two species are specified since they are indigenous to the area.
Testing for all outfall parameters must be conducted concurrent to WET testing. Testing may be reduced or
discontinued dependent on findings of no toxicity at the critical dilution and 1/2 the critical dilution,- increased
testing may also be specified if toxicity is found. Specific forms are provided for recording acute WET results.
Outfall: 002 | Receiving Water: Tyronza River Treatment: None
Amount/Components :
Unspecified amount of storm water runoff.
Parameter
Flow
O&G
pH
Limitations
Monthly
Average
N/A
Report
N/A
N/A
N/A
N/A
Dai ly
Maximum
N/A
Report
N/A
15.000000 mg/l
N/A
N/A
Other
Units not specified
See below
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/day
1/day
1/day
Sample Type
estimate
grab
grab
Page: 43
-------
Facility Home: Viskase Corporation
Permit Number: AR0036544
Facility Description: Manufacturers cellulosic food casing
SIC Code: 2823
N/A
N/A
N/A
50.000000 mg/l
See below
1/day
grab
Limitations/Monitoring Basis:
The limitations are continued from the previous permit based on the permit writer's judgement. Samples must be
taKon within the first hour of storm water discharge but are only required during daylight hours when the plant is
operating. The previous bases of these limitations and the current bases of the monitoring requirements were not
described.
Outfall: 101
Receiving Hater: Internal outfall via 001
Treatment: Not specified.
Araount/Ccwponents:
Unspecified amount of phenol containing water.
Parameter
Flow
Phenols
Limitations
Monthly
Average
N/A
Report
0.100000 Ib/d
N/A
Daily
Maximum
N/A
Report
O.ZOOOOO Ib/d
N/A
Other
Units not specified
Monitoring Requirements
Frequency
1/day
1/week
Sample Type
estimate
24hr fw composite
Limitations/Monitoring Basis:
The limitations are continued from the previous permit based on the permit writer's judgement. The previous bases
of these limitations and the current bases of the monitoring requirements were not described.
pccial Conditions Basis:
Where toxicity is found in retests, a plan for the conduct of a TRE must be submitted within 60 days; the objectives
and minimum elements of a TRE are specified. Notification in writing to the State is required 30 days prior to
beginning discharge of phenols through Outfall 101; Outfall 101 is inactive until notification is provided The
permittee must comply with 40 CFR Part 257 sludge disposal requirements. Other special conditions include'
reiteration of standard conditions; sludge disposal information; State operator licensing requirements- and
miecf.iianonii
-------
Facility Name: Libbey Owens Ford, Lathrop 10 Permit Number: CA0004839
Facility Description: Manufacturer of laminated and tempered auto glass SIC Code: 3211
Monitoring
Limit ELGs WQSs BPJ Only
Basis: J_ J. - ^
Storm WQ
Special BMPs Water Sediment Survey
Conditions: z. - - -
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
J. - - J- -
Bio
Survey TRES MDLs Monitoring Other
1 L '. - , J. J-
jstract Information:
Complete; Outfalls 001, 001A, 002, 003, and 007.
Outfall: 001 | Receiving Water: San Joaquin River I Treatment: Sed
Amount ax°mP°ng"8|'MGD Qf process wastewaters, domestic waste, noncontact cooling waters,, HF acid solutions, storm runoff,
and groundwater infiltration.
Parameter
BOD5
Chronic WET
Co
Coliform (T)
Cr
DO
Flow
Fluoride
Ni
O&G
Other
Pb
PH
Se
Sn
SS
TDS
Temp.
Limitations
Monthly
Average
3.200000 Ib/d
15.000000 mg/l
N/A
N/A
N/A
Report mg/l
N/A
23.000000
N/A
Report mg/l
N/A
Report mg/l
N/A
Report MGD
N/A
Report mg/l
N/A
Report mg/l
Report Ib/d
10.000000 mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report
N/A
Report mg/l
N/A
Report mg/l
N/A
0.100000 ml/l
N/A
Report mg/l
N/A
Report
Dai ly
Maximum
6.300000 Ib/d
30.000000 mg/l
N/A
Report
N/A
Report mg/l
N/A
500.000000
N/A
Report mg/l
N/A
Report mg/l
N/A
2.100000 MGD
N/A
23.000000 mg/l
N/A
Report mg/l
Report Ib/d
15.000000 mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report
N/A
Report mg/l
N/A
Report mg/l
N/A
0.200000 ml/l
N/A
Report mg/l
N/A
86.000000
Other
See below
See below
Units: #/100 ml
See below
See below
See below
Standard minerals
See below
Between 6.5 su and 8
.5 su
See below
See below
Units: degrees Faren
heit
Monitoring Requirements
Frequency
1/week
1 /month
1 /month
1 /month
1 /month
Dai ly
1/day
1 /month
1/week
1/year
1 /month
1/2 weeks
1 /month
1 /month
1/2 weeks
1/week
1/day
Sample Type
24 hr composite
Grab
Grab
Grab
Grab
'
Cont i nuous
Grab
Grab
24 hr composite
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Page: 45
-------
Facility Homo: Libbey Owens Ford, Lathrop 10 Permit Number: CA0004839
Facility Description: Manufacturer of laminated and tempered auto glass sic Code: 3211
TRC
TSS
N/A
Report mg/l
135.000000 Ib/d
30.000000 mg/l
N/A
0.100000 mg/l
162.000000 Ib/d
60.000000 mg/l
1/week
24 hr composite
Limitations/Monitoring Basis:
ELGs mass based limitations for TSS were calculated using the total maximum production of the facility (750 tons/day
float glass, 150,000 sq. ft. /day tempered automotive glass, 100,000 sq. ft. /day laminated glass) and 25,000 GPD of
domestic wastewater pursuant to the glass manufacturing point source category (40 CFR Part 426, Subparts E F and
G) and 40 CFR Part 133 secondary treatment regulations. All other limitations have been assumedto be based on water
quality considerations established as part of the Water Quality Plan, 2nd Edition for the Sacramento- San Joaquin
Delta Basin. The rationale for the development of monitoring requirements was not provided and monitoring
requirements for the discharge of TRC or DO to the receiving stream were not specified in the permit. Survival of
test fishes in 96-hr bioassay of undiluted effluent shall be no less than: minimum forany one bioassay (70%) and the
median for any three or more consecutive bioassays (90%).
Outfall: 001A | Receiving Water: Internal outfall to 001 | Treatment: None
Amount/Components:
Maximum flow of 0,3 MGD of wastewater from the production of architectural float glass.
Parameter
OSG
Other
TSS
Limitations
Monthly
Average
3. 100000 Ib/d
N/A
0.080000 Ib/d
N/A
3.000000 Ib/d
N/A
Dai ly
Maximum
2.100000 Ib/d
N/A
0.080000 Ib/d
N/A
3.000000 Ib/d
N/A
Other
0.0028 Ib/ton of pro
duct
P-.0001 Ib/ton of pr
oduct
0.004 Ib/ton of prod
uct
Monitoring Requirements
Frequency
"
Sample Type
•
Limitations/Monitoring Basis:
TSS, OSG, and P production-based ELGs were based on 40 CFR Part 426 Sufapart E. Mass-based ELGs were calculated
using a maximum production rate of 750 tons/day of float glass. Mass limits must be calculated on a weekly basis.
Monitoring requirements were not provided.
Outfall: 002 | Receiving Water: Internal outfall to 001 | Treatment: API
Amount/Components:
Maximum flow of 0.4 MGD of wastewater from the production of tempered automotive glass.
Parameter
OSG
TSS
Limitations
Monthly
Average
19.500000 Ib/d
N/A
35.400000 Ib/d
N/A
Dai ly
Maximum
19.500000 Ib/d
N/A
56.600000 Ib/d
N/A
Other
0.1316/1060 sqft pro
duct
See below
Monitoring Requirements
Frequency
Sample Type
Limitations/Monitoring Basis: ;
TSS and OSG production-based ELGs were based on 40 CFR Part 426 Subpart F. Mass-based ELGs were calculated using a
maximum production rate of 150,000 sq. ft. /day of laminated automotive glass. Mass limits must be calculated on a
Weekly basis. Monitoring requirements were not provided.
Page: 46
-------
Facility Name: Libbey Owens Ford, Lathrop 10 Permit Number: CA000483?
Facility Description: Manufacturer of laminated and tempered auto glass SIC Code: 3211
Outfall: 003 Receiving Water: Internal outfall to 001 | Treatment: API
Amount/Components:
Maximum flow of 0.4 HGD of wastewater from the production of laminated automotive glass.
Parameter
O&G
Other
TSS
Limitations
Monthly
Average
36.000000 Ib/d
N/A
22.000000 Ib/d
N/A
90.000000 Ib/d
N/A
Daily
Maximum
36.000000 Ib/d
N/A
22.000000 Ib/d
N/A
90.000000 Ib/d
N/A
Other
0.36 lb/1000 sqft pr
oduct
P-.22 lb/1000 sqft p
roduc
0.9 lb/1000 sqft pro
duct
Monitoring Requirements
Frequency
Sample Type
Limitations/Monitoring Basis:
TSS, P, and O&G production-based ELGs were based on 40 CFR Part 426 Subpart G. Maiss-based ELGs were calculated
using a maximum production rate of 100,000 sq. ft. /day of laminated automotive glass. Mass limits must be
calculated on a weekly basis. Monitoring requirements were not provided.
Outfall: 007 Receiving Water: San Joaquin River Treatment: N/A
Amount/Components:
Maximum of 0.83 MGD combined discharge from Outfalls 001-006.
Parameter
BODS
Coliform (T)
Fluoride
O&G
SS
TRC
TSS
Limitations
Monthly
Average
3.200000 Ib/d
15.000000 mg/l
N/A
23.000000
N/A
N/A
N/A
10.000000 mg/l
N/A
0.100000 ml/I
N/A
N/A
135.000000 Ib/d
30.000000 mg/l
Daily
Maximum
6.300000 Ib/d
30.000000 mg/l
N/A
500.000000
N/A
23.000000 mg/l
N/A
15.000000 mg/l
N/A
0.200000 ml/I
N/A
0.100000 mg/l
162.000000 Ib/d
60.000000 mg/l
Other
Units: MPN/ 100 ml
Monitoring Requirements
Frequency
Sample Type
Limitations/Monitoring Basis:
See limitations/monitoring basis for each of the outfalls. Monitoring requirements were not provided.
Special Conditions Basis: ,..,_.«
Monitoring requirements and limitations (for some parameters) were established for the discharge of wastewaters to
land (flow, BOD, TSS, TDS, O&G, DO, Se, Cr, Hi, Co, and Coliform (T)), upstream and downstream water monitoring
(TRC temperature, turbidity, DO, and F), water supply monitoring (P, standard minerals, and TDS), and sludge
monitoring (Cd, Cr, Cu, Pb, Ni, Se, Sn, and Zn). Reclaimed wastewater used for Uiwn irrigation shall meet criteria
contained in Title 22, California Code of Regulations. The DO content of the holding ponds used for land
application of wastewaters shall not be less than 1.0 mg/l for 16 hours in any 24-hr period. The discharge shall
not increase the turbidity of the receiving water by more than 10 percent over background levels. The discharge
shall not create a zone defined by water temperatures of more than 1 degree Farenheit above natural receiving water
temperature which exceeds 25 percent of the cross sectional area of the San Joaquin River at any point nor exceed
the background receiving water temperature by more than 40 degrees Farenheit. The fluoride limitation is based on
water quality considerations. -Discharges of fluoride process wastewaters are prohibited from April 15 to June 15, _
the critical time for spawning and migration of fish in the San Joaquin River. Monitoring for fluoride, Se, Cr, Ni,
and Co shall only occur when constituents are in use. O&G shall be sampled for using the trichlorof luorethane
extraction method. Land application requirements are consistent with the approved Operation Plan for Land Disposal
of Effluent. The discharger shall submit an updated Operations Plan for Land Disposal of Effluent by June 1991.
Within 120 days of permit issuance, the facility shall submit a plan to limit mineralization in the discharge to
Page: 47
-------
Facility Homo: Libbey Owens Ford, Lathrop 10
Permit Number: CA0004839
Facility Description: Manufacturer of laminated and tempered auto.glass
SIC Code: 3211
surface water. ^The discharger shall implement an effluent toxicity program in accordance with EPA procedures within
60 days of permit issuance and within 60 days of Board approval implement the approved biotoxicity monitoring ,
program. Compliance with the P limitation shall be based on total P in the effluent less the amount of P in the
supply and groundwater infiltration waters at the facility.
Effective Date: 02/22/91
Expiration Date: 02/01/96
Abstract Date: 04/07/93
Page: 48
-------
Facility Name: Advanced Micro Devices, Inc. Permlt Number: "0028797
Facility Description: Semiconductor manufacturer su; uoae- 3C"'*
Monitoring
Limit ELGs WQSs BPJ Only
Basis: J. J- J-
Storm UQ
Special BMPs Water Sediment Survey
Conditions: z - -
MET WET Testing Multiple Tiered
Limits Only Categories Limits Other
1 - - - -
Bio
Survey TRES MDLs Monitoring Other
jstract Information:
Complete; Outfall 001.
Outfall: 001 | Receiving Water: Calabazas Creek I Treatment: AirS, Fit
Amount/Components ^OOQ ^ contaminated groundwater from eight on-site extraction welts and 280,000 GPD of extracted
groundwater from two off-site systems.
Parameter
1,1,1-Trichloroet
hane
1,2-Cis-Dichloroe
thylene
1,2-Trans-Dichlor
oethylene
Ag
As
BODS
Cd
Chronic WET
CN
Cr+6
Cu
Dichlorobenzene
DO
Ethylbenzene
Flow
Hg
Hethylene chlorid
e
NH3-N
Limitations
Monthly
Average
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
Report kg/d
Report rag/ I
N/A
Report ug/l
N/A
N/A
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report mg/l
N/A
Report ug/l
N/A
Report MGD
N/A
Report ug/l
N/A
Report ug/l
Report kg/d
Report mg/l
Dai ly
Maximum
N/A
5.000000 ug/l
N/A
5.000000 ug/l
N/A
5.000000 ug/l
N/A
2.300000 ug/l
N/A
20.000000 ug/l
Report kg/d
Report mg/l
N/A
10.000000 ug/l
N/A
Report
N/A
25.000000 ug/l
N/A
11.000000 ug/l
N/A
20.000000 ug/l
N/A
5.000000 ug/l
N/A
Report mg/l
N/A
5.000000 ug/l
N/A
Report MGD
N/A
1.000000 ug/l
N/A
5.000000 ug/l
Report kg/d
0.400000 mg/l
Other
% survival
5.0 mg/l minimum
0.025 mg/l annual me
dian
Monitoring Requirements
Frequency
1 /month
1 /month
1 /month
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
not given
1/year
Continuous
1/year
1 /month
Variable
Sample Type
Grab
Grab
Grab
grab
Grab
Grab
Grab
Grab
grab
Grab
Grab
grab
not given
Grab
Recorder
grab
Grab
Grab
Page: 49
-------
Facility Nun: Advanced Micro Devices, Inc. Pennlt Number. CAOo28797
Facility Description: Semiconductor manufacturer SIC Code- 3674
Hi
Other
Pb
PH
TOS
Temp.
Tetrachlorocthyle
ne
TPH
Trichlorobcnzene
Vinyl chloride
VOCs CT>
Xylenes
Zn
H/A
Report ug/l
H/A
Report ug/l
M/A
Report ug/l
H/A
Report
H/A
Report mg/l
H/A
Report
H/A
Report ug/l
H/A
Report ug/l
H/A
Report ug/l
M/A
Report ug/l
M/A
Report ug/l
N/A
Report ug/l
H/A
Report ug/l
H/A
7.100000 ug/l
H/A
5.000000 ug/l
H/A
5.600000 ug/l
H/A
Report
H/A
Report mg/l
H/A
Report
H/A
5.000000 ug/l
H/A
50.000000 ug/l
H/A
5.000000 ug/l
H/A
0.500000 ug/l
H/A
10.000000 ug/l
H/A
5.000000 ug/l
N/A
58.000000 ug/l
Trichlorof luorometha
ne
Between 6.5 su and 8
.5 su
Units: degrees Celci
us
1/year
1 /month
1/year
1 /month
1/quarter
1/quarter
1 /month
1/year
1/year
1 /month
1 /month
1/year
1/year
Grab
'Grab
Grab
Grab
Grab
Grab
grab
Grab
grab
Grab
Grab
Grab
Grab
Liraitations/Honitoring Basis:
Effluent limitations are based on the Water Quality Control Plan for the San Francisco Bay Region (Basin Plan),
State and USEPA plans and policies, BATEA, and best technical judgement. EPA Region 9's draft guidance "NPDES
Permit Limitations for the Discharge of Contaminated Groundwater: Guidance Document" was considered and the San
Francisco Bay Regional Water Quality Control Board Internal Memorandum "Proposed NPDES Permit Limits for Common
Organic Pollutants Found at Service Stations and other Groundwater Cleanup Sites" was also used. The rationale for
the prescribed monitoring requirements was not contained in the fact sheet or permit. Toxicity limits are as
follows: the survival of rainbow trout in a 96-hr bioassay of the effluent shall be a median of 90% survival and a
90 porcentilo of not less than 70%. In addition to the. DO limit, the median DO concentration for any three
consecutive months shall not be less than 80% of the DO content at saturation. The pH shall not cause the receiving
water to vary from normal ambient pH levels by more than 0.5 units. The monitoring of flow shall be the influent
flow to the treatment system from the groundwater extraction wells. Monitoring for all other parameters shall be
;!£??* ? P01?! '" discharge immediately prior to discharge into the storm drain tributary of Calabazas Creek.
Additional monitoring requirements were imposed in the permit between the air stripper towers and the carbon
?«?™?™2niaHS11:'.an? SV f°int '"'V11!: u-°rm drain to its flow into Calabazas Creek. MH3-H shall be analyzed andi
££{£.» u ?» calculated whenever fish bioassay test results fail to meet the specified percent survival. The daily
StlHf «ns?iiuents°for EPA 601 "anafytes! ^ enf°rCed aS 1"nstantaneous maximum Imitations. Total VOCs are the
Special Conditions Basis:
Hone.
Effective Date: 12/12/90 Expiration Date: 12/12/95 Abstract Date: 04/07/93
Page: 50
-------
Facility Name: Granite Construction Co-Felton Permit Number: CA0048755
Facility Description: Open pit granite quarry and processing facility SIC Code: 1411
.imit
Basis:
Special
Conditions:
ELGs
BMPs
WQSs
I
Storm
Water
BPJ
Sediment
I •
Monitoring
Only
WQ
Survey
WET
Limits
Bio
Survey
WET Testing
Only
TRES
Multiple
Categories
MDLs
Tiered
Limits
Monitoring
J.
Other
Other
Abstract Information:
Complete; Outfall 001.
Outfall: 001
Receiving Water: Gold Gulch and/or Majors Creek
Treatment: Sed
Unspecified amt. of storm runoff and material washwaters from the overburden stockpile area, quarry pit settling pond,
asphalt batch plant & stockpile
Parameter
Flow
ss
TSS
Monthly
Average
N/A
Report MGD
N/A
Report ml/ I
N/A
Report mg/l
Limitations
Daily
Maximum
N/A
Report MGD
N/A
0.300000 ml/I
N/A
100.000000 mg/l
Other
Monitorin
Frequency
1 /month
3/week
3/week
g Requirements
Sample Type
Record
Grab
Grab
Limitations/Monitoring Basis: .
No justification'was provided in the rationale for permit development, but effluent limitations seem to be based on
water quality considerations, as contained in the Water Quality Control Plan, Central Coastal Basin. The discharge
shall not cause coloration in Gold Gulch and Majors Creek greater than 15 units or 10% above natural background
color, whichever is greater.
Special Conditions Basis: . .
By September 15th of every year, the permittee shall inspect, install, and have in proper operational condition all
erosion and sediment control systems necessary to assure compliance with the permit. The pH of the receiving waters
shall not be depressed below 7.0 su, raised above 8.3 su, or change more than 0.5 su. The discharge of any wastes
other than material washwater and stormwater runoff from the quarry site is prohibited.
Effective Date: 01/10/92
Expiration Date: 01/01/97
Abstract Date: 04/03/93
Page: 51
-------
Facility Name: Palo Verde Irrigation District Permit Number: CA0105139
Facility Description: Ground water treatment facility SIC Code. 4971
.. . Monitoring WET WET Testing Multiple Tiered
Limit ELGs WQSs BPJ Only Limits Only Categories Limits
Basis: ; 1 I i ._ ± ._ __
Storm WQ Bio
Special BHPs Water Sediment Survey Survey TRES MDLs Monitoring
Conditions: - - ~ - - - - J
Other •
Other
Abstract Information:
Complete; Outfall 001.
Outfall: 001 | Receiving Water: Lovekin Drain to Colorado R. | Treatment: AirS, gravity separation
Amount/Components:
Average daily flow of up to 190 gallons per minute of treated groundwater.
Parameter
Acute WET
Benzene
Ethylbenzene
Flow
Other
Pb
PH
TOS
Temp.
Toluene
Xylcncs
Limitations
Monthly
Average
N/A
N/A
N/A
Report ug/l
N/A
Report ug/l
N/A
Report GPD
N/A
Report ug/l
N/A
Report ug/l
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Report ug/l
N/A
Report ug/l
Daily
Maximum
N/A
Report
N/A
1.000000 ug/l
N/A
680.000000 ug/l
N/A
Report GPD
N/A
Report ug/l
N/A
50.000000 ug/l
N/A
Report
N/A
Report
N/A
Report
N/A
100.000000 ug/l
N/A
1750.000000 ug/l
Other
See below
Petroleum hydrocarbo
ns(T)
Between 6.0 su and 9
.0 su
Units: degrees Get si
us
Monitoring Requirements
Frequency
1/year
1/month
1 /month
Continuous
1/month
1/month
1/month
1/month
1/month
1/month
1/month
Sample Type
Grab
Grab
Grab
Recorder
Grab
Grab
Grab
Grab
Grab
Grab
!Grab
Limitations/Monitoring Basis:
Effluent limitations are based upon State Department of Health Service action levels, primary drinking water
standards, USEPA's water quality criteria, and best professional engineering judgement. The rationale for
monitoring was not provided. The effluent shall cause no acute toxicity in the receiving stream. Acute toxicity is
defined as less than 90% survival, 50% of the time, and less than 75% survival, 10% of the time in a 96-hour sttic
or continuous flow test.
Special Conditions Basis:
Influent monitoring shall consist of sampling for all identified parameters contained in 40 CFR Part 136 test method
601 and benzene, toluene, xylene, and ethylbenzene. At the time of permit issuance, the permittee is required to
sample once during the first and fifth day of operation for benzene, toluene, xylene, ethylbenzene, TDS and total
petroleum hydrocarbons. Bioassays are to be performed quarterly for the first year. pH and temperature are to be
monitored daily for 5 days and monthly thereafter. Priority metals and the parameters contained in 40 CFR Part 136
Test Method 601 are to be sampled once during the first day of operation and 2/year thereafter. Priority metals are
those defined in 40 CFR Part 136.
Effective Date: 01/22/92 Expiration Date: 01/22/97 Abstract Date: 04/06/93
Page: 52
-------
Facility Name: Climax Molybdenum Co. Henderson Permit Number: C00000230
Facility Description: Molybdenite mine dewatering and mi U discharge SIC Code: 1061
Monitoring
Limit ELGs WQSs BPJ Only
asis: j_ J. J. J.
Storm WQ
Special BMPs Water Sediment Survey
Conditions: z. — — -
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
J. J. . - - I
Bio
Survey TRES MDLs Monitoring Other
-_ 1 I J. J.
Complete; Outfalls 001(A, B, C, D, E, and F created for abstracting purposes; also represents 002), 003, 004(A and B
created for abstracting purposes), and 005.
Outfall: 001A | Receiving Water: Lower Urad Reservoir I Treatment: Sed
Amount/Components:
Average flow of 1.7 MGD consisting of mine dewatering, sanitary wastewater, and storm water.
Parameter
Acute WET
Ag (DS)
Al (DS)
As (DS)
Cd (DS)
Chronic WET
Cr+6
Cu (DS)
Fe (TR)
Flow
Hg (T)
Mn (TR)
Mo (T)
Hi (DS)
O&G
Pb (DS)
pH
Radium (T)
Limitations
Monthly
Average
N/A
N/A
N/A
0.005000 mg/l
N/A
Report mg/l
N/A
0.223000 mg/l
N/A
0.010000 mg/l
N/A
N/A
N/A
0.016000 mg/l
N/A
0.030000 mg/l
N/A
1.438000 mg/l
N/A
1.700000 MGD
N/A
0.001000 mg/l.
N/A
18.017000 mg/l
N/A
Report mg/l
N/A
0.239000 mg/l
N/A
N/A
N/A
0.012000 mg/l
N/A
N/A
N/A
Report
Daily
Maximum
N/A
Report %
N/A
Report mg/l
N/A
Report mg/l
N/A
0.499000 mg/l
N/A
Report mg/l
N/A
Report %
N/A
0.022000 mg/l
N/A
0.042000 mg/l
N/A
Report mg/l
N/A
Report MGD
N/A
0.002000 mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
2.070000 mg/l
N/A
10.000000 ,mg/l
N/A
, 0.294000 mg/l
N/A
Report
N/A
Report
Other
See below
Potentially dissolve
d
Potentially dissolve
d
Potentially dissolve
d
Potentially dissolve
d
See below
Potentially dissolve
d
Potentially dissolve
d
Potentially dissolve
d
No visible sheen
Potentially dissolve
d
Between 6.5 su and 9
.2 su
Units: pCi/l
Monitoring Requirements
Frequency
1 /quarter
1/week
1 /month
1/week
1 /month
2/year
1/week
1/week
1 /month
1/week
1/week
1/week
1 /month
1/week
1/week
1/week
1/week
1 /month
Sample Type
grab
grab
grab
grab
grab
8hr fw composite
grab
grab
grab
instantaneous
grab
grab
grab
grab
grab/visual
grab
grab
grab
Page: 53
-------
Facility Name: ClTmax Molybdenum Co. Henderson Permit Number: C00000230
Facility Description: Molybdenite mine dewatering and mill discharge SIC Code: 1061
TSS
U (DS)
Zn (OS)
H/A
30.000000 mg/l
H/A
Report mg/l
H/A
1.538000 mg/l
H/A
H/A
H/A
Report mg/l
N/A
Report mg/l
45 mg/l 7-day averag
e
Potentially dissolve
d
Potentially dissolve
d
1/week
1 /month
1/week
grab
grab
grab
Limitations/Monitoring Basis:
Outfall 001A created to represent limits which apply during the months of October through May, only, from the
effective date of the permit through 7/8/93. Limits for Cu, Pb, Ho, TSS, and Hg based on ELGs in 40 CFR Part 440
Subpart J. Limits for Zn, Cd, and Mn based on WQSs and consistent with THDLs for Clear Creek. State "Regulations
for Effluent Limitations" (10.1.0) used for O&G limits.. Limits for all metals are for "potentially dissolved" metal
fractions as defined in the "Basic Standards and Methodologies for Surface Water" (3.1.0). The pH limit is based on
the previous permit, analysis of downstream pH, and Fed Reg 440.131(d). Limits for Fe and Ni are based on WQSs.
Limits for Ag based on historical data until WQSs are in effect. Monitoring was set for Al and radium because they
were detected downstream. WET testing consistent with "Regulations for the State Disharge Permit System" (Section
6.9.7). Beginning July July 1, 1995, the IWC will vary seasonally: Oct-May, IWC 63%; Jun-Jul, IWC 21%; and Aug-Sep,
1WC 44%. Acute toxicity limit based on reasonable potential associated with discharge from mine containing heavy
metals. WET testing is to be conducted following the EPA guidance document. Acute WET testing is to include 2
species, 48-hour and 96-hour tests, using replacement static tests. If individual test shows toxicity at a
concentration less than or equal to the instream waste concentration (seasonal value given in the permit) or 50%
species mortality in any dilution, the permittee must notify the permitting authority and begin accelerated testing.
under the direction of the permitting authority, the permittee will perform a preliminary toxicity investigation
and/or a TRE and/or a toxicity control program. Chronic WET testing is to be conducted for one year using static
replacement tests and 2 species, following the EPA guidance document. The potentially dissolved metal fraction is
defined as an analytical method in a footnote and a citation is provided.
Outfall: 001B | Receiving Water: Lower Urad Reservoir | Treatment: Sed
Amount/Components:
Average flow of 1.7 HGD consisting of mine dewatering, sanitary wastewater, and storm water.
Parameter
Acute WET
Ag (DS)
Al (OS)
As (DS)
Cd (DS)
Chronic HET
Cr+6
Cu (DS)
Fe (TR)
Flow
Kg (T)
Hn (TR)
Limitations
Monthly
Average
H/A
H/A
H/A
0.005000 mg/l
H/A
Report mg/l
H/A
0.540000 mg/l
H/A
0.028000 mg/l
H/A
H/A
H/A
0.040000 mg/l
H/A
0.026000 mg/l
N/A
3.332000 mg/l
H/A
1.600000 MGD
H/A
0.001000 mg/l
H/A
49.337000 mg/l
Daily
Maximum
N/A
Report %
N/A
Report mg/l
N/A
Report mg/l
N/A
1.163000 mg/l
N/A
Report mg/l
N/A
Report %
N/A
0.052000 mg/l
H/A
0.033000 mg/l
H/A
Report mg/l
N/A
Report MGD
N/A
0.002000 mg/l
N/A
Report mg/l
Other
Potentially dissolve
d
Potentially dissolve
d
Potentially dissolve
d
Potentially dissolve
d
Potentially dissolve
d
Potentially dissolve
d
Monitoring Requirements
Frequency
1/quarter
1/week
1 /month
1/week
1 /month
2/year
1/week
1/week
1 /month
1/week
1/week
1/week
Sample Type
See permit protocol
grab
grab
grab
grab
See permit protocol
grab
grab
grab
instantaneous
grab
grab
Page: 54
-------
Facility Name: Climax Molybdenum Co. Henderson ' Permit Number: C00000230
Facility Description: Molybdenite mine dewatering and mill discharge SIC Code: 1061
Mo (T)
Ni CDS)
O&G
Pb (DS)
PH
Radium (T)
TSS
U (DS)
Zn (DS)
N/A
Report mg/l
N/A
0.265000 mg/l
N/A
N/A
N/A
0,005000 mg/l
N/A
N/A
N/A
Report
N/A
30.000000 mg/l
N/A
Report mg/l
N/A
4.231000 mg/l
N/A
Report mg/l
N/A
2.278000 mg/l
N/A
10.000000 mg/l
N/A
0.105000 mg/l
N/A
Report
N/A
Report
N/A
N/A
N/A
Report mg/l
N/A
Report mg/l
Potentially dissolve
d
No visible sheen
Potentially dissolve
d
Between 6.5 su and 9
,2 su
Units: pci/l
45 mg/l 7-day averag
e
Potentially dissolve
d
Potentially dissolve
d
1 /month
1/week
1/week
1/week
1/week
1 /month
1/week
1 /month
1/week
grab
grab
grab/visual
grab
grab
grab
grab
grab
grab
Limitations/Monitoring Basis:
Outfall 001B was created to represent limits which apply during the months of June and July, only from the effective
date of the permit through 7/8/93. See Limits/Monitoring Basis Discussion for Outfall 001A.
Outfall: 001C | Receiving Water: Lower Urad Reservoir | Treatment: Sed
Amount/Components :
Average flow of 1.7 MGD consisting of mine dewatering, sanitary wastewater, and s;torm water.
Parameter
Acute WET
Ag (DS)
Al (DS)
As (DS)
Cd (DS)
Chronic WET
Cr+6
Cu (DS)
Fe (TR)
Flow
Hg (T)
Limitations
Monthly
Average
N/A
N/A
N/A
0.005000 mg/l
N/A
Report mg/l
N/A
0.289000 mg/l
N/A
0.014000 mg/l
N/A
N/A
N/A
0.021000 mg/l
N/A
0.023000 mg/l
N/A
1.832000 mg/l
N/A
1.600000 MGD
N/A
0.001000 mg/l
Dai ly
Maximum
N/A
Report %
N/A
Report mg/l
N/A
Report mg/l
N/A
0.617000 mg/l
N/A
Report mg/l
N/A
Report %
N/A
0.028000 mg/l
N/A
0.029000 mg/l
N/A
Report mg/l
N/A
Report MGD
N/A
0.002000 mg/l
Other
Potentially dissolve
d
Potentially dissolve
d
Potentially dissolve
d
Potentially dissolve
d
Potentially dissolve
d
Potentially dissolve
d
Monitoring Requirements
Frequency
1/quarter
1/week
1 /month
1/week
1 /month
2/year
1/week
1/week
1 /month
1/week
1/week
Sample Type
See permit protocol
grab
grab
grab
grab
See permit protocol
grab
grab
grab
instantaneous
grab
Page: 55
-------
Facility Mame: Climax Molybdenum Co. Henderson • Permit Number: C00000230
Facility Description: Molybdenite mine dewatering and mill discharge SIC Code: 1061
Mn (TR>
Ho (T)
Hi (OS)
OS6
Pb (OS)
PH
Radium (T)
TSS
U (OS)
Zn CDS)
N/A
25.024000 mg/l
N/A
Report mg/l
N/A
0.200000 mg/l
N/A
N/A
N/A
0.006000 mg/l
N/A
N/A
N/A
Report
N/A
30.000000 mg/l
N/A
Report mg/l
N/A
2.131000 mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
1.647000 mg/l
N/A
10.000000 mg/l
N/A
0.132000 mg/l
N/A
Report
N/A
Report
N/A
N/A
N/A
Report mg/l
N/A
Report mg/l
Potentially dissolve
d
No visible sheen
Potentially dissolve
d
Between 6.5 su and 9
.2 su
Units: pCi/l
45 mg/l 7-day averag
e
Potentially dissolve
d
Potentially dissolve
d
1/week
1 /month
1/week
1/week
1/week
1/week
1 /month
1/week
1 /month
1/week
grab
grab
grab
grab/visual
grab
grab
grab
grab
grab
grab
i
Limitations/Monitoring Basis:
Outfall 001C was created to represent limits which apply during the months of August and September, only from the
effective date of the permit through 7/8/93. See Limits/Monitoring Basis Discussion for Outfall 001A.
Outfall: 0010 | Receiving Water: Lower Urad Reservoir | Treatment: Sed
Amount/Components :
Average flow of 1.7 MGD consisting of mine dewatering, sanitary wastewater, and storm water.
Parameter
Acute WET
Afl (OS)
Al (OS)
As (OS)
Cd (OS)
Chronic WET
Cr+6
Cu (OS)
Fe (TR>
Flow
Limitations
Monthly
Average
N/A
H/A
N/A
0.000300 mg/l
N/A
0.160000 mg/l
N/A
0.200000 mg/l
N/A
0.002400 mg/l
N/A
N/A
N/A
0.015000 mg/l
N/A
0.027000 mg/l
N/A
1.300000 mg/l
N/A
2.610000 MGD
Dai ly
Maximum
N/A
Report %
N/A
0.006500 mg/l
N/A
1.100000 mg/l
N/A
0.440000 mg/l
N/A
0.009000 mg/l
N/A
Report %
N/A
0.020000 mg/l
N/A
0.038000 mg/l
N/A
Report mg/l
N/A
Report MGD
Other
See below for limits
Potentially dissolve
d
Potentially dissolve
d
Potentially dissolve
d
Potentially dissolve
d
Potentially dissolve
d
Potentially dissolve
d
Monitoring Requirements
Frequency
1/quarter
1/week
1 /month
1/week
1 /month
2/year
1/week
1/week
1 /month
1/week
Sample Type
See permit protocol
grab
grab
grab
grab
See permit protocol
grab
grab
grab
instantaneous
Page: 56
-------
Facility Name: Climax Molybdenum Co. Henderson Permit Number: C00000230
Facility Description: Molybdenite mine dewatering and mill discharge SIC Code: 1061
Hg (T)
Mo (T)
Ni (DS)
O&G
Pb (DS)
pH
Radium (T)
TSS
U (DS)
Zn (DS)
N/A
0.001000 mg/l
N/A
Report mg/l
N/A
0.239000 mg/l
N/A
N/A
N/A
0.011000 mg/l
N/A
N/A
N/A
Report
N/A
30.000000 mg/l
N/A
4.247000 mg/l
N/A
0.258000 mg/l
N/A
0.002000 mg/l
N/A
Report mg/l
N/A
2.070000 mg/l
N/A
10.000000 mg/l
N/A
0.270000 mg/l
N/A
Report
N/A
Report
N/A
N/A
N/A
6.107000 mg/l
N/A
0.259000 mg/l
Potentially dissolve
d
No visible sheen
Potentially dissolve
d
Between 6.5 su and 9
.2 su
Units: pCi/l; see be
low.
45 mg/l 7- day avg.
Potentially dissolve
d
Potentially dissolve
d
1/week
1 /month
1/week
1/week
1/week
1/week
1 /month
1/week
1 /month
1/week
grab
grab
grab
grab/visual
grab
grab
grab
grab
grab
grab
Limitations/Monitoring Basis:
Outfall 001D was created to represent limits which apply during the months October through May, only from 7/9/93
through 9/30/97. See Limits/Monitoring Basis Discussion for Outfall 001A. Limits for radium begin October 1, 1994.
October through May monthly average limits will be 7.476 pCi/l and the permittee is required to report the daily,
maximum.
Outfall: 001E | Receiving Water: Lower Urad Reservoir | Treatment: Sed
Amount/Components :
Average flow of 1.7 MGD consisting of mine dewatering, sanitary wastewater, and storm water.
Parameter
Acute WET
Ag (DS)
Al (DS)
As (DS)
Cd (DS)
Chronic WET
Cr+6
Cu (DS)
Fe (TR)
Flow
Limitations
Monthly
Average
N/A
N/A
N/A
0.000090 mg/l
N/A
0.260000 mg/l
N/A
0.500000 mg/l
N/A
0.001600 mg/l
N/A
N/A
N/A
0.037000 mg/l
N/A
0.021000 mg/l
N/A
3.100000 mg/l
N/A
2.490000 MGD
Daily
Maximum
N/A
Report %
N/A
0.002000 mg/l
N/A
2.600000 mg/l
N/A
1.060000 mg/l
N/A
0.005300 mg/l
N/A
Report %
N/A
0.047000 mg/l
N/A
0.028000 mg/l
N/A
Report mg/l
N/A
Report MGD
Other
See below for limits
Potentially dissolve
d
Potentially dissolve
d
Potentially dissolve
d
'Potentially dissolve
d
Potentially dissolve
d
Potentially dissolve
d
Monitoring Requirements
Frequency
1 /quarter
1/week
1 /month
1/week
1 /month
2/year
1/week
1/week
1 /month
1/week
Sample Type
See permit protocol
grab
grab
grab
grab
See permit protocol
grab
grab
grab
instantaneous
Page: 57
-------
Facility Hame: Climax Molybdenum Co. Henderson Permit Number: C00000230
Facility Description: Molybdenite mine dewatering and mill discharge SIC Code: 1061
Hg (T)
Ho (T)
Hi CDS)
OSG
Pb (DS)
PH
Radium (T)
TSS
U (OS)
Zn (DS)
H/A
0.001000 mg/l
M/A
Report mg/l
N/A
0.265000 mg/l
N/A
N/A
N/A
0.001100 mg/l
M/A
N/A
N/A
Report
N/A
30.000000 mg/l
N/A
3.066000 mg/l
N/A
0.194000 mg/l
N/A
0.002000 mg/l
N/A
Report mg/l
N/A
2.278000 mg/l
N/A
10.000000 mg/l
N/A
0.096000 mg/l
N/A
Report
N/A
Report
N/A
N/A
N/A
4.299000 mg/l
N/A
0.197000 mg/l
Potentially dissolve
d
No visible sheen
Potentially dissolve
d
Between 6.5 su and 9
.2 su
Units: pCi/l See be
low.
45 mg/l 7- day averag
e
Potentially dissolve
d
Potentially dissolve
d
1/week
1 /month
1/week
1/week
1/week
1/week
1 /month
1/week
1/month
1/week
grab
grab
grab
grab/visual
grab
grab
grab
grab
grab
grab
Limitations/Monitoring Basis:
Outfall 001E was created to represent limits which apply during the months of June and July, only from 7/9/93
through 9/30/97. See Limits/Monitoring Basis Discussion for Outfall 001A. Limits for radium begin October 1, 1994.
The monthly average limit for June and July will be 18.188 pCi/l and the permittee will be required to report the
daily maximum.
Outfall: 001F | Receiving Water: Lower Urad Reservoir | Treatment: Sed
Amount/Components:
Average flow of 1.7 HGD consisting of mine dewatering, sanitary wastewater, and storm water.
Parameter
Acute MET
Ag (DS)
Al (DS)
AS (DS)
Cd (DS)
Chronic WET
Cr+6
Cu (DS)
Fe (TR)
Flow
Limitations
Monthly
Average
N/A
N/A
N/A
0.000100 mg/l
N/A
0.180000 mg/l
N/A
0.250000 mg/l
N/A
0.001700 mg/l
N/A
N/A
N/A
0.018000 mg/l
N/A
0.014000 mg/l
N/A
1.600000 mg/l
N/A
2.630000 MGD
Daily
Maximum
N/A
Report %
N/A
0.002700 mg/l
N/A
1.300000 mg/l
N/A
0.520000 mg/l
N/A
0.003700 mg/l
N/A
Report %
N/A
0.023000 mg/l
N/A
0.018000 mg/l
N/A
Report mg/l
N/A
Report MGD
Other
See below for limits
Potentially dissolve
d
Potentially dissolve
d
Potentially dissolve
d
Potentially dissolve
d
Potentially dissolve
d
Potentially dissolve
d
Monitoring Requirements
Frequency
1/quarter
1/week
1/month
1/week
1/month
2/year
1/week
1/week
1/month
1/week
Sample Type
See permit protocol
grab
grab
grab
grab
See permit protocol
grab
grab
grab
instantaneous
Page: 58
-------
Facility Name: Climax Molybdenum Co. Henderson Permit Number: C00000230
Facility Description: Molybdenite mine dewatering and mill discharge SIC Code: 1061
Hg (T)
Mo (T)
Ni (DS)
O&G
Pb (DS)
pH
Radium (T)
TSS
U (DS)
Zn (DS)
N/A
0.001000 mg/l
N/A
Report mg/l
N/A
0.200000 mg/l
N/A
N/A
N/A
0.003300 mg/l
N/A
N/A
N/A
Report
N/A
30.000000 mg/l
N/A
2.834000 mg/l
N/A
0.189000 mg/l
N/A
0.002000 mg/l
N/A
Report mg/l
N/A
1.647000 mg/l
N/A
10.000000 mg/l
N/A
0.078000 mg/l
N/A
Report
N/A
Report
N/A
N/A
N/A
3.870000 mg/l
N/A
0.183000 mg/l
Potentially dissolve
d
No visible sheen
Potentially dissolve
d
Between 6.5 su and 9
.2 su
Units: pCi/l See be
low.
45 mg/l 7- day averag
e
Potentially dissolve
d
Potentially dissolve
d
1/week
1 /month
1/week
1/week
1/week
1/week
1 /month
1/week
1 /month
1/week
grab
grab
grab
grab/visual
grab
grab
grab
grab
grab
grab
L imi tat i ons/Moni tori ng Bas i s :
Outfall 001 F was created to represent limits which apply during the months of August and September, only from 7/9/93
through 9/30/97. See Limits/Monitoring Basis Discussion for Outfall 001A. Limits for radium begin October 1, 1994.
The monthly average limits for August and September will be 9.707 pCi/l and the permittee will be required to report
the daily maximum.
Outfall: 003 Receiving Water: Internal to Outfall 001 | Treatment: AS
Amount/Components :
Average flow 0.018 MGD consisting of sanitary wastewater only (ssociated with mining)
Parameter
BODS
FC
Flow
TRC
Limitations
Monthly
Average
N/A
30.000000 mg/l
N/A
Report
N/A
Report ' MGD
N/A
N/A
Dai ly
Maximum
N/A
45.000000 mg/l
N/A
Report
N/A
Report MGD
N/A
0.500000 mg/l
Other
Units: No./lOO ml
Monitoring Requirements
Frequency
1 /month
1 /month
1 /month
1/week
Sample Type
grab
grab
instantaneous
grab
Limitations/Monitoring Basis:
Internal outfall 003 was established to monitor and regulate TRC. Limits for TRC and O&G were based on the "State
Regulations for Effluent Limitations" (10.1.0). Monitoring requirements were established for FC because it is known
to be present, but not expected to be at levels of concern. Limits for BODS were included because elevated levels
have been found at this outfall. The limit is technology-based, using secondary treatment standards. Monitoring
requirements were established as 1/week for parameters of concern.
Page: 59
-------
Facility Home: Climax Molybdenum Co. Henderson Permit Number: C00000230
Facility Description: Molybdenite mine dewatering and mill discharge SIC Code: 1061
Outfall: 004A | Receiving Water: Williams Fork River | Treatment: None specified.
Amount/Components:
Typically, no flow of milling process uastewater bypass.
Parameter
Cd (DS)
CM (T)
Cu (OS)
Fc (TR)
HO (T)
Hn (TR)
Pb (DS)
pH
S04
TSS
Zn (DS)
Limitations
Monthly
Average
M/A
0.000580 mg/l
N/A
0.005000 mg/l
N/A
0.005800 mg/l
N/A
1.000000 mg/l
N/A
0.000010 mg/l
N/A
1.000000 mg/l
N/A
0.001200 mg/l
N/A
Report
N/A
250.000000 mg/l
N/A
30.000000 mg/l
N/A
0.052000 mg/l
Daily
Maximum
N/A
0.001500 mg/l
N/A
0.010000 mg/l
N/A
0.008000 mg/l
N/A
2.000000 mg/l
N/A
0.000020 mg/l
N/A
2.000000 mg/l
N/A
0.025000 mg/l
N/A
Report
N/A
N/A
N/A
45.000000 mg/l
N/A
0.057000 mg/l
Other
Potentially dissolve
d
Applies during disch
arge
Potentially dissolve
d
Applies during disch
arge
Applies during disch
arge
Potentially dissolve
d
Between 6.5 su and 9
.0 su
Applies during disch
arge
Applies during disch
arge
Potentially dissolve
d
Monitoring Requirements
Frequency
1/week
1/week
1/week
1/week
1/week
1/week
1/week
1/week
1/week
I/week
1/week
Sample Type
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
Limitations/Monitoring Basis:
When discharge from Outfall 004 results from a 10-year, 24-hour storm event, the instream water quality standards
must be met. In addition, prior to discharge, the permittee must submit written notice of their intent to discharge
10 days prior to the beginning date of any discharge. Along with such notice, the permittee is required to submit a
recent analysis of the mill circuit water for specified parameters, and an estimate of the total time required to
discharge. Discharge without a documented 10-year 24-hour storm event is addressed in this abstract in Outfall
0048. The basis for the TSS and pH limits and the monitoring conditions was not discussed.
Outfall: 005 | Receiving Water: Williams Fork River | Treatment: None
Amount/Components:
Gage station on the River.
Parameter
Cd (DS)
CM (T)
CU (DS)
Fe (TR)
Flow
Limitations
Monthly
Average
M/A
N/A
H/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/ 1
N/A
Report mg/l
N/A
Report MGD
Other
Monitoring Requirements
Frequency
1/week
1/week
1/week
1/week
1/week
Sample Type
• grab
grab
grab
grab
instantaneous
Page:
60
-------
Facility Name: Climax Molybdenum Co.Henderson P«™t Number: C00000230
Facility Description: Molybdenite mine dewatering and mill discharge SIC Code: 1061
Hg (T)
Mn (TR)
Pb CDS)
S04
Zn (DS)
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
1/week
1/week
1/week
1/week
1/week
grab
grab
grab
grab
grab
Lim1ThisnUHTmto0n"toriBngSpSo1nt for the mill side, used to measure flow and calculate the final instream concentration
for any discharges from Outfall 004.
Outfall: 004B j Receiving Water: Wi 1 liams Fork River Treatment: None specified.
Amount/Components :
Typically no flow of milling process wastewater bypass.
Parameter
Acute WET
Cd (DS)
Cd (T)
CN (T)
Cu (DS)
Cu (T)
Fe (TR)
Hg (T)
Mn (TR)
Pb (DS)
Pb (T)
PH
S04
TSS
Zn (DS)
Limitations
Monthly
Average
N/A
N/A
N/A
0.000580 mg/l
N/A
0.050000 mg/l
N/A
0.005000 mg/l
N/A
0.005800 mg/l
N/A
0.150000 mg/l
N/A
1.000000 mg/l
N/A
0.000010 mg/l
N/A
1.000000 mg/l
N/A
0.001200 mg/l
.N/A
0.300000 mg/l
N/A
Report
N/A
250.000000 mg/l
N/A
20.000000 mg/l
N/A
0.052000 mg/l
Daily
Maximum
N/A
Report %
N/A
0.001500 mg/l
N/A
0.100000 mg/l
N/A
0.010000 mg/l
N/A
0.008000 mg/l
N/A
0.300000 mg/l
N/A
2.000000 mg/l
N/A
0.000020 mg/l
N/A
2.000000 mg/l
N/A
0.025000 mg/l
N/A
0.600000 mg/l
N/A
Report
N/A
N/A
N/A
30.000000 mg/l
N/A
0.057000 mg/l
Other
Applies during disch
arge
Potentially dissolve
d
Applies during disch
arge
Applies during disch
arge
Potentially dissolve
d
Applies during disch
arge
Applies during disch
arge
Applies during disch
arge
Potentially dissolve
d
Applies during disch
arge
Between 6.5 su and 9
.0 su
Applies during disch
arge
Applies during disch
arge
Potentially dissolve
d
Monitoring Requirements
Frequency
1 /quarter
1/week
1/week
1/week
1/week
1/week
1/week
1/week
1/week
1/week
1/week
1/week
1/week
1/week
1/week
Sample Type
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
Page: 61
-------
Facility Name: Climax Molybdenum Co.Henderson
Permit Number: C00000230
Facility Description: Molybdenite mine dewatering and mill discharge
Zn (T)
N/A
0.500000 mg/l
N/A
1.000000 mg/l
Applies during disch
arge
1/week
SIC Code: 1061
grab
Limitations/Monitoring Basis:
When discharge from Outfall 004 results without a documented 10-year, 24-hour storm event, effluent limitations for
ftf ihi. h2clo'*on 11' W-l' ST)' T!S and WET .?s.wel1 as instream water quality standards must be met. Discussion
of the basis for the limits and monitoring conditions was not provided.
Special Conditions Basis:
A Whole effluent toxicity control program plan is due 30 days from the permit effective date. An update of the
Materials Containment Plan is due 90 days from the permit effective date. A report and implementation plan for
controlling radium is due by August 1, 1993. The permit contains a reopener based on the results of the toxicity
tests. Storm water discharges are not included in this permit at this time, pending notification on the group
permit application. The permittee is required to document storms greater than a 10-year 24-hour event which
qualifies the facility for the precipitation-based limits for Outfall 004. The permittee is required to install a
flow measuring device within 90 days of the permit effective date if not already present.
Effective Date: 10/01/9H
Expiration Date: 09/30/97
Abstract Date: 05/04/93
Page: 62
-------
Facility Name: Fort St Vrain Electric Gen Sta
Permit Number: C00001121
Facility Description: Nuclear power plant being decommissioned with no electricity generated SIC Code: 4931
Limit ELGs WQSs BPJ
Basis: 11 I
Storm
Special BHPs Water Sediment
Conditions: J. J. 2.
Monitoring
Only
J.
WQ
Survey
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
2. J. - ' - J.
Bio
Survey TRES MDLs Monitoring Other
z I 1,1 I
Abstract Information:
Partial: Outfalls 001A, 002 (representative of 001B), 006, and 007. No monitoring is required for Outfalls 003, 004,
and 005.
Outfall: 001A Receiving Water: South Platte River | Treatment: Sed
Amount/Components :
2.0794 MGD average flow containing the overflow from the farm pond at the Parshall flume, which is prior to entering
the river.
Parameter
Flow
O&G
pH
Temp.
TRC
Limitations
Monthly
Average
N/A
Report MGD
N/A
N/A
N/A
Report
N/A
Report F
N/A
0.250000 mg/l
Daily
Maximum
N/A
Report MGD
N/A
10.000000 mg/l
N/A
Report
N/A
86.000000 F
N/A
.0.250000 mg/l
Other
See below
Between 6.5 su and 9
.0 su
See below
Monitoring Requirements
Frequency
1/week
1/week
1/week
1/week
1/week
Sample Type
instantaneous
visual
grab
in-situ
grab
Limitations/Monitoring Basis:
Limits for TRC based on ELGs in 40 CFR Parts 423.12 and 423.13 as well as WQSs because the power plant, now being
decommissioned, will eventually operate. The limits were determined using a flow weighted calculation for 6
contributing wastewater sources. For some of these sources BPJ values were used in the calculation. Release of
free available Cl and TRC are limited to 2 hrs/day from any one unit and no more than one unit at a time. Discharges
from metal cleaning and cooling tower basin cleaning wastes are prohibited. Discharge of PCBs is prohibited.
Limits for pH are based on State WQSs (5 CCR 1002-8). O&G limits are based on State Standards, Regulations for
Effluent Limitations" (10.1.0) If a visible sheen or floating oil is observed at a discharge point, corrective
actions are to be taken. A log of these activities is required. Temperature limits are based on BPJ and river
classification as warm water aquatic specified in the State Basic Standards and Methodologies for Surface Water
(3.1.0). Net TSS limits set in accordance with 40 CFR Part 122.45(2)(g). Monitoring conditions based on previous
permit. The permit contains monitoring for the 126 priority pollutants due to chemicals added for cooling tower
maintenance. A one time analysis for all priority pollutants, organic chemicals, PCBs and other chemicals indicated
in the permit renewal application is required for each permit renewal.
Outfall: 002 | Receiving Water: St Vrain Creek | Treiatment: Sed
Amount/Components :
2.0794 MGD average flow, discharging only as an alternative to Outfall 001B during ditch maintenance, containing
discharge from the drainage slough
Parameter
Acute WET
Chronic WET
Cr (T)
Fe (TR)
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
0.027500 mg/l
N/A
1.400000 mg/l
Daily
Maximum
N/A
Report
N/A
Report
N/A
0.027500 mg/l
N/A
Report mg/l
Other
See below
Monitoring Requirements
Frequency
1 /quarter
See below , 2/year
1 /month
1 /month
Sample Type
grab
8hr fw composite
grab
grab
Page: 63
-------
Facility Name: Fort St Vrain Electric Gen Sta Permit Number: C00001121
Facility Description: Nuclear power plant being decommissioned with no electricity generated SIC Code: 4931
Flow
NH3 (T)
OSG
P (T)
pH
Temp.
TRC
TSS
Zn
N/A
Report HGD
N/A
Report mg/l
N/A
N/A
N/A
Report mg/l
N/A
Report
N/A
Report F
N/A
0.250000 mg/l
N/A
30.000000 mg/l
N/A
0.200000 mg/l
N/A
Report MGD
N/A
N/A
N/A
10.000000 mg/l
N/A
N/A
N/A
Report
N/A
86.000000 F
N/A
0.250000 mg/l
N/A
46.500000 mg/l
N/A
0.210000 mg/l
mg/l as N
See below
Between 6.5 su and 9
.0 su
See below
Net, see below
1/week
1 /month
1/week
1 /month
1/week
1/week
1/week
1/week
1 /month
instantaneous
grab
visual
grab
grab
in-situ
grab
grab
• grab
Limitations/Monitoring Basis:
Limitations/Monitoring Basis for Outfall 001A also applies here. Chronic toxicity testing required Jan-June, Jul-
Dcc, until June 30, 1996. WET testing is to be conducted to evaluate the synergistic or antagonistic effect of
compounds. Acute WET testing is to be conducted following EPA methods for placement static tests of a single
effluent grab sample using 1 specie with the 48hr test and another with the 96hr test. If a test shows toxicity at
concentrations less than or equal to the IWC of 100%, or if 50% mortality is found in any dilution, the permittee
wust notify the permitting authority, and begin an accelerated testing program. Under the direction of the
permitting authority, the permittee will perform a preliminary toxicity investigation and/or a TRE and/or a toxicity
control program. Chronic WET testing is to be conducted using 3 grab samples composited for a miimum of 8 hours.
Chronic testing is to be conducted using EPA methods for static replacement tests, and 2 species. The permittee is
required to install a flow measuring device within 90 days of the permit effective date if not already present.
TSS. Cr, and Zn limits based on ELGs. Net TSS limits set in accordance with 40 CFR Part 122.45(2)(g). Fe limit
included based on an assessment of water quality data. If an individual toxicity test shows toxicity at specified
levels, an accelerated testing schedule is required. WET testing requirements established by Section 6.9.7 of the
"Regulations for the State Discharge Permit System" for discharges from wastewater treatment facilities. One time
analysis per_permit term of priority pollutants, organic chemicals, PCBs, and other chemicals included to ensure no
detection, with exception of Cr(T) and Zn(T). Monitoring for ammonia and phosphorus continued from past permit
because chemicals used at the facility contain them.
Outfall: 006 | Receiving Water: Internal to Outfalls 001 or 2 [ Treatment: API
Amount/Components :
Unspecified amount of low volume waste discharging from the turbine building drain at the end of the 24- inch pipe,
prior to mixing with other waters.
Parameter
Flow
OSG
pH
TSS
Limitations
Monthly
Average
N/A
Report MGD
N/A
15.000000 mg/l
N/A
Report
N/A
30.000000 mg/l
Daily
Maximum
N/A
Report MGD
N/A
20.000000 mg/l
N/A
Report
N/A
100.000000 mg/l
Other
No visible sheen.
Between 6.0 su and 9
.0 su
Monitoring Requirements
F requency
1/week
1/week
1/week
1 /month
Sample Type
instantaneous
visual
grab
grab
Limitations/Monitoring Basis:
Limits for O&G and TSS are based on ELGs in 40 CFR Parts 423.12 and 423.13 because the power plant will eventually
operate, and the discharge is entirely low volume waste. Limits for pH are based on the State "Regulations for
Effluent Limitations" (10.1.0). The basis for the monitoring conditions was not discussed. The limits for TSS and
OSG do not apply when storm water runoff dischared from smaller pipes adjacent to 24-in pipes.
Page: 64
-------
Facility Name: Fort St Vrain Electric Gen Sta P«™t Number: C00001121
Facility Description: Nuclear power plant being decommissioned with no electricity generated SIC Code: 4931
Outfall: 007 Receiving Water: Internal to Outfalls 001 or 2 Treatment: API, AS, Dis, AerL
Amount ^mponen^s. ^ 0_0030 HQD cons,-st,-ng Of internal discharge from sewage treatment system from last treatment unit,
prior to mixing with other waters.
Parameter
BODS
FC
Flow
O&G
PH
TRC
TSS
Limitations
Monthly
Average
N/A
30.000000 mg/l
N/A
6000.000000
N/A
Report MGD
N/A
N/A
N/A
Report
N/A
Report mg/l
N/A
75.000000 mg/l
Daily
Maximum
N/A
Report mg/l
N/A
N/A
N/A
Report MGD
N/A
10.000000 mg/l
N/A
Report
N/A
0.500000 mg/l
N/A
Report mg/l
Other
7-day avg: 45 mg/l
Units: NO./100 ml
No visible sheen.
Between 6.0 su and 9
.0 su
7-day avg: 110 mg/l
Monitoring Requirements
Frequency
1 /month
1 /month
1/week
1/week
1/week
1/week
1 /month
Sample Type
grab
grab
instantaneous
visual
grab
grab
grab
Llm Imitations are" based1 on those contained in previous permit. Limits for pH, O&G, BODS, and TSS based on State
"Regulations for Effluent Limitations" (10.1.0). Fecal coliform limit based on State Fecal Coliform Policy. A 7-
day average limit of 12,000 /100 ml is also provided. TRC is regulated because chlorine is used for disinfection.
The basis for the TRC limitation was not discussed. The basis for monitoring was not discussed.
SpeC1TheC permittee is*5 required to prepare and submit a storm water management plan containing specific BMPs, and
implement it on a schedule established in the permit. The permittee is required to submit an updated Materials
Containment Plan within 90 days of the permit effective date. Site-specific BMPs in the permit include managing the
total combined flow from the main cooling tower, service cooling tower, and flow from the storage ponds.
Radiological monitoring data sampled for the NRC must be submitted. The permit includes a reopener based on the
results of toxicity testing.
Effective Date: 04/30/93 Expiration Date: 11/30/97 Abstract Date: 04/30/93
Page: 65
-------
Facility Name: Denver Stapleton Intl. Airport Permit Number; C00026620
Facility Description: Discharges from storm sewer system associated with large airport SIC Code: 4581
... Monitoring WET WET Testing Multiple
Basis: - ^ J */y Llml'ts Only Categories
Storm WQ Bio
Special BHPs Water Sediment Survey Survey TRES MDLs
conditions: j / /
— — - ± _ ± ±
Tiered
Limits
Monitoring
J.
Other
J.
Other
^
Abstract Information:
Partial; Outfalls 008 (representative of 009A, 009B, 009C, and 010 in summer) and 010 (in winter).
Outfall: 008 | Receiving Water: Sand Creek | Treatment: None specified.
Afflount/CoBjponents :
1.8 HOD based on 1.2 year storm event consisting of storm drainage from storm sewer line #1.
Parameter
Acute WET
BOOS
Ethylenc glycol
FC
Flow
Jet fuel
OSG
pH
Propylene glycol
Trichloroethylene
TSS
Limitations
Honthly
Average
N/A
N/A
N/A
Report mg/l
N/A
Report mg/l
N/A
2000.000000
N/A
Report HGD
N/A
Report mg/l
N/A
N/A
N/A
Report
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
Daily
Maximum
N/A
50.000000 %
N/A
Report mg/l
N/A
19.000000 mg/l
N/A
N/A
N/A
12.800000 MGD
N/A
Report mg/l
N/A
10.000000 mg/l
N/A
Report
N/A
Report mg/l
N/A
0.005000 mg/l
N/A
Report mg/l
Other
mortality with IWC 8
7%
Units: No./100 ml
Between 6.5 su and 9
.0 su
Monitoring Requirements
Frequency
1/quarter
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
Sample Type
grab
grab
grab
grab
instantaneous
grab
grab
grab
grab
grab
grab
Limitations/Monitoring Basis:
cHtorlfElL'Hf"™5!: °"iy Ci!ay th™U9h !eP?en*er5- Discharge allowed in winter, with same limits, if several
lralt£ if r^f,?rTuh D\sch*r.3e '? authorized on y during or within 24 hours following a precipitation event.
du£hl™n required whenever there Is a precipitation event, and on a monthly basis regardless of the source of the
discharge. Host of the imits were developed using BPJ or continued from previous permit without further
nSrf Xr'rfM Jthylene glycol limit is based on human health concerns, as the the receiving water flows into a river
vtoUticnf, rintaSn ™eh,Jn hhlf.haS%th- Previ°ys.P^mit limit was retained, even though the permittee had many
violations. Based on human health criteria, no limit was included for propylene glycol. The limit for TCE was
based on drinking water standards listed in "Basic Standards and Methodologies for Surface Water" (31 11) and was
r££i!ri£2 £2? *?" P*?V1°US fS™ft-u The ^"mitS f°r PH and FC were based °" water quality standards, even though
EE •«!?«« ?fr?* f S could-no? be estimated. The WQSs were applied directly to the effluent. Monitoring-only
t^M^'c * J£ fU!ib?:?l8e-lt oS n°t.e>
-------
Facility Name: Denver Stapleton Intl. Airport Permit Number: C00026620
Facility Description: Discharges from storm sewer system associated with large airport SIC Code: 4581
Outfall: 010 Receiving Water: Sand Creek Treatment: Sed.
Amount/Components:
Unknown volume consisting of ground water from Eastside Treatment Plant detention pond, discharging only in emergency
to protect pond bed integrity.
Parameter
Acute WET
BODS
Ethylene glycol
FC
FlOW
Jet fuel
O&G
PH
Propylene glycol
Tri ch loroethy lene
TSS
Limitations
Month ly
Average
N/A
N/A
N/A
Report mg/l
N/A
Report mg/l
N/A
2000.000000
N/A
Report MGD
N/A
Report mg/l
N/A
N/A
N/A
Report
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
Dai ly
Maximum
N/A
50.000000 %
N/A
Report mg/l
N/A
19.000000 mg/l
N/A
N/A
N/A
12.800000 MGD
N/A
Report mg/l
N/A
10.000000 mg/l
N/A
Report
N/A
Report mg/l
N/A
0.005000 mg/l
N/A
Report mg/l
Other
mortality with IWC 8
7%
Units: No./100 ml
Between 6.5 su and 9
.0 su
Monitoring Requirements
Frequency
1/quarter
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
Sample Type
grab
grab
grab
grab
instantaneous
grab
grab
grab
grab
grab
grab
Limitations/Monitoring Basis:
Limits apply year around, although this outfall has never been used, and it is expected that it will never be used.
Discharge from the other outfalls is not authorized unless several criteria provided in the permit are met.
Sampling is required whenever there is a precipitation event, and on a monthly basil's regardless of the source of the
discharge. Monitoring-only was used for jet fuel because it is not expected to be present, but had been detected.
Host of the limits were developed using BPJ or continued from previous permit without further explanation. Ethylene
glycol limit is based on human health concerns, as the receiving water flows into a riverused for drinking water.
In this case, the previous permit was retained, even though the permittee had many violations. Based on human
health criteria, no limit was included for propylene glycol. The limit for TCE was based on drinking water
standards listed in "Basic Standards and Methodologies for Surface Water" (3. 1.11), and was continued from the
previous permit. The limits for pH and FC were based on water quality standards, even though receiving water low
flow could not be estimated. The WQSs were applied directly to the effluent. See Limitations/Monitoring Basis for
Outfall 008 for a discussion of WET testing.
Special Conditions Basis:
Instream WET testing (biomonitoring) is required 2/year up- and down-stream of the discharge points to determine the
toxicity of the receiving waters. An updated O&M plan is required, including an ethylene glycol monitoring and
elimination plan. The permit contains a toxicity reopener clause. Due to part problems with airport tenants,
permittee is required to monitor for the following at 5 discharge points, 1/year, using grab samples:organic toxic
pollutants with specified fractions using GC/HS (detection limits provided); TDS, TSS, ammonia(T), pH, surfactants,
COD, Cd(TR), Cr(+6), Cu(TR), Fe(TR), Pb(TR), Mn(TR), Ag(TR), and Zn
-------
Facility Home: Highway 36 Land Development Co Permit Number: C00042064
Facility Description: Hazardous waste treatment and disposal SIC Code: 9999
Monitoring
Limit ELGs UQSs BPJ Only
Basis: ^ ^ J. I
Storm WQ
Special BHPs Water Sediment Survey
Conditions: j_ 2. - -
WET WET Testing Multiple Tiered
Limits Only Categories Limits
J. 2. - -
Bio
Survey TRES MDLs Monitoring
-1 I -
Other
I
Other
I
Abstract Information:
Complete; Outfalls 001 and 002.
Outfall: 001 | Receiving Water: Beaver Creek | Treatment: GAC, Fil, Scr
Amount/Components :
Stormwater discharges from the triple cell carbon adsorption system, designed for a daily maximum flow of 0.36 MGD,
only after onsite uses maximized.
Parameter
1,1,1-Trichloroet
hano
1,1,2,2-Tetrachlo
rocthane
1,1,2-Trichloroet
hanc
1,1-Dichloroethyl
cne
1,2,4,5-Tetrachlo
robcnzenc
1,2-Cis-Dichloroe
thy 1 cne
1,2-Dichlorobcnze
no
1,2-Dichloroethan
e
1,2-Dichloropropa
nc
1,2-Diphcnylhydra
zine
1,2-Trans-Dichlor
oethylene
1,3-Dichlorobcnze
ne
1,4-Dichlorobenze
ne
2,3,7,8-TCOD
2,4,5-TP
2,4,5-Trichloroph
enol
2,4,6-Trichloroph
enol
2,4-D
Limitations
Monthly
Average
N/A
200.000000 ug/l
N/A
2400.000000 ug/l
N/A
28.000000 ug/l
N/A
7.000000 ug/l
N/A
2.000000 ug/l
N/A
70.000000 ug/l
N/A
620.000000 ug/l
N/A
5.000000 ug/l
N/A
0.560000 ug/l
N/A
0.050000 ug/l
N/A
70.000000 ug/l
N/A
620.000000 ug/l
N/A
75.000000 ug/l
N/A
Report ug/l
N/A
10.000000 ug/l
N/A
700.000000 ug/l
N/A
2.000000 ug/l
N/A
100.000000 ug/l
Daily
Maximum
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
Other
30-day avg: 2.2 x 10
(-7)
Monitoring Requirements
Frequency
1/day
1/day
1/day
1/day
1/day
. 1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
Sample Type
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
Page: 68
-------
Facility Name: Highway 36 Land Development Co Permit Number: C00042064
Facility Description: Hazardous waste treatment and disposal SIC Code: ""
2,4-Dichloropheno
I
2,4-Dimethylpheno
I
2-Chlorophenol
Acenaphthene
Acrolein
Acrylonitrile
Acute WET
Ag (TR)
Al (TR)
Aldicarb
Aldrin
Alpha (T)
As (T)
Asbestos (fibrous
)
B
Ba (TR)
Be (TR)
Benzene
Benzidine
Beta (T)
BHC
Bis (2-chloroethy
I) ether
BODS
Carbofuran
Carbon tetrachlor
ide
N/A
21.000000 ug/l
N/A
Report ug/l
N/A
2000.000000 ug/l
N/A
520.000000 ug/l
N/A
21.000000 ug/l
N/A
2600.000000 ug/l
N/A
N/A'
N/A
0.000150 mg/l
N/A
0.050000 mg/l
N/A
10.000000 ug/l
N/A
0.002000 ug/l
N/A
Report
N/A
Report mg/l
N/A
7.100000
N/A
2.000000 mg/l
N/A
Report mg/ I
N/A
0.130000 mg/l
N/A
5.000000 ug/L
N/A
0.000200 ug/l
N/A
Report
N/A
Report ug/l
N/A
0.030000 ug/l
N/A
30.000000 mg/l
N/A .
36.000000 ug/l
N/A
5.000000 ug/l
N/A
Report ug/l
N/A
2120.000000 ug/l
N/A
4380.000000 ug/l
N/A
1700.000000 ug/l
N/A
68.000000 ug/l
N/A
7550.000000 ug/l
N/A
50.000000 %
N/A
Report mg/l
N/A
Report mg/l
N/A
Report ug/l
N/A
Report ug/l
N/A
15.000000
N/A
0.050000 mg/l
N/A
Report
N/A
Report mg/l
N/A
5.000000 mg/l
N/A
Report mg/l
N/A
Report ug/l
N/A
Report ug/l
N/A
15.000000
N/A
100.000000 ug/l
N/A
Report ug/l
N/A
N/A
N/A
Report ug/l
N/A •
Report ug/l
Units: % mortality
Units: pCi/l
Units: mil fibers(>1
Ou)/l
Units: pCi/l
7- day avg.: 45 mg/l
1/day
1/day
1/day
1/day
1/day
1/day
1 /quarter
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
Page: 69
-------
Facility Home: Highway 36 Land Development Co Permit Number: C00042064
Facility Description: Hazardous waste treatment and disposal SIC Code: 9999
Cd (TR)
Chlordonc
Chloride
Chlorobenzene
Chronic WET
CM (free)
Co (TR)
Cr (TR)
Cr+6
CS2
Cu (OS)
ODD
DDE
DDT and derivativ
es
Dcfiseton
Dichloropropcnc
Dieldrin
Dinitrotolucne
DO
Endosulfan sulfat
e
Endrin
Ethylbenzene
FC
Fe (OS)
Fc
-------
Facility Name: Highway 36 Land Development Co Permit Number: C00042064
Facility Description: Hazardous waste treatment and disposal SIC Code: 9999
Fl
Flow
Fluoranthene
Hardness
Heptachlor
Heptachlor epoxid
e
Hexach I orobenzene
Hexachlorobutadie
ne
Hexachlorocyclope
ntadiene
Hexach I oroethane
Hg
-------
Facility Homo: Highway 36 Land Development Co Permit Number; C00042064
Facility Description: Hazardous waste treatment and disposal SIC Code. 9999
OSG
Parach loromctacrc
sol
Parathion
Pb (DS)
PCBs (T)
Pcntach lorobenzon
e
Pentachlorophcnol
pH
Phenol
Radium (T)
Sb (TR>
Sc (T)
SOA
70S
Tetrachlorocthyle
no
TKH
Tl (TR)
TOC
Toluene
Toxopticno
Trichloroothylene
Trihalomothanes (
T>
TSS
U (T)
V (TR)
N/A
N/A
N/A
Report ug/l
N/A
0.013000 ug/l
M/A
0.033000 mg/l
N/A
0.005000 ug/l
N/A
6.000000 ug/l
M/A
5.700000 ug/l
N/A
N/A
N/A
2560.000000 ug/l
N/A
Report
N/A
1.600000 mg/l
N/A
0.020000 mg/l
N/A
250.000000 mg/l
N/A
500.000000 mg/l
N/A
10.000000 ug/l
N/A
Report mg/l
N/A
0.150000 mg/l
N/A
Report mg/l
N/A
2420.000000 ug/l
N/A
0.000200 ug/l
N/A
5.000000 ug/l
N/A
100.000000 ug/l
N/A
30.000000 mg/l
N/A
Report
N/A
0.100000 mg/l
N/A
10.000000 mg/l
N/A
30.000000 ug/l
N/A
0.065000 ug/l
N/A
0.050000 mg/l
N/A
Report ug/l
N/A
Report ug/l
N/A
9.000000 ug/l
Report
N/A
N/A
10200.000000 ug/l
N/A
5.000000
N/A
9.000000 mg/l
N/A
0.050000 mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report ug/l
N/A
Report mg/ I
N/A
Report mg/l
N/A
Report mg/l
N/A
Report ug/l
N/A
0.730000 ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report mg/ 1
N/A
0.035000
N/A
Report mg/l
See below
potentially dissolve
d
Between 6.5 su and 9
.0 su
Units: pCi/l
Units: mg/l as N
7 day avg.: 45 mg/l
Units: pCi/l
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
1/day
gr.ab/visual
grab
. grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
Page: 72
-------
Facility Name: Highway 36 Land Development Co
Permit Number: C00042064
Facility Description: Hazardous waste treatment and disposal
SIC Code: 99?
Vinyl chloride
Zn (TR)
N/A
2.000000 ug/l
N/A
0.500000 mg/l
N/A
Report
ug/l
N/A
0.560000 mg/l
1/day
1/day
grab
grab
1
5°,
"Gold
protection
s:,
i r,d.c«»,™;." t =r.
|
life -U th. "Blue Bo.k" for livestock and
JSK arss.1!1 a,srs.Trwrs {.SSPSSS?
in oo.pli.nc, »ith RCKA re,uir™.nt> .Li.it. for JJe org.nics »r,
^^
toxicitv control program. Chronic WET testing is to oe conducted u^ma -• ai «" =="t"=- w-..,r--.™ . ~. - ........
hours Chronic testing is to be conductedusing EPA methods for static replacement test, and 2 species. The
aoteniiallv d ssolved metal fraction is defined as an analytical method in a footnote and a citation is provided
Motoring for TOC was established because it is an indicator parameter. The limitations and monitonng for most of
the metal! are specified as TR based on Basic Standards, due to agricultural and domestic receivmg water uses.
Where monitorfngPbui no Umitsre used, the parameter is expected to be present, but not ,n concentrate of concern.
Outfall: 002 | Receiving Water: Beaver Creek Treatment: Sed
Amount/Components^^ ^ jntena,ttent d,-scharges from uncontaminated storm water retention basin, as this water is
normally used onsite
Parameter
BODS
Flow
O&G
pH
TDS
TKN
TOC
Limitations
Monthly
Average
N/A
Report mg/l
N/A
Report MGD
N/A
N/A
N/A
N/A
N/A
Report mg/l
N/A
Report MGD
N/A
Report mg/l
Dai ly
Maximum
N/A
Report mg/l
N/A
Report MGD
N/A
Report mg/ I
N/A
Report su
N/A
Report mg/l
N/A
Report MGD
N/A
Report mg/l
Other
Report 7 day average
Visual monitoring M
week
Monitoring Requirements
Frequency
1 /month
1/week
1 /month
1/week
1 /month
1 /month
1 /month
Sample Type
grab
continuous
grab
grab
grab
grab
grab
Page: 73
-------
Facility Name: Highway 36 Land Development Co
Permit Number: C00042064
Facility Description; Hazardous waste treatment and disposal
SIC Code: 9999
N/A
Report mg/l
N/A
N/A
1/month
grab
Limitations/Monitoring Basis:
thnJ0™ ™? r?Sujred because this is an uncontaminated diverted water source. Monitoring is required to
that no potential contamination occurs into the uncontaminated runoff collection system. requlrea T0
Special Conditions Basis:
Provid!d in Part c of the
The detection level for use in analyzing the organics is
nul Tta,
™ Sire.* p?SS"
'"" '
P«~'« ""tain. , rnprnr ta ,
d«'=« "iu"n »» *»• « tte.pr.lt
Effective Date: 08/10/90
Expiration Date: 05/31/95
Abstract Date: 04/13/93
Page: 74
-------
r -.-* >t nmrn i^ Permit Number: CT0000850
Facility Name: FIDCO, Inc.
Facility Description: Food products processing SIC coae- iuyv
Monitoring
Limit ELGs WQSs BPJ Only
Basis: ' - i 1 ^
Storm WQ
Special BMPs Water Sediment Survey
Conditions: 2. - -
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
J. - - - -
Bio
Survey TRES MDLs Monitoring Other
- 'i - - ' -
jstract Information:
Partial; Outfalls 001 and 002 (represents 003).
Outfall: 001 | Receiving Water: Housatonic River Treatment: Floe, Set, Dis, AerL
Amount/Components:
0.13 MGD (average) of treated food processing wastewater.
Parameter
Acute WET
BODS
Chronic WET
Col i form (T)
FC
Fecal streptococc
i (FS)
Flow
NH3-N
N02-N
N03-N
Organic-N
P (T)
PH
TRC
TSS
Limitations
Monthly
Average
N/A
N/A
N/A
60.000000 mg/l
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
1.000000 mg/l
N/A
N/A
N/A
0.680000 mg/l
N/A
60.000000 rag/ I
Dai ly
Maximum
N/A
Report
N/A
100.000000 mg/l
N/A
Report
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Report
N/A
120.000000 mg/l
N/A
N/A
N/A
N/A
N/A
N/A
N/A
1.500000 rag/ 1
N/A
Report
N/A
1.360000 mg/l
N/A
100.000000 mg/l
Other
See below
See below
See below
See below
Between 6.0 su and 9
.5 su
Monitoring Requirements
Frequency
1/quarter
1 /week
1/quarter
1/week
1/week
1/week
During discharg
1/week
1/week
1/week
1/week
1/week
1/week
1/day
1/week
Sample Type
Composite
Composite
Composite
Grab
Grab
Grab
Record »
Composite
Composite
Composite
Composite
Composite
Composite
Grab
Composite
The°tasisnlfo°rHmitations and monitoring conditions was not provided except as a general reference to consistency
with BAT and WQSs. Concentration of pollutants limited in any grab sample is required to be less than 1.5 times the
daily maximum limit at all times. For parameters requiring grab samples, the maximum limit may not be exceeded.
The P(T) limit is applicable only from May 1 through August 15. The NH3-N limit is applicable from June 1_through
September 30. Coliform (T) must not exceed 2400/100 ml during May 1 through September 30. Acute WET testing and
chronic WET testing are to be conducted following EPA guidance using 2 species, specified di lution water, 5
dilutions and a 48 hour test for Daphnia pulex and a 96 hour test for Pimephales promelas. Compliance with the
acute WET limit is achieved when the LC50 value for the effluent is greater than 3 times the_IWC. Compliance with
the chronic WET is achieved when the LC50 is 20 times the IWC. The IWC may be calculated using mean effluent flow.
Page: 75
-------
Facility Nome: FIDCO, Inc. Perm1t Numbep: CT0000850
Facility Description: Food products processing sic code- 2099
faU°Xthit™™J?^?lT°nd t?SV!! rec'uired Wlth'n 30 davs- If 2 consecutive test results, or three in one year
™L,Sr^ t£^ 3 th i be required to propose a schedule to accomplish toxicity reduction. The permittee is
E^m?l™,o $? *eth° *- * and the number of hours of discharge for each day of sample collection and/or the
IS^?™? « * £ ?l!!l? *T ° Coll^ctln9 ?rab samples. Toxicity testing results that indicate less than 90%
survival are to be immediately retested. Any "violation of a toxicity limit requires a second sample analysis If
Srai??lf "s roqu^ed^conduct ^l^ ^^ '"" " S^e yMr 6XCeed the maxfmum daily toxicty liraft' *he
Outfall: 002 | Receiving Water: Housatonic River Treatment: None
Amount/Components :
0,3 HGO (average) of noncontact cooling water.
Parameter
Acute WET
Chronic WET
Cu (T)
Flow
HII3
HI (T)
OSG
Pb (T)
PH
Surfactants
TOS
Tcwp.
TRC
TSS
Zn
Limitations
Monthly
Average
M/A
N/A
M/A
N/A
M/A
N/A
N/A
M/A
M/A
N/A
N/A
N/A
N/A
M/A
N/A
H/A
N/A
N/A
N/A
M/A
N/A
N/A
M/A
H/A
M/A
N/A
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
Report
N/A
Report
N/A
0.060000 mg/l
N/A
Report
M/A
3.000000 mg/l
N/A
0.925000 mg/l
N/A
5.000000 mg/l
N/A
0.014000 mg/l
N/A
Report
N/A
0.500000 mg/l
N/A
1500.000000 mg/l
N/A
Report
H/A
0.116000 mg/l
N/A
H/A
N/A
0.153000 mg/l
Other
See below
See below
See below
Between 6.0 su and 9
.5 su
See below
Monitoring Requirements
Frequency
2/year
2/year
1/quarter
During discharg
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1 /month
1/quarter
1/quarter
1/quarter
Sample Type
Composite
Compos i te
composite
Record
Cpmposite
Composite
Cpmposite
Composite
Composite
Composite
Composite
Grab
Composite
Composite
Composite
Limitations/Monitoring Basis:
f" *>"> Iiroitat1"on?/™2!to"ng basl? for 0utfaU °01- Compliance with acute and chronic toxicity limit shall be
or lr^l^»n°Unli!llflC^ '"P*}?? occurs in the dai tv Composite sample of effluent at a concentration equal to
or greater than NOAEL as determined by pass-fail methodology in State regulations. The iwc = 1 for Outfall 002
The permittee is prohibited from using water treatment chemicals or additives containing Cr, Cu, Pb,Zn, or tribiityt
Special Conditions Basis: ~~ ~~~ =—=—=-=—=-
Toxicity test results that indicate less than 90% survival are to be immediately retested. Any violation of a
toxicity limit requires a second sample analysis. If two consecutive test results or three test results in a sinale
year exceed maximum daily toxicity limit, the permittee is required to conduct a TRE.
Effective Date: 09/25/92 Expiration Date: 09/25/97 Abstract Date: 09/14/93
Page: 76
-------
Facility Name: FIDCO, Inc.
Permit Number: CT0000850
Facility Description: Food products processing
SIC Code: 2099
Page: 77
-------
Facility Name: Summit Corp of America Permit Number: CT0001180
Facility Description: Metal finishing SIC Code: 3471
,. ,. _,„ Monitoring WET WET Testing Multiple
Limit ELGs WQSs BPJ Only Limits Only Categories
Basis: J. J. ^ 1 J. r. i.
Storm WQ Bio
Special BMPs Water Sediment Survey Survey TRES MDLs
Conditions: J. 2. z. - - J.
Tiered
Limits Other
Monitoring Other
- I
Abstract Information:
Complete; Outfall 001
Outfall: 001 | Receiving Water: Haugatuck River | Treatment: Neut, PF
Amount/Components :
0.376 HGO average, 0.5 MGD daily maximum, of treated metal finishing wastewater.
Parameter
Acute WET
Ag
Al
AU
BOOS
Cd
Chronic WET
CM (A), Amenable
CN
CM (T>
Cr
Cu
Fe
Flow
Fluoride
NH3
Hi
Other
Pb
Limitations
Average
H/A
H/A
0.027200 kg/d
0.100000 mg/l
N/A
2.000000 mg/l
N/A
0.100000 mg/l
N/A
N/A
0.025000 kg/d
0.100000 mg/l
N/A
N/A
N/A
0.100000 mg/l
0.193060 kg/d
0.220000 mg/l
N/A
1.000000 mg/l
0.218000 kg/d
1.000000 mg/l
N/A
3.000000 mg/l
N/A
N/A
N/A
20.000000 mg/l
N/A
N/A
N/A
1.000000 mg/l
N/A
N/A
0.048300 kg/d
0.100000 mg/l
Maximum
N/A
Report
0.054400 kg/d
0.500000 mg/l
N/A
4.000000 mg/l
N/A
0.500000 mg/l
N/A
Report
0.050000 kg/d
0.500000 mg/l
N/A
Report
N/A
0.200000 mg/l
0.386200 kg/d
0.400000 mg/l
N/A
2.000000 mg/l
0.436000 kg/d
2.000000 mg/l
N/A
5.000000 mg/l
N/A
Report
N/A
40.000000 mg/l
N/A
10.000000 mg/l
N/A
2.000000 mg/l
N/A
Report
0.096600 kg/d
0.500000 mg/l
Other
See below
See below
See below
Indium
Monitoring Requirements
Frequency
1 /quarter
1/week
1/week
1/week
1/month
1/year
1/quarter
1/week
1/week
1/year
1/week
1/week
During discharg
1/week
1/week
1/week
1/week
1/month
Sample Type
Composite
Composite
Composite
Composite
Composite
Composite
Composite
grab
Grab
Composite
Composite
Composite
Record
composite
Composite
Composite
Composite
Composite
Page: 78
-------
Facility Name: Summit Corp of America Permit Number: CT0001180
Facility Description: Metal finishing SIC Code: 3471
Pd
pH
Sn
Temp.
TRC
TSS
TTOs
Zn
N/A
N/A
N/A
N/A
N/A
2.000000 mg/l
N/A
N/A
N/A
0.350000 mg/l
N/A
20.000000 mg/l
N/A
N/A
0.558500 kg/d
1.000000 mg/l
N/A
Report
N/A
N/A
N/A
4.000000 mg/l
N/A
N/A
N/A
0.620000 mg/l
N/A
30.000000 mg/l
N/A
1.000000 mg/l
1.117000 kg/d
2.000000 mg/l
Between 6.0 su and 9
.5 su
See below
See below
1/week
1 /month
1/week
1/week
1/week
1 /month
1/week
composite
Composite
Composite
Grab
Composite
Grab
Composite
Limitations/Monitoring Basis: .
The limits and monitoring conditions were based on ELGs in 40 CFR Part 433 Section 22a-430-4s(2) and State WQSs.
The concentration of the pollutants limited on any grab sample is required to be less than 1.5 times the maximum
daily concentrations. The mass-based limitations (Cu, Cd, Pb, Ag, Zn, and CN(T)) become effective two years after
permit issuance. The permittee is required at all times to record the total flow and the number ofhours of
discharge for each day of sample collection, and/or the instantaneous flow at the time of grab sample collection.
In lieu of analyzing for TTO, each monthly report may include a statement certifying compliance with an approved
solvent management plan. Compliance with acute WET limit is achieved when the LC!50 is greater than 3 times the IWC.
Compliance with chronic WET limit is achieved when the LC50 is greater than 20 times the IWC. Acute and chronic WET
monitoring are to be conducted following specified EPA guidance, specified dilution water, and a 48 hour test using
Daphnia. The mean effluent flow rate may be used to calculate the IWC. TRC is to be monitored during CN sampling.
Free residual chlorine is also to be monitored at this time. The temperature of the discharge must not raise the
temperature of the receiving stream by more than 4 degrees nor increase the temperature of the receiving stream
above 85 degrees Farenheit.
Special Conditions Basis: . , , ..
On or before 30 days from permit issuance, the permittee is required to retain a qualified PE to perform studies to
achieve compliance with mass-based effluent limits. On or before 270 days from permit issuance, the permittee is
required to submit a report outlining remedial measures to achieve compliance with mass-based effluent limits, no
later than 2 years after permit issuance. Toxicity testing results that indicate less than 90% survival are to be
immediately retested. Any violation of the toxicity limit requires a second sample analysis. If two consecutive
test results or three test results in a single year exceed the maximum daily toxicity limit, the permittee is
required to conduct a TRE. Within 365 days after permit issuance, the permittee is required to verify that spill
containment has been provided around all CN plating baths. Quarterly status reports are required to be submitted.
Effective Date: 05/11/93 Expiration Date: 05/11/98 Abstract Date: 09/14/93
Page: 79._
-------
Facility Home: Drawn Metal Tube Company Permit Number: CT0001601
Facility Description: Copper alloy tube redrawn mill SIC Code: 3351
Monitoring
Limit ELGs WQSs BPJ Only
Basis: III I
Storm WQ
Special BMPs Water Sediment Survey
Conditions: - Z -
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
1 - - - -
Bio
Survey TRES HDLs Monitoring Other
- 1 - - -
Abstract Information:
Complete; Outfall 001
Outfall: 001 | Receiving Water: Haugatuk R. via storm sewer | Treatment: Neut, Floe, Set, Fit, Red
Amount/Components:
0.013 MGD (average) of copper forming wastewater.
Parameter
Acute WET
Chronic WET
Cr (T)
Cr+6
Cu
Fe
Flow
Hi
OSG
Pb
pH
Temp.
TSS
Zn
Limitations
Monthly
Average
H/A
H/A
H/A
H/A
0.022000 kg/d
0.490000 mg/l
0.004500 kg/d
0.100000 mg/l
0.021700 kg/d
1.000000 mg/l
0.056700 kg/d
3.000000 mg/l
H/A
H/A
0.045400 kg/d
1.000000 mg/l
0.454000 kg/d
10.000000 mg/l
0.004500 kg/d
0.100000 mg/l
H/A
H/A
H/A
H/A
0.908000 kg/d
20.000000 mg/l
0.045400 kg/d
1.000000 mg/l
Dai ly
Maximum
H/A
Report
H/A
Report
0.054000 kg/d
1.190000 mg/l
0.009100 kg/d
0.200000 mg/l
0.043400 kg/d
2.000000 mg/l
0.094500 kg/d
5.000000 mg/l
N/A
Report
0.090800 kg/d
2.000000 mg/l
0.681000 kg/d
15.000000 mg/l
0.009100 kg/d
0.200000 mg/l
H/A
Report
H/A
Report
1.362000 kg/d
30.000000 mg/l
0.090800 kg/d
2.000000 mg/l
Other
See below
See below
See below
Between 7.5 su and 9
.8 su
See below
Monitoring Requirements
Frequency
1/quarter
1 /quarter
1/week
1/week
1/week
1/week
During discharg
1/week
1/week
1/week
1/week
1/week
1/week
Sample Type
Grab or composite
Grab or composite
Grab
Grab
Composite
Composite
Record
Composite
Grab
Composite
Composite
Composite
Composite
Limitations/Monitoring Basis:
The limitations and monitoring conditions were based on ELGs in 40 CFR Part 468 for Cr(T) and BPJ and State WQSs for
the others. The concentration of pollutants limited in any grab sample is required to be less than 1.5times the
daily maximum limit at all times. Flow monitoring is to be conducted during discharge. The permittee must record
the total flow and the number of hours of discharge on each day of sample collection and/or the instantaneous flow
at the time of collecting grab samples. Acute and chronic WET monitoring are to be performed monthly for the first
12 months and quarterly thereafter using daily composite samples, specified dilution water, EPA guidance, and 48
hour test using Daphnia pulex. Compliance with the acute WET permit condition is achieved when the LC50 value for
the effluent is greater than three times the IWC. Compliance with the chronic WET permit condition is achieved when
the LC50 value for the effluent is greater than 20 times the IWC. The mean effluent flow rate may be used to
calculate the IWC. The temperature of the discharge is not to raise the normal temperature of the receiving stream
more than 4 degrees Farenheit or increase the receiving stream temperature above 85 degrees Farenheit.
Page: 80
-------
Facility Name: Drawn Metal Tube Company
Facility Description: Copper alloy tube redrawn mill
Special Conditions Basis:
On or before 60 days from permit issuance, the permittee is required to submit a
aquatic toxicity. On or before 150 days from permit issuance, the permittee is
Effective Date: 04/23/93 Expiration
Date: 04/23/98
Permit Number: CT0001601
SIC Code: 3351
report detailing methods to reduce
required to submit a TRE.
Abstract Date: 09/14/93
Page: 81
-------
Faeflfty Name: Johnson & Johnson Advanced Hat . Permit Number: GA0001791
Facility Description: Manufactures woven gauze products and film from polymers SIC Code: 2833
Monitoring WET WET Testing Multiple Tiered
Limit ELGs WQSs BPJ Only Limits , Only Categories Limits Other
Basis: „ J. J. 1 2. i. - -
Storm WQ Bio
Special BMPs Water Sediment Survey Survey TRES HDLs Monitoring Other
Conditions: J_ ^ ^ L ' L i. J. J. I
Abstract Information:
Complete; Outfalls DOHA and B created for abstracting purposes), and 002.
Outfall: 001A | Receiving Water: Redwine Creek | Treatment: Eq *• AS + Dis
Amount/Components :
An average flow of 0.17 MGD, consisting of process wastewater treatment plant effluent, effective 9/4/92 through
5/31/93
Parameter
BOOS
COO
CP (T)
Cu
FC
Flow
P«
Phenols
Sulfide
TSS
Zn
Limitations
Dai ly
Average
184.000000 Ib/d
N/A
1304.000000 Ib/d
N/A
2.000000 Ib/d
N/A
Report
N/A
N/A
N/A
N/A
Report
N/A
N/A
2.000000 Ib/d
N/A
4.000000 Ib/d
N/A
408.000000 Ib/d
N/A
Report
N/A
Daily
Maximum
368.000000 Ib/d
N/A
2607.000000 Ib/d
N/A
4.000000 Ib/d
N/A
Report
N/A
N/A
400.000000
N/A
Report MGD
N/A
N/A
4.000000 Ib/d
N/A
8.000000 Ib/d'
N/A
816.000000 Ib/d
N/A
Report
N/A
Other
Units not specified
Units: #/100 ml
Between 6.0 su and 9
.0 su
Units not specified
.Monitoring Requirements
Frequency
3/week
3/week
1/quarter
1/month
1/week
continuous
3/week
1/quarter
, 1/quarter
3/week
1/year
Sample Type
24hr composite
24hr composite
24hr composite
24hr composite
grab
record
grab
•grab
grab
24hr composite
24hr composite
Limitations/Monitoring Basis:
The BOOS limitations are based on State water quality control regulations for the protection of fishing designated
uses and calibrated stream model calculations (assumed from information given in rationale). The remaining limits
are BPJ -based on "the plant's demonstrated performance." The basis of the monitoring conditions was not described.
Outfall: 001B | Receiving Water: Redwine Creek | Treatment: AS, Dis
Amount/Components:
An average flow of 0.17 MGD, consisting of process wastewater treatment plant effluent, effective 6/1/93 through
4/30/97 , '
Parameter
BOOS
Limitations
Daily
Average
184.000000 Ib/d
N/A
Daily
Maximum
368.000000 Ib/d
N/A
Other
Monitoring Requirements
Frequency
3/week
Sample Type
24hr composite
Page: 82
-------
Facility Name: Johnson & Johnson Advanced Hat Permit Number: GA0001 791
Facility Description: Manufactures woven gauze products and film from polymers SIC Code: 2833
COD
Cr (T)
Cu
FC
Flow
PH
Phenols
Sulf ide
TSS
Zn
1304.000000 Ib/d
N/A
2.000000 Ib/d
N/A
N/A
N/A
N/A
N/A
N/A
Report MGD
N/A
N/A
2.000000 Ib/d
N/A
4.000000 Ib/d
N/A
408.000000 Ib/d
N/A
Report Ib/d
N/A
2607.000000 Ib/d
N/A
4.000000 Ib/d
N/A
N/A
7.200000 ug/l
N/A
400.000000
N/A .
Report MGD
N/A
N/A
4.000000 Ib/d
N/A
8.000000 Ib/d
N/A
816.000000 Ib/d
N/A
Report Ib/d
N/A
See below
Units: MPN/100 ml
Between 6.0 su and 9
.0 su
Units not specified
3/week
1/quarter
1 /month
1/week
continuous
3/week
1/quarter
1/quarter
3/week
1/year
24hr composite
24hr composite
24hr composite
grab
record
grab
grab
grab
24hr composite
24hr composite
Limitations/Monitoring Basis:
The BODS limitation is based on State water quality control regulations for the protection of fishing designated
uses and calibrated stream model calculations (assumed from information given in rationale). Other limits based on
BPJ, or "the plant's demonstrated performance." The basis for the copper limitation beginning June 1, 1993 was not
provided. The basis of the remaining monitoring conditions was not described.
Outfall: 002 j Receiving Water: Balus Creek ' | Treatment: None specified
Amount/Components: .
This outfall is for emergency use consisting only of once through noncontact cooling water, with no heavy metal
inhibitor nor chemical additives.
Parameter
Flow
Limitations
Dai ly
Average
N/A
Report MGD
Daily
Maximum
N/A
N/A
Other
See below
Monitoring Requirements
Frequency,
Sample Type
Limitations/Monitoring Basis:
Flow monitoring conditions were not specified despite flow being listed in the effluent limitations and monitoring
requirements table for outfall 002.
Special Conditions Basis:
The permit requires the implementation of baseline BHPs. Storm water discharges are authorized as long as they do
not violate State water quality standards. If toxicity is suspected, the permittee may be required to develop a
program for whole effluent toxicity monitoring and the preparation of a toxicity reduction evaluation plan; where
specified, 90 days are provided to submit a toxicity study plan, 90 days are provided to conduct the study after
approval, and 270 days are provided to implement the TRE if a TRE is required. State-specific sludge monitoring,
reporting, and disposal conditions are included; a plan of operation for land application is required upon written
notification. The bases of these conditions were not described.
Effective Date: 09/04/92 Expiration Date: 04/30/97 Abstract Date: 04/01/93
Page: 83
-------
Facility Name: ITT Rayonier, Inc
Permit Number: GA0003620
Facility Description: Pulp and paper mill that produces market bleached kraft
SIC Code: 2611
Limit
Basis:
ELGs
WQSs
I
BPJ
Monitoring
Only
J.
WET
Limits
WET Testing
Only
Multiple
Categories
Tiered
Limits
Other
J.
Special
Conditions:
BHPs
J.
Storm
Water
J.
Sediment
WQ
Survey
J.
Bio
Survey
J.
TRES
HDLs
Monitoring
J.
Other
1
Abstract Information:
Complete; Outfall 001 represents the combined limits for outfalls 001 and 002.
Outfall: 001 | Receiving Water: Altamaha River
Treatment: Scr + PC + AL
Amount/Components:
63 HGO from outfalls 001 and 002 (combined) of process wastewater, sanitary wastes and stormwater runoff
Parameter
Z,3,7,8-TCDD
BOOS
Color
Flow
pH
TSS
Limitations
Daily
Average
N/A
0.000168 ug/l
22300.000000 Ib/d
N/A
N/A
Report
N/A
Report HGD
N/A
N/A
42010.000000 Ib/d
N/A
Daily
Maximum
N/A
N/A
33450.000000 Ib/d
N/A
N/A
Report
N/A
Report MGd
N/A
N/A
77600.000000 Ib/d
N/A
Other
Procedures are speci
fied
Seasonal: see below
Units not specified
See below
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/quarter
1/day
1/week
continuous
1/day
1/day
Sample Type
24hr composite
composite
composite
record
grab
composite
Limitations/Monitoring Basis:
These limitations are for the combined discharges from Outfalls 001 and 002. Although the discharges are subject to
ELGs (40 CFR Part 400), BOD5 and TSS limits are based on past permit limitations in accordance with antibacksliding.
BOOS limitations are consistent with State water quality control regulations for protection of fishing designated
uses and calibrated stream model calculations. Limits shown for BODS above apply from May 1 through Nov. 30.
Limits for BODS from Dec. 1 through Apr. 30 are 32,000 Ib/d daily avg. and 48,000 Ib/d daily max. Annual monitoring
by composite sampling of B00120 is also required. The dioxin limit is water quality-based established using a ,human
health risk level concentration at average stream flow conditions. In addition to dioxin, other parameters such as
Zn, chloroform, 1,1-dichloroethane, and toluene were evaluated. Their concentrations were not considered
significant. Sludge monitoring, reporting, and disposal conditions are included, and a plan of operation for land
application is required upon written notification.
Special Conditions Basis:
River samples are required to be collected 2/month during May through Nov. and analyzed for BODS, BOD40, DO, pH, and
temperature. These data will be used in the State's stream model. River monitoring requirements are based on a
court order. Analyses for fish tissue samples showing bioaccumulation of dioxin and furan are required to be
conducted and reported on an annual basis; monitoring is required in accordance with a State-specific study plan.
If toxicity is suspected, the permittee may be required to develop a program for net monitoring and prepare a
toxicity reduction evaluation; where specified 90 days are provided to submit a toxicity study plan,90 days are
provided to conduct the study after approval, and 270 days are provided to implement the TRE if a TRE is required.
State-specific sludge monitoring, reporting, and disposal conditions are included; a plan of operation for land
application is required upon written notification. Storm water discharges are authorized as long as they do not
violate State water quality standards. Other than described above, the bases of the special conditions were not
discussed.
[Effective Date: 11/25/92
Expiration Date: 11/30/95
Abstract Date: 03/30/93
Page: 84
-------
Facility Name: Forstmann & Company Permit Number: GA0003760
Facility Description: Fabric mill that complex finishes wool and wool blends SIC Code: 2221
Monitoring
Limit ELGs UQSs BPJ Only
Basis: J. iL - J.
Storm WQ
Special BMPs Water Sediment Survey
Conditions: J. iL - -
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
— — — J-
Bio
Survey TRES MDLs Monitoring Other
11 1 - ^
Complete; Outfalls 001, 002, and OOSCcreated to represent the combined plant discharges including 001 and 002).
Outfall: 001 | Receiving Water: Oconee River I Treatment: Eq + AS + Sed
Amount/Components:
Unspecified amount of storm water discharge.
Parameter
BODS
Flow
PH
Limitations
Daily
Average
Report
N/A
N/A
Report MGD
N/A
N/A
Daily
Maximum
Report
N/A
N/A
' Report MGD
N/A
N/A
Other
Units not specified
See below
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1 /month
1 /month
1 /month
Sample Type
grab
instantaneous
grab
Limitations/Monitoring Basis:
Requirements apply to only the storm water discharge from the polishing pond which contribute to Outfall OUT. The
bases for the requirements were not described.
Outfall: 002 | Receiving Water: Oconee River I Treatment: Eq + AS
Amount/Components :
0.5 MGD max. of groundwater remediation flow.
Parameter
Flow
pH
Trichloroethylene
Limitations
Daily
Average
N/A
N/A
N/A
N/A
N/A
Report
Daily
Maximum
0.500000 MGD
N/A
Report
N/A
Report
N/A
Other
Between 6.0 su and 9
.0 su
Units not specified
Monitoring Requirements
Frequency
1/quarter
1 /quarter
1/quarter
Sample Type
meter
grab
grab
Limitations/Monitoring Basis: , - - -
Requirements apply to only the groundwater remediation discharges to Outfall 002. The flow limit is equal to the
anticipated maximum flow rate. The bases for the requirements were not given.
Outfall: 003 | Receiving Water: Oconee River I Treatment: Eq + As + Sed
Amount/Components:
An average of 3.7 MGD of treated process, utility, and sanitary wastewater and storm water from pond and outfalls 001
and 002.
Parameter
BODS
COD
Limitations
Daily
Average
750.000000 Ib/d
N/A
7900.000000 Ib/d
N/A
Dai ly
Maximum
1500.000000 Ib/d
N/A
15800.000000 Ib/d
N/A
Other
Monitoring Requirements
Frequency
5/week
5/week
Sample Type
24hr composite
24hr composite
Page: 85
-------
Facility Name: Forstmann & Company Permit Number: GA0003760
Facility Description: Fabric mill that complex finishes wool and wool blends SIC Code: 2221
Cr (T)
Flow
PH
Phenols
Sulfido
Trichloroothylene
TSS
Zn
6.800000 Ib/d
N/A
N/A
Report MGD
N/A
M/A
6.800000 Ib/d
N/A
13.600000 Ib/d
N/A
Report Ib/d
N/A
1710.000000 Ib/d
N/A
Report Ib/d
N/A
13.600000 Ib/d
N/A
N/A
Report MGD
N/A
N/A
13.600000 Ib/d
N/A
27.000000 Ib/d
N/A
Report Ib/d
N/A
3420.000000 Ib/d
N/A
Report Ib/d
N/A
Between 6.0 su and 9
.0 su
Report (no units giv
en)
1/month
continuous
1/day
1/month
1/month
1/year
5/week
1/year
24hr composite
recorder
grab
grab
grab
grab
24hr composite
24hr composite
Limitations/Monitoring Basis:
These limitations are for the combined discharges from outfalls 001 and 002 from sources noted. All limitations
except BOOS are based on ELGs (40 CFR Part 410; Subpart B) and the previous permit. BODS limits are based on State
water quality control regulations for protection of fishing designated uses and calibrated stream model
calculations. The BOOS limits are the same as those in the last permit, consistent with ant i backsliding. Since the
IWC for Zn, CrCT), and trichloroethylene is less then 50%, no UQ-based limits are imposed. However, since zinc and
trichloroethylene were found to be present, but not in significant amounts, monitoring and reporting are required.
Cr (T) limits are imposed based on ELGs. The basis of the remaining monitoring conditions was not described.
Special Conditions Basis:
The permit requires the implementation of baseline BMPs. Storm water discharges are authorized as long as they do
not Violate State water quality standards. If toxicity is suspected, the permittee may be required to develop a
program for whole effluent toxicity monitoring and the preparation of a toxicity reduction evaluation plan; where
specified, 90 days are provided to submit a toxicity study plan, 90 days are provided to conduct the study after
approval, and 270 days are provided to implement the TRE if a TRE is required. State-specific sludge monitoring,
reporting, and disposal conditions are included; a plan of operation for land application is required upon written
notification. The bases of these conditions were not described.
Effective Date: 10/23/92 Expiration Date: 08/31/97 Abstract Date: 03/31/93
Page: 86
-------
Facility Name: US Naval Submarine Base Permit Number: GA0027707
Facility Description: Submarine support facility with metal plating and launch tube ops. SIC Code: 9731
Monitoring
Limit ELGs WQSs BPJ Only
Basis: J. L J. J.
Storm ' WQ
Special BHPs Water Sediment Survey
Conditions: J. — - -
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
Z I. — — £
Bio
Survey TRES MDLs Monitoring Other
- - - - J.
Abstract Information:
Complete; Outfalls 001, 002, 003, and 004. All outfall numbers were created for abstracting purposes.
Outfall: 001 | Receiving Water: Kings Bay | Treatment: Not described.
Amount/Components:
Unspecified amount of Water Pollution Control Plant discharge.
Parameter
1,1,1-Trichloroet
hane
1,1,2-Trichloroet
hane
Al (T)
BODS
Bromoform
Cd (T)
Cr
Cu
FC
Fe
Flow
Hg
Methylene chlorid
e
' Ni
O&G
Pb
PH
Phenol
Limitations
Daily
Average
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
100.000000 Ib/d
24.000000 mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report lag/ 1
N/A
Report mg/l
N/A
200.000000
N/A
Report mg/l
0.500000 MGD
N/A
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
N/A
N/A
Report mg/l
N/A
N/A
N/A
Report mg/l
Daily
Maximum
N/A
Report mg/l
N/A
Report mg/l
N/A'
Report mg/l
150.000000 Ib/d
36.000000 mg/l
' N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
400.000000
N/A
Report mg/l
0.750000 MGD
N/A
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
104.000000 Ib/d
25.000000 mg/l
N/A
Report mg/l
N/A
N/A
N/A
Report mg/l
Other
Units: #/100 ml
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1 /quarter
1/quarter
1 /month
3/week
I/quarter
1 /month
1 /month
1 /month
1/week
1 /month
continuous
1 /month
1/quarter
1 /month
1/week
1 /month
1/day
1/quarter
Sample Type
grab
grab
grab
composite
grab
composite
composite
composite
grab
composite
recorder
composite
grab
composite
grab
composite
grab
grab-
Page: 87
-------
Facility Name: US Naval Submarine Base Permit Number: GA0027707
Facility Description: Submarine support facility with metal plating and launch tube ops. SIC Code: 9731
Toluene
Trichloroothylene
TSS
Zn
M/A
Report mg/l
M/A
Report mg/l
100.000000 Ib/d
24.000000 mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
150.000000 Ib/d
36.000000 mg/l
N/A
Report mg/l
1/quarter
1/quarter
3/week
1 /month
grab
grab
composite
composite
Limitations/Monitoring Basis:
As this is a permit modification, based on the addition of an industrial wastewater pretreatment plant, the bases
for the water pollution control plant limits were not included.
Outfall: 002 | Receiving Water: Kings Bay | Treatment: Not described.
Amount/Components :
Unspecified amount of Industrial Uastewater Pretreatment Plant effluent.
Parameter
Al
Cd
CH (T)
Cr (T)
Cu
Fe
Flow
Hg
Hotels (T)
Hi
Pb
PH
Zn
Limitations
Daily
Average
N/A
Report mg/l
N/A
0.070000 mg/l
N/A
Report mg/l
N/A
0.500000 mg/l
N/A
0.700000 mg/l
N/A
Report mg/l
N/A
Report HGD
N/A
0.002000 mg/l
N/A
2.000000 mg/l
N/A
Report mg/l
N/A
0.100000 mg/l
N/A
N/A
N/A
1.000000 mg/l
Daily
Maximum
N/A
Report mg/l
N/A
0.100000 mg/l
N/A
Report mg/ I
N/A
N/A
N/A
N/A
N/A
Report mg/l
N/A
Report HGD
N/A
N/A
N/A
N/A
N/A
Report mg/l
N/A
N/A
N/A
N/A
N/A
N/A
Other
See below
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
2/month
2/month
2/month
2/month
2/month
2/month
continuous
2/month
2/month
2/month
2/month
1/day
2/month
Sample Type
composite
composite
grab
composite
composite
composite
record
composite
composite
composite
composite
grab
compos i te
Limitations/Monitoring Basis:
The basis for this permit modification is the addition of an industrial wastewater pretreatment plant. The limits
for the individual metals are based on BPJ, cited as "engineer's estimated performance." The limit for metals (T)
is based on the contract document's specifications. Total metals consist of the sum of Cu, Cd, Fe, Pb, Ni, Cr, Zn,
and Al. Cn(T), metals, and organics are being monitored at this outfall because they are expected to be present.
Only bronoform and CM were reported as detected on the 2C application; organics are not expected at levels of
concern but CM and metals may be at levels of concern and thus are monitored more frequently. pH limits are set in
accordance with the facility's request via specific correspondence.
Page: 88
-------
Facility Name: US Naval Submarine Base Permit Number: GA0027707
Facility Description: Submarine support facility with metal plating and launch tube ops. SIC Code: 9731
Outfall: 003 | Receiving Water: Kings Bay | Treatment: Not described.
Amount/Components:
Unspecified amount of Batch Wastewater Treatment System discharge of treated launce tube wastewater.
Parameter
CN (A)
Flow
PH
Limitations
Daily
Average
N/A
0.050000 mg/l
N/A
Report gal
N/A
N/A
Daily
Maximum
N/A
0.100000 mg/l
N/A
Report gal
N/A
N/A
Other
See below
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1 /batch
1 /batch
Sample Type
grab
grab
Limitations/Monitoring Basis:
The limits for CN are based on contract document specifications. Report volume for flow for each batch. Flow
monitoring and sample time were not specified. The bases of the monitoring requirements were not described.
Outfall: 004 | Receiving Water: Kings Bay | Treatment: Not described.
Amount/Components :
Unspecified amount of Batch Wastewater Treatment System discharge of treated plating solutions.
Parameter
Ag
Cd
CN (A)
Cr (T)
Cu
Flow
Ni
Pb •
pH
TTOs
Zn
Limitations
Daily
Average
N/A
O.Z40000 mg/l
N/A
0.070000 mg/l
N/A
0.050000 mg/l
N/A
1.710000 mg/l
N/A
2.070000 mg/l
Report gal
N/A
N/A
2.380000 mg/l
N/A
0.430000 mg/l
N/A
N/A
N/A
M/A
N/A
1.480000 mg/l
Dai ly
Maximum
N/A
0.430000 mg/l
N/A
0.110000 mg/l
N/A
0.100000 mg/l
N/A
2.770000 mg/l
N/A
3.380000 mg/l
Report gal
N/A
N/A
3.980000 mg/l
N/A
0.690000 mg/l
N/A
N/A
N/A
2.130000 mg/l
N/A
2.610000 mg/l
Other
See below
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/year
1/year
1 /batch
1/year
1/year
1/batch
1/year
1/year
1/batch
1/year
1/year
Sample Type
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
Limitations/Monitoring Basis:
The limits for CN are based on contract document specifications since they are more stringent than promulgated
guidelines under 40 CFR Part 433. The limits for metals and TTO are based on NSPS ELGs for metal finishing (40 CFR
Part 433). Components of TTO are specified under 40 CFR 433.11. The permit requires that all toxic organics with
quantifiable concentrations greater than 10 ug/l to be added in summing TTO. In lieu of monitoring for TTOs, the
permittee may make the certification described in the special requirements section. Report volume of each batch for
flow monitoring. Flow sample type was not specified in the permit: Monitoring requirements and pH limitations were
not described.
Page: 89
-------
Facility Name: US Naval Submarine Base
Permit Number: GA0027707
Facility Description: Submarine support facility with metal plating and launch tube ops.
SIC Code: 9731
Special Conditions Basis:
The permit requires the implementation of baseline BMPs. Storm water discharges are authorized as long as they do
not violate State water quality standards. If toxicity is suspected, the permittee may be required to develop a
program for whole effluent toxicity monitoring and prepare a toxicity reduction evaluation plan; where specified, 90
days are provided to submit a toxicity study plan, 90 days are provided to conduct the study afterapproval, and 270
days arc provided to implement the TRE if a TRE is required. State-specific sludge monitoring, reporting, and
disposal conditions are included; a plan of operation for land application is required upon written notification.
The permittee is given the option of certifying that no toxic organcis are present in the wastewater as opposed to
monitoring. If the certification option is chosen, the permittee must prepare a toxic organic management plan. The
permittee is required to submit a plan of study for conducting a dye or equivalent dilution study to establish
mixing zones, since a dilution factor is no currently available. Other than described above, the bases of these
conditions were not provided.
Effective Date: 02/12/92
Expiration Date: 04/27/94
Abstract Date: 04/02/93
Page: 90
-------
Facility Name: Hilo Coast Processing Company
Permit Number: :HI0000191
Facility Description: Sugar cane mill for the production of raw sugar
•SIC Code: 2061
Limit
Basis:
ELGs
J.
UQSs
J.
BPJ
Monitoring
Only
J.
WET
Limits
I
WET Testing
Only
Multiple
Categories
Tier.ed
Limits,
'Other
Special
Conditions:
BMPs
Storm
Water
Sediment
J.
WQ
Survey
J.
Bio
Survey
4.
TRES
I
MDLs
Monitoring
'J. '
Other
•J.
Abstract Information:
Complete; Outfalls 001, 002, 003.
Outfall: 001
Receiving Water: Pacific Ocean
Treatment: None.
Amount/Components:
19.3 MGD of once through cooling water and storm water runoff.
Parameter
Acute WET
BODS
Chronic WET
Flow
NH3-N
P (T)
pH
Temp.
TON-N
TSS
Limitations
Monthly
Average
N/A
80.000000
N/A
N/A
N/A
80.000000 %
N/A
Report MGD
N/A
Report mg/l
N/A
Report mg/I
N/A
Report mg/l
N/A
N/A
N/A
N/A
N/A
Report mg/l
N/A
Report
Dai ly
Maximum
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Report MGD
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
N/A
N/A
N/A
N/A
Report mg/l
N/A
Report
Other
See below
See below
Report min. and max.
su
Report degrees C(F)
Unit:lb/1000lb,gross
cane
Monitoring Requirements
Frequency
1/month
1/quarter
1/month
continuous
1/6 months
1/6 months
1/6 months
1/quarter
1/week
1/6 months
1/week
Sample Type
24hr fw composite
grab
24hr fw composite
recorder
grab
grab
grab
grab
grab
grab
24hr fw composite
Limitations/Monitoring Basis:
TSS limitations apply to combined discharge from Outfalls 001, 002, and 003 and are ELG-based consistent with the
sugar cane processing category (40 CFR Part 409; Subpart F). The acute and chronic WET limits and monitoring
requirements were developed in accordance with the EPA National Policy on water quality-based permit limits for
toxic pollutants (49 FR 9016) and specific EPA correspondence. Four species and their respective endpoints are set
forth for use in WET testing based on a communique from EPA's National Effluent Toxicity Assessment Center The
facility must select 3 of the 4 tests (3 acute and 1 chronic) and notify the State within 45 days as to which tests
will be conducted. If the limit is violated, WET monitoring will increase to 1/week until 6 consecutive tests show
compliance; monitoring may be decreased if 12 consecutive months of testing show no toxicity. WET monitoring is
established since it is limited. FC, though found to be present at high levels, will not be regulated since it is
beleived that the FC is naturally occuring rather than a result of mill activities; specific reports are cited to
substantiate this conclusion. BODS, TSS, and pH monitoring is set forth due to ELGs citing these parameters. TSS
monitoring is also established since it is limited and are consistent with the past permit. Flow monitoring is
specified to allow for quantification of discharges. Monitoring for temp, is based on the thermal nature of the
discharge. Monitoring for N (T), NH3-N, TON-N, and P (T) is based on the discharge data provided in the Zone of
Mixing Application. Survival is present in 100% effluent for Acute WET monitoring. Fertilization is present in
100% effluent in Chronic WET monitoring.
Page: 91
-------
Facility Name: Hilo Coast Processing Company Permit Number: HI0000191
Facility Description: Sugar cane mill for the production of raw sugar SIC Code: 2061
Outfall: 002 | Receiving Water: Pacific Ocean | Treatment: Sed
Amount /Component s :
0.016 HGO of storm water runoff from cane trash area
Parameter
8005
Flow
pH
ss
TSS
Limitations
Monthly
Average
N/A
Report mg/l
N/A
Report HGD
N/A
N/A
N/A
Report ml/ 1
N/A
Report
Daily
Maximum
N/A
Report mg/l
N/A
Report MGD
N/A
N/A
N/A
Report ml/l
N/A
Report
Other
Report min. and max.
su
Unit:lb/1000lb,gross
cane
Monitoring Requirements
Frequency
1/discharge
continuous
1/discharge
1/discharge
1/week
Sample Type
grab
recorder
grab
grab
24hr fw composite
Limitations/Monitoring Basis: ,
TSS limitations apply to combined discharge from Outfalls 001, 002, and 003 and are ELG-based consistent with the
sugar cane processing category (40 CFR Part 409; Subpart F). TSS, BODS, and pH monitoring is set forth due to ELGs
citing these parameters. Flow monitoring is specified to allow for quantification of discharges. SS monitoring is
based on the fact that the storm water discharge, if it occurs, overflows a settling basin. No nutrient monitoring
is specified since the discharge is basically storm water runoff and is expected to occur infrequently.
Outfall: 003 | Receiving Water: Pacific Ocean | Treatment: Sed
Amount/Components :
3.8 HGD of mill process wastewaters
Parameter
Acute WET
BOOS
Chronic WET
Flow
M
HH3-H
P
pH
SS
TON-N
Limitations
Monthly
Average
N/A
80.000000 %
N/A
Report mg/l
N/A
80.000000 %
N/A
Report MGD
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
N/A
N/A
Report ml/I
N/A
Report mg/l
Dai ly
Maximum
N/A
N/A
N/A
Report mg/l
N/A
N/A
N/A
Report MGD
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
N/A
N/A
Report ml/l
N/A
Report mg/l
Other
See below
See below
Report min. and max.
su
Monitoring Requirements
Frequency
1 /month
1 /quarter
1 /month
recorder
1 /quarter
1/quarter
1 /quarter
1/quarter
1/quarter
1/quarter
Sample Type
24hr fw composite
grab
24hr fw composite
continuous
grab
grab
grab
grab
grab
grab
Page: 92
-------
Facility Name: Hilo Coast Processing Company
Permit Number: HI0000191
Facility Description: Sugar cane mill for the production of raw sugar
,SIC .Code: 2061
TSS
N/A
Report
N/A
Report
Unit:lb/1000lb gross
cane
1/week
24hr fw composite
Limitations/Monitoring Basis:
TSS limitations apply to combined discharge from Outfalls 001,002, and 003 and are ELG-based consistent with the
sugar cane processing category (40 CFR Part 409; Subpart F). The basis of the WET limits and monitoring
requirements are the same as set forth under the outfall 001 discussion. TSS, BODS, and pH monitoring is set forth
due to ELGs citing these parameters. Flow monitoring is specified to allow for quantificaiton of discharges. SS
monitoring is specified to allow for quantification of discharges. SS monitoring is established since the process
waters are treated by hydroclone and sedimentation prior to discharge. Monitoring for N (T), NH3-N, TON-N, and P
(T) are set forth since these parameters are commonly associated with fertilizers and are included in applicable
UQS. Survival is present in 100% effluent in Acute WET monitoring. Fertilization is present in 100% effluent in
Chronic WET monitoring.
Special Conditions Basis: .
A sediment monitoring plan must be developed to determine the sedimentation rate allowable for the survival of the
marine community; the plan must be submitted within 180 days with annual reports provided thereafter. The sediment
study is required to meet 40 CFR 125.123(d)(2) requirements (as per EPA correspondence) and to ensure that no
unreasonable degradation of the marine environment occurs. Receiving water limitations are set forth for N (T),
NH3-N, TON-N, P (T), chlorophyll, turbidity, pH, DO, temp., and salinity and have been established considering the
continuous nature of the discharge, the infrequent receiving water monitoring, and the need tocomply with UQS;
2/year receiving water monitoring is specified as per EPA correspondence, and due to the difficulty in monitoring.
Aerial photos showing specific items including the receiving water are required 1/quarter on the same day as samples
are taken. Annual monitoring of benthic organisms must also be conducted and must include the diversity and
distribution of the biological community; this monitoring is required pursuant to EPAorrespondence and should serve
as an indicator of the impacts of the discharge. These photos are designed to establish the zone of mixing; this
requirement is based on EPA correspondence. If two consecutive WET tests show violations, a schedule for conducting
a TRE must be submitted within 45 days. Other conditions include: (1) a compliance deadline for toxicity limits of
1 year; (2) the submittal within 45 days of a report which details how the mill's domestic sewage is disposed and
indicates that such is not being discharged; and (3) daily monitoring of tons of gross sugar is required pursuant to
specific EPA correspondence. Other than discussed above, the basis for these conditions were not described.
Effective Date: 09/12/91
Expiration Date: 02/28/95
Abstract Date: 04/22/93
Page: 93
-------
Facility Name: California & Hawaiian Sugar Co Permit Number: H 10000281
Facility Description: Cane Sugar refinery - . , SIC bode: 2062
Monitoring
Limit ELGs WQSs BPJ Only
Basis: 1 I ^ l
Storm UQ
Special BMPs Water Sediment Survey
Conditions: i i i 1
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
Bio
Survey TRES MDLs Monitoring Other
- J. - I I
Abstract Information:
Complete; Outfall 001.
Outfall: 001 | Receiving Water: Aeia Stream | Treatment: Not described
Amount/Components :
3.17 HGO of boiler blowdown, condenser cooling water, and commpressor water.
Parameter
Acute HET
BOOS
Chronic WET
00
Flow
HH3-N
P (T)
P«
Temp.
TON-H
TSS
Limitations
Monthly
Average
N/A
H/A
186.000000 Ib/d
N/A
N/A
N/A
N/A
Report mg/l
N/A
Report MGD
N/A
Report mg/l
N/A
Report mg/l
N/A
N/A
N/A
104.000000 F
N/A
Report mg/l
39.000000 Ib/d
N/A
Daily
Maximum
N/A
N/A
514.000000 Ib/d
N/A
N/A
N/A
N/A
Report mg/l
N/A
Report MGD
N/ft
Report mg/ 1
N/A
Report mg/l
N/A
N/A
N/A
109.000000 F
N/A
Report mg/l
47.000000 Ib/d
N/A
Other
See below
See below
See below
Between 6.0 su and 9
.0 su
See below
Monitoring Requirements
Frequency
1/month
1/week
1/month
1/week
continuous
1/week
1/week
1/week
1/week
1/week
1/week
Sample Type
24hr fw composite
24hr fw composite
24hr fw composite
grab
recorder
grab
grab
grab
grab
grab
24hr fw composite
Limitations/Monitoring Basis:
Productions based limits are included for BODS and TSS. The BODS monthly avg. limit is 0.86 Ib/ton of melt and the
daily max. limit is 2.38 Ib/ton of melt. The TSS monthly avg. limit is 0/18 Ib/ton of melt and the daily max. limit
is 0.54 Ib/ton of melt. Limitations are ELG-based consistent with the sugar cane processing category (40 CFR Part
tin Acute and chror"c WET monitoring requirements set forth 4 species and their respective endpoints. The
facility must select 2 of the 4 tests (3 acute and 1 chronic) and notify the State within 45 days as to which tests
Mill be conducted. If the limit is violated, WET monitoring will increase to 1/week until consecutive tests show
compliance; monitoring may be decreased if 12 consecutive months of testing show no toxicity. 50% survival in 100%
effluent of Acute WET testing. Fertilization in 100% effluent of Chronic WET testing. The basis of the monitorinq
conditions were not described.
Special Conditions Basis:
Although not specifically stated in the permit, influent monitoring must be conducted to determine TSS and BODS
discharge contributions in Ib/ton of melt; influent monitoring is, however, specifically delineated in the fact
sheet. Receiving water limitations are set forth for N (T), NH3-N, TON-N, P (T), chlorophyll, turbidity, pH, DO,
temp., and salinity. Monitoring prior to and after the influence of the discharge impacts (locations specified) is
required in order to document discharge impacts; 1/month monitoring is required the first year and 1/quarter
thereafter. If two consecutive WET tests show violations, a schedule for conducting a TRE must be submitted within
45 days. Other conditions include a compliance deadline for toxicity limits of 2 years and a requirement to report
the ton of melt at a frequency of 1/month. Other than discussed above, the basis for these conditions were not
described.
Page: '94
-------
Facility Name: California & Hawaiian Sugar Co
Permit Number: HI0000281
Facility Description: Cane Sugar refinery
SIC Code: 2062
Effective Date: ,01/17/90
Expiration Date: 06/30/94
Abstract Date: 04/22/93
Page: 95
-------
Facility Nome: Amoron HC&D, LTD, Kappa Quarry
Permit Number: HI0020796
Facility Description: Stone quarry, and rock, sand, and concrete processing plant
SIC Code: 1492
Limit
Basis:
ELGs
J.
WQSS
I
BPJ
I
Monitoring
Only
WET
Limits
WET Testing
Only
Multiple
Categories
Tiered
Limits
I
Other
I
Special
Conditions:
BMPs
Storm
Water
I
Sediment
WQ
Survey
J.
Bio
Survey
TRES
MDLs
Monitoring
Other
Abstract Information:
Complete; Outfall 001.
Outfall: 001 | Receiving Water: Kapaa Stream
Treatment: Sed
Amount/Components:
0.003 MGD of equipment washdown and dust control wastewaters
Parameter
Flow
pH
SS
TSS
Turbidity
Limitations
Daily
Average
M/A
Report MGD
M/A
N/A
N/A
0.100000 ml/I
N/A
20.000000 mg/l
N/A
5.000000 NTU
Dai ly
Maximum
N/A
Report MGD
N/A
N/A
N/A
0.200000 ml/I
N/A
50.000000 rag/ 1
N/A
N/A
Other
Between 6.0 su and 9
.0 su
Seasonal; see below
Seasonal; see below
Monitoring Requirements
Frequency
1/discharge
1/discharge
1/discharge
1/discharge
1/discharge
Sample Type
estimate
grab
grab
grab
grab
Limitations/Monitoring Basis:
Limitations are based on ELGs for mineral mining and processing (40 CFR Part 436), State WQS, past permit limits,
and BPJ. Receiving water limitations are set out for TSS and turbidity; however. Outfall 001 has been identified as
an appropriate monitoring location. Monitoring of the receiving water is optional based on whether the permittee
would like to demonstrate the influence of the receiving water on the results. These criteria vary for the wet
season (Nov. 1 through Apr. 30) and dry season (May 1 through Oct. 31), and are provided for three categories:
monthly avg., result not to exceed criteria more than 10% of the time, and result not to exceed criteria more than
25C of the time. Respectively, for TSS (wet weather) the limits are 20, 50, and 80 mg/l, and for TSS (dry weather)
the Units are 10, 30, and 55 mg/l. Respectively, for turbidity (wet weather) the limitsare 5, 15, and 25 NTU, and
for turbidity (dry weather) the limits are 2, 5.5, and 10 NTU.
Special Conditions Basis:
Within 30 days of the effective date of this permit, the Permittee shall submit to the Director of Health an updated
Stormuater and Effluent Management Program for approval. The approved management program will become part of the
permit. The basis of this condition was not discussed. Monitoring for receiving water quality compliance was
described above.
Effective Date: 01/03/90
Expiration Date: 05/31/94
Abstract Date: 04/22/93
Page: 96
-------
Facility Name: Dept. of Land & Mat. Resources Permit Number: HI0021148
Facility Description: Demonstration Desalting Plant SIC Code: 4941
Monitoring
Limit ELGs WQSs BPJ Only
Basis: i. J. - J.
Storm WQ
Special BHPs Water Sediment Survey
Conditions: L - - J.
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
Bio
Survey TRES MDLs Monitoring Other
- z - - J.
Abstract Information:
Complete; Outfall 001.
Outfall: 001 | Receiving Water: Ditch 2 mi. from Pacific Ocean | Treatment: RO + Ele
Amount/Components :
0.519 HGD of brine waste.
Parameter
Ametryoe
Atrazine
Ba
-------
Facility Home: Dopt. of Land & Nat. Resources
Permit Number: HI0021148
Facility Description: Demonstration Desalting Plant
SIC Code: 4941
Page: 98
-------
Facility Name: IELP 6th Street Station perm,-t Number: IA0000132
Facility Description: Steam Electric Power Company Plant SIC "Code: 4931
. . Monitoring WET WET Testing Multiple Tiered
Limit ELGs WQSs BPJ Only Limits Only Categories Limits Other
B3S1S! - . » -„/
Storm WQ Bio
sPe(=!ai BMPs Water Sediment Survey Survey TRES MDLs Monitoring Other
Conditions: -- - - -.. . . /
------ - _ i
Abstract Information:
Complete; Outfalls 001 (interim limits), 001A (final limits), 002(interim limits),, and 002A (final limits). 001A and
DOHA were created for abstract purposes.
Outfall: 001 Receiving Water: Cedar River | Treatment: None
Amount/Components :
Unspecified amount of condenser cooling water and boiler blowdown.
Parameter
Acute WET
Flow
Other
Temp.
TRC
Limitations
Monthly
Average
N/A
1.000000 T.U.
N/A
59.000000 mgd
N/A
1.450000 mg/l
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
N/A
N/A
106.120000 mgd
N/A
N/A
N/A
103.000000
N/A
0.200000 mg/l
Other
see below
NaBr/NaClO
units: degrees Faren
heit
See below
Monitoring Requirements
Frequency
1/year
1/day
1/day
1/day
1/2 weeks
Sample Type
24 hr composite
24 hour total
measure
grab
grab
Limitations/Monitoring Basis:
Acute toxicity must be tested using ceriodaphnia and pimphales. No limitations basis is provided in the permit
TRC interim limit is equal to that required under effluent guidelines. For TRC, the ratio of NaBr to sodium
hypochlorite is 1.45 or greater, to ensure complete conversion of the sodium hypochlorite to NaCl and HOBr. If the
ratio of NaBr to sodium hypochlorite is 1.45 or greater, the amount of chlorine in the effluent is considered to be
zero. TROs must be measured using the amperometric method specified in Standard Methods, 17th edition. Duration of
chlorination must be recorded at a frequency of 1/day.
Outfall: 001A Receiving Water: Cedar River | Treatment: None
Amount/Components:
Unspecified amount of condenser cooling water and boiler blowdown.
Parameter
Acute WET
Flow
Other
Temp.
TRC
Limitations
Monthly
Average
N/A
1.000000
N/A
59.000000 MGD
N/A
1.450000 mg/l
N/A
N/A
26.000000 Ib/d
0.030000 mg/l
Daily
Maximum
N/A
N/A
N/A
106.120000 MGD
N/A
N/A
N/A
103.000000
39.000000 Ib/d
0.045000 mg/l
Other
see below
NaBr/NaClO
units: degrees Faren
heit
See below
Monitoring Requirements
Frequency
1/year
1/day
1/day
1/day
1/2 weeks
Sample Type
24 hr composite
24 hour total
measure
grab
grab
Page: 99
-------
Facility Name: IELP 6th Street Station Permit Number: IA0000132
Facility Description: Steam Electric Power Company Plant SIC Code: 4931
TROs
H/A
M/A
N/A
0.200000 mg/l
1/week
grab
Limitations/Monitoring Basis:
See Outfall 001.
Outfall: 003 | Receiving Water: Cedar River I Treatment: Sed
Amount/Components: .
Unspecified amount of ash pit cooling, bearing cooling, ash sluice water, and miscellaneous equipment cooling water.
Parameter
Acute WET
Flow
OSG
pH
TSS
Limitations
Monthly
Average
N/A
1.000000 T.U.
N/A
1.150000 mgd
N/A
10.000000 mg/l
N/A
Report
N/A
30.000000 mg/l
Daily
Maximum
N/A
N/A
N/A
2.020000 mgd
N/A
15.000000 mg/l
N/A
Report
N/A
100.000000 mg/l
Other
see below
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/year
1/week
1 /month
1 /month
1 /month
Sample Type
24 hr composite
grab
grab
grab
grab
Limitations/Monitoring Basis: ....
Toxicity testing must be conducted using ceriodaphnia and pimephales. Limitations basis is not provided in the
permit.
Outfall: 002A | Receiving Water: Cedar River I Treatment: Sed.
Amount/Components: . , .
Unspecified amount of ash pit cooling, bearing cooling, ash sluice water, and miscellaneous equipment cooling water.
Parameter
Acute WET
Flow
OSG
P«
TSS
Limitations
Monthly
Average
N/A
1.000000 T.U.
N/A
1.150000 mgd
N/A
10.000000 mg/l
N/A
Report
N/A
30.000000 mg/l
Daily
Maximum
N/A
N/A
N/A
2.020000 mgd
N/A
15.000000 mg/l
N/A
Report
N/A
100.000000 mg/l
Other
see below
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/year
1/week
1 /month
1 /month
1 /month
Sample Type
24 hr composite
grab
grab
grab
grab
limitations/Monitoring Basis: ....
Toxicity testing must be conducted using ceriodaphnia and pimephales. Limitations basis is not provided in the
permit.
Special Conditions Basis:
For outfalls 001 and 001A, free available chlorine or TROs cannot be discharged from any unit for more than two
hours in one day and only one unit in a plant can discharge free available chlorine or TROs at the same time. This
is equivalent to effluent guidelines requirements for once through cooling water.
Effective Date: 03/30/93 Expiration Date: 03/29/98 Abstract Date: 06/22/93
Page: 100
-------
Facility Name: Aluminum Company of America
Permit Number: IA0003395
Facility Description: Aluminum rolling
SIC Code: 3355
.imit
Basis:
ELGs
WQSs
BPJ
Monitoring
Only
J.
WET
Limits
WET Testing
Only
Multiple
Categories
Tiered
Limits
Other
I
Special
Conditions:
BMPs
Storm
Water
Sediment
WQ
Survey
Bio
Survey
TRES
MDLs
J.
Monitoring
J.
Other
J.
Abstract Information:
Complete; Outfalls 001, 002, 003, 004, 005, 006, and 801.
Outfall: 001
Receiving Water: Internal outfall
Treatment: None.
Amount/Components:
Normally zero mgd (except during storms) of storm water, process water from cold rolling operations, and plant-wide
process water.
Parameter
Flow
pH
Temp.
Limitations
Daily
Average
N/A
Report mgd
N/A
Report
N/A
N/A
Maximum
N/A
N/A
N/A
N/A
N/A
110.000000
Other
Between 6.0 su and 9
.0 su
units: degrees Faren
heit
Monitoring Requirements
Frequency
1/week
1/week
1/week
Sample Type
measure
grab
grab
Limitations/Monitoring Basis:
Mass limitations are based on net addition to the Mississippi River. Discharge calculations are provided in the
permit. Temperature must not exceed 110 degrees Farenheit from April 1 through October 31, and must not exceed 85
degrees Farenheit from November 31 through March 31. No other limitations basis is provided.
Outfall: 002
Receiving Water: Internal outfall
Treatment: Unspecified.
Amount/Components:
Normally zero mgd (except during storms) of storm water, process water from foil rolling operations, and sheet
finishing, and plant-wide process water
Parameter
Flow
PH
Temp.
Limitations
Daily
Average
N/A
Report mgd
N/A
Report
N/A
N/A
Maximum
N/A
N/A
N/A
N/A
N/A
110.000000
Other
Between 6.0 su and 9
.0 su
units: degrees Faren
heit
Monitoring Requirements
Frequency
1/week
1/week
1/week
Sample Type
measure
grab
grab
Limitations/Monitoring Basis:
Mass limitations are based on net addition to the Mississippi River. Discharge calculations are provided in the
permit. Temperature must not exceed 110 degrees Farenheit from April 1 through October 31, and must not exceed 85
degrees Farenheit from November 31 through March 31. No other limitations basis is provided.
Outfall: 003
Receiving Water: Internal outfall
Treatment: Unspecified.
Amount/Components:
Normally zero mgd (except during storms) of storm water, process water from foil rolling and laminating operations, and
cold rolling operations.
Parameter
Flow
Limitations
dai ly
Average
N/A
Report mgd
Maximum
N/A
N/A
Other
Monitoring Requirements
Frequency
1/week
Sample Type
measure
Page: 101
-------
Facility Name: Aluminum Company of America Permit Number: IA0003395
Facility Description: Aluminum rolling ' ' . SIC Code: 3355
pH
Temp.
N/A
Report
N/A
N/A
N/A
N/A
N/A
110.000000
Between 6.0 su and 9
.0 su
Units: degrees Faren
heit
1/week
1/week
grab
grab
Limitations/Monitoring Basis:
Mass limitations are based on net addition to the Mississippi River. Discharge calculations are provided in the
permit. Temperature must not exceed 110 degrees Farenheit from April 1 through October 31, and must not exceed 85
degrees Farenheit from November 31 through March 31. No other limitations basis is provided.
Outfall: 004 | Receiving Water: Internal outfall | Treatment: Unspecified.
Amount/Components: >
Normally zero mgd (except during storms) of storm water, process water from hot rolling and mill water reclamation
operations, and plant process water
Parameter
Flow
PH
Tcnsp.
Limitations
Dai ly
Average
N/A
Report mgd
N/A
Report
N/A
N/A
Maximum
N/A
N/A
N/A
N/A
N/A
110.000000
Other
Between 6.0 su and 9
.0 su
Units: degrees Faren
heit
Monitoring Requirements
Frequency
1/week
1/week
1/week
Sample Type
measure
grab
grab
Limitations/Monitoring Basis:
Mass limitations are based on net addition to the Mississippi River. Discharge calculations are provided in the
permit. Temperature must not exceed 110 degrees Farenheit from April 1 through October 31, and must hot exceed 85
degrees Farenheit from November 31 through March 31. No other limitations basis is provided.
Outfall: 005 | Receiving Water: Internal outfall | Treatment: Unspecified. '
Amount/Components:
Normally zero mgd (except during storms) of storm water, process water from hot rolling operations and plant-wide
process water.
Parameter
Flow
pH
Temp.
Limitations
Dai ly
Average
N/A
Report mgd
N/A
Report
N/A
N/A
Maximum
N/A
N/A
N/A
N/A
N/A
110.000000
Other
Between 6.0 su and 9
.0 su
Units: degrees Faren
heit
Monitoring Requirements
Frequency
1/week
1/week
1/week
Sample Type
measure
grab
grab
Limitations/Monitoring Basis:
Mass limitations are based on net addition to the Mississippi River. Discharge calculations are provided in the
permit. Temperature must not exceed 110 degrees Farenheit from April 1 through October 31, and must not exceed 85
degrees Farenheit from November 31 through March 31. No other limitations basis is provided.
Outfall: 006 | Receiving Water: Internal outfall | Treatment: Unspecified.
Amount/Components:
Unspecified amount of storm water, process water from ingot casting and etching, blowdown from cooling tower, and
plant-Hide process water. :
Parameter
Limitations
Daily
Average
Maximum
Other
Monitoring Requirements
Frequency
Sample Type
Page: 102
-------
Facility Name: Aluminum Company of America Permit Number: IA0003395
Facility Description: Aluminum rolling SIC Code: 3355
Flow
PH
Temp.
N/A
Report mgd
N/A
Report
N/A
N/A
N/A
N/A
N/A
N/A
N/A
110.000000
Between 6.0 su and 9
.0 su
Units: degrees Faren
heit
1/week
1/week
1/week
measure
grab
grab
Limitations/Monitoring Basis:
Mass limitations are based on net addition to the Mississippi River. Discharge calculations are provided in the
permit. Temperature must not exceed 110 degrees Farenheit from April 1 through October 31, and must not exceed 85
degrees Farenheit from November 31 through March 31. No other limitations basis is provided.
Outfall: 007 | Receiving Water: Internal outfall | Treatment: Unspecified.
Amount/Components :
Unspecified amount of blowdown from river water treatment plant and Outfall 004 discharge (if any).
Parameter
Flow
pH
Temp.
Limitations
Daily
Average
N/A
Report mgd
N/A
Report
N/A
N/A
Maximum
N/A
N/A
N/A
N/A
N/A
110.000000
Other
Between 6.0 su and 9
.0 su
Units: degrees Faren
heit
Monitoring Requirements
Frequency
1/week
1/week
1/week
Sample Type
measure
grab
grab
Limitations/Monitoring Basis:
Mass limitations are based on net addition to the Mississippi River. Discharge calculations are provided in the
permit. Temperature must not exceed 110 degrees Farenheit from April 1 through October 31, and must not exceed 85
degrees Farenheit from November 31 through March 31. No other limitations basis is provided.
Outfall: 801 | Receiving Water: Mississippi River | Treatment: Unspecified.
Amount/Components:
Unspecified amount of total, plant discharge from all outfalls.
Parameter
Ag (T)
Al CT)
As (T)
Ba
Cd (T)
CN (T)
Cr
-------
Facility Homo: Aluminum Company of America Permit Number: IA0003395
Facility Description: Aluminum rolling SIC Code: 3355
Flow
Hg
Hi
OSG
Pb (T)
PCBs (T)
Phenols
So (T)
Tetrachlorocthyle
no
TSS
Zn (T)
N/A
Report mgd
0.260000 Ib/d
0.001000 mg/l
3337.000000 Ib/d
13.500000 mg/l
5010.000000 Ib/d
N/A
132.000000 Ib/d
0.530000 mg/l
N/A
N/A
257.000000 Ib/d
10.400000 mg/l
116.000000 Ib/d
0.470000 mg/l
N/A
N/A
8140.000000 Ib/d
N/A
113.000000 Ib/d
1.340000 mg/l
N/A
Report mgd
0.400000 Ib/d
0.001600 mg/l
5004.000000 Ib/d
20.200000 mg/l
8350.000000 Ib/d
N/A
198.000000 Ib/d
0.800000 mg/l
N/A
0.000030 mg/l
385.000000 Ib/d
15.600000 mg/l
174.000000 Ib/d
0.700000 mg/l
1.800000 Ib/d
N/A
17117.000000 Ib/d
N/A
270.000000 Ib/d
2.000000 mg/l
See below
See below
See below
See below
1/week
1 /month
1 /month
1/week
1 /month
1/week
1 /month
1 /month
1/2 weeks
1/week
1/week
measure
grab
grab
grab
grab
. grab
grab
grab
grab
grab
grab
Limitations/Monitoring Basis:
Mass limitations are based on net addition to the Mississippi River CTSS, O&G, Al(T), Zn(T)). Intake water must be
sampled for TSS, O&G, AlCT), Hn(T), Cr(T), and CN(T) at same frequencies as for effluent monitoring. Discharge
calculations are provided in the permit. Temperature must not exceed 110 degrees Farenheit from April 1 through
October 31, and must not exceed 85 degrees Farenheit from November 31 through March 31. No other limitations basis
is provided. The PCB limit applies after June 1, 1993 as specified in compliance schedule.
Special Conditions Basis:
For outfall 801, compliance results reported as <0.5 ppb wil be considered to be in compliance. Monitoring for PCBs
must be conducted using EPA Method 608 with results reported to a detection limit of 0.5 ppb. Results reported as
<0.5 ppb will be considered to be in compliance. Weekly sampling for CN is not required if the first wastewater
sample of each calendar year has less than 0.07 mg/l CN. A compliance schedule for meeting the effluent limitations
is included in the permit.
Effective Date: 02/05/91 Expiration Date: 02/01/96 Abstract Date: 06/24/93
Page: 104
-------
Facility Name: John Deere Dubuque Works Permit Number: IA3126107
Facility Description: Not provided SIC Code:
Monitoring
Limit ELGs WQSs BP'J Only
Basis: I. I. I. J.
Storm WQ
Special BHPs Water Sediment Survey
Conditions: L - 2. -
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
— J. - 2. 4.
Bio
Survey TRES MDLs Monitoring Other
— — - J. -
Abstract Information:
Partial; Outfalls 002, 003, 004, 005, 008, 011. Permit also covers outfalls 090, 010, and 014-028, (stormwater and
drinking fountain water discharges.
Outfall: 002 Receiving Water: Little Haquoketa & Mississipi | Treatment: Sed, Skimmer
Amount/Components:
Unspecified amount of noncontact cooling water, drinking fountain drains and storm water discharge.
Parameter
Acute WET
Flow
O&G
PH
Temp.
Limitations
Month ly
Average
N/A
1.000000 TU
N/A
2.534000 mgd
211.000000 Ib/d
10.000000 mg/l
Report
N/A
N/A
N/A
Daily
Maximum
N/A
N/A
N/A
3.800000 mgd
317.000000 Ib/d
15.000000 mg/l
Report
N/A
N/A
95.000000
Other
see below
Between 6.0 su and 9
.0 su
units: degrees Fareri
heit
Monitoring Requirements
Frequency
1/year
5/week
1/week
1/week
1/week
Sample Type
24 hr composite
24 hr total
grab
grab
grab
Limitations/Monitoring Basis:
WET testing must be conducted using both Ceriodaphnia and Pimephales. The effluent must show no toxicity. pH
minimum is a weekly average minimum. No further information is provided for the limitations basis.
Outfall: 003 Receiving Water: Little Maquoketa & Mississipi | Treatment: Sed, Aer
Amount/Components :
Unspecified amount of treated domestic wastewater.
Parameter
BODS
DO
FC
Flow
NH3-N
PH
Temp.
TRC
Limitations
Monthly
Average
50.000000 Ib/d
30.000000 mg/l
N/A
N/A
N/A
20.700000
N/A
0.200000 mgd
N/A
Report mg/l
Report
N/A
N/A
N/A
0.070000 Ib/d
0.093000 mg/l
daily
Maximum
75.000000 Ib/d
45.000000 mg/l
N/A
N/A
N/A
N/A
N/A
0.240000 mgd
N/A
N/A
Report
N/A
N/A
95.000000
0.100000 Ib/d
0.170000 mg/l
Other
See below
Units:#/100 ml, see
below
Between 6.0 su and 9
.0 su
units: degrees Faren
heit
See below
Monitoring Requirements
Frequency
1/week
2/week
1 /quarter
1/day
1 /quarter
1/week
2/week
2/week
Sample Type
24 hr composite
grab
24 hr total
24 hr composite
grab
grab
grab
Page: 105
-------
Facility Hame: John Deere Dubuque Works Permit Number: IA31Z6107
Facility Description: Not provided SIC Code:
TSS
50.000000 Ib/d
30.000000 mg/l
75.000000 Ib/d
45.000000 mg/l
See be low
1 /month
24 hr composite
.
Limitations/Monitoring Basis:
Fecal coliform limitations apply for summer only (April 1-October 31). No further information is provided for the
limitations basis. Intake monitoring required for Temp., BODS, TSS and pH at same frequencies and sample type as for
effluent monitoring.
Outfall: 004 | Receiving Water: Little Haquoketa and Hississip | Treatment: None.
Amount/Components:
Unspecified amount of condenser cooling water from electrical generator.
Parameter
Flow
pH
TRC
Limitations
daily
Average
N/A
21.000000 mgd
Report
N/A
N/A
N/A
dai ly
Maximum
N/A
23.000000 mgd
Report
N/A
N/A
0.200000 mg/l
Other
Between 6.0 and 10.0
su
Monitoring Requirements
Frequency
1 /month
1 /month
1 /event
Sample Type
24 hr total
grab
grab
Limitations/Monitoring Basis:
The maximum increase in temperature must not exceed 5.4 degrees celcius. TRC samples must be collected at the
condenser discharge before mixing with other wastestreams. Samples must be collected only on days when the
condenser is chlorinated. No further information is provided on the limitations basis.
Outfall: 005 | Receiving Water: Little Haquoketa & Mississipi | Treatment: Sed, API
Amount/Components :
Unspecified amount of noncontact cooling water, drinking fountain drains, and stormwater discharge.
Parameter
Acute WET
Flow
O&G
PH
Temp.
Limitations
daily
Average
N/A
1.000000
N/A
9.000000 mgd
751.000000 Ib/d
10.000000 mg/l
Report
N/A
N/A
N/A
dai ly
Maximum
N/A
N/A
N/A
13.500000 mgd
1126.000000 Ib/d
15.000000 mg/l
Report
N/A
N/A
95.000000
Other
see below
Between 6.0 su and 9
.0 su
units: degrees Faren
heit
Monitoring Requirements
. Frequency
1/year
1/day
1/week
1/week
1/week
Sample Type
24 hr composite
24 hr total
grab
grab
grab
Limitations/Monitoring Basis:
WET testing must be conducted using both ceriodaphnia and pimephales. The effluent must show no toxicity. No
further information is provided for the limitations basis. ,
Outfall: 008 | Receiving Water: Little Haquoketa & Mississipi | Treatment: Sed
Amount/Components:
Unspecified amount of tractor wash booth drain, landfill leachate, and storm water.
Parameter
Cd
Limitations
daily
Average
0.080000 Ib/d
0.340000 mg/l
daily
Maximum
0.120000 Ib/d
0.350000 mg/l
Other
Monitoring Requirements
Frequency
1 /month
Sample Type
grab
Page: 106
-------
Facility Name: John Deere Dubuque Works Permit Number: ,IA3 126 107
Facility Description: Not provided SI9'C,9<:le: • .-
Cr+6
Cu (T)
Flow
NH3-N
Pb (T)
PH
Temp.
Zn
-------
Facility Mane: John Deere Dubuque Works Permit Number: IA3126107
Facility Description: Mot provided SIC Code:
pH
Temp.
TSS
TTOs
Zn (T)
Report
N/A
N/A
N/A
91.000000 Ib/d
31.000000 mg/l
N/A
N/A
4.320000 Ib/d
1.480000 mg/l
Report
N/A
N/A
95.000000
175.000000 Ib/d
60.000000 mg/l
6.000000 Ib/d
2.130000 mg/l
7.620000 Ib/d
2.610000 mg/l
Between 6.0 su and 9
.0 su
units: degrees Faren
heit
see below
2/week
2/week
2/week
1/6 months
2/week
grab
grab
24 hr composite
grab
24 hr composite
Limitations/Monitoring Basis:
UET testing must be conducted using both ceriodaphnia and pimephales. The effluent must show negative toxicity.
Total toxic organic pollutants ("other") are limited to the following parameters: 1,1-DCA, 1,1-DCE, T-1, 2-DCE,
chloroform, 1,1,1-TCA, carbon tetrachloride, TCE, 1,1,2-trichloroethanne, benzene, tetrachloroethene, toluene,
1,1,2,2-tetrachloroethane, ethylbenzene, and xylene. No further information is provided for the
limitations/monitoring basis.
Special Conditions Basis:
Stormwater monitoring is required at Outfalls 002, 005, 006, 008, 009, 010, 014, 015, 016, 017, 018, 019, 020, 021,
022, 023, 024, 025, 026, 027, and 028, but parameters not available at time of abstracting. Sample types must be 24
hr. composites. Total Toxic Organics includes 1,1-DCE, 1,1-DCA, T-I, 2-DCE, chloroform, 1,1,1-TCA, Carbon tet, TCE,
1,1,2-Trichloroethane, benzene, tetrachloroethene, 1,1,2,2-Tetrachloroethane, toluene, ethylbenzene, and xylene.
Effective Date: 09/03/92 Expiration Date: 09/01/97 Abstract Date: 06/28/93
Page: 108
-------
Facility Name: Monsanto Company - Muscatine Permit Number: IA7000102
Facility Description: Organic chemical manufacturer SIC code- 2869
, . . Monitoring WET WET Testing Multiple Tiered
^"".t ELGs WQSs BPJ Only Limits Only Categories Limits Other
Basis: -- - - _ J - - t
Storm WQ Bio
Special BMPs Water Sediment Survey Survey TRES MDLs Monitoring Other
conditions: -- - - - / _ _
Abstract Information:
Complete; Outfall 001, 002, and 003.
Outfall: 001 | Receiving Water: Missippippi River | Treatment: Not specified
Amount/Components :
Unspecified amount of organic chemical manufacturing process wastewater.
Parameter
Acute WET
BODS
NH3-N
Other
PH
ss
TRC
TSS
Limitations
Daily
Average
N/A
N/A
2131.000000 Ib/d
N/A
1358.000000 Ib/d
N/A
5.820000 Ib/d
N/A
Report
N/A
N/A
N/A
14.700000 Ib/d
0.177000 mg/l
2332.000000 Ib/d
N/A
Dai ly
Maximum
N/A
1.000000 TU
6615.000000 Ib/d
N/A
1681.000000 Ib/d
N/A
13.250000 Ib/d
N/A
Report
N/A
N/A
Report mg/l
22.100000 Ib/d
0.266000 mg/l
6019.000000 Ib/d
N/A
Other
See below
Herbicides, see belo
w
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/year
5/week
5/week
7/week
1/day
1/day
5/week
5/week
Sample Type
24 hr composite
24 hr composite
24 hr composite
24 hr composite
continuous
grab
grab
24 hr composite
Limitations/Monitoring Basis:
The first WET test must be conducted within 3 months of permit issuance and once per year thereafter. Toxicity
testing must be conducted using Ceriodaphnia dubia and Pimephales promelas, and must follow Standard Operating
Procedure: Effluent Toxicity Testing, IDNR. March 1991, and Iowa Administrative Code chapters 567-60.2 and 567-
63.4(2). The diluted effluent samples must contain a minimum of 13.1% effluent water and 86.9% culture water
Monitoring and limits for Total Registered Herbicides includes the sum of all manufactured or formulated herbicides
including but not limited to Lasso (alachlor). Ramrod (butachlor). Machete (propachlor), acetochlor, Avadex
(triallate), Atrazine and Trifluralin. Grab samples must be collected in the aeration basin and analyzed for SS
DO, MLSS, Settleabihty, and temp, at a frequency of 5/week. No further discussion on limitations basis is provided
in the permit.
Outfall: 002 Receiving Water: Internal outfall Treatment: ABS wastewater treatment plant
Amount/Components :
Unspecified amount of wastewater treatment plant effluent from ABS treatment plant.
Parameter
1,1,1-Trichloroet
hane
1,1,2,2-Tetrachlo
roethane
1,1,2-Trichloroet
hane
Limitations
Daily
Average
0.098000 Ib/d
N/A
0.103000 Ib/d
N/A
0.098000 Ib/d
N/A
Dai ly
Maximum
0.252000 Ib/d
N/A
0.261000 Ib/d
N/A
0.252000 Ib/d
N/A
Other
Monitoring Requirements
Frequency Sample Type
1/6 months grab
1/6 months grab
1/6 months grab
Page: 109
-------
Facility Hanxs: Monsanto Company - Huscatine Permit Number: IA7000102
Facility Description: Organic chemical' manufacturer SIC Code: 2869
1,1-Dichloroethan
e
1,1-Oichloroethyl
ene
1,2,4-Trichlorobe
nzcno
1,2-Dichlorobonze
no
1,2-Dichloroethan
e
1,2-Dichloropropa
no
1,2-Trans-Dichlor
oothylcno
1,3-Dichlorobonze
no
1,3-Dichloropropo
no
1,4-Dichlorobenze
no
2,4-Dichlorophcno
2,4-Dimethylpheno
I
2,4-Dinitrophenol
2,4-Dinitrotoluen
e
2,6-Dinitrotoluen
c
2-Chlorophcnol
2-Hitrophcnol
3,4-Bcnzofluorant
hcne
4,6-Dinitro-o-cre
sol
4-Hitrophenol
Acenaphthenc
Acenaphthylene
Acrylonitrile
Anthracene
Benzene
0.103000 Ib/d
N/A
0.075000 Ib/d
N/A
0.320000 Ib/d
N/A
0.360000 Ib/d
N/A
0.320000 Ib/d
N/A
0.714000 Ib/d
N/A
0.098000 Ib/d
N/A
0.140000 Ib/d
N/A
0.135000 Ib/d
N/A
0.070000 Ib/d
N/A
0.180000 Ib/d
N/A
0.080000 Ib/d
N/A
0.330000 Ib/d
N/A
0.530000 Ib/d
N/A
1.190000 Ib/d
N/A
0.140000 Ib/d
N/A
0.190000 Ib/d
N/A
0.110000 Ib/d
N/A
0.360000 Ib/d
N/A
0.340000 Ib/d
N/A
0.100000 Ib/d
N/A
0.100000 Ib/d
N/A
0.450000 Ib/d
N/A
0.100000 Ib/d
N/A
0.173000 Ib/d
N/A
0.275000 Ib/d
N/A
0.117000 Ib/d
N/A
0.650000 Ib/d
N/A
0.760000 Ib/d
N/A
0.980000 Ib/d
N/A
1.074000 Ib/d
N/A
0.252000 Ib/d
N/A
0.210000 Ib/d
N/A
0.205000 Ib/d
N/A
0.130000 Ib/d
N/A
0.520000 Ib/d
N/A
0.170000 Ib/d
N/A
0.570000 Ib/d
N/A
1.330000 Ib/d
N/A
2.990000 Ib/d
N/A
0.460000 Ib/d
N/A
0.320000 Ib/d
N/A
0.280000 Ib/d
N/A
1.290000 Ib/d
N/A
0.580000 Ib/d
N/A
0.280000 Ib/d
N/A
0.280000 Ib/d
N/A
1.130000 Ib/d
N/A
0.280000 Ib/d
N/A
0.635000 Ib/d
N/A
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1 /month
1/6 months
1/6 months
grab
grab
24 hr composite
24 hr composite ' •
grab
grab
grab
24 hr composite
grab
24 hr composite
24 hr composite
24 hr composite
24 hr composite
24 hr composite
24 hr composite
24 hr composite
24 hr composite
24 hr composite
24 hr composite
24 hr composite
24 hr composite
24 hr composite
grab
24 hr composite
grab
Page: 110
-------
Facility Name: Monsanto Company - Huscatine Permit Number: IA7000102
Facility Description: Organic chemical manufacturer • SIC Code: 2869
Benzo (a) anthrac
ene
Benzo (a) pyrene
Benzo (k) fluoran
thane
Bis (2-chlorisopr
opyl) ether
Bis (2-ethylhexyl
) phthalate
BODS
Carbon tetrachlor
ide
Chlorobenzene
Chloroethane
Chloroform
Chrysene
CN (T)
Cr (T)
Cu (T)
Di-n-butyl phthal
ate
Diethyl phthalate
Dimethyl phthalat
e
Ethylbenzene
Fluoranthene
Fluorene
Hexach lorobenzene
Hexachlorobutadie
ne
Hexach loroethane
Methyl chloride
Methylene chlorid
e
0.100000 Ib/d
N/A
0.110000 Ib/d
N/A
0.100000 Ib/d
N/A
1.400000 Ib/d
N/A
0.480000 Ib/d
N/A
112.000000 Ib/d
N/A
0.084000 Ib/d
N/A
0.070000 Ib/d
N/A
0.490000 Ib/d
N/A
0.098000 Ib/d
N/A
0.100000 Ib/d
N/A
1 .960000 Ib/d
N/A
5.180000 Ib/d
N/A
6.770000 Ib/d
N/A
0.130000 Ib/d
N/A
0.380000 Ib/d
N/A
0.090000 Ib/d
N/A
0.150000 Ib/d
N/A
0.120000 Ib/d'
N/A
0.100000 Ib/d
N/A
0.070000 Ib/d
N/A
0.090000 Ib/d
N/A
0.100000 Ib/d
N/A
0.400000 Ib/d
N/A
0.190000 Ib/d
N/A
0.280000 Ib/d
N/A
0.280000 Ib/d
N/A
0.280000 Ib/d
N/A
3.530000 Ib/d
N/A
1.300000 Ib/d
N/A
299.000000 Ib/d
N/A
0.177000 Ib/d
N/A
0.130000 Ib/d
N/A
1.250000 Ib/d
N/A
0.215000 Ib/d
N/A
0.280000 Ib/d
N/A
5.600000 Ib/d
N/A
12.930000 Ib/d
N/A
15.770000 Ib/d
N/A
0.270000 Ib/d
N/A
0.950000 Ib/d
N/A
0.220000 Ib/d
N/A
0.504000 Ib/d
N/A
0.320000 Ib/d
N/A
0.280000 Ib/d
N/A
0.130000 Ib/d
N/A
0.230000 Ib/d
N/A
0.250000 Ib/d
N/A
0.890000 Ib/d
N/A
0.420000 Ib/d
N/A
See below
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
2/week
1/6 months
1 /month
1/6 months
1/6 months
1/6 months
1 /month
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1 /month
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
24 hr composite
24 hr composite
24 hr composite
24 hr composite
24 hr composite
24 hr composite
grab
grab
grab
grab
24 hr composite
grab
24 hr composite
24 hr composite
24 hr composite
24 hr composite
24 hr composite
grab
24 hr composite
24 hr composite
24 hr composite
24 hr composite
24 hr composite
grab
grab
Page: 111
-------
Facility Name: Monsanto Company - Muscatine Permit Number: IA7000102
Facility Description: Organic chemical manufacturer sic Code: 2869
Naphthalene
Hi
Nitrobenzene
Pb (T)
P*
Phcnanthrenc
Phenol
Pyrene
Toluene
Trichloroothylene
TSS
Vinyl chloride
Zn
0.100000 Ib/d
N/A
7.890000 Ib/d
N/A
0.130000 Ib/d
N/A
1.490000 Ib/d
N/A
Report
N/A
0.100000 Ib/d
N/A
0.070000 Ib/d
N/A
0.120000 Ib/d
N/A
0.121000 Ib/d
N/A
0.098000 Ib/d
N/A
187.000000 Ib/d
N/A
0.490000 Ib/d
N/A
4.900000 Ib/d
N/A
0.280000 Ib/d
N/A
18.570000 Ib/d
N/A
0.320000 Ib/d
N/A
3.220000 Ib/d
N/A
Report
N/A
0.280000 Ib/d
N/A
0.120000 Ib/d
N/A
0.310000 Ib/d
N/A
0.374000 Ib/d
N/A
0.252000 Ib/d
N/A
607.000000 Ib/d
N/A
1.250000 Ib/d
N/A
12.180000 Ib/d
N/A
Between 6.0 su and 9
.0 su
1/6 months
1/6 months
1/6 months
1/6 months
1/day
1/6 months
1/6 months
1/6 months
1/6 months
1/6 months
5/week
1/6 months
1/6 months
24 hr composite
24 hr composite
24 hr composite
24 hr composite
continuous
24 hr composite
24 h'r composite
24 hr composite
grab
grab
24 hr composite
grab
24 hr composite
Limitations/Monitoring Basis:
The pH must be maintained within the limitations specified except if: 1) the pH limitation is exceeded for less than
7 hours and 26 minutes in any calendar month, or 2) the pH limitation is exceeded for less than 60 minutes. No
further discussion on limitations basis is provided in the permit.
Outfall: 003 | Receiving Water: Internal outfall | Treatment: Ag wastewater treatment plant
Amount/Components :
Unspecified amount of wastewater treatment plant effluent from Ag waste treatment plant.
Parameter
1,2-Dichlorocthan
e
BOOS
COO
Other
pH
Limitations
Daily
Average
N/A
N/A
1125.000000 Ib/d
N/A
6331.000000 Ib/d
N/A
1.120000 Ib/d
N/A
Report
N/A
Daily
Maximum
N/A
Report
5205.000000 Ib/d
N/A
9114.000000 Ib/d
N/A
4.510000 Ib/d
N/A
Report
N/A
Other
See below
total registered her
bicid
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/6 months
5/week
1/week
7/week
1/day
Sample Type
grab
24 hr composite
24 hr composite
24 hour composite
continuous
Page: 112
-------
Facility Name: Monsanto Company - Muscatine
Permit Number: IA7000102
Facility Description: Organic chemical manufacturer
SIC Code: 2869
TSS
1266.000000 Ib/d
N/A
4291.000000 Ib/d
N/A
5/week
24 hr composite
Limitations/Monitoring Basis:
The pH must be maintained within the limitations specified except if: 1) the pH limitation is exceeded for less than
7 hours and 26 minutes in any calendar month, or 2) the pH limitation is exceeded for less than 60 minutes. Total
registered herbicides include alachlor, butachlor, propachlor, acetochtor, aradex and atrazine. No further
discussion on limitations basis is provided in the permit. Total registered herbicides includes all manufactured
formulas, including but not limited to Lasso (alachlor). Ramrod (butachlor). Machete (parachlor), acetochlor, Avadex
(triallate), atrazine and triflurelin.
Special Conditions Basis:
Influent flow (24 hour) and BODS (24 hr. comp.) monitoring is required at the influent of the ABS and Ag treatment
units, at frequencies of 2/week and 5/week respectively. For Outfall 001, a TRE is required if two successive
positive toxicity results are achieved or if three positive results out of five are achieved. If positive toxicity
results, monitoring frequency increases to 1/quarter. For all 3 outfalls, the pH limitations may be exceeded if:
1) the total time of pH limitation is exceeded less than 7 hours and 26 minutes in any calendar month, or 2) the pH
limitation is not exceeded for more than 60 minutes at any one time. Total flow monitoring and reporting is
required for Outfall 001 and may be measured as the summed flow from Outfall 002 and 003 or as the summed influent
to the ABS and Ag waste treatment plants. Sample frequency/type is specified as 1/day and24 hr commp. for alachlor,
butachlor, propachlor and acetochlor.
Effective Date: 03/06/89
Expiration Date: 03/01/94
Abstract Date: 06/23/93
Page: 113
-------
Facf Uty Mama: DOI, FWS Hagerman Nat'l Fish Permit Number: ID0000825
Facility Description: Fish hatching and rearing facility . . . Sic Code: 0921
Monitoring
Limit ELGs WQSs BPJ Only
Basis: z - I I
Storm WQ
Special BHPs Water Sediment Survey
Conditions: j. - - J.
WET WET Testing Multiple Tiered
Limits Only. Categories Limits Other
Bio :
. Survey TRES MDLs Monitoring Other
- - ; .- - I
Abstract Information:
Complete; Outfalls 001 and 002.
Outfall: 001 | Receiving Water: Riley Creek | Treatment; Sed
Amount/Components :
Unspecified amount of raceway or pond discharges. .
Parameter
Flow
NH3 (T)
P CT>
SS
TKN
TO?)
TSS
Limitations
Monthly
Average
M/A
Report ,MGD
N/A
Report mg/l
N/A
Report mg/l
N/A
0.100000 mg/l
N/A
Report mg/l
M/A
Report mg/l
N/A
5.000000 mg/l
Instant
Maximum
N/A
Report MGD
N/A
Report mg/ 1
N/A
Report mg/l
N/A
N/A
N/A
Report mg/l
N/A
Report mg/l
N/A
15.000000 mg/l
Other
See below
See below
See below
See below
Monitoring Requirements
Frequency
1 /month
1/2 months
1/2 months
2/month
1/2 months
1/2 months
1/2 months
Sample Type
total
24hr fw composite
24hr fw composite
grab
24hr fw composite
24hr fw composite
24hr fw composite
Limitations/Monitoring Basis:
Constituents of concern are solids associated with fish fecal material and uneaten fish foods. Effluent limits were
based on BPJ using the best conventional technology of vacuum or standpipe drain cleaning of screened raceways.
This technology was evaluated as part of a study dated July 23, 1984. The limits for TSS and SS are net values. In
order to obtain credit for net values, intake water samples must be taken on the same day, during the same period
that the effluent sample is taken. Nutrient parameters must also be reported as net values. Frequency of
monitoring is based on variability in operations, magnitude of pollutants, and difficulty in monitoring for certain
pollutants. Sample type may either be 8hr or 24hr flow-weighted composites. Nutrient monitoring (TON, NH3, TKN, P)
is required for one year unless the permittee opts to participate in a nutrient characterization study as discussed
in special conditions. Requirements are consistent with data requirements • of Snake River Study designed to assess
cumulative impacts of nutrients from dischargers. Monitoring requirements are based on variability in operations,
magnitude of pollutants, and difficulty in monitoring for certain pollutants. Frequencies and parameters of the
nutrients to be monitored are consistent with requirements for other facilities of this type and size in the Idaho
fish-culturing industry.
Outfall: 002 | Receiving Water: Riley Creek | Treatment: Sed
Amount/Components :
Unspecified amount of cleaning waste treatment system discharges.
Parameter
Flow
MH3
P (T)
Limitations
Monthly
Average
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
Daily
Maximum
N/A
Report MGD
N/A
Report mg/l
N/A
Report mg/l
Other
See below
See below
Monitoring Requirements
Frequency
1/week
1 /month
1 /month
Sample Type
total
8hr fw composite
8hr fw composite
Page: 114
-------
Facility Name: DOI, FWS Hagerman Nat'I Fish
Permit Number: ID0000825
Facility Description: Fish hatching and rearing facility
SIC Code: 0921
SS
TKN
TON
TSS
N/A
N/A
N/A
Report mg/l
N/A
Report mg/l
N/A
N/A
N/A
1.000000 mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
100.000000 mg/l
See below
See below
1/week
1/month
1/month
1/month
grab
8hr fw composite
8hr fw composite
8hr fw composite
Limitations/Monitoring Basis:
Constituents of concern are solids associated with fish fecal material and uneaten fish foods. Percent removal for
cleaning waste treatment system is not included as a parameter because unique conditions exist such that solids do
not accumulate in raceways (i.e., daily cleaning and low fish/flow ratio). Also, monitoring of TSS and SS from 1988
to 1989 showed low values. Therefore, it would be difficult to accurately determine compliancewith % removal
parameter. Monitoring of TSS and SS is required in order to characterize the effluent and assess overall treatment
efficiency. Nutrient monitoring is being required as described above in the outfall 001 discussion. Monitoring
requirements are based on variability in operations, magnitude of pollutants, and difficulty in monitoring for
certain pollutants. The frequencies and parameters of the nutrients to be monitored areconsistent with requirements
for other facilities of this type and size in the Idaho fish-culturing industry.
Special Conditions Basis:
The permit limits the use of drugs, medications, disinfectants, and disease control chemicals to: those approved
for hatchery used by USFDA or EPA; those exempt from registration for fishing use; or those declared generally safe
by USDA. Products must be used in accordance with the permitted uses and applications specified by the
manufacturer. Discharge of these drugs, chemicals or medications in toxic amounts are prohibited. Chlorine used
for disinfection must be neutralized prior to discharge. Reporting is also required in association with this
condition. The permits allows the changes in annual productions to less than 20,000 Ibs/yr with a feeding rate of
less than 5,000 Ibs/mo. exempt the permittee from monitoring requirements 30 days after notification to EPA.
Notification is then required if the production exceeds that level. Nutrient monitoring is required as discussed
above to develop a THDL for the middle Snake River. The permittee may choose to participate in a nutrient
characterization study conducted by the ID fish culturing industry or the monitoring requirements set forth above.
There are specific requirements for developing a monitoring plan and implementation dates set forth for the
characterization study in the permit. If the plan is not approved by 5/1/91, the nutrient monitoring above must be
performed. Other special conditions address the following: (1) requirements that fish mortalities and spawning
wastes not be discharged; (2) prohibition from discharging sweepings of accumulated solids from raceways or ponds;
(3) prohibition for removing or raising dam boards in raceways or ponds to allow the discharge of solids; (4)
prohibition on the rearing of fish in settling or cleaning waste treatment ponds; (5) prohibition from discharging
untreated cleaning wastes; and (6) requirement that cleaning be performed frequently to minimize buildup of solids
and that during cleaning, the release of accumulated buildup of solids is prohibited (cleaning frequency must be
reported). Unless indicated above, a discussion of the need for, or the basis of the special conditions was not
provided.
Effective Date: 11/26/90
Expiration Date: 11/27/95
Abstract Date: 04/04/93
Page: 115
-------
Facility Home: Potlatch Corp, Lewiston Fac. Permit Number: ID0001163
Facility Description: Production of bleached grades of paper board, tissue and market pulp SIC Code: 2611
Monitoring
Limit ELGs UQSs BPJ Only
Basis: I 1 J. I
Storm WQ
Special BHPs Water Sediment Survey
Conditions: J. - J. I
UET WET Testing Multiple Tiered
Limits Only Categories Limits Other
J. - J. - I
Bio
Survey TRES MDLs Monitoring Other
11 1 I L
Abstract Information:
Complete; outfall 001.
Outfall: 001 | Receiving Water: Snake River | Treatment: PC, AS
Amount/Components:
38.6 HGO mill process wastewater
Parameter
2,3,7,8-TCDD
2,3,7,8-TCDF
Al (DS>
Al (TR)
AOX
AS (OS)
As (TR)
BOOS
Chloroform
Chronic WET
Cr+6 (S)
Cu (OS)
Cu (TR)
Flow
Kg (OS)
Hg (TR)
NH3-N
P (T)
Limitations
Monthly
Average
H/A
Report ppq
N/A
Report ppq
N/A
2.500000 mg/l
M/A
2.500000 mg/l
4662.000000 Ib/d
N/A
N/A
2.000000 ug/l
N/A
2.000000 ug/l
22800.000000 Ib/d
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A MGD
N/A
0.350000 ug/l
N/A
0.350000 ug/l
N/A
3.000000 mg/l
N/A
Report mg/l
Dai ly
Maximum
N/A
Report ppq
N/A
Report ppq
N/A
3.500000 mg/l
N/A
3.500000 mg/l
6274.000000 Ib/d
N/A
N/A
2.700000 ug/l
N/A
2.700000 ug/l
43800.000000 Ib/d
N/A
N/A
237.000000 ug/l
38.000000 TUc
N/A
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug\l
N/A
N/A MGD
N/A
0.480000 ug/l
N/A
0.480000 ug/l
N/A
5.400000 mg/l
N/A
Report mg/l
Other
See below
See below
See below
See below
See be low
See below
See below
See below
Monitoring Requirements
Frequency
1/quarter
1/quarter
1/week
1/week
1/week
1/week
1/week
1/day
1 /month
1/quarter
1/week
1/week
1/week
cont i nuous
1/week
1/week
See below
1 /month
Sample Type
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
grab
24hr fw composite
24hr fw composite
24hr fw composite
record
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
Page: 116
-------
acility Name: Potlatch Corp, Lewiston Fac.
Permit Number: ID0001163
Facility Description: Production of bleached grades of paper board, tissue and market pulp
SIC Code: 2611
Pb (DS)
Pb (TR)
pH
Se
Temp.
TSS
Turbidity
Zn (DS)
Zn (TR)
N/A
72.000000 ug/l
N/A
72.000000 ug/l
N/A
N/A
N/A
1.000000 mg/l
N/A
N/A
43400.000000 Ib/d
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
100.000000 ug/l
N/A
100.000000 ug/l
N/A
N/A
N/A
1.400000 mg/l
92.000000 F
N/A
80700.000000 Ib/d
N/A
N/A
N/A
N/A
N/A ug/l
N/A
N/A ug/l
See below
See below
Between 5.0 su and 9
.0 su
See below
See below
1/week
1/week
continuous
1/week
continuous
1/day
1/quarter
1/week
1/week
24hr fw composite
24hr fw composite
Record
24hr fw composite
Record
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
Limitations/Monitoring Basis:
The limitations for BODS and TSS are based on BPT/BCT effluent guidelines at 40 CFR Part 430 Subparts G, H, and S.
For river flows less than 22,000 cfs the BODS limit is based on WQ considerations, with monthly average limits for
BODS determined based on the flow in the Snake River at the diffuser, using a weighted average of the daily average
limitations and production basis of 1624 tons/day. AOX limits are based on BPJ consistent with similar limits being
established in OR and WA for bleached pulp and paper mills. The limit for 2,3,7,8-TCDD is based on the established
THDL. A compliance schedule to meet 2,3,7,8-TCDD limits of 0.39 mg/day annual average and 0.83 mg/day daily maximum
by September 30, 1992 is included. Limits and/or monitoring for Hg, Al, As, Se, Pb, Cro+, Cu, and Zn are based on
the potential for exceedance of UQSs. The Hg and As limits may be met by complying with the limits stated above or
by not exceeding the concentration in the intake water, whichever is greater. The permit has a reopener clause that
states that after the first year of monitoring for metals, the permit may be reopened to decrease the frequency of
monitoring and/or to establish limits. Phosphorous is being monitored due to problems with algal blooms. Acute and
chronic toxicity are required to be monitored and a TIE/TRE performed if limits are exceeded. NH3 is limited based
on WQ considerations. The monitoring frequency is increased to daily when ammonia is added to the treatment system.
The temp, limit is based on WQ. The temperature limit will not be applicable when the temperature of the Snake
River 200 feet upstream is equal to or greater than 67.5 degrees F for the previous day. A limit for heat is
applicable, determined by multiplying the flow in the receiving stream by 593,000 BTU/cfs day. Compliance is
determined by subtracting the temperature of the discharge from the temperature of the receiving stream. The pH
limit is based on WQ considerations. The permittee is required to report tons/day production.
Special Conditions Basis:
Chemical agents containing pentachlorophenol, trichlorophenol and zinc are prohibited based on BAT guidelines in 40
CFR 430. The permit requires the development of chlorinated organics control and monitoring program that includes
process modifications and reduction of 2,3,7,8-TCDD, 2,3,7,8-TCDF and AOX in discharges. A dilution study plan to
determine the size, configuration and dilution within the zone of initial dilution is required because the diffuser
is not located perpendicular to the river flow as assumed by State criteria. The permit may be reopened based on
the results. A BMP plan must be developed and maintained to address and prevent or minimize the potential for the
release of toxics. Any changes to the plan must be submitted to the DMR and may cause the permit to be reopened.
Compliance with the 2,3,7,8-TCDD loading limit will be determined by direct measurement of the mass discharge rate
in the bleach plant effluent. Values of non-detect will be computed as 1/2 the detection value. If removal of
dioxin (or another isomer or congener of dioxin or furan) in the treatment sstem can be demonstrated, compliance may
be measured using the removal efficiency. Discharge to ground water is prohibited by the permit based on known
leakage from the secondary treatment systems to the receiving stream. A seepage reduction/control program is
required to be developed and implemented. A characterization study of the wastes in any surface impoundment is also
required. Quarterly effluent monitoring resin acids, fatty acids, chlorophenol, guaiacols, catechols, and other
miscellaneous organics is required. If after one year, the compounds are not detected, monitoring may be
discontinued. Amounts of types of slimicides used at the facilityare required to be reported annually. A receiving
stream study must be performed to monitor: 1) metals (monthly); 2) turbidity (quarterly); and 3) DO, travel
time/velocity, temperature, pH, nutrients and BODS (weekly forthree months). After three years, the permit may be
reopened to reduce the frequency of monitoring, change parameters and/or sampling locations. A study must be
performed for monitoring sediments annually for all cogeners of TCDD and TCDF, extractable organic halogens, TOC,
PAH, metals, and volatile sulfides. A bioaccumulation study must be performed to determine the impact of the
discharge on three most affected species. Monitoring must be performed annually for all cogeners of TCDD and TCDF
and percent lipid.
Effective Date:
04/07/92
Expiration Date:
04/07/97
Abstract Date:
04/04/93
Page: 117
-------
Facility Homo: Del Monte Corp., Franklin, ID
Permit Number: ID0001180
Facility Description: Prepares, processes and cans green beans
SIC Code: 2032
Limit
Basis:
ELGs
I
UQSS
I
BPJ
Monitoring
Only
WET
Limits
WET Testing
Only
Multiple
Categories
Tiered
Limits
Other
Special
Conditions:
BMPs
Storm
Water
Sediment
WQ
Survey
Bio
Survey
TRES
MDLs
Monitoring
Other
I
Abstract Information:
Complete; Outfall 001.
Outfall: 001 | Receiving Water: Cub River
Treatment: Scr+AL+AnL+clis
Amount/Components:
.0525 mgd flow from washing, processing, cooling water, storm water and sanitation.
Parameter
BOOS
DO
FC
Flow
PH
TSS
Limitations
Monthly
Average
523.000000 Ib/d
H/A
H/A
N/A
M/A
200.000000
H/A
Report MGD
N/A
N/A
705.000000 Ib/d
N/A
Dai ly
Maximum
729.000000 Ib/d
N/A
N/A
N/A
N/A
N/A
N/A
Report MGD
N/A
N/A
1366.000000 Ib/d
N/A
Other
5 mg/l daily min
Units: No./lOO ml
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
2/week
2/week
2/day
1/week
2/week
Sample Type
24hr fw composite
grab
instantaneous
grab
24hr fw composite
imitations/Monitoring Basis:
Limitations for BOOS, TSS and pH are ELG-based upon the existing permit limits and best conventional pollutant
control technology consistent with BCT for the fruit, vegetable and specialties segment of the canned and preserved
fruits and vegetables point source category (40 CFR Part 407). Fecal coliform and D^O. limits are based on ID water
quality standards and current permit limits. Monitoring required in the permits is necessary to demonstrate
compliance with the effluent limits and to assure WQS are being met. Frequencies are based on the size and type of
plant, reflecting the minimum sampling required to monitor plant performance. Sample types are based on the
potential for effluent variability. Monitoring frequencies are retained from the previous permit.
pccial Conditions Basis:
The permit contains a special condition requiring that the facility develop and implement a sludge/solid waste
disposal program within 6 months. This program must be approved by the State and be submitted to EPA. The
requirements were established based on ID State water quality standards which prohibit storage of deleterious
materials adjacent to or in the immediate vicinity of State waters unless adequate controls are provided to ensure
that the materials will not enter State waters as a result of runoff, wind, storage, failure, accidents, third party
activities, etc. The facility stores sludges removed from their lagoons and snippings and branches from the process
in piles within close proximity to the water.
ffective Date: 01/08/93
Expiration Date: 01/08/98
Abstract Date: 04/05/93
Page: 118
-------
Facility Name: Univ.of Idaho Irrig. Lagoons
Permit Number: ID0027154
Facility Description: Aquaculture research facility
SIC Code: 8221
Limit
Basis:
ELGs
WQSs
1
BPJ
Monitoring
Only
J.
WET
Limits
WET Testing
Only
J.
Multiple
Categories
Tiered
Limits
Other
Special
Conditions:
BMPs
Storm
Water
Sediment
WQ
Survey
J.
Bio
Survey
TRES
MDLs
Monitoring
I
Other
J.
Abstract Information:
Complete; Outfall 001.
Outfall: 001
Receiving Water: Paradise Creek
Treatment: Dis
Amount/Components:
125 gpm of aquaculture wastewater.
Parameter
BODS
DO
FC
Flow
Formaldehyde
NH3 (T)
N03
P (T)
SS
TRC
Limitations
Monthly
Average
N/A
Report mg/l
N/A
N/A
N/A
100.000000
N/A
Report MGD
N/A
N/A
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
N/A
N/A
Report ml/I
N/A
N/A
Daily
Maximum
N/A
Report
mg/l
N/A
N/A
N/A
N/A
N/A
Report
MGD
3.700000
2.000000
Ib/d
mg/l
N/A
Report
N/A
Report
N/A
Report
mg/l
mg/l
mg/l
N/A
N/A
N/A
Report
ml/I
N/A
N/A
Other
8.0 mg/l daily min.
#/100 ml;200/100 ml
wk av
first year only
first year only
first year only
Report min/max. I.e.
See below
Monitoring Requirements
Frequency
2/month
2/month
2/month
weekly
1/week
2/month
2/month
2/month
2/week
2/month
1/week
Sample Type
24hr fw composite
grab
grab
record
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
24hr fw composite
grab
Limitations/Monitoring Basis:
Limits for DO were based on water quality concerns of the receiving water at the WA State border. WA State tests
performed in June 1991 showed DO levels of less than 5 mg/l. Formaldehyde is present due to ectoparasitic and
fungal treatment. The limit is BPJ based on known toxicity data and the maximum discharge concentration from the
facility for 1991. Additional instream studies will be required to assess the impact of the pollutant on the
receiving stream. Fecal coliform limits are based on ID State standards for secondary contact recreation. The TRC
limit requires that the discharge contain a concentration below that of the detection limit for the DPD method of
analysis. This limit is based on the ID State water quality standard of 0.011 mg/l and negotiations with the
facility. The parameters NH3(T), N)3, and P(T) are only required to be monitored during the first year of the
permit. Short-term, whole effluent testing for chronic toxicity is being required and is discussed in the special
conditions section below. Monitoring frequencies are based on the minimum sampling required to adequately monitor
facility performance. Monitoring activities are required to be performed on the same day that the nearby POTU
(Moscow Wastewater Treatment Facility) conducts their effluent discharge monitoring. A justification of this
requirement was not provided.
Special Conditions Basis:
The permit limits the use of drugs, medications, disinfectants, and disease control chemicals to: those approved
for hatchery use by USFDA or EPA; those exempt from registration for fishing use; or those declared generally safe
by USDA. Products must be used in accordance with the permitted uses and applications specified by the
manufacturer. Discharge of these drugs, chemicals or medications in toxic amounts are prohibited. An instream
monitoring plan to address the close proximity of other discharges is also required to be developed and submitted
within 60 days. For the first year of the permit, upstream and downstream monitoring is required as follows: 1)
Page: 119
-------
Facility Name: Univ.of Idaho Irrig. Lagoons Permit Number: ID0027154
Facility Description: Aquaculture research facility SIC Code; 8221
for each effluent formaldehyde sample taken, upstream and downstream samples will be taken and analyzed for
formaldehyde; and 2) for each effluent ammonia sample taken, upstream and downstream samples will be taken and
analyzed for pH and temperature. Stream flow at the time of sampling is also required to be reported. Two chronic
toxicity tests are required to be performed within 90 days of permit issuance using two species in acordance with
EPA protocols. The permit may be reopened if the results of the tests show a need for additional biomonitoring or
the need for a toxicity limit. Unless indicated above, a discussion of the need for or basisof the special
conditions was not provided.
Effective Date: 06/16/92 Expiration Date: 06/16/97 Abstract Date: 04/04/93
Page: 120
-------
Facility Name:
Quantum-USI Division
, Tuscola
Permit Number: IL0000141
Facility Description: Organic chemical manufacturer
Limit
Basis:
Special
Conditions:
ELGs WQSs
I I
Storm
BMPs Water
BP,
Sediment
Monitoring
Only
WQ
Survey
WET
Limits
Bio
Survey
WET Testing Multiple
Only Categories
J. z.
TRES MDLs
1 -
SIC Code: 2821
Tiered
Limits
Monitoring
Other
Other
Abstract Information:
Complete: 001
Outfall: 001
| Receiving Water:
Kaskaskia River
Amount/Components :
Maximum of 7.2 mgd of process waste, cooling
and storm water.
Parameter
1,1,1-Trichloroet
hane
1,1,2-Trichloroet
hane
1,1-Dichloroethan
e
1,1-Dichloroethyl
ene
1,2,4-Trichlorobe
nzene
1,2-Dichl orobenze
ne
1,2-Dichloroethan
e
1,2-Dichloropropa
ne
1,2-Trans-Dichlor
oethylene
1,3-Dichlorobenze
ne
1,4-Dichlorobenze
ne
2,4-Dichloropheno
I
2,4-Dimethylpheno
2,4-Dinitrophenol
2,4-Dinitrotoluen
e
2,6-Dinitrotoluen
e
2-Chlorophenol
2-Nitrophenol
| Treatment: Unspecified
tower and boiler blowdown, ion exchange regenerant waste, sanitary waste.
Limitations
Monthly
Average
0.319000 Ib/d
0.021000 mg/l
0.319000 Ib/d
0.021000 mg/l
0.334000 Ib/d
0.022000 mg/l
0.243000 Ib/d
0.016000 mg/l
1.032000 Ib/d
0.068000 mg/l
1.169000 Ib/d
0.077000 mg/l
1.032000 Ib/d
0.068000 mg/l
2.322000 Ib/d
0.153000 mg/l
0.319000 Ib/d
0.021000 mg/l
0.471000 Ib/d
0.031000 mg/l
0.228000 Ib/d
0.015000 mg/l
0.592000 Ib/d
0.039000 mg/l
0.273000 Ib/d
0.018000 mg/l
1.078000 Ib/d
0.071000 mg/l
1.715000 Ib/d
0.113000 mg/l
3.871000 Ib/d
0.255000 mg/l
0.471000 Ib/d
0.031000 mg/l
0.622000 Ib/d
0.041000 mg/l
Daily
Maximum
0.820000 Ib/d
0.054000 mg/l
0.820000 Ib/d
0.054000 mg/l
0.896000 Ib/d
0.059000 mg/l
0.379000 Ib/d
0.025000 mg/l
2.125000 Ib/d
0.140000 mg/l
2.474000 Ib/d
0.163000 mg/l
3.203000 Ib/d
0.211000 mg/l
3.491000 Ib/d
0.230000 mg/l
0.820000 Ib/d
0.054000 mg/l
0.668000 Ib/d
0.044000 mg/l
0.425000 Ib/d
0.028000 mg/l
1.700000 Ib/d
0.112000 mg/l
0.546000 Ib/d
0.036000 mg/l
1.867000 Ib/d
0.123000 mg/l
4.326000 Ib/d
0.285000 mg/l
9.730000 Ib/d
0.641000 mg/l
1.488000 Ib/d
0.098000 mg/l
1.047000 Ib/d
0.069000 mg/l
Other
Monitoring Requirements
Frequency
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
Sample Type
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
Page: 121
-------
FacfUty Name: Quantum-USI Division, Tuscola Permit Number: IL0000141
:acflity Description: Organic chemical manufacturer SIC Code: 2821
3,4-Bcnzofluorant
hcnc
4,6-Dinitro-o-crc
sol
4-Hitrophcnol
Accnaphthcnc
Accnaphthylcnc
Acrylonitrilc
Anthracene
B
Ba (T)
Benzene
Benzo (a) anthrac
ertc
Benzo (a) pyrcnc
Benzo (k) fluoran
thane
Bis (2-ethylhexyl
) phtholatc
BODS
Carbon tetrachlor
ido
Cd (T)
Chloride
Chlorobcnzcnc
Chlorocthane
Chloroform
Chryscno
CH (T)
Cr (T)
CU (T)
0.349000 Ib/d
0.023000 mg/l
1.184000 Ib/d
0.078000 mg/l
1.093000 Ib/d
0.072000 mg/l
0.334000 Ib/d
0.022000 mg/l
0.334000 Ib/d
0.022000 mg/l
1.457000 Ib/d
0.096000 mg/l
0.334000 Ib/d
0.022000 mg/l
H/A
N/A
N/A
H/A
0.562000 Ib/d
0.037000 mg/l
0.334000 Ib/d
0.022000 mg/l
0.349000 Ib/d
0.023000 mg/l
0.334000 Ib/d
0.022000 mg/l
1.563000 Ib/d
0.103000 mg/l
479.850000 Ib/d
20.000000 mg/l
0.273000 Ib/d
0.018000 mg/l
0.192000 Ib/d
0.004000 mg/l
N/A
N/A
0.228000 Ib/d
0.015000 mg/l
1.590000 Ib/d
0.104000 mg/l
0.319000 Ib/d
0.021000 mg/l
0.334000 Ib/d
0.022000 mg/l
0.563000 Ib/d
0.012000 mg/l
16.697000 Ib/d
1.000000 mg/l
2.979000 Ib/d
0.062000 mg/l
0.926000 Ib/d
0.061000 mg/l
4.205000 Ib/d
0.277000 mg/l
1 .882000 Ib/d
0.124000 mg/l
0.896000 Ib/d
0.059000 mg/l
0.896000 Ib/d
0.059000 mg/l
3.673000 Ib/d
0.242000 mg/l
0.896000 Ib/d
0.059000 mg/l
118.400000 Ib/d
1.970000 mg/l
670.500000 Ib/d
11.140000 mg/l
2.064000 Ib/d
0.136000 mg/l
0.896000 Ib/d
0.059000 mg/l
0.926000 Ib/d
0.061000 mg/l
0.896000 Ib/d
0.059000 mg/l
4.235000 Ib/d
0.279000 mg/l
1242.000000 Ib/d
40.000000 mg/l
0.577000 Ib/d
0.038000 mg/l
4.145000 Ib/d
0.069000 mg/l
N/A
N/A
0.425000 Ib/d
0.028000 mg/l
4.068000 Ib/d
0.268000 mg/l
0.698000 Ib/d
0.046000 mg/l
0.896000 Ib/d
0.059000 mg/l
2.978000 Ib/d
0.050000 mg/l
42.045000 Ib/d
2.000000 mg/l
6.053000 Ib/d
0.101000 mg/l
See below
See below
See below
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1 /month
1 /month
1 /month
1/year
1/year
1/year
1/year
1/week
1/year
1/week
1/day
1/year
1/year
1/year
1/year
1 /month
1/week
1/week
grab
grab
grab
grab
grab
grab
grab
composite
composite
grab
grab
grab
grab
grab
composite
grab
composite
grab
grab
grab
grab
grab
composite
composite
composite
Page: 122
-------
Facility Name: Quantum-USI Division, Tuscola Permit Number: IL0000141
Facility Description: Organic chemical manufacturer SIC Code: 2821
Di-n-butyl phthal
ate
Di ethyl phthalate
Dimethyl phthalat
e
Ethylbenzene
FC
Fl
Flow
Fluoranthene
Fluorene
Hexach lorobenzene
Hexach I orobutadi e
ne
Hexach I oroethane
Methyl chloride
Methylene chlorid
e
Naphthalene
Ni (T)
Nitrobenzene
O&G
Other
Pb (T)
pH
Phenanthrene
Phenol
Pyrene
SOS
0.410000 Ib/d
0.027000 mg/l
1.229000 Ib/d
0.081000 mg/l
0.288000 Ib/d
0.019000 mg/l
0.486000 Ib/d
0.032000 mg/l
N/A
N/A
N/A
N/A
N/A
Report mgd
0.379000 Ib/d
0.025000 mg/l
0.334000 Ib/d
0.022000 mg/l
0.228000 Ib/d
0.015000 mg/l
0.304000 Ib/d
0.020000 mg/l
0.319000 Ib/d
0.021000 mg/l
1 .305000 Ib/d
0.086000 mg/l
0.607000 Ib/d
0.040000 mg/l
0.334000 Ib/d
0.022000 mg/l
25.650000 Ib/d
1.000000 mg/l
0.410000 Ib/d
0.027000 mg/l
722.000000 Ib/d
15.000000 mg/l
0.440000 Ib/d
0.029000 mg/l
4.857000 Ib/d
N/A
N/A
Report
0.334000 Ib/d
0.022000 mg/l
0.228000 Ib/d
0.015000 mg/l
0.379000 Ib/d
0.025000 mg/l
N/A
N/A
0.865000 Ib/d
0.057000 mg/l
3.081000 Ib/d
0.203000 mg/l
0.713000 Ib/d
0.047000 mg/l
1.639000 Ib/d
0.108000 mg/l
N/A
400.000000
167.000000 Ib/d
2.780000 mg/l
N/A
Report mgd
1.032000 Ib/d
0.068000 mg/l
0.896000 Ib/d
0.059000 mg/l
0.425000 Ib/d
0.028000 mg/l
0.744000 Ib/d
0.049000 mg/l
0.820000 Ib/d
0.054000 mg/l
2.884000 Ib/d
0.190000 mg/l
1.351000 Ib/d
0.089000 mg/l
0.896000 Ib/d
0.059000 mg/l
60.410000 Ib/d
2.000000 mg/l
1.032000 Ib/d
0.068000 mg/l
1805.000000 Ib/d
30.000000 mg/l
0.668000 Ib/d
0 . 044000 mg/ 1
10.473000 Ib/d
0.181000 mg/l
N/A
Report
0.896000 Ib/d
0.059000 mg/l
0.395000 Ib/d
0.026000 mg/l
1.017000 Ib/d
0.067000 mg/l
N/A
N/A
units:#/100 ml
fluoride, see below
1,3-dichloropropylen
e
Between 6.0 su and 9
.0 su
See below
1/year
1/year
1/year
1 /month
1/week
1 /month
continuous
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1 /month ,
1/year
1/year
1/week
1/year
1 /month
1/week
1/year
1/year
1/year
1/day
grab
grab
grab
grab
grab
composite
24hr total
grab
grab
grab
grab
grab
grab
grab •
grab
composite
grab
single grab
grab
composite
grab
grab
grab
grab
grab
Page: 123
-------
Facility Name: Quantum-USI Division, Tuscota . Permit Number: IL0000141
Facility Description: Organic chemical manufacturer SIC Code: 2821
IDS
Tetrachloroethyle
no
Toluene
Trichloroethylene
TSS
Vinyl chloride
2n (T)
N/A
H/A
0.334000 Ib/d
0.022000 mg/l
0.395000 Ib/d
0.026000 mg/l
0.319000 Ib/d
0.021000 mg/l
760.660000 Ib/d
25.000000 mg/l
1.579000 Ib/d
0.104000 mg/l
15.930000 Ib/d
1.000000 mg/l
H/A
N/A
0.850000 Ib/d
0.056000 mg/l
1.214000 Ib/d
0.080000 mg/l
0.820000 Ib/d
0.054000 mg/l
2315.240000 Ib/d
50.000000 mg/l
4.068000 Ib/d
0.268000 mg/l
39.620000 Ib/d
2.000000 mg/l
See below
1/day
1/year
1 /month
1/year
1/week
1/year
1/year
grab
grab
grab
grab
composite
grab
composite
Limitations/Monitoring Basis: . . . , „„_ ,
Limits are based on previous permit, UQS, and ELG 40 CFR Part 414, OCPSF. The above effluent limits for BODS and
TSS apply only when the discharge dilution is 5:1 or greater. If the dilution rate is less, the BODS monthly
average loading is 479.85 Ib/d and concentration is 10 mg/l; the BOD5 daily maximum loading is 1242.17 Ib/d and
concentration is 20 mg/l; the TSS monthly average loading is 577.5 Ib/d and concentration is 12 mg/l; and the TSS
daily maximum loading is 1444 Ib/d and concentration is 24 mg/l. The effluent limits for TDS, sulfate, and
chlorides shall be determined on a daily basis (equations are provided) based on flow rates.
Special Conditions Basis: ,.,.., „ „ _, ,- **.
Daily max. fecal coliform count should not exceed 400 per 100 ml. The permit may be modified for Ba, B and F after
monitoring for one year. Upstream of the discharge point shall be monitored for Cd for one year. A compliance
schedule for the Cd limit is provided. The permit contains a reopener based on the promulgation of an applicable
effluent standard or limitation which contains more stringent limitations. Toxicity testing is required one year
prior to permit renewal. Acute toxicity testing is to be performed with 96 or 48 hour tests following EPA guidance.
THO species and four dilutions must be used as well as 100% effluent. Chronic toxicity testing is also required
using a green alga in a 96 hour test following EPA guidance and using four dilutions.
Effective Date: 04/10/91 Expiration Date: 12/01/95 Abstract Date: 04/27/93
Page: 124
-------
Facility Name: Amoco Chemical Co. - Joliet Permit Number: IL0001643
Facility Description: Polystyrene manufacturer SIC code- 2821
, . . Monitoring WET WET Testing Multiple
Llmlt ELGs WQSs BPJ Only Limits Only Categories
Basis: J- 1 L J. 1 I
Storm UQ Bio
Special BMPs Water Sediment Survey Survey TRES MDLs
Conditions: Z. z - ~ J. 2
Tiered
Limits
Monitoring
Other
Other
J.
Abstract Information:
Partial for outfalls 001, 002 (representative of 003), and 004.
Outfall: 001 Receiving Water: Des Plaines River | Treatment: Sed, AS, API
Amount/Components :
Approximately 1 mgd of treated process water, cooling tower blowdown, utilities bUiwdown, stormwater, and treated
sanitary wastewater.
Parameter
1,1,1-Trichloroet
hane
1,1,2-Trichloroet
hane
1,1-Dichloroethan
e
1,1-Dichloroethyl
ene
1,2,4-Trichlorobe
nzene
1,2-Dichlorobenze
ne
1,2-Dichloroethan
e
1 ,2-Dichloropropa
ne
1,2-Trans-Dichlor
oethylene
1,3-Dichlorobenze
ne
1,3-Trans-Dichlor
opropylene
1,4-Dichlorobenze
ne
2,4-Dichloropheno
2,4-Dimethylpheno
H,4-Dinitrophenol
2,4-Dinitrotoluen
e
2,6-Dinitrotoluen
e
2-Chlorophenol
Limitations
Daily
Average
0.084000 Ib/d
0.021000 mg/l
0.084000 Ib/d
0.021000 mg/l
0.088000 Ib/d
0.022000 mg/l
0.064000 Ib/d
0.016000 mg/l
0.271000 Ib/d
0.068000 mg/l
0.306000 Ib/d
0.077000 mg/l
0.270000 Ib/d
0.068000 mg/l
0.609000 Ib/d
0.153000 mg/l
0.084000 Ib/d
0.021000 mg/l
0.123000 Ib/d
0.031000 mg/l
0.155000 Ib/d
0.029000 mg/l
0.060000 Ib/d
0.015000 mg/l
0.155000 Ib/d
0.039000 mg/l
0.072000 Ib/d
0.018000 mg/l
0.282000 Ib/d
0.071000 mg/l
0.450000 Ib/d
0.113000 mg/l
1.014000 Ib/d
0.255000 mg/l
0.123000 Ib/d
0.031000 mg/l
Daily
Maximum
0.215000 Ib/d
0.054000 mg/l
0.215000 Ib/d
0.054000 mg/l
0.235000 Ib/d
0.059000 mg/l
0.099000 Ib/d
0.025000 mg/l
0.557000 Ib/d
0.140000 mg/l
1.648000 Ib/d
0.163000 mg/l
0.839000 Ib/d
0.211000 mg/l
0.915000 Ib/d
0.230000 mg/l
0.215000 Ib/d
0.054000 mg/l
0.175000 Ib/d
0.044000 Ib/d
0.175000 Ib/d
0.044000 mg/l
0.111000 Ib/d
0.028000 mg/l
0.446000 Ib/d
0.112000 mg/l
0.143000 Ib/d
0.036000 mg/l
0.489000 Ib/d
0.123000 mg/l
1.134000 Ib/d
0.285000 mg/l
2.550000 Ib/d
0.641000 mg/l
0.390000 Ib/d
0.098000 mg/l
Monitoring Requirements
Other Frequency
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
Sample Type
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
Page: 125
-------
Facility Name: Amoco Chemical Co. - Jolfet ?er™* Nuraber: IL0001643
Facility Description: Polystyrene manufacturer '. ,SIC Code: ?8Z1
a-Nitrophenol
3,4-Benzofluorant
hene
4,6-Dfnitro-o-cre
sol
4-Hitrophenol
Acenaphthene
Accnaphthylcne
Acrylonitrile
Acute WET
Anthracene
Benzene
Bcnzo (a) anthrac
cne
Bcnzo (a) pyrcne
Bcnzo (k) f luoran
thane
Bis (2-ethylhcxyl
) phthalate
BOOS
Carbon tetrachlor
ide
Chlorobcnzene
Chloroothono
Chloroform
Chrysene
CM (T)
Cr CTR)
cu CT)
Di-n-butyl phthal
ate
Di ethyl phthalate
0.163000 Ib/d
0.041000 mg/l
0.091000 Ib/d
0.023000 mg/l
0.310000 Ib/d
0.078000 mg/l
0.286000 Ib/d
0.072000 mg/l
0.088000 Ib/d
0.022000 mg/l
0.088000 Ib/d
0.235000 mg/l
0.382000 Ib/d
0.096000 mg/l
H/A
M/A
0.088000 Ib/d
0.022000 mg/l
0.147000 Ib/d
0.037000 mg/l
0.088000 Ib/d
0.022000 mg/l
0.091000 Ib/d
0.023000 mg/l
0.088000 Ib/d
0.022000 mg/l
0.410000 Ib/d
0.103000 mg/l
147.000000 Ib/d
20.000000 mg/l
0.072000 Ib/d
0.018000 mg/l
0.060000 Ib/d
0.015000 mg/l
0.414000 Ib/d
0.104000 mg/l
0.084000 Ib/d
0.021000 mg/l
0.088000 Ib/d
0.022000 mg/l
0.735000 Ib/d
0.100000 mg/l
4.400000 Ib/d
1.000000 mg/l
5.800000 Ib/d
0.500000 mg/l
0.107000 Ib/d
0.027000 mg/l
0.322000 Ib/d
0.081000 mg/l
0.274000 Ib/d
' 0.069000 mg/l
0.243000 Ib/d
0.061000 mg/l
1.102000 Ib/d
0.277000 mg/l
0.493000 Ib/d
0.124000 mg/l
0.235000 Ib/d
0.059000 Ib/d
0.022000 Ib/d
0.059000 mg/l
0.963000 Ib/d
0.242000 mg/l
N/A
1.000000
0.235000 Ib/d
0.059000 mg/l
0.541000 Ib/d
0.136000 mg/l
0.235000 Ib/d
0.059000 mg/l
0.243000 Ib/d
0.061000 mg/l
0.235000 Ib/d
0.059000 mg/l
1.110000 Ib/d
0.279000 mg/l
657.000000 Ib/d
40.000000 mg/l
0.151000 Ib/d
0.038000 mg/l
0.111000 Ib/d
0.028000 mg/l
1.066000 Ib/d
0.268000 mg/l
0.183000 Ib/d
0.046000 mg/l
0.235000 Ib/d
0.059000 mg/l
3.290000 Ib/d
0.200000 mg/l
11.000000 Ib/d
2.000000 mg/l
13.400000 Ib/d
1.000000 mg/l
0.227000 Ib/d
0.057000 mg/l
0.808000 Ib/d
0.203000 mg/l
Units: TUa, see belo
w
1/year '
1/year
1/year
1/year
1/year
1/year
1/year
1 /month
1/year
1/year
1/year
1/year
1/year
1/year
3/week .
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
grab
grab
grab
grab
*-!
grab
grab
grab
composite
grab
grab
grab
grab
grab
grab
composite
grab
grab
grab
grab
grab
composite
composite
composite
grab
grab
Page: 126
-------
Facility Name: Amoco Chemical Co. - Joliet Permit Number: IL0001643
Facility Description: Polystyrene manufacturer SIC Code: Z82''
Dimethyl ph thai at
e
Ethylbenzene
Flow
Fluoranthene
Fluorene
Hexach I orobenzene
Hexachlorobutadie
ne
Hexach loroethane
Methyl chloride
Hethylene chlorid
e
Hn
Naphthalene
NH3-N
Ni (T)
Nitrobenzene
Pb (T)
PH
Phenanthrene
Phenol
Pyrene
Tetrach loroethyl e
ne
TOO
Toluene
Trichloroethylene
TSS
0.076000,, Ib/d
0.019000 mg/l
0.127000 Ib/d
0.032000 mg/l
N/A
Report mgd
0.099000 Ib/d
0.025000 mg/l
0.088000 Ib/d
0.022000 mg/l
0.060000 Ib/d
0.015000 mg/l
0.080000 Ib/d
0.020000 mg/l
0.084000 Ib/d
0.021000 mg/l
0.342000 Ib/d
0.086000 mg/l
0.159000 Ib/d
0.040000 mg/l
7.350000 Ib/d
1.000000 mg/l
0.088000 Ib/d
0.022000 mg/l
N/A
N/A
6.700000 Ib/d
1.000000 mg/l
0.107000 Ib/d
0.027000 mg/l
1.300000 Ib/d
0.200000 mg/l
N/A
N/A
0.088000 Ib/d
0.022000 mg/l
0.060000 Ib/d
0.015000 mg/l
0.099000 Ib/d
0.025000 mg/l
0.088000 Ib/d
0.022000 mg/l
N/A
Report mg/l
0.103000 Ib/d
0.026000 mg/l
0.084000 Ib/d
0.021000 mg/l
184.000000 Ib/d
25.000000 mg/l
0.187000 Ib/d
0.047000 mg/l
0.430000 Ib/d
0.108000 mg/l
N/A
N/A
0.271000 Ib/d
0.068000 mg/l
0.235000 Ib/d
0.059000 mg/l
0.111000 Ib/d
0.028000 mg/l
0.195000 Ib/d
0.049000 mg/l
0.215000 Ib/d
0.054000 mg/l
0.756000 Ib/d
0.190000 mg/l
0.354000 Ib/d
0.089000 mg/l
32.860000 Ib/d
2.000000 mg/l
0.235000 Ib/d
0.059000 mg/l
N/A
N/A
15.800000 Ib/d
2.000000 mg/l
0.271000 Ib/d
0.068000 mg/l
2.700000 Ib/d
0.400000 mg/l
N/A
Report
0.235000 Ib/d
0.059000 mg/l
0.103000 Ib/d
0.026000 mg/l
0.266000 Ib/d
0.067000 mg/l
0.223000 Ib/d
0.056000 mg/l
N/A
N/A
0.318000 Ib/d
0.080000 mg/l
0.215000 Ib/d
0.054000 mg/l
821.500000 Ib/d
50.000000 mg/l
See below
Between 6.0 and 10.0
su
1/year
1/year
1/day
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/week
1/year
5/week
1/year
1/year
1/year
7/week
1/year
1/year
1/year
1/year
7/week
1/year
1/year
7/week
grab
grab
continuous
grab
grab
grab
grab
grab
grab
grab
composite
grab
composite
composite
grab
composite
grab
grab
grab
grab
grab
composite
grab
grab
composite
Page: 127
-------
Facility Name: Amoco Chemical Co. - Jolfet Permit Number: 1L0001643
Facility Description: Polystyrene manufacturer SIC Code: 2821
Vinyl chloride
2n
0.414000 Ib/d
0.104000 mg/l
4.200000 Ib/d
1.000000 mg/l
1.066000 Ib/d
0.268000 mg/l
10.400000 Ib/d
2.000000 mg/l
1/year
1/year
grab
composite
Limitations/Monitoring Basis:
The effluent NH3-N concentration limit is based on the Illinois Pollution Control Board Rules and Regulations,
Chapter 1, Subtitle C, Section 302.407. Because they are more stringent than Federal limits, State promulgated
effluent standard in Subpart 304.120 were used as the basis for BODS and TSS limits. State effluent standards in
Subpart 304.124 were used for Mn, Cr (T), Cu, CM, Pb, Hi, and Zn. Subpart 304.125 was used for pH. The remaining
parameters are ELG-limited based on 40 CFR Part 414.91. Outfall 001 discharge is limited to 1 acute toxicity unit
(TUa) on a daily maximum basis unless the permittee can demonstrate that a higher toxicity limit is warranted. The
1 TUa limit and monthly monitoring requirement becomes effective 4 years from the effective date of the permit. WET
testing is required following an EPA guidance document and using two species: a 48-hour acute Ceriodaphnia bioassay
and a 96-hour acute fathead minnow bioassay. Any test resulting in greater than 50 % mortality to the test organism
(1 TUa) Hill be considered a violation of the WET limit.
Outfall: 002 | Receiving Water: Des Plaines River | Treatment: None.
Amount/Components:
Unspecified amount of stormwater.
Parameter
C8005
Flow
pH
TOC
Limitations
Daily
Average
N/A
20.000000 mg/l
N/A
Report mgd
N/A
Report
N/A
N/A
Daily
Maximum
N/A
40.000000 mg/l
N/A
N/A
N/A
N/A
N/A
Report mg/l
Other
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/week
1/week
1/week
1/week
Sample Type
composite
single reading
grab
composite
Limitations/Monitoring Basis:
State effluent standards in Subparts 304.125 and 304.120 were used for pH and CBOD5, respectively. The basis for
monitoring for TOC was not provided.
Outfall: 004 | Receiving Water: Des Plaines River | Treatment: Unspecified.
Amount/Components :
Unspecified amount of treated sanitary wastewater.
Parameter
CB005
Flow
pH
TSS
Limitations
Daily
Average
5.210000 Ib/d
25.000000 mg/l
N/A
Report mgd
N/A
Report
6.260000 Ib/d
30.000000 mg/l
Daily
Maximum
10.430000 Ib/d
50.000000 mg/l
N/A
N/A
N/A
N/A
12.510000 Ib/d
60.000000 mg/l
Other
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/week
continuous
1/week
1/week
Sample Type
composite
not given
grab
grab
Limitations/Monitoring Basis:
State effluent standards in Subpart 304.120 were used for CBOD5 and TSS. Subparts 304.125 was used for pH.
Special Conditions Basis:
The permit includes a reopener clause based on the promulgation of applicable effluent standards or limitations or
WQSs that are more stringent than the existing permit limits. Because toxicity has been demonstrated in Amoco's'
discharge, a plan for a TRE for Outfall 001 is required within 90 days of the effective date of the permit. After
approval, the TRE is to be completed immediately, incorporating elements described in the permit, and a report of
Page: 128
-------
Facility Name: Amoco Chemical Co. - Joliet
Permit Number: IL0001643
Facility Description: Polystyrene manufacturer
SIC Code: 2821
the findings is to be submitted to the agency within 9 months. If, after the TRE is provided, the toxicity in the
effluent remains greater than 1 TUa, a mixing zone study and a biological survey will be required. For NPDES permit
renewal, the applicant must submit test results of aquatic toxicity screening (chronic and acute WET testing) and
chemical-specific testing following specified EPA methods.
Effective Date: 04/17/92
Expiration Date: 02/01/97
Abstract Date: 06/08/93
Page: 129
-------
Facility Home: 3M-Cordova Permit Number: IL0003140"'
Facility Description: Organic chemicals, plastics, and synthetic fibers manufacturer , ,. SIC Code: 2899
Monitoring
Limit ELGs WQSs BPJ Only
Basis: ; I ^ 1
Storm UQ
Special BHPs Water Sediment Survey
Conditions: 2. - - J.
WET WET Testing Multiple Tiered .. ' „ '
Limits Only Categories ' Limits Other
- j. --•-,-.. i,_:
Bio
Survey TRES MDLs Monitoring Other
I - - - I
Abstract Information:
Complete: Q01A, 001, and 001B. Outfall 001 represents interim limits, outfall 001B was created for abstract purposes
and represents final limits.
Outfall: 001 | Receiving Water: Mississippi River | Treatment: Sed+EQ+AerD+AS
Amount/Components:
Approximately 9.83 mgd of treated process water. . , ,
Parameter
Acute WET
BOOS
CM
FC
Fc (T)
Fl
Flow
Ha
Hn
NH3-H
OSG
PH
Tercp.
TSS
Limitations
Daily
Average
M/A
H/A
1151.000000 Ib/d
20.000000 mg/l
N/A
Report mg/l
N/A
N/A
115.100000 Ib/d
2.000000 mg/l
864.000000 Ib/d
15.000000 mg/l
N/A
Report mgd
N/A
Report mg/l
N/A
Report mg/l
1673.000000 Ib/d
146.000000 mg/l
864.000000 Ib/d
15.000000 mg/l
N/A
N/A
N/A
N/A
1439.000000 Ib/d
25.000000 mg/l
Dai ly
Maximum
N/A
Report
2302.000000 Ib/d
40.000000 mg/l
N/A
Report mg/l
N/A
400.000000
230.200000 Ib/d
4.000000 mg/l
1728.000000 Ib/d
30.000000 mg/l
N/A
N/A
N/A
Report mg/l
N/A
Report mg/l
17532.000000 Ib/d
153.000000 mg/l
1728.000000 Ib/d
30.000000 mg/l
N/A
Report
N/A
N/A
2878.000000 Ib/d
50.000000 rog/l
Other
See below
Units:#/100 ml
Fluoride
Between 6.0 su and 9
.0 su
See below
Monitoring Requirements
Frequency
1 /month
2/week
1 /month
1 /month
1 /month
' 2/week
continuous
1 /month
1 /month
2/week
1/month
2/week
2/week
2/week
Sample Type
not given
composite
composite
grab
composite
composite
not given
composite
composite
composite
grab
grab
single reading
composite
Limitations/Monitoring Basis: ,
State WQ-based limits from Subpart 304 are used for BODS, TSS, pH, FC, fluoride, Fe, and O&G. Monitoring only
limits are continued from the previous permit and include CM, Hg, and Hn because they are not expected to be at
levels of concern. State WQ-based limits from Subpart 302 are used for temperature and NH3-N. Final effluent NH3-N
concentration and load limits are based on an approved mixing zone consisting of 25:1 dilution and encompassing an
area to 1000 feet below Outfall 001. Based on State WQSs, the wastewater discharged must not cause the receiving
stream temperature to increase more than 5 degrees Farenheit. Receiving water temperature maximum monthly limits
arc provided. . . " . .
Page: 130
-------
Facility Name: 3M-Cordova . Permit Number: IL0003140
Facility Description: Organic chemicals, plastics, and synthetic fibers manufacturer SIC Code: 2899
Outfall: 001A I Receiving Water: Internal to Outfall 001 | Treatment: Sed+EQ+AerD+AS
Amount/Components:
Approximately 1.16 mgd of treated process water.
Parameter
Flow
Limitations
dai ly
Average
N/A
Report mgd
Maximum
N/A
N/A
Other
Monitoring Requirements
Frequency
continuous
Sample Type
not given
Limitations/Monitoring Basis:
State UQ- based limits are used for flow.
Outfall: 001B | Receiving Water: Mississippi River | Treatment: Sed+EQ+AerD+AS
Amount/Components :
Approximately 9.83 mgd of treated process water.
Parameter
BODS
CN
FC
Fe (T)
Fl
Flow
Hg
Hn
NH3-N
O&G
PH
Temp.
TSS
Limitations
Daily
Average
1151.000000 Ib/d
20.000000 mg/l
N/A
Report mg/l
N/A
N/A
115.100000 Ib/d
2.000000 mg/l
864.000000 Ib/d
15.000000 mg/l
N/A
Report mgd
N/A
Report mg/l
N/A
Report mg/l
4583.000000 Ib/d
40.000000 mg/l
864.000000 Ib/d
15.000000 mg/l
N/A
N/A
N/A
N/A
1439.000000 Ib/d
25.000000 mg/l
Daily
Maximum
2302.000000 Ib/d
40.000000 mg/l
N/A
Report mg/l
N/A
400.000000
230.200000 Ib/d
4.000000 mg/l
1728.000000 Ib/d
30,000000 mg/l
N/A
N/A
N/A
Report mg/l
N/A
Report mg/l
6875.000000 Ib/d
60.000000 mg/l
1728.000000 Ib/d
30.000000 mg/l
N/A
Report
N/A
N/A
2878.000000 Ib/d
50.000000 mg/l
Other
Units:#/100 ml
Between 6.0 su and 9
.0 su
•
Moni tori ng Requi rements
Frequency
2/week
1 /month
1 /month
2/week
2/week
continuous
1 /month
1 /month
2/week
1 /month
2/week
2/week
2/week
Sample Type
composite
composite
grab
composite
composite
not given
composite
composite
composite
grab
grab
single reading
composite
Limitations/Monitoring Basis:
See limitations/monitoring basis for Outfall 001.
Special Conditions Basis:
The permit contains a reopener clause based on the promulgation of applicable standards or regulations containing
more stringent limitations. A compliance schedule for meeting the NH3-N limitations is provided based on aconcern
for mussels and known problems with aquatic toxicity. Acute toxicity testing on Outfall 001 effluent must be
performed monthly within 30 days of achieving final effluent limits for NH3-N, as provided in the compliance
schedule. Toxicity testing is required following EPA guidance using 2 species, arid 5 dilutions as well as 100%
effluent. For fish, testing must be conducted over a 96-hour period, while a 48-hour period must be used for
Page: 131
-------
Facility Home: 3M-Cordova
Permit Number: IL0003140
Facility Description: Organic chemicals, plastics, and synthetic fibers manufacturer
SIC Code: 2899
invertebrates. These dilutions are to be adjusted as the effluent toxicity becomes known to achieve at least 2
concentrations higher and lower than the expected LC50. While the permit does not require a TIE or TRE.the permit
contains a special condition allowing a permit modification to require these. This special condition operates as a
rcopcnor, and also allows for permit modification to include establishment of numerical limitations based on
toxicity testing results. Chemical specific testing on the Outfall 001A effluent must be performed monthly for 113
priority pollutants, per 40 CFR Part 136 Appendix A, Methods 624 and 625, and for non-priority pollutants using
analytical methods described in the permit. Sample results for the following parameters must be reported to the
permitting authority: Ba, CM, Cu, Fl, fats, O&G, Fe, Pb, Mn, Hg, Hi, Zn, and Co. Cobalt was added because it has
been found in the wastewater treatment plant sludge. The permit contains a reopener allowing for reduction or
discontinuance of these monitoring and reporting requirements. A mussel survey and habitat study must be performed
after 8/1/95 but before the expiration date of the permit, and submitted with the permit renewal application.
Effective Date: 10/31/91
Expiration Date: 06/01/96
Abstract Date: 06/07/93
Page: 132
-------
Facility Name: Marathon Oil - Robinson Permi-t Number. iLOOo4073
Facility Description: Petroleum refinery that manufactures various petroleum products SIC Code: 2911
.... Monitoring UET WET Testing ' Multiple
|j™j*. EkGs W5SS BPJ Only Limits Only Categories
Storm WQ Bio
Special BMPs Water Sediment Survey Survey TRES MDLs
Conditions: ^ -_ - ^ . } /
Tiered
Limits Other
J.
Monitoring Other
J. I
Abstract Information:
Complete; Outfalls 001, 002, and 003
Outfall: 001 Receiving Water: Unnamed trib. to Sugar Creek Treatment: API, DAF, AS, Fil
Amount/Components :
Approximately 1.87 mgd (average) of petroleum manufacturing wastewater from wastewater treatment plant.
Parameter
BODS
Chronic WET
Cl
COD
Cr (T)
Cr+6
Flow
NH3-N
O&G
pH
Phenols
S
TDS
Temp.
TSS
Limitations
Daily
Average
241.000000 Ib/d
10.000000 mg/l
N/A
N/A
N/A
N/A
9204.000000 Ib/d
N/A
10.400000 Ib/d
1.000000 mg/l
0.340000 Ib/d
0.011000 mg/l
N/A
Report mgd
61.200000 Ib/d
2.000000 mg/l
361.000000 Ib/d
15.000000 mg/l
Report
N/A
N/A
N/A
7.000000 Ib/d
N/A
N/A
N/A
Report
N/A
289.000000 Ib/d
12.000000 mg/l
Daily
Maximum
612.000000 Ib/d
20.000000 mg/l
N/A
Report
21425.000000 Ib/d
700.000000 mg/l
17738.000000 Ib/d
N/A
30.300000 Ib/d
2.000000 mg/l
0.490000 Ib/d
0.016000 mg/l
N/A
Report mgd
122.400000 Ib/d
4.000000 mg/l
763.000000 Ib/d
30.000000 mg/l
Report
N/A
3.100000 Ib/d
0.100000 mg/l
15.600000 Ib/d
N/A
91823.000000 Ib/d
3000.000000 mg/l
Report
N/A
735.000000 Ib/d
24.000000 mg/l
Other
See below
See below
See below
See below
See below
See below
See below
Between 6.0 su and 9
.0 su
See below
See below
See below
Monitoring Requirements
Frequency
2/week
1 /month
2/week
2/week
2/week
2/week
1/day
2/week
1/week
2/week
2/week
2/week
2/week
2/week
2/week
Sample Type
24hr composite
not provided
24hr composite
24hr composite
24hr composite
24hr composite
continuous
24hr composite
24hr composite
grab
24hr composite
24hr composite
24hr composite
grab
24hr composite
Limitations/Monitoring Basis:
EXiSuf"91.Pf™1-t 4mits "er?,USed f°r BOD5, TSS, O&G (fats, oil and grease), and Cr (T). State WQS were used to
establish limits for chloride, TDS, NH3-N, phenol, and Cr+6. ELG-based limits using 40 CFR Part 419 Subpart B were
used for COD and S. Chronic toxicity testing is required within 60 days of the effective date of the permit These
limits were based on zero dilution. EPA and State specifications for chronic WET testing are to be followed' The
testing must consist of 7 day larval survival and growth tests performed on the fathead minnow, using 100% effluent
Chronic toxicity testing limits are based on previous testing results. The limit of a NOAEL of not less than 100% "
effluent becomes effective 9/30/95. The maximum temperature increase must not exceed 5 degrees Farenheit
Wastewater discharged from the facility must not alone or in combination with other sources cause the receiving
stream to violate the thermal limitations at the edge of the mixing zone defined by Illinois Administration Code,
Page: 133
-------
Facility Man*: Marathon Oil - Robinson Permit Nurab,er: IL0004073
Facility Description: Petroleum refinery that manufactures various petroleum products SIC Code. 2911
Titlo 35, Chapter 1, Subtitle C. Based on State WQSs, the wastewater discharged must cause the receiving stream
t^rature to increase more than 5 degrees Farenheit. Receiving water temperature maximum monthly limits are
provided. The imit for oil and grease includes fats. Each O&G sample comprising the 24hr composite is to be
Kzed separately and an arithmetic mean calculated. Individual O&G samples forming the composite are limited to
75 K Taken from the existing permit, a storm water credit is allowed in lb/1000 gallons of storm "^^ f°^ COD,
OSG, BOOS, TSS, Cr CT>, Cr+6, and phenolic compounds. However, the permittee is prohibited from discharging more
than 918 tb of fats, O&G (time period is not specified). The NH3-N limit shown applies April through October. The
November through March limits are 70.4 mg/l monthly average and 140.8 mg/l daily maximum.
Outfall: 002 | Receiving Water: Unnamed trib. to Sugar Creek Treatment: none
Amount/Components:
Unspecified amount of contaminated storm water.
Parameter
Benzene
BOOS
COO
Cr
Cr+6
Ethylbcnzcno
Flow
NH3-H
OSG
PAHs
PH
Phenols
Toluene
TSS
Limitations
Average
M/A
N/A
Report Ib/d
10.000000 mg/l
Report Ib/d
N/A
Report Ib/d
1.000000 mg/l
Report Ib/d
0.011000 mg/l
N/A
N/A
N/A
Report mgd
Report
N/A
Report Ib/d
15.000000 mg/l
N/A
N/A
N/A
Report
Report Ib/d
N/A
N/A
N/A
Report Ib/d
12.000000 mg/l
Maximum
N/A
Report mg/l
Report Ib/d
20.000000 mg/l
Report Ib/d
N/A
Report Ib/d
2.000000 mg/l
Report Ib/d
0.016000 mg/l
N/A
Report mg/l
N/A
Report mgd
Report
N/A
Report Ib/d
30.000000 mg/l
N/A
Report mg/l
N/A
Report
Report Ib/d
0.100000 mg/l
N/A
Report mg/l
Report Ib/d
24.000000 mg/l
Other
See below
See below
See below
See below
See below
See below
Units not provided
See below
See below
Between 6.0 su and 9
.0 su
See below
See below
See below
Monitoring Requirements
Frequency
2/year
1/day
1/day
1/day
1/day
2/year
continuous
1/day
1/day
2/year
1/day
1/day
2/year
1/day
Sample Type
24 hr composite
grab
grab
grab
grab
24hr composite
estimate
grab
grab
24hr composite
grab
grab
24hr composite
grab
""^iVeTilHat^s/Lnltoring basis discussion for Outfall 001. Any discharge from Outfall 002 is treated as bypass.
See stormwat™ credit allowances described under Outfall 001. Samples to be tested for PAHs, benzene, toluene, and
othylbcnzene are to be taken from 2 distinct precipitation events if 2 such discharges occur during a calendar year.
Acceptable detection limits are provided in the permit. The basis for this testing was not discussed.
Page: 134
-------
Facility Name: Marathon Oil - Robinson . . Perm! t Number: I L0004073
Facility Description: Petroleum refinery that manufactures various petroleum products SIC Code: 2911
Outfall: 003 Receiving Water: Unnamed trib. to Sugar Creek | Treatment: none
Amount/Components: ...... . ...
Unspecified amount of uncontaminated storm water. .
Parameter
Chloride
GOD
Cr (T)
Cr+6
Flow
NH3-N
O&G
PH
Phenols
S
TDS
TOC
TSS
. Limitations
Daily
Average
N/A
N/A
N/A
Report mg/l
N/A
1.000000 mg/l
N/A
0.011000 mg/l
N/A
Report mgd
N/A
2.000000 mg/l
N/A
15.000000 mg/l
N/A
Report
N/A
N/A
N/A
.Report mg/l
N/A
N/A
N/A ,
N/A
N/A
35.000000 mg/l
Daily
Maximum
N/A
550.000000 mg/l
N/A
Report mg/l
N/A
2.000000 mg/l
N/A
0.016000 mg/l
N/A
Report mgd
N/A
4.000000 mg/l
N/A
30.000000 mg/l
N/A
Report
N/A
0.100000 mg/l
N/A
Report mg/l
N/A
2000.000000 mg/l
N/A
110.000000 mg/l
N/A
70.000000 mg/l
Other
April-October
...
Between 6.0 su and 9
.•0 su
Monitoring Requirements
Frequency
2/year
2/year
1/day
1/day
continuous
' 1/day
1/day
1/day
1/day
H/year
2/year
1/day
2/yean
Sample Type
24hr composite
24hr composite
24hr composite
24hr composite
estimate
24hr composite
math, composite
grab
24hr composite
24hr composite
24hr composite
24hr composite
24hr comp
m See limitations/monitoring basis discussion for Outfall 001 except no ELGs. Also, TOC based on BPJ using ELG 40 CFR
Subpart 419 for discharge of contaminated storm water without treatment. TSS limits taken from 2/3/89 Industrial
Unit memorandum on TSS limits for stormwater discharges. The NH3-N limit applies April through October. The
November through March NH3-N limits are 2.3 mg/l monthly average and 4.6 daily maximum.
PeC1A compliance8 schedule is provided for achieving the WET effluent limit. A plan for conducting a TRE must be
submitted to the permitting authority by 3/1/93. The plan is to be implemented and a report submitted by 12/1/93.
Actions are to be. taken based on the findings of the report; the effluent limit becomes effective on 9/30/95.
Effective Date: 10/30/92 Expiration Date: 10/30/97 Abstract Date: 04/26/93
Page: 135
-------
Facility Name: General Electric - Ht. Vernon Permit Number: IN0002101
Facility Description: Organic chemical and synthetic manufacturer SIC Code: 2869
Limit ELGs WQSs
Basis: j_ I
Storm
Special BMPs Water
Conditions: ^ ^
Monitoring WET WET Testing Multiple Tiered
BPJ Only Limits Only Categories Limits Other
J. 1 r. I - - I
WQ Bio
Sediment Survey Survey TRES MDLs Monitoring Other
---- I - 1 J.
Abstract Information:
Complete: Outfalls 001, 002, 002A (created for abstract purposes), 003, 004, and 005. 002 includes interim limits,
002A includes limits using a diffuser.
Outfall: 001 | Receiving Water:
Ohio River | Treatment: Fil, GAC
Amount/Components:
Only used for emergencies to discharge a process brine stream during failure of Brine Recovery Plant. Estimated flow
would be 1.0 mgd.
Parameter
Chloride
Flow
P«
Phenols
70S
TSS
Limitations
Monthly
Average
Report Ib/d
N/A
M/A
Report MGD
N/A
Report su
Report Ib/d
N/A
Report Ib/d
M/A
Report Ib/d
M/A
Daily
Maximum
Report Ib/d
N/A
N/A
Report MGD
N/A
Report su
Report Ib/d
N/A
Report Ib/d
N/A
Report Ib/d
N/A
Limitations/Monitoring Basis:
Monitoring only is required for
the Brine Recovery Plant,
Outfall: 002 | Receiving Water:
Other
Monitoring Requirements
Frequency
1/day
1/day
1/day
1/day
1/day
1/day
Sample Type
grab
24 hr total
grab
grab
grab
grab
all parameters. Discharge from 001 is only authorized in the event of failure of
Ohio River | Treatment: AS, Neut, Scr, Fil
Amount/Components :
Approximately 6.60 mgd of discharge from wastewater treatment plant including boiler blowdown, stormwater and process
and sanitary wastcwator.
Parameter
1,1,1-Trichloroet
hone
1,1,2-Trichloroct
hane
1,1-Dichlorocthan
e
1,1-Dichloroethyl
one
1,3,4-THchlorobe
nzono
1,2-Dichlorobcnze
rve
Limitations
Monthly
Average
1.110000 Ib/d
M/A
1.110000 Ib/d
H/A
1.170000 Ib/d
M/A
0.850000 Ib/d
N/A
3.610000 Ib/d
N/A
4.080000 Ib/d
H/A
Daily
Maximum
2.860000 Ib/d
N/A
2.860000 Ib/d
N/A
3.130000 Ib/d
N/A
1.330000 Ib/d
N/A
7.430000 Ib/d
N/A
8.650000 Ib/d
N/A
Other
Monitoring Requirements
Frequency
1/year
1/year
1/year
1/year
1/year
1 /month
Sample Type
grab
grab
grab
grab
24hr composite
grab
Page: 136
-------
Facility Name: General Electric - Mt. Vernon Perml-t Humber; IN00021Q1
Facility Description: Organic chemical and synthetic manufacturer slc Code. 2869
e
1,2-Dichloropropa
ne
1,H-Trans-Dichlor
oethylene
1,3-Cis-Dichlorop
ropylene
1,3-Dichlorobenze
ne
1,4-Dichlorobenze
ne
2,2-Bis (4-hydrox
y-phenyl) pro
2,4-Dichloropheno
2,4-Dimethylpheno
2,4-Dinitrophenol
2,4-Dinitrotoluen
e
2,6-Dinitrotoluen
e
2-Chlorophenol
2-Nitrophenol
3,4-Benzof luorant
hene
4,6-Dinitro-o-cre
sol
4-Nitrophenol
Acenaphthene
Acenaphthylene
Acrylonitrile
Acute WET
Ag
Anthracene
Benzene
Benzo (a) anthrac
ene
3.610000 Ib/d
N/A
8.120000 Ib/d
N/A
1.110000 Ib/d
N/A
1.540000 Ib/d
N/A
1.640000 Ib/d
N/A
0.800000 Ib/d
N/A
11.800000 Ib/d
200.400000 ug/l
2.070000 Ib/d
N/A
0.960000 Ib/d
N/A
1.570000 Ib/d
26.600000 ug/l
5.990000 Ib/d
N/A
13.530000 Ib/d
N/A
1 .640000 Ib/d
N/A
2.180000 Ib/d
N/A
1.220000 Ib/d
N/A
4.140000 Ib/d
N/A
3.820000 Ib/d
N/A
1.170000 Ib/d
N/A
1.170000 Ib/d
N/A
5.090000 Ib/d
N/A
N/A
N/A
0.180000 Ib/d
3.000000 ug/l
1.170000 Ib/d
N/A
1 .960000 Ib/d
N/A
1.170000 Ib/d
N/A
11.190000 Ib/d
N/A
12.200000 Ib/d
N/A
2.860000 Ib/d
N/A
2.330000 Ib/d
N/A
2.330000 Ib/d
N/A
1 .490000 Ib/d
N/A
27.450000 Ib/d
466.200000 ug/l
5.940000 Ib/d
N/A
1.910000 Ib/d
N/A
3.650000 Ib/d
62.000000 ug/l
15.120000 Ib/d
N/A
34.000000 Ib/d
N/A
5.200000 Ib/d
N/A
3.660000 Ib/d
N/A
3.240000 Ib/d
N/A
14.690000 Ib/d
N/A
6.580000 Ib/d
N/A
3.130000 Ib/d
N/A
3.130000 Ib/d
N/A
12.840000 Ib/d
N/A
N/A
Report
0.410000 Ib/d
7.000000 ug/l
3.130000 Ib/d
N/A
7.210000 Ib/d
N/A
3.130000 Ib/d
N/A
'
See below
1/year
1/year
1/year
1/year
1/year
1/year
1 /month
1 /month
1/year
1 /month
1/year
1/year
1 /month
1 /month
1/year
1 /month
1 /month
1/year
1/year
1/year
2/year
1 /month
1/year
1/year
1/year
grab
grab
grab
grab
grab
grab
24hr composite
24hr composite
24hr composite
24hr composite
24hr composite
24hr composite
grab
24hr composite
24hr composite
24hr composite
24hr composite
24hr composite
24hr composite
grab
24hr composite
24hr composite
24hr composite
grab
24hr composite
Page: 137
-------
Facility Name: General Electric - Mt. Verncn Permlt Number: IN00021°1
Facility Description: Organic chemical and synthetic manufacturer SIC Code, tow
Benzo (d) pyrene
Benzo (k) fluoran
thane
Bis (E-chlorisopr
opyl) other
Bis (2-ethylhexyl
) phthalate
BOOS
Carbon tetrachlor
Ida
Chlorobcnzene
Chloroethanc
Chloroform
Chrysene
CH
COO
Cr (T)
Cu (TR)
Dt-n-butyl phthal
ate
Diethyl phthalate
Dimethyl phthalat
c
Ethylbcnzcne
FC
Flow
Fluoranthcne
Fluorene
Hexach I orobenzene
Hexachlorobutadie
ne
Hexachloroethane
1.220000 Ib/d
N/A
1.170000 Ib/d
N/A
15.960000 Ib/d
N/A
5.460000 Ib/d
N/A
1494.000000 Ib/d
N/A
0.960000 Ib/d
N/A
0.800000 Ib/d
N/A
5.520000 Ib/d
N/A
1.110000 Ib/d
N/A
1.170000 Ib/d
N/A
1.110000 Ib/d
18.900000 ug/l
8714.000000 Ib/d
N/A
13.520000 Ib/d
N/A
1.210000 Ib/d
20.600000 ug/l
1.430000 Ib/d
N/A
4.300000 Ib/d
N/A
1.010000 Ib/d
N/A
1.700000 Ib/d
N/A
N/A
200.000000 No.
N/A
Report HGD
1.330000 Ib/d
N/A
1.170000 Ib/d
N/A
0.310000 Ib/d
5.200000 ug/l
1.060000 Ib/d
N/A
1.110000 Ib/d
N/A
3.240000 Ib/d
N/A
3.130000 Ib/d
N/A
40.150000 Ib/d
N/A
14.800000 Ib/d
N/A
3938.000000 Ib/d
N/A
2.020000 Ib/d
N/A
1.490000 Ib/d
N/A
14.220000 Ib/d
N/A
2.440000 Ib/d
N/A
3.130000 Ib/d
N/A
2.590000 Ib/d
44.000000 ug/l
26143.000000 Ib/d
N/A
33.730000 Ib/d
N/A
2.830000 Ib/d
48.000000 ug/l
3.020000 Ib/d
N/A
10.770000 Ib/d
N/A
2.490000 Ib/d
N/A
5.730000 Ib/d
N/A
N/A
400.000000 No.
N/A
Report HGD
3.610000 Ib/d
N/A
3.130000 Ib/d
N/A
0.710000 Ib/d
12.000000 ug/l
2.600000 Ib/d
N/A
2.860000 Ib/d
N/A
Units: No./lOO ml
1/year
1/year
1/year
1/day
1 /month
1/year
1/year
1 /month
1/year
1 /month
1/day
1 /month
1 /month
1/year
1/year
1/year
1/year
1 /month
1/day
1/year
1/year
1/year
. 1/year
1/year
24hr Composite
grab
24hr composite
24hr composite
grab
grab
grab
grab
24hr composite
24hr composite
24hr composite
24hr composite
24hr composite
24hr composite
24hr composite
24hr composite
grab
grab
24hr total
24hr composite
24hr composite
24hr composite
grab
grab
Page: 138
-------
Facility Name: General Electric - Mt. Vernon Permit Number: IN0002101
Facility Description: Organic chemical and synthetic manufacturer SIC Code: 2869
Methyl chloride
Methylene chlorid
e
Naphthalene
Hi (T)
Nitro-n-methyl ph
thalimide
Nitrobenzene
Pb (T)
PH
Phenanthrene
Phenol
Phenols
Pyrene
Temp.
Tetrach loroethyle
ne
Tetrahydrofuran
TOC
Toluene
TRC
Trichtoroethylene
TSS
Vinyl chloride
Zn CTR)
4.560000 Ib/d
N/A
2.120000 Ib/d
N/A
1.170000 Ib/d
N/A
20.580000 Ib/d
N/A
Report Ib/d
N/A
1.430000 Ib/d
N/A
N/A
N/A
N/A
N/A
1.170000 Ib/d
N/A
0.800000 Ib/d
N/A
41.200000 Ib/d
N/A
1.330000 Ib/d
N/A
N/A
Report C
1.170000 Ib/d
N/A
Report Ib/d
N/A
2750.000000 Ib/d
N/A
1.380000 Ib/d
N/A
N/A
0.020000 mg/l
1.110000 Ib/d
N/A
2358.000000
N/A Ib/d
5.520000 Ib/d
N/A
6.070000 Ib/d
N/A
10.080000 Ib/d
N/A
4.720000 Ib/d
N/A
3.130000 Ib/d
N/A
48.460000 Ib/d
N/A
Report Ib/d
N/A
3.610000 Ib/d
N/A
0.710000 Ib/d
12.000000 ug/l
N/A
N/A
3.130000 Ib/d
N/A
1 .380000 Ib/d
N/A
82.400000 Ib/d
N/A
3.550000 Ib/d
N/A
N/A
Report C
2.970000 Ib/d
N/A
Report Ib/d
N/A
8249.000000 Ib/d
N/A
4.240000 Ib/d
N/A
N/A
0.040000 mg/l
2.860000 Ib/d
N/A
7576.000000 Ib/d
N/A
14.220000 Ib/d
N/A
12.750000 Ib/d
N/A
Between 6.0 su and 9
.0 su
1/year
1/month
1/year
1/month
1/month
1/year
1/year
continuous
1/year
1/month
1/day
1/year
1/day
1/year
1/month
1/day
1/month
1/day
1/year
1/day
1/year
1/month
grab
, grab
24hr composite
24hr composite
24hr composite
24hr composite
24hr composite "
record
24hr composite
24hr composite
24hr composite
24hr composite
grab
grab
24hr composite
24hr composite
grab
grab
grab
24hr composite
grab
24hr composite
Limitations/Monitoring Basis:
All organic limits are ELG-based per 40 CFR, Part 414, OCPSF, except hexachlorobenzene and 2,4-dimtrophenol.
Limitations for hexachlorobenzene, 2,4-dinitrophenol, Cu, CN, and Ag are WQ-based. When a diffuser is used, the
2,4-dinitrophenol limitation is ELG-based. pH, TSS, BOD5, Cr (T), and Ni limitations are ELG-based per 40 CFR Part
414, OCPSF. Limitations for total phenols are BPJ-based and are the same as in the previous permit. Zn,
tetrahydrofuran, and nitro-N-methyl phthalimide limitations are based on the previous permit. Temperature and E-
coli monitoring limitations are WQ-based. The maximum limit for Pb is set equal to the 50th percentile of Pb in the
receiving stream. Cu, Zn, and Ag shall be measured and reported as "total recoverable" until a test method is
approved which measures acid-soluble metal. According to 40 CFR, Part 136.3, Table II, the maximum holding time for
CN is 24 hours when sulfide is present and 14 days when sulfide is absent. CN, therefore, shall be monitored by
Page: 139
-------
Facility Name: General Electric - Mt. Vernon Perrait Number: IN0002101
Facility Description: Organic chemical and synthetic manufacturer SIC Code: 2869
collecting a grab sample and analyzing it within 24 hours. If it can be demonstrated that the wastewater contains
no sulfidc, a composite sample may be collected and analyzed within 14 days. E. Coli limitations and monitoring
requirements apply annually from Apr. 1 through Oct. 31, except when: (a) fecal coliform may be reported instead of
fqc??w ?r j first three ninths. After 3 months, E. Coli must be used. The monthly average limit for E. Coli is
125/100 ml and the daily max. is 235/100 ml; (b) a variance may be requested for fecal coliform monitoring from Nov.
1 through Mar. 31; (c) a variance from the lead limitation may be requested on the basis that naturally occurring Pb
concentrations in the receiving waters prevent the attainment of the standard. The limits for Ag (TR) and 2 2-
BisM-hydroxy-phenyO propane are provided with a compliance schedule for achieving these limits. In the interim
the permittee reports the measurements. Acute WET testing is to be initiated within 90 days as follows: For the'
first 6 months, testing is to be conducted 1/month, a 96hr definitive static renewal LC10 bioassay shall be
conducted using a fathead minnow. A 48hr definitive static removal LC10 bioassy shall be conducted using
Coriodaphnia or Daphnia species. A definitive static renewal LC10 bioassy shall be conducted using a species
representative of the receiving stream's aquatic community from the list in Table 1 of EPA/600/4-85/013 Chemical
sampling must accompany each water sample taken for bioassay analysis. If an effluent diffuser is installed,
testing should include multiple dilutions using receiving stream water from upstream of Outfall 002.
Outfall: 002A | Receiving Water: Ohio River | Treatment: AS, Neut, Scr, Fil
Amount/Components :
Approximately 6.60 mgd of discharge from wastewater treatment plant including boiler blowdown, stormwater, and process
and sanitary wastewater.
Parameter
1,1,1-Trichloroet
hone
1,1,2-THchloroot
hane
1,1-Dichloroethan
e
1,1-Dichloroethyl
ene
1,2,4-THchtorobe
nzcno
1,2-Dichlorobenze
ne
1,2-Dlchlorocthan
e
1,2-Dichloropropa
no
1,2-Trans-Dichlor
oethylenc
1,3-Cis-Dichlorop
ropy 1 ene
1,3-Dichlorobenze
no
1,4-Dichlorobenze
no
2,2-Bis <4-hydrox
y-phcnyl) pro
2,4-Dichlorophcno
2,4-Dimcthylphcno
2,4-Dinitrophenol
Limitations
Monthly
Average
1.110000 Ib/d
H/A
1.110000 Ib/d
H/A
1.170000 Ib/d
N/A
0.850000 Ib/d
H/A
3.610000 Ib/d
H/A
4.080000 Ib/d
H/A
3.610000 Ib/d
H/A
8.120000 Ib/d
H/A
1.110000 Ib/d
N/A
1.540000 Ib/d
H/A
1.640000 Ib/d
N/A
0.800000 Ib/d
H/A
80.820000 Ib/d
1372.600000 ug/l
2.070000 Ib/d
H/A
0.960000 Ib/d
H/A
3.770000 Ib/d
N/A ug/l
Daily
Maximum
2.860000 Ib/d
N/A
2.860000 Ib/d
N/A
3.130000 Ib/d
N/A
1.330000 Ib/d
N/A
7.430000 Ib/d
N/A
8.650000 Ib/d
N/A
11.190000 Ib/d
N/A
12.200000 Ib/d
H/A
2.860000 Ib/d
H/A
2.330000 Ib/d
N/A
2.330000 Ib/d
N/A
1.490000 Ib/d
N/A
188.030000 Ib/d
3193.500000 ug/l
5.940000 Ib/d
N/A
1.910000 Ib/d
H/A
6.520000 Ib/d
N/A ug/l
Other
Monitoring Requirements
Frequency
1/year
1/year
1/year
1/year
1/year
1/month
1/year
1/year
1/year
1/year
1/year
1/year
1/month
1/month
1/year ^
1/month
Sample Type
grab
grab
grab
grab
24hr composite
grab
grab
grab
grab
grab
grab
grab
24hr composite
24hr composite
24hr composite
24hr composite
Page: 140
-------
Facility Name: General Electric - Mt. Vernon Permit "umber: IN0002101
Facility Description: Organic chemical and synthetic manufacturer SIC Code- 2869
2,4-Dinitrotoluen
2,6-pinitrotoluen
2-Chlorophenol
2-Nitrophenol
3,4-Benzofluorant
tiene
4,6-Dinitro-o-cre
sol
4-Ni^rophenol
Acenaphthene
Acenaphthylene
Acrylonitrile
Acute WET
Ag
Anthracene
Benzene
Benzo (a) anthrac
ene
Benzo (k) fluoran
thane
Bis (2-chlorisopr
opyl) ether
Bis (2-ethylhexyl
) phthalate
BODS
Carbon tetrachlor
ide
Chlorobenzene
Chloroethane
Chloroform
Chrysene
CN
5.990000 Ib/d
N/A
13.530000 'lb/d
N/A
1 .640000 lb/d
N/A
2.180000 lb/d
N/A
1.220000 lb/d
N/A
4.140000 'lb/d
N/A
3.820000 lb/d
N/A
1.170000 lb/d
N/A
1.170000 lb/d
N/A
5.090000 lb/d
N/A
N/A
N/A
1.160000 lb/d
19.700000 ug/l
1.170000 lb/d
N/A
1 .960000 lb/d
N/A
1.170000 lb/d
N/A
1.170000 lb/d
N/A
15.960000 lb/d
N/A
5.460000 lb/d
N/A
1494.000000 lb/d
N/A
0.960000 lb/d
N/A
0.800000 lb/d
N/A
5.520000 lb/d
N/A
1.110000 lb/d
N/A
1.170000 lb/d
N/A
5.110000 lb/d
N/A ug/l
15.120000 lb/d
N/A
34.000000 lb/d
N/A
5.200000 lb/d
N/A
3.660000 lb/d
N/A
3.240000 lb/d
N/A
14.690000 lb/d
N/A
6.580000 lb/d
N/A
3.130000 lb/d
N/A
3.130000 lb/d
N/A
12.840000 lb/d
N/A
N/A
Report
2.700000 lb/d
45.800000 ug/l
3.130000 lb/d
N/A
7.210000 lb/d
N/A
3.130000 lb/d
N/A
3.130000 lb/d
N/A
40.150000 lb/d
N/A
14.800000 lb/d
N/A
3938.000000 lb/d
N/A
2.020000 lb/d
N/A
1.490000 lb/d
N/A
14.220000 lb/d
N/A
2.440000 lb/d
N/A
3.130000 lb/d
N/A
14.600000 lb/d
N/A ug/l
- -.
See below
1/year
1/year
1 /month
1 /month
1/year
1 /month
1 /month
1/year
1/year
1/year
2/year
1 /month
1/year
1/year
1/year
1/year
1/year
1/year
1/day
1 /month
1/year
1/year
1 /month
1/year
1 /month
24hr composite
24hr composite
grab
24hr composite
24hr composite
24hr composite
24hr composite
24hr composite
24hr composite
grab
24hr composite
24hr composite
24hr composite
grab
24hr composite
24hr composite
grab
24hr composite
24hr composite
grab
grab
grab
grab
24hr composite
24hr composite
Page: 141
-------
Facility Haws: General Electric - Ht. Vernon Perm1t Number: iN0002101
Facility Description: Organic chemical and synthetic manufacturer . SIC Code: 2869
COO
cr (T)
CU
Di-n-butyl phthal
ate
Oiethyl phthalate
Dimethyl phthalat
e
Ethylbcnzcne
FC
Flow
Fluoranthcne
Fluorene
llcxach I orobenzene
Hexach I orobutadi e
ne
Hexach lorcethane
Methyl chloride
KethyUne chlorid
e
Naphthalene
Ni
Mitro-n-raethyl ph
thaliraida
Nitrobenzene
Pb (T)
PH
Phenanthrene
Phenol
Pyrcne
8714.000000 Ib/d
N/A
13.520000 Ib/d
N/A
4.250000 Ib/d
N/A ug/l
1.430000 Ib/d
N/A
4.300000 Ib/d
N/A
1.010000 Ib/d
N/A
1.700000 Ib/d
N/A
N/A
200.000000 No.
N/A
Report MGD
1.330000 Ib/d
N/A
1.170000 Ib/d
N/A
0.550000 Ib/d
9.300000 ug/l
1.060000 Ib/d
N/A
1.110000 Ib/d
N/A
4.560000 Ib/d
N/A
E. 120000 Ib/d
N/A
1.170000 Ib/d
N/A
20.580000 Ib/d
N/A
Report Ib/d
N/A
1.430000 Ib/d
N/A
N/A
N/A
N/A
N/A
1.170000 Ib/d
N/A
0.800000 Ib/d
N/A
1.330000 Ib/d
N/A
26143.000000 Ib/d
N/A
33.730000 Ib/d
N/A
9.110000 Ib/d
N/A ug/l
3.020000 Ib/d
N/A
10.770000 Ib/d
N/A
2.490000 Ib/d
N/A
5.730000 Ib/d
N/A
N/A
400.000000 No.
N/A
Report HGD
3.610000 Ib/d
N/A
3.130000 Ib/d
N/A
1.280000 Ib/d
21.700000 ug/l
2.600000 Ib/d
N/A
2.860000 Ib/d
N/A
10.080000 Ib/d
N/A
4.720000 Ib/d
N/A
3.130000 Ib/d
N/A
48.460000 Ib/d
N/A
Report Ib/d
N/A
3.610000 Ib/d
N/A
0.710000 Ib/d
12.000000 ug/l
N/A
N/A
3.130000 Ib/d
N/A
1.380000 Ib/d
N/A
3.550000 Ib/d
N/A
Between 6.0 su and 9
.0 su
1/day
1 /month
1 /month
1/year
1/year
1/year
1/year
1 /month
1/day
1/year
1/year
1/year
1/year
1/year
1/year
1 /month
1/year
1 /month
1 /month
1/year
• 1/year
continuous
1/year
1/month
1/year
24hr composite
24hr composite
24hr composite
24hr composite
24hr composite
24hr composite
grab
grab
24hr total
24hr composite
24hr composite
24hr composite
grab
grab
grab
grab
24hr composite
24hr composite
24hr composite
24hr composite
24hr composite
record
24hr composite
24hr composite
24hr composite
Page: 142
-------
Facility Name: General Electric - Mt. Vernon Permit Number: I N00021 01
Facility Description: Organic chemical and synthetic manufacturer SIC Code: 2869
Temp.
Tetrachloroethyle
ne
TOC
Toluene
TRC
Trichloroethylene
TSS
Vinyl chloride
Zn CTR)
N/A
Report C
1.170000 Ib/d
N/A
2750.000000 Ib/d
N/A
1 .380000 Ib/d
N/A
N/A
0.020000 mg/l
1.110000 Ib/d
N/A
N/A
2358.000000 Ib/d
5.520000 Ib/d
N/A
6.070000 Ib/d
N/A
N/A
Report C
2.970000 Ib/d
N/A
8349.000000 Ib/d
N/A
4.240000 Ib/d
N/A
N/A
0.040000 mg/l
2.860000 Ib/d
N/A
7576.000000 Ib/d
N/A
14.220000 Ib/d
N/A
12.750000 Ib/d
N/A
1/day
1/year
1/day
1 /month
1/day
1/year
1/day
1/year
1 /month
grab
grab
24hr composite
grab
grab
grab
24hr composite
grab
24hr composite
Limitations/Monitoring Basis:
All organic limits are ELG-based per 40 CFR, Part 414, OCPSF, except hexachlorobenzene and 2,4-dimtrophenol.
Limitations for hexachlorobenzene, 2,4-dinitrophenol, Cu, CN, and Ag are WQ-based. When a diffuser is used, the
2,4-dinitrophenol limitation is ELG-based. pH, TSS, BODS, Cr (T), and Ni limitations are ELG-based per 40 CFR Part
414, OCPSF. Limitations for total phenols are BPJ-based and are the same as in the previous permit. Zn, bisphenol-
A, tetrahydrofuran, and nitro-N-methyl phthalimide limitations are based on the previous permit. Temperature and E-
coli monitoring limitations are WQ-based. The maximum limit for Pb is set equal to the SOthpercentile of Pb in the
receiving stream. Cu, An, and Ag shall be measured and reported as "total recoverable" until a test method is
approved which measures acid-soluble metal. According to 40 CFR, Part 136.3, Table II, the maximum holding time for
CN is 24 hours when sulfide is present and 14 days when sulfide is absent. CN, therefore, shall be monitored by
collecting a grab sample and analyzing it within 24 hours. If it can be demonstrated that the wastewater_contains
no sulfide, a composite sample may be collected and analyzed within 14 days. E. Coli limitations and monitoring
requirements apply annually from April 1 through October 31, except as stated below: -fecal coliform may.be reported
instead of E. coli, for the first three months. After three months, E. coli must be used. The monthly average
level for E. coli is 125/100 and the daily max is 235/100. A variance may be requested for fecal coliform
monitoring from November 1 through March 31. A variance from the lead limitation may be requested on the basis that
naturally occurring Pb concentrations in the receiving waters prevent the attainment of the standard. Chlorine
CTRC) shall be used only from April 1 through November 30.
Outfall: 003 | Receiving Water: Ohio River | Treatment: PC
Amount/Components :
Approximately 0.14 mgd of clarifier blowdown from treatment plant.
Parameter
Al (TR)
Flow
pH
TRC
Limitations
Monthly
Average
N/A
N/A
N/A
Report MGD
N/A
N/A
N/A
N/A
Dai ly
Maximum
Report Ib/d
Report mg/l
N/A
Report MGD
N/A
N/A
N/A
Report mg/l
Other
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/week
1/day
1/day
1/day
Sample Type
grab
24 hr total
grab
grab
Limitations/Monitoring Basis:
Monitoring only is required for flow and TSS. Outfall 003 may be used to discharge wastewater until three years
after the effective date. If additional water treatment additives are to be used, the IDEM ijnust be notified. Al
and Cl must be measured and reported as "total recoverable" for Outfall 003 until such a test method is approved
which measures acid-soluble metal. Chlorine will be used only from April 1 through November 30. If the permit is
requested to be modified to extend beyond 3 years, final effluent limitations will be required.
Page:' 143
I '
-------
Facility Name: General Electric - Mt. Vernon Permit Number: IN0002101
Facility Description: Organic chemical and synthetic manufacturer Sic Code: 2869
Outfall: 004 | Receiving Water: Ohio River | Treatment: None.
Amount/Components :
Approximately 0.25 mgd of cooling tower and boiler blowdown, treatment plant backwash, and stormwater.
Parameter
Al (TR)
Flow
pH
Temp.
TRC
TSS
Limitations
Monthly
Average
N/A
N/A
N/A
Report MGD
N/A
N/A
N/A
Report
N/A
0.020000 rag/ I
Report Ib/d
Report mg/l
Dai ly
Maximum
N/A
Report mg/l
N/A
Report MGD
N/A
N/A
N/A
Report
N/A
0.040000 mg/l
Report Ib/d
Report mg/l
Other
Between 6.0 su and 9
.0 su
units: degrees Celsi
us
interim lims=report
only
Monitoring Requirements
Frequency
1/week
1/day
1/day
1/day
1/day
1/week
Sample Type
grab
24 hr total
grab
grab
grab
grab
Limitations/Monitoring Basis:
Monitoring only is required, for flow, Al, and temperature. TRC is a WQ-based Limitation. For Outfall 004, Al must
be measured and reported as "total recoverable" until such a test method is approved which measures acid-soluble
metal. Al must be monitored for 6 months to determine if it is in significant quantities. A review of the Al
requirements may be requested after 6 months. Chlorine shall be used only from Apr. 1 through Nov. 30, annually.
Compliance with the TRC limitation will be demonstrated if the observed effluent concentrations are less than the
limit of detection.
Outfall: 005 | Receiving Water: Ohio River | Treatment: None.
Amount/Components :
Approximately 0.18 mgd of cooling tower and boiler blowdown, and stormwater.
Parameter
Flow
P«
Temp.
Limitations
Monthly
Average
N/A
Report MGD
N/A
N/A
N/A
Report
Dai ly
Maximum
N/A
Report MGD
N/A
N/A
N/A
Report
Other
Between 6.0 su and 9
.0 su
units: degrees Celsi
us
Monitoring Requirements
Frequency
1/day
1/day
1/day
Sample Type
24 hr total
grab
grab
Limitations/Monitoring Basis:
Monitoring only is required for flow, temp., and pH.
Special Conditions Basis:
The permit contains additional conditions: The discharge shall be free of floating and settleable solids, shall not
cause excessive foam in the receiving waters, shall not contain oil or other substances that cause a visible film or
sheen on the receiving waters, and shall be free of substances that are unsightly or deleterious or that produce
color, odor, or other conditions in such a degree as to create a nuisance. A reopener clause is present concerning
incorporating more stringent effluent limitations should they be developed, the promulgation of stormwater
regulations, conditions for WET limitations, and the use of an effluent diffuser with a mini dilution ratio of less
than 13.7. If toxicity is demonstrated, a TRE is required. A schedule for compliance with the TRE requirement is
provided. Post-TRE biomonitoring requirements are also specified. A BMP plan is required. Site-specific BMP
requirements are specified in the permit.
Effective Date: 02/01/91 Expiration Date: 11/30/95 Abstract Date: 06/10/93
Page: 144
-------
Facility Name: Inland Container Corporation Permit Number: IN0036447
Facility Description: Corrugated paper container manufacturer SIC Code: 2631
Monitoring
Limit ELGs WQSs BPJ Only
Basis: J. J. J. -
Storm UQ
Special BHPs Water Sediment Survey
Conditions: L - — -
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
Z 1 - J- J.
Bio
Survey TRES MDLs Monitoring Other
- I - - I
Abstract Information:
Complete for Outfall 001 with 001A created for abstracting purposes.
Outfall: 001 | Receiving Water: Wabash River I Treatment: PC, AnL, AerL, Sed
Amount/Components :
1.8 mgd of treated wastewaters from cooling tower blowdown, paper machine process, stock preparation, and sanitary
wastewater.
Parameter
Acute WET
BODS
Coliform (T)
Flow
NH3
PH
TSS
Limitations
Monthly
Average
N/A
N/A
1707.000000 Ib/d
N/A
N/A
N/A
Report mgd
N/A
332.000000 Ib/d
N/A
N/A
N/A
3750.000000 Ib/d
N/A
Daily
Maximum
N/A
Report
3414.000000 Ib/d
N/A
N/A
235.000000
Report mgd
N/A
664.000000 Ib/d
N/A
N/A
N/A
7500.000000 Ib/d
N/A
Other
See below
-------
Facf tfty Name: Inland Container Corporation Permit Number; IN0036447
Facility Description: Corrugated paper container manufacturer ' SIC Code: 2631
Coliforra (T)
Flow
NH3
p«
TSS
N/A
N/A
N/A
Report HGD
693.000000 Ib/d
N/A
N/A
N/A
3750.000000 Ib/d
N/A
N/A
235.000000
N/A
Report HGD
1386.000000 Ib/d
N/A
N/A
N/A
7500.000000 Ib/d
N/A
(E. coli) units=#/10
0 ml
winter limitation
Between 6.0 su and 9
.0 su
1 /month
5/week
3/week
5/week
3/week
grab
24hr total
grab
grab
grab
Limitations/Monitoring Basis:
These limits are in effect from December 1 through April 30. See basis for Outfall 001.
Special Conditions Basis:
A reopcner clause is present based on stormwater and biomonitoring requirements. If changes are to be made in the
use of water treatment additives, IDEM must be notified and the additive must be approved before use. Within 90 days
of the permit's effective date. If toxicity is demonstrated, a TRE must be conducted. Chemical sampling must
accompany each water sample taken for WET testing and bioassay analysis. A schedule of compliance for a TRE is
provided in the permit in the case that toxicity has been found. After completion of a TRE, monthly toxicity tests
must be performed for a period of 3 months. If no toxicity is shown, toxicity tests must be conducted once every
six months for the duration of the permit. The permit also contains the following conditions: the discharge shall
be free of floating and settleable solids, shall not cause excessive foam in the receiving waters, shall not contain
oil or other substances in amounts sufficient enough to create a visible film or sheen on the receiving waters, and
shall be free of substances that are in amounts sufficient to be unsightly or deleterious or which produce color,
odor, or other conditions in such a degree as to create a nuisance.
Effective Date: 11/01/91 Expiration Date: 09/30/96 Abstract Date: 06/16/93
Page: 146
-------
Facility Name: Roll Coater, Inc. Permit Number: I N00381 72
Facility Description: Coil coating facility that paints and coats steel coils. SIC Code: 3479
Monitoring
Limit ELGs WQSs BPJ Only
iasis: ; J. ; J.
Storm WQ
Special BMPs Water Sediment Survey
Conditions: z - - —
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
Z ' J. - - J.
Bio
Survey TRES MDLs Monitoring Other
1 I - - I
Abstract Information:
Complete: Outfall 001.
Outfall: 001 | Receiving Water: Travis Ditch | Treatment: Not specified
Amount/Components:
Approximately 0.145 mgd of wastewaters from coil washing, zinc phosphating, oxide coating, chrome rinsing, and
painting.
Parameter
Acute WET
Chloride
Chronic WET
CN (T)
Cr (T)
Cr+6
Cu
-------
Facility Hano: Roll Coator, Inc.
Permit Number: IN0038172
Facility Description: Coil coating facility that paints and coats steel coils.
SIC Code: 3479
an LC 50 of less than 7.0% effluent of the test organism. Chronic toxicity is shown if the NOEL is less than 7.C
If acute or chronic toxicity is found, another test must be performed using the same test species.
Special Conditions Basis:
The permit contains the following conditions: No excessive foam shall be present in the receiving waters. The
discharge shall be fee of floating and settleable solids. The discharge shall not contain oil or other substances
in amounts sufficient to create a visible film or sheen on the receiving waters. No unsightly or deleterious
substances or substances which produce color, odor, or other conditions that may create a nuisance are permitted.
If any two WET tests indicate the presence of toxicity, a TRE must be ihitiated. WET tests required by the permit
may be suspended while the TRE is conducted. TRE plan requirements and a compliance schedule are provided in the
permit. A reopener clause based on the promulgation of more stringent toxic effluent standards. The permittee is
required to provide containment facilities for cyanide or cyanogen compounds (when these compounds are used) in
accordance with the requirements of 327 IAC 2-2-1.
Effective Date: 02/01/93
Expiration Date: 12/31/97
Abstract Date: 06/09/93
Page: 148
-------
Facility Name: ABB Power T&D Co., Inc.
Permit Number: IN0053384
Facility Description: Manufacturer of misc. electronic components used for electric power. SIC Code: 3679
Monitoring
Limit ELGs WQSs BPJ Only
Basis: - 1 I. 4.
Storm WQ
Special BMPs Water Sediment Survey
Conditions: J. 2. 2. -
WET
Limits
Bio
Survey
WET Testing Multiple Tiered
Only Categories Limits Other
- - L I
TRES MDLs Monitoring Other
--III
Abstract Information:
Partial: Outfalls 001 (representative of outfalls 101 and 003) and 002.
Outfall: 001 | Receiving Water: Unnamed ditch to sinkhole
| Treatment: None.
Amount/Components :
Varying amounts of stormwater.
Parameter
Al (TR)
CN
Flow
Isopropylbiphenyl
O&G
PCBs (T)
pH
Tetrach loroethyle
ne
Trichloroethylene
Zn (TR)
Limitations
Monthly
Average
N/A
0.170000 mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report ug/l
N/A
10.000000 mg/l
N/A
Report ug/l
N/A
N/A
N/A
Report ug/l
N/A
Report ug/l
N/A
0.160000 mg/l
Daily
Maximum
N/A
0.400000 mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report ug/l
N/A
15.000000 mg/l
N/A
0.001000 ug/l
N/A
N/A
N/A
8.000000 ug/l
N/A
27.000000 ug/l
N/A
0.380000 mg/l
Other
See below
See below
Between 6.0
.0 su
su and 9
See below
See below
See below
Monitoring Requirements
Frequency
1/week
1/month
1/week
1/month
1/week
1/week
1/month
1/month
1/month
1/week
Sample Type
grab
grab
instantaneous
grab
grab
grab
grab
grab
grab
grab
Limitations/Monitoring Basis:
Oil and grease limitations are WQ-based per State WQSs 327 (IAC 2-1-6). The permit contains a compliance schedule
for attaining the Al limits. pH is also a WQ-based limitation and is the same as the previous permit. The PCBs
limitation is based on State WQSs. Zn and Al limitations are based on State WQSs and their chronic toxicity to
warmwater aquatic life at a hardness of 250 mg/l. Isopropylbiphenyl and cyanide are to be monitored toensure they
are not discharged because they have been detected in the effluent. The monitoring and limits for
tetrachlorethylene and trichloroethylene were established to ensure these parameters are not discharged to
thereceiving waters.
Outfall: 002 | Receiving Water: Two tributaries to Stout Creek
| Treatment: None
Amount/Components :
Varying amounts of stormwater.
Parameter
Flow
O&G
Limitations
monthly
Average
N/A
Report HGD
N/A
10.000000 mg/l
dai ly
Maximum
N/A
N/A
N/A
15.000000 mg/l
Other
Monitoring Requirements
Frequency
1/month
1/month
Sample Type
instantaneous
grab
Page: 149
-------
Facility Hame: ABB Power T&D Co., Inc.
Permit Number: IN0053384
Facility Description: Manufacturer of misc. electronic components used for electric power.
SIC Code: 3679
PH
N/A
N/A
N/A
H/A
Between 6.0 su and 9
.0 su
1 /month
grab
Limitations/Monitoring Basis:
See the discussion for outfall 001.
Special Conditions Basis:
A BMP Plan must be developed within 6 months after the permit's effective date and implemented within 6 months after
approval. Site-specific BMP requirements are provided in the permit including testing for PCBs in the facility
property. Flow shall be measured at approximately the same time as the effluent is sampled for the other
parameters. Compliance with the PCB limitations is based on the limit of detection provided in the permit. The
samples taken for PCBs analysis must not be filtered prior to analysis. If isopropylbiphenyl, PCE, TCE, and/or CN
are detected in the effluent, the permit may be modified to set limits. The weekly wastewater sample must be taken
during the first precipitation event, ice or snow melt of each calendar week. The permit contains a reopener clause
stating that the permit may be modified to include more stringent or different conditions necessary. The permit
specifies that the discharge shall be free of floating and settleable solids, shall not cause excessive foam in the
receiving waters, shall not contain oil or other substances in amounts sufficient enough to create a visible film or
sheen on the receiving waters, and shall be free of substances that are in amounts sufficient to be unsightly or
deleterious or which produce color, odor, or other conditions in such a dgree as to create a nuisance.
Effective Date: 06/01/91
Expiration Date: 04/30/96
Abstract Date: 06/15/93
Page: 150
-------
Facility Name: Total Petroleum/Ark. Refinery Permit Number: KS0000434
Facility Description: Petroleum refinery SIC Code: 2911
Monitoring
Limit ELGs WQSs BPJ Only
Basis: I 11 1
Storm UQ
Special BHPs Water Sediment Survey
Conditions: 2. z. ^
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
- - - - 1
Bio
Survey TRES MDLs Monitoring Other
- - - - J-
Abstract Information:
Complete; Outfall 001 with 001A created for abstracting purposes.
Outfall: 001 Receiving Water: Walnut River ] Treatment: API, AerL
Amount/Components: • -,''**
0.85 HGD of process wastewater, boiler blowdown, cooling tower blowdown, and storm water runoff.
Parameter
BOD5
Chloride
COD
Cr
Cr+6
DO
Flow
Fluoride
NH3-N
O&G
Other
pH
Phenols
S03
TSS
Limitations .
Daily
Average
263.000000 Ib/d
30.000000 mg/l
N/A
N/A
1834.000000 Ib/d
N/A
2.000000 Ib/d
0.250000 mg/l
0.160000 Ib/d
0.020000 mg/l
N/A
N/A
N/A
N/A
N/A
N/A
144.000000 Ib/d
12.000000 mg/l
77.000000 Ib/d
10.000000 mg/l
1.400000 Ib/d
0.170000 mg/l
N/A
N/A
1.700000 Ib/d
0.200000 mg/l
N/A
N/A
210.000000 Ib/d
80.000000 mg/l
Daily
Maximum
473.000000 Ib/d
45.000000 mg/l
N/A
Report mg/l
3535.000000 Ib/d
350.000000 mg/l
5.500000 Ib/d
0.700000 mg/l
0.350000 Ib/d
0.040000 mg/l
N/A
Report mg/l
N/A
Report MGD
N/A
Report mg/l
315.000000 Ib/d
18.000000 mg/l
143.000000 Ib/d
15.000000 mg/l
3.100000 Ib/d
0.390000 mg/l
N/A
Report
3.500000 Ib/d
0.450000 mg/l
N/A
Report mg/l
330.000000 Ib/d
120.000000 mg/l
Other
See below
Sul fides
Between 6.0 su and 9
.0 su
See below
Monitoring Requirements
Frequency
1/week
1/week
1/week
1/week
1/week
1/week
1/day
1/week
1/week
1/week
1/week
1/week
1/week
1/week
Sample Type
Grab
grab
Grab
Grab
Grab
Grab
Weir
grab
Grab
Grab
Grab
Grab
Grab
Grab
Limitations/Monitoring Basis: . .
The limits shown for NH3-N apply April through October. The November-March limits for NH3-N are 144 Ib/d and 24
mg/l daily average and 315 Ib/d and 36 mg/l daily maximum. Sulfates and chlorides are to be monitored biannually
during February and August. The limits and monitoring requirements were based on ELGs in 40 CFR Part 419 for mass
limitations, BPJ, and historical performance data and/or State WQSs for concentration limitations.
Page: 151
-------
Fsef Uty Homo: Total Petroteum/Ark. Refinery Permit Number: KS0000434
Facility Description: Petroleum refinery SIC Code: 2911
Outfall: 001A | Receiving Water: Walnut River | Treatment: API+AerL
Amount/Components :
Unspecified amount of contaminated runoff.
Parameter
BODS
COO
Cr
-------
Facility Name: IBP, Inc. Permit Number: KS000081 7
Facility Description: High process beef packing SIC Code: 2011
Monitoring
.imit ELGs WQSs BPJ Only
Jasis: J. J. 4. J.
Storm UQ
Special BMPs Water Sediment Survey
Conditions: - — - -
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
Z. J. - J- J-
Bio
Survey TRES MDLs Monitoring Other
- _ 1 J. J.
Abstract Information:
Complete; Outfalls 001, 002, 003.
Outfall: 001 Receiving Water: Neosho R./Cottonwood R./Fox Cr Treatment: AS + AnL + AerL
Amount/Components :
Unspecified amount from the final clarifier on an emergency basis.
Parameter
BODS
FC
Flow
NH3-N
O&G
PH
TRC
TSS
Limitations
Dai ly
Average
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
Report
N/A
Report
N/A
Report HGD
N/A
Report
N/A
Report
N/A
Report
N/A
0.011000 mg/l
N/A
Report
Other
See below
See below
See below
See below
See below
See below
Monitoring Requirements
Frequency
2/month
2/month
1/day
2/month
2/month
2/month
1/week
2/month
Sample Type
Grab
Grab
Weir
Grab
Grab
Grab
Grab
Grab
Limitations/Monitoring Basis:
The permittee is required to notify the permitting authority 10 days prior to any discharge from Outfall 001. The
total mass and concentration limits, monitoring frequency, and sample type given in the permit for Outfall002 apply
for either discharge point or the combined discharges from both outfalls. The permit fact sheet specifies that the
limits and monitoring conditions are provided to protect designated water uses and the water quality of the
Cottonwood River. While not describing the basis for individual limits, the permit fact sheet states that ELGs from
40 CFR Part 432, Subpart D were used. Concentration limitations were established using BPJ and historical
performance data as well as State WQSs. A maximum effluent flow of 4.48 HGD was used to calculate mass limitations
using 40 CFR Part 432.
Outfall: 002 | Receiving Water: Neosho R./Cottonwood R./Fox Cr | Treatment: AS + AnL + AerL
Amount/Components :
2.25 MGD from the lagoon system consisting of process discharges.
Parameter
Acute WET
BODS
FC
Limitations
Daily
Average
N/A
N/A
1234.000000 Ib/d
40.000000 mg/l
N/A
N/A
Daily
Maximum
N/A
Report
1494.000000 Ib/d
40.000000 mg/l
N/A
400.000000
Other
See below
See below
Units: #/100
Monitoring Requirements
Frequency
2/5 years
2/month
2/month
Sample Type
not given
Grab
Grab
Page: 153
-------
Facility Name: IBP, Inc. Permit Number: KS000081 7
Facility Description: High process beef packing SIC Code: 2011
Flow
HH3-H
OSG
PH
TRC
TSS
H/A
N/A
N/A
N/A
569.000000 Ib/d
15.000000 mg/l
N/A
N/A
N/A
N/A
1636.000000 Ib/d
80.000000 mg/l
N/A
Report HGD
853.000000 Ib/d
22.000000 mg/l
1138.000000 Ib/d
30.000000 mg/l
N/A
Report
N/A
Report mg/l
3272.000000 Ib/d
120.000000 mg/l
See below
Between 6.0 su and 9
.0 su
2/month
2/month
2/month
2/month
2/month
Total
Grab
Grab
Grab
Grab
Grab
Limitations/Monitoring Basis:
See the basis provided for Outfall 001. The limits shown for BODS apply October-Hay. BODS limits for June and
September are 38 mg/l and 1234 Ib/d daily average and 38 mg/l and 1420 Ib/d daily maximum. BODS limits for July and
August are 25 mg/l and 934 Ib/d daily average and daily maximum. The limits shown for NH3-N apply December-
February. The NH3-N daily maximum which apply March and November are 15 mg/l and 568 Ib/d; April and October limits
are 8 mg/l and 327 Ib/d; Hay-September limits are 4 mg/l and 179 Ib/d. Acute WET tests are to be conducted in July
1994 and December 1996 using 2 specified species and following specified State procedures. If the WET test results
show greater than 20% mortality in any dilution ratio, the permittee is required to notify the permitting authority.
Outfall: 003 | Receiving Water: Cottonwood River | Treatment: None
Amount/Components :
Instroam monitoring
Parameter
WI3-H
P«
Tcfflp.
Limitations
Average
N/A
N/A
N/A
N/A
N/A
N/A
Maximum
N/A
Report mg/l
N/A
Report
N/A
Report
Other
Units: degrees Faren
heit
Honitoring Requirements
Frequency
2/month
2/month
2/month
Sample Type
Grab
Grab
Grab
Limitations/Monitoring Basis:
The basis for these monitoring conditions was not specifically provided.
Special Conditions Basis:
Guidance fop meeting the TRC limit at Outfall 001, which is below detection level, is provided. The permittee is
required to sample and report results from the observation wells in the groundwater system bordering the treatment
ponds 1/quarter for pH, chlorides, nitrates, ammonia, and BODS using 3 grabs. Guidance for sludge application is
provided. The use of earthen lagoons is addressed. This is a draft permit.
Effective Date: M/A Expiration Date: N/A Abstract Date: 09/08/93
Page: 154
-------
Facility Name: Farmland Industries, Inc. Permit Numbers KS0001601
Facility Description: Produces nitrogenous fertilizer sle Code: 2873
Monitoring
Limit ELGs WQSs BPJ Only
lasis: J. J. - i
Storm WQ
Special BHPs Water Sediment Survey
Conditions: ill 1
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
1 J. - - ^
Bio
Survey TRES MDLs Monitoring Other
1 1 1 - J-
Abstract Information:
Complete; Outfall 001.
Outfall: 001 Receiving Water: Kansas River I Treatment: Neut+Sed
Amount/Components:
0.9 MGD of process wastewater, cooling tower blowdown and storm water runoff.
Parameter
Acute WET
COD
Flow
N (T)
NH3-N
N03
PH
TON
TSS
Limitations
Daily
Average
N/A
N/A
N/A
90.000000 mg/l
N/A
N/A
Report Ib/d
Report mg/l
659.000000 Ib/d
80.000000 mg/l
253.000000 Ib/d
N/A
N/A
N/A
782.000000 Ib/d
80.000000 mg/l
N/A
Report mg/l
Daily
Maximum
N/A
Report
N/A
135.000000 mg/l
N/A
Report MGD
Report Ib/d
Report mg/l
1421.000000 Ib/d
120.000000 mg/l
680.000000 Ib/d
N/A
N/A
Report
1462.000000 Ib/d
145.000000 mg/l
N/A
Report mg/l
Other
See below
See below
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/quarter
1/week
1/day
1/week
1/week
1/week
1/week
1/week '
1/week
Sample Type
Grab
24hr composite
Total
Sum N
Grab
24hr composite
Grab
Grab
Composite
Limitations/Monitoring Basis:
N(T) represents a sum of all measured N values. Acute WET testing is torbe conducted quarterly during 1992, and
2/year thereafter following State guidance using 2 species. The LC50 is to be determined using 20% effluentor
greater. If any acute toxicity test indicates toxicity, the permittee is required to notify the permitting
authority and initiate a replicate test. The requirements for flow, TSS, N(T), and acute WET were based on BPJ.
ELGs in 40 CFR Part 418 and historical performance data were used to determine limits and monitoring requirements
for NH3-N, TON and N03. Limits and/or monitoring requirements for pH were based on 40 CFR Part 423 usingBPJ
(cooling tower blowdown). The limits and monitoring requirements for COD were based on historical performance data
and BPJ „
Special Conditions Basis:
The use of earthen lagoons is addressed.
Effective Date: 09/30/91
Expiration Date: 09/01/96
Abstract Date: 09/09/93
Page: 155
-------
Facility Name: Midwest Grain Products, Inc. Permit Number: KS0001635
Facility Description: Distiller of alcohol using wheat starch and gluten SIC Code: 2085
Monitoring WET WET Testing Multiple Tiered
Limit ELGs WQSs BPJ Only Limits Only Categories Limits Other
Basis: ^ ^ ^ j_ - -_ j_ L ._
Storm WQ Bio
Special BHPs Water Sediment Survey Survey TRES HDLs Monitoring Other
Conditions: i i i ; - - - j. -
Abstract Information:
Complete; Outfalls 001A and 001B.
Outfall: 001A | Receiving Water: Missouri R via White Clay Crk. | Treatment: None
Amount/Components :
2.5 MOD of cooling water.
Parameter
BOOS
Flow
pH
Temp.
TSS
Limitations
Daily
Average
N/A
N/A
N/A
N/A
N/A
Report
N/A
N/A
N/A
Report
Daily
Maximum
N/A
10.000000 mg/l
N/A
Report MGD
N/A
Report
N/A
Report
N/A
Report
Other
Between 6.0 su and 9
.0 su
Units: degrees Faren
heit
Monitoring Requirements
Frequency
2/week
1/day
2/week
2/week
2/week
Sample Type
24hr composite
Parshall flume
grab
Grab
24hr composite
Limitations/Monitoring Basis:
Monitoring requirements for flow, TSS, and temperature were based on BPJ. The pH limits were based on State WQSs.
The limit and monitoring requirement for BODS were based on BPJ and historical performance data.
Outfall: 001B | Receiving Water: Missouri R via White Clay Crk. | Treatment: Aer+PC
Amount/Components :
1.15 MGO treated process wastewater.
Parameter
BOOS
Flow
PH
TSS
Limitations
Daily
Average
1160.000000 Ib/d
45.000000 mg/l
N/A
N/A
N/A
N/A
1267.000000 Ib/d
45.000000 mg/l
Daily
Maximum
3414.000000 Ib/d
90.000000 mg/l
N/A
Report MGD
N/A
Report
3874.000000 Ib/d
90.000000 mg/l
Other
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
2/week
1/day
2/week
2/week
Sample Type
24hr composite
Parshall flume
Grab
24hr composite
Limitations/Monitoring Basis:
Flow monitoring requirements were based on BPJ. The BODS and TSS limits and monitoring requirements were based on
ELGs in 40 CFR Parts 406 and 414, BPJ, and historical performance data. The pH limits were based on StateWQSs.
Special Conditions Basis:
The permittee is required to conduct one-time testing for all pollutants identified under Part V-C of "EPA Form 2C -
Wastewater Discharge Informatio," including; metals, cyanide, total phenols, GC/MS fraction - volatile compounds
GC/HS fraction - acid compounds, GC/MS base neutral compounds, and GC/MS fraction pesticides.
Effective Date: 06/04/93 Expiration Date: 09/30/96 Abstract Date: 09/09/93
•
Page: 156
-------
Facility Name: DOE-Paducah Gaseous Diffusion Permit Number: KY0004049
Facility Description: Isotopic enrichment of uranium hexaf luoride ' sic Code: 4931
Monitoring
Limit ELGs WQSs BPJ Only
Basis: Z. J. 4. J.
Storm WQ
Special BHPs Water Sediment Survey
Conditions: J. Z z z
WET WET Testing Multiple Tiered
Limits Only Categories Limits
J- J. Z Z
Bio
Survey TRES MDLs Monitoring
z I I I
Other
Other
J.
Abstract Information:
Partial; Outfalls 001, 002, 003, 004, 005, 006, 008 (representing 009-012), 013 (representing 015-018), and 014.
Outfall: 001 | Receiving Water: Big Bayou Creek | Treatment: ChRed, Sed, Neut, AL
Amount/Components :
1.59 HGD of chromium reduction cooling tower blowdown, misc. steam plant wastewater, misc. floor drains, stormwater
runoff, and other components.
Parameter
Al (TR)
Alpha (DS)
Alpha (SS)
Beta (DS)
Beta (SS)
Cd (TR)
Chronic WET
Cr+6
Cu (TR)
Fe (TR)
Flow
Hardness
Ni (TR)
O&G
Other
P (T)
Pb (TR)
PCBs (T)
Limitations
Monthly
Average
N/A
Report mg/l
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
0.002000 mg/l
N/A
Report
N/A
0.011000 mg/l
N/A
0.026000 mg/l
N/A
Report mg/l
N/A
Report MGD
N/A
Report mg/l
N/A
0.342000 mg/l
N/A
10.000000 mg/l
N/A
1.000000 mg/l
N/A
1.000000 mg/l
N/A
0.010000 mg/l
N/A
0.000079 mg/l
Dai ly
Maximum
N/A
Report mg/l
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
0.011000 mg/l
N/A
1.000000
N/A
0.016000 mg/l
N/A
0.042000 mg/l
N/A
Report mg/l
N/A
Report MGD
N/A
Report mg/l
N/A
3.079000 mg/l
N/A
15.000000 mg/l
N/A
1.000000 mg/l
N/A
1.000000 mg/l
N/A
0.262000 mg/l
N/A
0.000079 mg/l
Other
Units: pCi/l
Units: pCi/l
Units: pCi/l
Units: pCi/l
-
Monitoring Requirements
Frequency
2/month
1/quarter
1/quarter
1/quarter
1/quarter
2/month
Variable
2/month
mg/l as CaC03
Isopropanol
Only P, not total
2/month
2/month
1/week
1/week
2/month
1/week
1 /month
1/week
2/month
1 /month
Sample Type
Grab
Grab
Grab
Grab
Grab
Grab
24hr composite
Grab
Grab
Grab
Instant.
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Page: 157
-------
Fact If ty Name: DOE-Paducah Gaseous Diffusion Permit Number: KY0004049
Facility Description: Isotopic enrichment of uranium hexafluoricle SIC Code: 4931
pH
Terap.
TRC
Trichloroethylene
TSS
U (T>
Zn (TR)
N/A
N/A
N/A
86.000000
N/A
0.010000 mg/l
N/A
0.081000 mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
0.230000 mg/l
N/A
N/A
N/A
Report
N/A
0.019000 mg/l
N/A
0.081000 mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
0.254000 mg/l
Between 6.0 su and 9
.0 su
Units: degrees Faren
heit
1/week
1/week
1/week
1/month
1/week
1/week
2/month
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Limitations/Monitoring Basis: .
O&G limits are BPJ-based limitations established pursuant to the State's authority authority to set BPJ-based
limits, Cd(TR), Cu(TR), Cr+6, Pb(TR), Ni(TR), Zn(TR), trichloroethylene, TRC, PCBs, and chronic WET limits areWQ-
based limitations derived by the Steady State Uasteload Allocation Model. Acetone, isopropanol, P, temp., TRC, and
pH are WQ-based limitations consistent with State surface water standards. Chronic toxicity testing must be
conducted quarterly using two species the first year; the State may designate the most sensitive species for testing
after this initial monitoring. Retesting within 15 days must be performed if toxicity is evident. Accelerated
1/month testing may be required if toxicity exceedances persist. Hardness, TSS, AUTR), Fe(TR), IKT), alpha(SS),
beta(DS), and beta (SS) monitoring requirements were established based on the permit writer's judgement and are
consistent with State surface water standards. A discussion of the basis of the remaining monitoring conditions was
not provided.
Outfall: 002 | Receiving Water: Little Bayou Creek | Treatment: AS
Amount/Components: , ,
0.83 HGO of once through cooling water, floor and roof drains, and drains for eyewash baths, safety showers, and water
fountains.
Parameter
Al (TR)
Alpha (DS>
Alpha (SS)
Beta (DS)
Beta (SS)
Cd (TR)
Chronic MET
Cr (TR)
Cu (TR)
Fe (TR)
Limitations
Monthly
Average
N/A
Report mg/l
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
0.001000 mg/l
N/A
Report
N/A
0.001000 mg/l
N/A
0.012000 mg/l
N/A
Report mg/l
Daily
Maximum
N/A
Report mg/l
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
0.004000 mg/l
N/A
1.000000
N/A
0.016000 mg/l
N/A
0.018000 mg/l
N/A
Report mg/l
Other
Units: pCi/l
Units: pCi/l
Units: pCi/l
Units: pCi/l
Monitoring Requirements
Frequency
1/month
1/quarter
1 /quarter
1/quarter
1/quarter
1/month
Variable
1/month
1/month
1/month
Sample Type
Grab
Grab
Grab
Grab
Grab
Grab
24hr composite
Grab
Grab
Grab
Page: 158
-------
Facility Name: DOE-Paducah Gaseous Diffusion Permit Number: KY0004049
Facility Description: Isotopic enrichment of uranium hexaf luoride SIC Code: 4931
Flow
Hardness
Ni (TR)
O&G
P (T)
Pb (TR)
PCBs (T)
PH
Temp.
TRC
Trichloroethylene
TSS
U (T)
Zn (TR)
N/A
Report HGD
N/A
Report mg/l
N/A
0.158000 mg/l
N/A
10.000000 mg/l
N/A
1.000000 mg/l
N/A
0.003000 mg/l
N/A
0.000079 mg/l
N/A
N/A
N/A
86.000000
N/A
0.010000 mg/l
N/A
0.081000 mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
0.106000 mg/l
N/A
Report MGD
N/A
Report mg/l
N/A
1.418000 mg/l
N/A
15.000000 mg/l
N/A
1.000000 mg/l
N/A
0.082000 mg/l
N/A
0.000079 mg/l
N/A
N/A
N/A
Report
N/A
0.019000 mg/l
N/A
0.081000 mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
0.117000 mg/l
mg/l as CaCOS
Only P, not total
Between 6.0 su and 9
.0 su
Units: degrees Faren
heit
1/month
1/month
1/month
1/month
1/month
1/month
1/month
1/month
1/month
1/month
1/month
1/month
1/quarter
1/month
Instant.
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Limitations/Monitoring Basis:
O&G, TSS, and hardness limits are BPJ-based limits established pursuant to the State's authority to set BPJ-based
limits. Cd(TR), Cu(TR), Cr(TR), Pb(TR), Ni(TR), Zn(TR), trichtoroethylene, TRC, PCBs, and chronic WET limits are
WQ-based limitations derived by the Steady State Uasteload Allocation Model. The limitations set forth for Cr(T)
are the Cr+6 UQ-based limitations contained in the calculations. P, temp. 'and pH are WQ-based limitations consistent
with State surface water standards. Chronic toxicity testing must be conducted quarterly using two species the
first year; the State may designate the most sensitive species for testing after this initial testing. Retesting
within 15 days must occur if toxicity is evident. Accelerated 1/month testing may be required if toxicity
exceedances persist. Al(TR), Fe(TR), U(T), alpha(SS), beta(DS), and beta (SS) monitoring requirements were
established based on the permit writer's judgement and are consistent with State surface water standards. A
discussion of the basis of the remaining monitoring conditions was not provided.
Outfall: 003 | Receiving Water: Little Bayou Creek | Treatment: Not described
Amount/Components:
Typically no discharge; can receive diversion ditch wastewaters not going to 001.
Parameter
Al (TR)
Alpha (DS)
Alpha (SS)
Beta (DS)
Limitations
Average
N/A
Report ,mg/l
N/A
Report
N/A
Report
N/A
Report
Maximum
N/A
Report mg/l
N/A
Report
N/A
Report
N/A
Report
Other
Units: pCi/l
Units: pCi/l
Units: pCi/l
Monitoring Requirements
Frequency
1/month
1/quarter
1/quarter
1/quarter
Sample Type
Grab
Grab
Grab
Grab
Page: 159
-------
Fee fifty Name: DOE-Paducah Gaseous Diffusion Permit Number: KY0004049
Facility Description: Isotopic enrichment of uranium hexafluoride SIC Code: 4931
Beta Css)
Cd (TR)
Cr (TR)
Cu (TR)
Fc (TR)
Flow
Hardness
Hi (TR)
OSG
P (T)
Pb (TR)
PCBS (T)
p«
Temp.
TRC
Trichloroethylene
TSS
U (T)
Zn (TR)
N/A
Report
N/A
0.001000 mg/l
N/A
0.001000 mg/l
N/A
0.012000 mg/l
N/A
Report mg/l
N/A
Report HGO
N/A
Report mg/l
N/A
0.158000 mg/l
N/A
10.000000 mg/l
N/A
1.000000 mg/l
N/A
0.003000 mg/l
N/A
0.000079 mg/l
N/A
N/A
N/A
89.000000
N/A
0.010000 mg/l
N/A
0.081000 mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
0.106000 mg/l
N/A
Report
N/A
0.004000 mg/l
N/A
0.016000 mg/l
N/A
0.018000 mg/l
N/A
Report mg/l
N/A
Report HGD
N/A
Report mg/l
N/A
1.418000 mg/l
N/A
15.000000 mg/l
N/A
1.000000 mg/l
N/A
0.082000 mg/l
N/A
0.000079 mg/l
N/A
N/A
N/A
Report
N/A
0.019000 mg/l
N/A
0.081000 mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
0.117000 mg/l
Units: pCi/l
mg/l as CaC03
Only P, not total
Between 6.0 su and 9
.0 su
Units: degrees Faren
heit
1/quarter
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1/month
1 /month
Grab
Grab
Grab
Grab
Grab
Instant.
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Limitations/Monitoring Basis:
OSG, TSS, and hardness limits are BPJ-based limitations established pursuant to the State's authority to set BPJ-
bascd limits. Cd(TR), Cu(TR), Cr(TR), Pb(TR), Ni(TR), Zn(TR), trichloroethylene, TRC, and PCBs limitsare WQ-based
limitations derived by the Steady State Wasteload Allocation Model. Acetone, isopropanol, P, temp., and pH are WQ-
bascd limitations consistent with State surface water standards. Al(TR), Fe(TR), U(T), alpha(DS), alpha (SS), beta
(OS), and beta (SS) monitoring requirements were established based on the permit writer's judgement consistent with
State surface water standards. A discussion of the basis of the remaining monitoring conditions was not provided.
Page: 160
-------
FacUity Name: DOE-Paducah Gaseous Diffusion Perrait Humber: KY0004Q49
Facility Description: Isotopic enrichment of uranium hexafluoride SIC Code. 4931
Receiving Water: Internal outfall via 008 Treatment: Unspecified
Amount/Components: ~
0.423 HGD primarily composed of treated sanitary sewage including lab drains, showers, laundries, and other drains
Parameter
Limitations
Monthly
Average
BODS N/A
30.000000 mg/l
FC N/A
200.000000
Flow N/A
Report MGD
pH N/A
N/A
Daily
Maximum
N/A
45.000000 mg/l
N/A
400.000000
N/A
Report MGD
N/A
N/A
Other
Units: #/100 ml
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
2/month
H/month
2/month
2/month
Sample Type
Grab
Grab
Instant.
Grab
Limitations/Monitoring Basis:
Internal outfall limitations were established since dilution at Outfall 008 would not allow for the determination of
compliance with secondary limitations. BODS, FC, and PH limitations are established in accordance with State
regulations which require biodegradable wastes to meet specified effluent limitations? The fact sheet dictates
that sewage treatment plants with flows more than 0.025 must meet secondary. A visual observation mustbe conducted
"nditio^f wereCneotadesc"bedr " "" "^ «* itS diSChar9e' The baS1"S °f the V'SUal observation^ mooring"
Outfall: 005
Receiving Water: Big Bayou Creek | Treatment: AL
Amount/Components: • " "
0.785 MGD of water treatment plant filter backwash and clarifier sludge.
Parameter
Al (TR)
Cd (TR)
Cr (TR)
Cu (TR)
Fe (TR)
Flow
Hardness
Mi (TR)
O&G
P (T)
Pb (TR)
PCBs (T)
Limitations
Monthly
Average
N/A
Report mg/l
N/A
0.001000 mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report MGD
N/A
Report mg/l
N/A
Report mg/l
N/A
10.000000 mg/l
N/A
1.000000 mg/l
N/A
Report mg/l
N/A
0.000079 mg/l
Daily
Maximum
N/A
Report mg/l
N/A
0.004000 mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report MGD
N/A
Report mg/l
N/A
Report mg/l
N/A
15.000000 mg/l
N/A
1.000000 mg/l
N/A
Report mg/l
N/A
0.000079 mg/l
Monitoring Requirements
Other Frequency
mg/l as CaC03
Only P, not total
2/month
2/month
2/month
2/month
2/month
1/week
1/week
2/month
1/week
1/week
2/month
1 /month
Sample Type
Grab
Grab
Grab
Grab
Grab
Instant.
Grab
Grab
Grab
Grab
Grab
Grab
Page: 161
-------
Facility Hamc: DOE-Paducah Gaseous Diffusion P«™*- Number: KY0004049
Facility Description: Isotopic enrichment of uranium hexafluoride SIC Code- A931
pH
TRC
TSS
Zn (TR)
H/A
N/A
H/A
0.010000 mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
N/A
N/A
0.019000 mg/l
N/A
Report mg/l
N/A
Report mg/ 1
Between 6.0 su and 9
.0 su
1/week,
1/week
H/month
Grab , ,
Grab
Grab
Ura!taoSGTrrfTst0limIitsBar1eSBPJ-based limitations established pursuant to the State's authority to set BPJ.-based limits.
TRC and PCBs are WQ-based limitations consistent with State surface water standards as derived by the Steady State
Wastcload Allocation Model P and PH are WQ-based limitations consistent with State surface water standards
Hardness monitoring requirements were established based on the permit writer's judgement AKTR), .^<{R) CrCTR),
CdfTRi CutTR) Pb(TR) Ni(TR), and Zn(TR) monitoring requirements were established based on the permit writer's
Judgment consistent with State surface water standards. A discussion of the basis of the remamg conditions was .
Outfall: 006 | Receiving Water: Big Bayou Creek 1 Treatment: AL ...
0.78?WGO of' water treatment plant filter backwash and clarifier sludge.
Parameter
Al (TR)
Cd (TR)
Chronic WET
Cr (TR)
Cu (TR)
Fc (TR)
Flow
Hardness
Mi (TR)
OSG
P (T)
Pb (TR)
PCBS (T)
PH
TRC
Limitations
Monthly
Average
N/A
Report mg/l
N/A
Report mg/l
N/A
N/A
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report MGD
N/A
Report mg/l
N/A
Report mg/l
N/A
10.000000 mg/l
N/A
1.000000 mg/l
N/A
Report mg/l
N/A
0.000079 mg/l
N/A
N/A
N/A
0.010000 mg/l
Daily
Maximum ,
N/A
Report mg/l
N/A
Report mg/l
N/A
1.000000
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report MGD
N/A
Report mg/l
N/A
Report mg/l
N/A
15.000000 mg/l
N/A
1.000000 mg/l
N/A
Report mg/l.
N/A
0.000079 mg/l
N/A
N/A
N/A
0.019000 mg/l
, Other
mg/l as CaC03
Only P, not total
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
2/month
2/month
Variable
2/month
2/month .
2/month ,
1/week
1/week
2/month
1/week
1/week
2/month
1 /month
1/week
1/week
Sample Type
Grab
Grab
'
24hr composite
Grab
Grab
Grab
Instant.
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Page: 162
-------
Facility Name: DOE-Paducah Gaseous Diffusion Permit Number: KY0004049
Facility Description: Isotopic enrichment of uranium hexafluoride SIC Code: 4931
TSS
Zn (TR)
.N/A
30.000000 mg/l
N/A
Report mg/l
N/A
50.000000 mg/l
N/A
Report mg/l
I/week
2/month
Grab
Grab
Limitations/Monitoring Basis:
O&G and TSS limits are BPJ-based limitations established pursuant to the State's authority to set BPJ-based limits.
TRC and PCBs are WQ- based limitations consistent with State surface water standards as derived by the Steady State
Wasteload Allocation Model. P and pH are WQ- based limitations consistent with State surface water standards.
Hardness monitoring requirements were established based on the permit writer's judgement. Al(TR), Fe(TR), Cr(TR),
Cd(TR), Cu(TR), Pb(TR), Ni(TR), and Zn(TR) monitoring requirements were established based on the permit writer's
judgement consistent with State surface water standards. Chronic tbxicity limits are established consistent with
State standards for prohibition of degradation and in accordance with acceptable numerical mixing zones. Chronic
toxicity testing must be conducted quarterly using 2 species the first year; the State may designate the most
sensitive species for testing after this initial monitoring. Retesting within 15 days must be conducted if toxicity
is evident. Accelerated 1/month testing may be required if toxicity exceedahces persist. A discussion of the basis
for the remaining monitoring conditions was not provided.
Outfall: 008 | Receiving Water: Big Bayou Creek | Treatment: DeCl
Amount/Components:
0.176 HGD of wastewaters from roof and floor drains, steam condensate, cooling water, paint spray booth wash water, and
miscellaneous drains.
Parameter
Al (TR)
Alpha (DS)
Alpha (SS)
Beta (DS)
Beta (SS)
Cd (TR)
Chronic WET
Cr (T)
Cu (TR)
Fe (TR)
Flow
Hardness
Hi (TR)
O&G
P (T)
Limitations
Monthly
Average
N/A
Report mg/l
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
0.001000 mg/l
N/A
Report
N/A
0.011000 mg/l
N/A
0.012000 mg/l
N/A
Report mg/l
N/A
Report HGD
N/A
Report mg/l
N/A
0.158000 mg/l
N/A
10.000000 mg/l
N/A
1.000000 mg/l
Daily
Maximum
N/A
Report mg/l
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
0.004000 mg/l
N/A
1.000000
N/A
0.016000 mg/l
N/A
0.018000 mg/l
N/A
Report mg/l
N/A
Report MGD
N/A
Report mg/l
N/A
1.418000 mg/l
N/A
15.000000 mg/l
N/A
1.000000 mg/l
Other
Units: pCi/l
Units: pCi/l
Units: pCi/l
Units: pCi/l
mg/l as CaC03
Only P, not total
Monitoring Requirements
Frequency
2/month
1/quarter
1/quarter
1/quarter
1/quarter
2/month
Variable
2/month
2/month
2/month
1/week
1/week
2/month
1/week
1/week
Sample Type
Grab
Grab
Grab
Grab
Grab
Grab
24hr composite
Grab
Grab
Grab
Instant.
Grab
Grab
Grab
Grab
Page: 163
-------
Facility Name: DOE-Paducah Gaseous Diffusion Permit Number: KY0004049
Facility Description: Isotopic enrichment of uranium hexaf luoride SIC Code: 4931
Pb
-------
(Facility Name: DOE-Paducah Gaseous Diffusion
Facility Description: Isotopic enrichment of uranium hexafluoride
Cu (TR)
Fe (TR)
Flow
Hardness
Ni (TR)
O&G
Pb (TR)
PCBs (T)
pH
Trichloroethylene
TSS
U (T)
Zn (TR)
N/A
0.012000 mg/l
N/A
Report mg/l
N/A
Report MGD
N/A
Report mg/l
N/A
0.158000 mg/l
N/A
10.000000 mg/l
N/A
0.003000 mg/l
N/A
0.000079 mg/l
N/A
N/A
N/A
0.081000 mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
0.106000 mg/l
N/A
0.018000 mg/l
N/A
Report mg/l
N/A
Report MGD
N/A
Report mg/l
N/A
1.418000 mg/l
N/A
15.000000 mg/l
N/A
0.082000 mg/l
N/A
0.000079 mg/l
N/A
N/A
N/A
0.081000 mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
0.117000 mg/l
mg/l as CaC03
Between 6.0 su and 9
.0 su
Permit Number: KY0004049
• .
SIC Code: 4931
• ^=^^=^=^==
1/month crab
I/month Grab
1/month Instant.
1/month Grab
1/month Grab
1/month
1/month
1/month
1/month
1/month
1/month
1/quarter
1/month
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Limitations/Monitoring Basis:
consistent with State surface water standards chronfr i-nvi^lf, ! !: P lmiuS are UQ-based limitations
species the first year; the State may designate the mSst sensitive T^9 T ? c?nducted quarterly using two
Chronic toxicity monitoring is established consistent with £?at™ff !°P test',n9 after this initialtesting.
(TR) Fe (TR), U (T), alpha (SS), alpha (DS) beta (DS) and teta «« m W?*er.standards and aeneral provisions! Al
on the perm t writer's judgement and are consistent with State surfld ™ltor"«/equirementswere established based
of the remaining monitoring conditions was not provided surface "ater standards. A discussion of the basis
Treatment: AL
Outfall: 014 | Receiving Hater: Big Bayou Creek
Amount/Components:
Typically no discharge as this outfall serves as an alternate disposal of filter backwash.
Parameter
Al (TR)
Cd (TR)
Cu (TR)
Fe (TR)
Flow
Monthly
Average
N/A
Report
mg/l
N/A
0.001000 mg/l
N/A
Report mg/l
N/A
Report rag/I
N/A
Report MGD
Daily
Maximum
N/A
Report
mg/l
N/A
0.004000 mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report MGD
Other
Monitoring Requirements
Frequency
2/month
2/month
2/month
2/month
.... 1/week
Sample Type
Grab
Grab
Grab
Grab
Instant.
Page: 165
-------
Facility Name: DQE-Paducah Gaseous Diffusion
__=————————
Permit Number: XY0004049
rUCtlivy Names wwc;-reww*-w'i ««—--- -..---- _
Facility Description; Isotopic enrichment of uranium hexafluoride
Hardness
Mi OR)
OSG
Pb
PCBs (T>
PH
TSS
Zn (TR>
H/A
Report mg/l
N/A
Report mg/l
N/A
10.000000 mg/l
H/A
Report mg/l
N/A
0.000079 mg/l
N/A
N/A
N/A
Report mg/l
N/A
Report mg/l
N/A
N/A
Report mg/l
N/A
15.000000 tng/l
N/A
Report rag/I
N/A
0.000079 mg/l
N/A
N/A
N/A
Report mg/l
N/A
Report mg/l
Between 6.0 su and 9
.0 su
2/month •
1/week
2/month
1/month
1/week
1/week
2/month
Grab
Grab
Grab
Grab
Grab
Grab
Grab
^-HatlonfSst^^
pH limits are WQ-based limitations
S^^^SffsHSSr.^SH^iS'
not provided.
Special Conditions Basis: ..... j ,,«i^=ri =nH imnipmented within one year; this condition was imposed to
^ A generic BMP plan is required to be developed and ^fiented "^"^^^ required to achieve the HDLs set out in
prevent accidental release of CWA Section 311 P°i^*an*s;ddr^sp™5lnce of the toxicity limit which is based upon
SO CFR Part 136. A TRE may be/e^ed by the State to address ex «^a™e °TU outfalls \ t1mes during the first
State regulations. The permittee must ™°* fT1™ p°^^ special conditions address the following: 1) .
and second years and.before the permit expiration date °™% *P^h . L 2) a prohibition of degradat^n of
'*
Page: 166
-------
Facility Name: CF Industries, Inc. ^"nit Number: LA0000418
Facility Description: Nitrogenous fertilizer manufacturer SIC Code: 2873
Monitoring
Limit ELGs WQSs BPJ Only
iasisr J. z. — ' J.
Storm UQ
Special BHPs Water Sediment Survey
Conditions: z. - ' - -
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
- ' 1 .. -' ^ -.
Bio
Survey TRES MDLs Monitoring Other
- , I , - - J-
Abstract Information: '
Complete; Outfall 001 (enumerated A and B for abstracting purposes) and 002.
Outfall: 001A Receiving Water: Mississippi River Treatment: Not described
mOUrV.47nMGD of process wastewater, cooling tower blowdown, sanitary wastewater, and storm water runoff.
Parameter
Acute WET
Flow
NH3-N
N03-N
Organic-N
Temp.
Zn
Limitations
Dai ly
Average
N/A '
Report TUa
N/A
Report MGD
2645.000000 Ib/d
N/A
2645.000000 Ib/d
N/A
2430.000000 Ib/d
N/A
• N/A
105.000000 F
56.000000 Ib/d
N/A '
Daily
Maximum
N/A
Report Tua
N/A
Report MGD
5265.000000 Ib/d
N/A
5265.000000 Ib/d
N/A
4600.000000 Ib/d
N/A
N/A
115.000000 F
80.000000 Ib/d
N/A
Other
Monitoring Requirements
Frequency
1/quarter
continuous
3/week
3/week
3/week
continuous
3/week
Sample Type
24hr fw composite
record
24hr fw composite
24hr fw composite
24hr fw composite
record
24hr fw composite
Limitations/Monitoring Basis: ' ','.... , ^
Outfall 001A has been established as part of the permit abstract process to represent those, limitations that are
effective untill the start up of the new plant expansion. Limitations for all'parameters are consistent with the
past permit in accordance with anti-backstiding. Past permits limitations were ELG-based consistent with BAT and
BCT of the fertilizer manufacturing category (40 CFR Part 418). The basis of the monitoring conditions was not
discussed.
Outfall: 001B | Receiving Water: Mississippi River | Treatment: Not described
Amount/Components:
5.47 MGD of process wastewater, cooling tower blowdown, sanitary wastewater, and storm water runoff
Parameter
Acute WET
Flow
NH3-N
N03-N
Organic-N
Limitations
Dai ly
Average
N/A
Report TUa
N/A
Report MGD
3358.000000 Ib/d
N/A
1057.000000 Ib/d
N/A
3006.000000 Ib/d
N/A
Daily
Maximum
N/A
Report TUa
N/A
Report MGD
6737.000000 Ib/d
N/A
2255.000000 Ib/d
N/A
5680.000000 Ib/d
N/A
Other
Monitoring Requirements
Frequency
1/quarter
continuous
3/week
3/week
3/week
Sample Type
24hr fw composite
record
24hr fw composite
24hr fw composite
24hr fw composite
Page: 167
-------
Facility Ham: CF Industries. Inc. Perrnl-t Number. LA0000418
Facility Description: Nitrogenous fertilizer manufacturer • SIC Code: 2873
Tcfnp*
Zn
H/A
105.000000 F
56.000000 Ib/d
H/A
N/A
• 115.000000 F
80.000000 Ib/d
N/A
continuous
3/week
record
24hr fw composite
Limitations/Monitoring Basis:
Outfall 001B has been established as. part of the permit abstract process to represent those limitations that become
effective after the start up of the plant expansion. Only Organic-N, N03-N, and NH3-N limitations are effected by
the plant expansion. For these parameters, limitations are ELG-based consistent with NSPS for fertilizer
manufacturing (40 CFR Part 418; Subpart C). Calculations supporting these changes were provided for Organic-N and
Hnj"H only*
Outfall: 002 | Receiving Water: Mississippi River Treatment: Mot described.
Amount/Components :
Unspecified amount of clarifier underflow.
Parameter
Alkalinity
Clarifying agents
Flow
TOO
TSS
Limitations
Dai ly
Average
Report Ib/d
N/A
Report Ib/d
N/A
N/A
Report HGD
Report Ib/d
N/A
Report Ib/d
N/A
Daily
Maximum
Report Ib/d
N/A
N/A
N/A
N/A
Report MGD
Report Ib/d
N/A
Report Ib/d
N/A
Other
Phenol-phthalein met
hod
See below
Monitoring Requirements
Frequency
1/week
1/week
1/week
1/week
Sample Type
grab
estimate
grab
grab
Limitations/Monitoring Basis:
Reporting of the monthly average on a per pound basis of the clafifying agents used in the intake water systems is
required. A discussion of the basis of the monitoring requirements was not provided.
Special Conditions Basis:
Requirements for the conduct and the submittal, within 30 days of a TRE plan are specified where toxicity is found
in two consecutive samples. The TRE plan must specify the approach and methodology for the conduct of theTRE and
the date of initiation of the TRE. TRE requirements are consistent with the EPA Region 6 approach, requirements for
advance notification prior to the completion of the plant expansion are also specified. A discussion of the basis
of the special conditions other than described above were not provided.
Effective Date: 08/29/92 Expiration Date: 08/28/97 Abstract Date: 04/13/93
Page: 168
-------
Facility Name: Agrico Chemical Company
Facility Description: Produces phosphoric acid
, . . Monitoring
Limit ELGs UQSs BPJ Only
Basis: - 1 I J.
Storm UQ
Special BHPs Water Sediment Survey
Conditions: J_ ^ - .
Permit Numbers LA0004847
WET WET Testing Multiple
Limits Only Categories
^ J.
Bio
Survey TRES MDLs
- J- I
SIC Code: 2874
Tiered
Limits Other
J. J.
Monitoring Other
I
Abstract Information:
Partial; 001 (representing 002), 102 (representing 202 and 302), 402, 502, 003, 004. and 105 (represents ?n-5 »nH VKI
Outfall: 001 Receiving Water: Mississippi River
| Treatment: Not described
Amount/Components :
165.3 HGD of once-through cooling water, scrubber water and fertilizer area nonpracess wastewater
Parameter
Chronic WET
Fl
Flow
P (T)
Radium (226)
S04
Temp.
TSS
Limitations
Daily
Average
N/A
Report
165.000000
N/A
N/A
Report MGD
15000.000000 Ib/d
N/A
N/A
N/A
Report Ib/d
N/A
N/A
Report F
Report Ib/d
N/A
Dai ly
Maximum
N/A
N/A
222.800000
N/A
N/A
Report MGD
34200.000000 Ib/d
N/A
N/A
N/A
Report Ib/d
N/A
N/A
Report F
Report Ib/d
N/A
Other
See below
Units: 1000lb/d,see
below
See below
See below
See below
See below
Monitoring Requirements
Frequency
1 /month
3/week
continuous
3/week
1 /month
3/week
continuous
3/week
Sample Type
24hr fw composite
24hr fw composite
record
24hr fw composite
monthly composite
24hr fw composite
record
24hr fw composite
Limitations/Monitoring Basis:
These limits represent the limits for the combined discharges from Outfalls 001 and 002. Effluent limitations and
P^ri ^"^requirements are continued from the previous permit. The fluoride limits (Fl) which were based oHo^R
Part .122.44(a) because the ELGs at 40 CFR Part 418.13 were rescinded for phosphoric acid plants located in the
Mississipp, River southern delta, and P (T) limitations were based on "Swift Tower flouride collection at the
evaporators." However, the Swift Towers have reduced the P (T) daily avg. to less than 15,000 Ib/d and this has
r*nd nnpfiln hd 9S,a PTiV1""! base? °n BPJ' The mass dl'scharge *>r flouride, P (T), TSS, and S04 Outfallf 001
Jh^rSSh- 3 b* c? culated by subtracting the each parameter's mass as contributed from Outfalls 003 and 004 from
2£r ^l ? °Uh ^f: ^ aV9' and daUy maX- P »* the avg. of the monthly composite is the fw composite of a?
i«n* A£epxe ??-9 lVe 24hr f" composites; ^is has been changed from an annual avgu limit to a quarterly avg limit
as per the facility's request. The quarterly average limit is 0.0032 curie/day. pH is not regulated pursuant to an
FDF variance. Chrome WET testing must be conducted on the fw sample from Outfalls 001, 002"and 003? TesUng mus?
represent na low'now condit1 ?P6|lflC ™ 9U^Ce ^ Procedures'- the permit specifies that 5 dilution™
toxir??C « H i conditions) 2 species, and 6 endpoints. Retesting must be conducted within 15 days where
toxicity is demonstrated. Reporting forms for chronic WET tests are provided.
Outfall: 003 Receiving Water: Mississippi River
[ Treatment: Not described
Amount/Components : " "
0.396 MGD of active CaS04 storage pile water and contaminated nonprocess fertilizer area wastewater
Limitations
Dai ly
Parameter Average
Chronic WET N/A
Report
Maximum
N/A
N/A
Monitoring Requirements
Other
See below
Frequency
1 /month
Sample Type
24hr fw composite
Page: 169
-------
Fruity Hame: Agrico Chemical Co^any Permlt Mumber: LA0004847
Facility Description: Produces phosphoric acid
Fl
Flew
P (T)
pH
Report Ib/d
25.000000 mg/l
N/A
Report HGD
Report Ib/d
35.000000 mg/l
N/A
M/A
Report Ib/d
75.000000 mg/l
N/A
Report HGD
Report Ib/d
105.000000 mg/l
N/A
N/A
See below
3/week
continuous
3/week
continuous
record
24hr fw composite
record
LiraftlVfSCUmTtit1onsS1aSnd monitoring requirements are incorporated from the previous permit ELGs contained in 40
CFR Part 4 8 were rescinded for southern Louisiana producers. However, the ELG technology has been applied based on
BPJ, specifically limiting process discharges to only those resulting from surges caused by a 25yr 2^r rainfa I
event! Tiered P (T) limits must be calculated based on 4 tiers of recewing stream low flow and equations provided
fntho permit in order to generate a WQ-based limit for combined discharges of P (T) from Outfalls 003 and 004.
V?olKs of dSily max! P (T) are to be reported orally within 24 hours. pH Umitationsand excursions are
discussed at Outfall 102.
Outfall: 004 | Receiving Water: Mississippi River I Treatment: Not described
Amount/Components: . . ,
4.032 HGO of inactive CaS04 storage pile excess storm drainage
Parameter
Ag (T)
Al (T)
Alpha (T)
As (T)
Be (T)
Cd (T)
Chronic WET
Cr (T)
Cu (T)
Fl
Flow
Hg (T)
Hi
P
Pb (T)
Limitations
Daily
Average
N/A
Report mg/l
Report mg/l
Report mg/l
Report
Report
N/A
Report mg/l
N/A
Report mg/l
Report mg/l
Report mg/l
Report
N/A
N/A
Report mg/l
N/A
Report mg/l
Report Ib/d
Report mg/l
Report HGD
N/A
N/A
Report mg/l
H/A
Report mg/l
Report Ib/d
Report mg/l
N/A
Report mg/l
Daily
Maximum
N/A
Report mg/l
Report mg/l
Report mg/l
Report
Report
N/A
Report mg/l
N/A
Report mg/ I
Report mg/l
Report mg/l
N/A
N/A
N/A
Report mg/l
N/A
Report mg/ 1
Report Ib/d
Report mg/l
Report HGD
N/A
N/A
Report mg/l
N/A
Report mg/l
Report Ib/d
Report mg/l
N/A
Report mg/ I
Other
See below
.
See below
See below
Monitoring Requirements
Frequency
1 /month
1/week
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
3/week
continuous
1 /month
1 /month
.j^r* •
3/week
1 /month
Sample Type
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
record
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
/r-;%
Page: 170
-------
Facility Name: Agrico Chemical Company Perm-t Number: ^^
Facility Description: Produces phosphoric acid SIC Code. 2874
pH
Radium (226)
Sb (T)
Se (T)
S04
Tl (T)
TSS
U (T)
zn (T)
Report su
N/A
Report
0.400000
N/A
Report mg/l
N/A
Report mg/l
Report Ib/d
Report Ib/d
N/A
Report mg/l
Report Ib/d
Report mg/l
Report Ib/d
.Report mg/l
N/A
Report mg/l
Report su
N/A
Report
0.500000
N/A
Report mg/l
N/A
Report mg/l
Report Ib/d
Report Ib/d
N/A
Report mg/l
Report Ib/d
Report mg/l
, Report Ib/d
Report mg/l
N/A
Report mg/l
See below
See below
See below
continuous
1 /month
1 /month
1/month
3/week
1/month
3/week
1/week
1/month
•
record
24hr fw composite
24hr fw composite ,
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
Limitations/Monitoring Basis:
Ilrlft in(TVimitS mUSt ^ Cau«U,!:ated, ?as?d on 4 tiers of receiving stream low flew and equations provided in the
STSirJS™ ' VTS*? anW?;bafed l'mit f°J combined discharges of P (T) from Outfalls 003 and 004; the numbeV
of exceedances is limited to 0 (daily max.) and must also be reported as a daily avg. Compliance with an annual
noa[ of(75'/lr± ?f ^"W /^T ™ reqU1>fd * JanUarY 1- 1994' this limi* represent the ?ac ity"s pledged
9°ai,.°f 75/° reductl°n 1" P (T) discharges. Analytical procedures for measuring U (T), Ra (226) and gross alpha
particle activity [alpha (T)] are also specified in the permit. Units are pCi/day (mass) and pel/ml
(concentration) Toxic priority metals are specified in the permit as consisting of the total form of Sb, As, Be,
DHlimits ar» not 8«J'inr?A ?A ' al?d Zn". Compliance determinations are based on the HDLs provided in the perm t.
However ulSJfn i«n H»« 5' h * Pe™ittee is required isto report instantaneous minimum and maximum each month.
limitation, ?h! r,- UCT ^fement completion, the facility must submit a report which specifies achievable
thP rpri?C?A Ch™mc WET monitoring is required because pollutants present in the effluent may cause toxicity in
the receiving waters and WET is the most direct measure of potential toxicity. These conditions are set forth to
K?bu^-°tati°nS,?fMWnn!e^i0!: 3°3'- CIYr°m'C UET tests m"st include the P^evl'°us months- hghLf weekly avg. %
^•i* ? 2 U=T *tfa l °°4 d;schar9e ln the sample to be analyzed; data supporting this % must be included in the
submittal of WET testing results. Chronic WET testing limits is the same as discussed at Outfall 001. Additional
Urin^i?" hnd ^T'nM?9 f?r °°^ sPe?if'V that river flow data must be obtained from USGS for each da^ and reported
as an attachment to DHRs; the min river flow must be reported on the DMRs. A discussion of the bases of the
monitoring requirements and Ra (226) limits were not provided.
Outfall: 102 J Receiving Water: Internal to outfall 002 | Treatment: Not described
Amount/Components:
20.048 MGD of primarily noncontact cooling water with some boiler feed wastes
Parameter
Flow
PH
Temp.
Limitations
Dai ly
Average
N/A
Report HGD
N/A
N/A
N/A
Report F
Dai ly
Maximum
N/A
Report MGD
N/A
N/A
N/A
Report F
Other
See below
Monitoring Requirements
Frequency
continuous
contiuous
contiuous
Sample Type
record
rec.ord
record
Limitations/Monitoring Basis:
minut«/monthndn!!!0nlt0rl"n9 ?on'dit1ons are incorporated from the previous permit. pH excursions are limited to 446
minutes/month and_no excursions may exceed a duration of 60 minutes. pH limits are specified as 6.0 su
instantaneous minimum and 9.0 su instantaneous maximum.
Page: 171
-------
Facflfty Homo: Agrico Chemical Company
— — ^ ~ ~ ~ r~ . . SIC Code: 2874
Outfall- 105 Receiving Water: Ditch to Bayou des Acadiens Treatment: Not described
Amount/Components :
noncontaminated storm water
Parameter
COO
Flow
OSG
pH
Limitations
Average
N/A
N/A
N/A
Report HGD
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
100.000000 mg/l
N/A
Report HGD
N/A
15.000000 mg/l
N/A
N/A
Other
See below
Monitoring Requirements
Frequency
1 /month
1/week
1 /month
1 /month
Sample Type
grab
estimate
grab
, grab
UmftSSU%re3blaSedSon the -standard storm water requirements- developed by the state and EPA Region 6. PH
limits ore spocified as 6.0 su instantaneous minimum and 9.0 su instantaneous maximum.
OUtfall- 402 | Receiving Water: Internal to outfall 002 Treatment: Not described
Amount/Components :
0.173 HGO of clarifier underflow
Parameter
Clarifying agents
Flow
Limitations
Daily
Average
Report Ib/d
N/A
N/A
Report HGD
Lfmftatlons/Monitoring Basis:
Monitoring requi rements are based or
Daily
Haximum
Report Ib/d
N/A
N/A
Report HGD
Other
the Lower Hississippi River Silt Policy which
fying agents used.
Monitoring Requirements
Frequency
1/week
1/week
Sample Type
estimate
estimate
stipulates that the reporting of
Outfall: 502 | Receiving Water: Internal to outfall 002 Treatment: Not described
Amount/Components:
0.086 HGO of treated sanitary sewage
Parameter
BOOS
FC
Flow
pH
Limitations
Daily
Average
N/A
30.000000 mg/l
N/A
200.000000
N/A
Report HGD
N/A
H/A
Dai ly
Haximum
N/A
45.000000 mg/l
N/A
400.000000
N/A
Report HGD
N/A
N/A
Other-
Units: #/100 ml;see
below
See below
Honitoring Requirements
Frequency
1 /month
1 /month
1/week
1 /month
Sample Type
grab
grab
estimate
grab
Page: 172
-------
Facility Name: Agrico Chemical Company
Permit Number: LA0004847
Facility Description: Produces phosphoric acid
SIC Code: 2874
TSS
N/A
30.000000 mg/l
N/A
45.000000 mg/l
1/month
grab
Limitations/Monitoring Basis:
Limitations, except FC, are incorporated from the previous permit. Stat defined FC limitations are also included;
the basis of these limitations was not described. The FC limits will become effective upon completion of
modification to the package treatment plant. The basis of the monitoring requirements was not described. pH limits
are specified as 6.0 su instantaneous minimum and 9.0 su instantaneous maximum.
Special Conditions Basis:
Two BMPs plans are required: (1) a BMP plan developed by the permittee to mitigate shipping and handling pollutant
must comply with 40 CFR Part 125, Subpart K and be submitted to EPA Region 6 and the State within 60 days; and (2) a
BMP plan developed by the permittee to address solvent recovery from the uranium extraction process (referred to as
the FURC plant) must maximize solvent recovery to thereby minimize losses to the gypsum stack. This BMP plan must
be updated annually and be submitted to EPA Region 6 and the State. Additionally, quarterly reports must be
submitted over the 240 days estimated to complete a storm water reuse plan at the FURC plant. The BMP plan is set
forth to regulate the discharge of these pollutants. The facility has committed to the State to reduce by 75% the
discharge of pollutants from inactive gypsum stacks. A plan which involves segregating active and inactive pile
areas, recycling runoff within the active piles because of the high SW pollutant concentrations, and abating areas
within the inactive pile areas was developed. Plan implementation is currently underway and is expected to be
completed within 2 years under ideal conditions or 3 years under wet weather conditions; the permit thus requires
the affected areas to comply with discharge restrictions which generally apply to Outfall 004 and Outfall 004 P (T)
limitations by 12/31/93 (within 3 years). Quarterly reports from 10/92 to 1/94 are required as part of the
compliance schedule. Upon completion of the abatement program, periodic inspections must be conducted of
specifically cited areas. Where problems are noted, they must be reported within 15 days and corrected within 30
days; a plan must be submitted for problems requiring more than 30 days for correction. Where toxicity is
demonstrated in 2 consecutive WET tests, the facility is required to develop and siubmit, within 30 days, a plan for
the conduct of a TRE. Minimum elements of the plan include a description of the sipecific approach, methodology, and
date of TRE initiation. TRE requirements are in accordance with the typical EPA Region 6 approach. Specific
compliance threshold levels have been established for pollutants. Analytical methods must detect to the level of
the compliance threshold. For reporting purposes, zero should be used when analytical results are below the
threshold. Other special conditions include: (1) a listing of CAS and STORET numbers; (2) requirements to orally
report daily max. violations of P (T) at Outfalls 003 and 004; (3) specific VOA sampling and compositing methods;
(4) preparing and submitting a monthly summary along withDMRs of specific information at P (T) discharges at
Outfalls 003 and 004; (5) where changes in the source of rock ore occur, analyzing the rock for the Outfall 004
regulating pollutants; and (6) miscellaneous definitions, explanations, and related information. Other than
discussed above, the bases of these special conditions were not described.
Effective Date: 10/12/92
Expiration Date: 10/11/97
Abstract Date: 05/18/93
Page: 173
-------
Facility Name: Neste Resins Corporation Permit Number: LA0007501
Facility Description: Resin manufacturer Sic Code: 2821
Monitoring
Limit ELGs UQSs BPJ Only
Basis: i J. 1 I
Storm WQ
Special BHPs Water Sediment Survey
Conditions: z. z - -
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
- z z. I 1
Bio
Survey TRES MDLs Monitoring Other
- - 1 i L . I
Abstract Information:
Confute; Outfalls 001 and 002.
Outfall: 001 | Receiving Water: Brushy Creek [ Treatment: Stab, AnL, Aer, Sed
Amount/Components :
0.0319 HGO of treated kettle rinse water, contaminated storm water, misc. blowdown, condensate, and demineralizer and
sanitary wastowater.
Parameter
1,1,1-TrSchloroct
hane
1,1,2-Trichloroet
hano
1,1-Dichloroethan
e
1,1-Dichloroethyl
cno
1,2,4-Trichlorobe
nzene
1,2-Dichlorobcnzc
no
1,2-Dichloroothan
e
1,2-Oiehloropropa
ne
1,2-Trans-Dichlor
oothylcnc
1,3-Cis-Dichlorop
ropy I one
1,3-Dichlorobenze
ne
1,4-Dichlorobenze
ne
2,4-Dichloropheno
2,4-Dimethylphcno
2,4-Dinitrophenol
2,4-Dinitrotoluen
e
2,6-Dinitrotolucn
c
2-Chlorophcnol
Limitations
Dai ly
Average
0.002490 Ib/d
N/A
0.002490 Ib/d
N/A
0.002610 Ib/d
N/A
0.000380 Ib/d
0.370000 ug/l
0.008050 Ib/d
N/A
0.009120 Ib/d
N/A
0.002260 Ib/d
2.190000 ug/l
0.018120 Ib/d
N/A
0.002490 Ib/d
N/A
0.002040 Ib/d
1.980000 ug/l
0.003670 Ib/d
N/A
0.001780 Ib/d
N/A
0.004620 Ib/d
N/A
0.002130 Ib/d
N/A
0.008410 Ib/d
N/A
0.013380 Ib/d
N/A
0.030200 Ib/d
N/A
0.003670 Ib/d
N/A
Daily
Maximum
0.006400
N/A
0.006400 Ib/d
N/A
0.006990 Ib/d
N/A
0.000600 Ib/d
0.580000 ug/l
' 0.016580 Ib/d
N/A
0.019300 Ib/d
N/A
0.007010 Ib/d
6.800000 ug/l
0.027240 Ib/d
N/A
0.006400 Ib/d
N/A
0.003090 Ib/d
3.000000 ug/l
0.005210 Ib/d
N/A
0.003320 Ib/d
N/A
0.013260 Ib/d
N/A
0.004260 Ib/d
N/A
0.014570 Ib/d
N/A
0.033750 Ib/d
N/A
0.075910 Ib/d
N/A
0.011610 Ib/d
N/A
Other
Monitoring Requirements
Frequency
1/year
1/year
1/year
1/year ,
1/year .
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
Sample Type
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
Page: 174
-------
Facit.ty Name: Neste Res,ns Corporation permit Nuraber: ^^
Facility Description: Resin manufacturer
2-Nitrophenol
3,4-Benzof luorant
hene
4,6-Dinitro-o-cre
sol
4-Nitrophenol
Acenaphthene
Acenaphthylene
Acrylonitrile
Anthracene
Benzene
Benzo
-------
Facility Manns: Neste Resins Corporation
— — — — — — ^— ^— — - SIC Code: 2821
Facility Description: Resin manufacturer — ..
Flow
Fluoranthcne
Fluorene
Hexachlorobenzene
Hcxnchlorobutadie
no
Hexachlorocthane
Methyl chloride
Hethylene chlorid
e
Naphthalene
nitrobenzene
pH
Phenanthrene
Phenol
—
Phenols
Pyrene
Temp.
Tctrachloroethyle
ne
TKN
Toluene
Trichloroethylene
TSS
Vinyl chloride
Zn (T)
N/A
Report MGD
0.002960 Ib/d
N/A
0.002610 Ib/d
N/A
H/A
0.000130 ug/l
N/A
0.045000 ug/l
0.002490 Ib/d
N/A
0.010180 Ib/d
N/A
0.004740 Ib/d
N/A
0.002610 Ib/d
N/A
0.003200 Ib/d
N/A
N/A
N/A
0.002610 Ib/d
N/A
0.001780 Ib/d
N/A
0.025770 Ib/d
25.000000 ug/l
0.002960 Ib/d
N/A
N/A
N/A
0.001010 Ib/d
0.980000 ug/l
20.000000 Ib/d
N/A
0.003080 Ib/d
N/A
0.002490 Ib/d
N/A
10.000000 Ib/d
N/A
0.012320 Ib/d
N/A
0.024430 Ib/d
23.700000 ug/l
N/A
Report MGD
0.008050 Ib/d
N/A
0.006990 Ib/d
N/A
N/A
0.000240 ug/l
N/A
0.110000 ug/l
0.006400 Ib/d
N/A
0.022500 Ib/d
N/A
0.010540 Ib/d
N/A
0.006990 Ib/d
N/A
0.008050 Ib/d
N/A
N/A
N/A
0.006990 Ib/d
N/A
0.003080 Ib/d
N/A
0.051540 Ib/d
50.000000 ug/l
0.007930 Ib/d
N/A
N/A
100.000000 F
0.002580 Ib/d
2.500000 ug/l
40.000000 Ib/d
N/A
0.009470 Ib/d
N/A
0.006400 Ib/d
N/A
20.000000 Ib/d
N/A
0.031740 Ib/d
N/A
0.060730 Ib/d
58.910000 ug/l
See below
See below
Between 6.0 su and 9
.0 su
continuous
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/day
1/year
1/year
2/week
1/year
1/day
1/year
2/week
1/year
1/year
2/week
1/year
1 /month
record
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
SSI<"$'^ic:^^^^
Page: 176
-------
Facility Name: Neste Resins Corporation
Permit Number: LA0007501
:acility Description: Resin manufacturer
SIC Code: 2821
m!MT|' ^e"°iS' ben*ene- carbon tetrachloride, 1,2-dichloroethane, 1,1-dichloroethylene 1 3-
ne v?nvr,M -H '.met^ eneuChl0n'de' tetrachloroethylene, 1,1,2-trich oroethane?
Outfall: 002
Receiving Water: Brushy Creek
Amount/Components:
0.0917 HGO of once through cooling water and uncontaminated storm water runoff.
Treatment: Not specified.
Parameter
Flow
Phenols
Temp.
TKN
Daily
Average
N/A
Report HGD
N/A
N/A
N/A
N/A
N/A
Report F
N/A
N/A
Limitations
Daily
Maximum
N/A
Report MGD
N/A
N/A
N/A
0.100000 mg/l
N/A
Report F
N/A
3.000000 mg/l
Other
Between 6.0 su and 9
.0 su
imitations/Monitoring Basis:
Monitoring Requirements
Frequency
5/week
1/day
2/week
5/week
2/week
Sample Type
estimate
grab
grab
grab
grab
tbe previous
pecial Conditions Basis: '
ffective Date: 10/26/92
Expiration Date: 10/25/97
Abstract Date: OS/27/93
Page: 177
-------
Facility Hame: Louisiana PSL, Sterhngton
— — , „ SIC Code: 4931
Monitoring
Limit ELGs WQSs BPJ Only
Basis: J. I - *
Storm WQ
Special BHPs Water Sediment Survey
Conditions: - - - -
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
J_ z. - ' *-
Survey ' TRES HDLs Monitoring Other
- ' 1 J. , ' J- *
^trpap«8l;ro^ftflls 02A, 003, 005 (representing 004 and 006), and 05a
Onfall: 003 | Receiving Water: Ouachita River I Treatment: Not descnbed.
^^Vy^aY^di'scharqe of once through cooling water from Unit 6.
Parameter
Chronic WET
Flow
Temp.
TRC
Limitations
Daily
Average
N/A
N/A
N/A
Report MGD
N/A
112.000000 F
N/A
N/A
Dai ly
Maximum
N/A
N/A
N/A
159.000000 MGD
N/A
N/A
22.100000 Ib/d
0.200000 mg/l
Other
See below
115F inst. max; see
below
See below
Monitoring Requirements
Frequency
1 /quarter
continuous
continuous
1/week
Sample Type
24hr fw composite
record
record
grab
Outfall- 005 | Receiving Water: Unnamed ditch to Ouachita Rive I Treatment: Not descnbed.
0 2«"?SoCof low volume, oily wastes, and previously monitored wastes;
Parameter
Flow
OSG
P«
TSS
Limitations
Dai ly
Average
N/A
Report HGO
N/A
15.000000 mg/l
N/A
N/A
N/A
30.000000 mg/l
Daily
Maximum
N/A
Report MGD
N/A
20.000000 mg/l
N/A
N/A
N/A
100.000000 mg/l
Other
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/day
1/week
1/week
1/week
Sample Type
estimate
grab
grab
grab
lfmfTlMlS7rl™LB6"talU consistent with steam electric generating guidelines (40 CFR Part 423) and the past
permit. Monitoring requirements are based on the past permit.
Page: 178
-------
Fac,l,ty Name: Lou1Siana P&L, Sterlings perm]-t ^^ IMQ07579
(Facility Description: Steam electric power plant.
-------
:acHfty Home: Louisiana PSL, Sterlington
:acility Description: Steam electric power plant.
Permit Number: LA0007579
SIC Code: 4931
FlOM
N/A
Report HGD
N/A
Report HGD
1/day
estimate
discharging.
ar
Special Conditions Basis: , ^,.,-M1.v ,-,, reauired to develop and submit, within 30
Where toxicity is deraonstrated ,n two C0^^V^^P foftht^f^an L ude^ description ofPthe specific approach.
Effective Date: 11/01/92
Expiration Date: N/A
Abstract Date: 04/14/93
Page: 180
-------
Facility Name: Boston Edison Company
Permit Number: HA0003557
Facility Description: Steam electric power generator
SIC Code: 4931
Limit
Basis:
ELGs
J.
WQSs
I
BPJ
I
Monitoring
Only
WET
Limits
WET Testing
Only
Multiple
Categories
Tiered
Limits
Other
I
Special
Conditions:
BMPs
J.
Storm
Water
Sediment
WQ
Survey
Bio
Survey
TRES
MDLs
Monitoring
J.
Other
J.
Abstract Information:
Partial; Outfalls 001, 002, 003, 004 (representative of 005, 006, and 007), 010, and 011
Outfall: 001
Receiving Water: Cape Cod Bay
Treatment: None
Amount/Components:
447 MGD of condenser cooling water.
Parameter
Boron (B)
Flow
PH
Sodium Nitrite
Temp.
TROs
Limitations
Monthly
Average
N/A
N/A
N/A
447.000000 MGD
N/A
N/A
N/A
N/A
N/A
N/A
N/A
0.100000 mg/l
Daily
Maximum
N/A
Report
N/A
510.000000 MGD
N/A
Report
N/A
Report
N/A
102.000000
N/A
0.100000 mg/l
Other
See below
See below
See below
Units: degrees Faren
heit
Monitoring Requirements
Frequency
not given
Continuous
Continuous
not given
Continuous
When in use
Sample Type
not given
Estimate
not given
not given
not given
Grab
Limitations/Monitoring Basis:
The water quality-based pH limit requires that pH may not vary more than 0.5 su from that of the intake water (pH
monitoring frequency was not specified). The difference in temperature between the discharge and the intake shall
not exceed a daily maximum of 32 degrees Farenheit. Sodium borate may not exceed 1.0 mg/l above bcakground (by
calculation) from Outfall 001, and 16,500 mg/l in each 20,000 gallon batch of discharge sodium pentaborate. Sodium
nitrite may not exceed 2.0 mg/l (by calculation) at the point of discharge, before mixing with the Bay water. The
number of gallons of sodium nitrite released, concentration, and calculated concentration before mixing must be
monitored and reported. The rate of temperature change from Outfall 001 may not exceed 1) 3 degrees Farenheit for
any 60 minute period during normal steady state plant operation and 2) a 10 degree change for any 60 minute period
during normal loading cycling. Variation in the inlet temperature shall not be considered as an operational rise or
fall in temperature. Normal startup temperature rise may not exceed specifiedpermit limits (except in the event of
an emergency reactor shutdown). Thermal plumes from the station 1) may not deleteriously interfere with the natural
movements, reproductive cycles, or migratory pathways for the indigenous water body populations, and 2) shall have
minimal contact with the surrounding shorelines. Narrative water quality based standards require that discharges
may not jeopardize any Class SA use of Cape Cod Bay, nor violate water quality standards. State water quality
policy forms the basis for narrative effluent limits for all outfalls including a prohibition against floating,
suspended and settleable solids or visible sheen or foam that would cause aesthetically objectional conditions or
impair any assigned use of the receivinf water. Fungicides and slimicides containing trichlorophenol or
pentochlorophenol may not be used in the manufacturing process. PCBs and treated or untreated chemicals containing
heavy metals from cleaning condensers or equipment are prohibited from the discharge. Materials or concentrations
or combinations which are toxic or hazardous to aquatic life are prohibited. The Nuclear Regulatory Commission has
authority over operational limits and facility operating license DPR-35.
Outfall: 002
Receiving Water: Cape Cod Bay
Treatment: None
Amount/Components:
65 MGD thermal backwash for bio-fouling control.
Parameter
Flow
Limitations
Monthly
Average
N/A
N/A
Daily
Maximum
N/A
255.000000 MGD
Other
See below
Monitoring Requirements
Frequency
When in use
Sample Type
Estimate
Page: 181
-------
Facility Homo: Boston Edison Company Permit Number: MA0003557
Facility Description: Steam electric power generator • SIC Code: 4931
p«
Temp.
N/A
N/A
H/A
H/A
N/A
Report
N/A
120.000000
See below
Units: degrees Faren
heit
not given
Continuous
not given
Limitations/Monitoring Basis:
Tho water quality-based pH limit requires that pH may not vary more than 0.5 su from that of the intake water (pH
monitoring frequency was not specified). The difference in temperature between the discharge and the intake shall
not exceed a daily maximum of 32 degrees Farenheit. The flow is estimated as if backf lushing took place for 24
continuous hours, and flow is allowed 3 hours per day twice a week (4 times a week if necessary due to"environmental
conditions." narrative water quality based standards require that discharges may not jeopardize any Class SA use of
Cape Cod Bay, nor violate water quality standards. State water quality policy forms the basis for narrative
effluent limits for all outfalls including a prohibition against floating, suspended and settleable solids or
visible sheen or foam that would cause aesthetically objectional conditions or impair any assigned used of the
receiving water. However, when condenser leaks occur, the use of a reasonable amount of biodegradable and nontoxic
material may be used to the extent necessary to find and/or seal the leak. Fungicides and slimicides containing
trichlorophenol or pentachlorophenol may not be used in the manufacturing process. PCBs and treated or untreated
chemicals containing heavy metals from cleaning condensers or equipment are prohibited from the discharge.
Materials or concentrations or combinations that are toxic or hazardous to aquatic life are prohibited. The Nuclear
Regulatory Commission has authority over operational requirements, radionuclide discharge limits, and facility
operating license DPR-35.
Outfall: 003 | Receiving Water: Cape Cod Bay | Treatment: None
Amount/Components :
2.0 HGD intake screen wash.
Parameter
Flow
P«
Limitations
Monthly
Average
N/A
2.100000 MGD
N/A
N/A
Daily
Maximum
H/A
2.100000 MGD
N/A
Report
Other
See below
See below
Monitoring Requirements
Frequency
1/day
Continuous
Sample Type
Estimate
Grab
Limitations/Monitoring Basis:
The water quality-based pH limit requires that pH may not vary more than 0.5 su from that of the intake water (pH
monitoring frequency was not specified). The difference in temperature between the discharge and the intake shall
not exceed a daily maximum of 32 degrees Farenheit. The flow must be estimated from pump curves and operational
hours. Narrative water quality based standards require that discharges may not jeopardize any Class SA use of Cape
Cod Bay, nor violate water quality standards. State water quality policy forms the basis for narrative effluent
limits for all outfalls including a prohibition against floating, suspended and settleable solids or visible sheen
or foam that would cause aesthetically objectional conditions or impair any assigned used of the receiving water.
Outfall: 004 | Receiving Water: Cape Cod Bay [ Treatment: None
Amount/Components:
Unspecified amount of stormwater runoff.
Parameter
O&G
PH
TSS
Limitations
Monthly
Average
H/A
H/A
N/A
N/A
N/A
30.000000 mg/l
Dai ly
Maximum
N/A
15.000000 mg/l
N/A
Report
N/A
100.000000 mg/l
Other
Between 6.0 su and 8
.5 su
Monitoring Requirements
Frequency
2/year
2/year
Sample Type
Grab
Grab
Limitations/Monitoring Basis:
See limitations/monitoring basis discussion for Outfall 001.
Page: 182
-------
Facility Name: Boston Edison Company
Permit Number: MA0003557
Facility Description: Steam electric power generator
SIC Code: 4931
Outfall: 010
Receiving Water: Cape Cod Bay
Treatment: Cooling towers
Amount/Components:
17.4 HGD of plant service cooling water.
Parameter
Flow
TROs
Limitations
Monthly
Average
N/A
19.400000 MGD .
N/A
0.500000 mg/l
Daily
Maximum
N/A
N/A
N/A
1.000000 mg/l
Other
-
See below
Monitoring Requirements
Frequency
Continuous
Continuous
Sample Type
Continuous
Continuous
Limitations/Monitoring Basis:
The flow must be estimated from pump curves and operational hours. The permittee is not allowed to discharge any
pollutants except chlorine (limited as TRO based on water quality standards). If continuous chlorination is used to
control macroinvertebrates, the TRO daily maximum is 1.0 mg/l and the average daily limit is 0.50 mg/l in the
service water discharge prior to mixing with any other streams. Narrative water quality based standards require
that discharges may not jeopardize any Class SA use of Cape Cod Bay, nor violate WQSs. State water quality policy
forms the basis for narrative effluent limits for all outfalls including a prohibition against floating, suspended
and settleable solids or visible sheen or foam that would cause aesthetically objectional conditions or impair any
assigned use of the receiving water. Fungicides and slimicides containing trichlorophenol or pentachlorophenol may
not be used in the manufacturing process. PCBs and treated or untreated chemicals containing heavy metals from
cleaning condensers or equipment are prohibited from the discharge. Materials or concentrations or combinations
which are toxic or hazardous to aquatic life are prohibited. The Nuclear Regulatory Commission has authority over
operational requirements, radionuclide discharge limits, and facility operating license DPR-35.
Outfall: 011
Receiving Water: Cape Cod Bay
Treatment: None
Amount/Components:
0.01 MGD average monthly flow of makeup water and demineralization wastewater.
Parameter
Flow
PH
TSS
Limitations
Month ly
Average
N/A
0.015000 MGD
N/A
N/A
N/A
30.000000 mg/l
Daily
Maximum
N/A
0.060000 MGD
N/A
Report
N/A
100.000000 mg/l
Other
See below
Between 6.1 su and 8
.4 su
See below
Monitoring Requirements
F requency
When in use
Batch
Sample Type
Grab
Limitations/Monitoring Basis:
See Outfall 001 for discussion of limitations/monitoring basis for flow and pH.
the steam electric industry, 40 CFR Part 423.
The TSS limit is based on ELGs for
Special Conditions Basis: '
The sodium borate concentration in the storage tanks and dilution provided by the circulating water pumps flow must
be controlled. To control the sodium pentaborate release, a circulating cooling water pump must be in operation to
ensure proper dilution. Sand may be removed from the intake structure when the sand buildup interferes with the
rotating screen equipment. A barrier net must be maintained near the terminal end of the discharge canal to prevent
fish entry into the canal. If EPA or the State determine that the barrier is not effective in preventing the
mortality of menhaden or other finfish, then the permittee must maintain an average dissolvedN saturation level of
less than 115% (defined in the permit). Chlorine is the only biocide allowed. The chlorination cycle for the
circulating cooling water systems may not exceed two hours per day for each point siource, unless it can be
demonstrated to EPA that a longer period is necessary to control macroinvertebrates.. Continuous chlorination may be
used for Outfall 010, if needed to control macroinvertebrates. If continuous monitoring equipment become
inoperative, 1/day manual grab samples are allowed. Any fish kill must be reported to EPA. The State and EPA can
impose requirements for fish studies. The 1990 Environmental Monitoring Programs and plans approved by the State
and EPA are part of this permit. These documents establish environmental monitoring including the following: 1) a
technical advisory committee to ensure that marine studies are valid; 2) fish monitoring by the MA Department of
Marine Fisheries; 3) impingement rate monitoring for the four travelling intake screens; 4) 2/yr flora and fauna
benthic monitoring; and 1/week or 2/week entrainment monitoring focusing on ichthyoplankton. All live fish trapped
in intake screens must be returned to the water in an area located outside the thermal plume to prevent impingement.'
Sluice waters employed in backwashing the intake screens must bedechlorinated before use. The 1990 program also
includes thermal discharge fish surveillance activities including the following: 1) overflights to locate and notify
the plant of large schools of fish in the vicinity; 2) observation of the discharge canal; and 3) diver inspections
of the discharge canal and fish barrier net. The third part of the 1990 program describes the actions taken to
Page: 183
-------
Facility Name: Boston Edison Company
Facility Description: Steam electric power generator
determine when dissolved nitrogen saturation reduction is
If nitrogen saturation reduction is needed, the plant may
necessary to prevent
have to reduce power
Effective Date: 04/29/91 Expiration Date: 04/29/96
Permit Number: MA0003557
SIC Code: 4931
fish kills due to gas bubble disease.
geration or shutdown.
Abstract Date: 07/01/93
Page: 184
-------
Fac,l,ty Name: Worcester Spinning & Finishing Permit Number; HAQ004171
Facility Description: Textile finisher ^n „ ^ ^^
Limit ELGs «
-------
Facility Hmnci Worcester Spinning & Finishing Permit Number: MA0004171
. ~~ TT " SIC Code: 2269
Facility Description: Textile finisher ____==__!=__=»=__=_=—=—=
Special Condition* Ba^s: notified if any existing maunfacturing, commercial, mining, and silviculture
discharge" hive reason to believe that a toxic pollutant not limited in the permit may be routinely or frequently
^
r
control of toxic and hazardous pollutants.
Effective Date: 10/30/92
Expiration Date: 10/30/97 Abstract Date: 09/09/93
Page: 186
-------
Facility Name: Strathmore Paper Company Permit Number: MA0005011
Facility Description: Manufacture nonintegrated specialty papers from cotton and wood pulp SIC Code: 2679
. . .. Monitoring WET WET Testing Multiple
Limit ELGs WQSs BPJ Only Limits Only Categories
Basis: I I 11 i. I • 1
Storm WQ Bio
Special BMPs Water Sediment Survey Survey TRES MDLs
Conditions: J_ - - - . . -
" Tiered
Limits Other
- ••- " I
Monitoring -Other
Abstract Information:
Complete; Outfalls 001 and 003.
Outfall: 001 | Receiving Water: Connecticut River | Treatment: None
Amount/Components: ,
Unspecified amount of sandfilter backwash from river intake.
Parameter
Flow
pH
TSS
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
30.000000 mg/l
Daily
Maximum
N/A
Report MGD
N/A
Report
N/A
60.000000 mg/l
Other
See below
Between 6.5 su and 8
.3 su
Monitoring Requirements
Frequency Sample Type
Continuous Total
not given not given
See below I 1/day 4 grabs
Limitations/Monitoring Basis:
The TSS limit was retained from the previous permit to prevent backsliding per 40 CFR Part 122.44(1) During
periods in which the silt load carried by the Connecticut River exceeds 100 mg/l TSS, the effluent may not exceed
that of the intake water. Under these circumstances, the permittee must monitor and report TSS of the influent and
submit the results with the corresponding DMR. Flow monitoring must be conducted continuously when the facility
discharges and TSS must be monitored each day a discharge occurs. A report of no discharge must be submitted when
Outfall 001 is not in use. State water quality policy forms the basis for the pH limit. Water quality-based
narrative effluent limits include a prohibition against floating, suspended and settleable solids or visible sheen
or foam that would cause aesthetically objectional conditions or impair any assigned use of the receivinq water
Other monitoring requirements were based on 40 CFR Part 122.44CJ), 122.44(i), and 122.48.
Outfall: 003 | Receiving Water: Northeast Utilities Power Cana | Treatment: Neut, ChPt, Microstrain
Amount/Components :
2.17 MGD treated process wastewater.
Parameter
Acute WET
BODS
Chronic WET
Flow
pH
Limitations
Monthly
Average
N/A
N/A
660.000000 Ib/d
N/A
N/A
N/A
N/A
Report MGD
N/A
Report
Daily
Maximum
N/A
Report
1320.000000 Ib/d
N/A
N/A
N/A
N/A
Report MGD
N/A
Report
Other
See below
See below
Between 6.5 su and 8
.3 su
Monitoring Requirements
Frequency
1/quarter
2/week
1/quarter
Cont i nuous
not given
Sample Type
not given
Composite
not given
Daily total
not given
Page: 187
-------
Facility Mame: Strathmore Paper Company
Permit Number: MA0005011
Facility Description: Manufacture nonintegrated specialty papers from cotton and Hood pulp
SIC Code: 2679
TSS
500.000000 Ib/d
N/A
1000.000000 Ib/d
N/A
2/week
Composite
Production-based ELGs were calculated for the BOD and TSS limits per 40 CFR Part 430.180, Subpart R, for the
manufacture of about 72 tons per day of nonintegrated cotton specialty papers from cotton and wood pulp. The
existing permit limits were established prior to the ELGs. The TSS limit was retained from the previous permit to
prevent backsliding per 40 CFR Part 122.44
-------
Limit
Basis:
Special
Conditions:
ELGs WQSs
J. I
Storm
BHPs Water
BPJ
Sediment
Monitoring WET
Only Limits
I I
WQ Bio
Survey Survey
Abstract Information:
Partial; Outfalls 005 (representative of 007), 006 (representative of
Outfall: 005
| Receiving Water:
WET Testing Multiple
Only Categories
TRES MDLs
Tiered
Limits Other
j_
Monitoring Other
008 and 010), 01s (representative of 02s-09s) and
Taunton R. /Muddy Cove Brook
Treatment: None
Amount/Components: •
0.067 HGD uncontaminated noncontact cooling water.
Parameter
Color
Flow
PH
Temp.
Limitations
Monthly
Average
N/A
Report
N/A
0.500000 MGD
N/A
Report
N/A
N/A
Daily
Maximum
N/A
Report
N/A
1.000000 MGD
N/A
Report
N/A
83.000000
Other
See below
Between 6.5
.0 SU
SU and 8
Units: degrees faren
heit
Monitoring Requirements
Frequency
1/quarter
1 /month
1 /month
1 /month
Sample Type
grab
report daily flow
4 grabs report range
4 grabs
006
Receiving Water: Taunton R./Muddy Cove Brook
Treatment: None
nount/Components:
0.018 MGD uncontaminated noncontact cooling water.
Parameter
Flow
PH
Temp.
Zn (TR)
Limitations
Monthly
Average
N/A
0.400000 MGD
N/A
N/A
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
1.500000 MGD
N/A
Report
N/A
83.000000
N/A
N/A
Other
Between 6.5 su and 8
.0 su
Units: degrees Faren
heit
Monitoring Requirements
Frequency
1/month
1 /month
1 /month
Limitations/Monitoring Basis:
fi^'h^ sal?Pte\comPosed of at_least 4 grab samples must be collected 15 minutes apart
m L?T ?»aJ^m eV2n^dy£ln9 n°rmal bus'"ess hours. Other monitoring requirements
122.44Q), 122.44(0, and 122.48. See Outfall 01s for pH limitations basis qulrements
Sample Type
not given
4 grabs
Grab
Page: 189
-------
Facflfty Name: ICI Americas Inc. .
Facility Description: Specialty organic chemical manufacturer
Outf.lt: 011A | Receiving Water: Taunton R./Huddy Cove Creek Treatment: Unspecified b,ological treatmen
Amount/Components:
0.3 HGO treated wastewater.
Parameter
1,1,1-THehloroet
hone
1,1,2-Trichloroet
hone
1,1-Dlchloroethan
e
1,1-Dichloroethyl
ene
1,2,4-Trichlorobe
nzcnc
1,2-Dichlorobenze
no
1,2-Dichloroethan
e
1,2-Dichloropropa
ne
1,2-Trans-Dichlor
oethylcne
1,3-Oichlorobenze
ne
1,3-Dichloroprope
ne
1,4-Dichlorobenze
ne
2,4-Dichloropheno
I
2,4-Dfmethylpheno
2,4-Dinitrophenol
2,4-Dfnitrotoluen
e
2,6-Dinitrotolucn
e
2-Chlorophenol
2-Hitrophenol
3,4-Benzofluorant
hcne
4,6-Dinitro-o-cre
sol
4-Hitrophenol
Limitations
Monthly
Average
0.040000 Ib/d
H/A
0.040000 Ib/d
H/A
0.050000 Ib/d
H/A
0.030000 Ib/d
H/A
0.140000 Ib/d
H/A
0.160000 Ib/d
N/A
0.140000 Ib/d
N/A
0.320000 Ib/d
N/A
0.040000 Ib/d
N/A
0.070000 Ib/d
H/A
0.060000 Ib/d
H/A
0.030000 Ib/d
N/A
0.080000 Ib/d
N/A
0.040000 Ib/d
H/A
0.150000 Ib/d
N/A
0.240000 Ib/d
H/A
0.530000 Ib/d
H/A
0.070000 Ib/d
N/A
0.090000 Ib/d
N/A
0.050000 Ib/d
H/A
0.160000 Ib/d
N/A
0.150000 Ib/d
N/A
Dai ly
Maximum
0.110000 Ib/d
N/A
0.110000 Ib/d
N/A
0.120000 Ib/d
N/A
0.050000 Ib/d
N/A
0.290000 Ib/d
N/A
0.340000 Ib/d
N/A
0.440000 Ib/d
H/A
0.480000 Ib/d
N/A
0.110000 Ib/d
N/A
0.090000 Ib/d
N/A
0.090000 Ib/d
H/A
0.060000 Ib/d
N/A
0.230000 Ib/d
H/A
0.080000 Ib/d
N/A
0.260000 Ib/d
N/A
0.590000 Ib/d
H/A
1.340000 Ib/d
N/A
0.200000 Ib/d
N/A
0.140000 Ib/d
H/A
0.130000 Ib/d
N/A
0.580000 Ib/d
N/A
0.260000 Ib/d
N/A
Other
->'-
Monitoring Requirements
Frequency
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1/month
1 /month
1/month
1/month
1/month,
1/month
1/month
1/month
1/month
1 /month
1/month
1/month
Sample Type
Grab
Grab
Grab
Grab
Composite
Composite
Grab
Grab
Grab
Composite
Grab
Composite
Composite
Composite
Composite
Composite
Composite
Compos i te
Composite
Composite
Composite
Composite
Page: 190
-------
Facility Name: ICI Americas Inc. Permit Number: HA0005291
Facility Description: Specialty organic chemical manufacturer , SIC Code: 2869
Acenaphthene
Acenaphthylene
Acrylonitrile
Acute WET
Anthracene
Benzene
Benzo (a) anthrac
ene
Benzo (a) pyrene
Benzo (k) fluoran
thane
Bis (2-ethylhexyl
) phthalate
BODS
Bromoform
Carbon tetrachlor
ide
Chlorobenzene
Chloroethane
Chloroform
Chrysene
CM CT)
Co
-------
Facility Name: 1CI Americas Inc. Permit Number: MA0005291
Facility Description: Specialty organic chemical manufacturer SIC Code: 2869
Ethylbenzene
Fe (T)
Flow
Fluoranthcnc
Fluorcne
Hexachlorobonzone
Hexachlorobutadie
ne
Kcxaehlorocthanc
Methyl chloride
Hcthylene chlorid
e
Naphthalene
HH3-H
Ml
Hitrobcnzene
Other
Pb
pH
Phcnanthrene
Phenol
Pyrene
Temp.
Tetrachloroethyle
ne
Toluene
Trichloroethylene
TSS
0.070000 Ib/d
M/A
3.000000 Ib/d
N/A
N/A
0.255000 HGD
0.050000 Ib/d
N/A
0.050000 Ib/d
N/A
0.030000 Ib/d
N/A
0.040000 Ib/d
N/A
0.040000 Ib/d
N/A
0.180000 Ib/d
N/A
0.080000 Ib/d
N/A
0.050000 Ib/d
N/A
120.000000 Ib/d
N/A
0.880000 Ib/d
N/A
0.060000 Ib/d
N/A
75.000000 Ib/d
N/A
0.330000 Ib/d
N/A
N/A
N/A
0.050000 Ib/d
N/A
0.030000 Ib/d
N/A
0.050000 Ib/d
N/A
N/A
Report
0.040000 Ib/d
N/A
0.050000 Ib/d
N/A
0.040000 Ib/d
N/A
119.000000 Ib/d
N/A
0.230000 Ib/d
N/A
6.000000 Ib/d
N/A
N/A
0.300000 MGD
0.140000 Ib/d
N/A
0.120000 Ib/d
N/A
0.060000 Ib/d
N/A
0.100000 Ib/d
N/A
0.110000 tb/d
N/A
0.400000 Ib/d
N/A
0.190000 Ib/d
N/A
0.120000 Ib/d
N/A
325.000000 Ib/d
N/A
1.190000 Ib/d
N/A
0.140000 Ib/d
N/A
150.000000 tb/d
N/A
0.450000 Ib/d
N/A
N/A
Report
0.120000 Ib/d
N/A
0.050000 Ib/d
N/A
0.140000 Ib/d
N/A
N/A
Report
0.110000 Ib/d
N/A
0.170000 Ib/d
N/A
0.110000 Ib/d
N/A
382.000000 Ib/d
N/A
Phosphate
Between 6.0 su and 8
.5 su
Units: degrees Faren
heit
1 /month
1/week
Continuous
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1/week
1/week
1 /month
1/week
1/week
Continuous
1 /month
1 /month
1 /month
1 /month
1/month
1 /month
1/month
1/week
Grab
Compos i te
Recorder
Composite
Composite
Composite
Composite
Composite
Grab
Grab
Composite
Grab
Composite
Composite
Compos i te
Composite
Report range
Composite
Composite
Composite
Grab
Grab
Grab
Grab
Composite
Page: 192
-------
Facility Name: ICI Americas Inc.
Permit Number: MA0005291
Facility Description: Specialty organic chemical manufacturer
SIC Code: 2869
Vinyl chloride
Zn (T)
0.220000 Ib/d
N/A
0.260000 Ib/d
N/A
0.560000 Ib/d
N/A
0.910000 Ib/d
N/A
1/month
1/week
Grab
Composite
.imitations/Monitoring Basis:
BOD and TSS limits and 56 toxic organic pollutant limits are based on ELGs, 40 CFF! Part 414, OCPSF category. The
daily maximum CN and Cu limits are water-quality based. Cr, An, Ni, and Pb limits are technology-based past
demonstrated performance limits. EPA and the MADEP approved computer modelling using UDKHDEN for calculating the
zone of initial dilution (ZID). End-of-pipe NH3 limits are calculated using background stream concentration (200
ug/l) and the computer dispersion ratios of 77:1 at the boundary of the ZID and 330:1 for the total mixing zone.
For Fe, Co, and P, antibacksliding requires the existing permit limits to remain. Monitoring only was required for
color since the discharge through a diffuser will eliminate color concerns. Color must be monitored quarterly
during the first half hour of a storm event. Effluent temperature and bromoform parameters arerequired to be
monitored. The pH limits are based on the State water quality certification requirements for salt waters. State
water quality policy forms the basis for narrative effluent limits for all outfalls including a prohibition against
floating solids or visible foam in other than trace amounts. WET is limited using the LC50 at 10.8% dilution per
the Technical Support Document for Water Quality-based Toxics Control, EPA/505/2-90-001, March 1991. For each
monitoring event, two species must be tested. WET protocol require chemical analysis for pH, specific conductance,
salinity, TRO, TSS, NH3, TOC, Cd, Cr, Ni, Pb, Zn, Cu, and Al for each sampling evont. After a full year of
quarterly toxicity data, the permittee may request reduced monitoring for WET. Other monitoring requirements are
based on 40 CFR Part 122.44CJ), 122.44O"), and 122.48.
Outfall: 01S
Receiving Water: Taunton R./Muddy Cove Brook
Treatment: None
Amount/Components:
Unspecified amount of stormwater.
Parameter
Acute WET
Color
PH
Average
N/A
N/A
N/A
N/A
N/A
N/A
Limitations
Maximum
N/A
Report
N/A
Report
N/A
Report SU
Other
See below
Report only
Report range
Monitoring Requirements
Frequency
1 /quarter
1 /month
1 /month
Sample Type
composite
grab
4 grabs
Limitations/Monitoring Basis:
Monitoring only is required for color since the discharge through a diffuser will eliminate color concerns. Color
must be monitored quarterly during the first half hour of a storm event. pH limits are based on the Statewater
quality certification requirements for salt waters. WET is limited using the LC5D at 10.8% dilution per the
Technical Support Document for Water Quality-based Toxics Control, EPA/505/2-90-001, March 1991. For eachmonitoring
event, two species must be tested. WET protocol require chemical analysis for pH, specific conductance, salinity,
TRO, TSS, NH3, TOC, Cd, Cr, Ni, Pb, Zn, Cu, and Al for each sampling event. After a full year of quarterly toxicity
data, the permittee may request reduced monitoring for WET. For Outfall 01s, composite samples composed of at least
4 grab samples must be collected 15 minutes apart, commencing during the first hourof a storm event, during normal
business hours.
Special Conditions Basis:
Prior to rerouting any non-contact cooling water discharge to the treatment plant or elsewhere, EPA and DEP must be
notified at least 30 days in advance.
Effective Date: 07/18/92
Expiration Date: 07/18/97
Abstract Date: 07/03/93
Page: 193
-------
Facility Hamc: Boise Cascade ' Permit Number: ME0002054
Facility Description: Pulp and paper manufacturer , SIC Code: 2621
Monitoring WET ,WET Testing Multiple "Tiered . '
Limit ELGs WQSs , BPJ Only Limits Only Categories Limits Other
Basis: 1 I I I ± ._ ._ ._ ,_ _ . . ;
Storm WQ Bio -• . • .
Special BHPs Water Sediment Survey Survey TRES MDLs Monitoring Other
Conditions: 1 ^ 1 - . I I I -I
Abstract Information:
Partial; Outfalls 001 and 002 (representative of 003 and 004). Outfall designations 001A and 001B created for
abstracting purposes. ' '
Outfall: 001A | Receiving Water: Androscoggin River | Treatment: Direct 02 injection
Amount/Components :
Parameter
2,3,7,8-TCOD
2,3,7,8-TCOF
Acute WET
AOX
BOOS
Color
Flow
pH
Temp.
TSS
Limitations
Monthly
Average
M/A
N/A
N/A
N/A
N/A
N/A
Report Ib/d
Report mg/l
12000.000000 Ib/d
N/A
N/A
N/A
N/A
34.000000 MGD
M/A
N/A
N/A
Report
32900.000000 Ib/d
N/A
Daily
Maximum
4.600000 mg/d
0.030000 ug/l
91.000000 ug/d
Report ug/l
N/A
Report
N/A
N/A
20000.000000 Ib/d
N/A
N/A
Report
N/A
N/A
N/A
Report
N/A
Report
61400.000000 Ib/d
N/A
Other
See below
Report Ib/ton bleach
pulp
Seasonal, see below
Quarterly avg: 225 I
b/ton
Between 5.0 su and 9
.0 su
Units: degrees, Faren
heit
Monitoring Requirements
Frequency
2/quarter
2/quarter
1/quarter
1 /month ,
1/day
3/week
continuous
1/day
, 1/day
1/day
Sample Type
72 hr composite
72 hr composite
24 hr composite
24 hr composite
24 hr fw composite
24 hr composite
record
grab
grab
24 hr composite
Limitations/Monitoring Basis:
The limits shown for Outfall 001A are effective from June 1 through September 30 of each year. BOD and TSS limits
arc production based, using ELGs in 40 CFR Part 430, Subparts I, 0 and R. BOD limits are based on 40 CFR 125.3 and
antibacksliding regulations in 40 CFR 122.44(1) and past demonstrated performance. Flow limit was adopted from
previous permit. The maximum daily flow limit was deleted because it did not affect the toxics limits. Oxygen
injection is required at a minimum rate of 27,000 Ib/d at a point downstream of the facility between June 1 and
September 30. The TSS limit is based on the ELGs for fine kraft, groundwood, and nonintegrated paper using an
average production value. The color limit is a quarterly average limit. The 2378-TCDD limits apply for the first 2
years following permit issuance. Compliance is determined based on a detection level of 10 pq/l. This interim
limit is BPJ based, as determined by past demonstrated performance. The dioxin limit is required due to past
detections in the effluent and the fact that it is a 304(1) pollutant in Maine. The WET limit was calculated based
on acceptable instream mixing and a less than or equal to NOEC at 3.3%. Acute WET test protocols are specified,
using Ceriodaphnia dubia and fathead minnows, with salmonid substituted in Feb and Aug. The pH limit is based on
ELGs. Reporting is required for both discharge and ambient pH. The color limit is based on state effluent
standards for existing bleached kraft mills., Narrative WQSs are included in the permit. The permit prohibits the
use of chlorophenolic biocides. AOX monitoring was justified as a means to screen for one or more chlorinated
organic compounds which may be toxic or may contribute to toxicity.
Page: 194
-------
Facility Name: Boise Cascade Permit Number: HE0002054
Facility Description: Pulp and paper manufacturer SIC Code: 2621
Outfall: 002 | Receiving Water: Androscoggin River | Treatment: None
Amount/Components :
5 MGD noncontact cooling water
Parameter
Flow
PH
Temp.
Limitations
Monthly
Average
N/A
5.000000 MGD
N/A
N/A
N/A
N/A
Dai ly
Maximum
N/A
N/A
N/A
Report
N/A
95.000000
Other
Between 6.0 su and 8
.5 su
Units: degrees Faren
heit
Monitoring Requirements
Frequency
1 /month
1 /month
1 /month
Sample Type
record
grab
grab
Limitations/Monitoring Basis:
pH must be no lower than 0.5 su than the upstream pH. Flow, temperature, and pH limits and monitoring conditions
are continued from the previous permit.
Outfall: 001B | Receiving Water: Androscoggin River | Treatment: Direct 02 injection
Amount/Components:
Parameter
2,3,7,8-TCDD
2,3,7,8-TCDF
Acute WET
AOX
BODS
Color
Flow
pH
Temp.
TSS
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
Report Ib/d
Report mg/ I
12000.000000 Ib/d
N/A
N/A
N/A
N/A
34.000000 MGD
N/A
N/A
N/A
Report
32900.000000 Ib/d
• N/A
Daily
Maximum
91.000000 ug/d
N/A
N/A
0.200000 ug/l
N/A
Report
N/A
N/A
20000.000000 Ib/d
N/A
N/A
Report
N/A.
N/A
N/A
Report
N/A
Report
61400.000000 Ib/d
N/A
Other
See below
Report Ib/ton bleach
pulp
Seasonal, see below
Quarterly avg: 225 I
b/ton
Between 5.0 su and 9
.0 su
Units: degrees Faren
heit
Monitoring Requirements
Frequency
2/quarter
2/quarter
1/quarter
1 /month
1/day
3/week
continuous
1/day
1/day
1/day
Sample Type
72 hr composite
72 hr composite
24 hr composite
24 hr composite
24 hr fw composite
24 hr composite
record
grab
grab
24 hr composite
Limitations/Monitoring Basis:
The limits shown for Outfall 001B are effective from October 1 through Hay 31 of each year. See the
limitations/monitoring basis for Outfall 001A. The final limit for 2378-TCDD is water quality based, and is
effective 2 years after permit issuance.
Special Conditions Basis:
A BMP plan is required to reduce 2378-TCDD and 2378-TCDF and AOX in pulping and bleaching operations and wastewater
treatment. BMPs for chlorine minimization are required to support the interim BAT limits for 2378-TCDD. Fish tissue
monitoring for 2378-TCDD and 2378-TCDR are required annually in August for resident black bass and bullheads or
white suckers (or DEP-approved alternative organism). Fish tissue will be used to indicate whether effluent levels
are causing excursions above numeric standards. A thermal impact study is required to assess compliance with Maine
Page: 195
-------
Facility Nome: Boise Cascade
Permit Mumber: ME0002054
Facility Description: Pulp and paper manufacturer
SIC Code: 2631
temperature standards. An emergency response plan is required for detection of, and notification about malfunctions
of the oxygen injection system that is located downstream of the plant. The permittee must participate in the
State's priority pollutant program described in a 11/1/90 letter to the DEP from the Paper Industry Information
Office. Two reports to EPA within 2 years are required on (1) the economic and environmental impacts of alternative
hydroelectric eithdraual sites and operating procedures which would improvesummer DO levels in Gulf Island Pond, and
(2) an evaluation of possible inplant processing changes or wastewater treatment changes which could yieldat least a
10X reduction in actual summer BOO in the river. Within 3 years of the permit effective date, a report to EPA is
due evaluating the economic and environmental impacts of removing high oxygen demanding sediments from Gulf Island
Pond. Additional standard conditions are set forth per40 CFR Part 122.42(a)(1).
Effective Date: 04/30/92
Expiration Date: 03/30/97
Abstract Date: 09/27/93
Page: 196
-------
Facility Name: S.D. Warren Co - Scott Paper
Permit Number: HE0002321
Facility Description: Pulp and paper manufacturer
SIC Code: 2621
Limit
Basis:
ELGs
J.
WQSs
J.
BPJ
I
Monitoring
Only
J.
WET
Limits
I
WET Testing
Only
Multiple
Categories
Tiered
Limits
J.
Other
J.
Special
Conditions:
BMPs
I
Storm
Water
Sediment
WQ
Survey
J.
Bio
Survey
J.
TRES
J.
MDLs
Monitoring
I
Other
Abstract Information:
Complete; Outfalls 001 and 003 (designated as 001A, 001B, 003A, and 003B for abstracting purposes) and 002.
Outfall: 001A
Receiving Water: Presumpscot River
Treatment: AS
Amount/Components:
19 MGD process wastewater, sand filter backwash, and noncontact cooling water
Parameter
2,3,7,8-TCDD
2,3,7,8-TCDF
Acute WET
AOX
BODS
Chronic WET
Color
Flow
PH
TSS
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
Report
Report mg/l
4500.000000 Ib/d
N/A
N/A
N/A
N/A
Report
N/A
21.000000 MGD
N/A
N/A
12810.000000 Ib/d
N/A
Daily
Maximum
2.000000 mg/d
0.030000 ug/l
Report ug/d
0.200000 ug/l
N/A
Report
N/A
N/A
10200.000000 Ib/d
N/A
N/A
Report
N/A
Report
N/A
N/A
N/A
Report
25570.000000 Ib/d
N/A
Other
See below
See below
See below
Report kg/ton bleach
pulp
See below
Quarterly avg: 225 I
b/ton
Between 5.0 su and 9
.0 su
See below
Monitoring Requirements
Frequency
2/quarter
2/quarter
1/quarter
1/month
1/day
1/quarter
3/week
continuous
1/day
1/day
Sample Type
72 hr composite
72 hr composite
24 hr composite
24 hr composite
24 hr composite
24 hr composite
24 hr composite
record
grab
24 hr composite
Limitations/Monitoring Basis:
The limits shown for Outfall 001A apply to 001 during June 1 through October 31. The TSS and pH limits are ELG
based (40 CFR Part 430 for bleached kraft paper). The 2378-TCDD limit is BPJ based using the 1988-89 EPA/Paer
Industry Cooperative Dioxin Study and onsite testing. The state has established this limit as BAT and it applies
for the first three years of permit issuance. After that time, the daily maximum limits for 2378-TCDD are 31 ug/d
and report ug/l; these are water quality based limits. Acute and chronic WET testing is to be conducted following
??«CI*li Pr°tocols, using 3 species. The limits were calculated based on acceptable instream mixing with less than
14/. effluent for and acute NOEC and less than or equal to 12.5% effluent for the chronic NOEC. The permit contains
a heat added requirement based on water quality standards of 700 million Btu/d maximum daily during June 1 through
September 30 and 7 billion Btu/d during the remaining months of the year. The protocol for color monitoring is
provided in the permit, and is based on state standards. BOD limits are based onWQSs and antibacksliding
requirements. AOX monitoring is deemed necessary to screen for the presence of potentially toxic chlorinate
compounds.
Page: 197
-------
Facility Mamo: S.O. Warren Co - Scott Paper ' . Permit Number: ME0002321
Facility Description: Pulp and paper manufacturer , SIC Code: 2621
Outfall: 001B | Receiving Water: Presumpscot River Treatment: AS
19 HGO process wastewater, sand filter backwash, and noncontact cooling water
Parameter
2,3,7,8-TCDD
2,3,7,8-TCDF
Acute WET
AOX
BODS
Chronic WET
color
Flow
pH
TSS
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
Report
Report mg/l
6500.000000 Ib/d
N/A
N/A
N/A
N/A
Report
N/A
21.000000 MGD
N/A
N/A
14200.000000 Ib/d
N/A
Daily
Maximum
2.000000 mg/d
0.030000 ug/l
Report ug/d
0.200000 ug/l
N/A
Report
N/A
N/A
12000.000000 Ib/d
N/A
N/A
Report
N/A
Report
N/A
N/A
N/A
Report
26400.000000 Ib/d
N/A
Other
See below
See below
See below
Report kg/ton bleach
pulp
See below
Quarterly avg: 225 I
b/tpn
Between 5.0 su and 9
.0 su
See below
Monitoring Requirements
Frequency
2/quarter
2/quarter
1/quarter
1 /month
1/day
1/quarter
3/week
continuous
1/day
1/day
Sample Type
72 hr composite
72 hr composite
24 hr composite
24 hr composite
24 hr composite
24 hr composite
24 hr composite
record
grab
24 hr composite
Liraitations^onUonng Basis: 001B apply to 001 during November 1 through May 31. The 2378-TCDD limit is water
walty based and applies three years after permit issuance. The limit is based on EPA human health criteria and
assumes harmonic raeah flow. The color limit is expressed as a quarterly average and is based on an allowance under
state law to exceed state established BPT. The heat limit applies Oct 1 through May 31 and is water quality based
(MEOEP regulations. Ch. 582). Heat added during Nov 1 through May 31 must not exceed 7 billion Btu/d, and the
permittee is required to report the monthly average Btu/d. as well as the degrees Farenheit. The WET limits were
deemed necessary to protect against acute or chronic effects in teh receiving water.
Outfalls 002 | Receiving Water: Presumpscot River I Treatment: None
Amount/Components: '
75,000 gpd water treatment filter backwash
Parameter
Flow
P«
TSS
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
20.000000 mg/l
Dai ly
Maximum
N/A
Report MGD
N/A
Report
N/A
60.000000 mg/l
Other
Between 5.0 su and 8
.5 su
Monitoring Requirements
Frequency
1/day
1 /month
1 /month
Sample Type
estimate
grab
24 hr composite
L m t7he°pH Umi/'is'based'on state requirements. The TSS limit is based on the previous permit. The permit prohibits
the use of chemical additives to backwash water.
Page: 198
-------
Facility Name: S.D. Warren Co - Scott Paper
Permit Number: ME0002321
Facility Description: Pulp and paper manufacturer
SIC Code: 2621
Outfall: 003A
Receiving Water: Presumpscot River
Treatment: None
Amount/Components:
5 MGD noncontact cooling water
Parameter
Flow
PH
Temp:
' ' ' Limitations ' '
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
Dai ly
Maximum
N/A
Report MGD
N/A
Report
N/A
Report
Other
Between 5.0 su and 8
.5 su
See below
Monitoring Requirements
Frequency
1/day
1/week
2/day
Sample Type
estimate
grab
grab
Limitations/Monitoring Basis: '
The limits shown for Outfall 003A apply June 1 through September 30,. The pH limit is based on statelcertification.
the heat limit is based on state regulations, MEDEP reguations Ch 582, and is 700 million Btu/d daily maximum. The
permit prohibits cooling water additives.
Outfall: 003B
Receiving Water: Presumpscot River
Treatment: None
Amount/Compopents:
5 HGD noncontact cooling water
Parameter
Flow
Temp.
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
,N/A
Daily
Maximum
N/A
Report MGD
N/A
Report
N/A
Report
Other
Between 5.0 su and 8
.5 su
See below
Monitoring Requirements
Frequency
1/day
1/week
2/day
Sample Type
estimate
grab
grab
Limitations/Monitoring Basis: ' '
The limits shown for Outfall 003B apply October 1 through May 31'. The pH limit, is based on state certification.
The heat limit is based on state regulations, MEDEP regulations Ch 582, and is 7 billion Btu/d daily maximum. The
permit prohibits cooling water additives.
Special Conditions Basis:
A requirement is imposed for the facility to continue to implement its program to reduce 2378-TCDD and 2378-TCDF.
The permittee must submit annual reports on this program. Fish tissue monitoring is required for 2378-TCDD and
2378-TCDF annually during August for black bass and bullheads or white suckers, or a DEP-approved alternative
organism. The survey also requires monitoring of 10 softshelled clams (Mya arenaria) from the river for 2378-TCDD
and 2378-TCDF t'esting following protocol in the "Sampling Guidance Manual for the National Dioxin Study" (EPA,
1984). The permittee must ensure that the discharge does not cause or contribute to elevation of toxics in the
river above water quality criteria for toxic pollutants as referenced in Maine Law Title 38 MRSA 420. Within 18
months' of permit issuance, the permit requires a plan outlining monthly toxics monitoring upstream,in the effluent
and downstream, to determine whether the discharge is causing exceedances of WQSs. The plan must compare water
quality criteria with the effluent Cu and Pb concentrations. A state approved biological survey must be conducted •
within 18 months of the effective date of the permit. This survey includes fish, macroinvertegrate, plant community
arid benthic organisms located below the discharge and in the estuary. The plan must include instream monitoring for
the temp., DO, and TSS. Additional standard conditions are set forth per 40 CFR Part 122.42(a)(1). State and EPA
WET testing protocols are attached to the permit. Analytical methods andMDLs are provided for AOX, color, 2378-TCDD
and WET analysis.
Effective Date:
10/28/92
Expiration Date:
10/28/97
Abstract Date:
09/27/93
Page: 199
-------
Facility Name: The Cumberland Farms, Inc. Permit Number: ME0022314
Facility Description: The facility stores and distributes refined petroleum products. SIC Code: 5171
Monitoring
Limit ELGs WQSs BPJ Only
Basis: - J. J. I
Storm WQ
Special BMPs Water Sediment Survey
Conditions: J. J. ^ r.
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
- 1 - - -
Bio
Survey TRES MDLs Monitoring Other
- - I 1 -
Abstract Information:
Complete outfalls; 001 (A, B, and C for abstracting purposes), and 002.
Outfall: 001A | Receiving Water: Fore River on Casco Bay | Treatment: API
Amount/Components :
Unspecified amount of storm water runoff from fuel storage areas including boiler blowdown.
Parameter
Acute WET
Benzene
Ethylbenzene
Flow
086
PAHs
pH
Toluene
TSS
Xylcncs
Limitations
Average
N/A
N/A
N/A
500.000000 ug/l
N/A
N/A
N/A
Report
N/A
N/A
N/A
60.000000 ug/l
N/A
N/A
N/A
N/A
N/A
30.000000 mg/l
N/A
N/A
Maximum
N/A
Report
N/A
N/A
N/A
Report
N/A
3HO. 000000 GPM
N/A
15.000000 mg/l
N/A
N/A
N/A
Report SU
N/A
Report
N/A
100.000000 mg/l
N/A
Report
Other
See below
No units specified
No units specified
No units specified
Monitoring Requirements
Frequency
3/year
1 /month
1 /month
Continuous
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
Sample Type
grab
grab
grab
record
grab
grab
grab
grab
grab
grab
Limitations/Monitoring Basis:
The designations 001A, 001B, and 001C represent Outfall 001 at different time periods. 001A reflects the period
from the effective date to the first 12 months of the permit life, during wet weather. BPJ was used to apply the
stormwatcr runoff limits from the Steam Electric Point Source Category (40 CFR Part 423) to establish a TSS limit.
BPJ and the demonstrated level of performance at oil terminals with API separators forms the basis for the benzene
limit. The frequency of once per month is further defined as "one significant storm event per month". If no storm
occurs, a negative report is filed. The Oil and Grease limit is based on State certification (not described). pH
monitoring is based on State WQSs but limit was not imposed pending verification that terminal operations did not
influence pH. WET testing required in spring, summer and fall using a dapnid and a fathead minnow. After 1st year
of permit term, WET frequency is reduced to 1/year. The Acute WET limit is less than 50 % mortality after 48 hours.
PAH limits are WQ based, using Tidal Prism Method for limits calculations. The limit given is for one chemical.
The permit provides a detection level of 10 ug/l and a list of PAHs. Narrative State WQSs are included in the
permit. No other basis for monitoring was provided.
Page: 200
-------
Facility Name: The Cumberland Farms, Inc. Permit Number: ME0022314
Facility Description: The facility stores and distributes refined petroleum products. SIC Code: 5171
Outfall: 001B Receiving Water: Fore River on Casco Bay Treatment: API ,
Amount/Components:
Unspecified amount of storm water runoff from fuel storage areas including boiler blowdown.
Parameter
Acute WET
Benzene
Ethylbenzene
Flow
O&G
PAHs
pH
Toluene
TSS
Xylenes
Limitations
Average
N/A
N/A
N/A
500.000000 ug/l
N/A
N/A
N/A
Report
N/A
N/A
N/A
60.000000 ug/l
N/A
N/A
N/A
N/A
N/A
30.000000 mg/l
N/A
N/A
Maximum
N/A
Report
N/A
N/A
N/A
Report
. N/A
320.000000 GPM
N/A
15.000000 mg/l
N/A
N/A
N/A
Report SU
N/A
Report
N/A
100.000000 mg/l
N/A
Report
Other
See below
No units specified
No units specified
Monitoring Requirements
Frequency
1/year
1/quarter
1/quarter
continuous
1 /month
1/quarter
1 /month
1/quarter
1 /month
1/quarter
Sample Type
grab
grab
grab
record
grab
grab
grab
grab
grab
grab
Limitations/Monitoring Basis: .
The designations 001A, 001B, and 001C represent Outfall 001 at different time periods. 001A reflects the period
from the effective date to the first 12 months of the permit life, during wet weather. BPJ was used to apply the
stormwater runoff limits from the Steam Electric Point Source Category (40 CFR Part 423) to establish a TSS limit.
BPJ and the demonstrated level of performance at oil terminals with API separators forms the basis for the benzene
limit. The frequency of once per month is further defined as "one significant storm event per month". See the
basis for Outfall 001A.
Outfall: 001C | Receiving Water: Fore River on Casco Bay Treatment: API
Amount/Components :
Unspecified amount of storm water runoff from fuel storage areas including boiler blowdown.
Parameter
Flow
O&G
pH
TSS
Limitations
Monthly
Average
N/A
Report
N/A
N/A
N/A
N/A
N/A
30.000000 mg/l
Daily
Maximum
N/A
320.000000 GPM
N/A
15.000000 mg/l
N/A
Report SU
N/A
100.000000 mg/l
Other
Monitoring Requirements
Frequency
cont i nuous
2/year
2/year
2/year
Sample Type
record
grab
grab
grab
Limitations/Monitoring Basis:
The designations 001A, 001B, and 001C represent Outfall 001 at different time periods. 001C reflects dry weather
discharge. BPJ was used to apply the stormwater runoff limits from the Steam Electric Point Source Category (40 CFR
Part 423) to establish a TSS limit. BPJ and the demonstrated level of performance at oil terminals with API
separators forms the basis for the benzene limit. The frequency of once per month is further defined as "one
Page: 201
-------
Facility Name: The Cumberland Farms, Inc.
Permit Number: ME0022314
Facility Description: The facility stores and distributes refined petroleum products.
SIC Code: 5171
significant storm event per month". See the basis for Outfall 001A.
Outfall: 002 | Receiving Water: Fore River on Casco Bay
Treatment: None
Amount/Components:
Unspecified amount of untreated storm water runoff from fuel storage areas including boiler blowdown.
Parameter
O&G
PH
TSS
Limitations
Average
N/A
N/A
N/A
N/A
N/A
30.000000 rug/ 1
Maximum
N/A
15.000000 mg/l
N/A
Report SU
N/A
100.000000 mg/l
Other
Monitoring Requirements
Frequency
1/quarter
1 /quarter
1/quarter
Sample Type
grab
grab
grab
Limitations/Monitoring Basis:
The TSS limit is based on the determination that the "limit and sampling frequency are adequate to characterize the
discharge and sufficient to reflect poor operational conditions" according'to the Fact Sheet. The pH limit is based
on State HQSs for Class SC waters. The O&G limit is based on State certification requirements (not described).
Special Conditions Basis:
Cumberland Farms is required to install a continuous flow meter and manually control flow through the oil/water
separators to prevent oil or paniculate carryover. A BMP plan is required. Proper Maintenance Practices (PMPs)
Here required through the BMP plan to remove recently deposited organic matter :within the diked areas. Bilge water
and tank bottoms have a high potential to become contaminated when they contact petroleum products. Therefore,
untreated wastewater from these sources is prohibited until WET testing shows that toxicity is not occurring. The
discharge has met all effluent limits for Outfall 001, and the discharge has not violated numeric water quality
standards. Additional standard conditions per 40 CFR Part 122.42 (a)(1) were also established. Methods and MDLs
arocified for WET, PAHs, ethylbenzene, toluene, and xylenes. The permittee is required to submit laboratory data
sheets.
.
Effective
Date:
01/24/92
Expira.tion
Date:
01/23/97
Abstract
Date:
04/04/93
I
Page: 202
-------
Facility Name: United Technologies-Pratt&Whit Permit Number: MEOQ22861
Facility Description: Metal finishing for manufacture of aircraft parts. SIC Code: 3721
Monitoring
Limit ELGs WQSs BPJ Only
Basis: J_ J_ J_ j.
Storm WQ
Special BMPs Water Sediment Survey
Conditions: J. , — - -
. WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
1 -. • • - - ' . ' -
Bio
Survey TRES MDLs Monitoring Other
Abstract Information:
Partial; Outfalls 003, 004, and 005 (representative of 006, 007, and 008).
Outfall: 003 | Receiving Water; Great Works River | Treatment: Neut, CAC, Fil (high pressure a
Amount/Components:
130,000 GPD treated process and sanitary wastewater.
Parameter
Ag (T)
Cd (T)
Chronic WET
CN (T)
Cr (T)
Cr+6
Cu (T)
Fl
Flow
Ni (T)
O&G
P (T)
Pb (T)
PH
Temp.
TSS
TTOs
Limitations
Average
N/A
Report mg/l
0.006300 Ib/d
3.800000 ug/l
N/A
N/A
0.100000 Ib/d
0.062000 mg/l
0.620000 Ib/d
, N/A
0.220000 Ib/d
0.130000 mg/l
0.053000 Ib/d
0.03ZOOO mg/l
N/A
N/A
N/A
0.200000 HGD
0.800000 Ib/d
0.480000 mg/l
N/A
N/A
0.034000 Ib/d
0.020000 mg/l
0.008200 Ib/d
4.900000 ug/l
N/A
N/A
N/A
Report
N/A
N/A
N/A
N/A
Maximum
N/A
Report mg/l
0.013000 Ib/d
5.300000 ug/l
N/A
N/A
0.450000 Ib/d
0.180000 mg/l
0.250000 Ib/d
N/A
0.320000 Ib/d
0.130000 mg/l
0.080000 Ib/d
0.032000 mg/l
N/A
10.000000 mg/l
N/A
0.300000 MGD
2.500000 Ib/d
1.000000 mg/l
N/A
15.000000 mg/l
0.100000 Ib/d
0.040000 mg/l
0.220000 Ib/d
87.000000 ug/l
N/A
N/A
N/A
Report
N/A
15.000000 mg/l
N/A
2.130000 mg/l
Other
See below
See below
Units: degrees Faren
heit
See below
Monitoring Requirements
Frequency
1 /month
1/week
1/quarter
1 /month
1/week
1/week
1/week
1 /month
Continuous
1/week
1/week
1/week
1/week
1/day
3/week
2/month
1/quarter
Sample Type
Composite
Composite
Composite
Grab
Composite
Composite
Composite
Composite
Recorder
Composite •
Grab
Grab
Composite
Grab
Grab
Composite
Grab
Page: 203
-------
Facility Nome: United Technologies-Pratt&Uhit Permit Number: ME0022861
Facility Description: Metal finishing for manufacture of aircraft parts. SIC Code: 3721
Zn (T)
0.420000 Ib/d
0.250000 mg/l
0.630000 Ib/d
0.190000 mg/l
1 /month
Composite
Limitations/Monitoring Basis:
Mass and concentration limits for metals, TTOs, and CN are based on ELGs for the metal finishing category. It
appears that the limits for Cd, Cr+6, Pb, Hi (monthly average only), Cu, and CN are water quality based. The
dilution factor is 9.2 and the 7Q10 is 2.55 cfs. The basis for the other limits (monthly average Cr and Cu, Zn, P,
Flf and Ag) appear to be based on water quality criteria. The daily maximum limits for Cr, Ni, TSS, and O&G are
based on the existing permit (Federal anti-backsliding). Where composite samples are required in the permit, they
must be comprised of at least 8 grab samples collected throughout the period of one working day. Based on State
UQSs, the pH range limit of 5.0 to 8.5 applies, unless influent pH exceeds that range. Chronic WET testing is
required to evaluate the C-NOEC (limited at 8.4%), A-NOEC (limited at >79%), and the LC50 (reporting purposes only).
The test species include instream mixing with >14% effluent and >12.5% effluent, respectively. WET protocol require
use of Ccriodaphnia dubia and Salvelinus forntinalis in January and July and Pimephales prone I as in April and
October, tested quarterly. WET tests must be conducted in February and August using Ceriodaphnia dubia and
Salvelinus fontinalis and in Hay and November using Ceriodaphnia dubia and Pimephales promelas. Testing protocol is
provided in the permit. Temperature limits apply from the point of discharge to a downstream dam. Receiving water
(outside the mixing zone) may not exceed 68 degrees Farenheit not increase by more than 5 degrees F. When the
ambient temperature exceed 68 degrees F, then the maximum allowable increase is 0.5 degrees F. Monitoring is
required 3/week from Hay through October (upstream and downstream). Permit contains narrative WQSs applicable at
all outfalls. Toxicity frequency is based on EPA policy for discharges with dilution less than 10:1.
Outfall: 004 | Receiving Water: Great Works River | Treatment: None
Amount/Components :
5000 GPD (average) noncontact wastewater.
Parameter
FlcH
PH
Temp.
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
0.280000 MGD
N/A
N/A
N/A
Report
Other
Between 6.0 su and 8
.5 su
Units: degrees Faren
heit
Monitoring Requirements
Frequency
Continuous
1 /month
1/day
Sample Type
Recorder
Grab
Grab
Limitations/Monitoring Basis:
The permit limits the pH change above background to 0.5 su.
Outfall: 005 | Receiving Water: Great Works River | Treatment: None
Amount/Components :
Unspecified amount of stormwater.
Parameter
Flow
OSG
P«
TSS
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Dai ly
Maximum
N/A
Report MGD
N/A
Report mg/l
N/A
N/A
N/A
Report mg/ 1
Other
Between 6.0 su and 8
.5 su
Monitoring Requirements
Frequency
1 /quarter
1 /quarter
1 /month
1/quarter
Sample Type
Estimate
Grab
Grab
Grab
Limitations/Monitoring Basis:
The permit limits the pH change above background to 0.5 su.
Special Conditions Basis:
The permittee may opt to submit a TTO certification (per 40 CFR Part 433) in lieu of monitoring for one or more TTO
pollutants. The permittee's Solvent Management Plan (SMP) must be updated and submitted to the State within 180
days of permit reissuance. The permittee must ensure that the discharge does not cause or contribute to elevation
of toxics in the river above water quality criteria for toxic pollutants as referenced in Maine LawTitle 38 MRSA
Page: 204
-------
1
Facility Name: United Technologies-Pratt&Uhit
Facility Description: Metal finishing for manufacture of aircraft parts.
420. Additional standard conditions are set forth per 40 CFR Part 122.42(a)(1). The A-NOEC and
described as the acute and chronic limits set equal to the inverse of the dilution factor (9.2).
are determined based on acute and chronic effects, respectively.
Effective Date: 07/12/92 Expiration Date: 07/12/97
Permit Number: HE0022861
SIC Code: 3721
C-NOECs are
A-NOEC and C-NOEC
Abstract Date: 09/25/93
Page: 205
-------
Facility Name: Potlatch Corp. Permit Number: HN00014Z2
Facility Description: Paper mill, noninteg rated SIC Code: 2621
Monitoring
Limit ELGs UQSs BPJ Only
Basis: J. J. - I
Storm UQ
Special BHPs Water Sediment Survey
Conditions: ; z. - -
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
Bio
Survey TRES MDLs Monitoring Other
z - I - i
Abstract Information:
Complete; Outfalls 010, 020.
Outfall: 010 | Receiving Water: Mississippi River | Treatment: Cac, Scr, Neut
Amount/Components :
0.369 HOD (average rate) noncontact cooling water.
Parameter
Flow
pH
Twnp.
TRC
Limitations
Monthly
Average
H/A
H/A
H/A
M/A
H/A
H/A
H/A
H/A
Daily
Maximum
H/A
Report MGD
N/A
Report
H/A
100.000000
H/A
38.000000 ug/l
Other
Between 6.0 su and 9
.0 su
Units: degrees Faren
heit
Monitoring Requirements
Frequency
Continuous
1 /month
Cont i nuous
1 /month
Sample Type
Total
Grab
Limitations/Monitoring Basis:
The permit contains a prohibition of the discharge of floating solids or visible foam in other than trace amounts,
as well as oil or other substances sufficient to create a visible color film on the surface of the receiving waters.
Tho EPA method for monitoring for TRC is specified and the detection level is discussed. The basis for the above
limitations and monitoring conditions was not provided.
Outfall: 020 | Receiving Water: Mississippi R. | Treatment: PC, Scr, Neut
Amount/Components :
Unspecified amount of treated process wastewater.
Parameter
Acute WET
Acute WET
C8005
CB005
Flow
Flow
P (T)
P (T)
pH
Limitations
Monthly
Average
H/A
H/A
H/A
H/A
1050.000000 Ib/d
H/A
1050.000000 Ib/d
M/A
N/A
H/A
H/A
H/A
H/A
H/A
H/A
H/A
H/A
H/A
Dai ly
Maximum
H/A
H/A
N/A
N/A
2100.000000 Ib/d
H/A
2100.000000 Ib/d
H/A
N/A
Report MGD
N/A
Report MGD
N/A
Report
N/A
Report
N/A
Report
Other
Units not specified
Units not specified
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/day
1/day
Continuous
Continuous
1 /month
1 /month
Sample Type
24 hr fw composite
24 hr fw composite
Total
Total
24 hr fw composite
24 hr fw composite
Page: 206
-------
Facility Name: Potlatch Corp. Permit Number: MN0001422
Facility Description: Paper mill, nonintegrated SIC Code: 2621
PH
Temp.
Temp.
TRC
TRC
TSS
TSS
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
1260.000000 Ib/d
N/A
1260.000000 Ib/d
N/A
N/A
Report
N/A
100.000000
N/A
100.000000
N/A
N/A
N/A
N/A
2520.000000 Ib/d
N/A
2520.000000 Ib/d
N/A
Between 6.0 su and 9
.0 su
Units: degrees Faren Continuous
heit
Units: degrees Faren Continuous
heit
1 /month
1 /month
| 1/day
[ 1/day
i
Grab
Grab
24 hr fw composite
24 hr fw composite
L imi tat i ons/Moni tori ng Basi s :
Acute toxicity testing is to be conducted following specified EPA guidance, using 3 species and 5 dilutions. After
1 year of monthly P(T) testing, the permittee may request a reduced monitoring frequency if the analytical results
have been consistently below detection levels using specified EPA methods. The EPA method for monitoring for TRC is
specified and the detection level is discussed. The limitations for CBOD5 and TSS were based on ELGs in 40 CFR Part
430 Subpart R and State WQSs in HN Rule Ch 7050.0210, Subpart 10; 7050.0211, Subpart 1; and 7050.0212, Subpart 1 and
Subpart 3.
Special Conditions Basis:
The permit may be reopened based on the results of toxicity testing.
Effective Date: 09/30/92 Expiration Date: 09/30/97 Abstract Date: 09/18/93
Page: 207
-------
Facility Home: Boise Cascade Corporation Permit Number: MN0001643
Facility Description: Pulp and paper manufacturer (bleached kraft, nonintegrated fine, unbte SIC Code: 2611
Monitoring
Limit ELGs WQSs BPJ Only
Basis: £ I - I
Storm WQ
Special BHPs Water Sediment Survey
Conditions: J. - - I
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
- 1 - I -
Bio
Survey TRES MDLs Monitoring Other
1 I lid.
Abs tract Information:
Complete; Outfall 030.
Outfall: 030 | Receiving Water: Rainy River I Treatment: PF, AS, ChOx
Amount/Components :
36.39 HGO cooling water, noncontact cooling water, and process wastewater
Parameter
2,3,7,8-TCOD
2,3,7,8-TCDF
2,4,6-Trichloroph
enol
2,4-Dichloropheno
I
Acute WET
AOX
6005
Chlorosyrirtgaldch
yde
Flow
P
-------
Facility Name: Boise Cascade Corporation
Permit Number: MN0001643
Facility Description: Pulp and paper manufacturer (bleached kraft, nonintegrated fine, unble
SIC Code: 2611
The limits then effective until 7/1/96 are 3.28 (10 -7) kg/d daily maximum for dioxin and 1.0 (10 05) kg/d daily
maximum for furan. These mass limits are based on an average flow of 23.4 MGD.
Special Conditions Basis: -^=—=-==—=_=_=
The permittee is required to conduct a 2 phase dioxin and chlorinate organics control program. Upon permit issuance
the permittee must eliminate brownstock defoamers containing recycled oils, minimize use of foamers containing
dioxin precursors, and implement dioxin formation minimization measures. Phase II involves the application of
alternate technologies to minimize dioxin and chlorinated organic formation and submit study reports to achieve
compliance with respective limits. If monthly average production rates fall below 1100 gross MOTPD, the permit may
be reopened to accurately reflect production for the mass based limits • penult may
11/24/92
Expiration Date:
10/31/96
Abstract Date:
09/14/93
Page: 209
-------
Facility Nome: Otter Tail Power Co.-Hoot Lake Pe™it Number: MN0002011
Facility Description: Coal-fired steam electric generating plant SIC Code: 4931
Monitoring
Limit ELGs WQSs BPJ Only
Basis: 2. - - x.
Storm WQ
Special BHPs Water Sediment Survey
Conditions: i z - -
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
Bio
Survey TRES • MDLs Monitoring Other
— - — - ^
AbStrpartiBl;rlOutffanils 901, 904, 905, 906, 909, 020, 030, and 040 representative of 14 total outfalls.
Outfall: 020 | Receiving Water: Otter Tail River I Treatment: Not specified
A™WAver«acnoft|: to 8 HG/batch twice per year of metal cleaning wastes and material storage/coal pile runoff water.
Parameter
Cu (T>
Cu (T)
Fe (T)
Fe (T)
Flow
Flow
0£G
OSG
P«
PH
TSS
TSS
Limitations
Monthly
Average
3.300000 Ib/d
0.200000 mg/l
3.300000 Ib/d
0.200000 mg/l
H/A
N/A
N/A
N/A
H/A
N/A
H/A
H/A
167.000000 Ib/d
10.000000 mg/l
167.000000 Ib/d
10.000000 mg/l
N/A
H/A
H/A
N/A
501.000000 Ib/d
30.000000 mg/l
501.000000 Ib/d
30.000000 mg/l
Daily
Maximum
6.700000 Ib/d
0.400000 mg/l
6.700000 Ib/d
0.400000 mg/l
16.700000 Ib/d
1.000000 mg/l
16.700000 Ib/d
1.000000 mg/l
N/A
Report MGD
N/A
Report MGD
250.000000 Ib/d
15.000000 mg/l
250.000000 Ib/d
15.000000 tng/l
N/A
Report
N/A
Report
835.000000 Ib/d
50.000000 mg/l
835.000000; Ib/d
100.000000 mg/l
Other
Between 6.0 su and 9
.0 su
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/batch disch.
1/batch disch.
1/batch disch.
1/batch disch.
1/batch disch.
1/batch disch.
1/batch disch.
1/batch disch,,
1/batch disch.
1/batch disch.
1/batch disch.
1/batch disch.
Sample Type
Grab
Grab
Grab
Grab
Estimate
Estimate
Grab
Grab
Grab
Grab
Grab
Grab
L!mitThe^sisnforrth|Bl1mitations and monitoring conditions was not provided. The mass limitations were based on the
total batch flow divided by the number of days of the batch discharge which was estimated as an average of 2 HGD.
Outfall: 030 | Receiving Water: Otter Tail River I Treatment: Not specified
Amount/Components :
0.0054 to 0.0108 MGD of vacuum seal line water.
Parameter
Flow
Limitations
Monthly
Average
N/A
N/A
Daily
Maximum
N/A
Report MGD
Other
Monitoring Requirements
Frequency
1/day
Sample Type
Estimate
Page: 210
-------
Facility Name: Otter Tail Power Co. -Hoot Lake Permit Number: MN0002011
Facility Description: Coal-fired steam electric generating plant SIC Code: 4931
Flow
O&G
O&G
PH
pH
TSS
TSS
N/A
N/A
0.900000 Ib/d
10.000000 mg/l
0.900000 Ib/d
10.000000 mg/l
N/A
N/A
N/A
N/A
2.700000 Ib/d
30.000000 mg/l
2.700000 Ib/d
30.000000 mg/l
N/A
Report MGD
1.400000 Ib/d
15.000000 mg/l
1.400000 Ib/d
15.000000 mg/l
N/A
Report
N/A
Report
9.000000 Ib/d
100.000000 mg/l
9.000000 Ib/d
100.000000 mg/l
Between 6.0 su and 9
.0 su
Between 6.0 su and 9
.0 su
1/day
1/week
1/week
1/week
1/week
Estimate
Grab
Grab
Grab
Grab
Limitations/Monitoring Basis:
The basis for the limitations and monitoring conditions was not provided.
Outfall: 040 | Receiving Water: Otter Tail River | Treatment: Not specified
Amount/Components :
0.144 MGD of bearing cooling water line water.
Parameter
Flow
Flow
TRC
TRC
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
Report MGD
N/A
Report MGD
0.005000 Ib/d
0.050000 mg/l
0.005000 Ib/d
0.050000 mg/l
Other
Monitoring Requirements
Frequency
1/day
1/day
1/day
1/day
Sample Type
Estimate
Estimate
Grab
Grab
Limitations/Monitoring Basis:
The basis of the limitations and monitoring conditions was not provided.
Outfall: 901 | Receiving Water: Otter Tail River | Treatment: Not specified
Amount/Components:
Average 11.5 MGD condenser cooling water.
Parameter
Flow
Flow
Temp.
Temp.
TRC
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
Report MGD
N/A
Report MGD
N/A
Report
N/A
Report
0.450000 Ib/d
0.050000 mg/l
Other
See below
See below
See below
Monitoring Requirements
Frequency
1/day
1/day
1/hour
1/hour
Sample Type
Estimate
Estimate
Record
Record
Page: 211
-------
Facility Nome: Otter Tail Power Co. -Hoot Lake Permit Number: MN0002011
Facility Description: Coal-fired steam electric generating plant SIC Code: 4931
TRC
N/A
N/A
0.450000 Ib/d
0.050000 mg/l
See below
Limitations/Monitoring Basis:
The effluent must not raise the temperature of the receiving water at the edge of the mixing zone defined in the
permit by more than 5 degrees Farenheit above natural during April and May, or above 86 degrees Farenheit atall
times. Monitoring, recording and reporting for temperature is required at least hourly. The permittee is required
to report the monthly average plant capacity factor as a percent of total capacity. TRC represents bromine and TRO
as chlorine. The discharge of TRC must not exceed a total of 2 hr/24 hr period and must not be discharged from more
than one outfall simultaneously. All outfalls contain the prohibition of discharge of floating solids or visible
foam in other than trace amounts as well as oil or other substances in amounts sufficient to create a visible color
film on the surface of the receiving waters. The basis for the limitations and monitoring conditions was not
provided.
Outfall: 904 | Receiving Water: Otter Tail River | Treatment: Not specified
Amount/Components:
Average 0.0014 MGO of boiler blowdown water.
Parameter
Cu
Cu
Flow
Flow
OSG
OSG
PH
pH
TSS
TSS
Limitations
Monthly
Average
0.050000 Ib/d
N/A
0.050000 Ib/d
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
1.900000 Ib/d
10.000000 mg/l
1.900000 Ib/d
10.000000 mg/l
N/A
N/A
N/A
N/A
5.700000 Ib/d
30.000000 mg/l
5.700000 Ib/d
30.000000 mg/l
Dai ly
Maximum
0.100000 Ib/d
N/A
0.100000 Ib/d
N/A
0.200000 Ib/d
1.000000 mg/l
0.200000 Ib/d
1.000000 mg/l
N/A
Report MGD
N/A
Report MGD
2.900000 Ib/d
15.000000 mg/l
2.900000 Ib/d
15.000000 mg/l
N/A
Report
N/A
Report
19.100000 Ib/d
100.000000 mg/l
19.100000 Ib/d
100.000000 mg/l
Other
Between 6.0 su and 9
.0 su
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1 /month
1 /month
1 /month
1 /month
1/day
1/day
1 /month
1 /month
1 /month
1 /month
Sample Type
Grab
Grab
Grab
Grab
Estimate
Estimate
Grab
Grab
Grab
Grab
Limitations/Monitoring Basis:
The basis for the limitations and monitoring conditions was not provided.
Page: 212
-------
Facility Name: Otter Tail Power Co.-Hoot Lake Permit Numbep: HN0002011
Facility Description: Coal-fired steam electric generating plant SIC Code. 493i
Outfall: 905 Receiving Water: Otter Tail River [Treatment: Not specified
Amount/Components: " •
Average and maximum of 0.0085 HGD/tank discharge of demineralizer regenerant water.
Parameter
Flow
Flow
O&G
O&G
PH
PH
TSS
TSS
Limitations
Average
N/A
N/A
N/A
N/A
0.700000 Ib/d
10.000000 mg/t
0.700000 Ib/d
10.000000 mg/l
N/A
N/A
N/A
N/A
a. 100000 Ib/d
30.000000 mg/l
2.100000 Ib/d
30.000000 mg/l
Maximum
N/A
Report HGD
N/A
Report HGD
1.100000 Ib/d
15.000000 mg/l
1.100000 Ib/d
15.000000 mg/l
N/A
Report
N/A
Report
7.100000 Ib/d
100.000000 mg/l
7.100000 Ib/d
100.000000 mg/l
Other
Between 6.0 su and 9
.0 su
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/day
1/day
1/month
1 /month
1/month
1/month
Limitations/Monitoring Basis:
The basis for the limitations and monitoring conditions was not provided.
Sample Type
Estimate
Estimate
Grab
Grab
Grab
Grab
Outfall: 906 | Receiving Water: Otter Tail River | Treatment: Not specified
Amount/Components :
0.0115 MGD of discharge from Unit 1 floor drains.
Parameter
Flow
Flow
O&G
O&G
PH
pH
TSS
TSS
Limitations
Average
N/A
N/A
N/A
N/A
6.800000 Ib/d
10.000000 mg/l
6.800000 Ib/d
10.000000 mg/l
N/A
N/A
N/A
N/A
20.500000 Ib/d
30.000000 mg/l
20.500000 Ib/d
30.000000 mg/l
Maximum
N/A
Report MGD
N/A
Report MGD
10.300000 Ib/d
15.000000 mg/l
10.300000 Ib/d
15.000000 mg/l
N/A
Report
N/A
Report
68.400000 Ib/d
100.000000 mg/l
68.400000 Ib/d
100.000000 mg/l
Other
Between 6.0 su and 9
.0 su
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/day
1/day
1/week
1/week
1/week
1/week
Limitations/Monitoring Basis: ~~
The basis for the limitations and monitoring conditions was not provided.
Sample Type
Estimate
Estimate
Grab
Grab
Grab
Grab
Page: 213
-------
i — — — — J u .. . u Permit Number: MN0002011
Facility Mamo: Otter Tail Power Co. -Hoot Lake
Onfall: 909 | Receiving Water: Otter Tail River 1 Treatment: Not specified
Amount/Components:
0.400 HGO of Units 1 and 2 cooling tower blowdown.
Parameter
Flow
Flow
pH
PH
TRC
TRC
TSS
TSS
Limitations
Average
N/A
H/A
N/A
N/A
H/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
125.000000 Ib/d
30.000000 mg/l
125.000000 Ib/d
30.000000 mg/l
Maximum
N/A
Report HGD
N/A
Report HGD
N/A
Report
N/A
Report
0.020000 Ib/d
0.050000 mg/l
0.020000 Ib/d
0.050000 mg/l
417.000000 Ib/d
100.000000 mg/l
417.000000 Ib/d
100.000000 mg/l
Other
Between 6.0 su and 9
.0 su
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/day
1/day
1/week
1/week
1/day
1/day
1/week
1/week
Sample Type
Estimate
Estimate
Grab
Grab
Grab
Grab
Grab
Grab
^fft^lS5S.Wth. use of water treatment or chemical additives the permittee is required to submit a written
request at least 30 days in advance. The discharge of PCBs is prohibited.
Effective Date: 09/30/92 Expiration Date: 07/31/97 Abstract Date: 09/18/83
Page: 214
-------
1
Facility Name: Northern States Power Company
Facility Description: Fossil Fuel Steam Electric
Limit ELGs WQSs
Basis: 2. z.
Storm
Special BMPs Water
Conditions: ^ ^
BPJ
Sediment
Generating Plant
Monitoring
Only
J.
WQ
Survey
I
WET
Limits
Bio
Survey
Permit Number:. MN0002186
SIC Code: 4931
WET Testing Multiple Tiered
Only Categories Limits
TRES MDLs Monitoring
- - I
Other
Other
I
Abstract Information:
Complete; Outfalls 010 and 020.
Outfall: 010 Receiving Water:
Mississippi
River
Treatment: Sed
Amount/Components :
2.3 HGD of cooling tower blowdown
Parameter
Flow
Other
pH
IDS
Temp.
TROs
TSS
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
585.000000 kg/d
30.000000 mg/l
Daily
Maximum
N/A
Report MGD
11540.000000 kg/d
N/A
N/A
Report
48988.000000 kg/d
N/A
N/A
Report
0.480000 kg/d
0.100000 mg/l
1949.000000 , kg/d
100.000000 mg/l
Other
S03 and S04
Between 6.0
.0 su
total
su and 9
See below
Cl TROs as
elow
Cl,,see b
Monitoring Requirements
Frequency
continuous
1/week
continuous
1/week
continuous
1/week
1/week
Sample Type
grab
24 hr composite
not given
24 hr composite
not given
grab
24 hr composite
Limitations/Monitoring Basis:
The discharge of chlorine, TRO expressed as chlorine, or bromine (TRO as chlorine} shall not exceed 2 hours/unit per
24 hour period or a total of 6 hours/day. The permittee is required to monitor the amount of time of chlorine or
bromine application and report it with other monitoring reports. The limit for TROs shown above is associated with
the use of chlorine. The limit for TROs from the use of bromine is 0.12 kg/d and 0.025 mg/l daily maximum. The
discharge of heat to the river from the main condensers is prohibited. Heat may be discharged in the blowdown from
the recirculated cooling water system provided it is retained for a minimum of 24 hours prior to discharge. The
basis for the limitations and monitoring conditions was not provided.
Outfall: 020 Receiving Water:
Mississippi
River
Treatment: None specified
Amount/Components :
5.05 MGD of cooling tower blowdown deicing water
Parameter
Flow
Other
PH
TDS
Temp.
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
Report MGD
11540.000000 kg/d
N/A
N/A
Report
48988.000000 kg/d
N/A
N/A
95.000000
Other
S03 and S04
Between 6.0
.0 su
total
su and 9
See below;
9 F
units: de
Monitoring Requirements
Frequency
continuous
1/day
continuous
1/day
continuous
Sample Type
not given
24 hr composite
not given
24 hr composite
not given
Page: 215
-------
FaefUty Mama: Northern States Power Company
Permit Number: MN0002186
Facility Description: Fossil Fuel Steam Electric Generating Plant
SIC Code: 4931
TROS
TSS
N/A
N/A
M/A kg/d
N/A mg/l
0.300000 kg/d
0.200000 mg/l
1913.000000 kg/d
100.000000 mg/l
Cl TROs as Cl, see b
elow
1/day
1/day
grab
grab
Limitations/Monitoring Basis:
During the period November through March when icing occurs, the permittee is authorized to discharge through Outfall
020. Outfalls 010 and 020 may not operate simultaneously. Chlorination and bromination shall be minimized to the
extent practicable and shall be limited to 2 hours/24 hour period. The permittee is required to report the
frequency, duration, and flow of deicing dicharge events. All monitoring conditions apply only during discharge.
The limit for TROs shown above is associated with the use of chlorine. The limit for TROs form the use of bromine
is 0.08 kg/d and 0.05 mg/l daily maximum. When directly discharging cooling tower blowdown, daily grab samples are
to be taken except for those monitored continuously, after the discharge occurs for greater than 12 hours duration.
If the discharge occurs for less than 12 hours, the effort to grab a sample must be made consistent with the time of
day and day of week, due to the unpredictable nature of the need for deicing the intake. The basis for the
limitations and monitoring conditions was not provided.
Special Conditions Basis:
The permittee shall submit for approval, at least 120 days prior to abandonment of any ash disposal pond, a plan to
provide a clay cap to minimize erosion and infiltration from the former disposal area. The permittee shall submit
for approval at least 60 days prior to construction, plans for constructing holding ponds. The permittee is
required to submit annual reports on ground water studies, river water quality, trace element and intake deice
discharge studies. The permittee is required to request approval at least 30 days in advance of using water
treatment or chemical additives. The discharge of PCBs is prohibited.
Effective Date: 09/30/92
Expiration Date: 09/30/97
Abstract Date: 09/14/93
Page: 216
-------
Facility Name: SB Ft Tanning & City Red Wing
Permit Number: MN0038962
Facility Description: Leather Tanning & Finishing
SIC Code: 3111
Limit
Basis:
ELGs
UQSs
BPJ
Monitoring
Only
J.
WET
Limits
WET Testing
Only
Multiple
Categories
Tiered
Limits
I
Other
Special
Conditions:
BMPs
Storm
Water
Sediment
WQ
Survey
Bio
Survey
TRES
MDLs
Monitoring
Other
J.
Abstract Information:
Complete; Outfalls 100 (A and B for abstracting purposes) and 200.
Outfall: 100A
Receiving Water: Hay Creek
Treatment: Scr, AS, Dis, PC
Amount/Components:
0.34 MGD treated wastewater from color and fat liquor retanm'ng and finishing operations
Parameter
Acute WET
CBOD5
Cr (T)
Cr+6
FC
Flow
NH3 (T)
OSG
PH
TRC
TSS
Limitations
Monthly
Average
N/A
N/A
43.900000 kg/d
N/A
4.000000 kg/d
N/A
N/A
N/A
N/A
200.000000
N/A
N/A
N/A
N/A
17.600000 kg/d
N/A
N/A
N/A
N/A
N/A
52.700000 kg/d
N/A
Daily
Maximum
N/A
Report
133.500000 kg/d
N/A
11.700000 kg/d
N/A
N/A
Report
N/A
N/A
N/A
Report MGD
N/A
Report
40.000000 kg/d
N/A
N/A
Report
N/A
0.100000 mg/l
160.200000 kg/d
N/A
Other
See below
units not specified
See below; units:#/1
00 ml
units not specified
Between 6.0 su and 9
.0 su
See below
Monitoring Requirements
Frequency
1/quarter
3/week
3/week
1/month
3/week
continuous
3/week
3/week
continuous
1/day
3/week
Sample Type
24 hr fw composite
24 hr composite
24 hr composite
grab
grab
total
24 hr composite
grab
not given
grab
24 hr composite
Limitations/Monitoring Basis: ~
The limitations and monitoring conditions for Outfall 100A apply to Outfall 20100 when daily production is less than
or equal to 6189 sides per day. The FC limit applies from March 1 through October 31 and is a monthly geometric
Tean-r!£ f9°.orgamsmf Per 10° ral- The TRC daily monitoring requirement does not apply on weekends and holidays
The TRC limit is applicable upon installation of dechlorination facilities. The CR+6 monitoring requirement is"
effective for the first 12 months after permit issuance. Acute WET tests are to be conducted using 3 species and 5
dilutions for the first year of the permit. If results indicate less than 50% mortality in 100% effluent the
testing is to be 1/month. The tests are to be conducted following the EPA guidance manual. The basis for the
limitations and monitoring conditions was not provided.
Page: 217
-------
FacfUty Name: SB Ft Tanning & City Red Wing Permit Number: HN0038962
Facility Description: Leather Tanning & Finishing SIC c°de: 3111
Outfall: 100B | Receiving Water: Hay Creek I Treatment: Scr, AS, Dis, PC
Amount/Components :
0.34 MOD treated wastewater from color and fat liquor retanning and finishing operations
Parameter
Acute WET
CB005
Cr
-------
Facility Name: SB Ft Tanning & City Red Wing Permit Number: MN0038962
Facility Description: Leather Tanning & Finishing SIC Code: 3111
Special Conditions Basis:
The permit contains compliance schedules for dechlorination and sludge management. The permittee must submit plans
(no later than 11/30/90) for dechlorination facilities. Operations are to commence by 5/31/91. A reportis to be
submitted upon completion of construction and commencement of operation of dechlorination facilities. The permittee
is required to submit a preliminary plan (no later than 1/31/91) for review and conment for thetemporary storage and
final disposal of solids or sludge removed from the treatment system. A final plan is to be submitted within 180
days of the effective date of the permit. A temporary plan is due by 9/14/90, with implementation by 5/1/91. The
permit contains a reopener based on the results of toxicity tests. The permit prohibits the discharge of PCBs.
Effective Date: 09/24/90 Expiration Date: 08/31/95 Abstract Date: 08/14/93
Page: 219
-------
Facility Homo: Piper Impact, Inc. • Permit Number: MS0000931
Facility Description: Cleaning and etching of metal parts SIC Code: 3479
Monitoring
Limit ELGs WQSs BPJ Only
Basis: 1 J. ^ -
Storm WQ
Special BHPs Hater Sediment Survey
Conditions: ^ z L -
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
J. - - I I
Bio
Survey TRES MDLs Monitoring Other
- I - - -I
Abstract Information:
Complete; Outfall 001 (A and B created for abstracting purposes).
Outfall: 001A | Receiving Water: Jasper Creek | Treatment: Red, Floe, Neut, Sed
Amount/Components :
0.3261 HGO of process vmstewater.
Parameter
Ag
-------
Facility Name: Piper Impact, Inc. .
* v • • Permit Number: MS0000931
Facility Description: Cleaning and etching of metal parts „,„ „ . ,,„
' Zn (T)
1.070000 Ib/d
0.500000 rag/ I
2.140000 Ib/d
1.000000 mg/l
1/week
24hr composite
Limitations/Monitoring Basis: ~ ~
IfcMV^TjlS S£&^
Outfall: 001B | Receiving Water: Jasper Creek | treatment: Red, Floe Neut Sed
Amount/Components: ' ~ —
0.2261 HGD of process wastewater.
Parameter
Ag
-------
Facility Name: Piper Impact, Inc.
Facility Description: Cleaning and etching of metal parts
Permit Number: MS0000931
SIC Code: 3479
Zn (T)
0.940000 Ib/d
0.396000 mg/l
0.826000 Ib/d
0.438000 mg/l
1
1/week
24hr composite
for abstracting purposes to represent limitations effective from 02/04/92 through 07/08/96.
001A.
Effective Date: 07/09/91
Expiration Date: 07/08/96
Abstract Date: 06/01/93
Page: 222
-------
Facility Name: Bryan Foods, Inc. P6™1"* Number: "S0001783
Facility Description: Slaughter and processing of pork products SIC Codes 2013
, , Monitoring
Limit ELGs WQSs BPJ Only
Basis: J_ j. - -
Storm WQ
Special BMPs Water Sediment Survey
Conditions: • -z. ^ z. ' . , -
WET WET Testing , Multiple Tiered
Limits Only Categories Limits Other
I. - - J. -
Bio
Survey TRES MDLs Monitoring Other
— — — — 4.
Abstract Information:
Complete; Outfall 001 (A and B created for abstracting purposes).
Outfall: 001A Receiving Water: Unnamed trib. to Town Creek . Treatment: AnL+AS+Dis
Amount/Components:
0.04 MGD sanitary wastewater, 0.04 MGD cooling water, 1.33 MGD process wastewater, and 0.84 HGD boiler blowdown.
Parameter
BODS
FC
Flow
NH3-N
O&G
pH
TRC
TSS
Limitations
Daily
Average
225.000000 Ib/d
15.000000 mg/l
N/A
Report
N/A
Report MGD
90.000000 Ib/d
6.000000 mg/l
150.000000 Ib/d
10.000000 mg/l
N/A
Report
N/A
N/A
465.000000 Ib/d
Report mg/l
Daily
Maximum
450.000000 Ib/d
30.000000 mg/l
N/A
400.000000
N/A
Report MGD
180.000000 Ib/d
12.000000 mg/l
300.000000 Ib/d
20.000000 mg/l
N/A
Report
N/A
N/A
930.000000 Ib/d
Report mg/l
Other
Units: #/100 ml
Between 6.0 su and 8
.5 su
Not greater than 0.5
mg/l
Monitoring Requirements
Frequency
1/week
1/week
cont i nuous
1/week
1/week
1/week
1/week
1/week
Sample Type
24hr composite
grab
record
24hr composite
24hr composite
grab
grab
24hr composite
Limitations/Monitoring Basis:
Outfall 001A was created for abstracting purposes to represent those limitations effective from 03/27/90 through
09/30/92. All limits except TSS are UQ-based. TSS limits are ELG-based in accordance with the meat products
processing category (40 CFR Part 432, Subpart D). Mass limits are derived using the daily average flow of 1.8 mgd.
NH-3 and TRC were found to be at chronically toxic levels; a schedule for achieving the stringent WQ-based limits is
provided. Monitoring is specified regularly for flow and at sufficient frequency for other pollutants to ensure
compliance with permit conditions.
Outfall: 001B Receiving Water: Unnamed trib. to Town Creek | Treatment: AnL+AS+Dis
Amount/Components:
0.04 MGD sanitary wastewater, 0.04 MGD cooling water, 1.33 MGD process wastewater, and 0.84 MGD boiler blowdown.
Parameter
BODS
FC
Flow
NH3-N
Limitations
Dai ly
Average
225.000000 Ib/d
15.000000 mg/l
N/A
Report
N/A
Report MGD
30.000000 Ib/d
2.000000 mg/l
Dai ly
Maximum
450.000000 Ib/d
30.000000 mg/l
N/A
400.000000
N/A
Report MGD
45.000000 Ib/d
3.000000 mg/l
Other
Units:#/100 ml; see
below
Monitoring Requirements
Frequency
1/week
1/week
cont i nuous
1/week
Sample Type
24hr composite
grab
record
24hr composite
Page: 223
-------
Facility Name: Bryan Foods, Inc. Permit Number: MS0001783
Facility Description: Slaughter and processing of pork products SIC Code: 2013
OHQ
pH
TRC
TSS
150.000000 Ib/d
10.000000 mg/l
N/A
Report
N/A
N/A
465.000000 Ib/d
Report mg/l
300.000000 Ib/d
20.000000 mg/l
N/A
Report
N/A
N/A
930.000000 Ib/d
Report mg/l
Between 6.0 su and 8
.5 su
Not greater than 0.0
11 mg
1/week
1/week
1/week
1/week
24hr composite
grab
grab
24hr composite
Limitations/Monitoring Basis:
Outfall 001B was created for abstracting purposes to represent those limitations effective from 10/01/92 through
03/26/95. Limitations at 001B reflect the final WQ-based limits for NH-3 and TRC. The basis of the limitations and
monitoring requirements is as described at Outfall 001A. The FC limit shown above applies May through October. The
FC limits that apply November through April are 4000 S/100 ml.
Special Conditions Basis:
Within 120 days, a schedule for compliance including final limitations (for Outfall 001B) is required to be
submitted; compliance must be achieved by 10/1/92. Other special conditions include requirements for 1)
notification within 90 days of closure or abandonement of the facility, and 2) notification 60 days prior to
introducing cooling and boiler water additives.
Effective Date: 03/27/90 Expiration Date: 03/26/95 Abstract Date: 06/01/93
Page: 224
-------
Facility Name; Kimberly-Clark, Corinth Mills
Facility Description: Non-woven fabric manufacturer
Permit Number: HS0035882
Abstract Information:
Complete; Outfalls 001, 002, and 003.
Outfall: 001
Receiving Water: Unnamed tribs. to Sevenmile Cr
Amount/Components:
Treatment: AS+EQ+Floc+Dis+Stab+Neut+DeCl
Parameter
BODS
DO
FC
Flow
NH3-N
pH
Temp.
TRC
TSS
Daily
Average
12.550000 Ib/d
35.000000 mg/l
N/A
N/A
N/A
456.000000
N/A
Report MGD
1.080000 tb/d
3.000000 mg/l
N/A
N/A
N/A
Report
N/A
0.050000 mg/l
19.540000 Ib/d
Report
1
5
91
t
95
0
29
Limitations
Daily
Maximum
18.830000 Ib/d
52.500000 mg/l
N/A
N/A
N/A
912.000000
N/A
Report MGD
1.610000 Ib/d
4.500000 mg/l
N/A
N/A
N/A
95.000000
N/A
0.075000 mg/l
29.320000 Ib/d
Report
Other
Seasonal; see below
not < 6.0 mg/l; see
below
Units:#/100 ml; see
below
Seasonal; see below
Between 6.0 su and 9
.0 su
units: degrees Faren
heit
Cone, units not spec
ified
Monitoring Requirements
Frequency
2/month
2/month
2/month
continuous
2/month
2/month
2/month
2/month
2/month
Sample Type
24hr composite
grab
grab
record
24hr composite
grab
grab
grab
24hr composite
Limitations/Monitoring Basis-
o
daily average, and 2.69 Ib/d and 7.5 mg/l daUy max mm- for oul « /n
Ib/d and 63 mg/l daily maximum; for FC, 8636/ 00 ml SaHy averaae and 17?7?/?nn ?
BOD5, FC, DO, and TRC are WQ-based in accordance w th State^er'au^tv -I •
not consistent with those set forth in the fact sheet Se^nna? i? ?! Z criteria.
probability of recreational contac? dCring lu^er Seasonal Umi s a e" sefforth
greater at higher temperatures. TSS limits are based nnth» inn*
these limits are not consistent with those set forth in the fac^sh^
textile manufacturing category (40 CFR Part 410 Subnart in nr hi
not being included in the permit since they do no? pole a threa?"to
based limit was not discussed. Temp pH and DO
Monitoring is specified regularly ?or'ffow and a?
with permit conditions. 9Ularly now and at
1'79 lb/d and 5
dally avera9e< and 22-59
maxlmum- L'mits for NH3-N,
Except for DO, these limits are
Hf°^ FC dUe t0 the higher
N slnce 1ts toxicity is
^ 5ermit aPP^-"tion;
-based consistent with the
' .Ph?nols- a"d Cr (T), are
j . The omission of the COD ELG-
cond"cted after conmingting of 001 and 002.
frequency for other pollutants to ensure compliance
Page: 225
-------
Facility Hanxs; Kimberly-Clark, Corinth Hills
Foe! Uty Description: Non-woven fabric manufacturer
Outfall: 002 | Receiving Water; Unnamed tribs. to Sevenmile Cr
Permit number: MS0035882
SIC Code: 2297
Treatment: Not specified.
treated sand filter backwash, boiler blowdown. and cooling tower blowdown.
Parameter
Cu
DO
Flow
pH
Temp.
Limitations
dai ly
Average
N/A
N/A
M/A
N/A
H/A
Report HGD
M/A
N/A
N/A
Report
daily
Maximum
M/A
N/A
M/A
N/A
M/A
Report HGD
N/A
N/A
N/A
95.000000
Other
See below
Mot less than 6.0 rag
/I . .
See below
Between 6.0 su and 9
.0 su
units: degrees Faren
heit
Honitorin
Frequency
2/month
2/month
continuous
2/month
2/month
g Requirements
Sample Type
24hr composite
grab.
record
grab
grab
Limitations/Monitoring Basis:
it Limits for pH are set consistent with those at outfall 001.
required for 6 months after which data will be evaluated to
-
Outfall: 003 | Receiving Water: Unnamed tribs. to Sevenmile Cr
* e
for otheTpollutants to ensure compliance with permit conditions
t
for * ^ ,t
must be
| Treatment: Not specified.
avg. of noncontact cooling water and 6.46 HGD max. of manufacturing area storm water runoff.
Parameter
8005
Flow
OS6
pH
Limitations
Dai ly
Average
H/A
N/A
N/A
Report HGD
N/A
10.000000 mg/l
N/A
N/A
Daily
Maximum
N/A
N/A
N/A
Report HGD
N/A
15.000000 mg/l
N/A
N/A
Other
See below
See below
Between 6.0 su and 9
.0 su
Monitorin
Frequency
2/month
2/month
2/month
2/month
g Requirements
Sample Type
grab
instantaneous
grab
grab . -
Limitations/Monitoring Basis: ,1-,.,,«„„ that oil sheens are not visible to the limited concentrations. Limits
OSG limits are based on ^search indicating that o I sheens ^e ™t *is^ due to the concentrations found as
permit or more stringent limitations.
Abstract Date: 06/01/93
Expiration Date: 11/25/96
Effective Date: 11/26/91
Page: 226
-------
Facility Name: Greenville Manufacturing, Inc.
Permit Number: HS0047759
Facility Description: Knit outerwear textile mill
SIC Code: 2254
Limit
Basis:
ELGs
I
WQSs
I
BPJ
J.
Monitoring
Only
J.
WET
Limits
WET Testing
Only
Multiple
Categories
Tiered
Limits
I
Other
Special
Conditions:
BMPs
Storm
Water
Sediment
WQ
Survey
Bio
Survey
TRES
MDLs
Monitoring
Other
I
Abstract Information:
Complete; Outfall 001 (A, B, and C created for abstracting purposes).
Outfall: 001A
Receiving Water: Mississippi River
Treatment: Scr+AS+AL
Amount/Component s:
2.75 MGD of treated process wastewater, welt water treatment wastewater, sanitary uastewater, and boiler blowdown.
Parameter
BODS
Chloride
COD
Cr (T)
FC
Flow
PH
Phenols
Sulfide
TDS
TRC
TSS
Limitations
Monitoring Requirements
Daily
Average
380.000000 Ib/d
Report mg/l
N/A
N/A
6200.000000 Ib/d
Report mg/l
10.000000 Ib/d
Report mg/l
N/A
200.000000
N/A
Report MGD
N/A
N/A
10.000000 Ib/d
Report mg/l
20.000000 Ib/d
Report mg/l
N/A
N/A
N/A
Report mg/l
1180.000000 Ib/d
Report mg/l
Daily
Maximum
780.000000 Ib/d
Report mg/l
N/A
N/A
9620.000000 Ib/d
Report mg/l
20.000000 Ib/d
Report mg/l
N/A
400.000000
N/A
Report MGD
N/A
N/A
20.000000 Ib/d
Report mg/l
40.000000 Ib/d
Report mg/l
N/A
N/A
N/A
0.500000 mg/l
2640.000000 Ib/d
Report mg/l
Other
chlorides, see below
Units: #/100 ml; sea
sonal
Between 6.5 su and 9
.0 su
See below
If any chlorine used
Frequency
1/week
1 /month
1/week
1/week
1/week
continuous
2/month
1/week
1/week
1 /month
1/week
1/week
Sample Type
24hr composite
24 hr composite
24hr composite
24hr composite
grab
record
grab
grab
grab
24hr composite
grab
24hr composite
Limitations/Monitoring Basis:
Outfall 001A was established for abstracting purposes to represent those limitations based upon a production rate of
200,000 Ib/d and lasting from 12/15/92 through 06/30/93. Limitations for FC are seasonal based on WQ; limits
contained above are effective from May through Oct. (summer) and limits of 2000/100 ml daily avg. and 4000/100 ml
daily max. are effective from Nov. through Apr. (winter). Mass limits at Outfall 001A are derived using a
production rate of 200,000 Ib/d. Plant production must be calculated each day and reported on DMRs as a daily
average; this is necessary to ensure treatment efficiency. pH and FC limits are WQ-based in accordance with State
water quality criteria. TRC limits are set because of the potential to disinfect the discharge to meet FC limits.
The FC limits shown above are applicable May through October. The November through April limits are 200/100 ml
daily average and 400/100 ml daily maximum. The TRC limits are set based on BPJ that there will be no exceedance of
instream toxicity criteria. The remaining limits are ELG-based consistent with NSPS for the textile manufacturing
category (40 CFR Part 410; Subpart E). Monitoring for TDS and chlorides is required until sufficient data is
collected which demonstrates no exceedances of water quality. Monitoring is specified regularly for flow and at
sufficient frequency for other pollutants to ensure compliance with permit conditions.
Page: 227
-------
Facility Memo: Greenville Manufacturing, Inc. Permit Number: MS0047759
Facility Description: Knit outerwear textile mill SIC Code: 2254
Outfall: 001B | Receiving Water: Mississippi River | Treatment: Scr+AS+AL
Amount/Components: , ,,.,,,.
2.75 HGO of treated process wastewater, well water treatment wastewater, sanitary wastewater, and boiler blowdown.
Parameter
BOOS
Chloride
COO
CP (T>
FC
FlOH
PH
Phenols
Sulfido
TOS
TRC
TSS
Limitations
Dai ly
Average
532.000000 Ib/d
Report mg/l
H/A
N/A
8680.000000 Ib/d
Report rag/ 1
14.000000 Ib/d
Report mg/ 1
N/A
200.000000
H/A
Report MGD
H/A
H/A
14.000000 Ib/d
Report mg/l
28.000000 Ib/d
Report mg/l
H/A
N/A
H/A
Report mg/l
1652.000000 Ib/d
Report mg/l
Daily
Maximum
1008.000000 Ib/d
Report mg/l
N/A
N/A
13468.000000 Ib/d
Report mg/ 1
28.000000 Ib/d
Report mg/l
N/A
400.000000
H/A
Report MGD
N/A
N/A
28.000000 Ib/d
Report mg/l
56.000000 Ib/d
Report mg/l
N/A
H/A
N/A
0.500000 mg/l
3696.000000 Ib/d
Report mg/l
Other
see below
Units: #/100 ml; sea
sonal
Between 6.5 su and 9
.0 su
see below
If any chlorine used
Monitoring Requirements
Frequency
1/week
1 /month
1/week
1/week
1/week
continuous
2/month
1/week
1/week
1 /month
1/week
1/week
Sample Type
24hr composite
24 hr composite
24hr composite
24hr composite
grab
record
grab
grab
grab
24 hr composite
grab
24hr composite
Limitations/Monitoring Basis:
Outfall 001B was established for abstracting purposes to represent those limitations based upon a production rate of
280,000 Ib/d and lasting from 07/01/93 through 1Z/31/94. The bases for the limitations and monitoring conditions
arc the some as described at Outfall 001A.
Outfall: 001C | Receiving Water: Mississippi River | Treatment: Scr+AS+AL
Amount/Components:
2.75 HGO of treated process wastewater, well water treatment wastewater, sanitary wastewater, and boiler blowdown.
Parameter
BOOS
coo
Cr
-------
1
FacUity Name: Greenvi lie Manufacturing, Inc. Permit Number: HS0047759
Facility Description: Knit outerwear textile mill SIC Code. 2254
pH
Phenols
Sulfide
TRC
TSS
N/A
N/A
18.000000 lb/d
Report mg/l
36.000000 lb/d
Report mg/l
N/A
Report mg/l
2124.000000 lb/d
Report mg/l
N/A
N/A
36.000000 lb/d
Report mg/l
72.000000 lb/d
Report mg/l
N/A
0.500000 mg/l
4752.000000 lb/d
Report mg/l
Between 6.5 su and 9
.0 su
If any chlorine used
2/month
1/week
1/week
1/week
1/week
grab
grab
grab
grab
24hr composite
Limitations/Monitoring Basis:
7*nf™i ?P15 Wa5 fsta^ished for abstracting purposes to represent those limitations based upon a production rate of
360,000 lb/d and lasting from 01/01/95 through 12/14/97. The bases for the limitations and monitoring conditions
are the same as described at Outfall 001A, except that the reporting of plant production may be discontinued once
the scheduled production rate has been achieved.
Special Conditions Basis:
A schedule of compliance is set requiring the submission of plans and specifications by 11/30/92 "as built"
specifications within 60 days of system completion, and a Form 2C application within 180 days of discharge
initiation. This schedule is set forth since certain actions are necessary to satisfy State and Federal
regulations. Progress reports are required within 10 days of each schedule milestone. Compliance dates for each
tier of limits are also set based on the projected production schedule. Other special conditions include
requirements for : 1) notification within 90 days of closure or abandonement of the facility; 2) notification 60
days pnor_to introducing cooling and boiler additives; 3) the use of multiple pipe diffusion for discharges to the
Mississippi River; and 4) sludge disposal include specifications of a dike/berm enclosure and the submittal of
sludgemonitoring data after the first occurrence of land applications.
Effective Date: 12/15/92 Expiration Date: 12/14/97 Abstract Date: 06/01/93
Page: 229
-------
Facility Home: Hoechst Celanese Corp.
Facility Description: Manufacturers polyester resins Slu uoae- """' j
Monitoring
Limit ELGs WQSs BPJ Only
Basis: J. J. J. J-
Storm WQ
Special BHPs Water Sediment Survey
:onditions: i .1 1 -
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
J. - - . J- ~
Bio
Survey TRES MDLs Monitoring Other
L - ^ -
Abstract Information: . . n._
Complete; Outfalls 001 (A and B for abstracting purposes) and 002.
Outfall: 001A | Receiving Water: Buffalo Creek Treatment: AS
Amount/Components: . -
Unspecified amount of process and domestic wastewater.
Parameter
1,1,1-Trichloroet
hane
1,1,2-Trichloroet
hane
1,1-Dichloroethan
e
1,1-Oichloroethyl
ene
1,Z,4-Trichlorobe
nzene
1,2-Dichlorobenze
no
1,2-Dichloroethan
e
1,2-Dichloropropa
nc
1,2-Trans-Dichlor
oethylene
1,3-Dichlorobcnze
ne
1,3-Oichloroprope
no
1,4-Dichlorobenze
ne
2,4-Dichloropheno
2,4-Dimethylpheno
2,4-Dinitrophenol
2,4-Dinitrotoluen
e
2,6-Dinitrotoluen
e
H-chlorophenol
Limitations
Average
0.051000 Ib/d
N/A
0.051000 Ib/d
N/A
0.053000 Ib/d
N/A
0.039000 Ib/d
M/A
0.164000 Ib/d
M/A
0.186000 Ib/d
N/A
0.122000 Ib/d
N/A
0.370000 Ib/d
M/A
0.051000 Ib/d
M/A
0.075000 Ib/d
N/A
0.070000 Ib/d
N/A
0.036000 Ib/d
N/A
0.010000 Ib/d
N/A
0.044000 Ib/d
N/A
0.172000 Ib/d
N/A
0.129000 Ib/d
N/A
0.617000 Ib/d
N/A
0.011000 Ib/d
N/A
Maximum
0.131000 Ib/d
N/A
0.131000 Ib/d
N/A
0.143000 Ib/d
M/A
0.060000 Ib/d
N/A
0.339000 Ib/d
N/A
0.394000 Ib/d
N/A
0.447000 Ib/d
N/A
0.556000 Ib/d
N/A
0.131000 Ib/d
N/A
0.106000 Ib/d
N/A
0.106000 Ib/d
N/A
0.068000 Ib/d
N/A
0.010000 Ib/d
N/A
0.087000 Ib/d
N/A
0.297000 Ib/d
N/A
0.129000 Ib/d
H/A
1.550000 Ib/d
N/A
0.011000 Ib/d
N/A
Other
Monitoring Requirements
Frequency
1/quarter
1 /quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
Sample Type
grab
Grab
Grab
24 hr fw composite
24 hr fw composite
24 hr fw composite
grab
Grab
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
Page: 230
-------
Facility Name: Hoechst Celanese Corp. Permit Number: NC0004952
Facility Description: Manufacturers polyester resins , • SIC Code: 2821
2-Nitrophenol
3,4-Benzof luorant
hene
4,6-Dinitro-o-cre
sot
4-Nitrophenol
Acenaphthene
Acenaphthylene
Acrylonitrile
Anthracene
Benzene
Benzo (a) anthrac
ene
Benzo (a) pyrene
Benzo (k) fluoran
thane
Bis (2-chlorisopr
opyl) ether
Bis (2-ethylhexyl
) phthalate
BODS
Carbon tetrachlor
ide
Chlorobenzene
Chloroethane
Chloroform
Chronic WET
Chrysene
CN (t)
Cr (T)
CU (T) •'
Di-n-butyl phthal
ate
0.099000 Ib/d
N/A
0.003000 Ib/d
N/A
0.189000 Ib/d
N/A
0.174000 Ib/d
N/A
0.003000 Ib/d
N/A
0.003000 Ib/d
N/A
0.069000 Ib/d
N/A
0.003000 Ib/d
N/A
0.089000 Ib/d
N/A
0.003000 Ib/d
N/A
0.003000 Ib/d
N/A
0.003000 Ib/d
N/A
0.728000 Ib/d
N/A
0.249000 Ib/d
N/A
275.000000 Ib/d
N/A
0.044000 Ib/d
N/A
0.036000 Ib/d
N/A
0.252000 Ib/d
N/A
0.051000 Ib/d
N/A
N/A '
N/A
0.003000 Ib/d
N/A
0.515000 Ib/d
N/A
2.685000 Ib/d
N/A
1 .016000 Ib/d
N/A
0.065000 Ib/d
N/A
0.167000 Ib/d
N/A
0.003000 Ib/d
N/A
0.670000 Ib/d
N/A
0.300000 Ib/d
N/A
0.003000 Ib/d
N/A
0.003000 Ib/d
N/A
0.069000 Ib/d
N/A
0.003000 Ib/d
N/A
0.132000 Ib/d
N/A
0.003000 Ib/d
N/A
0.003000 Ib/d
N/A
0.003000 Ib/d
N/A
1.831000 Ib/d
N/A
0.675000 Ib/d
N/A
530.000000 Ib/d
N/A
0.092000 Ib/d
N/A
0.068000 tb/d
N/A
0.648000 Ib/d
N/A
0.111000 Ib/d
N/A
N/A
Report
0.003000 Ib/d
N/A
0.515000 Ib/d
N/A
5.154000 Ib/d
N/A
8.175000 Ib/d
N/A
0.138000 Ib/d
N/A
1/quarter
See below
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/day
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
grab
24 hr fw composite
grab
24 hr fw composite
24 hr fw composite
24 hr fw composite
Grab
24 hr fw composite
24 hr fw composite
grab
grab
Grab
Grab
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
Page: 231
-------
Facility Name: Hoechst Cetanese Corp. P6™^ Number: NC0004952
Fact Uty Description: Manufacturers polyester resins SIC Code: 2821
Di ethyl phthalatc
Dimethyl phthalat
e
Ethylbcnzcnc
FC
Flow
Fluoranthcnc
Fluorcno
Hoxoch I orobcnzcne
llexachlorobgtadic
ne
llcxachloroethane
Methyl chloride
Hethylcnc chlorid
e
Maphthalcnc
Hi
Nitrobenzene
OSG
P (T)
Pb (T)
p»l
Phcnanthrcne
Phenol
Pyrene
Tetrachloroothyle
ne
Toluene
TON
0.196000 Ib/d
N/A
0.046000 Ib/d
N/A
0.077000 Ib/d
M/A
M/A
ZOO. 000000 mg/l
N/A
0.800000 MGD
0.060000 Ib/d
N/A
0.003000 Ib/d
N/A
0.001000 Ib/d
N/A
0.048000 Ib/d
N/A
0.051000 Ib/d
N/A
0.208000 Ib/d
N/A
0.097000 Ib/d
N/A
0.003000 Ib/d
N/A
2.779000 Ib/d
N/A
0.065000 Ib/d
N/A
N/A
N/A
N/A
N/A
0.774000 Ib/d
N/A
N/A
N/A
0.003000 Ib/d
N/A
0.036000 Ib/d
N/A
0.003000 Ib/d
N/A
0.039000 Ib/d
N/A
0.063000 Ib/d
N/A
N/A
N/A
0.491000 Ib/d
N/A
0.114000 Ib/d
N/A
0.261000 Ib/d
N/A
N/A
400.000000 mg/l
N/A
N/A
0.164000 Ib/d
N/A
0.003000 Ib/d
N/A
0.001000 Ib/d
N/A
0.119000 Ib/d
N/A
0.131000 Ib/d
N/A
0.460000 Ib/d
N/A
0.215000 Ib/d
N/A
0.003000 Ib/d
N/A
2.779000 Ib/d
N/A
0.164000 Ib/d
N/A
N/A
Report
N/A
Report
1.669000 Ib/d
N/A
N/A
Report
0.003000 Ib/d
N/A
0.063000 Ib/d
N/A
0.003000 Ib/d
N/A
0.089000 Ib/d
N/A
0.193000 Ib/d
N/A
N/A
Report
Units not specified
Units not specified
Between 6.0 SU and 9
.0 SU
1/quarter
1/quarter
1/quarter
1/week
Continuous
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
2/year
1/quarter
1/day
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
2/year
24 hr fw composite
24 hr fw composite
Grab
grab
Record
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
Grab
24 hr fw composite
24 hr fw composite
24 hr fw composite
grab
24 hr fw composite
24 hr fw composite
grab
24 hr fw composite
Grab
24 hr fw composite
24 hr fw composite
Grab
24 hr fw composite
Page: 232
-------
K Permit Number: NC0004952
Facility Description: Manufacturers polyester resins -,„ „ , „„.,„
TSS
Vinyl chloride
Zn (T)
0.051000 Ib/d
N/A
520.000000 Ib/d
N/A
0.222000 Ib/d
N/A
2.540000 Ib/d
N/A
0.131000 Ib/d
N/A
975.000000 Ib/d
N/A
0.222000 Ib/d
N/A
6.313000 Ib/d
N/A
1/quarter
1/day
1/quarter
1/quarter
Grab
24 hr fw composite
Grab
24 hr fw composite
Limitations/Monitoring Basis: " —
ThP li!!!-!:at«0nSnSS"n u°P 2UrfaU °°1 in **** abstract f°r °°^ apply from the permit effective date until 9/30/94
D as welt asrBpS to £L±tT T c? culat!d us^ ELGs in « CFR Pa^ 414.31 Sufapart C and Part 414 41 Subpart
lira?? ?« h« H «? ? un£ S domestic wastewater, groundwater remeditation and boiler water treatment. The FC
limit is based on State UQSs and the fact that the waste is 19% domestic wastewater in a 23:1 dilution The
auTdS/ °l!±?5 Tlr18 'S r:qm>ed °f aU major OCPSF f*"l't'«» and represents 40 CFR Part 4 4?91 Subpart I
Droved1 ThI Rnns fL^-^T ^ are ^er q-all"^y ll"ml"ted- The basis for the monitoring requirements was not
S j?^™^ 2 s-KirsiTn-or'as a 2S,r?rt£; jftjs?3s rs^e
Itd^e^n^^
Cer odaphma. Compliance is defined as no observable inhibition of reproduction or significant mortality at
SS: ssrrstCS-^siir test fau- the permittee - ^^ tH c^r^t^ie^u! UPOn
Outfall: 001B Receiving Water: Buffalo Creek Treatment: AS
Amount/Components: '
Unspecified amount of process and domestic wastewater.
Parameter
1,1,1-Trichloroet
hane
1,1,2-Trichloroet
hane
1,1-Dichloroethan
e
1,1-Dichloroethyl
ene
1,2,4-Trichlorobe
nzene
1,2-Dichlorobenze
ne
1,2-Dichloroethan
e
1,2-Dichloropropa
ne
1,2-Trans-Dichlor
oethylene
1 ,3-0 ich lorobenze
ne
1,3-Dichloroprope
ne
1,4-Dich lorobenze
ne
2,4-Dichloropheno
Limitations
Average .
0.051000 Ib/d
N/A
0.051000 Ib/d
N/A
0.053000 Ib/d
N/A
0.039000 Ib/d
N/A
0.164000 Ib/d
N/A
0.186000 Ib/d
N/A
0.122000 Ib/d
N/A
0.370000 Ib/d
N/A
0.051000 Ib/d
N/A
0.075000 Ib/d
N/A
0.070000 Ib/d
N/A
0.036000 Ib/d
N/A
0.010000 Ib/d
N/A
Maximum
0.131000 Ib/d
N/A
0.131000 Ib/d
N/A
0.143000 Ib/d
N/A
0.060000 Ib/d
N/A
0.339000 Ib/d
N/A
0.394000 Ib/d
N/A
0.447000 Ib/d
N/A
0.556000 Ib/d
N/A
0.131000 Ib/d
N/A
0.106000 Ib/d
N/A
0.106000 Ib/d
N/A
0.068000 Ib/d
N/A
0.010000 Ib/d
N/A
Other
Monitoring Requirements
i Frequency
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
Sample Type
grab
Grab
Grab
24 hr fw composite
24 hr fw composite
24 hr fw composite
grab
Grab
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
Page: 233
-------
Facility Name: Hocchst Celanese Corp. .
. • . • • ' SIC Code: 2821
Facility Description: Manufacturers polyester resins — .
2,4-DiBxsthylpheno
a,4-Dln1trophonol
2,4-Dinftrotoluen
e
2,6-Dinitrotoluen
e
2-Chlorophenol
2-Hitrophenol
3,4-Benzofluorant
herns
4,6-Dinitro-o-cre
sol
4-Mftrophenol
Accnaphthene
Acenuphthylene
Acrylonitrile
Anthracene
Benzene
Bcnzo (a) anthrac
ene
Benzo (a) pyrene
Bcnzo (k) fluoran
thane
Bis (2-chlorisopr
opyl) ether
Bis (2-ethylhexyl
) phthalate
BODS
Carbon tetrachlor
!d«
Chlorobcnzcne
Chloroethane
Chloroform
Chronic WET
0.044000 Ib/d
H/A
0.172000 Ib/d
N/A
0.129000 Ib/d
N/A
0.617000 Ib/d
N/A
0.011000 Ib/d
M/A
0.099000 Ib/d
N/A
0.003000 Ib/d
N/A
0.189000 Ib/d
N/A
0.174000 Ib/d
N/A
0.003000 Ib/d
N/A
0.003000 Ib/d
N/A
0.069000 Ib/d
N/A
0.003000 Ib/d
N/A
0.089000 Ib/d
N/A
0.003000 Ib/d
N/A
0.003000 Ib/d
N/A
0.003000 Ib/d
N/A
0.728000 Ib/d
N/A
0.249000 Ib/d
N/A
85.500000 Ib/d
N/A
0.044000 Ib/d
N/A
0.036000 Ib/d
N/A
0.252000 Ib/d
N/A
0.051000 Ib/d
N/A
N/A
N/A
0.087000 Ib/d
N/A
0.297000 Ib/d
N/A
0.129000 Ib/d
N/A
1.550000 tb/d
N/A
0.011000 Ib/d
N/A
0.167000 Ib/d
N/A
0.003000 Ib/d
N/A
0.670000 Ib/d
N/A
0.300000 Ib/d
N/A
0.003000 Ib/d
N/A
0.003000 Ib/d
N/A
0.069000 Ib/d
N/A
0.003000 Ib/d
N/A
0.132000 Ib/d
N/A
0.003000 Ib/d
N/A
0.003000 Ib/d
N/A
0.003000 Ib/d
N/A
1.831000 Ib/d
N/A
0.675000 Ib/d
N/A
212.200000 Ib/d
N/A
0.092000 Ib/d
N/A
0.068000 Ib/d
N/A
0.648000 Ib/d
N/A
0.111000 Ib/d
N/A
N/A
Report
•
1/quarter
T/quarter
1/quarter
• 1/quarter
T/quarter
1/quarter
1/quarter
1/quarter
1/quarter ',
1/quarter
1/quarter
1/quarter
T/quarter
'I/quarter
1/quarter
1/quarter
, ; 1/quarter
T/quarter
1/quarter
' 1/day
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
24 hr fw composite
24 hr fw composite
24 hr fw composite •
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
grab
24 hr fw composite
grab
24 hr fw composite
24 hr fw composite '
24 hr fw composite
Grab
24 hr fw composite
24 hr fw composite
grab
grab
Grab
Grab
24 hr fw composite
Page: 234
-------
Facility Name: Hoechst Celanese Corp. Permit Numbers .NC0004952
Facility Description: Manufacturers polyester resins s*c Code: 2821
Chrysene
CN (T>
Cr (T)
Cu (T)
Di-n-butyl phthal
ate
Di ethyl phthal ate
Dimethyl phthalat
e
Ethylbenzene
FC
Flow
Fluoranthene
Fluorene
Hexachlorobenzene ,
Hexachlorobutadie
ne
Hexachloroethane
Methyl chloride
Methylene chlorid
e
Naphthalene
Hi (T)
Nitrobenzene
O&G
P (T)
Pb (T)
PH
Phenanthrene
0.003000 Ib/d
N/A
0.515000 lb/d
N/A
2.685000 lb/d
N/A
1 .016000 lb/d
N/A
0.065000 lb/d
N/A
0.196000 lb/d
N/A
0.046000 lb/d
N/A
0.077000 lb/d
N/A
N/A
200.000000
N/A
0.800000 MGD
0.060000 lb/d
N/A
0.003000 lb/d
N/A
0.001000 lb/d
N/A
0.048000 lb/d
N/A
0.051000 lb/d
N/A
0.208000 lb/d
N/A
0.097000 lb/d
N/A
0.003000 lb/d
N/A
2.779000 lb/d
N/A
0.065000 lb/d
N/A
N/A
N/A
N/A
N/A
0.774000 lb/d
N/A
N/A
N/A
0.003000 lb/d
N/A
0.003000 lb/d
N/A
0.515000 lb/d
N/A
5.154000 lb/d
N/A
8.175000 lb/d
N/A
0.138000 lb/d
N/A
0.491000 lb/d
N/A
0.114000 lb/d
N/A
0.261000 lb/d
N/A
N/A
400.000000
N/A
N/A
0.164000 lb/d
N/A
0.003000 lb/d
N/A
0.001000 lb/d
N/A
0.119000 lb/d
N/A
0.131000 lb/d
N/A
0.460000 lb/d
N/A
0.215000 lb/d
N/A
0.003000 lb/d
N/A
2.779000 lb/d
N/A
0.164000 lb/d
N/A
N/A
Report
N/A
Report
1.669000 lb/d
N/A
N/A
Report
0.003000 lb/d
N/A
Units:#/100 ml
Units not specified
Units not specified
Between 6.0 SU and 9
.0 SU
1/quarter
1 /quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/week
Continuous
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
2/year
1/quarter
1/day
1/quarter
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
Grab
Grab
Record
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
24 hr fw composite
Grab
24 hr fw composite
24 hr fw composite
24 hr fw composite
grab
24 hr fw composite
24 hr fw composite
grab
24 hr fw composite
Page: 235
-------
Facility Name: Hoechst Celanese Corp. Permit Number: NC0004952
Facility Description: Manufacturers polyester resins SIC Code: 2821
Phenol
Pyrcnc
Tctrachloroethyle
nc
Toluene
TOM
Trlehloroethylene
TSS
Vinyl chloride
Zn CT)
0.036000 Ib/d
M/A
0.003000 Ib/d
N/A
0.039000 Ib/d
M/A
0.063000 Ib/d
H/A
N/A
N/A
0.051000 Ib/d
N/A
152.800000 Ib/d
N/A
0.222000 Ib/d
N/A
2.540000 Ib/d
N/A
0.063000 Ib/d
N/A
0.003000 Ib/d
N/A
0.089000 Ib/d
N/A
0.193000 Ib/d
N/A
N/A
Report
0.131000 Ib/d
N/A
395.000000 Ib/d
N/A
0.222000 'Ib/d
N/A
6.313000 Ib/d
N/A
1/quarter
1/quarter
1 /quarter
1/quarter
2/year
1/quarter
1/day
1/quarter
1/quarter
Grab
24 hr fw composite
24 hr fw composite
Grab
24 hr fw composite
Grab
24 hr fw composite
Grab
24 hr fw composite
Limitations/Monitoring Basis:
The limitations shown for outfall 001 in the abstract for outfall 001B apply from 10/1/94 until the permit
expiration date. See the basis for outfall 001A.
Outfall: 002 | Receiving Water: Buffalo Creek | Treatment: None
Arrwunt/Cooponcnts :
Unspecified amount of cooling water.
Parameter
Flow
PH
Tcnp.
TRC
Limitations
Average
N/A
N/A
N/A
N/A
N/A
Report
N/A
N/A
Maximum
Report
N/A
N/A
Report
N/A
Report
N/A
Report
Other
Units not specified
Between 6.0 SU and 9
.0 SU
See below
Units not specified
Monitoring Requirements
Frequency
1/week
1/week
1/week
1/week
Sample Type
instantaneous
Grab
Grab
Grab
Limitations/Monitoring Basis:
The basis for the limitations and monitoring conditions was not provided. The temperature of the effluent must not
cause an increase of the receiving stream temp, of more than 2 degrees C, nor cause the ambient temp, to exceed 29
degrees C.
Special Conditions Basis:
The permittee was required to test for pollutants 1/year using EPA approved methods for the following analytical
fractions: purgeables (volatile organics), acid extractables, base/neutral extractables, organochlorine pesticides
and PBCs, herbicides, metals, and other inorganics. In addition, other significant levels of organic chemicals are
to be quantified and reported in the annual pollutant analysis monitoring requirement reporting form. The permittee
is required to obtain authorization for the use of any biocide in the cooling water no later than 90 days prior to
use. The permit contains guidelines for sludge disposal.
Effective Date: 04/01/93 Expiration Date: 12/31/97 Abstract Date: 09/18/92
Page: 236
-------
Facility Name: Crompton and Knowtes
Facility Description: Manufactures
Limit ELGs WQSs
Basis: J_ J_
Storm
Special BMPs Water
Conditions: 2. -
Corp. Permit Number: NC0005274
cyclic intermediates and dye stuffs. SIC Code: 2865
Monitoring
BPJ Only
I. J.
WQ
Sediment Survey
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
J. - - •' I I
Bio
Survey TRES MDLs Monitoring Other
- - - 1 I
Abstract Information:
Complete; Outfalls 001 (A and B created for abstracting purposes) and 002.
Outfall: 001A Receiving Water:
S. Fork Catawba River | Treatment: AerL, Neut, Set, Fil
Amount/Components :
0.3 HGD of process wastewater.
Parameter
1,1,1-Trichloroet
hane
1,1,1-Trichloroet
hane
1,1,2-Trichloroet
hane
1,1,2-Trichloroet
hane
1,1-Dichloroethan
e
1,1-Dichloroethan
e
1,1-Dichloroethyl
ene
1,1-Dichloroethyl
ene
1,2,4-Trichlorobe
nzene
1,2,4-Trichlorobe
nzene
1,2-Dichlorobenze
ne
1 , 2-D i ch lorobenze
ne
1,2-Dichloroethan
e
1,2-Dichloroethan
e
1,2-Dichloropropa
ne
1 , 2-D i ch loropropa
ne
1,2-Trans-Dichlor
oethylene
1,2-Trans-Dichlor
oethylene
Limitations
Monthly
Average
0.135000 Ib/d
N/A
0.135000 Ib/d
N/A
0.135000 Ib/d
N/A
0.135000 Ib/d
N/A
0.148000 Ib/d
N/A
0.148000 Ib/d
N/A
0.063000 Ib/d
N/A
0.063000 Ib/d
N/A
0.350000 Ib/d
N/A
0.350000 Ib/d
N/A
0.408000 Ib/d
N/A
0.408000 Ib/d
N/A •
0.528000 Ib/d
N/A
0.528000 Ib/d
N/A
0.575000 Ib/d
N/A
0.575000 Ib/d
N/A
0.135000 Ib/d
N/A
0.135000 Ib/d
N/A
Dai ly
Maximum
0.053000 Ib/d
N/A
0.053000 Ib/d
N/A
0.053000 Ib/d
N/A
0.053000 Ib/d
N/A
0.055000 Ib/d
N/A
0.055000 Ib/d
N/A
0.040000 Ib/d
N/A
0.040000 Ib/d
N/A
0.170000 Ib/d
N/A
0.170000 Ib/d
N/A
0.193000 Ib/d
N/A
0.193000 Ib/d
N/A
0.170000 Ib/d
N/A
0.170000 Ib/d
N/A
0.383000 Ib/d
N/A
0.383000 Ib/d
N/A
0.053000 Ib/d
N/A
0.053000 Ib/d
N/A
Other
k
Monitoring Requirements
Frequency
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
Sample Type
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Page: 237
-------
Facility Nome: Cronpton and Knowles Corp. Permit Number: NC0005274
Facility Description: Manufactures cyclic intermediates and dye stuffs. SIC Code: 2865
1,3-Dichlorobonze
ne
1,3-Dichlorobenzo
no
1,3-Dichloroprope
ne
1,3-Dichloroprope
ne
1,4-Dichlorobenzc
ne
1,4-Dichlorobcnze
ne
2,4-Dichloropheno
2,4-Dichloropheno
2,4-Dimethylpheno
2,4-Dimethylpheno
2,4-Dinitrophenol
2,4-Dinitrophenol
2,4-Dinitrotolucn
c
2,4-Dinitrotoluen
e
2,6-Dinitrotolucn
e
2,6-Dinitrotoluen
e
2-Chlorophcnol
2-Chlorophcnol
2-Hitrophenol
2-Nitrophenol
4,6-Dinitro-o-cre
sol
4,6-Dinitro-o-cre
sol
4-Kitrophenol
4-Nitrophcnol
Acenaphthene
0.110000 Ib/d
N/A
0.110000 Ib/d
N/A
0.110000 Ib/d
N/A
0.110000 Ib/d
H/A
0.070000 Ib/d
N/A
0.070000 Ib/d
N/A
0.280000 Ib/d
N/A
0.280000 Ib/d
N/A
0.090000 Ib/d
N/A
0.090000 Ib/d
N/A
0.308000 Ib/d
N/A
0.308000 Ib/d
N/A
0.713000 Ib/d
N/A
0.713000 Ib/d
N/A
1.604000 Ib/d
N/A
1.604000 Ib/d
N/A
0.245000 Ib/d
N/A
0.245000 Ib/d
N/A
0.173000 Ib/d
N/A
0.173000 Ib/d
N/A
0.693000 Ib/d
N/A
0.693000 Ib/d
N/A
0.310000 Ib/d
N/A
0.310000 Ib/d
N/A
0.148000 Ib/d
N/A
0.078000 Ib/d
N/A
0.078000 Ib/d
N/A
0.073000 Ib/d
N/A
0.073000 Ib/d
N/A
0.038000 Ib/d
N/A
0.038000 Ib/d
N/A
0.098000 Ib/d
N/A
0.098000 Ib/d
N/A
0.045000 Ib/d
N/A
0.045000 Ib/d
N/A
0.178000 Ib/d
N/A
0.178000 Ib/d
N/A
0.283000 Ib/d
N/A
0.283000 Ib/d
N/A
0.638000 tb/d
N/A
0.638000 Ib/d
N/A
0.078000 Ib/d
N/A
0.078000 Ib/d
N/A
0.103000 Ib/d
N/A
0.103000 Ib/d
N/A
0.195000 Ib/d
N/A
0.195000 Ib/d
N/A
0.180000 Ib/d
N/A
0.180000 Ib/d
N/A
0.055000 Ib/d
N/A
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Page: 238
-------
Facility Name: Crompton and Knowles Corp. Permit Number: NC0005274
Facility Description: Manufactures cyclic intermediates and dye stuffs. SIC Code: 2865
Acenaphthene
Acenaphthylene
Acenaphthylene
Acrylonitrile
Acrylonitrile
Anthracene
Anthracene
Benzene
Benzene
Bis (2-ethylhexyl
) phthalate
Bis (2-ethylhexyl
) phthalate
BODS
BOOS
Carbon tetrachlor
ide
Carbon tetrachlor
ide
Chlorobenzene
Chlorobenzene
Chloroethane
Chloroethane
Chloroform
Chloroform
Chronic WET
Chronic WET
CN (T)
CN CT)
0.148000 Ib/d
N/A
0.148000 Ib/d
N/A
0.148000 Ib/d
N/A
0.605000 Ib/d
N/A
0.605000 Ib/d
N/A
0.148000 Ib/d
N/A
0.148000 Ib/d
N/A
0.340000 Ib/d
N/A
0.340000 Ib/d
N/A
0.698000 Ib/d
N/A
0.698000 Ib/d
N/A
112.000000 tb/d
N/A
112.000000 Ib/d
N/A
0.095000 Ib/d
N/A
0.095000 Ib/d
N/A
0.070000 Ib/d
N/A
0.070000 Ib/d
N/A
0.671000 Ib/d
N/A
0.671000 Ib/d
N/A
0.115000 Ib/d
N/A
0.115000 Ib/d
N/A
N/A
N/A
N/A
N/A
3.002000 Ib/d
N/A
3.002000 Ib/d
N/A
0.055000 Ib/d
N/A
0.055000 Ib/d
N/A
0.055000 Ib/d
N/A
0.240000 Ib/d
N/A
0.240000 Ib/d
N/A
0.055000 Ib/d
N/A
0.055000 Ib/d
N/A
0.093000 Ib/d
N/A
0.093000 Ib/d
N/A
0.258000 Ib/d
N/A
0.258000 Ib/d
N/A
300.000000 Ib/d
N/A
300.000000 Ib/d
N/A
0.045000 Ib/d
N/A
0.045000 Ib/d
N/A
0.038000 Ib/d
N/A
0.038000 Ib/d
N/A
0.260000 Ib/d
N/A
0.260000 Ib/d
N/A
0.053000 Ib/d
N/A
0.053000 Ib/d
N/A
N/A
Report
N/A
Report
1.051000 Ib/d
N/A
1.051000 Ib/d
N/A
See below
See below
See below
See below
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/day
1/day
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
I/quarter
1/quarter
1/quarter
1/quarter
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
24hr fw composite
24hr fw composite
Grab
Grab
' Grab
Grab
Grab
Grab
Grab
Grab
24hr fw composite
24hr fw composite
Grab
Grab
Page: 239
-------
Facility Name: Crompton and Knowles Corp. Permit Number: NC0005274
Facility Description: Manufactures cyclic intermediates and dye stuffs. SIC Code: 2865
Cr
Cr (T)
Cu
Cu (T>
Di-n-butyl phthal
ate
Di-n-butyl phthal
ate
Diethyl phthalatc
Diethyl phthalatc
Dimethyl phthalat
e
Dimethyl phthalat
e
DO
DO
Ethylbonzene
Ethylbenzene
Flow
Flew
Fluoranthene
Fluoranthene
Fluorcne
Fluorcne
Hcxach I orobcnzcne
Hcxach I orobenzone
Hcxachlorobutadie
ne
Hcxach lorobutadi e
ne
Hcxach lorocthanc
6.931000 Ib/d
N/A
6.931000 Ib/d
H/A
8.457000 Ib/d
H/A
8.457000 Ib/d
H/A
0.143000 Ib/d
H/A
0.143000 Ib/d
N/A
0.508000 Ib/d
M/A
0.508000 Ib/d
H/A
0.118000 Ib/d
H/A
0.118000 Ib/d
H/A
H/A
H/A
H/A
H/A
0.270000 Ib/d
H/A
0.270000 Ib/d
H/A
H/A
0.300000 MGD
H/A
0.300000 MGD
0.170000 Ib/d
H/A
0.170000 Ib/d
H/A
0.148000 Ib/d
H/A
0.148000 Ib/d
H/A
0.070000 Ib/d
H/A
0.070000 Ib/d
H/A
0.123000 Ib/d
H/A
0.123000 Ib/d
H/A
0.135000 Ib/d
H/A
2.777000 tb/d
H/A
2.777000 Ib/d
H/A
3.628000 tb/d
H/A
3.628000 Ib/d
H/A
0.068000 Ib/d
H/A
0.068000 Ib/d
H/A
0.203000 Ib/d
H/A
0.203000 Ib/d
N/A
0.048000 tb/d
N/A
0.048000 tb/d
H/A
H/A
Report
H/A
Report
0.080000 Ib/d
H/A
0.080000 Ib/d
N/A
N/A
N/A
N/A
N/A
0.063000 Lb/d
N/A
0.063000 Ib/d
N/A
0.055000 Ib/d
N/A
0.055000 Ib/d
H/A
0.038000 Ib/d
N/A
0.038000 Ib/d
N/A
0.050000 Ib/d
H/A
0.050000 Ib/d
H/A
0.053000 Ib/d
H/A
Units not specified
Units not specified
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/day
1/day
1/quarter
1/quarter
Continuous
Continuous
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Record
Record
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Page: 240
-------
Facility Name: Crompton and Knowles Corp. Permit Number: NC0005274
Facility Description: Manufactures cyclic intermediates and dye stuffs. SIC Code: 2865
Hexach loroethane
Methyl chloride
Methyl chloride
Methylene chlorid
e
Methylene chlorid
e
Na
Na
Naphthalene
Naphthalene
Ni (T)
Ni (T)
Nitrobenzene
Nitrobenzene
Other
Other
P
P (T)
PAHs
PAHs
Pb (T)
Pb (T)
Phenanthrene
Phenanthrene
Phenol
Phenol
0.135000 Ib/d
N/A
0.475000 Ib/d
N/A
0.475000 Ib/d
N/A
0.223000 Ib/d
N/A
0.223000 Ib/d
N/A
N/A
N/A
N/A
N/A
0.148000 Ib/d
N/A
0.148000 Ib/d
N/A
9.958000 Ib/d
N/A
9.958000 Ib/d
N/A
0.170000 Ib/d
N/A
0.170000 Ib/d
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
1.726000 Ib/d
N/A
1.726000 Ib/d
N/A
0.148000 Ib/d
N/A
0.148000 Ib/d
N/A
0.065000 Ib/d
N/A
0.065000 Ib/d
N/A
0.053000 Ib/d
N/A
0.215000 Ib/d
N/A
0.215000 Ib/d
N/A
0.100000 Ib/d
N/A
0.100000 Ib/d
N/A
N/A
Report
N/A
Report
0.055000 Ib/d
N/A
0.055000 Ib/d
N/A
4.228000 Ib/d
N/A
4.228000 Ib/d
N/A
0.068000 Ib/d
N/A
0.068000 Ib/d
N/A
N/A
Report
N/A
Report
N/A
Report
N/A
Report
0.019000 Ib/d
4.800000 ug/l
0.019000 Ib/d
4.800000 ug/l
0.801000 Ib/d
N/A
0.801000 Ib/d
N/A
0.055000 Ib/d
N/A
0.055000 Ib/d
N/A
0.038000 Ib/d
N/A
0.038000 Ib/d
N/A
Units not specified
Units not specified
Chlorine-units not g
iven
Chlorine-units not g
iven
Units not specified
Units not specified
1 /quarter •
1 /quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1 /month
1 /month
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
Grab
Grab
Grab
Grab
Grab
24hr fw composite
24hr fw composite
Grab
Grab
Grab
Grab
Grab
Grab
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Page: 241
-------
Facility Name: Crocnpton and Knowles Corp. Permit Number: NC0005274
Facility Description: Manufactures cyclic intermediates and dye stuffs. , ' SIC Code: 2865
Phenols
Phenols
pyrene
Pyrcne
Temp.
T6fllp.
Tctrachloroethyle
no
Tetrachloroothyle
no
Toluene
Toluene
TOM
TON
Trichloroethylene
Trichloroethylene
TSS
TSS
Vinyl chloride
Vinyl chloride
Zn (T)
Zn CT)
0.660000 Ib/d
H/A
0.660000 Ib/d
N/A
0.168000 Ib/d
N/A
0.168000 Ib/d
H/A
N/A
H/A
M/A
N/A
0.140000 Ib/d
N/A
0.140000 Ib/d
N/A
0.200000 Ib/d
N/A
0.200000 Ib/d
N/A
N/A
N/A
N/A
N/A
0.135000 Ib/d
N/A
0.135000 Ib/d
N/A
143.000000 Ib/d
N/A
143.000000 Ib/d
N/A
0.671000 Ib/d
H/A
0.671000 Ib/d
H/A
6.530000 Ib/d
N/A
6.530000 Ib/d
N/A
1.320000 Ib/d
N/A
1.320000 Ib/d
N/A
0.063000 Ib/d
H/A
0.063000 Ib/d
H/A
N/A
Report
N/A
Report
0.055000 Ib/d
N/A
0.055000 Ib/d
N/A
0.065000 Ib/d
H/A
0.065000 Ib/d
H/A
H/A
Report
N/A
Report
0.053000 Ib/d
H/A
0.053000 Ib/d
H/A
458.000000 Ib/d
N/A
458.000000 Ib/d
N/A
0.260000 Ib/d
H/A
0.260000 Ib/d
N/A
2.627000 Ib/d
H/A
2.627000 Ib/d
H/A
See below
See below
Units not specified
Units not specified
• •
•
1/week
1/week
1 /quarter
1/quarter
1/day
1/day
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/day
1/day
1/quarter
1/quarter
1/quarter
1/quarter
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
24hr fw composite
24hr fw composite
Grab
Grab
24hr fw composite
24hr fw composite
Grab
Grab
Grab
Grab
Limitations/Honitoring Basis: . , , . „ *.,
Tho limitations for Outfall shown in the abstract for 001A apply beginning with the permit effective date until
plant expansion above 0.300 HGO. Host of the limitations were based on ELGs in 40 CFR Part 414.8 Subpart H and 40
CFR 414.91 Subpart I. The phenols and PAHs limits were based on State WQSs. Previous permit limits and monitoring
conditions wore continued for flow, phenols, and pH. The basis for the remaining monitoring conditions was not
provided. The BOOS limit is to be measured by maintaining the temperature at 20 degrees Celcius. Chronic WET
testing is to be conducted using Ceriodaphnia following State guidance. Compliance is defined as no observable
inhibition of reproduction or significant mortality at 0.38% effluent concentration. If any test fails, the
permittee is required to conduct monthly testing. Upon passing, quarterly testing resumes. The temperature of the
effluent is prohibited from causing an increase of temperature in the receiving stream of more than 5 degrees
Farenheit and from causing the ambient temperature to exceed 90 degrees Farenheit. The chemicals defined as PAHs
for this permit are listed. :
Page: 242
-------
Facility Name: Crompton and Knowles Corp. Permit Number: NC0005274
Facility Description: Manufactures cyclic intermediates and dye stuffs. ' SIC Code: 2865
Outfall: 001B | Receiving Water: S. Fork Catawba River | Treatment: AerL, Neut, Set, Fil
Amount/Components :
0.3 HGD of process wastewater.
Parameter
1,1,1-Trichloroet
hane
1,1,1-Trichloroet
hane
1,1,2-Trichtoroet
hane
1,1,2-Trichloroet
hane
1,1-Dichloroethan
e
1,1-Dichloroethan
e
1,1-Dichloroethyl
ene
1,1-Dichloroethyl
ene
1,2,4-Trichlorobe
nzene
1,2,4-Trichlorobe
nzene
1,2-Dichlorobenze
ne
1,2-Dichlorobenze
ne
1,2-Dichloroethan
e
1,2-Dichloroethan
e
1 , 2-D i ch I oropropa
ne
1, 2-D ich I oropropa
ne
1,2-Trans-Dichlor
oethylene
1,2-Trans-Dichlor
oethylene
1 , 3 - D i ch I orobenze
ne
1,3-Dichlorobenze
ne
1,3-Dichloroprope
ne
1,3-Dichloroprope
ne
Limitations
Monthly
Average
0.180000 Ib/d
N/A
0.180000 Ib/d
N/A
0.180000 Ib/d
N/A
0.180000 Ib/d
N/A
0.197000 Ib/d
N/A
0.197000 Ib/d
N/A
0.083000 Ib/d
N/A
0.083000 Ib/d
N/A
0.467000 Ib/d
N/A
0.467000 Ib/d
N/A
0.544000 Ib/d
N/A
0.544000 Ib/d
N/A
0.704000 Ib/d
N/A
0.704000 Ib/d
N/A
0.767000 Ib/d
N/A
0.767000 Ib/d
N/A
0.180000 Ib/d
N/A
0.180000 Ib/d
N/A
0.147000 Ib/d
N/A
0.147000 Ib/d
N/A
0.147000 Ib/d
N/A
0.147000 Ib/d
N/A
Daily
Maximum
0.070000 Ib/d
N/A
0.070000 Ib/d
N/A
0.070000 Ib/d
N/A
0.070000 Ib/d
N/A
0.073000 Ib/d
N/A
0.073000 Ib/d
N/A
0.053000 Ib/d
N/A
0.053000 Ib/d
N/A
0.227000 Ib/d
N/A
0.227000 Ib/d
N/A
0.257000 Ib/d
N/A
0.257000 Ib/d
N/A
0.227000 Ib/d
N/A
0.227000 Ib/d
N/A
0.510000 Ib/d
N/A
0.510000 Ib/d
N/A
0.070000 tb/d
N/A
0.070000 Ib/d
N/A
0.103000 tb/d
N/A
0.103000 Ib/d
N/A
0.097000 Ib/d
N/A
0.097000 Ib/d
N/A
Other
Monitoring Requirements
Frequency
1 /quarter
1 /quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
Sample Type
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Page: 243
-------
Facility Homo: Crompton and Knowles Corp. Permit Number: NC0005274
Facility Description: Manufactures cyclic intermediates and dye stuffs. SIC Code: 2865
1,4-Dichlorofacnze
nc
1,4-Dichlorobenze
ne
2,4*0 ichlorophcno
2,4-Dichlorophcno
t
2,4-Dimcthylpheno
2,4-Oimethylphcno
2,4-Dinitrophcnol
2,4-Dinitrophcnol
2,4-Dinitrotoluen
e
2,4-Dinitrotolucn
c
2,6-Dinitrotoluon
e
2,6-Dinitrotolucn
e
2-Chlorophenol
2-Chlorophcnol
2-Mitrophcnol
2-Nitrophcnol
3,4-Bcnzofluorant
hcno
3,4-8cnzofluorant
hene
4,6-Dinitro-o-cre
sol
4,6-Dinitro-o-cre
sol
4-Hitrophcnol
4-Hitrophenol
Accnaphthcnc
Accnophthcnc
Acenophthylone
0.093000 Ib/d
N/A
0.093000 Ib/d
M/A
0.374000 Ib/d
M/A
0.374000 Ib/d
N/A
0.120000 Ib/d
N/A
0.120000 Ib/d
N/A
0.410000 Ib/d
N/A
0.410000 Ib/d
N/A
0.951000 Ib/d
N/A
0.951000 Ib/d
N/A
2.138000 Ib/d
N/A
2.138000 Ib/d
N/A
0.327000 Ib/d
N/A
0.327000 Ib/d
N/A
0.230000 Ib/d
N/A
0.230000 Ib/d
N/A
0.203000 Ib/d
N/A
0.203000 Ib/d
N/A
0.924000 Ib/d
N/A
0.924000 Ib/d
N/A
0.414000 Ib/d
N/A
0.414000 Ib/d
N/A
0.197000 Ib/d
N/A
0.197000 Ib/d
N/A
0.197000 Ib/d
N/A
0.050000 Ib/d
N/A
0.050000 Ib/d
N/A
0.130000 Ib/d
N/A
0.130000 Ib/d
N/A
0.060000 Ib/d
N/A
0.060000 tb/d
N/A
0.237000 tb/d
N/A
0.237000 Ib/d
N/A
0.377000 Ib/d
N/A
0.377000 Ib/d
N/A
0.851000 Ib/d
N/A
0.851000 Ib/d
N/A
0.103000 Ib/d
N/A
0.103000 tb/d
N/A
0.137000 Ib/d
N/A
0.137000 Ib/d
N/A
0.077000 Ib/d
N/A
0.077000 Ib/d
N/A
0.260000 Ib/d
N/A
0.260000 Ib/d
N/A
0.240000 Ib/d
N/A
0.240000 Ib/d
N/A
0.073000 Ib/d
N/A
0.073000 Ib/d
N/A
0.073000 tb/d
N/A
1/quarter
1/quarter
1 /quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Page: 244
-------
Facility Name: Crompton and Knowles Corp. Permit Number: NC0005274
Facility Description: Manufactures cyclic intermediates and dye stuffs. SIC Code: 2865
Acenaphthylene
Acrylonitrile
Acryloni trite
Anthracene
Anthracene
Benzene
Benzene
Benzo (a) anthrac
ene
Benzo (a) anthrac
ene
Benzo (a) pyrene
Benzo (a) pyrene
Benzo (k) fluoran
thane
Benzo (k) fluoran
thane
Bis (2-ethylhexyl
) phthalate
Bis (2-ethylhexyl
) phthalate
BODS
BODS
Carbon tetrachlor
ide
Carbon tetrachlor
ide
Chlorobenzene
Chlorobenzene
Chloroethane
Chloroethane
Chloroform
Chloroform
0.197000 Ib/d
N/A
0.807000 Ib/d
N/A
0.807000 Ib/d
N/A
0.197000 Ib/d
N/A
0.197000 Ib/d
N/A
0.454000 Ib/d
N/A
0.454000 Ib/d
N/A
0.197000 Ib/d
N/A
0.197000 Ib/d
N/A
0.203000 Ib/d
N/A
0.203000 Ib/d
N/A
0.197000 Ib/d
N/A
0.197000 Ib/d
N/A
0.931000 Ib/d
N/A
0.931000 Ib/d
N/A
150.000000 Ib/d
N/A
150.000000 Ib/d
N/A
0.127000 Ib/d
N/A
0.127000 Ib/d
N/A
0.093000 Ib/d
N/A
0.093000 Ib/d
N/A
0.894000 Ib/d
N/A
0.894000 Ib/d
N/A
0.153000 Ib/d
N/A
0.153000 Ib/d
N/A
0.073000 Ib/d
N/A
0.320000 Ib/d
N/A
0.320000 Ib/d
N/A
0.073000 Ib/d
N/A
0.073000 Ib/d
N/A
0.123000 Ib/d
N/A
0.123000 Ib/d
N/A
0.073000 Ib/d
N/A
0.073000 Ib/d
N/A
0.077000 Ib/d
N/A
0.077000 Ib/d
N/A
0.073000 Ib/d
N/A
0.073000 Ib/d
N/A
0.344000 Ib/d
N/A
0.344000 Ib/d
N/A
437.000000 Ib/d
N/A
437.000000 Ib/d
N/A
0.060000 Ib/d
N/A
0.060000 Ib/d
N/A
0.050000 Ib/d
N/A
0.050000 Ib/d
N/A
0.347000 Ib/d
N/A
0.347000 Ib/d
N/A
0.070000 Ib/d
N/A
0.070000 Ib/d
N/A
See below
See below
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/day
1/day
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
24hr fw composite
24hr fw composite
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Page: 245
-------
Facility Name: Crompton and Knowles Corp. Permit Number: NC0005274
Facility Description: Manufactures cyclic intermediates and dye stuffs. SIC Code: 2865
Chronic WET
Chronic WET
chryscne
Chryscne
CM (T)
CM (T)
Cr
Cr (T>
Cu (T)
Cu
-------
Facility Name: Crompton and Knowles Corp. ' Permit Number: NC0005274
Facility Description: Manufactures cyclic intermediates and dye stuffs. SIC Code: 2865
Fluorene
Hexach lorobenzene
Hexach lorobenzene
Hexach I orobutadi e
ne
Hexach lorobutadie
ne
Hexach loroethane
Hexach loroethane
Methyl chloride
Methyl chloride
Methylene chlorid
e
Methylene chlorid
e
Na
Na
Naphthalene
Naphthalene
Ni (T)
Ni (T)
Nitrobenzene
Nitrobenzene
Other
Other
P (T)
P
PAHs
PAHs
0.197000 Ib/d
N/A
0.093000 Ib/d
N/A
0.093000 Ib/d
N/A
0.163000 Ib/d
N/A
0.163000 Ib/d
N/A
0.180000 Ib/d
N/A
0.180000 Ib/d
N/A
0.634000 Ib/d
N/A
0.634000 Ib/d
N/A
0.297000 Ib/d
N/A
0.297000 Ib/d
N/A
N/A
N/A
N/A
N/A
0.197000 Ib/d
N/A
0.197000 Ib/d
N/A
13.277000 Ib/d
N/A
13.277000 Ib/d
N/A
0.227000 Ib/d
N/A
0.227000 Ib/d
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
0.073000 Ib/d
N/A
1 0.050000 Ib/d
N/A
0.050000 Ib/d
N/A
0.067000 Ib/d
N/A
0.067000 Ib/d
N/A
0.070000 Ib/d
N/A
0.070000 Ib/d
N/A
0.287000 Ib/d
N/A
0.287000 Ib/d
N/A '
0.133000 Ib/d
N/A
0.133000 Ib/d
N/A
N/A
Report
N/A
Report
0.073000 Ib/d
N/A
0.073000 Ib/d
N/A
5.638000 Ib/d
N/A
5.638000 Ib/d
N/A
0.090000 Ib/d
N/A
0.090000 Ib/d
N/A
N/A
Report
N/A
Report
N/A
Report
N/A
Report
0.012000 Ib/d
3.600000 ug/l
0.012000 Ib/d
3.600000 ug/l
Units not specified
Units not specified
Chlorine-units not g
iven
Chlorine-units not g
iven
Units not specified
Units not specified
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1 /month
1 /month
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
24hr fw composite
24hr fw composite
Grab
Grab
Grab
Grab
Grab
Grab
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
Grab
Grab-
Page: 247
-------
Facility Home: Crompton and Knowles Corp. Permit Number: NC0005274
Facility Description: Manufactures cyclic intermediates and dye stuffs. SIC Code: 2865
Pb (T)
Pb (T)
Phenanthrcne
Phcnanthrene
Phenol
Phenol
Phenols
Phenols
Pyrcne
Pyrcne
Terop.
Temp.
Tctrachloroothyle
no
Tetrachloroothyle
ne
Toluene
Toluene
TOM
TON
Trichloroethylene
Trichlorocthylene
TSS
TSS
Vinyl chloride
Vinyl chloride
Zn (T)
2.30ZOOO Ib/d
N/A
2.302000 Ib/d
N/A
0.197000 Ib/d
H/A
0.197000 Ib/d
H/A
0.087000 Ib/d
N/A
0.087000 Ib/d
H/A
0.660000 Ib/d
H/A
0.660000 Ib/d
H/A
0.224000 Ib/d
H/A
0.224000 Ib/d
H/A
H/A
H/A
H/A
H/A
0.187000 Ib/d
N/A
0.187000 Ib/d
H/A
0.267000 Ib/d
H/A
0.267000 Ib/d
N/A
H/A
H/A
H/A
H/A
0.135000 Ib/d
H/A
0.135000 Ib/d
H/A
192.000000 Ib/d
H/A
192.000000 Ib/d
N/A
0.894000 Ib/d
H/A
0.894000 Ib/d
H/A
8.707000 Ib/d
H/A
1.068000 tb/d
H/A
1.068000 Ib/d
H/A
0.073000 Ib/d
N/A
0.073000 Ib/d
H/A
0.050000 Ib/d
N/A
0.050000 Ib/d
N/A
1.320000 Ib/d
N/A
1.320000 Ib/d
N/A
0.083000 Ib/d
N/A
0.083000 Ib/d
N/A
H/A
Report
N/A
Report
0.073000 Ib/d
N/A
0.073000 Ib/d
H/A
0.087000 Ib/d
N/A
0.087000 Ib/d
N/A
H/A
Report
N/A
Report
0.053000 Ib/d
N/A
0.053000 tb/d
N/A
615.000000 Ib/d
N/A
615.000000 Ib/d
N/A
0.347000 Ib/d
N/A
0.347000 Ib/d
N/A
3.503000 Ib/d
N/A
See below
See below
Units not specified
Units not specified
total suspended resi
due
total suspended resi
clue
1/quarter
1 /quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/week
1/week
1/quarter
1/quarter
1/day
1/day
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/day
1/day
1/quarter
1/quarter
1/quarter
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
24hr fw composite
24hr fw composite
Grab
Grab
24hr fw composite
24hr fw composite
Grab
Grab
Grab
Page: 248
-------
Facility Name: Crompton and Knowles Corp. Permit Number: NC0005274
Facility Description: Manufactures cyclic intermediates and dye stuffs. SIC Code: 2865
Zn (T)
8.707000 Ib/d
N/A
3.503000 Ib/d
N/A
1/quarter
Grab
Limitations/Monitoring Basis: .
The limitations for Outfall 001 shown in the abstract for 001B apply beginning with the permit effective date until
plant expansion above 0.300 HGD. See the basis discussion for Outfall 001A. Compliance with the chronic WET
requirement is defined as no observable inhibition of reproduction or significant mortality at 0.5 % effluent
concentration.
Outfall: 002 Receiving Water: S. Fork Catawba River | Treatment: None
Amount/Components :
Unspecified amount of cooling water.
Parameter
Flow
Flow
pH
PH
Temp.
Temp.
TRC
TRC
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
N/A''
N/A
N/A
Report
N/A
Report
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
Report MGD
N/A
Report MGD
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
Report
Other
Between 6.0 su and 9
.0 su
Between 6.0 su and 9
.0 su
See below
See below
Units not specified
Units not specified
Monitoring Requirements
Frequency
1/week
1/week
1/week
1/week
1/week
1/week
I/week
1/week
Sample Type
Instantaneous
Instantaneous
Grab
Grab
Grab
Grab
Grab
Grab
Limitations/Monitoring Basis:
The temperature of the effluent must not cause an increase in the temperature of the receiving stream of more than
2.8 degrees Celcius and must not cause the ambient temperature to exceed 32 degrees Celcius. The discharge of
floating solids or visible foam in other than trace amounts is prohibited.
Special Conditions Basis:
The permittee is required to test for pollutants 1/year using EPA approved methods for the following analytic
fractions: purgeables (volatile organics), acid extractables, base/neutral extractables, organochlorine pesticides
and PCBs, herbicides, metals, and other inorganics. In addition, other significant levels of organic chemicals are
to be quantified and reported in the annual pollutant analysis monitoring requirement reporting form. The permittee
is required to obtain authorization for use of any biocide in the cooling water no later than 90 days prior to use.
Guidelines for sludge disposal are provided.
Effective Date: 03/01/93 Expiration Date: 05/01/96 Abstract Date: 09/18/93
Page: 249
-------
Facility Name: Fieldcrest Cannon, Inc. Permit Number: MC0005479
Facility Description: Carpet manufacturer SIC Code: 2271
, , Monitoring WET WET Testing Multiple
Limit ELGs WQSs BPJ Only Limits Only Categories
Basis: 1 J. 2. J. -_ I ^
Storm UQ Bio
Special BMPs Water Sediment Survey Survey TRES MDLs
Conditions: ^ z z z. z
Tiered
Limits Other
Monitoring Other
J. -
Abstract Information:
Complete; Outfall 001
Outfall: 001 | Receiving Water: Gum Swamp Creek | Treatment: AerL+Clar+Neut+Dis
Amount/Components :
0.3 MGD of industrial and domestic wastewater.
Parameter
Bis (H-cthylhoxyl
) phthalate
BODS
Chronic WET
COD
DO
FC
Flow
HH3-H
Other
P
pa
Temp.
TKH
TRC
TSS
Limitations
Average
N/A
N/A
54.200000 Ib/d
N/A
H/A
H/A
100.800000 Ib/d
H/A
N/A
N/A
H/A
200.000000
H/A
0.300000 mgd
H/A
H/A
N/A
H/A
H/A
H/A
N/A
H/A
H/A
N/A
N/A
N/A
H/A
N/A
54.200000 Ib/d
H/A
Maximum
N/A
735.000000 ug/l
106.400000 Ib/d
N/A
N/A
Report
201.600000 Ib/d
N/A
N/A
Report
N/A
400.000000
H/A
N/A
H/A
Report
N/A
Report
N/A
Report
H/A
Report
N/A
Report
N/A
Report
N/A
Report
106.400000 Ib/d
N/A
Other
See below
Units not specified
Units: #/100 ml
Units not specified
MBAS: units not spec
ified
Units not specified
Between 6.0 su and 9
.0 su
Units not specified
Units not specified
units not specified
Monitoring Requirements
Frequency
1/quarter
1/week
1/quarter
1/week
1/week
1/week
Continuous
1 /month
1 /month
1/quarter
1/day
1/week
1 /month
1/day
1/week
Sample Type
Grab
Composite
Composite
Composite
Grab
Grab
Recorder
Composite
Composite
Composite
Grab
Grab
Composite
Grab
Composite
Limitations/Monitoring Basis:
Upstream and downstream samples are to be analyzed for FC and temperature. The influent flow is to be monitored as
Hell as the effluent flow. Chronic WET testing is to be conducted following state guidance using ceriodaphnia. The
effluent concentration at which there may be no observable inhibition of reproduction or significant mortality is
1.5%. The permit contains a prohibition of discharge of floating solids or visible foam in other than trace
amounts. Upstream and downstream grab samples are to be tested for conductivity 1/week. The limits for BODS COD
TSS, and pH Here calculated using 40 CFR guidelines 410 Subpart C (low water use processing),410.32 (general
processing - BPT). Limits for bis (2-ethylhexyl) phthalate and fecal coliform are based on water quality standards
contained in 15 NCAC 2B.0211. The toxicity test is based on the instream waste concentration.
Page: 250
-------
Facility Name: Fieldcrest Cannon, Inc. Permit Number: NC0005479
Facility Description: Carpet manufacturer SIC Code: 2271
Special Conditions Basis:
The permit contains a reopener based on the results of the WET testing or any other test results that indicate
potential impacts to the receiving stream. The permittee is required to conduct annual tests for specified
pollutants using EPA approved methods. As part of this annual pollutant analysis monitoring, the permittee is
required to identify the largest 10 GC/MS peaks in the purgeable, base/neutral extractable, and acid extractable
fractions (or fewer, as applicable) for chemicals other than those specified, and approximately quantify them.
Effective Date: 08/01/91 Expiration Date; 12/31/94 Abstract Date: 09/10/93
Page: 251
-------
Facility Name: Gutzmer Construction - Lisbon Permit Number: ND0023809
Facility Description: Sand and gravel washing operation
Limit ELGs WQSs
Basis: ^ I
Storm
Special BHPs Water S
Conditions: z. -
Monitoring
BPJ Only
J. 2.
WQ
ediment Survey
WET WET Testing Multiple
Limits Only Categories
Bio
Survey TRES MDLs Ho
SIC Code: 1442
Tiered
Limits Other
nitoring Other
Abstract Information:
Complete; Outfall 001.
Outfall: 001 | Receiving Water: Sheyenne River | Treatment: FU
Amount/Components:
Unspecified amounts of wash water and/or pit dewatering stormwater discharges.
Parameter
Flow
OSG
p«
TSS
Limitations
Daily
Average
N/A
Report mgd
N/A
N/A
N/A
N/A
N/A
30.000000 mg/l
Daily
Maximum
N/A
N/A
H/A
10.000000 mg/l
N/A
N/A
N/A
45.000000 mg/l
Other
See below
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/day
1/day
1/week
1/week
Sample Type
instantaneou
visual
grab
grab
Limitations/Monitoring Basis:
Effluent limitations are based on 40 CFR Part 436. subpart C, North Dakota Water Quality Standards, and BPJ. The
limitations are continued from the previous permit. If a visible sheen or floating oil is seen in the effluent, a
grab sample must be taken and analyzed to ensure compliance with the O&G limitation. The bases of the monitoring
Mere not described.
Special Conditions Basis:
H/A
Effective Date: 07/01/92
Expiration Date: 06/30/97 Abstract Date: 04/13/93
Page: 252
-------
Facility Name: Minn-Dak Farmers Cooperative Permit Number: ND0024368
Facility Description: Sugar beet and beet fiber processing SIC Code: 2063
Monitoring
Limit ELGs WQSs BPJ Only
Basis: J. J. 4. J.
Storm UQ
Special BMPs Water Sediment Survey
Conditions: z. - - -
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
- I - - 1
Bio
Survey TRES MDLs Monitoring Other
- I -11
Abstract Information:
Complete for outfalls 001 and 002.
Outfall: 001 Receiving Water: Red River Treatment: AnD, AerD, CAC
Amount/Components :
Unspecified amount of treated wastewaters from storage pond with capacity of approximately 200 million gallons.
Parameter
Acute WET
BODS
COD
DO
FC
Flow
NH3-N
PH
Temp.
TSS
Limitations
Average
N/A
N/A
N/A
25.000000 mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
N/A
N/A
Report mgd
N/A
Report mg/l
N/A
N/A
N/A
N/A
N/A
30.000000 mg/l
daily
Maximum
99999.000000
N/A
N/A
N/A
N/A
Report mg/l
N/A
Report mg/l
N/A
400.000000
N/A
Report mgd
N/A
Report mg/l
Report
N/A
32.000000
N/A
N/A
N/A
Other
See below
See below
Units: #/100 ml
See below
Between 6.0 su and 9
.0 su
Units: degrees celci
us
See below
Monitoring Requirements
Frequency
1 /quarter
1/day
1/day
1/day
1/day
continuous
2/week
1/day
1/day
1/day
Sample Type
grab
grab
grab
grab
grab
recorder
grab
grab
grab
grab
Limitations/Monitoring Basis:
Limitations are based on the Sugar Processing Point Source Category, Subpart A - Beet Sugar Processing Subcategory
(40 CFR Part 409.10-17), North Dakota Water Quality Standards, and BPJ. BODS is based on WQS and is retained from
the previous permit. The maximum allowable Ib/d BODS and TSS are WQ-based on the flow of the receiving stream and
the Ibs of sugar produced (per ELGs), using the more stringent. When flow in the Red River is less than 100 cfs, no
discharge is allowed unless extenuating circumstances exist and specific authorization has been granted. When flow
in the Red River is from 100 to 600 cfs, the maximum allowable discharge of BODS and TSS is to be determined on a
case by case basis using equations provided. Acute static replacement toxicity tests roust be performed once per
quarter. (Discharge authorization must be granted by the State.)
Outfall: 002 Receiving Water: Red River | Treatment: Not specified.
Amount/Components :
Unspecified amount of discharge from groundwater wells on intermittent basis.
Parameter
Flow
Limitations
Daily
Average
N/A
Report mgd
Dai ly
Maximum
N/A
N/A
Other
Monitoring Requirements
Frequency
1/day
Sample Type
instant.
Page: 253
-------
Facility Name: Mim-Dak Farmers Cooperative
Permit Number: ND0024368
Facility Description: Sugar beet and beet fiber processing
SIC Code: 2063
Other
Report
H/A
N/A
H/A
See below - gen. ana
lysis
1/quarter
grab
Limitations/Monitoring Basis:
Ground water from two wells is pumped and used for plant process water. No discharge has occurred since 1989. No
limitations are set for Outfall 002 per the previous permit. The permit provides that no discharge of process water
or contaminated area runoff shall be allowed. During periods of discharge, the permittee must monitor for a general
chemical analysis including the following pollutants: Ca, Hg, Na, K, Fe, Mn, conductivity, pH,total hardness (as
CaC03), TDS, N04, turbidity, S04, and flow.
Special Conditions Basis:
The permittee is required to monitor Red River for DO I/day in three places, and monitor Red River flow 1/day during
discharge periods. No discharge is allowed during periods of ice cover. Predischarge samples must be taken and
analyzed for NH3, BODS, COD, fecal coliforms, pH, and TSS. Once per quarter the permittee is required to monitor
for S03, Ar, Cu, hardness, Hg, Se, S04, and total Zn. No discharge is allowed when the Red River flow is less than
100 cfs unless extenuating circumstances exist and specific authorization has been made by permitting authority.
Pounds of sugar must be reported each month. Once per quarter, acute static replacement toxicity tests must be
conducted on seperate grab samples. Using acute 48-hour tests for ceriodaphnia sp. and acute 96-hour tests for
fathead minnows. If acute toxicity occurs, additional tests shall be conducted. If acutetoxicity occurs in the
second test, testing shall be conducted on each subsequent discharge but no more than one per month. If 4
consecutive acute toxicity tests over a 12-month period shows no acute toxicity, permittee may request a reduction
to quarterly testing of one species.
Effective Date: 04/01/92
Expiration Date: 03/31/97
Abstract Date: 04/13/93
Page: 254
-------
Facility.Name: Coteau Properties Co - Beulah
Permit Number: ND0025038
Facility Description: Surface coal mining and reclamation activities
SIC Code: 1221
Limit
Basis:
ELGs
WQSs
I
BPJ
Monitoring
Only
WET
Limits
WET Testing
Only
Multiple
Categories
Tiered
Limits
Other
J.
Special
Conditions:
BMPs
Storm
Water .
Sediment
WQ
Survey
Bio
Survey
TRES
MDLs
Monitoring
Other
Abstract Information:
Partial; One outfall representative of 37. Outfalls 002A, 002B, 002C/002D, 002E, and 002F were created for abstract
purposes. .. . ., . , .
Outfall: 002A
Receiving Water: Beulah Trench Creek.
Treatment: Sed
Amount/Components: ' , .,
Unspecified amount from.sedimentation ponds to treat drainage from active surface mining areas.
Parameter
Fe (T)
Flow
O&G
pH
TSS
Limitations
Daily
Average
' N/A
3.500000 rag/ I
N/A
Report mgd
N/A
N/A
N/A
Report
N/A
35.000000 mg/l
Daily
,. Maximum
N/A
7.000000 mg/l
N/A
N/A
N/A
10.000000 mg/l
N/A
N/A
N/A
70.000000 mg/l
Other
See below
See below
Between 6.0 su and 9
.0 su
See below
Monitoring Requirements
Frequency
1 /month
1/day
1/day
1 /month
1/week
Sample Type
grab
instant.
visual
instant.
grab
Limitations/Monitoring Basis:
Limits and monitoring conditions for Fe (T) and TSS shown for Outfall 002D apply at Outfall 002A during
precipitation or snow melt events. North Dakota State Department of Health and Consolidated Laboratories standards
apply for five phases of mining activities: 1) active mining areas, 2) reclamation areas, seeding complete, 3)
reclamation areas, vegetation established, 4) discharges attributable to precipitation or snow melt events, and5)
discharges from sewage lagoons. Limits are continued from the previous permit. For sedimentation pond removal
sites, BMPs replace effluent limitations and monitoring requirements. The Public Service Comission's Policy
Memorandum No. 19 is used for water quality and vegetative standards which must be met before a structure is
removed. If a visible sheen or floating oil is found in the effluent, a grab sample is to be analyzed to ensure
compliance with the limits.
Outfall: 002B
Receiving Water: Beulah Trench Creek
Treatment: Sed
Amount/Components:
Unspecified amount from sedimentation ponds to treat drainage from reclamation areas, seeding complete.
Parameter
Flow
PH
TSS
Limitations
Daily
Average
N/A
Report mgd
N/A
Report
N/A
N/A
Daily
Maximum
N/A
N/A
N/A
N/A
N/A
70.000000 mg/l
Other
Between 6.0 su and 9
.0 su
See below
Monitoring Requirements
Frequency
1/day
1 /month
1/week
Sample Type
instant.
instant.
grab
Limitations/Monitoring Basis:
See Limitations/Monitoring Basis for Outfall 002A.
Page: 255
-------
Facility Name: Coteau Properties Co - Beulah Permit Number: ND0025038
Facility Description: Surface coal mining and reclamation activities SIC Code: 1221
Outfall: 002C | Receiving Water: Beulah Trench Creek | Treatment: Sed
Amount/Components:
Unspecified amount from sedimentation ponds to treat drainage from reclamation areas, vegetation established.
Parameter
Flow
pll
TSS
Limitations
Daily
Average
N/A
Report mgd
N/A
Report
N/A
N/A
Daily
Maximum
N/A
N/A
N/A
N/A
N/A
70.000000 mg/l
Other
Between 6.0 su and 9
.0 su
See below
Monitoring Requirements
Frequency
1/day
1/quarter
1 /quarter
Sample Type
instant.
instant.
grab
Limitations/Monitoring Basis:
Sec Limitations/Monitoring Basis for Outfall 002A.
Outfall: 0020 | Receiving Water: Beulah Trench Creek | Treatment: Sed
Amount/Components :
Unspecified amount from sedimentation ponds designed to contain 10-yr 24-hr storm; active mining and reclamation,
seeding complete.
Parameter
Fe
Flow
OSG
ptl
ss
TSS
Limitations
Daily
Average
N/A
Report mg/l
N/A
Report mgd
N/A
N/A
N/A
Report
N/A
N/A
N/A
Report mg/l
Daily
Maximum
N/A
N/A
N/A
N/A
N/A
10.000000 mg/l
N/A
N/A
N/A
0.500000 ml/I
N/A
Report mg/l
Other
See below
See below
Between 6.0 su and 9
.0 su
See below
Monitoring Requirements
Frequency
1 /month
1/day
1/day
1 /month
1/week
1/week
Sample Type
grab
instant.
visual
instant.
grab
grab
Limitations/Monitoring Basis:
See Limitations/Monitoring Basis for Outfall 002A. Fe (T) and O&G limits are applicable to active mining areas
only. Daily maximum limitation for SS is waived if there is a precipitation event and/or snow melt greater than 3.1
inches in 24 hours.
Outfall: OOHE | Receiving Water: Beulah Trench Creek | Treatment: Sed
Amount/Components:
Unspecified amount from sedimentation ponds designed to contain 10-yr, 24-hr storm; reclamation area, vegetation
established.
Parameter
Flow
pH
Limitations
Dai ly
Average
N/A
Report mgd
N/A
Report
Daily
Maximum
N/A
N/A
N/A
N/A
Other
Between 6.0 su and 9
.0 su
Mom" tori ng Requi rements
Frequency
1/day
1/quarter
Sample Type
instant.
instant.
Page: 256
-------
Facility Name: Coteau Properties Co - Beulah Permit Number: ND0025038
Facility Description: Surface coal mining and reclamation activities SIC Code: 1221
SS
TSS
N/A
N/A
N/A
N/A
N/A
0.500000 ml/I
N/A
Report mg/l
See below
1 /quarter
1/quarter
grab
grab
Limitations/Monitoring Basis:
See Limitations/Monitoring Basis for Outfall 002A. Daily maximum limitation for SS is waived if there is a
precipitation event and/or snow melt greater than 3.1 inches in 24 hours.
Outfall: 002F | Receiving Water: Beulah Trench Creek | Treatment: Sed
Amount/Components:
Unspecified amount from sewage lagoons.
Parameter
BODS
Flow
O&G
pH
TSS
Limitations
Dai ly
Average
N/A
25.000000 rag/ I
N/A
Report mgd
N/A
N/A
N/A
Report
N/A
30.000000 mg/l
Daily
Maximum
N/A
45.000000 mg/l
N/A
N/A
N/A
10.000000 mg/l
N/A
N/A
N/A
45.000000 mg/l
Other
See below
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1 /week
1/day
1/day
1 /month
1/week
Sample Type
grab
instant.
visual
instant.
grab
Limitations/Monitoring Basis:
See Limitations/Monitoring Basis for Outfall 002A.
Special Conditions Basis:
BHPs and all procedures identified in the approved reclamation plan are required to be followed throughout the
course of the pond removal. Pond removal activities are required to be summarized on the DHR.
Effective Date: 01/01/92 Expiration Date: 12/31/96 Abstract Date: 04/13/93
Page: 257
-------
Facility Naroo: Basin Electric Power Coop-Bism Permit Number: ND0025232
Facility Description: Lignite coal-fired steam electric generating plant . SIC Code: 4931
Monitoring
Limit ELGs WQSs BPJ Only
Basis: J. J. 1 J.
Storm WQ
Special BHPs Water Sediment Survey
londitions: z. - - J-
WET WET, Testing Multiple Tiered
Limits Only Categories Limits Other
2. J. - - • J. -
Bio
Survey TRES MDLs Monitoring Other
- J. - I ' - .
Abstract Information: . , • •
Partial for outfalls 001, 003, 004, 007, 008, 009, and 010; 3 other outfallspare either similar to the selected
outfalls or have no regulated discharge point.
Outfall: 001 | Receiving Water: Missouri . | Treatment: Not specified.
Amount/Components:
Average of 71.36 once through cooling water discharge, daily screen washings, and ash pond overflow.
Parameter
Acute WET
Flow
Metals (T)
pH
Terop.
TRC
Limitations
Average
H/A
N/A
N/A
Report mgd
N/A
Report mg/ I
N/A
Report
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
Report
N/A
Report mgd
N/A
Report ' mg/ 1
N/A
Report
N/A
37.200000
9.900000 Ib/d
0.200000 mg/l
Other
See below
Between 6.5 su and 9
.0 su
Units: degrees celci
us
Applies when ch I or in
at ing
Monitoring Requirements
Frequency
1/quarter
1/week
2/year
1/week
continuous
1/week
Sample Type
grab
instant.
grab
grab
recorder
grab
Limitations/Monitoring Basis:
Limitations are based on ELG - 40 CFR Part 423. The limitations are for the once-through cooling water because the
other waste streams are regulated at internal points. The pH limit is continued from the existing permit. The limit
for tcflw. is WQ-based. The TRC mass limit was calculated using 1/12 the average discharge rate. Monitoring for TRC
Is unnecessary when there is no chlorination. Acute toxicity testing must be performed on Outfall 001 effluent
1/quartcr beginning July 1, 1992. Static replacement toxicity tests are to be conducted 1/quarter using a 48-hour
test with Ceriodaphnia sp. and a 98-hour test with fathead minnows. Acute toxicity is 50% or more mortality at any
concentration. The tests are to be conducted following EPA and Regional guidance documents. If toxicity occurs, a
second test is to be conducted within 4 weeks. If toxicity continues, testing is required 1/month, and a TRE may be
rcoAjIred. Maximum limitation for TSS is 100 mg/l for discharge overflow caused by a rainfall in excess of 3.2 ;
Inches in a 24hr period. Cu (T) and Fe (T) are to be monitored 14 and 21 days after metal cleaning activities
sampled at Discharge 008. If ash pond effluent is present in outfall 003 discharge, sampling must be performed for
total recoverable As, Ba, B, Cd, Cr, Cu, Pb, Hg, Se, and Zn.
Outfall: 003 | Receiving Water: Internal to Outfall 001. , | Treatment: Not specified.
Amount/Corcponents: , . ' - "
Average flow of 8.78 mgd of low volume wastes, fly ash and bottom ash transport water, and coal pile and plant/site
runoff.
Parameter
Acute WET
CU (T)
Fc (T)
Limitations
Average
N/A
N/A
N/A
1.000000 mg/l
N/A
1.000000 mg/l
Dai ly
Maximum
N/A
Report
N/A
1.000000 mg/l
N/A
1.000000 mg/l
Other
See below
Monitoring Requirements
Frequency
2/year
variable
variable
Sample Type
grab :
grab
grab
Page: 258
-------
Facility Name: Basin Electric Power Coop-Bism Permit Number: ND0025232
Facility Description: Lignite coal-fired steam electric generating plant SIC Code: 4931
Flow
Metals
-------
Facility Homo: Basin Electric Power Coop-Bism Permit Number: ND0025232
Facility Description: Lignite coal-fired steam electric generating plant SIC Code: 4931
TSS
N/A
30.000000 mg/l
N/A
100.000000 mg/l
1/week
grab
Limitations/Monitoring Basis:
Monitoring requirements are based on BPJ. Limitations for O&G and TSS, based on BPJ, are taken from low volume
waste in ELGs 40 CFR Part 423. A temperature limit was not considered necessary. Discharge of PCBs is prohibited.
Outfall: 009 | Receiving Water: Internal to Outfall 001 | Treatment: Not specified.
Amount/Components:
Unspecified amount of sump discharge from the pump intake.
Parameter
Flow
O&G
pH
TSS
Limitations
Daily
Average
N/A
Report mgd
N/A
N/A
N/A
Report
N/A
Report mg/l
Dai ly
Maximum
N/A
Report mgd
N/A
10.000000 mg/l
N/A
Report
N/A
Report mg/l
Other
Between 6.5 su and 9
.0 su
Monitoring Requirements
Frequency
1/day
1/day
1/week
1/week
Sample Type
instant.
visual
grab
grab
Limitations/Monitoring Basis:
The basis for the monitoring requirements was not discussed.
Outfall: 010 | Receiving Water: Internal to Outfall 003 | Treatment: Not specified.
Amount/Components :
Unspecified amount of runoff water from the plant site.
Parameter
BOOS
COO
OSG
P (T)
TDS
TKH
TON
TSS
Limitations
Daily
Average
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
Dai ly
Maximum
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/ 1
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
Other
Monitoring Requirements
Frequency
2/year
2/year
2/year
2/year
2/year
2/year
2/year
2/year
Sample Type
grab
grab
grab
grab
grab
grab
grab
grab
Limitations/Monitoring Basis:
Honitoring was established based on the expectation that this outfall will soon be covered by a storm water general
permit.
Page: 260
-------
Facility Name: Basin Electric Power Coop-Bism
Facility Description
Lignite coal-fired
Permit Number: ND0025232
steam electric generating plant
Outfall: 008 | Receiving Water: Internal to Outfall 003
Amount/Components :
Unspecified amount from boiler bottom for metal cleaning
Parameter
Cu (T)
Fe (T)
Tr
wastes.
Limitations
Dai ly
Average
N/A
Report mg/l
N/A
Report mg/l
Dai ly
Maximum
N/A
Report mg/l
N/A
Report mg/l
Other
SIC Code: 4931
eatment: Not specified.
Monitoring Requirements
Frequency
variable
variable
Sample Type
grab
grab
Limitations/Monitoring Basis: , , . ... _
The basis for the monitoring requirement was not discussed. Permittee must monitor 1/metal cleaning event until Z
samples/month have been obtained.
Special Conditions Basis: .... ,
Acute toxicity testing must be performed on effluent from Outfall 003 once per quarter. If toxicity is detected, a
TRE may need to be performed. TRC may not be discharged from any single generating unit for more than 2 hours per
day unless the discharge is required for macroinvertebrate control. Monitoring for TRC is not necessary if
chlorination is not occurring. For 003, in addition to quarterly monitoring for metals, a general chemical analysis
and monitoring for metals, CM, and total phenols must be performed once over the life of the permit. For 004, samples
must be taken at the north end of the septic tank addition to the sewage treatment plant. For 007, no increase in
temp, of the Missouri River greater than 5 degrees above background is allowed.For 010, only 1 sample/year may be
collected from snowmelt runoff. The other must be from a rain event.
Effective Date: 01/01/92
Expiration
Date: 12/31/96
Abstract Date: 04/15/93
Page: 261
-------
Facility Name: Coy Paper Company, Inc.
Permit Number:. NH0001261
Facility Description: Lightweight paper manufacturer producing specialty tissue paper
SIC Code: 2621
Limit
Basis;
ELGs
WQSs
J.
BPJ
Monitoring
Only
•L
WET
Limits
I
WET Testing
Only
Multiple
Categories
Tiered
Limits
I
Other
Special
Conditions:
BMPs
Storm
Water
Sediment
WQ
Survey
Bio
Survey
TRES
MDLs
Monitoring
Other
Abstract Information:
Complete; Outfalls 001 (abstracted as 001A and 001B) and 002.
Outfall: 001A | Receiving Water: Sugar River
Treatment: Neut, Floe
Amount/Components:
0.4 MOD process flow, unquantified River intake filter discharges.
Parameter
Acute WET
8005
Flow
P (T)
PH
TSS
Limitations
Monthly
Average
N/A
N/A
Report mg/l
295.000000 Ib/d
N/A
Report MGD
Report mg/l
N/A
N/A
Report
Report mg/l
235.000000 Ib/d
Daily
Maximum
N/A
100.000000 %
Report mg/l
300.000000 Ib/d
N/A
Report MGD
N/A
N/A
N/A
Report
Report mg/l
350.000000 Ib/d
Other
See below
Between 6.5 su and 8
.0 su
Monitoring Requirements
Frequency
4/year
2/month
continuous
4/year
continuous
2/month
Sample Type
24hr fw composite
24hr fw composite
reorder
24hr fw composite
recorder
24hr fw composite
Limitations/Monitoring Basis: • '
These limitations are applicable for "Production Level 1", defined as current production levels, 9.96 tons/day. The
permittee is required to report monthly production levels 1/quarter. Production-based ELGs were calculated for the '
BOO and TSS limits using 40 CFR Part 430, Subpart X for the pulp and paper industrial category. Total tons of paper
produced must be reported for each month in the quarter in terms of tons/day where day refersto the number of
calendar days the mill was in operation during the month. Federal anti-backsliding regulations [40 CFR 122.44(1)]
require previously existing more stringent limits for BOD and TSS Level 1 (535 and 480 mg/respectively) and Level 2
(645 and 580 mg/l, respectively) daily maximum limits. Also, the average monthly BOD Level 2 limit (355 mg/l) was
deleted due to antibacksliding since the existing permit limit was 300 mg/l. Production Level 2 limits apply after
prior notice and approval by EPA. Based on ELG, the permittee certified that it does not use chlorophenolic
containing biocides in its process. Reporting for maximum daily and average monthly BOD and TSS and phosphorous are
required per a requirement that the State certify that no violations of water quality standards will occur. The pH
limitation is based on State water quality standards. An acute daily maximum WET limit was calculated based on
acceptable instream mixing and the LC50 using undiluted effluent for both a freshwater invertebrate and a vertebrate
tested quarterly. A WET monitoring protocal is specified and the results may be reduced if 4 consecutive results
show no toxicity. During periods of no discharge, a DMR report of zero for flow, TSS and pH must be filed.
Monitoring frequencies were established in accordance with 40 CFR Part 122.4KJ), 122.44O") and 122.48. State
policy forms the basis for a narrative effluent limit prohibiting the discharge of floating solids or visible foam
in other than trace amounts.
Outfall: 001B | Receiving Water: Sugar River | Treatment: Neut+Floc
Amount/Components:
0.4 HGO process flow unquantified River intake and untreated filter discharges
Parameter
Acute WET
BOOS
Limitations
Monthly
Average
N/A
N/A
Report mg/l
300.000000 Ib/d
Daily
Maximum
N/A
100.000000 %
Report mg/l
300.000000 Ib/d
Other
See below
Monitoring Requirements
Frequency
4/year
2/month
Sample Type
24hr fw composite
24hr fw composite
Page: 262
-------
Facili'ty Name: Coy Paper Company, Inc. Permit Number: NH0001261
Facility Description: Lightweight paper manufacturer producing specialty tissue paper SIC Code: 2621
Flow
P (T)
P"
TSS
N/A
Report 'MGD
Report mg/l
N/A
N/A
Report
Report mg/l
285.000000 Ib/d
N/A
Report MGD
N/A
N/A
N/A
Report
Report mg/l
350.000000 Ib/d
Between 6.5 su and 8
.0 su
continuous
4/year
cont i nuous
2/month
recorder
24hr fw composite
recorder
24hr fw composite
Limitations/Monitoring Basis:
See Limitations/Monitoring Basis Discussion for Outfall 001A. These limitations are applicable for "Production
Level 2" defined as 12 tons/day on a monthly average. The permittee is required to provide prior notification to
EPA of this production level. The permittee is required to report monthly production levels 1/quarter.
Outfall: 002 | Receiving Water: Sugar River | Treatment: Neut+Floc
Amount/Components:
0.4 MGD process flow, unqualified River untreated filter discharges.
Parameter
Flow
PH
TSS
Limitations
Monthly
Average
N/A
Report GPD
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
N/A
N/A
Report su
N/A
Report mg/l
Other
Monitoring Requirements
Frequency
1/quarter
1/quarter
1/quarter
Sample Type
estimate
grab
grab
Limitations/Monitoring Basis:
Monitoring is required only when outfall is in use.
Special Conditions Basis:
Standard conditions only are set forth, per 40 CFR Part 122. 42(a)(1). '
Effective Date: 07/26/92 ' Expiration Date: 07/26/97 Abstract Date: 04/22/93
Page: 263
-------
Facility Name: Public Service of New Hamphire
Permit Number: NH0001465
Facility Description: Steam electric power generation and distribution
SIC Code: 4911
Limit
Basis:
ELGs
WQSS
I
BPJ
I
Monitoring
Only
J.
WET
Limits
WET Testing
Only
Multiple
Categories
Tiered
Limits
J.
Other
J.
Special
Conditions:
BMPS
J.
Storm
Water
Sediment
WQ
Survey
J.
Bio
Survey
J.
TRES
MDLs
J.
Monitoring
J.
Other
i
Abstract Information:
Partial; Outfalls 001(representative of 002), 003, 003A, 003B, 004(representative of 005), and 006.
Outfall: 001 | Receiving Water: Internal to Outfall 003
| Treatment: None specified
Amount/Components:
Unspecified amount of HK-1 condenser outlet non-contact cooling water.
Parameter
Flow
TROs
Limitations
Monthly
Average
N/A
Report MGD
M/A
H/A
Daily
Maximum
N/A
69.100000 MGD
N/A
0.200000 mg/l
Other
See below
Monitoring Requirements
F requency
continuous
1/week
Sample Type
calculate
grab
Limitations/Monitoring Basis:
The TRO limit applies only when the condenser outlet is in use. The TRO limit is based on ELGs (40 CFR Part 423)
for TRC and the previous permit. The permit writer defines TRO as synonomous with TRC. Calculations usinga
dissipation factor in the cooling canal of 42:1 resulted in a level of chlorine in the canal discharge of an order
of magnitude below the MOL for TRC, thus consistent with the water quality-based TRO limit set for Outfall 003. The
preferred method for analyzing TRC is specified. Flow is to be calculated based on pump curves, hours of pump
operation, and 190 feet river levels. The basis for monitoring in this permit was described as that needed to yield
data representative of the discharges under authority of Section 308(a) of the Clean Water Act. PCBs are prohibited
in the discharge. However, the basis for this prohibition was not provided.
Outfall: 003 | Receiving Water: Merrimack River
Treatment: Sed
Amount/Components:
265 HGO circulating cooling water ash settling and discharge and west yard drain.
Parameter
DO
Flow
O&G
PH
TROs
Limitations
Monthly
Average
N/A
N/A
N/A
265.300000 MGO
N/A
N/A
N/A
Report
N/A
N/A
Dai ly
Maximum
N/A
75.000000 %
N/A
275.400000 MGD
N/A
Report mg/l
N/A
Report
N/A
0.026000 mg/l
Other
min. saturation
Between 6.5 su and 8
.0 su
See below
Monitoring Requirements
Frequency
1 /month
continuous
1 /month
continuous
1 /month
Sample Type
graab
calculate
grab
record
grab
Limitations/Monitoring Basis:
The permittee is required to report the instream river pH. The limits for pH are based on State WQSs range. Flow
is to be calculated at elevation 190 ft, based on pump curves and hours of pump operation. The TRO limit applies
only when the outfall is in use. The TRO limit is water quality-based to protect aquatic life in the Merrimack
River, a Class B Waterway. The basis for the DO limit was not discussed. The O&G monitoring requirement is based
on state WQSs. If oil sheen is visible, monthly monitoring will be required.
Page: 264
-------
Facility Name: Public Service of New Hamphire Permit Number: NH0001465
Facility Description: Steam electric power generation and distribution SIC Code: 4911
Outfall: 003A | Receiving Water: Internal to Outfall 003 | Treatment: Sed
Amount/Components:
4.6 HGD Ash Settling Pond Discharge during normal operation
Parameter
Cu
-------
Facility Hame: Public Service of New Hamphire
Permit Number: NK0001465
Facility Description: Steam electric power generation and distribution
SIC Code: 491T
sheen is present, monthly monitoring is required to satisfy the State certification, the permittee is required to
report the maximum and minimum pH values for the month. '. '
Outfall: 004 | Receiving Water: Herrimack River
Treatment: None specified.
Amount/Components:
Unspecified amount from 5 sources of Wash water and fire protection overflow
Parameter
Flow
OSG
PH
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
Dai ly
Maximum
N/A
Report GPD
N/A
Report
N/A
Report
Other
Estimate total
See below
Between 6.5 su and 8
.0 su
Monitoring Requirements
Frequency
1/year
1/day
1/year
Sample Type
estimate
observe
grab
Limitations/Monitoring Basis:
Permittee must report results of daily observations and sample 1/year if oil sheen is observed. Permittee is
required to report range of results of grab samples of each of the 5 pipes that comprise this outfall.
Outfall: 006 | Receiving Water: Merrimack River
Treatment: None specified.
Amount/Components:
Unspecified amount of stormwater from the Southeast yard drain
Parameter
Flow
OSG
PH
TSS
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
Report mg/l
N/A
Report mg/l
N/A
Report su
N/A
Report mg/l
Other
Report range
Monitoring Requirements
Frequency
1/year
1/year
1/year
1/year'
Sample Type
estimate
grab
4 grabs
grab
Limitations/Monitoring Basis:
Permittee is required to report actual stormwater flow based on annual precipitation data or estimated flow from a
10 year, 24 hour rainfall event.
Special Conditions Basis:
The plant is exempt from the temperature ELG due to age. Based on past performance, EPA determined that state water
?uality temperature standards will be met. Temperature monitoring in the receiving stream is required to be
nitiated when the river temperature reaches 50 degrees F for the purpose of equipment reliability and employee
safety. The permittee must ensure that discharges from 2 pipes containing related wastewater from the intake dredge
dewatcring lagoon do not increase the naturally occurring turbidity of the Merrimack River by more than 10 NTUs.
Simultaneous multi-unit chlrorination or bromination is prohibited. The permittee must notify the State one month
prior to switching to bromination. Outfall 003B chemical cleaning operations may not occur more than 30 days each
year, and may not be performed during weekends unless provisions are made with the NHDES. The coal pile may not
allowed to discharge runoff to the ash ponds without treatment in the wastewater treatment facility. Water drawn
from fuel oil tanks is prohibited from being discharged. River intake screens mustbe cleaned and natural debris
sueh as tree branches, fish, shellfish and aquatic organisms collected in the screens must be returned to the river.
Other solid Haste collected in the screens must be landfilled. Screen design may not be changed without prior
approval of the EPA. The plant's power spray module system to cool the water must be operated to maintain a mixing
zone river temperature not to exceed 69 degrees F, or a change in temperature of not more than one degree F when the
ambient river temperature exceeds 68 degrees F. All available power spray modules must be operated when both
criteria listed above are exceeded. The permit requires continuous river surface monitoring conditions for
temperature, pH and DO. These data must be submitted 1/year. A (BMP) plan for segregation of the ash settling
ponds from nearby wetlands must be submitted to the State for approval within one year of the permit effective date.
Within 90 days of approval, construction of ash pond structures must begin and the permittee is required to notify
EPA construction of ash pond structures, etc. must be completed. A technical advisory committee composed of several
agencies was appointed to set up a study program for the thermal characteristic, anadromous fish, fish impingement
and pump entrainment relative to the discharge. The committee members are negotiating an agreement relative to the
Page: 266 '
-------
Facility Name: Public Service of New Hamphire Permit Number: NH0001465
Facility Description: Steam electric power generation and distribution SIC Code: 4911
anadromous fish at hydroelectric facilities on the Merrimack River. Their findings will be incorporated into future
modifications of this permit, andform the basis for permit requirements to conduct: impingement monitoring. The
permittee is required to report extraordinary impingement events. Furthermore, the PSNH is required to conduct
river Herring Ichthyoplankton and American Shad Ichthyoplankton pump entrainment monitoring from Jun 15-Jul 15 (the
migration period past the Hooksett Dam), Requirements for data reporting to the various agencies involved in these
studies as well as meetings to be scheduled between the facility and the agencies are set forth in the permit. The
current permit requires impingement monitoring by collecting all fish from both condenser outlets once during Jul 1-
Oct 15.
Effective Date: N/A Expiration Date: N/A Abstract Date: N/A
Page: 267
-------
Facility Homo: Process Engineering, Inc. Permit Number: MH0020788
Facility Description: Fabrication of metal products, stainless steel, Al and alloy SIC Code: 3433
Monitoring
Limit ELGs WQSs BPJ Only
Basis: ^ J. J. J.
Storm UQ
Special BHPs Hater Sediment Survey
Conditions: j. 4. - -
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
L - - - J-
Bio
Survey TRES MDLs Monitoring Other
Abstract Information:
Partial; Outfall 001, representative of Outfalls 002, 003, 004, 005, 007, 010, and 011.
Outfall: 001 | Receiving Water: Little River via wetlands | Treatment: None
Amount/Components :
100 GPD consisting of stormwater, infiltration groundwater, and X-Ray developing wastewater
Parameter
Al (T)
Cu (T)
Fe (T)
Flow
Hn (T)
O&G
pH
TSS
Zn
Limitations
Average
H/A
N/A
N/A
H/A
N/A
N/A
N/A
N/A
N/A
N/A
H/A
H/A
N/A
N/A
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
Report mg/l
H/A
Report mg/ 1
N/A
Report mg/l
H/A
Report GPD
H/A
Report mg/l
N/A
15.000000 mg/l
N/A
Report su
N/A
Report mg/l
N/A
Report mg/l
Other
Report min. and max.
Monitoring Requirements
Frequency
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
Sample Type
composite
composite
composite
estimate
composite
grab
grab
composite
composite
Limitations/Monitoring Basis:
Outfall 001 is limited for O&G based on previous permit (antibacksliding) and BPJ. A narrative standard specifies
no discharge of floating of solids or visible foam in other than trace amounts. The basis for monitoring for the
other parameters was not discussed. Grab samples must be collected during normal business hours, and although
composite samples are required for TSS and metals, the permit did not indicate the sampling period to beused.
StorntHator runoff must be monitored quarterly using a program where 2 outfalls of the 8 total outfalls are sampled
each quarter resulting in each outfall being sampled in a 12 month period. The stormwater sample can be collected
during any precipitation event which causes flow and can be sampled in the discharge pipe. Sampling procedures
described in the NPDES Storm Water Sampling Guidance Document (EPA 833-B-92-001, July, 1992) were recommended in the
permit.
Special Conditions Basis:
A BMP plan must be developed and initiated within 180 days of the effective date of the permit effective date. All
construction must be completed within 21 months of the effective date. The plan must address controls to prevent
releases of toxic and hazardous pollutants and be consistent with EPA's NPDES Best Management Practices Guidance
Document. It must contain stormwater pollution prevention plan, SPCC plans (if applicable), RCRA management contain
a stormwater pollution prevention plan, SPCC plans (if applicable), RCRA management procedures or practices. The
BMP plan must be updated and reviewed by an inplant engineer.
Effective Date: 10/11/92 Expiration Date: 10/11/97 Abstract Date: 05/24/93
Page: 268
-------
Facility Name: Bio-Energy Corporation
Permit Number: NH0021652
Facility Description: Steam Electric Power Generation from woodchips
SIC Code: 4931
.imit
Basis:
ELGs
J.
WQSs
I
BPJ
J.
Monitoring
Only
I
WET
Limits
WET Testing
Only
Multiple
Categories
Tiered
Limits
Other
I
Spec i aI
Conditions:
BMPs
I
Storm
Water
I
Sediment
WQ
Survey
Bio
Survey
TRES
MDLs
Monitoring
J.
Other
Abstract Information:
Complete: Outfalls 001A, 001B, SW-1
Outfall: 001A
Receiving Water: Contoocook River
Treatment: None specified
Amount/Components:
63,000 GPD process wastewater cooling tower and boiler blowdown(11,000 GPD) stormwater runoff.
Parameter
Flow
O&G
PH
Temp.
TSS
Monthly
Average
N/A
8800.000000 GPD
H/A
15.000000 mg/l
N/A
N/A
N/A
N/A
N/A
30.000000 mg/l
Limitations
Daily
Maximum
N/A
11000.000000 GPD
N/A
20.000000 mg/l
N/A
N/A
N/A
90.000000 F
N/A
100.000000 mg/l
Other
Multiply value by 10
Between 6.5 su and 8
.0 su
Monitoring Requirements
Frequency
continuous
2/month
2/month
2/month
2/month
Sample Type
Total Daily
grab
grab
grap
8hr composite
Limitations/Monitoring Basis:
Because ELGs have not been established for power generation using wood chips, the limitations are based on the
previous permit (anti-backsliding) and BPJ using ELGs for the Steam Electric Power Generating Point Source Category
(40 CFR Part 423). This includes TSS, O&G limits using low-volume waste category as well as the priority pollutant
monitoring requirements. No monitoring frequency was provided for priority pollutants. Compliance was established
as being determined by engineering calculations to demonstrate the regulated pollutants are not detected. State
water quality standards form the basis for the pH and temperature standards, as well as five narrative effluent
limits for Outfalls 001A and 001B. These include 1) the discharge cannot cause a violation of water quality
standards or result in demonstrable harm to aquatic life 2) the discharge cannot cause objectionable color, odor, or
turbidity, 3) chlorination may not be used for biofouling control, 4) chromium may not be used as a cooling tower
maintenance chemical, and 5) discharge of PCBs is prohibited. BPJ using Steam Electric Power Generation ELGs forms
the basis for the permit requirement that, except for zinc (which is numerically limited) and chromium (which the
facility certifies is not used in the cooling tower maintenance), none of the126 priority pollutants contained in
cooling tower maintenance chemicals shall be present in detectable amounts in the effluent (using 40 CFR Part 136
methods). However, no monitoring nor reporting conditions accompaniedthis prohibition. An additional water
quality-based prohibition also applies as follows: the effluent may not contain a visible oil sheen, foam, floating
solids.
Outfall: 001B | Receiving Water: Internal to Outfall 001A Treatment: None specified
Amount/Components :
Cooling tower blowdown
Parameter
FAC
Flow
Limitations
Monthly
Average
N/A
0.200000 mg/l
N/A
20000.000000 GPD
Daily
Maximum
N/A
0.500000 mg/l
N/A
N/A
Other
See below
Monitoring Requirements
Frequency
2/month
continuous
Sample Type
grab
total daily
Page: 269
-------
Facility Home: Bio-Energy Corporation
Permit Number: NH0021652
Facility Description: Steam Electric Power Generation from woodchips
SIC Code: 4931
Zn (TR)
N/A
1.000000 mg/t
N/A
1.000000 mg/l
2/month
8hr composite
Limitations/Monitoring Basis:
FAC is used as defined in 40 CFR Part 423.11(1). The permit specifies the EPA test method. The limitation for FAC
is BPJ-bascd using the once through cooling water category in 40 CFR Part 423. The Zn limits are also BPJ-based
using 40 CFR Part 423. Five narrative effluent limits are shown in the Limitations/Monitoring Basis Discussion for
Outfall 001A.
Outfall: SW-1 | Receiving Water: Contoocook River
Treatment: None specified
Amount/Components:
Unspecified amount stormwater
Parameter
Flow
OSG
PH
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
Report
N/A
Report
N/A
Report
Other
Report range, su
Monitoring Requirements
Frequency
2/year
2/year
2/year
Sample Type
estimate
grab
grab
Limitations/Monitoring Basis:
For the stormwater discharge (Outfall SW-1), two storm events must be sampled (according to 40 CFR Part 136 methods)
during the periods March 1- April 30 and September 1- October 30 using grab samples collected during normal business
hours. A discussion of the basis of the remaining monitoring conditions was not provided.
Special Conditions Basis:
Permit conditions specify an approved list and maximum dosage of water treatment chemicals for use in the boiler and
cooling Hater power generation processes onsite. The chemicals may not be increased, substituted or intermixed
Without prior State approval. Justification for prohibiting intermixing of different brands or combinations of
water treatment chemicals is that there are no toxicity studies showing whether synergistic or antagonistic effects
will occur in the receiving stream if chemical mixing is allowed. A BMP plan is required to minimize the potential
for violations of the terms of the permit, including water quality standards, human health and the environment. It
must establish specific objectives for control of toxic and hazardous pollutants and be consistent with the EPA
guidance entitled, "NPDES Best Management Practices Guidance Document." The BMP planis due 180 days from the permit
effective date. A stormwater pollution plan, spill prevention plan and hazardous waste management plan must be
included in the BMP plan. Additional standard conditions are set forth per 40 CFR Part 122.42 (a)(1).
Effective Date: 08/01/92
Expiration Date: 07/01/97
Abstract Date: 04/20/93
Page: 270
-------
acility Name: Hackensack Water Company
Permit Number: NJ0003310
acitity Description: Industrial water treatment plant
SIC Code: 4941
imit
asis:
ELGs
WQSs
BPJ
Monitoring
Only
4.
WET
Limits
WET Testing
Only
Multiple
Categories
Tiered
Limits
Other
I
pecial
onditions:
BMPs
Storm
Water
Sediment
WQ
Survey
Bio
Survey
TRES
MDLs
Monitoring
I
Other
I
bstract Information:
Complete; Outfall 004
utfall: 004
Receiving Water: Hackensack River
Treatment: Sludge lagoon
.mount/Components:
0.01286 MGD of decant water from sludge lagoons.
Parameter
Fe (T)
Flow
PH
TOC
TPH
TSS
Limitations
Monthly
Average
N/A
1.500000 mg/l
N/A
N/A
N/A
Report
N/A
N/A
N/A
N/A
N/A
20.000000 mg/l
Daily
Maximum
N/A
2.000000 mg/l
N/A
Report mgd
N/A
N/A
N/A
20.000000 mg/l
N/A
10.000000 mg/l
N/A
40.000000 mg/l
Other
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/month
1/month
1/month
1/month
1/month
1/month
Sample Type
Grab
Measure
Grab
Grab
grab
Grab
in accordance with the provisions of NJAC 7:14A-3.13(a)12.i and with Federal anti-
backs tiding provisions of 40 CFR 122.44(1). Limitations for TSS, pH, petroleum hydrocarbons, Fe, and TOC are
based on existing permit limitations and in accordance with the anti-backsliding provisions stated above.
A reopener clause is present based on the discharge of toxic pollutants. No discharge of floating solids or yisib e
foam in other than trace amounts is allowed. No visible sheen is allowed. Laboratory and sampling personnel shall
report if there is any visible sheen on the water sample or if any odors are detected. Sampling shall occur on a
quarterly basis when there is an active water flow due to a truck transfer of partially dewatered sludge into the
lagoons If a representative sample cannot be obtained or if there are problems obtaining the sample, the permittee
should notify the Department of Environmental Protection and Energy within 10 businessdays. For these quarterly
samples, pH is limited to 5.0 s.u. to 9.0 s.u., and petroleum hydrocarbons are limited to 20 rag/I. Conditions are
provided in the permit for residuals management. Residuals management conditions have been developed in accordance
with NJPDES Regulations, NJAC 7:14A-1, and the Sludge Quality Assurance Regulations, NJAC 7:14A-4.
contains general conditions and requirements for the infiltration-percolation lagoons.
The permit
Effective Date: 03/01/93
Expiration Date: 02/28/98
Abstract Date: 09/09/93
Page: 271
-------
Facility Name: American Biltrite, Inc.
Permit Number: NJ0031895
Facility Description: Floor tile manufacturer
SIC Code: 3996
Limit
Basis:
ELGs
WQSS
BPJ
Monitoring
Only
J.
WET
Limits
WET Testing
Only
Multiple
Categories
Tiered
Limits
Other
J
Special
Conditions:
BHPs
J.
Storm
Water
Sediment
WQ
Survey
Bio
Survey
TRES
MDLs
Monitoring
Other
J.
Abstract Information:
Complete; Outfalls 001 and 002
Outfall: 001 | Receiving Water: Storm sewer to Assumpink Creek
Treatment: None
Amount/Components:
0.086 HGO stormwater runoff
Parameter
COO
Flow
pH
TPH
TSS
Limitations
Monthly
Average
N/A
N/A
N/A
Report mgd
N/A
N/A
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
100.000000 mg/l
N/A
N/A
N/A
Report
N/A
15.000000 mg/l
N/A
50.000000 mg/l
Other
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/month
1/month
1/month
1/month
1/month
Sample Type
Grab
Calculate
Grab
Multiple grab
Grab
Limitations/Monitoring Basis:
M?J!aJJ°?S for Petrojeum hydrocarbons are imposed in accordance with the Oil and Grease Effluent Limitations NJAC
cinil^Ai Sith^* *• /'nT'T^0^' C°D' a2dJTSS are based on EPA Re9ionat Guidance for storm water discharges
consistent With Section 402 of the CWA as amended. Regional guidance is based on a memorandum from EPA Chief of
Toxic and Inorganic Wastes Section, Water Facilities Branch. These limits are less astringent thanthose in the last
permft as these represent storm water discharges and the previous permit represented cooling water discharge oH
limitations are based on existing permit limitations and are consistent with the anti-backsliding provisions'of NJAC
jjui u a) • ' H° dls,charge of floating solids or visible foam is allowed in other than trace amounts and no
visfble sheen is permitted. Samples must be collected during the first discharge event of the month occurring
during working hours. Samples for petroleum hydrocarbons must be collected during the first precipitation event of
the month which causes a discharge during working hours and is preceded by aminimum dry period of 72 hours Samples
for petroleum hydrocarbons must be taken 15, 30, and 45 minutes after the onset of the discharge. pH must not be
lower than the measured pH of the rainfall.
Hitfall: 002 | Receiving Water: Storm sewer to Assumpink Creek
Treatment: None
mount/Components:
0.318 HGO stormwater, untreated contact and noncontact cooling water, and water from a pneumatic condensate tank.
Parameter
COO
:low
pH
PH
Limitations
Monthly
Average
N/A
N/A
N/A
Report mgd
N/A
N/A
N/A
N/A
Dai ly
Maximum
N/A
100.000000 mg/l
N/A
N/A
Report
N/A
N/A
15.000000 mg/l
Other
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/month
1/month
1/month
1/month
Sample Type
Grab
Calculate
Grab
grab
Page: 272
-------
Facility Name: American BiUnite, Inc.
Permit Number: NJ0031895
Facility Description: Floor tile manufacturer
SIC Code: 3996
TSS
N/A
N/A
N/A
50.000000 mg/l
1 /month
Grab
Limitations/Monitoring Basis: ,--...• „,„„
Limitations for petroleum hydrocarbons are imposed in accordance with the Oil and Grease Effluent Limitations, NJAC
7:14A-14.1 et seq. Limitations for pH, COD, temp., and TSS are based on EPA Regional Guidance for storm water and
cooling water discharges consistent with Section 402 of the CWA as amended. Regional guidance is based on a
memorandum from EPA Chief of Toxic and Inorganic Wastes Section, Water Facilities Branch. Temperature and pH
limitations are based on existing permit limitations and are consistent with the anti-backsliding provisions of NJAC
7-14A-3.13(a)12.i and 40 CFR Part 122.44. No discharge of floating solids or visible foam is allowed in other than
trace amounts and no visible sheen is permitted. pH must not be lower than the measured pH of the rainfall.
Special Conditions Basis: . .
A toxic pollutant discharge reopener clause is present in the permit. If the permittee begins using biocides or
other cooling water additives, the permittee must notify the Department of Environmental Protection and Energy
(Department) at least 180 days prior to use so that the permit may be reopened to incorporate any additional
limitations deemed necessary. No discharge of pollutants from Outfall 003 is allowed. Beginning one year after the
permit effective date, the permittee is required to provide an effluent characterisation consisting of twelve
quarterly samples taken at two internal points just after the contact cooling process before mixing with other waste
water. The effluent must be sampled for priority pollutants, base neutrals, volatiles, and chlorine produced
oxidants. If the first four consecutive samples for an individual parameter are nondetects, sampling for that
parameter may be discontinued for the rest of the 3 year effluent characterization period. The effluent
characterization is consisten with procedures presented in EPA's Technical Support Document for Determining Water
Quality Based Effluent Limitations. The permittee must submit an Effluent Characterization Study Report which
summarizes the data collected for each parameter detected. This report will be used to determine if water quality
based effluent limitations or technology based limits are necessary to protect the designated use of the receiving
water body. A BMP Plan must be developed within 6 months of the permit's effective date and submitted to the
Department within 1 year of the effective date of the permit. Limestone dust must be prevented from entering the
discharge to Outfalls 001 and 002 through good housekeeping practices. A specific plan for the storage, disposal,
and transfer of limestone dust must be developed.
Effective
Date:
01/01/93
Expiration
Date:
12/31/97
Abstract
Date:
09/13/93
I
Page: 273
-------
Facility Home: Atlantic Metal Products, Inc.
Permit Number: NJ0070696
Facility Description: Sheet metal manufacturer
SIC Code: 3444
Limit
Basis:
ELGs
WQSs
BPJ
Monitoring
Only
WET •
Limits
WET Testing
Only
Multiple
Categories
Tiered
Limits
Other
J.
Special
Conditions:
BMPs
Storm
Water
Sediment
WQ
Survey
Bio
Survey
TRES
MDLs
Monitoring
I
Other
I
Abstract Information:
Complete; Outfall 001.
Outfall: 001 | Receiving Water: Elizabeth River
Treatment: None.
Amount/Components:
7500 gpd of untreated non-contact cooling water.
Parameter
COO
Flow
PH
TPH
TSS
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
10.000000
N/A
N/A
Daily
Maximum
N/A
50.000000 ing/1
N/A
Report
gpd
N/A
Report
N/A
86.000000
N/A
15.000000 mg/l
N/A
20.000000 mg/l
Other
Between 6.0 su and 9
.0 su
Units: degrees Faren
heit
Monitoring Requirements
Frequency
. 1/month
1/month
1/month
1/month
1/month
1/month
Sample Type
Grab
Meter
Grab
Grab
grab
Grab
imitations/Monitoring Basis:
Monitoring for flow is required pursuant to NJAC 7:14A-3.13(a)9.i.(2) and the NJPDES regulations fee calculation
retirements. Limitations for pH, temperature, and COD are based on EPA Region 2's "Permit Development Guidance
Cooling Water-Surface Water Runoff," December 8, 1978. Limitations for petroleum hydrocarbons are based on NJAC
7:HA-1«.1, the NJ oil and grease regulations. No limitations basis is provided for TSS. '
pccial Conditions Basis:
A toxic pollutant discharge reopener clause is included. Beginning one year after the permit effective date, the
permittee is required to collect a grab sample for chlorine produced oxidants once per quarter. If the initial four
quarterly samples for chlorine produced oxidants result in levels below detection, sampling may be discontinued
The permittee is required to notify the permitting authority at least 180 days before using biocides or other
cooling water additives so that the permit may be reopened to incorporate any limitations deemed necessary.
ffective Date: 01/01/93
Expiration Date: 12/31/97
Abstract Date: 09/10/93
Page: 274
-------
Facility Name: The Glidden Company Permit Number: OH0000621
Facility Description: Manufactures resins and coatings for use in linings, paint, etc. SIC Code: 2851
Monitoring WET WET Testing Multiple Tiered
Limit ELGs WQSs BPJ Only Limits Only Categories Limits Other
Basis: -11 1 - J. z £ J.
Storm WQ Bio
Special BMPs Water Sediment Survey Survey TRES MDLs Monitoring Other
Conditions: - L z. ~ - - - • - J
Abstract Information:
Complete; Outfalls 001, 601, and 602.
Outfall: 001 | Receiving Water: Huron River | Treatment: Not specified
Amount/Components :
0.12 mgd process wastewater sanitary wastewater, boiler and cooling tower blowdown and softener regeneration.
Parameter
BODS
Chronic WET
Cu
Filterable Residu
e (T)
Flow
Hexach I orobenzene
N02
Nonf ilterable res
idue (T)
O&G
P (T)
Pb (T)
pH
Temp.
TTOs
Zn (T)
Limitations : Monitoring Requirements
Monthly
Average
N/A
20.000000 mg/l
N/A
Report
N/A
N/A
N/A
N/A
N/A
Report mgd
N/A
Report ug/l
N/A
Report mg/l
N/A
30.000000 mg/l
N/A
N/A
N/A
Report mg/l
N/A
Report ug/l
N/A
N/A
N/A
Report
N/A
N/A ug/l
N/A
N/A
Daily
Maximum
N/A
30.000000 mg/l
N/A
Report
N/A
44.000000 ug/l
N/A
Report
N/A
Report mgd
N/A
Report ug/l
N/A
Report mg/l
N/A
45.000000 mg/l
N/A
10.000000 mg/l
N/A
Report mg/l
N/A
Report ug/l
N/A
Report
N/A
Report
N/A
2130.000000 ug/l
N/A
270.000000 ug/l
Other
See below
Between 6.5 SU and 9
.0 SU
Units: degrees C
See below
.
Frequency
1/week
6/year
1 /month
1 /month
continuous
1 /month
1/month
1/week
1/week
1/month
1/month
1/week
1/week
once
1/month
Sample Type
grab or composite
24 hr composite
grab
grab
total
grab
grab
grab or composite
grab
grab
grab
grab
grab
Not given
grab
Limitations/Monitoring Basis:
Limits for BODS and TSS are based on the previous permit and/or Ohio EPA policy. Copper and zinc limitations were
based on calculated WLAs and ant i backsliding (Zn). Effluent characterization revealed marginally elevated
concentrations of N02, P(T), and hexachlorobenzene, therefore, monitoring was recommended. The State EPA
recommended monitoring for Pb to verify that it is net contributing to current use impairments. Earlier bioassays
revealed chronic toxicity in approximately one third of the samples. Chronic WET monitoring using ceriodaphnia and
pimephales and 5 dilutions is required for one year following procedures provided in the permit and State guidance
documents. The permittee is required to determine LC50 and. for EC50, LOEC and NOEC for each test species using
appropriate exposure time. Water quality standards were used to establish limitations for oil and grease and pH.
The option for TTOs monitoring and/or certification were based on the current permi't and BPJ. If the permittee
Page: 275
-------
Facility Homo: The Glidden Company Permit Mumber: OH0000621
Facility Description: Manufactures resins and coatings for use in linings, paint, etc. SIC Code: 2851
chooses certification, a toxic organic management plan is due within 90 days after completion of a wastewater
characterization monitoring program. A certification statement must be submitted 1/month attesting to no dumping of
TTOs into wastewater discharges, and the implementation of the TTO management plan. The basis for the other limits
or monitoring requirements were not provided.
Outfall: 601 | Receiving Water: Internal to Outfall 001 | Treatment: Scr, AS, Fit, Dis
Amount/Components:
Unspecified amount of sanitary wastewaters, boiler and cooling tower blowdown and softener regeneration.
Parameter
CB005
Color
cu
pH
TRC
Limitations
Monthly
Average
H/A
10.000000 mg/l
N/A
Report
N/A
Report ug/l
H/A
1000.000000
N/A
Report mgd
N/A
12.000000 mg/l
H/A
H/A
N/A
N/A
Daily
Maximum
N/A
15.000000 mg/l
N/A
Report
N/A
Report ug/l
N/A
2000.000000
N/A
Report mgd
N/A
18.000000 mg/l
N/A
Report
N/A
0.500000 mg/l
Other
See below
#/100 ml, summer onl
y
Between 6.5 SU and 9
.0 SU
Summer only
Monitoring Requirements
Frequency
1/month
1/day
1/month
1/month
1/day
1/month
1/month
1/month
Sample Type
grab or composite
observe
grab
grab
total
grab or composite
grab
grab
Limitations/Monitoring Basis: . . .
The permittee is required to observe and report color, odor and turbidity according to a severity table provided in
the permit. The limits for CB005 and TRC are based on State policy. Copper is to be monitored because it is known
to be present, but is not expected to be in concentrations of concern. The FC and pH limits are based on WGSs. The
basis for other monitoring conditions were not discussed.
Outfall: 60Z | Receiving Water: Internal to Outfall 001 | Treatment: AerL
Amount/Components:
Unspecified amount of under drainage from fields where process wastewater was sprayed.
Parameter
Ag
Cr (T)
Cr+6 (OS)
Flow
TTOs
Limitations
Monthly
Average
N/A
Report ug/l
N/A
Report ug/l
H/A
Report ug/l
N/A
Report mgd
N/A
Report ug/l
Daily
Maximum
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/ 1
N/A
Report mgd
N/A
Report ug/l
Other
Monitoring Requirements
Frequency
1/month
1/month
1/month
1/month
once
Sample Type
grab
grab
grab
24 hour total
not given
Page: 276
-------
Facility Name: The Glidden Company
Facility Description: Manufactures resins and coatings for use in linings, paint, etc.
Zn (T) N/A N/A
Report ug/l Report ug/l
Permit Number: OH0000621
SIC Code: 2851
1/month grab
Limitations/Monitoring Basis:
The limits for pH are based on WQSs. The basis for the other monitoring condition!! were not discussed.
Special Conditions Basis:
The permit contains a reopener based on the promulgation of applicable regulations
limitations or conditions or regulatory a pollutant not limited in the permit. It
stream use determinations or waste load allocations. The permittee is required to
initiating the use of cooling water treatment additives.
Effective Date: 09/09/88 Expiration Date: 09/06/93
or standards with more stringent
also contains a reopener based on
obtain written permission before
Abstract Date: 06/15/93
Page: 277
-------
Facility Name: BP Chemicals of America Inc. Permit Number: OH0002615
Facility Description: Manufactures ammonia, urea, nitric acid, ammonium nitrate, and other. • SIC Code: 2873
Monitoring
Limit ELGs WQSs BPJ Only
Basis: z J. - ^
Storm UQ
Special BHPs Water Sediment Survey
Conditions: J. J. - i.
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
- J. . - - J.
Bio
Survey TRES MDLs Monitoring Other
- - - - J.
Abstract Information:
Partial; outfalls 001 (A and B for abstracting purposes) 002 (representative of 003 and 004) and 603.
Outfall: 001A | Receiving Water: Ottawa River | Treatment: Sed, Neut, AirS, IE, AS
Amount/Components :
4.23 mgd discharge consisting of storm water from production areas, non-contact cooling water, cooling tower blowdown,
and sanitary wastewater.
Parameter
Acetonitrile
Acrylonitrile
CE005
Chronic WET
CM
DO
Flow
HH3
NQ2-H
N03-M
Honfiltcrable res
iduc (T)
05G
Organic-H
P
Urea
Limitations
Monthly
Average
N/A
M/A
0.412000 kg/d
30.000000 ug/l
110.000000 kg/d
8.000000 mg/l
N/A
N/A
N/A
N/A
N/A
5.000000 mg/l
N/A
N/A
206.000000 kg/d
15.000000 mg/l
N/A
N/A
N/A
N/A
412.000000 kg/d
30.000000 mg/l
N/A
N/A
386.000000 kg/d
N/A
N/A
N/A
N/A
N/A
N/A
Report ug/l
N/A
N/A
Daily
Maximum
N/A
Report mg/l
0.825000 kg/d
60.000000 ug/l
220.000000 kg/d
16.000000 mg/l
N/A
Report
0.550000 kg/d
0.040000 mg/l
N/A
4.000000 mg/l
N/A
Report mgd
412.000000 kg/d
30.000000 mg/l
N/A
Report mg/l
137.000000 kg/d
10.000000 mg/l
825.000000 kg/d
60.000000 mg/l
137.000000 kg/d
10.000000 mg/l
773.000000 kg/d
N/A
21.000000 kg/d
1.500000 mg/l
N/A
Report
N/A
Report ug/l
N/A
Report mg/l
Other
See below
Limit is minimum
Between 6.5 SU and 9
.0 SU
Monitoring Requirements
Frequency
1/week
1/week
1/week
1/year
1 /month
1/week,
1/day
4/week
1 /month
1/week
1/week
1/week
1/week
1/week
continuous
1 /month
1/week
Sample Type
composite
composite
composite
24hr composite
composite
grab
24 hour total
composite
composite
composite
composite
grab
composite
composite
not given
grab
composite
Limitations/Monitoring Basis:
Outfall 001A was created for abstracting purposes and represents limits for Outfall 001 that are effective from
permit issuance until the permittee has completed any necessary construction to achieve final limitations, and no
Page: 278
-------
Facility Name: BP Chemicals of America Inc. Permit Number: OH000261 5
Facility Description: Manufactures ammonia, urea, nitric acid, ammonium nitrate, and other. SIC Code: 2873
longer than 36 months from permit issuance. The permit contains a compliance schedule for achieving the final
limitations for CN(T) and acrylonitrile, as Well as installation of internal monitoring station 603. CBOD5
limitations based on existing permit. Acrylonitrile and acetonitrile limitations were imposed because they were
detected in the effluent. O&G limitations are based on existing effluent quality (EEQ). Phosphorous is required to
be limited due to an international agreement between Canada and the United States (Great Lakes Agreement).
Biomonitoring is required in response to observed water quality degradation in the vicinity of the discharges.
Chronic toxicity testing is to be conducted using 2 species and 5 dilutions, following State and EPA guidance
manuals. Specified chemical analyses are to be conducted using the same samples. The permittee is required to
determine an LC50 and/or an EC50 and a LOEC and a NOEC. Information to be inclueded in the report summarizing the
results are outlined in the permit. Nitrogenous compounds are believed to be contributors to knownstream
degradation problems. As criteria for nitrites are under review, monitoring with no limits are included. Daily
maximum limits for nitrates are based on existing effluent quality, and no monthly average is required because
measurements show existing concentrations to be lower than current permit limits. Current permit limits for total
organic N are continued because nitrogenous compounds are believed to be responsible for nonattainable stream uses.
Ammonia-N and CN limits are based on waste load allocations procedures and state policy; DO limits are based on
WGSs The basis for the limits for nonf i Iterable residue was not discussed. Urea, flow, and pH monitoring are
based on existing State EPA policy. Excursions from the pH range are permitted subject to the following: the total
time the pH values are outside the given range must not exceed 7 hours and 26 minutes in any calendar month, and no
individual excursion is allowed to exceed 60 minutes. TSS was based on effluent quality.
Outfall: 001B | Receiving Water: Ottawa River I Treatment: Sed, Neut, AirS, IE, AS
^""l^mgTdischarge consisting of storm water from production areas, non-contact cooling water, cooling tower blowdown,
and sanitary wastewater.
Parameter
Acetonitrile
Acrylonitrile
CBOD5
Chronic WET
CN (T)
DO
Flow
NH3
N02-N
N03-N
Nonf i Iterable res
idue (T)
O&G
Organic-N
P (T)
pH
Limitations
Monthly
Average
N/A
N/A
0.412000 kg/d
30.000000 ug/l
110.000000 kg/d
8.000000 mg/l
N/A ,
N/A
N/A
N/A
N/A
5.000000 mg/l
N/A
N/A
206.000000 kg/d
15.000000 mg/l
N/A
N/A
N/A
N/A
412.000000 kg/d
30.000000 mg/l
N/A
N/A
386.000000 kg/d
N/A
N/A
N/A
N/A
N/A
Dai ly
Maximum
N/A
Report ug/l
0.825000 kg/d
60.000000 ug/l
220.000000 kg/d
16.000000 mg/l
N/A
Report
0.180000 kg/d
0.013000 mg/l
N/A
4.000000 mg/l
N/A
Report mgd
412.000000 kg/d
30.000000 mg/l
N/A '
Report ug/l
137.000000 kg/d
10.000000 mg/l
825.000000 kg/d
60.000000 mg/l
137.000000 kg/d
10.000000 mg/l
773.000000 kg/d
N/A
21.000000 kg/d
1.500000 mg/l
N/A
Report
Other
See below
Limit is minimum
See below
Between 6.5 SU and 9
.0 SU
Monitoring Requirements
Frequency
1/week
1/week
1/week
1/year
1 /month
1/week
1/day
4/week
1 /month
1/week
1/week
1/week
1/week
1/week
Continuous
Sample Type
composite
composite
composite
24hr composite
composite
grab
total
composite
composite
composite
composite
grab
composite
composite
not given
Page: 279
-------
Facility Maroe: BP Chemicals of America Inc. Perml-t Number: OH0002615
Facility Description: Manufactures ammonia, urea, nitric acid, ammonium nitrate, and other. SIC Code: 2873
Tl (T)
Urea
H/A
Report ug/l
N/A
N/A
N/A
Report ug/l
N/A
Report mg/l
1/month
1/week
grab
composite
Limitations/Monitoring Basis:
Outfall 001B was created for abstracting purposes and represents limits for Outfall 001 that are effective no later
than 36 months from the effective date of the permit and lasting until the expiration date. See the basis for
Outfall 001A. The limits shown for HH3 represents winter limits. The sunnier limits are monthly averages 103 kq/d
and 7.5 mg/l, and daily maximums 206 kg/d and 15 mg/l.
Outfall: 003 | Receiving Water: Ottawa River | Treatment: None
Amount/Components:
1.56 mgd untreated stormwater discharge.
Parameter
Flow
NH3
OSG
P«
Urea
Limitations
Average
N/A
H/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
Report mgd
N/A
Report mg/l
N/A
10.000000 mg/l
N/A
Report
N/A
Report mg/l
Other
Between 6.5 SU and 9
.0 SU
Monitoring Requirements
Frequency
1/day
1/month
1/month
1/month
1/month
Sample Type
total
grab
grab
grab
grab
Limitations/Monitoring Basis:
Flow and Urea monitoring requirements are based on state policy. The O&G limit is based on WGSs, and the NH3 limit
is based on Hater quality criteria.
Outfall: 603 | Receiving Water: Internal to Outfall 001 | Treatment: None specified
Amount/Components :
Unspecified amount of process flows from the chem seps ion exchange unit.
Parameter
Flow
H03
Limitations
Average
N/A
N/A
N/A
11.300000 mg/l
Maximum
N/A
Report MGD
N/A
34.600000 mg/l
Other
Monitoring Requirements
Frequency
1/day
1/week
Limitations/Monitoring Basis:
The basis for the limits and monitoring conditions were not provided.
Sample Type
total
composite
Special Conditions Basis:
The permit requires the facility to have a BMP program in place including a storm water management plan to control
pollutants in the discharges from Outfall 002, 003, and 004. The permittee must receive written permission before
using cooling water treatment additives. The permit contains a reopener based on the development of water quality
standards, stream use determinations, and/or wasteload allocations.
Effective Date: 12/29/89 Expiration Date: 12/26/94 Abstract Date: 06/21/93
Page: 280
-------
Facility Name: Ohio Valley Electric Corp. Permit Number: OH000528Z
Facility Description: Generates electricity from coal fired plant SIC Code: 4911
Monitoring
Limit ELGs WQSs BPJ Only
Basis: J. J. - J.
Storm WQ
Special BMPs Water Sediment Survey
Conditions: L - - J.
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
I. - - - J.
Bio
Survey TRES MDLs Monitoring Other
- - 1 J. I
Abstract Information:
Partial: Outfalls 001, 002, 003 (represents 093), 005, 006, 007. Where compliance is phased, outfall designations A
and B used for abstracting purposes.
Outfall: 001A | Receiving Water: Ohio River | Treatment: Sed
Amount/Components :
2.5 HGD of bottom ash sluice.
Parameter
Cd (TR)
Cu (TR)
Flow
Hg (TR)
Nonf ilterable res
idue (T)
O&G
Pb (TR)
pH
Zn (TR)
Limitations
Monthly
Average
N/A
Report ug/l
N/A
Report ug/l
N/A
Report mgd
N/A
Report ug/l
284.000000 kg/d
30.000000 rag/ I
142.000000 kg/d
15.000000 mg/l
N/A
Report ug/l
N/A
Report SU
N/A
Report ug/l
Daily
Maximum
N/A
Report ug/l
N/A
Report ug/l
N/A
Report mgd
N/A
Report ug/l
946.000000 kg/d
100.000000 mg/l
189.000000 kg/d
20.000000 mg/l
N/A
Report ug/l
N/A
Report SU
N/A
Report ug/l
Other
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/week
1/week
1/day
1 /quarter
1/week
1 /month
1/week
1/week
1/week
Sample Type
grab
grab
24 hour total
grab
grab
grab
grab
grab
grab
Limitations/Monitoring Basis:
Outfall 001A was created for abstracting purposes. Outfall 001A limitations are effective for the first 3 years
from the effective date of the permit. Residue (total nonf i Iterable) and oil and grease limits are based on
calculated waste load allocations (WLA), and the State surface water toxic strategy. pH limits are based on State
water quality standards. Cadmium and zinc monitoring requirements are based on waiter quality standards. The
loading limitations were calculated using a flow of 2.5 MGD. Flow monitoring at all outfalls is based on State
Policy.
Outfall: 001B | Receiving Water: Ohio River ] Treatment: Sed
Amount/Components :
2.5 HGD of bottom ash sluice.
Parameter
Cd (TR)
Cu (TR)
Flow
Limitations
Month ly
Average
N/A
Report ug/l
N/A
N/A
N/A
Report mgd
Daily
Maximum
N/A
Report ug/l
0.350000 kg/d
37.000000 ug/l
N/A
Report mgd
Other
Monitoring Requirements
Frequency
1/week
1/week
Daily
Sample Type
grab
grab
24 hour total
Page: 281
-------
Facility Hame: Ohio Valley Electric Corp. Permit Number: OH0005282
Facility Description: Generates electricity from coal fired plant SIC Code: 4911
Hg (TR)
llonfi I tenable res
iduc (T)
oac
Pb (TR)
pH
Zn (TR)
N/A
Report ug/l
284.000000 kg/d
30.000000 mg/l
142.000000 kg/d
15.000000 mg/l
0.260000 kg/d
28.000000 ug/l
N/A
N/A
N/A
Report ug/l
N/A
Report ug/l
946.000000 kg/d
100.000000 mg/l
189.000000 kg/d
20.000000 mg/l
2.460000 kg/d
260.000000 ug/l
N/A
N/A
N/A
Report ug/l
Between 6.0 su and 9
.0 su
1 /quarter
1/week
1 /month
1/week
1/week
1/week
grab
grab
grab
grab
grab
grab
Limitations/Monitoring Basis:
Outfall 001B was created for abstracting purposes. Outfall 001B limitations become effective after 3 years from the
permit effective date. See the basis discussion for Outfall 001A.
Outfall: 002A | Receiving Water: Internal to Outfall 003 | Treatment: API
Amount/Components :
0.1 HCO of turbine room sump, transformer deck stormwater runoff, oil room sump.
Parameter
Cd (TR)
Cu (TR)
Flow
Kg (TR)
Honf i Itcrable res
idue (T)
OSG
Pb (TR)
PH
Zn (TR)
Limitations
Monthly
Average
N/A
Report ug/l
N/A
Report ug/l
N/A
Report mgd
N/A
Report ug/l
11.400000 kg/d
30.000000 mg/l
5.700000 kg/d
15.000000 mg/l
Report kg/d
Report ug/l
N/A
Report
N/A
Report ug/l
Daily
Maximum
N/A
Report ug/l
N/A
Report ug/ 1
N/A
Report mgd
N/A
Report ug/l
37.850000 kg/d
100.000000 mg/l
7.600000 kg/d
20.000000 mg/l
Report kg/d
Report ug/l
N/A
Report
N/A
Report ug/l
Other
Between 6.5 su and 9
.0 su
Monitoring Requirements
Frequency
1/week
1/week
1/day
1/quarter
1/2 weeks
1 /month
1/week
1/2 weeks
1/week .
Sample Type
composite
composite
24 hour total
composite
composite
composite
composite
composite
composite
Limitations/Monitoring Basis:
Outfall 002A was created for abstracting purposes. Outfall 002A limitations are effective for the first 3 years
from the permit effective date. The loading limitations were calculated using a flow of 0.1 HGD. Cadmium, copper
lead and mercury are based on calculated WLA and the State Surface Waster Toxic Strategy. Total non-filterable
residue and oil and grease are based on BPT (40 CFR Part 423.12). pH is based on State water quality standards.
Page: 282
-------
Facility Name: Ohio Valley Electric Corp. Permit Number: OH0005282
Facility Description: Generates electricity from coal fired plant SIC Code: 4911
Outfall: 002B | Receiving Water: Internal to Outfall 003 Treatment: API
Amount/Components:
0.1 MGD of turbine room sump, transformer deck stormwater runoff, oil room sump.
Parameter
Cd (TR)
Cu (TR)
Flow
Hg (TR)
Nonf ilterable res
idue (T)
O&G
Pb (TR)
pH
Zn (TR)
Limitations
Monthly
Average
N/A
Report ug/l
Report
Report ug/l
N/A
Report mgd
N/A
Report ug/l
11.400000 kg/d
30.000000 mg/l
5.700000 kg/d
15.000000 mg/l
0.011000 kg/d
28.000000 ug/l
N/A
Report
Report kg/d
Report ug/l
Daily
Maximum
N/A
Report ug/l
0.014000 kg/d
37.000000 ug/l
N/A
Report mgd
N/A
Report ug/l
37.850000 kg/d
100.000000 mg/l
7.600000 kg/d
20.000000 mg/l
0.098000 kg/d
260.000000 ug/l
N/A
Report
0.110000 kg/d
300.000000 ug/l
Other
Between 6.5 su and 9
.0 su
Monitoring Requirements
Frequency
1/week
1/week
1/day
1/quarter
1/2 weeks
1 /month
1/week
1/2 weeks
1/week
Sample Type
composite
composite
24 hour total
composite.
composite
composite
composite
grab
composite
Limitations/Monitoring Basis: ,,...-. , ..
Outfall 002B was created for abstracting purposes. Outfall 002B limitations become effective after 5 years from the
permit effective date. See the basis discussion for Outfall 002A. Cadmium, copper, lead, and mercury are based on
calculated WLA. Total non-filterable residue and oil and grease are based on BPT(40 CFR Part 423.12). pH is based
on State water quality standards.
Outfall: 003 | Receiving Water: Ohio River Treatment: None.
Amount/Components:
Unspecified amount of once through cooling water.
Parameter
Flow
PH
Temp.
TRC
Limitations
Monthly
Average
N/A
Report
N/A
Report
N/A
Report
N/A
N/A
Daily
Maximum
N/A
Report mgd
N/A
Report
N/A
Report C
N/A
0.200000 mg/l
Other
Between 6.5 su and 9
.0 su
Units: degrees Cels
ius
Monitoring Requirements
Frequency
1/day
3/week
1/day
1/day
Sample Type
24 hour, total
grab
24 hour maximum
grab'
Limitations/Monitoring Basis:
Water temperature and flow monitoring requirements are based on the State's policy for water quality evaluation. A
thermal discharge limitation is the result of a thermal water quality variance. The thermal discharge limitation
is 5990 x 10"6 BTU/hr, monitoring/day. Total residual chlorine (TRC) is a BAT linitation (40 CFR Part 423.13).
This outfall's number is designated as Outfall 003 only when chlorination of the wastewater lasts 2 hours or less.
If chlorination during any particular day exceeds 2 hours, the Outfall number changes to Outfall 093. The TRC daily
maximum limit when operating as Outfall 093 is .038 mg/l.
Page: 283
-------
Facility Name: Ohio Valley Electric Corp. Permit Number: OH0005282
Facility Description: Generates electricity from coal fired plant SIC Code: 4911
Outfall: 005A | Receiving Water: Kyger Creek | Treatment: Neut, Sed
Amount/Components:
15.5 mgd of fly ash sluice water, and misc. low volume wastewater, including coal storage area runoff.
Parameter
As (TR)
Be (TR)
Cd (TR)
Cr (TR)
Cu (TR)
Flow
Hg (TR)
NH3
Hi (TR)
OSG
Pb (TR)
PH
Tl (TR)
TSS
Zn (TR)
Limitations
Monthly
Average
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report mgd
N/A
Report ug/l
N/A
Report mg/l
N/A
Report ug/ 1
880.000000 kg/d
15.000000 mg/l
N/A
Report ug/l
N/A
Report
N/A
Report ug/l
1760.000000 kg/d
30.000000 mg/l
N/A
Report ug/l
Daily
Maximum
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report mgd
N/A
Report ug/l
N/A
Report mg/ 1
N/A
Report ug/l
1173.000000 kg/d
20.000000 mg/l
N/A
Report ug/ I
N/A
Report
N/A
Report ug/l
5867.000000 kg/d
100.000000 mg/l
N/A
Report ug/l
Other
Between 6.5 su and 9
.0 su
Monitoring Requirements
Frequency
1/week
1/week
1/week
1/week
1/week
1/day
1/quarter
1/day
1/week
1 /month
1/week
3/week
1/week
3/week
1/week
Sample Type
grab
grab
grab
grab
grab
24 hour total
grab
grab
grab
grab
grab
grab
grab
grab
grab
Limitations/Monitoring Basis:
Outfall 005A was created for abstracting purposes. Outfall 005A limitations are effective for the first 3 years
from the permit effective date. Tl, HH3, As, Cd, Cu, Pb, Zn, and Hg monitoring requirements are based on calculated
HLAs and the State Surface Water Toxic Strategy. Be monitoring is based on the existing permit. Limits are water
quality based, loading limitations were calculated using a flow of 15.5 MGD.
Outfall: 005B | Receiving Water: Kyger Creek | Treatment: Neut, Sed
Amount/Components :
15.5 mgd of fly ash sluice water, and misc. low volume wastewater, including coal storage area runoff.
Parajixster
As (TR)
Limitations
Monthly
Average
N/A
Report ug/l
Daily
Maximum
N/A
Report ug/l
Other
Monitoring Requirements
Frequency
1/week
Sample Type
grab
Page: 284
-------
Facility Name: Ohio Valley Electric Corp. Permit Number: OH0005282
Facility Description: Generates electricity from coal fired plant SIC Code: 4911
Be (TR)
Cd (TR)
Cr (TR)
Cu (TR)
Flow
Hg (TR)
NH3
Ni (TR)
O&G
Pb (TR)
PH
Tl (TR)
TSS
Zn (TR)
N/A
Report ug/l
0.410000 kg/d
7.000000 ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report mgd
N/A
Report ug/l
Report kg/d
Report mg/l
N/A
Report ug/l
880.000000 kg/d
15.000000 mg/l
1.640000 kg/d
28.000000 ug/l
N/A
Report
N/A
Report ug/l
1760.000000 kg/d
30.000000 mg/l
Report kg/d
Report ug/l
N/A
Report ug/l
0.650000 kg/d
11.000000 ug/l
N/A
Report ug/l
N/A
37.000000 ug/l
N/A
Report mgd
N/A
Report ug/l
763.000000 kg/d
13.000000 mg/l
N/A
Report ug/l
1173.000000 kg/d
20.000000 mg/l
15.500000 kg/d
264.000000 ug/l
N/A
Report
N/A
Report ug/l
5867.000000 kg/d
100.000000 mg/l
17.400000 kg/d
297.000000 ug/l
Between 6.5 su and 9
.0 su
1/week
1 /week
1/week
1/week
1/day
1/quarter
1/day
1/week
1 /month
1/week
3/week
1/week
• 3/week
1/week
grab
grab
grab
grab
24 hour total
grab
grab
grab
grab
grab
grab
grab
grab
grab
Limitations/Monitoring Basis:
Outfall 005B was created for abstracting purposes. Outfall 005B limitations become effective after 3 years from the
permit effective date. TSS and O&G are based on BPT (40 CFR Part 423.12). Nitrogen-ammonia, arsenic, cadmium,
lead, zinc, and mercury are based on calculated WLAs. Monitoring is based on the existing permit. Copper,
thallium, and pH are water quality based. Flow is based on State policy. Loading limitations were calculated using
a flow rate of 15.5 HGD.
Outfall: 006A | Receiving Water: Ohio River | Treatment: AS, Dis
Amount/Components :
.083 mgd of sanitary wastewater.
Parameter
CBOD5
Color
Cu (TR)
DO
FC
Limitations
Monthly
Average
0.790000 kg/d
25.000000 mg/l
N/A
N/A
N/A
Report ug/l
N/A
Report mg/ I
N/A
200.000000
Dai ly
Maximum
1.260000 kg/d
40.000000 mg/l
N/A
Report S
N/A
Report ug/l
N/A
Report mg/l
N/A
400.000000
Other
See below
Units: #/100 ml
Monitoring Requirements
Frequency
1/2 weeks
1/day
1/quarter
1/2 weeks
1 /Month
Sample Type
grab
Observation
grab
grab
grab
Page: 285
-------
Facility Nome: Ohio Valley Electric Corp. Permit Number: OH0005282
Facility Description: Generates electricity from coal fired plant SIC Code: 4911
Flew
NH3
Honfilterable res
idue (T)
Other
pH
TRC
Turbidity
En (TR)
N/A
Report mgd
Report kg/d
Report mg/l
0.940000 kg/d
30.000000 mg/l
N/A
N/A
N/A
Report
0.016000 kg/d
0.500000 mg/l
N/A
N/A
N/A
Report ug/l
N/A
Report mgd
Report kg/d
Report mg/l
1.410000 kg/d
45.000000 mg/l
N/A
Report S
N/A
Report
0.047000 kg/d
1.500000 mg/l
N/A
Report S
Report
Report ug/l
Odor; see below
Between 6.5 su and 9
.0 su
See below
1/day
1/2 weeks
1/2 weeks
1/day
" 1/month
1/2 weeks
1/day
1 /quarter
24 hour total
grab
grab
Observation
grab
'grab
Observation
grab
Limitations/Monitoring Basis:
Outfall 006A was created for abstracting purposes. Outfall 006A limitations are effective for 12 months from the
effective date of the period. Color, odor, and turbidity are reported in severity (s) units defined in the permit.
During the summer only, the permittee is required to monitor for E. coli 1/month using grab samples. The limit
shown above for FC applies during the sunnier (Hay 1- Oct. 31) The winter (Nov. 1 - April 30) FC limit is 1000/100
ml monthly average and 2000/100 ml daily maximum. The FC limits are based on State WQSs. The loading limitations
Here calculated using a flow of 8300 gpd. The remaining limits and monitoring conditions for Outfall 006 follow
State policy for sanitary discharges from industrial facilities. Monitoring for Zn and *Cu was based on their
detection in analysis, and the need to collect data on their presence in the discharge.
Outfall: 006B | Receiving Water: Ohio River • | Treatment: AS, Dis
Amount/Components:
.033 mgd of sanitary wastewater.
Parameter
CB005
Color
Cu (TR)
DO
FC
Flow
MI3
Nonfiltcrable res
idue (T)
pH
TRC
Limitations
Monthly
Average
0.790000 kg/d
25.000000 mg/l
N/A
N/A
N/A
Report ug/l
N/A
Report mg/l
N/A
200.000000
N/A
Report mgd
N/A
Report mg/l
0.940000 kg/d
30.000000 mg/l
N/A
Report
N/A kg/d
N/A mg/l
Dai ly
Maximum
1.260000 kg/d
40.000000 mg/l
N/A
Report S
N/A
Report ug/l
N/A
Report mg/l
N/A
400.000000
N/A
Report mgd
N/A
Report mg/l
1.410000 kg/d
45.000000 mg/l
N/A
Report
0.016000 kg/d
0.500000 mg/l
Other
See below
Units #/100 ml
Between 6.5 SU and 9
.0 SU
Monitoring Requirements
Frequency
1/2 weeks
1/day
1/quarter
1/2 weeks
1 /Month
Daily
1/2 weeks
1/2 weeks
1/month
1/2 weeks
Sample Type
grab
Observation
grab
grab
grab
24 hour total
grab
grab
grab
grab
Page: 286
-------
Facility Name: Ohio Valley Electric Corp. Permit Number: OH0005282
Facility Description: Generates electricity from coal fired plant SIC Code: 4911
Turbidity
Zn (TR)
N/A .
N/A
N/A
Report ug/l
N/A
Report S
N/A
Report ug/l
See below
1/day
1/quarter
Observation
grab
Limitations/Monitoring Basis:
Outfall 006B was created for abstracting purposes. Outfall 006B limitations are effective beginning 12 months from
the permit effective date until the expiration. Color, odor, and turbidity are reported in descriptive severity (S)
units defined in the permit. See basis for Outfall 006A.
Outfall: 007 | Receiving Water: Ohio River | Treatment: AS, Dis, DeCl
Amount/Components :
.043 mgd of sanitary wastewater.
Parameter
CBOD5
Color
Cu (TR)
DO
FC
Flow
NH3
Nonf ilterable res
idue (T) .
pH
TRC
Turbidity
Zn (TR)
Limitations
Month ly
Average
0.407000 kg/d
25.000000 mg/l
N/A
N/A
N/A
Report ug/l
N/A
Report mg/l
N/A
200.000000
N/A
Report mgd
N/A
Report mg/l
0.490000 kg/d
30.000000 mg/l
N/A
Report
N/A kg/d
N/A mg/l
N/A ' '
Report S
N/A
Report ug/l
Dai ly
Maximum
0.651000 kg/d
40.000000 mg/l
N/A
Report S
N/A
Report ug/l
N/A
Report mg/l
N/A
400.000000
N/A
Report mgd
N/A
Report mg/l
0.730000 kg/d
45.000000 mg/l
N/A
Report
0.008100 kg/d
0.500000 mg/l
N/A
Report S
N/A
Report ug/l
Other
See below
Units:, #/100 ml
Between 6.5 SU and 9
.0 SU
See below
Monitoring Requirements
Frequency
1/2 weeks
1/day
: 1/quarter
1/2 weeks
1 /Month
Dai ly
1/2 weeks
1/2 weeks
1 /month
1/2 weeks
1/day
1/quarter
Sample Type
grab
Observation
grab
grab
grab
24 hour total
grab
grab
grab
grab
Observation
grab
Limitations/Monitoring Basis:
The limit shown above for FC applies during the summer (Hay 1-Oct 31). The winter (Nov 1-Apr 30) FC limit is
1000/100 ml monthly average and 2000/100 ml daily maximum. The loading limitations! were calculated using a flow of
4300 gpd. See the limitations basis discussion for Outfall 006A.
Special Conditions Basis:
Special conditions include a compliance schedule to have treatment and controls installed. Intake monitoring
1/quarter is required at a specified station. The grab samples are to be analyzed for the total recoverable form of
As, Tl, Be, Ni, Zn, Cd, Pb, Cu, and Hg. After 36 months, samples for Cu are to be analyzed 1/week. The permit
contains a compliance schedule for submitting a permit-to-install application and constructing treatment and
controls needed to meet the final effluent limitations for Outfalls 001, 002, 005, and006. The permit contains a
reopener based on the promulgation of applicable standards or regulations containing more stringent limits or
controlling pollutants not limited in the permit. The permittee is required to obtain written permission before
using cooling or boiler water treatment additives that are discharged. Discharge of PCBs is prohibited. The permit
lists 4 storm water runoff outfalls. Other storm water discharges must be described in a 2 F application to the
State EPA. The permit maybe reopened based on state and Federal storm water program requirements. Procedures are
provided for the treatment of chemical metal cleaning wastewater, including sampling and reporting.
Page: 287
-------
Facility Haroo: Ohio Valley Electric Corp.
Permit Number: OH0005282
Facility Description: Generates electricity from coal fired plant
SIC Code: 4911
Effective Date: 11/01/92
Expiration Date: 04/01/97
Abstract Date: 06/18/93
Page: 288
-------
Facility Name: Armco Steel Company, L.P. Permit Number: OH0009997
Facility Description: Produces flat rolled steel and intermediate products of pig iron,, SIC Code: 3370
, . . Monitoring WET WET Testing Multiple
Lllnlt ELGs WQSs BPJ Only Limits Only Categories
Basis= - J. J. 1 J. I I
Storm WQ Bio
Special BMPs Water Sediment Survey Survey TRES HDLs
Conditions: J. J. ~ J. J. - J
Tiered
Limits Other
Monitoring Other
I
Abstract Information:
Partial; Outfalls 001, 002, 003 and 004 (A,B,C for abstracting), 005, 011, 015, 613, 614, 631, 641 642- outfall 002C
represents 1015.
Outfall: 001 Receiving Water: Great Miami River | Treatment: Not specified
Amount/Components :
2.13 MGD non contact cooling water process wastewater and storm water runoff.
Parameter
Flow
Nonf ilterable res
idue (T)
O&G
Pb (T)
Zn (T)
Limitations
Average
N/A
N/A
1364.000000 kg/d
N/A
136.000000 kg/d
N/A
4.800000 kg/d
N/A
7.340000 kg/d
N/A
Daily
Maximum
N/A
Report mgd
3409.000000 kg/d
N/A
409.000000 kg/d
N/A
14.560000 kg/d
N/A
20.550000 kg/d
N/A
Other
Monitoring Requirements
Frequency Sample Type
1/day calculated
1/week Calculated
1/week calculated
1/week calculated
1/week calculated
Limitations/Monitoring Basis:
Outfall 001 represents the sum of the discharges from Outfalls 613 and 614. Monitoring for flow is based on State
EPA policy. Total non-filterable residue and lead limitations are based on BPJ. Oil and grease limits are based on
water quality standards. Zinc limits are is based on calculated WLAs. "Calculatec!" sample type refers to the sum
of the quantities measured at Outfalls 613 and 614. The fact sheet and the permit have discrepancies.
Outfall: 002A Receiving Water: Dicks Creek | Treatment: Not specified
Amount/Components :
Unspecified amount of non contact cooling water from by products of Coke Plant, non contact river water and well water
and storm runoff. '
Parameter
Acute WET
Ag (T)
As (T)
Cd (T)
Chronic WET
CN (free)
Fl
Limitations
Monthly
Average
N/A
Report
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report
N/A
N/A
N/A
Report mg/l
Maximum
N/A
N/A
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
N/A
N/A
0.046000 mg/l
N/A
Report mg/l
Other
See below
See below
Fluoride
Monitoring Requirements
Frequency
1 /month
1/week
1/week
1/week
1 /quarter
2/week
1 /month
Sample Type
composite
24 hr. composite
24 hr. composite
24 hr. composite
compos i te
grab
24 hr. composite
Page: 289
-------
Facility Name: Armco Steel Company, L.P. Permit Number: OH0009997
Facility Description: Produces flat rolled steel and intermediate products of pig iron. , . SIC Code: 3370
Flow
NH3
HonfHterable res
iduc (T)
OSG
PH
N/A
N/A
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
N/A
N/A
Report mgd
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report SU
Between 6.5 SU and 9
.0 SU
1/Day
2/week
2/week
2/week
1/week
24 hr. total
24 hr. composite
24 hr composite
grab
grab
Outfall 002CA) was created for abstracting purposes. The requirements for 002CA) apply for 36 months, beginning
from the effective date of the permit. Limits for non-filterable residue are based on BPJ. Oil and grease and pH
arc based on water quality standards. Nitrogen (ammonia), cyanide, arsenic, cadmium, silver are based on calculated
UlAs (WQBELs) Fluoride is based on BPJ. Flow is based on standard State EPA policy. WET (chronic and acute)
monitoring requirements and limitations are water quality based effluent limitations. , Chronic toxicity and acute
toxicity monitoring requirements in the permit stipulate that two species must be used (Cenodaphma and Pimephales
promotes).
Outfall: 002B [ Receiving Water: Dicks Creek Treatment: Not specified
AWOUnUns^f1ledSamount of non contact cooling water from by-products of Coke Plant, non-contact river water and well water,
storm runoff.
Parameter
Acute WET '
Ag (T)
As
Cd (T)
Chronic WET
CN (free)
Fl
Flow
mi3
Monfilterable res
idue
O&G
p«
Limitations
Monthly
Average
N/A
Report
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report
N/A
N/A
N/A
Report mg/l
N/A
N/A
N/A
N/A
N/A
Report mg/l
N/A
N/A
N/A
N/A
Maximum
N/A
N/A
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/ I
N/A
N/A
N/A
0.046000 mg/l
N/A
Report mg/l
N/A
Report mgd
N/A
11.800000 mg/l
N/A
Report mg/ 1
N/A
10.000000 mg/l
N/A
Report SU
'Other
See below
See below
Summer
Between 6.5 SU and 9
.0 SU
Monitoring Requirements
Frequency
1 /month ,
1/week
1/week
1/week
1/quarter
2/week
1 /month
1/day
2/week
2/week
2/week
1/week
Sample Type
composite
24 hr. composite
24 hr. composite
24 hr. composite
composite
. grab
24 hr. composite
24 hr. total
24 hr. composite
24 hr composite
grab
grab
Outfalls OOH(C) was created for abstracting purposes. The requirements for Outfall 002(C) become effective on the
53rd month and last until the expiration of the permit. Limits for non-filterable residue are based on BPJ. Oil and
grease and pH are based on water quality standards. Nitrogen (ammonia), cyanide, arsenic, cadmium, silver are based
Page: 290,
-------
Facility Name: Armco Steel Company, L.P. Permit Number: OH0009997
Facility Description: Produces flat rolled steel and intermediate products of pig iron,, SIC Code: 3370
on calculated WLAs (WQBELs). Fluoride is based on BPJ. Flow is based on standard State EPA policy concerning
evaluations. WET (chronic and acute) monitoring requirements and limitations are water quality based effluent
limitations.
Outfall: 002C | Receiving Water: Dicks Creek | Treatment: None
Amount/Components:
Non-contact cooling water from by-products of Coke Plant, non- contact river water and well water, storm runoff.
Parameter
Acute WET
Ag (T)
As (T)
Cd (T)
Chronic WET
CN (free)
Fl
Flow
NH3
Nonfi I tenable res
idue (T)
O&G
pH
Limitations
Monthly
Average
N/A
N/A
Report kg/d
Report ug/l
Report kg/d
Report ug/l
Report kg/d
Report ug/l
N/A
N/A
N/A
N/A
Report kg/d
Report mg/l
N/A
N/A
N/A
N/A
Report kg/d
Report mg/l
N/A
N/A
N/A
N/A
Dai ly
Maximum
N/A
1.000000 TUa
Report kg/d
Report ug/l
Report kg/d
Report ug/l
Report kg/d
Report ug/l
N/A
1.000000 TUc
N/A
0.046000 mg/l
Report kg/d
Report mg/l
N/A
Report mgd
N/A
11.800000 mg/l
Report kg/d
Report mg/l
N/A
10.000000 mg/l
N/A
Report SU
Other
2 species
2 species
Summer
range 6.5 to 9.0
Monitoring Requirements
Frequency
1 /month
1/week
1/week
1/week
1/quarter
2/week
1 /month
Dai ly
2/week
2/week
2/week
1/week
Sample Type
composite
24 hr. composite
24 hr. composite
24 hr. composite
composite
grab
24 hr. composite
24 hr. total
24 hr. composite
24 hr composite
grab
grab
Limitations/Monitoring Basis:
Outfalls 002(A), 002(B), and 002(C) are the same outfalls. The requirements for 002(A) apply for 36
months, beginning from the effective date of the permit. Requirements for 002(B) become effective 36 monthsfrom the
effective date and last until the 53rd month. The requirements for Outfall 002(0 become effective on the 53rd
month and last until the expiration of the permit. The "A,B,C" designations have been given inthis abstract solely
to illustrate the varying permit limits over the life of the permit (i.e., in reality only one outfall
exists). Limits for non-filterable residue are based on BPJ. Oil and grease and pH are based on water quality
standards. Nitrogen (ammonia), cyanide, arsenic, cadmium, silver are based on calculated WLAs (WQBELs).
Fluorideis based on BPJ. Flow is based on standard State EPA policy concerning evaluations. WET (chronic and
acute) monitoring requirements and limitations are water quality based effluent limitations.
Outfall: 003A | Receiving Water: Dick's Creek | Treatment: Not specified
Amount/Components :
0.47 HGD Basic Oxygen Furnace (BOF)clarif ication system, cooling tower blowdown, storm runoff.
Parameter
Ag (T)
Limitations
Average
N/A
Report ug/l
Maximum
N/A
Report ug/l
Other
Monitoring Requirements
Frequency
1/week
Sample Type
24 hr composite
Page: 291
-------
Facility Memo: Artnco Steel Company, L.P. Permit Number: OH0009997
Facility Description: Produces flat rolled steel and intermediate products of pig iron. SIC Code: 3370
As (T)
Cd
Chronic WET
CM (free)
Cu (T)
Fe
Fl
Flow
Hn (T)
HH3
Honfilterablc res
idue (T)
OSG
PAHs
Pb (T)
p*
Phenols
2n (T)
N/A
Report ug/l
N/A
Report ug/l
N/A
Report TUc
N/A
N/A
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
N/A
N/A
Report ug/l
N/A
Report ug/l
N/A
Report mg/l
N/A
Report ug/l
N/A
N/A
N/A
Report ug/ I
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Report ug/l
N/A
Report ug/l
N/A
N/A
N/A
N/A
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ragd
N/A
Report ug/l
N/A
Report ug/l
N/A
Report mg/l
N/A
Report ug/l
N/A
Report ug/ 1
N/A
Report ug/l
N/A
Report SU
N/A
Report ug/l
N/A
Report ug/ I
See below
Between 6.5 SU and 9
.0 SU
1/week
1/week
1 /quarter
1/week
1 /month
1 /month
1/day
1 /month
2/week
2/week
2/week
1/quarter
1/week
1/week
1 /month
1 /month
24 hr composite
24 hr composite
Composite
24 hr composite
24 hr composite
24 hr composite
24 hr. total
24 hr composite
24 hr composite
24 hr. composite
Grab
Grab
24 hr. composite
Grab
Grab
Grab
Limitations/Monitoring Basis:
Outfall 003A Has created for abstracting purposes. Outfall 003A's limitations monitoring requirements apply for 36
months beginning fromthe effective date of the permit. Chronic toxicity testing requires the use of two species
(Ceriodaphnia and Pimephales promelas). Iron, phenolics (4AAP), manganese, non-filterable residue, fluoride, and
PAHs requirements are based on BPJ. PAHs are to be monitored during storm flow and represent a sum of chemicals
listed in the permit. Oil and grease and pH are based on WQS. Nitrogen ammonia have summer and winter requirements
based on calculated WLAs. Winter requirements (30 day avg are 3.5 mg/l or 6.2 kg/day). Cyanide (free), arsenic,
cadmium, copper, lead, silver, zinc, chronic toxicity, are based on WLAs.
Outfall: 0038 | Receiving Water: Dick's Creek | Treatment: Not specified
Amount/Components :
0.47 MGO Basic Oxygen Furnace (BOF)clarification system, cooling tower blowdown, storm runoff.
Parameter
Aa (T)
As (T)
Limitations
Average
N/A
Report ug/l
N/A
Report ug/l
Maximum
N/A
Report ug/l
N/A
Report ug/l
Other
Monitoring Requirements
Frequency
1/week
1/week
Sample Type
24 hr composite
24 hr composite
Page: 292
-------
Facility Name: Arraco Steel Company, L.P. Permit Number: OH0009997
Facility Description: Produces flat rolled steel and intermediate products of pig iron. SIC Code: 3370
Cd (T)
CN (free)
Cu (T)
Fe (T)
Fl
Flow
Hn (T)
NH3
Nonfilterable res
idue (T)
Pb (T)
pH
Zn (T)
N/A
Report ug/l
N/A
N/A
N/A
Report ug/ I
N/A
Report ug/l
N/A
Report ug/l
N/A
N/A
N/A
Report ug/l
N/A
Report ug/l
N/A
Report mg/l
N/A
Report ug/l
N/A
N/A
N/A
N/A
N/A
Report ug/l
N/A
N/A
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report mgd
N/A
Report ug/l
N/A
Report ug/l
N/A
Report mg/l
N/A
Report ug/l
N/A
Report SU
N/A
N/A
Between 6.5 SU and 9
.0 SU
1/week
1/week
1 /month
1 /month
1/day
1 /month
2/week
2/week
1/week
1/week
24 hr composite
24 hr composite
24 hr composite
24 hr composite
24 hr. total
24 hr composite
24 hr composite
24 hr. composite
24 hr. composite
Grab
Limitations/Monitoring Basis: ....,, , , ...
Outfall 003B was created for abstracting purposes. The limists for outfall 003B apply beginning 36 months from the
effective date through the expiration date. The O&G limit is a net concentration limit, the difference between the
concentration measured ant Stations 803 and 003 should not exceed this limit. PAHs are to be monitored during storm
flow and represent a sum of chemicals listed in the permit.
Outfall: 004A | Receiving Water: North Branch of Dicks Creek | Treatment: Not specified
Amount/Components:
2.11 MGD of blowdown from South Treatment Facility process wastewaters, non-contact (annealing) wastewaters, and storm
water runoff.
Parameter
Acute WET
Ag (T)
As (T)
Cd (T)
Chronic WET
CN (free)
Cr (T)
Limitations
Average
N/A
N/A
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
N/A
N/A
Report mg/l
N/A
Report ug/l
Maximum
N/A
Report
N/A
Report ug/l
N/A
Report ug/l
N/A
Report ug/l
N/A
Report
N/A
0.046000 mg/l
N/A
Report ug/l
Other
See below
See below
Monitoring Requirements
Frequency
1/quarter
1/week
1/week
1/week
1/quarter
1/week
1/week
Sample Type
Not give
24 hr composite
24 hr. composite
24 hr. composite
Not given
24 hr. composite
24 hr. composite
Page: 293
-------
Facility Hamc: Armco Steel Company, L.P. Permit Number: OH0009997
Facility Description: Produces flat rolled steel and intermediate products of pig iron. SIC Code: 3370
CU
Flow
NH3
OSG
Pb (T)
PH
Zn (T)
N/A
Report ug/l
N/A
Report mgd
N/A
Report mg/l
N/A
Report mg/l
N/A
Report ug/l
N/A
N/A
N/A
Report ug/l
N/A
Report ug/l
N/A
Report mgd
N/A
11.800000 mg/l
N/A
Report mg/l
N/A
Report ug/l
N/A
Report SU
N/A
Report ug/l
Summer
Between 6.5 SU and 9
.0 SU
1/week
1/day
2/week
2/week
1/week
2/week
1/week
24 hr. composite
24 hr. total
24 hr. composite
grab
24 hr. composite
grab
24 hr. composite
Limitations/Monitoring Basis:
Outfall 004A was created for abstracting purposes. Outfall 004A requirements apply for 36 months beginning from the
permit effective date. Toxicity testing is required for 1 year, following specified biomonitoring guidance, using 2
species. pH and oil and grease are based on UQS. Nirogen ammoniasummer (Hay 1-Oct 31) limitations shown.' Winter
(Hov 1-Apr 30) are 9.9 mg/l (daily max. concentration). Limits for nitrogen ammonia are basedon calculated WLAs.
Chromium and lead are BPJ based, cyanide (free), arsenic, cadmium, copper, silver, zinc, and WET monitoring
requirements are based on caluculated WLAs.
Outfall: OMB | Receiving Water: North Branch of Dicks Creek | Treatment: Not specified
Amount/Components:
2.11 MOD of blowdoun from South Treatment Facility process wastewaters, non-contact (annealing) wastewaters, and storm .
water runoff.
Parameter
Acute WET
Ag
As (T)
Cd (T)
Chronic WET
CM (free)
Cr (T)
Cu
-------
Facility Name: Armco Steel Company, L.P. Permit Number: OH0009997
Facility Description: Produces flat rolled steel and intermediate products of pig iron. ' SIC Code: 3370
PH
Zn (T)
N/A
N/A
N/A
Report ug/l
N/A
Report SU
N/A
Report ug/l
Between 6.5 SU and 9
.0 SU
•••
2/week
1/week
grab
24 hr. composite'
Limitations/Monitoring Basis: ,,..,. „, , ...
Outfall 004B was created for abstracting purposes. Outfall 004B requirements apply beginning 36 months from the
permit effective date until the expiration. See the limitations/monitoring basis for Outfall 004A. Nitrogen
ammonia summer (May 1-Oct 31) limitations shown. Winter (Nov 1-Apr 30) requirements are 9.9 mg/l Cr+6 (DS)
: —
Limitations
Monthly
Average
N/A
N/A
N/A
Report ug/l
N/A
Report ug/l
N/A
N/A
0.270000 kg/d
N/A
N/A
Report ug/l
Daily
Maximum
N/A
Report TUa
N/A
Report ug/l
N/A
Report ug/l
N/A
Report TUa
0.970000 kg/d
N/A
N/A
Report ug/l
Other
See below
'
Monitoring Requirements
Frequency
1 /quarter
1/week
1/week
1/quarter
1/week
1 /month
Sample Type
composite
grab
grab
composite
grab
grab
Page: 295
-------
Facility Homo: Armco Steel Company. L.P. Permit Number. OH0009997
Facility Description: Produces flat rolled steel and intermediate products of pig iron. SIC Code: 3370
Cu (T)
Flow
llonf iltcroblc res
iduo (T)
OSG
Pb (T)
pH
Zn (T)
M/A
Report ug/l
H/A
Report mgd
N/A
Report ug/l
H/A
H/A
H/A
Report ug/l
H/A
N/A
N/A
Report ug/l
N/A
Report ug/t
N/A
Report mgd
N/A
Report ug/l
N/A
10.000000 mg/l
N/A
Report ug/l
N/A
Report SU
N/A
Report ug/l
Between 6.5 SU and 9
.0 SU
1/week
1/day
1/week
1/week
1/week
2/week
1/week
grab
24 hr. total
grab
grab
grab
grab
24 hr. composite
Limitations/Monitoring Basis:
Acute and Chronic WET testing is to be conducted using two species, following guidance specified in the permit The
basis for the limitations and monitoring conditions at this outfall was not provided.
Outfall: 015 | Receiving Water: Dick's creek | Treatment: Not specified
Amount/Components :
Unspecified amount of treated process wastewater, ground and well water, non-contact cooling water, and surface runoff.
Parameter
Acute WET
Ag (T)
Cd
Chronic WET
CH Cfree)
CP
Cu (T)
Flow
HH3
llonf ilterablc res
idue
0£G
Pb (T>
ptl
Limitations '
Monthly
Average
N/A
Report TUa
Report kg/d
Report ug/l
Report kg/d
Report ug/l
N/A
Report TUc
N/A
N/A
Report kg/d
Report mg/l
H/A
Report ug/l
H/A
N/A
N/A
N/A
Report kg/d
Report mg/l
Report kg/d
Report mg/l
N/A
Report ug/l
N/A
N/A
Daily
Maximum
N/A
N/A
Report kg/d
Report ug/l
Report kg/d
Report ug/l
N/A
N/A
N/A
0.046000 mg/l
Report kg/d
Report mg/l
N/A
Report ug/l
N/A
Report mgd
N/A
11.800000 mg/l
Report kg/d
Report mg/l
Report kg/d
Report mg/l
N/A
Report ug/l
N/A
Report SU
Other
See below
See below
summer
Between 6.5 SU and 9
.0 SU
Monitoring Requirements
Frequency
1 /month
1/week
1/week
1/quarter
2/week
1/week
1/week
1/day
2/week
1/week
1/week
1/week
1/week
Sample Type
composite
24 hr. composite
24 hr. composite
composite
grab
24 hr. composite
24 hr. composite
24 hr. total
24 hr. composite
24 hr composite
grab
24 hr. composite
grab
Page: 296
-------
Facility Name: Armco Steel Company, UP. , p*™* Nuraber: OH0009997
Facility Description: Produces flat rolled steel and intermediate products of pig iron. SIC Code: 3370
Zn (T)
N/A
Report ug/l
N/A
Report ug/l
1/week
24 hr. composite
Ll"mitfcLTeSandnchron"c Sit' Vesting is to be conducted using two species, following guidance specified in the permit The
basis for the limitations and monitoring conditions at this outfall was not provided. Beginning 36 months after the
permit effective date, a daily maximum limitation for O&G applies, 10 mg/l. At that time, a daily maximum
limitation for free cyanide also applies, 0.046 mg/l.
Outfall: 613 | Receiving Water: Internal to Outfall 001 Treatment: ChPt, Floe, Sed
Amount/Components:
1.04 HGD process wastewater from inonmaking and sintering.
Parameter
CN (T)
Flow
NH3
Nonfilterable res
idue (T)
O&G
Pb (T)
PH
Phenols
Zn (T)
Limitations
Monthly
Average
6.900000 mg/l
N/A
N/A
N/A
205.000000 kg/d
N/A
N/A
Report mg/l
N/A
Report mg/l
N/A
Report ug/l
N/A
N/A
0.900000 ug/l
N/A
N/A
Report ug/l
Daily
Maximum
13.700000 mg/l
N/A
N/A
Report mgd
410.000000 kg/d
N/A mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report ug/l
N/A
Report SU
1.800000 ug/l
N/A
N/A
Report ug/l
Other
Between 6.5 SU and 9
.0 SU
Monitoring Requirements
Frequency
1/week
1/day
1/week
1/week
1/week
1/week
1/week
1/week
1/week
Sample Type
24 hr. composite
24 hr. total
24 hr. composite
24 hr composite
grab
24 hr. composite
grab
24 hr. composite
24 hr. composite
LlmltNVtrogen0amnioni a9 ancT cyanide and phenolics total requirements are based on previous permit, lead and zinc are based
on BAT. TRC, pH, O&G, and non-filterable residue are based on BPT.
Outfall: 614 | Receiving Water: Internal to Outfall 001 Treatment: Floe, PC
Amount/Components^^ form1ng/ acl-d pickling, alkaline cleaning, painting, hot coating, metal finishing etc..., non-contact
cooling from air production.
Parameter
CN (T)
Cr (T)
Cr+6
Fe (T)
Limitations
Monthly
Average
N/A
Report mg/l
N/A
Report mg/l
N/A
Report ug/ I
N/A
Report ug/l
Dai ly
Maximum
N/A
Report mg/l
N/A
Report mg/l
N/A
Report ug/l
N/A
Report ug/l
Other
Monitoring Requirements
Frequency
1/week
1/week
1/week
1/week
Sample Type
grab
24 hr. composite
24 hr. composite
24 hr. composite
Page: 297
-------
Facility Name: Artnco Steel Company, L.P. Perrait Number. OH0009997
Facility Description: Produces flat rolled steel and intermediate products of pig iron. • • SIC Code: 3370
Flow
Naphthalene
HI (T)
Nonfilterable res
idue (T>
OSG
Pb (T>
PH
Totrachloroethyle
no
TTOs
Zn CT)
M/A
N/A
N/A
M/A
N/A
Report ug/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report ug/l
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Report ug/l
N/A
Report mgd
0.256000 kg/d
N/A
N/A
Report ug/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report ug/l
N/A
Report SU
0.383000 kg/d
N/A
1.740000 kg/d
N/A
N/A
Report ug/l
Between 6.5 SU and 9
.0 SU
See below
1/day
1/year
1/week
1/week
1/week
1/week
1/week
1/year
1 /month
1/week
Limitations/Monitoring Basis:
24 hr. total
24 hr. 'Composite
24 hr. composite •
24 hr composite
grab
24 hr. composite
grab
24 hr. composite
Variable
24 hr. composite
Outfall: 631 | Receiving Water: Internal to Outfall 003 | Treatment: Floe, PC
Amount/Components:
Unspecified amount of process wastewater from steelniaking.
Parameter
Flow
Honfilterable res
idue (T)
Pb (T)
P«
Zn (T)
Limitations
Monthly
Average
N/A
N/A
341.000000 kg/d
N/A mg/l
0.910000 kg/d
N/A
N/A
N/A
1.300000 kg/d
N/A
Daily
Maximum
N/A
Report mgd
1023.000000 kg/d
N/A mg/l
2.740000 kg/d
N/A
N/A
Report SU
3.890000 kg/d
N/A
Other
range 6.5 to 9.0
Monitoring Requirements
Frequency
Daily
1/week'
1/week
1/week
1/week
Limitations/Monitoring Basis:
Non-fUterable residue and pH is based on BPT. Zinc and lead are limited by BAT.
Sample Type
24 hr. total
24 hr composite
24 hr. composite
grab
24 hr. composite
Outfall: 641 | Receiving Water: Internal to outfall 004 | Treatment: Neut, Air, Floe, PC
Amount/Components:
1.8 HGO of Hastewater from acid pickling and cold forming processes.
Parameter
Flow
Limitations
Monthly
Average
N/A
* N/A
Daily
Maximum
N/A
Report mgd
Other
Monitoring Requirements
Frequency
1/week
Sample Type
24 hr. total
Page: 298
-------
Facility Mame: Armco Steel Company, L.P. Permlt Number: OH0009997
Facility Description: Produces flat rolled steel and intermediate products of pig iron,, SIC Code: 3370
Naphthalene
Nonfi I tenable res
idue
O&G
Pb (T)
PH
Tetrachloroethyle
ne
Zn (T)
N/A
N/A
561.000000 kg/d
N/A
187.000000 kg/d
N/A mg/l
1.140000 kg/d
N/A
N/A
N/A
N/A
N/A
0.725000 kg/d
N/A
0.723000 kg/d
N/A
1240.000000 kg/d
N/A
526.000000 kg/d
N/A mg/l
2.760000 kg/d
N/A
N/A
Report SU
0.383000 kg/d
N/A
2.180000 kg/d
N/A
Between 6.5 SU and 9
.0 SU
1/year
1/week
1/week
1/week
1/week
1/year
1/week
24 hr. composite
24 hr composite
grab
24 hr. composite
grab
24 hr. composite
24 hr. composite
Non-filterable residue, 'oil and Grease, and pH are .based on BPT. Chromium (+6), tetrachloroethylene, naphthalene
limits are based on BAT, lead and zinc are based on previous permit.
Outfall: 642 | Receiving Water: Internal to Outfall 004 | Treatment: Air, Floe, PC
Amount/Components:
0.29 HGD of metal finishing process wastewater.
Parameter
Ag (T)
Cr (T)
Flow
Ni (T)
Nonfilterable res
idue (T)
O&G
PH
TTOs
Zn
-------
Facility Home: Huskogcc Linerboard Mill
Permit Number: OK0041629
Facility Description: Manufacturer of natural and mottled white liner board
SIC Code: 2631
Limit
Basis:
ELGs
J.
WQSs
I
BPJ
JL
Monitoring
Only
WET
Limits
WET Testing
Only
J.
Multiple
Categories
Tiered
Limits
Other
Special
Conditions:
BMPs
Storm
Water
Sediment
WQ
Survey
Bio
Survey
TRES
J.
MDLs
Monitoring
Other
Abstract Information:
Complete; Outfalls 001 and 002.
Outfall: 001 | Receiving Water: Arkansas River
[ Treatment: Scr+floc+PG+AS
Amount/Components:
4.7 HGD of process Mater.
Parameter
Acute WET
BOOS
Cd (T)
Flow
HH3-H
PCBs (T)
PH
TSS
Limitations
Daily
Average
N/A
H/A
3696.000000 Ib/d
Report mg/l
Report Ib/d
Report Ib/d
N/A
Report HGD
25.000000 Ib/d
Report mg/l
0.024000 Ib/d
0.960000 ug/l
M/A
M/A
4048.000000 Ib/d
Report mg/l
Daily
Maximum
N/A
N/A
6864.000000
Report
Ib/d
mg/l
Report
Report
Ib/d
Ib/d
N/A
Report
MGD
50.000000
Report
Ib/d
mg/l
0.048000
1.930000
Ib/d
ug/l
N/A
N/A
7744.000000
Report
Ib/d
mg/l
Other
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1 /month
3/week
1/2 weeks
continuous
3/week
1/2 weeks
continuous
3/week
Sample Type
24hr fw composite
24hr fw composite
24hr fw composite
record
24hr fw composite
24hr fw composite
record
24hr fw composite
Limitations/Monitoring Basis:
BOOS, TSS, and pH limits are ELG-based consistent with the NSPS for pulp and paper manufacturing (40 CFR, Part 430),
the natural linerboard subcategory (Subpart E). The limitations were based on Subpart E exclusively because: (1)
the facility was unable to estimate the production mix between natural and mottled white linerboard due to market
demand volatility; (2) mottled white linerboard is not specifically addressed by ELGs but it is the permit writer's
best judgement that NSPS for pulp and paper manufacturing (40 CFR, Part 430) deink subcategory (Subpart Q) and
natural linerboard subcategory (Subpart E) are most applicable; and (3) the more stringent of these limits are those
calculated solely based on Subpart E. The pH limits are expected to maintain water quality standards. PCB limits
are BPJ-boscd by applying the same technology-based limits as imposed at a nearby pulp and paper mill; limits were
dccntcd necessary due to the potential presence of PCB-containing inks. Cr (T) monitoring is required base on
excecdances of WQ screening criteria; data will be gathered to determine WQ compliance and to evaluate the need for
limits. NH3-N and BODS limits are set forth consistent with stream waste load allocation modelling and consistent
with the proposed State WQ management plan pursuant to 40 CFR 122.44(d)(6). Acute WET monitoring is required
because pollutants present in the effluent may cause toxicity in the receiving waters and WET is the most direct
measure of potential toxicity. These conditions are set forth to prevent violations of CWA Section 102(a)(3) and to
achieve State standards pursuant to 40 CFR 122.44(d)(1) and CWA Section 303. Acute WET testing is required in
accordance with State policy. Acute WET testing must be conducted on specified dilutions in accordance with EPA
guidance manual procedures; where toxicity is evident in 100% effluent, retesting must be conducted within 15 days.
Rotcsting may be suspended after 3 consecutive 15 day tests. Forms are supplied in the permit for reporting
toxicity test results. Monitoring requirements for all pollutants are based on the permit writer's judgement.
Page: 300
-------
Facility Name: Huskogee Linerboard Hill Permit Number: OK0041 629
Facility Description: Manufacturer -of natural and mottled white liner board SIC Code: 2631
Outfall: 002 | Receiving Water: Unnamed trib. to Arkansas R. Treatment: Not described.
Amount/Components :
0.76 HGD daily average of storm water runoff
Parameter
BODS
Flow
O&G
PH
TOC
TSS
Limitations
Daily
Average
Report Ib/d
Report mg/l
N/A
Report MGD
N/A
Report mg/ I
N/A
N/A
Report Ib/d
Report mg/l
Report Ib/d
Report mg/l
Daily
Maximum
Report Ib/d
Report mg/l
N/A
Report MGD
N/A
15.000000 mg/l
N/A
N/A
Report Ib/d
50.000000 mg/l
Report Ib/d
Report mg/l
Other
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/day
1/day
1/day
1/day
1/day
1/day
Sample Type
grab
estimate
grab
in-situ
grab
grab
Limitations/Monitoring Basis:
TOC, O&G, and pH limitations are established "consistent with similar industrial storm water effluent limitations
within the Region and are judged to represent BCT/BAT treatment". The pH limits are expected to maintain water
quality standards. Monitoring requirements for BOD and TSS are established consistent with the State permit.
Monitoring requirements for all pollutants are based on the permit writer's judgement.
Special Conditions Basis:
Where two consecutive Acute WET tests show toxicity, a proposal for the conduct of a TRE must be submitted within 30
days. The proposal must specify the date on which the TRE will be initiated and the approach and methodologies to
be used. The permit contains reopener clauses based on wasteload allocation and monitoring results for cadmium.
Effective Date: 08/11/92 Expiration Date: 08/10/97 Abstract Date: 05/18/93
Page: 301
-------
Faci Uty Hants: Refolds Hetals Co., Troutdale Permit Number: OR0000060
Facility Description: Aluminum primary reduction plant SIC Code: 3334
Monitoring
Limit ELGs HQSs BPJ Only
Basis: I - i J-
Storm WQ
Special BMPs Water Sediment Survey
Conditions: j. - - -
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
L
-------
Facility Name: Reynolds Metals Co., Troutdale Permit Number: OR0000060
Facility Description: Aluminum primary reduction plant SIC Code: 3334
Outfall: 002 | Receiving Water: Internal to Outfall 001 | Treatment: BioF, Dis
Amount/Components :
0.035 HGD of sewage treatment plant effluent.
Parameter
BODS
FC
Flow
pH
TRC
TSS
Limitations
Monthly
Average
25.000000 Ib/d
30.000000 mg/l
N/A
200.000000
N/A
Report MGD
N/A
N/A
N/A
Report mg/l
25.000000 Ib/d
30.000000 mg/l
Daily
Maximum
50.000000 Ib/d
45.000000 mg/l
N/A
N/A
N/A
Report MGD
N/A
N/A
N/A
Report mg/l
50.000000 Ib/d
45.000000 mg/l
Other
Units: #/100ml
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
2/month
1/week
1/day
1/day
1/day
2/month
Sample Type
grab
grab
• meter
. grab
grab
grab
Limitations/Monitoring Basis:
The limits for outfall 002 were carried over form the previous permit. The original bases of these limits were not
provided. The monitoring frequencies for BOD and TSS were increased to ensure that monthly avg. could be
differentiated from daily max. The basis of the remaining monitoring conditions was not described.
Special Conditions Basis:
The permit contains several special conditions. The permit specifies that a spill plan be in force at all times.
The permit also requires that an appropriately qualified and informed individual be designated to handle wastewater
treatment. Where WET testing confirms toxicity, the permit requires development of a plan to eliminate toxicity
submission of the plan to the State for approval, and implementation, of the plan upon approval. The performance of
a mixing zone study is also set forth. Within fifteen <15) months of permit issuance, a report containing the
findings of the WET testing and the mixing zone study must be submitted to the State. Special monitoring
requirements described at Outfall 001 may also be considered special conditions. The basis of these conditions were
not described.
Effective Date: 04/19/91 Expiration Date: 03/31/96 Abstract Date: 04/15/93 |
Page: 303
-------
Facility Homo: THlamook County Creamery Assn Permit Number: OR0000141
Facility Description: Dairy products production, visitor center, delicatessen SIC Code: 2026
Monitoring
Limit ELGs WQSs BPJ Only
Basis: III I
Storm WQ
Special BHPs Water Sediment Survey
londitions: J_ - - -
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
- 1 - - -
Bio
Survey TRES MDLs Monitoring Other
-1 - I -'
Abstract Information:
Complete: Outfalls 001, 001a, and 002
Outfall: 001 | Receiving Water: Wilson River I Treatment: PC, AS, Dis
Amount/Components: ,
0.25 HGO of treated process and sanitary wastewater, blowdown from whey towers, and steam condensate.
Parameter
BOOS
Chronic WET
FC
Flow
pH
TRC
TSS
Limitations
Monthly
Average
88.000000 Ib/d
H/A
N/A
N/A
H/A
N/A
N/A
N/A
N/A
N/A
N/A
0.170000 mg/l
131.000000 Ib/d
N/A
Dai ly
Maximum
219.000000 Ib/d
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
0.300000 mg/l
341.000000 Ib/d
N/A
Other
See below
See below
See below
Between 6.0 su and 9
.0 su
See below
See below
Monitoring Requirements
Frequency
2/week
Variable
2/week
1/day
1/day
3/day
2/week
Sample Type
composite
See below
grab
read
grab
grab
composite
Limitations/Monitoring Basis: . ..... ,
BOO and TSS limits are ELG based <40 CFR Part 405) using 1985 production data despite production having increased.
The pH and fecal coliform limits are WQ-based and are consistent with State numerical WQ standards. For fecal
colifortn these limits are: "Geometric mean of all samples in calendar month shall not exceed 200. Not over 10% of
all samp es for calendar month shall exceed 400." TRC limits are WQ-based using numerical criteria and State-
specific mixing zone standards and were developed using the ambient- induced mixing model from EPA's TSD. In
addition to the monitoring requirements noted above, the permit also requires monitoring for influentBOD, TSS, and
pH at the same frequencies as effluent monitoring. Monitoring is also required for the amount of Cl used on a daily
basis. Chronic WET testing is required once during 1992 and again not more than six months prior to applying for
permit renewal. Testing is to be conducted in accordance with specific EPA guidance.
Outfall: 001A | Receiving Water: Internal Outfall via 001 | Treatment: Not discussed.
Amount/Components :
0.01 HGO maximum allowable from the whey cooling tower blowdown.
Parameter
Flow
PH
Terap.
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
N/A
N/A
N/A
N/A
N/A
Other
Shall not exceed 0.0
1 MGD
Between 6.0 su and 9
.0 su
Shall not exceed 90F
Monitoring Requirements
Frequency
1/week
1/week
1/week
Sample Type
estimate
grab
grab
Limitations/Monitoring Basis: . .
Temp, limits are carried over from the previous permit and their basis is not known; however, the limits were
determined to be protective of the State's numerical WQS. The pH limits are established to protect the
Page: 304
-------
=^=^» • ^=^^=*M=» -_ [__ a| ^
Facility Name: Tillamook County Creamery Assn
Permit Number: OR0000141
Facility Description: Dairy products production, visitor center, delicatessen
of the flow limitation was
Outfall: 002 | Receiving Water: Boquist Slough
Amount/Components: '
0.025 HGD max, allowable from the refrigeration system cooling tower blowdown.
«=«==«:=
Treatment: Mot discussed.
Parameter
Flow
Temp.
Limitations
Monthly
Average
Daily
Maximum
N/A
N/A
imitations/Monitoring Basis:
Temp, limits are carried over from the previous permit
determined to be protective of the State's numerical uo
provided1 WQS' N° baS1"S °f the fl°W limi^tion was pro
Other
Shall not exceed .02
5 MGD
Between 6.0 su and 9
.0 su
Shall not exceed 90F
Monitoring Requirements
Frequency
1/week
1/week
1/week
Sample Type
estimate
grab
grab
Special Conditions Basis:
fnr «iiiHn» H- -••••.••"••ii'.'w.. mis included a specific BMP for spiI
' «»
operation and
^ ™? PeSp°nSe and ns
the chronic WET testi"9 outlined
, and implemented if the WET
9lS° be cons'"dered special
Effective Date: 06/24/92
Expiration Date: 06/30/97
Abstract Date: 04/09/93
Page: 305
-------
I Facility Homo; Weyerhaeuser Company
Permit Number: OR0000515
Facility Description: Unbleached Kraft liner-board mill
SIC Code: 2611
Limit
Basis:
.Gs
I
IPs
L
WQSs
I
Storm
Water
Special
Conditions:
B*_u_«—^——
Abstract Information:
Complete: Outfalls 001,002, and 003.
BPJ
I
Sediment
Monitoring
Only
WQ
Survey
WET
Limits
Bio
Survey
I
WET Testing
Only
J.
TRES
J.
Multiple
Categories
MDLs
Tiered
Limits
J.
Monitoring
J.
Other
Other
J.
Outfall: 001 | Receiving Water; HcKenzie River
pulp mill, non-contact process waters, and log pond effluent.
Parameter
BODS
Chronic WET
color
Flow
P (T)
Temp.
TSS
Turbidity
Limitations
Monthly
Average
3000.000000 Ib/d
N/A
N/A
N/A
M/A
N/A
M/A
N/A
N/A
N/A
N/A
M/A
N/A
N/A
10000.000000 Ib/d
M/A
N/A
M/A
Dai ly
Maximum
4500.000000 Ib/d
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
100.000000 F
20000.000000 Ib/d
N/A
N/A
N/A
Other
Seasonal; see below
Between 6.0 su and 9
.0 su
Seasonal; see below
See below
Monitor ins
Frequency
3/week
1 /quarter
3/week
continuous
1 /month
1/day
3/week
3/week
3/week
j Requirements
Sample Type
24hr composite
See below
grab
record
24hr composite
grab
grab
24hr composite
grab
Fitations/Monitoring Basis: ar_,-nfi mpr form the previous permit. Limits shown above are effective from
BOOS and TSS limits are sea s°?aipf^^ed °ver f orm the p rev lou s p ^ ^ ^ ^^ lfa/d BOD5f and
Jun. 1 to Oct. 31 (summer); winter lira ts Affective tromNOV. i i £ Although their basis was not provided,
11,960 lb/d and 28,000 lb/d TSS, monthly ^9- f"d.d H ii^it«s f40 CFR Part 430) and the State's numerical WQS. In
these limits were compared to the applicable ELG-based l«nts (40 CFR Part ™>>.™ tupb,d, I1mits are UQ
both cases the existing limits were more stringent and were retained rn js . * ^^ assimilative capacity of
based and are consistent with State numerical WQS. The temp, limit so interim until a planned
the river rather than just the mixing zone's capacity. This temp^ urnt 's Honit0ring requirements were also
diffuser is installed and the permit is modified to Deflect the new mJ^ing z.^ ^^ ^ .^^ because the
included for P (T) in order to determine discharge cog^iou^ion . ^d- t t measure raore than 10% over
discharge was expected to_mcrease amb !^ levels by 0.01 mg/ . TurDI V Rlvep , station, and 3/week
background level. There is also ?/equ'^ntu^enzie River There is also a requirement to report "pulp produced
grab sampling of temp, and turbidity from the McKenz e Rjver. mere i r ^d cardboard» and "paper produced
(Kraft) - average air-dry tons/day for reporting P^"°d fJPT testinqisrequired quarterly and must be conducted in
average air-dry tons/day for reporting Perioo. . "T°n'^ "^' - d a d 3ual end-point test must be performed.
AH^IMHMM 11* *-h CMOf*! T1 f FPA QUlGSnCcB I nrSS oUKV I CO QIC I t-^ju I • *-*- «-•• •— •
flCCOrOvHiCO HI tn oJJVl^ll l« i.rrt gv«i**«••«!••. i
Testing may be reduced after 2 years.
Page: 306
-------
"— • • =^=^==
Facility Name: Weyerhaeuser Company
Facility Description: Unbleached Kraft linerboard mill
Permit Number: OR0000515
Outfall: 002
Receiving Water: McKenzie River
SIC Code: 2611
Amount/Components:
20 HGD max. of non-contact cooling water.
Treatment: 'HT
Parameter
Flow
pH
Temp.
Limitations
Monthly
Average
15.000000 MGD
N/A
N/A
N/A
N/A
100.000000 F
Daily
Maximum
25.000000 HGD
N/A
N/A
N/A
N/A
115.000000 F
Limitations/Monitoring Basis:
Other
See below
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
continuous
3/week
3/week
Sample Type
record
grab
grab
. wer
The pH upper limit was adjusted to account for a gal b"ooms
numerical WQS. The basis of the flow limitation was not
requirements was provided limitation was not
Protectlv« ?f the State's numerical WQS.
? established to protect the State's
No discussion of the bases for the monitoring
Outfall: 003 | Receiving Water: City storm water system'
Amount/Components:
5 MGD max. of non-contact cooling water
Treatment: HT
Parameter
Flow
pH
Temp.
3.000000 MGD
N/A
N/A
N/A
N/A
N/A
5.000000 MGD
N/A
N/A
N/A
N/A
N/A
Limitations/Monitoring Basis:
Between 6.0 su and 9
.0 su
1/day
3/week
3/week
estimate
grab
grab
Special Conditions Basis:
with a facility proposal. (2) Within two years of oerm?? ?
McKenzie river mustbe conducted to asse^^hrimpacrof OutfaU
the mixing zone of Outfall 002. If the survey ndicates that
community, or if WQS are violated the permittee mu"Iubm
the permit requirements. (3) Within six ^1^0?^^^
the discharge from Outfall 003 to the sectary channel of
- r
a"d the require^nts are consistent
UrVeV rt-^e seconda^ channel of the
-- Th'S study must also evaluate
8HS'9n'fi£an^ 'ropact °n the benthl'c
address the impacts andthe State may modify
''"^ be SUbm''tted *
.
Page: 307
-------
Facility Hame: Chevron Chemical Company
Facility Descri
IIHJH BIMILHI1.III.I . ""
Limit
Basis:
Special
Conditions:
Permit Number: OR0001635
r,^n. H™, anmonia. and ammonium nitrate fertilizer manufacturer . — __
»
BMPS
I
WQSs
I
Storm
Water
BPJ
J.
Sediment
Monitoring
Only
WQ
Survey
J.
MET
Limits
Bio
Survey
WET Testing
Only
J.
TRES
J.
Multiple
Categories
MDLs
Tiered
Limits
Monitoring
J.
Other
I
Other
J.
Abstract Information:
browM"*"! outfall 001. . •
-Jl L
all: 001
I Receiving Water:
:
Columbia River I Treatment: API
-
Parameter
Chronic VIET
Flow
NH3-H
N03-H
OSG
Organic-H
P«
SS
Terop.
blowdown, filter backwash, and storm runoff.
Limitations
Average
N/A
N/A
N/A
N/A
N/A
0.600000 mg/l
N/A
1.000000 mg/l
N/A
N/A
N/A
1.000000 mg/l
N/A
N/A
N/A
N/A
N/A
N/A
Maximum
N/A
N/A
N/A
N/A
N/A
4.000000 mg/l
N/A
4.000000 mg/l
N/A
N/A
N/A
4.000000 mg/l
N/A
N/A
N/A
N/A
N/A
N/A
Other
Shall not exceed 25
MGD
Net basis
Net basis
Shall not exceed 10
mg/l
Net basis
Between 6.0 su and 9
.0 su
See below
See below
Monitorinc
Frequency
4/year
1/day
2/week
1/week
2/week
1/day
1/week
1/day
Requi rements
Sample Type
See below
meas.
24hr composite
grab
24hr composite
record
grab
meas.
Limitations/Monitoring Basis: ,18V however since no process wastestreams are discharged, all
SS.WJSS iwswsss HHriJsrsi.strv'Siihri.sr's^iStrr8
K!tK.ts?X;H?^^^
erras JS ^gssxzg?$ HH^^^kcsssrr
5»r!?["e™.Ls:'!,!L;h' s.iT.iii'hSrss'SJS sn«s trs,;".;.'.™!^..*.™.. ^ i. t.»««i »>
sis
sss?ssisia
testing may be discontinued.
Special Conditions Basis: incoroorated in both the compliance schedule section
The permit includes a number of special col?^ions which are ^ncorporatea^ H ^ Qf wastewater
and the special conditions section. Department policy requires that ntier oa treating filter
streams prior to discharge; thus a compliance schedu ^ t°^°l?^du^ev?ous y e| p(an to eliminate toxicity must be
backwash water. In addition to the chronic WET ^sting outlined previously, P toxicity. The State may also
' submitted for State approval, ^.'^l^"*^pl* *?eJsL ^ecified in the permit and may reopen the
• " zone study to be performed in accordance with dates speciriea in_ui<= P^ T_^_| ^.^^^ ,.hal,
- • • - 1-*-=— *•-^ of the permit
Page: 308
-------
Facility Name: Chevron Chemical Company
Facility Description: Urea, ammonia, and ammonium nitrate fertilizer manufacturer
Permit Number: OR0001635
SIC Code: 2873
'-
Effective Date: 06/08/92
Expiration Date: 06/30/97
Page: 309
-------
II..III
FacUlty Name: Bradfor
__ •
FacUlty Description:
d Dyeing Assoc., Inc. , _ •
— , . ' SIC Code: 2269
Dyes and finishes wool and woven cloth products ,.
Monitoring
Lirait ELGS WQSs BPJ Only
Basis: J. * - *
Storm WQ
Special BHPs Water Sediment Survey
Conditions: ^ - - -
WET WET Testing
Limits Only
- J-
Bio
Survey TRES
±
Multiple Tiered
Categories Limits Other
^ 1 J.
MDLs Monitoring Other
I i J.
^To^lcW^tfall 002 (created for abstracting purposes), 002A, 002B, 002C, 002D, and 002E. __
btfall: OOZ | Receiving Water: Pawcatuck River 1 Treatment. AL
|*"°Un3/4>SWi!gn flow of wastewaters from manufacturing processes, sanitary, cooling, potable, and storm water.
Parameter
Acute WET
Cd
Cot i form (T)
Cu (T)
FC
Flow
NH3 (T)
Other
P
Pb (T)
PH
Priority pollutan
ts
Sb (T)
TOO
zn (T)
Limitations
Monthly
Average
N/A
N/A
N/A
3.000000 ug/l
200.000000
N/A
N/A
36.000000 ug/l
200.000000
N/A
2.300000 MGD
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
1.000000 ug/l
N/A
N/A
N/A
N/A
N/A
116.000000 ug/l
N/A
N/A
N/A
368.000000 ug/l
Daily
Maximum
N/A
N/A
N/A
6.000000 ug/l
400.000000
N/A
N/A
36.000000 ug/l
400.000000
N/A
3.600000 MGD
N/A
N/A
N/A
N/A
Report mg/l
N/A
Report mg/l
N/A
2.000000 ug/l
N/A
N/A
N/A
N/A
N/A
232.000000 ug/l
N/A
N/A
N/A
406.000000 ug/l
Other
See below
Units: MPN/100 ml
Units: MPN/100 ml
Monitor in WET testi
ng
Ortho-phosphorus
Monitor 1 year only
< 1 ug/l monthly ave
rage
Between 6.0 su and 9
.0 su
See below
Monitor in WET testi
ng
Monitoring Requirements
Frequency
1 /quarter
2/month
2/month
2/month
2/month
Continuous
every 2sp. event
1 /month
1 /month
2/month
1 /operating day
2/year
2/month
every 2sp. event
2/month
Sample Type
24hr fw composite
24hr fw composite
grab
24hr composite
grab
recorder
24hr composite
24hr composite
24hr composite
grab
Varies
24hr composite
24hr composite
^«™— l.---^™^— »—
Limitations/Monitoring Basis:
renresent those limitations which are in effect, regardless of
secondsry ^<«o*nn«i«v • •• • — -• — -- — i — ,
saa.-aiays ^^jj^r ^ JHEi git^;«Ss^^
a=^^^=^»£=^™=^"=
Page: 310
-------
Permit Number: R 1 0000043
L (Facility Description: Dyes and finishes wool and woven cloth oroducts ~ ~ i
' loads to the receiving water and a
is specified pursuant to the State
and State water quality regulation
manual procedures. Natural freshw
alkalinity, pH, specific conductanc
required at varying frequencies of
relating to recordkeeping and repoj
id in determining if nutrient removal is necessary. Priority pollutant monitorina
- TesHnnr09TA ^ ^l teS*™9 is Set out ™ conformance w th 40 CFR 131 "l
>. Testing must be conducted on two species in accordance with EPA guidance
-e^TS8 TSSU1NH3 TOC henols CK^Sb^ 8pecff?S anatVses of hardness.
the effluent and in some cases the dilution WEI
'ting, endpoint calculations, and sampling are ci
so provided for WET testing.
uull'ull: UUM Receiving Water: Pawcatuck R. | rreatment. AL — " — •
Amount/Components: . • — • •—-
3.4 cfs design flow of wastewaters from manufacturing processes, sanitary, cooling, potable, and storm water
Parameter
BODS
COD
Cr (T)
Phenols
Sulfide
Surfactants
TSS
Limitations
Monthly
Average
198.000000 Ib/d
Report mg/l
3102.000000 Ib/d
Report mg/l
0.700000 tb/d
Report mg/l
0.500000 Ib/d
Report mg/l
6.000000 Ib/d
Report mg/l
4.300000 Ib/d
Report mg/l
510.000000 Ib/d
Report mg/l
Daily
Maximum
396.000000 Ib/d
Report mg/l
4800.000000 Ib/d
Report mg/l
0.700000 Ib/d
Report mg/l
0.500000 Ib/d
Report mg/l
12.000000 Ib/d
Report mg/l
4.300000 Ib/d
Report mg/l
660.000000 Ib/d
Report mg/l
Other
Monitoring Requirements
Frequency
2/week
2/week
2/month
2/month
2/month
2/month
2/week
Sample Type
24hr composite
24hr composite
24hr composite
Grab
grab
24hr composite
24hr composite
Limitations/Monitoring Basis: "
4?o; lubjlrts B?dc'0andmDThlCODV(daHy)maxml"onlv)e fss'^h^ ?°nSrSt^ Wit!l textile manufacturing (40 CFR Part
Compliance Order issued by the State L™iis for sJfM£° ' i (T)f "^ surfa?tants lim''ts are based on a 1986
Outfall: 002B | Receiving Water: Pawcatuck R. I Tt.==<.m ,. „, ~— ~ — " •
Amount/Components s : •
3.4 cfs design flow of wastewaters from manufacturing processes, sanitary, cooling, potable, and storm water
Parameter
BODS
COD
Cr (T)
Phenols
Sulfide
Surfactants
Limitations
Monthly
Average
264.000000 Ib/d
Report mg/l
4136.000000 Ib/d
Report mg/l
1.000000 Ib/d
Report mg/l
0.600000 Ib/d
Report mg/l
8.000000 Ib/d
Report mg/l
5.800000 Ib/d
Report mg/l
Daily
Maximum
528.000000 Ib/d
Report mg/l
6400.000000 Ib/d
Report mg/l
1.000000 Ib/d
Report mg/l
0.600000 Ib/d
Report mg/l
16.000000 Ib/d
Report mg/l
5.800000 Ib/d
Report mg/l
Other
i
Monitoring Requirements
Frequency
1 /month
2/week
2/month
2/month
2/month
2/month
Sample Type
24hr composite
24hr composite
24hr composite
Grab
grab
24hr composite
-------
Facility Name: Bradford Dyeing Assoc., Inc.
Permit Number: RI0000043
Facility Description: Dyes and finishes wool and woven cloth products
•MHMM
TSS
SIC Code: 2269
680.000000 Ib/d
Report mg/l
880.000000 Ib/d
Report mg/l
2/week
24hr composite
basis of monitoring conditions was not described. =_=_===^=—=—^=
Outfall: 002C | Receiving Water: Pawcatuck R.
Treatment: AL
flow of wastewaters from manufacturing processes, sanitary, cooling, potable, and storm water.
Parameter
BOOS
COO
Cr (T)
Phenols
Sulfide
Surfactants
Limitations
Monthly
Average
330.000000 Ib/d
Report mg/l
5170.000000 Ib/d
Report rag/1
1.200000 Ib/d
Report mg/l
0.800000 Ib/d
Report mg/l
10.000000 Ib/d
Report mg/l
7.200000 Ib/d
Report mg/l
Dai ly
Maximum
660.000000 Ib/d
Report mg/l
8000.000000 Ib/d
Report mg/l
1.200000 Ib/d
Report mg/I
0.800000 Ib/d
Report mg/l
20.000000 Ib/d
Report mg/l
7.200000 Ib/d
Report mg/l
Other
Mom" tor in
Frequency
1 /month
2/week
2/raonth
2/month
2/month
2/month
2/week
g Requirements
Sample Type
24hr composite
24hr composite
24hr composite
Grab
grab
24hr composite
24hr composite
TSS
850.000000 Ib/d
Report mg/l
1100.000000 Ib/d
Report mg/l
z/weeic
™rSEib«^^
basis of monitoring conditions was not described.
Outfall: 002D | Receiving Water: Pawcatuck R. I Treatment. AL
Anwunt/Co^ncnts,:^ ^ ^ Hastewateps fpom manufactun-ng processes, sanitary, cooling, potable, and storm water.
Parameter
BOOS
COO
cr (T)
Phenols
Sulffda
Limitations
Monthly
Average
396.000000 Ib/d
Report mg/l
6204.000000 Ib/d
Report mg/l
1.400000 Ib/d
Report mg/l
1.000000 Ib/d
Report mg/l
12.000000 Ib/d
Report mg/l
Daily
Maximum
792.000000 Ib/d
Report mg/l
9600.000000 Ib/d
Report mg/l
1.400000 Ib/d
Report mg/l
1.000000 Ib/d
Report mg/l
24.000000 Ib/d
Report mg/ I
Other
Monitoring Requirements
Frequency
1 /month
2/week
2/month
2/month
2/month
Sample Type
24hr composite
24hr composite
24hr composite
Grab
grab
Page: 312
-------
Facility Name: Bradford Dyeing Assoc., Inc. Permit Number. RI0000043
Facility Description: Dyes and finishes wool and woven cloth products SjC Cocje. 2269
Surfactants
TSS
8.600000 Ib/d
Report mg/l
1020.000000 Ib/d
Report mg/l
8.600000 Ib/d
Report mg/l
1320.000000 Ib/d
Report mg/l
2/month
2/week
24hr composite
24hr composite
Limitations/Monitoring Basis:
BOD, sulfide, and COD (monthly av. only) limits are ELG-based consistent with textile manufacturing (40 CFR Part
410, Subparts B, C, and D). COD (daily max. only), TSS, phenols, Cr (T), and surfactants limits are based on a 1986
Compliance Order issued by the State. Limits for surfactants are also consistent with the permit issued in 1983
These limits are effective through production of 100,001 to 120,000 Ib/d. Tiered limitshave been established
pursuant to EPA 12/28/84 guidance regarding the application of product ion- based limits when fluctuations occur The
basis of monitoring conditions was not described.
Outfall: 002E | Receiving Water: Pawcatuck R. | Treatment: AL
Amount/Components :
3.4 cfs design flow of wastewaters from manufacturing processes, sanitary, cooling, potable, and storm water.
Parameter
BODS
COD
Cr (T)
Phenols
Sulfide
Surfactants
TSS
Limitations
Honthly
Average
462.000000 Ib/d
Report mg/l
7238.000000 Ib/d
Report mg/l
1.700000 Ib/d
Report mg/l
1.100000 Ib/d
Report mg/l
14.000000 Ib/d
Report mg/l
10.000000 Ib/d
Report mg/l
1190.000000 Ib/d
Report mg/l
Daily
Maximum
924.000000 Ib/d
Report mg/l
11200.000000 Ib/d
Report mg/l
1.700000 Ib/d
Report mg/l
1.100000 Ib/d
Report mg/l
28.000000 Ib/d
Report mg/l
10.000000 Ib/d
Report mg/l
1540.000000 Ib/d
Report mg/l
Other
Honitoring Requirements
Frequency
1 /month
2/week
2/month
2/month
2/month
2/month
2/week
Sample Type
24hr composite
24hr composite
24hr composite
Grab
grab
24hr composite
24hr composite
Limitations/Monitoring Basis:
/?n' |Uifid!' nnCLCOD $mJ!?thly av- onlV> limits are ELG-based consistent with textile manufacturing (40 CFR Part
rlm^H ParnSH ' •' A ^\h * - and surfactants limits are based on a 1986
Compliance Order issued by the State. Limits for surfactants are also consistent with the permit issued in 1983
nnr^u n^i PD^/sa/S/ ™ ^roush Production of 120,001 to 140,000 Ib/d. Tiered limitshave been established
pursuant to EPA 12/28/84 guidance regarding the application of production-based limits when fluctuations occur The
basis of monitoring conditions was not described.
rnLf;LP°U>hnth lJlP1*?d' ^ult? of less than the HDLs specified by RI Department of Health will constitute
compliance with the limit. When the HDL is not achievable in effluent, but is achievable in reagent water, results
reported as not detected will not be deemed a violation (subject to certification by laboratory director) HDL
requirements are based on Appendix B of the State Water Quality Regulations for Water Pollution Control A study is
required to determine the causes of foam and discoloration resulting from the discharge. The permittee is required
to analyze its effluent semi-annually for priority pollutants listed in 40 CFR Part 122, Appendix D, Tbls. Ila af
specified by the State User Fee Program. Recording of the monthly production shall be conducted and this
information reported annually.
Effective Date: 11/10/91 Expiration Date: 10/11/96 Abstract Date: 03/30/93
Page: 313
-------
FacHlty Homo: Northeast Atlantic Seafood Ltd
Permit Number: RI0021920
Facility Description: Fresh fish packaging and distribution SIC Code: 2092
Limit ELGs WQSs BPJ
Basis: ; z -
Storm
Special BMPs Water Sediment
:onditions: z - -
Monitoring
Only
I
WQ
Survey
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
I. I. — — ^
Bio
Survey TRES MDLs Monitoring Other
Z. - ^ J. J.
Abstract Information:
Complete; Outfall 001A.
Outfall: 001A | Receiving Water: Point Judith
Pond | Treatment: None.
Amount/Components:
0.202 MOD of untreated fish transport flume seawater
Parameter
BOOS
Flow
NH3-H
OSG
pH
TSS
Limitations
Monthly
Average
H/A
M/A
M/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
Report mg/l
N/A
0.202000 MGD
N/A
Report mg/l
N/A
Report mg/l
N/A
N/A
N/A
Report mg/l
Other
Between 6.8 su and 8
.5 su
Monitoring Requirements
Frequency
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
Sample Type
24hr fw composite
estimate
24hr fw composite
grab
grab
24hr fw composite
Limitations/Monitoring Basis: . .
A discussion of the basis of the pH limitation was not provided. Effluent monitoring requirements are specified in
accordance with the State regulations as well as 40 CFR 122. 4
-------
Facility Name: Sun Refining and Marketing Co.
Permit Number: RI0021946
Facility Description: Gas station groundwater remediation
SIC Code: 5983
Limit
Basis:
ELGs
UQSs
I
BPJ
J.
Monitoring
Only
WET
Limits
WET Testing
Only
Multiple
Categories
Tiered
Limits
Other
J.
Special
Conditions:
BMPs
Storm
Water
Sediment
WQ
Survey
Bio
Survey
TRES
MDLs
Monitoring
.Other
I'
Abstract Information:
Complete; Outfall 001A.
Outfall: 001A
Receiving Water: Wetland Trib. to Crookfall Br.
Treatment: AirS, +GAC
Amount/Components:
20 gpm of remediated gasoline contaminated groundwater
Parameter
Benzene
Ethylbenzene
Flow
Methyl tert butyl
ether
Other
PH
Toluene
Limitations
Monthly
Average
N/A
N/A
ug/l
N/A
N/A
Report gpm
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
1.000000 ug/l
N/A
1.000000 ug/l
20.000000 gpm
N/A
N/A
20.000000 ug/l
N/A
3.000000 ug/l
N/A
N/A
N/A
1.000000 ug/l
Other
See below
See below
See below
Xylene (T)
Between 6.5 su and 8
.0 su
See below
Monitoring Requirements
Frequency
1/2 weeks
1/2 weeks
continuous
1/2 weeks
1/2 weeks
1/2 weeks
1/2 weeks
Sample Type
grab
grab
recorder
grab
grab
grab
grab
imitations/Monitoring Basis:
The limits for benzene, ethyl-benzene, toluene, and xylenes (T) are set equal to Che analytical detection limit
(method not specified) so as to preclude discharges of the substances. Although the benzene limit is greaterthan
the proposed human health water ingestion criteria of 0.66 ug/l, this criteria is based on ingestion of 2 liters of
water for 70 years; the duration of the project is expected to be less than 7 years. The limit for MTBE is BPJ-
based consistent with the treatment systems performance; this limit is half of the State health advisory level
Limitations for benzene, toluene, ethylbenzene, and xylenes (T) have been recorded in the permit as less than (<>
the limit._ The sampling frequency of once every two weeks was selected since the treatment system of packed tower
air stripping followed by activated carbon will provide a greater degree of protection agaist breakthrough than
would normally be required.
'pecial Conditions Basis: =—=-=
Special conditions include: (1) the permittee is required to operate and maintain the recovery/treatment system in
accordance with the requirements of the Division of Groundwater and Freshwater Wetlands Protection- any failure of
the system must be reported to this division, (2) the permittee shall treat all groundwater pumped at the site using
the system described in the RIPDES application; and (3) the permittee shall obtain approval anor any necessary
permits from the Division of Air and Hazardous Materials prior to commencement of the discharge. These requirements
are based on State Water Quality Regulations and the State's Permit Regulations, both filed pursuant to Ch 46-12
as amended. '
ffective Date: 05/31/91
Expiration Date: 05/31/96
Abstract Date: 04/06/93
Page: 315
-------
Facility Name: Dart Industries, Inc Permit Number: RI0022021
Facility Description: Manufactures styrofoam products SIC Code: 3086
Monitoring
Limit ELGs WQSs BPJ Only
Basis: z J. - -
Storm WQ
Special BHPs Water Sediment Survey
looditions: — - - -
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
— — - - ^
Bio
Survey TRES MDLs Monitoring Other
- — — ^
Abstract Information:
Complete; Outfall 001A.
Outfall: 001A | Receiving Water: Blackstone River I Treatment: API, AirS, GAC
Amount/Components :
20 gpm of remediated gasoline contaminated groundwater
Pa remoter
Chlorobcnzcnc
Chlorodibromomcth
ane
Ethylbcnzonc
Flow
Hethylcne chlorid
c
Other
PCSs CO
P»
Tetrachlorccthyle
ne
Vinyl chloride
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
Report gpm
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
180.000000 ug/l
N/A
10.000000 ug/l
N/A
360.000000 ug/l
N/A
20.000000 gpm
N/A
2140.000000 ug/l
N/A
30.000000 ug/l
N/A
10.000000 ug/l
N/A
N/A
N/A
430.000000 ug/l
N/A
50.000000 ug/l
Other
Xylene
See below
Between 6.0 su and 8
.5 su
Monitoring Requirements
Frequency
1 /month
1/month
1 /month
1/day
1/month
1/month
1/month
1/month
1/month
1/month
Sample Type
grag
grab
grab
totalizer
grab
grab
grab
grab
grab
grab
Limitations/Monitoring Basis: .
The limits for chlorobenzene, ethylbenzene, methylene chloride, tetrachloro-ethylene, toluene and trichloroethylene
are WQ-based consistent with Rhode Island UQSs protection of chronic toxicity and a dilution factor of 10. "The
discharge limitations were established to ensure that the discharge meets the Rhode Island Department of
Environmental Management Minimum Database Guidelines." The limit for PCBs CT) has been recorded in the permit at
<10 ug/l. Monitoring shall be changed to 1/quarter upon notification to the State of the completion of the oil
recovery phase. A discussion of the basis for the other pollutant was not provided. A discussion of the basis of
the monitoring conditions was not provided.
Special Conditions Basis: .
Special conditions inlcude: (1) the permittee must operate the recovery/treatment system in accordance with the
requirements of the Division of Groundwater and Freshwater Wetlands Protection; (2) the permittee shall treat all
groundwatcr pumped at the site using the system described in the RPDES application; and (3) the permittee must
obtain approval and/or any necessary permits from the Division of Air and Hazardous Materials prior to commencement
of the discharge. The requirements of the permit are based on the State's Water Quality Regulations and the State's
Permit Regulations, filed pursuant to ch. 46-12, as amended.
Effective Date: 07/30/91 Expiration Date: 07/30/96 Abstract Date: 04/06/93
Page: 316
-------
Facility Name: Duke Power, Oconee Station
Permit Number: SC0000515
Facility Description: Nuclear power plant
SIC Code: 4931
Limit
Basis:
ELGs
I
WQSs
J.
BPJ
Monitoring
Only
J.
WET
Limits
WET Testing
Only
J.
Multiple
Categories
Tiered
Limits
I
Other
J.
Special
Conditions:
BMPs
I
Storm
Water
Sediment
WQ
Survey
Bio
Survey
TRES
MDLs
J.
Monitoring
I
Other
J.
Abstract Information:
Complete; Outfall 001 (A & B for abstracting purposes), 002 (A&B for abstracting purposes, 003, 004, 005, and 006.
Outfall: 001A
Receiving Water: Keowee Lake
Treatment: None.
Amount/Components:
2324.76 MGD of once through cooling water.
Parameter
Flow
Temp.
Limitations
Daily
Average
N/A
Report MGD
N/A
N/A
Daily
Maximum
N/A
Report MGD
N/A
N/A
Other
See below
Monitoring Requirements
Frequency
1/hour
1/hour
Sample Type
pump logs
calculation
Limitations/Monitoring Basis:
2=«?li/001A 1S created for abstracting purposes to represent those requirements effective from 08/01/92 through
05/31/94. Temp, may not exceed 100 F for more than 2 hours unless specifically cited conditions occur and then the
temp, may not exceed 103 F. The max. temp, rise must be less than 22 F when the intake temp, is more than 68 F
The discharge from the Station to Lake Hartwell is limited to 90 F daily avg. calculated by the sum of the temps in
a month divided by the number of measurements in a month. The discharge temp, from the Station shall be monitored
by continuous recorder. TRC and FAC may not be discharged. The monitoring requirements are continued from the
previous permit. The temperature limitation is based on State WQSs.
Outfall: 001B
Receiving Water: Keowee Lake
Treatment: None.
Amount/Components:
2324.76 MGD of once through cooling water and miscellaneous non-contact cooling water.
Parameter
Flow
Temp.
Limitations
Daily
Average
N/A
Report MGD
N/A
N/A
Daily
Maximum
N/A
Report MGD
N/A
N/A
Other
Monitoring Requirements
See below
Frequency
1/hour
1/hour
Sample Type
estimate
calculation
imitations/Monitoring Basis:
S,1^?1! 001B is created for abstracting purposes to represent those requirements effective from 06/01/94 through
07/31/97. The temp, rise is limited to 5 F daily max. as calculated by substracting the intake temp, from the
discharge temp. Monitoring for the intake temp, must be conducted 1/day by continuous sampling. TRC and FAC may
not be discharged. The permittee is required to maintain a record of the method (s) used to "measure" orestimate
flow. The monitoring requirements are continued from the previous permit. The temp, limitation is based on State
Outfall: 002A Receiving Water: Keowee River \ Treatment: Not specified.
Amount/Components :
drains° °f l°" V°lUme wastes- sar"tary sewage, chemical metal cleaning wastes, landfill leachate, and miscellaneous
Parameter
asbestos (fibrous
)
Limitations
Daily
Average
N/A
Report
Dai ly
Maximum
N/A
Report
Other
Units not specified
Monitoring Requirements
Frequency
1/year
Sample Type
grab
Page: 317
-------
FeciUty Maine: Duke Power, Oconee Station Permit Number: SCQ000515
Facility Description: Nuclear power plant SIC Code: 4931
Cd (T)
Chronic WET
cu (T)
Flow
Hydrazine
OSG
PH
TRC
TSS
N/A
Report
N/A
N/A
N/A
Report
N/A
N/A
N/A
Report
N/A
14.000000 mg/l
N/A
N/A
N/A
Report
N/A
30.000000 mg/l
N/A
Report
N/A
N/A
N/A
Report
N/A
N/A
N/A
Report
N/A
19.000000 mg/l
N/A
N/A
N/A
Report
N/A
98.000000 mg/l
Units not specified
See below
Units not specified
Reporting not given
Units not specified
Between 6.0 su and 9
.0 su
Units not specified
1 /month
1 /month
1 /month
1/week
1 /month
2/year
1/week
1/week
1/quarter
grab
24hr composite
grab
flow indicator
grab
grab
grab
grab
grab
Outfall 002A was created for abstracting purposes to represent those limitations effective from 08/01/92 through
05/31/94. Sampling for Cu (T) is to be performed when metal cleaning wastes are expected in the discharge. The
permit includes limits for excursions from the pH range when measured continuously as follows: the total time
during which the values are outside the required range must not exceed 7 hours and 26 minutes in any calendar month;
and no individual excursion from the range of pH values is allowed to exceed 60 minutes. A 3-broad chronic
toxicity test is required (based on State regulations) using a control and the IUC of 100%. The test is to be
conducted using one specie and following EPA and State guidance documents. After 12 consecutive months of "passed"
toxicity testing results, the permitting authority may terminate screening and impose a limitation. Monitoring
requirements for flow were continued from the previous permit. Monitoring will be required for Cu, Cd, and
hydrozine because they are expected to be present. The pH and TRC limits are based on Sta.te WQSs.The detection
level was established as the TRC limits because the State VICiSs were lower than the limit of detection. The O&G and
TSS limits are based on ELGs in 40 CFR Part 423.13 and account for dilution by noncontammated flows.
Outfall: 003 | Receiving Water: Internal to Outfall 002 | Treatment: AL, Dis
Amount/Components :
0.035 HGO of sanitary sewage.
Parameter
BOOS
FC
Flow
TSS
Limitations
Monthly
Average
N/A
30.000000 mg/l
N/A
200.000000
N/A
Report HGD
N/A
90.000000 mg/l
Dai ly
Maximum
N/A
60.000000 mg/l
N/A
400.000000
N/A
Report MGD
N/A
135.000000 mg/l
Other
Units: #/100 ml
Monitoring Requirements
Frequency
1/quarter
1/quarter
1/quarter
1/quarter
Sample Type
grab
grab
instantaneous
grab
The permittee is required to maintain a record of the method (s) used to "measure" or estimate flow. The flow
monitoring condition is continued from the previous permit. The FC, BOD5, and TSS limits and monitoring conditions
are continued from the previous permit.
Page: 318
-------
Facility Name: Duke Power, Oconee Station Permit Number: SC00005 15
Facility Description: Nuclear power plant SIC Code: 4931
Outfall: 004 Receiving Water: Internal to Outfall 002 | Treatment: Fil, Demin, Evap, Inc, Mix
Amount/Components :
0.007 MGD of radwaste system discharges.
Parameter
B
Flow
Hydrazine
pH
Limitations
Monthly
Average
N/A
Report
N/A
Report MGD
N/A
Report
N/A
N/A
Daily
Maximum
N/A
Report
N/A
Report MGD
N/A
Report
N/A
N/A
Other
Units not specified
Units not specified
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/quarter
1/quarter
1 /month
1 /month
Sample Type
SOday composite
estimate
grab
grab
Limitations/Monitoring Basis:
The same limitations .apply when this outfall is converted to discharges of low level radiological wastes and
chemical metal cleaning wastes by 6/1/94. The permittee is required to maintain a record of the method (s) used to
"measure" or estimate flow. Flow monitoring requirements are established based on the need for historical data for
permit writing purposes. The pH limits are based on State UQSs. Monitoring for I! is continued from the previous
permit. Monitoring requirements are established for hydrazine because it is expected to be present.
Outfall: 005 Receiving Water: Internal to Outfall 002 | Treatment: Neut + ChPt + Demin + Inc
Amount/Components:
0.18 MGD of chemcial metal cleaning wastes.
Parameter
Cu (T)
Fe (T)
Flow
Limitations
Monthly
Average
N/A
1.000000 'rag/ I
N/A
1.000000 mg/l
N/A
Report MGD
Daily
Maximum
N/A
1.000000 mg/l
N/A
1.000000 mg/l
N/A
Report MGD
Other
Monitoring Requirements
Frequency
1/batch
1/batch
1/batch
Sample Type
grab
grab
instantaneous
Limitations/Monitoring Basis:
The permittee is required to maintain a record of the method (s) used to "measure" or estimate flow. The limits for
Fe (T) and Cu (T) are based on ELGs in 40 CFR Part 423.13.
Outfall: 006 Receiving Water: Internal to Outfall 002 | Treatment: Neut + API + Sed
Amount/Components: • • '
0.0023 MGD of landfill leachate
Parameter
Ag
As
Ba
BODS
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Report
• Daily
Maximum
' N/A
Report
N/A '
Report
N/A
Report
N/A
Report
Other
Units not specified
Units not specified
Units hot specified
Units not specified
Monitoring Requirements
Frequency
1 /month
1 /month
1 /month
2/month
Sample Type
grab
grab
grab
grab
Page: 319
-------
Facility Name: Duke Power, Oconee Station Permit Number: SC0000515
Facility Description: Nuclear power plant SIC Code: 4931
Cd
cr
Flow
Hg
N03
OSG
Pb
PH
So
Specific conducts
nee
TOO
TSS
Zn
N/A
N/A
N/A
M/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Report
N/A
N/A
N/A
Report
N/A
N/A
N/A
N/A
N/A
Report
N/A
Report
N/A
N/A
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
Report
Units not specified
Units not specified
Units not specified
Units not specified
Units not specified
Units not specified
Units not specified
Units not specified
Units not specified
Units not specified
Units not specified
Units not specified
Units not specified
1 /month
1 /month
1 /month
1 /month
1 /month
2/month
1 /month
2/month
1 /month
1 /month
2/month
1 /month
1 /month
grab
grab
instantaneous
grab
grab
grab
grab
grab
grab
grab
grab
grab
grab
Sanding is not required until the landfill becomes operational. The permittee is required to maintain a record of
the method (s) used to "measure" or estimate flow. Beginning 6 months after the landfill receives its first waste
Via Outfall 006, the permittee is required to sample the discharge for the form 2C parameters 1/year. Monitoring
requirements were established for parameters that are expected to be present.
Outfall: 0028 | Receiving Water: Keowee River I Treatment: Not specified.
3.7 HGOof low volume wastes, sanitary sewage, chemical metal cleaning wastes, landfill leachate, and miscellaneous
drains.
Parameter
asbestos (fibrous
)
Cd (T)
Chronic WET
Cu (T)
Flow
Hydrazine
Limitations
Dai ly
Average
N/A
Report
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Report HGD
N/A
Report mg/l
Daily
Maximum
N/A
Report
N/A
Report
N/A
N/A
N/A
Report
N/A
Report HGD
N/A
0.012200 mg/l
Other
Units not specified
Less than 0.01 mg/l
See below
Less than 0.01 mg/l
Monitoring Requirements
Frequency
1/year
1 /month
1 /month
1 /month
1/day
1 /month
Sample Type
grab
grab
24hr composite
grab
instantaneous
grab
Page: 320
-------
Facility Name; Duke Power, Oconee Station
Permit Number: SC0000515
Facility Description: Nuclear power plant
TRC
TSS
N/A
N/A
N/A
30.000000 mg/l
N/A
N/A
N/A
Report
N/A
98.000000 mg/l
Between 6.0 su and 8
.5 su
Less than 0.1 mg/l
Limitations/Monitoring Basis-
1/week
1/week
1/quarter
grab
grab
grab
grab
those ttations effective from 06/01/94 through
"
med' o
•basis discussion for other parameters uner oCtfatf O^A °"
pecial Conditions Basis:
fl°W' See the ^i tat ioni oring
316 (a) variance request; a mixi^Uzonererqms;moah'e0nsSiepS t
S^MSfSLf?^KS ST^W S &"i. d
S boners10?-0" the USS °f "-'"tenance chem?ca s for once
r^S isndreCqu°!^ t4^}^^^^.^ ^
rSi^d^fn 9$ SarrWater m°nit°r?n9 Pla" —'"^
^b"'it a sudy PLan in the form of a
°, a°h'eVe the final thermal limitations.
«°S^°l -the discha--9eof significant
thrn, h ° f™8 1S Prohibited per 40 CFR Part
*hrou?h,.cooling water, recirculated cooling
bf maintained onsite and available for review
° ld W3St! Wlthin 90 days of the P^mit
elements for all treatment impoundments is
-------
Permit Number: SC0001368
Facility Heme: Cone Hills Corp., Carlisle
Facility Description: Fabric finisher
Special
Conditions:
I Treatment: Scr, Heut, AL, EQ, Floe, Sed
and sanitary wastewater
24hr fw composite
840.000000 Ib/d
N/A
24hr fw composite
24hr fw composite
24hr fw composite
2.0 mg/l minimum
Units:#/100 ml; see
below
Reporting not specif
ied
Between 6.0 su and 9
.0 su
24hr fw composite
4540.000000 Ib/d
N/A
2270.000000 Ib/d
N/A
Limitations/Monitoring Basis: . ,. „- „„,.„„<=«>« to reoresent those limitations effective from 11/01/91 through the
Ootfatl 001A Has created for abstracting P^P°ses to represent those i Qo /d productlon ,s
first day of the month at least 30 days after the perm ttee n°^T^| lb/d Th t- 1ts for BOD5( TSS, COD,
attained! The production level used to "tculate^the hm,0* E^S from 40 CFR Part 410 Subpart D. The daily maximum
Cr(T), phenols, FC monthly average and sulfide «e^ ^ased on ELGS rrom tQ m^ta^ the pH of the effluent
FC limit Has based.on State UQSs for a Clas|B stream ™e permitte excu?sl-ons: the total time during which the
Within the range given in the permit, with al owance Tor ine TO^I a g .n calendar month; and no
pH values are outside the required range should not exceed r "°"r» =^ - required per State regulations using a
individual excursion should exceed 60.minutes. Chrome ^city testing ^srq ^^ ^ orgam-sm/ foiiowing
control and an IWC of 10%. The test is to be "^f^^1^ Lcepiable toxicity testing may result in a reduction
EPA and State guidance id»«™"t8-.J"'1^ twelve moMhs, the permitting authority may terminate the
basis for other monitoring conditions were not ,
Page: 322
-------
Facility Name: Cone Hills Corp., Carlisle Permit Number: SC0001368
Facility Description: Fabric finisher SIC Code: 2269
Outfall: 001B | Receiving Water: Broad River | Treatment: Scr, Neut, AL, EQ, Floe, Sed
Amount/Components:
2.0 HGD of process and sanitary wastewater.
Parameter
BODS
Chronic WET
COD
Cr (T)
DO
FC
Flow
PH
Phenols
S
TSS
Limitations
Honthly
Average
1150.000000 Ib/d
N/A
N/A
N/A
20900.000000 Ib/d
N/A
17.400000 Ib/d
N/A
N/A
N/A
N/A
200.000000
N/A
N/A
N/A
N/A
17.400000 Ib/d
N/A
34.800000 Ib/d
N/A
3100.000000 Ib/d
N/A
Daily
Maximum
2300.000000 Ib/d
N/A
N/A
N/A
41800.000000 Ib/d
N/A
34.800000 Ib/d
N/A
N/A
N/A
N/A
400.000000
N/A
N/A
N/A
N/A
34.800000 Ib/d
N/A
69.600000 Ib/d
N/A
6200.000000 Ib/d
N/A
Other
See below
2.0 mg/l minimum
Units:#/100 ml; see
below
Reporting not specif
ied
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
3/week
1 /month
3/week
1/week
1/week
1/week
1/day
continuous
1 /month
1 /month
3/week
Sample Type
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
grab
continuous
record
grab
grab
24hr fw composite
Limitations/Monitoring Basis:
Outfall 001B was created for abstracting purposes to represent those limitations affective from the first day of the
month at least 30 days after the permittee notifies the state that 330,000 Ib/d production is attained through
04/30/95. See the basis discussion for Outfall 001 A.
Outfall: 002 | Receiving Water: Unnamed trib. to Broad River | Treatment: Sed
Amount/Components :
0.05 MGD of water plant wastewater.
Parameter
Flow
PH
TRC
TSS
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
N/A
30.000000 mg/l
Daily
Maximum
N/A
0.050000 HGD
N/A
N/A
N/A
0.100000 mg/l
N/A
60.000000 mg/l
Other
Between 6.0 and 9.0
su
Limit is <0.1 mg/l
Monitoring Requirements
Frequency
1/day
1/week
1/week
1/week
Sample Type
instantaneous
grab
grab
grab
Limitations/Monitoring Basis:
Flow is to be monitored during discharge periods with a daily maximum flow of 0.05 HGD. The limit for TSS is based
on the standard State limit and the advice of the Wasteload Allocation Section of the permitting authority, to
protect the Broad River during periods of heavy rains. The TRC limit is WQ-based and takes into consideration data
submitted in the application. The basis for other monitoring conditions was not discussed.
Page: 323
-------
Facility Name: Cone Hills Corp., Carlisle Permit Number: SC0001368
Facility Description: Fabric finisher SIC Code: 2269
Outfall: 003 | Receiving Water: Unnamed trib. to Broad River | Treatment: Not specified.
Amount/Components :
0.05 HGO of ash water.
Parameter
BOOS
Cu
Flow
O&G
Pb (T>
pH
TSS
Zn
Limitations
Monthly
Average
N/A
10.000000 Ib/d
N/A
N/A
N/A
N/A
N/A
15.000000 mg/l
N/A
N/A
N/A
N/A
N/A
30.000000 mg/l
N/A
59.000000 ug/l
Dai ly
Maximum
N/A
20.000000 Ib/d
N/A
10.000000 ug/l
N/A
0.050000 MGD
N/A
20.000000, mg/l
N/A
Report
N/A
N/A
N/A
50.000000 mg/l
N/A
65.000000 ug/l
Other
Limit is <10 ug/l
Units not specified
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/week
1/week
1/day
1/week
1/week
1/week
1/week
1/week
Sample Type
24hr fw composite
grab
instantaneous
grab
grab
grab
grab
grab
Limitations/Monitoring Basis: .
The limits for BOOS are based on the standard State limit and the advice of the Wasteload Allocation Section of the
permitting authority, to protect the Broad River during periods of heavy rains. The limits for TSS and O&G are
continued from the previous permit. Limits for Cu, Pb, and Zn are based on data submitted with the permit
application and State WQSs. No mass limits were included because the expected amounts are well below water quality
concerns. The basis for other monitoring conditions was not discussed.
Special Conditions Basis: . . .
The permittee is required to submit an annual sludge and soil testing report to the permitting authority. The
permit contains a list of 60 parameters to be analyzed for in these tests. Sludge testing is required every time
the sludge is spread, with at least one analysis per year. The permit includes several requirements in regard to
use and testing of the sludge. The permittee is required to analyze several groundwater testing wells for 12
parameters and submit a report on a quarterly basis. The permit contains a compliance schedule for the fecal
coliform limits. The requirement for a BMP plan relates to the identification and control of toxic and hazardous
substances listed in 40 CFR Part 117 and Tables II and III of Appendix D to 40 CFR Part 122. If the results of
toxicity testing fail, a toxicity evaluation plan must be submitted to the permitting authority within 60 days.
Effective Date: 11/01/91 Expiration Date: 04/30/95 Abstract Date: 06/01/93
Page: 324
-------
Facility Name: Mites Inc., Bushy Park Plant
Facility Description: Manufacturer of organic dyes
Monitoring
Limit ELGs WQSs BPJ Only
Basis: J_ ^ ^ ^
Storm WQ
Special BMPs Water Sediment Survey
Conditions: J_
WET
Limits
Bio
Survey
Abstract Information:
Complete; Outfalls 001 (A & B created for abstracting purposes), 002,
Outfall: 001A | Receiving Water: Cooper River
Permit Number: SC0003441
SIC Code: 2865
WET Testing Multiple Tiered
Only Categories Limits Other
1 ' - J. J.
TRES MDLs Monitoring Other
and 003.
Treatment: None specified
Amount/Components :
3.5 MGD of process and sanitary wastewater.
Parameter
1,1,1-Trichloroet
hane
1,1,2-Trichloroet
hane
1,1-Dichloroethan
e
1,1-Dichloroethyl
ene
1,2,4-Trichlorobe
nzene
1,2-Dichlorobenze
ne
1,2-Dichloroethan
e
1,2-Dichloropropa
ne
1,2-Trans-Dichlor
oethytene
1,3-Cis-Dichlorop
ropylene
1 ,3-Dichlorobenze
ne
1 ,4-Dichlorobenze
ne
2,4-Dichloropheno
2,4-Dimethylpheno
I
2,4-Dinitrophenol
2,4-Dinitrotoluen
e
2,6-Dinitrotoluen
e
2-Chlorophenol
Limitations
Monthly
Average
0.360000 Ib/d
N/A
0.360000 Ib/d
N/A
0.380000 Ib/d
N/A
0.270000 Ib/d
N/A
1.160000 Ib/d
N/A
1.310000 tb/d
N/A
1.160000 Ib/d
N/A
2.610000 Ib/d
N/A
0.360000 Ib/d
N/A
0.490000 Ib/d
N/A
0.530000 Ib/d
N/A
0.260000 Ib/d
N/A
0.660000 Ib/d
N/A
0.310000 Ib/d
N/A
1.210000 Ib/d
N/A
1.930000 Ib/d
N/A
4.350000 Ib/d
N/A
0.530000 Ib/d
N/A
Dai ly
Maximum
0.920000 Ib/d
Report
0.920000 Ib/d
Report
1.010000 Ib/d
Report
0.430000 Ib/d
Report
2.390000 Ib/d
Report
2.780000 Ib/d
Report
3.600000 Ib/d
Report
3.920000 Ib/d
Report
0.920000 Ib/d
Report
0.750000 Ib/d
Report
0.750000 Ib/d
Report
0.480000 Ib/d
Report
1.910000 Ib/d
Report
0.610000 Ib/d
Report
2.100000 Ib/d
Report
4.860000 Ib/d
Report
10.930000 Ib/d
Report
1.670000 Ib/d
Report
Other
Cone, units
ified
Cone, units
ified
Cone, units
ified
Cone, units
ified
Cone, units
ified
Cone, units
ified
Cone, units
ified
Cone, units
ified
Cone, units
ified
Cone, units
ified
Cone, units
ified
Cone, units
ified
Cone, units
ified
Cone, units
ified
Cone, units
ified
Cone, units
ified
Cone, units
ified
Cone, units
ified
not spec
not spec
not spec
not spec
not spec
not spec
not spec
not spec
not spec
not spec
not spec
not spec
not spec
not spec
not spec
not spec
not spec
Monitoring Requirements
Frequency
1/year
1/year
1/year
1/month
1/year
1/year
I/year
1/year
1/year
1/year
1/month
1/month
1/year
1/year
1/year
1/year
1/year
not spec 1/month
Sample Type
grab
grab
grab
grab
24hr fw composite
24hr fw composite
grab
grab
grab
grab
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
Page: 325
-------
Facility Hatnc: Miles Inc., Bushy Park Plant Permit Number: SC0003441
Facility Description: Manufacturer of organic dyes SIC Code: 2865
2-Mitrophcnol
3,4-Bcnzofluorant
hcne
4,6-Dinltro-o-cre
sol
4-Hitrophenol
Accnaphthcne
Acenaphthylene
Acrylonitrilc
Anthracene
As
Benzene
Benzo (a) anthrac
one
Benzo (a) pyrene
Benzo (k) fluoran
thane
Bis (2-ethylhexyl
} phthalate
BOOS
Carbon tetrachlor
ide
Chlorobcnzcnc
Chloroethane
Chloroform
Chronic MET
Chryscnc
CM (T)
Cr
CU
Di-n-butyl phthal
ate
0.700000 Ib/d
N/A
0.390000 Ib/d
N/A
1.330000 Ib/d
N/A
1.230000 Ib/d
N/A
0.380000 Ib/d
N/A
0.380000 Ib/d
N/A
1.640000 Ib/d
N/A
0.380000 Ib/d
N/A
N/A
50.000000 ug/l
0.630000 Ib/d
N/A
0.380000 Ib/d
N/A
0.390000 Ib/d
N/A
0.380000 Ib/d
N/A
1.760000 Ib/d
N/A
767.000000 Ib/d
N/A
0.310000 Ib/d
N/A
0.260000 Ib/d
N/A
1.770000 Ib/d
N/A
0.360000 Ib/d
N/A
N/A
N/A
0.380000 Ib/d
N/A
7.160000 Ib/d
N/A
3.200000 Ib/d
N/A
2.700000 Ib/d
N/A
0.460000 Ib/d
N/A
1.180000 Ib/d
Report
1.040000 Ib/d
Report
4.720000 Ib/d
Report
2.110000 Ib/d
Report
1.010000 Ib/d
Report
1.010000 Ib/d
Report
4.130000 Ib/d
Report
1.010000 Ib/d
Report
N/A
100.000000 ug/l
2.320000 Ib/d
Report
1.010000 Ib/d
Report
1.040000 Ib/d
Report
1.010000 Ib/d
Report
4.760000 Ib/d
Report
2045.000000 Ib/d
95.000000 mg/l
0.650000 Ib/d
Report
0.480000 Ib/d
Report
4.570000 Ib/d
Report
0.780000 Ib/d
Report
N/A
Report
1.010000 Ib/d
Report
16.180000 Ib/d
Report
5.400000 Ib/d
150.000000 ug/l
5.400000 Ib/d
150.000000 ug/l
0.970000 Ib/d
Report
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units' not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Units not specified;
see
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
1/year
1/year
1/year
1/year
1 /month
1/year
1/year
1/year
1 /month
1 /month
1/year
1/year
1/year
1 /month
4/week
1 /month
1 /month
1/year
1 /month
1/quarter
1/year
1 /month
4/week
2/week
1/year
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
24hr fw composite
24hr fw composite
grab
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
grab
grab
grab
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
Page: 326
-------
. : — ...... Permit Number: SC0003441
| Facility Description: Manufacturer of organic dyes ,
Diethyl phthalate
Dimethyl phthalat
e
Ethylbenzene
FC
Flow
Fluoranthene
Fluorene
Hexachlorobenzene
Hexachlorobutadie
ne
Hexachloroethane
Methyl chloride
Methylene chlorid
e
Naphthalene
NH3
Nitrobenzene
pH
Phenanthrene
Phenol
Phenols
Pyrene
Tetrachloroethyle
ne
TOC
Toluene
Trichloroethylene
TSS
1.380000 Ib/d
N/A
0.320000 Ib/d
N/A
0.550000 Ib/d
N/A
N/A "
1000.000000
N/A
N/A
0.430000 Ib/d
N/A
0.380000 Ib/d
N/A
0.260000 Ib/d
N/A
0.340000 Ib/d
N/A
0.360000 Ib/d
N/A
1.470000 Ib/d
N/A
0.680000 Ib/d
N/A
0.380000 Ib/d
N/A
545.000000 Ib/d
N/A
0.460000 Ib/d
N/A
N/A
N/A
0.380000 Ib/d
N/A
0.260000 Ib/d
N/A
7.200000 Ib/d
N/A
0.430000 Ib/d
N/A
0.380000 Ib/d
N/A
4552.000000 Ib/d
N/A
0.440000 Ib/d
N/A
0.360000 Ib/d
N/A
972.000000 Ib/d
N/A
3.460000 Ib/d
Report
0.800000 Ib/d
Report
1.840000 Ib/d
Report
N/A
2000.000000
N/A
Report MGD
1.160000 Ib/d
Report
1.010000 Ib/d
Report
0.480000 Ib/d
Report
0.840000 Ib/d
Report
0.920000 Ib/d
Report
3.240000 Ib/d
Report
1.520000 Ib/d
Report
1.010000 Ib/d
Report
720.000000 Ib/d
20.000000 mg/l
1.160000 Ib/d
Report
N/A
Report
1.010000 Ib/d
Report
0.440000 Ib/d
Report
10.800000' Ib/d
0.300000 mg/l
1/140000 Ib/d
Report
0.950000 Ib/d
Report
6822.000000 Ib/d
Report
1.360000 Ib/d
Report
0.920000 Ib/d
Report
2150.000000 Ib/d
N/A
Cone, units not spec
ified
Cbnc. units not spec
ified
Cone, units not spec
ified
'Units: #/100 ml
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
'ified
Cone, units not spec
ified
Cone, units not spec
ified ' ' •'
Between "6.0 su and 9
.0 su
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec'
ified
Cone, units not spec
ified
1/year
1/month
1 /month
1/month
1/day
1/month
1/year
1/year
1/year
1/year
1/year
1 T
1/year
1/month
2/week
1/month
continuous
1/year
1/month
3/week
1/year
1/year
2/week
1/month
1/year
4/week
24hr fw composite
24hr fw composite
grab
grab
continuous
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
grab
24hr fw composite
24hr fw composite
24hr fw composite
record
24hr fw composite
24hr fw composite
grab
24hr fw composite
grab
24hr fw composite
grab
grab
24hr fw composite
Page: 327
-------
Facility Name: Miles Inc., Bushy Park Plant
Facility Description: Manufacturer of organic dyes
Permit Number: SC0003441
SIC Code: 2865
Vinyl chloride
Zn
1.770000 Ib/d
N/A
3.800000 Ib/d
N/A
4.570000 Ib/d
Report
6.800000 Ib/d
350.000000 ug/l
c. units not spec
ed
1/year
2/week
grab
24hr fw composite
Outfall: 001B | Receiving Water: Cooper River
Treatment:
Amount/Components:
3.5 HGO of process and sanitary wastewater.
Parameter
1,1,1-Trichloroct
hane
1,1,2-Triehloroct
hone
1,1-Dichloroethan
e
1,1-Dichloroethyl
cnc
1,2,4-Trichlorobe
nzcno
1,2-Dichlorobcnze
nc
1,2-Dichloroothan
c
1,2-Dichloropropa
no
1,2-Trans-Dichlor
oethylcne
1,3-Cis-Dichlorop
ropyleno
1,3-Dichlorobonze
no
1,4-Dichlorobenze
nc
2,4-Dichloropheno
2,4-Dimethylpheno
Monthly
Average
0.610000 Ib/d
H/A
0.610000 Ib/d
N/A
0.640000 Ib/d
N/A
0.470000 Ib/d
N/A
1.990000 Ib/d
N/A
2.250000 Ib/d
N/A
1.990000 Ib/d
H/A
4.470000 Ib/d
N/A
0.610000 Ib/d
N/A
0.850000 Ib/d
N/A
0.910000 Ib/d
N/A
0.440000 Ib/d
N/A
1.140000 Ib/d
H/A
0.530000 Ib/d
H/A
Limitations
Daily
Maximum
1.580000 Ib/d
Report
1.580000 Ib/d
Report
1.720000 Ib/d
Report
0.730000 Ib/d
Report
4.090000 Ib/d
Report
4.760000 Ib/d
Report
6.160000 Ib/d
Report
6.720000 Ib/d
Report
1.580000 Ib/d
Report
1.290000 Ib/d
Report
1.290000 Ib/d
Report
0.820000 Ib/d
Report
3.270000 Ib/d
Report
1.050000 Ib/d
Report
Other
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Monitorinc
Frequency
1/year
1/year
1/year
1 /month
1/year
1/year
1/year
1/year
1/year
1/year
1 /month
1 /month
1/year
1/year
Requi rements
Sample Type
grab
grab
grab
grab
24hr fw composite
24hr fw composite
grab
grab
grab
grab
24hr fw composite
24hr fw composite
. 24hr fw composite
24hr fw composite
Page: 328
-------
Facility Name: Miles Inc., Bushy Park Plant Permit Number: SC0003441
Facility Description: Manufacturer of organic dyes SIC Code: 2865
2,4-Dinitrophenol
2,4-Dinitrotoluen
e
2,6-Dinitrotoluen
e
2-Chlorophenol
2-Nitrophenol
3,4-Benzof luorant
hene
4,6-Dinitro-o-cre
sol
4-Nitrophenol
Acenaphthene
Acenaphthylene
Acrylonitrile
Anthracene
As
Benzene
Benzo (a) anthrac
ene
Benzo (a) pyrene
Benzo (k) fluoran
thane
Bis (2-ethylhexyl
) phthalate
BODS
Carbon tetrachlor
ide
Chlorobenzene
Chloroethane
Chloroform
Chronic WET
Chrysene
2.070000 Ib/d
N/A
3.300000 Ib/d
N/A
7.450000 Ib/d
N/A
0.910000 Ib/d
N/A
1.200000 Ib/d
N/A
0.670000 Ib/d
N/A
2.280000 Ib/d
N/A
2.100000 Ib/d
N/A
0.640000 Ib/d
N/A
0.640000 Ib/d
N/A
2.800000 Ib/d
N/A
0.640000 Ib/d
N/A
1.500000 Ib/d
N/A
1.080000 Ib/d
N/A
0.640000 Ib/d
N/A
0.670000 Ib/d
N/A
0.640000 Ib/d
N/A
3.010000 Ib/d
N/A
1315.000000 Ib/d
N/A
0.530000 Ib/d
N/A
0.440000 Ib/d
N/A
3.040000 Ib/d
N/A
0.610000 Ib/d
N/A
N/A
N/A
0.640000 Ib/d
N/A
3.590000 Ib/d
Report
8.320000 Ib/d
Report
18.720000 Ib/d
Report
2.860000 Ib/d
Report
2.020000 Ib/d
Report
1.780000 Ib/d
Report
8.090000 Ib/d
Report
3.620000 Ib/d
Report
1.720000 Ib/d
Report
1.720000 Ib/d
Report
7.070000 Ib/d
Report
1.720000 Ib/d
Report
2.900000 Ib/d
Report
3.970000 Ib/d
Report
1.720000. Ib/d
Report
1.780000 Ib/d
Report
1.720000 Ib/d
Report
8.150000 Ib/d
Report
3510.000000 Ib/d
Report
1.110000 Ib/d
Report
0.820000 Ib/d
Report
7.830000 Ib/d
Report
1 .340000 Ib/d
Report
N/A
Report
1.720000 Ib/d
Report
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone. Units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Units not specified
Cone, units not spec
ified
1/year
1/year
1/year
1 /month
1/year
1/year
1/year
1/year
1 /month
1/year
1/year
1/year
1 /month
1 /month
1/year
1/year
1/year
1 /month
4/week
1 /month
1 /month
1/year
1/month
1/quarter
1/year
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
24hr fw composite
• 24hr fw composite
grab
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
grab
grab
grab
24hr fw composite
24hr fw composite .
Page: 329
-------
Facility Homo: Miles Inc., Bushy Park Plant Permit Number: SC0003441
Facility Description: Manufacturer of organic dyes . SIC Code: 2865
CM (T)
cr
Cu
Di-n-butyl phthal
ate
Diethyl phthalate
Dimethyl phthalat
e
DO
Ethylbenzene
FC
Flow
Fluoranthene
Fluorcne
Hexach lorobenzene
Hexach lorobutadi e
ne
Hexachloroethane
Methyl chloride
Hethylene chlorid
e
Naphthalene
HH3
Nitrobenzene
0£Q
pH
Phenanthrene
Phenol
Phenols
12.270000 Ib/d
N/A
3.200000 Ib/d
N/A
5.100000 Ib/d
N/A
0.790000 Ib/d
N/A
2.370000 Ib/d
N/A
0.550000 Ib/d
N/A
N/A
N/A
0.930000 Ib/d
N/A
N/A
1000.000000
N/A
Report MGD
0.730000 Ib/d
N/A
0.640000 Ib/d
N/A
0.440000 Ib/d
N/A
0.580000 Ib/d
N/A
0.610000 Ib/d
N/A
2.510000 Ib/d
N/A
1.170000 Ib/d
N/A
0.640000 Ib/d
N/A
320.000000 Ib/d
N/A
0.790000 Ib/d
N/A
N/A
10.000000 mg/l
N/A
N/A
0.640000 Ib/d
N/A
0.440000 Ib/d
N/A
7.200000 Ib/d
N/A
16.180000 Ib/d
Report
5.400000 Ib/d
Report
10.200000 Ib/d
Report
1.660000 Ib/d
Report
5.930000 Ib/d
Report
1.370000 Ib/d
Report
N/A
Report
3.150000 Ib/d
Report
N/A
2000.000000
N/A
Report MGD
1.990000 Ib/d
Report
1.720000 Ib/d
Report
0.820000 Ib/d
Report
1.430000 Ib/d
Report
1.580000 Ib/d
Report
5.550000 Ib/d
Report
2.600000 Ib/d
Report
1.720000 Ib/d
Report
640.000000 Ib/d
22.000000 mg/l
1.990000 Ib/d
Report
N/A
15.000000 mg/l
N/A
Report
1.720000 Ib/d
Report
0.760000 Ib/d
Report
10.800000 Ib/d
0.300000 mg/l
Cone, units not spec
if ied
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
1.0 mg/l min.
Cone, units not spec
ified
Units: #/100 ml
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Between 6.0 su and 9
.0 su
Cone, units not spec
ified
Cone, units not spec
ified
1 /month
2/week
2/week
1/year
1/year
1 /month
2/week
1 /month
2/month
1/day
1 /month
, 1/year
1/year
1/year
1/year
1/year ,
1/year
1 /month
4/week
1 /month
2/month ,
continuous
1/year
1 /month
3/week
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
grab
grab
continuous
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
grab
24hr fw composite
24hr fw composite
24hr fw composite
grab
record
24hr fw composite
24hr fw composite
grab
Page: 330
-------
Facility Name: Miles Inc., Bushy Park Plant Permit Number: SC0003441
Facility Description: Manufacturer of organic dyes SIC Code: 2865
Pyrene
Tetrach loroethyle
ne
TOC
Toluene
TRC
Trichloroethylene
TSS
Vinyl chloride
Zn
0.730000 Ib/d
N/A
0.640000 Ib/d
N/A
7798.000000 Ib/d
N/A
0.760000 Ib/d
N/A
N/A
0.500000 mg/l
0.610000 Ib/d
N/A
1666.000000 Ib/d
N/A
3.040000 Ib/d
N/A
3.800000 Ib/d
N/A
1.960000 Ib/d
Report
1.640000 Ib/d
Report
11687.000000 Ib/d
Report
2.340000 Ib/d
Report
N/A
1.000000 mg/l
1.580000 Ib/d
Report
4378.000000 Ib/d
Report
7.830000 Ib/d
Report
6.800000 Ib/d
250.000000 ug/l
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
Cone, units not spec
ified
1/year
1/year
2/week
1 /month
2/week
1/year
4/week
1/year
2/week
24hr fw composite
grab
24hr fw composite
grab
grab
grab
24hr fw composite
grab
24hr fw composite
Limitations/Monitoring Basis:
This outfall was created to represent limits which apply from 1/1/92 until the permit expiration date. See the
permit stipulations and discussion of basis for Outfall 001A. The mass limits were based on an average flow of 3.5
MGD. The basis for the limits was the same as for Outfall 001A, with the following exceptions. Calculations for
mass limits were proportioned according to the ratio of wastewater flows. A limit for DO was based on
recommendations resulting from output from a watershed model.
Outfall: 002 Receiving Water: Cooper River Treatment: Not specified
Amount/Components: •
Unspecified amount of once through noncontact cooling water.
Parameter '
BODS
Flow
PH
Zn (T>
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
2.630000 Ib/d
N/A
Daily
Maximum
N/A
10.000000 mg/l
N/A
Report
N/A
Report
4.380000 Ib/d
1.500000 mg/l
Other
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
2/month
1/day
2/month
2/month
Sample Type
grab
estimate
grab
grab
Limitations/Monitoring Basis: "
The basis for these monitoring conditions and limits was not discussed.
Outfall: 003 Receiving Water: Back River Treatment: Not specified
Amount/Components:
Water plant filter backwash.
Parameter
Al
Flow
Limitations
Monthly
Average
N/A
Report
N/A
Report MGD
Dai ly
Maximum
N/A
Report
N/A
Report MGD
Other
Cone, units not spec
ified
Monitoring Requirements
Frequency
1 /month
1 /month
Sample Type
grab
estimate
Page: 331
-------
Facility Home: Miles Inc., Bushy Park Plant
Permit Number: SC0003441
Facility Description: Manufacturer of organic dyes
SIC Codes 2865
p«
TSS
N/A
N/A
N/A
30.000000 mg/l
N/A
Report
N/A
60.000000 mg/l
Between 6.0 su and 9
.0 su
1/month
1 /month
grab
grab
Limitations/Monitoring Basis:
The basis for these monitoring conditions and limits was not discussed.
Special Conditions Basis:
The BMP plan must be updated according to specified criteria, but no due date was provided. Requirements for the
documentation and usage of maintenance chemicals for once through noncontact cooling water, recirculated cooling
Hater, boiler blowdown water, and air washer water are provided. Several sludge provisions are in the permit,
including: the permittee must obtain written approval before any revised disposal of sludge; the permittee must
submit information on the amount of sludge produced, the present disposal method; and the permittee must prepare and
submit a long-term program for sludge handling and disposal. This proposed long-term program must include a
schedule of implementation. The permit contains a compliance schedule for constructing and operating a discharge
diffuser before increasing manufacturing, and submitting a closure plan for a new wastewater treatment system.
Effective Date: 01/01/9Z
Expiration Date: 06/30/93
Abstract Date: 06/02/93
Page: 332
-------
FacHity Name: All,ed Fibers, Columbia Plant Perml-t Number; SC0003557
Facility Description: Manufacturer of nylon resin and nylon fiber SIC Code. 28?i
Limit P. r= nne ™ , Monitoring WET WET Testing Multiple
Basis- J / °n/ly Limits Onlv Categories
x- X- 2. £ ^ ^
. , Storm WQ Bio
Special BMPs Water Sediment Survey Survey TRES MDLs
conditions: J — - _ _
Tiered
Limits Other
- I
Monitoring Other
Abstract Information:
Partial; Outfalls 001 and 002 (representing Outfall 003).
Outfall: 001
Receiving Water: Saluda River I Treatment:
Amount/Components:
and6sludgePpreIsSbacktflush? C°ntaml'nated storm water' contact C0olin9 wate<-, b°'^ blowdown, sanitary wastewater.
Parameter
1,1,1-Trichloroet
hane
1,1,2-Trichloroet
hane
1,1-Dichloroethan
e
1,1-Dichloroethyl
ene
1,2,4-Trichlorobe
nzene
1,2-Dichlorobenze
ne
1,2-Dichtoroethan
e
1,2-Dichloropropa
ne
1,2-Trans-Dichlor
oethylene
1,3-Dichlorobenze
ne
1,4-Dichlorobenze
ne
2,4-Dichloropheno
2,4-Dimethylpheno
2,4-Dinitrophenol
?,4-Dinitrotoluen
2,6-Dinitrotoluen
2-Chlorophenol
2-Nitrophenol
Limitations
Monthly
Average
0.094000 Ib/d
N/A
0.094000 Ib/d
N/A
0.099000 Ib/d
N/A
0.072000 Ib/d
N/A
0.305000 Ib/d
N/A
0.345000 Ib/d
N/A
0.305000 Ib/d
N/A
0.686000 Ib/d
N/A
0.094000 Ib/d
N/A
0.139000 Ib/d
N/A
0.067000 Ib/d
N/A
0.175000 Ib/d
N/A
0.081000 Ib/d
N/A
0.318000 Ib/d
N/A
0.506000 Ib/d
N/A
1.143000 Ib/d
N/A
0.139000 Ib/d
N/A
0.184000 Ib/d
N/A
Dai ly
Maximum
0.242000 Ib/d
N/A
0.242000 Ib/d
N/A
0.264000 Ib/d
N/A
0.112000 Ib/d
N/A
0.627000 Ib/d
N/A
0.730000 Ib/d
N/A
0.946000 Ib/d
N/A
1.031000 Ib/d
N/A
0.242000 Ib/d
N/A
0.197000 Ib/d
N/A
0.125000 Ib/d
N/A
0.502000 Ib/d
N/A
0.161000 Ib/d
N/A
0.551000 Ib/d
N/A
1.277000 Ib/d
N/A
2.872000 Ib/d
N/A
0.439000 Ib/d
N/A
0.309000 Ib/d
N/A
Other
Monitoring Requirements
Frequency
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
Sample Type
grab
grab
grab
grab
24hr fw composite
24hr fw composite
grab
grab
grab
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
Page: 333
-------
Facility Name: Allied Fibers, Columbia Plant Pe™,t Number: SC0003557
Facility Description: Manufacturer of nylon resin and nylon fiber SIC Code- 28Z4
3,4-Benzofluorant
icno
4,6-Dinitro-o-cre
sol
4-Nitrophenol
Acenaphthene
Acenaphthylene
Acrylonitrile
Acute WET
Anthracene
Benzene
Benzo (a) enthrac
cno
Benzo (a) pyrene
Bcnzo (k) fluoran
thane
Bis (2-ethylhexyl
) phthalate
BOOS
Carbon tetrachlor
ide
Chlorobenzene
Chloroethane
chloroform
Chryscne
Oi-n-butyl phthal
ate
D) ethyl phthalate
Dimethyl phthalat
e
DO
Ethylbenzene
FC
0.103000 Ib/d
N/A
0.350000 Ib/d
N/A
0.323000 Ib/d
N/A
0.099000 Ib/d
N/A
0.099000 Ib/d
N/A
0.430000 Ib/d
N/A
N/A
H/A
0.099000 Ib/d
N/A
0.166000 Ib/d
N/A
0.099000 Ib/d
N/A
0.103000 Ib/d
N/A
0.099000 Ib/d
N/A
0.462000 Ib/d
N/A
103.000000 Ib/d
N/A
0.081000 Ib/d
N/A
0.067000 Ib/d
N/A
0.466000 Ib/d
N/A
0.094000 Ib/d
N/A
0.099000 Ib/d
N/A
0.121000 Ib/d
N/A
0.363000 Ib/d
N/A
0.085000 Ib/d
N/A
N/A
Report
0.143000 Ib/d
N/A
N/A
200.000000
0.273000 Ib/d
N/A
1.241000 Ib/d
N/A
0.556000 Ib/d
N/A
0.264000 Ib/d
N/A
0.264000 Ib/d
N/A
1.084000 Ib/d
N/A
N/A
Report
0.264000 Ib/d
N/A
0.609000 Ib/d
N/A
0.264000 Ib/d
N/A
0.273000 Ib/d
N/A
0.264000 Ib/d
N/A
1.250000 Ib/d
N/A
269.000000 Ib/d
N/A
0.170000 Ib/d
N/A
0.125000 Ib/d
N/A
1.201000 Ib/d
N/A
0.206000 Ib/d
N/A
0.264000 Ib/d
H/A
0.255000 Ib/d
N/A
0.910000 Ib/d
N/A
0.211000 Ib/d
N/A
N/A
Report
0.484000 Ib/d
N/A
N/A
400.000000
See below
5.0 mg/l min.
Units: #/100 ml
1/year
1/year
1/year
1/year
1/year
1/year
1 /month
1/year
1/year
1/year
1/year
1/year
1/year
3/week
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/week
1/year
1/week
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
24hr composite
24hr fw composite
grab
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
grab
grab
grab
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
grab
grab
Page: 334
-------
Facility Name: Allied Fibers. Columbia Plant Permit Number: SC0003557
Facility Description: Manufacturer of nylon resin and nylon fiber SIC Code. 2824
Fluoranthene
Fluorene
Hexach lorobenzene
Hexach I orobutadi e
ne
Hexach I oroethane
Methyl chloride
Methylene chlorid
e
Naphthalene
NH3-N
Nitrobenzene
O&G
pH
Phenanthrene
Phenol
Pyrene
Temp.
Tetrachloroethyle
ne
Toluene
TRC
Trichloroethylene
TSS
Vinyl chloride
Report HGD
0.112000 Ib/d
N/A
0.099000 Ib/d
N/A
0.067000 Ib/d
N/A
0.090000 Ib/d
N/A
0.094000 Ib/d
N/A
0.385000 Ib/d
N/A
0.179000 Ib/d
N/A
0.099000 Ib/d
N/A
N/A
Report mg/l
0.121000 Ib/d
N/A
N/A
42.000000 Ib/d
N/A
N/A
0.099000 Ib/d
N/A
0.067000 Ib/d
N/A
0.122000 Ib/d
N/A
N/A
N/A
0.099000 Ib/d
N/A
0.117000 Ib/d
N/A
N/A
0.500000 mg/l
0.094000 Ib/d
N/A
179.000000 Ib/d
N/A
0.466000 Ib/d
N/A
Report MGD
0.305000 Ib/d
N/A
0.264000 Ib/d
N/A
0.125000 Ib/d
N/A
0.220000 Ib/d
N/A
0.242000 Ib/d
N/A
0.851000 Ib/d
N/A
0.399000 Ib/d
N/A
0.264000 Ib/d
N/A
N/A
Report mg/l
0.305000 Ib/d
N/A
N/A
63.000000 Ib/d
N/A
Report
0.264000 Ib/d
N/A
0.117000 Ib/d
N/A
0.300000 Ib/d
N/A
N/A
92.000000 F
0.251000 Ib/d
N/A
0.359000 Ib/d
N/A
N/A
1.000000 mg/l
0.242000 Ib/d
N/A
540.000000 Ib/d
N/A
1.201000 Ib/d
N/A
Between 6.0 su and 9
.0 su
1/day
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1 /month
1/year
1/month
continuous
1/year
1/year
1/year
1/day
1/year
1/year
1/week
1/year
3/week
1/year
continuous
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
record
24hr fw composite
24hr fw composite
24hr fw composite
continuous
grab
grab
grab
grab
24hr fw composite
grab
Limitations/Monitoring Basis: ~
IhP STvln inctudes i'Tlts^or excursi°ns from the pH range when measured continuously as follows- the total time
^ttyasfss % ss-s sre.r nssft sa-s s^^ssxssfi? r
i E? ;;Sv?r »^'^^^«"^^^fcJ!^si
-------
aciUtyNoflxs: Allied Fibers, Columbia Plant
Permit Number: SC0003557
;acUity Description: Manufacturer of nylon resin and nylon fiber
SIC Code: 2824
monitoring and limitations for temp., O&G, and pH were continued from the existing permit. The DO, NH3:N, FC and
TRC limits weVe bSsed onWQ considerations and recommendations of the State's Wasteload Allocation Sectlon. The
tcwp. limit is based on State regulations and a letter cited in the rationale.
Outfall: 002 | Receiving Water: Kinley Creek
Treatment: Not specified.
Amount/Components:
21.84 MGO of noncontact cooling water and storm water.
Parameter
DO
Flow
P«
Tcflp.
Limitations
Monthly
Average
N/A
N/A
N/A
Report MGD
N/A
H/A
H/A
H/A
Daily
Maximum
N/A
Report
N/A
Report MGD
N/A
Report
N/A
90.000000 F
Other
5.0 mg/l min.
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/week
1/day
continuous
1/day
Sample Type
grab
continuous
record
continuous
Conditions were continued from the previous permit.
the use ol Sint^ebheoScals for once through noncontact cooling water,
bloMdown water, and air washer water.
cooling water, boiler
Abstract Date: 06/02/93
Effective Date: 12/01/90
Expiration Date: 09/30/94
Page: 336
-------
Facility Name: Homestake Mining Company Permit Numbep. SD0000043
Facility Description: Gold mining operation SIC Code- 1041
.. Monitoring • WET WET Testing Multiple
£1?]* ELGs Wfs BP/ °nLy Limits Only Categories
Basis. - J. J. I I -_ .
Storm WQ B,-0
Special BMPs Water , Sediment Survey Survey TRES MDLs
Conditions: - - - / / /
— — — i _ i ±
Tiered
Limits Other
- I
Monitoring Other
I I
Abstract Information:
Complete; Outfalls 001 and 002.
Outfall: 001 | Receiving Water: Gold Run Cr. to Uhitewood Cr. | Treatment: Not discussed.'
Amount/Components :
3.6 MGD/AU discharges from wastewater treatment facility
Parameter
Ag (TR)
As (TR)
Cd (TR)
Chronic WET
CN (WAD)
Cr (TR)
Cu (TR)
Flow
Hardness
Hg (TR)
NH3-N
Ni (TR)
Pb (TR)
pH
Temp.
TSS
Zn (TR)
Limitations
Monthly
Average
N/A
0.035000 mg/l
N/A
0.335000 mg/l
N/A
Report mg/l
N/A
N/A
N/A
0.127000 mg/l
N/A
Report mg/l
N/A
0.130000 mg/l
N/A
2500.000000 gpm
N/A
Report mg/l
N/A
0.001300 mg/l
N/A
N/A
N/A
Report mg/l
N/A
0.115000 mg/l
N/A
N/A
N/A
N/A
N/A
10.000000 mg/l
N/A
Report mg/l
Daily
Maximum
N/A
0.061000 mg/l
N/A
0.586000 mg/l
N/A
Report mg/l
N/A
N/A
N/A
0.222000 mg/l
N/A
Report mg/l
N/A
0.227000 mg/l
N/A
N/A
N/A
Report mg/l
N/A
0.002300 mg/l
N/A
N/A
N/A
Report mg/l
N/A
0.201000 mg/l
N/A
N/A
N/A
75.000000 F
N/A
30.000000 mg/l
N/A
Report mg/l
Other
See below
3600 gpm daily avg.
Seasonal; see below
Seasonal; see below
Variable; see below
Monitoring Requirements
Frequency
1/week
1/week
1/month
1/quarter
1/week
1/month
1/week
I/day
1/week
1/week
1/day
1/month
1/week
1/day
1/day
1/day
1/month
Sample Type
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
instantaneous
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
instantaneous
instantaneous
24hr fw composite
24hr fw composite
Limitations/Monitoring Basis:
Th! uf? i'T"* iS bafed °n BPJ and is intended to Prevent WQS exceedances in Whitewood Creek. The pH limits are
established as not less than 6.5 su nor greater than 8.8 su from Oct. 1 through Apr. 30 and not less than 6 5su nor
greater than 8.3 su from May 1 through Sept. 30. In addition, if the effluent pHviolates these limits, instream
Page: 337
-------
acUity Name: Homestake Mining Company
Permit Number: SD0000043
acUfty Description: Gold mining operation
SIC Code: 1041
monitoring is required, and the PH of the effluent must not exceed the ambient pH of the water. The pH limits are
wriS wer ffS the previous permit and are intended to prevent WQS exceedances ,n Whitewood Creek. The flow
timitsHore negotiated with the facility. Temp, limits are carries over fromthe previous permit; if the temp, is
than ^5 degrees F, the temp, of Whitewood Creek must be monitored. The discharge must not cause a temp
'
the NH3-M limits The limits for metal and CM were developed based on site specific WQ criteria for the
str\Z! A .i£le m™ baUnce approach was used to calculate the limits based on average monthly discharge rates of
5 5 cfs and 4.5 cfs for the 7025 stream flow. A chronic WET limit of no toxieity must be met by 1/1/94. This time
fraM has been determined to be the maximum allowable as per the permit writers judgement. Chronic WET testing must
KnduSted In accordance with EPA guidance manuals' and regional policy; 55% eff uent is specified based on stream
flow. fittest ng must be conducted within 4 weeks where toxieity is evident. Monitoring requirements may be reduced
Whcrenal metals and for hardness. These requirements are established to monitor possible impacts to water quality
and are based on the permit writer's judgement. _ ____==__=__==__=_=_==_™«™-~>=— -=——==
Dutfall: 002 | Receiving Water: Gold Run Cr. to Whitewood Cr.
Treatment: Not discussed.
Amount/Components:
Unspecified amount of non-contact cooling water from air compressors
Parameter
Flow
OSG
Tosp.
TSS
Limitations
Monthly
Average
H/A
N/A
N/A
H/A
N/A
N/A
N/A
N/A
N/A
30.000000 mg/l
Daily
Maximum
N/A
N/A
N/A
10.000000 mg/l
N/A
N/A
N/A
N/A
N/A
N/A
Other
See below
Between 6.0 su and 9
.0 su
Shall not exceed 75
deg F
Monitoring Requirements
Frequency
1/month
1/quarter
1/month
1/month
1/month
Sample Type
instantaneous
grab
instantaneous
grab
grab
Un "he°U«ritt for TSS, pH"and O&G are based on the previous permit. With the exception of O&G, the basis of these
limits was not discussed. The O&G limit is based on State WQS, and has two components; the numeric limit above, and
a narrative"qu rement prohibiting discharges that result in a visible sheen on the surface of the stream. Visual
SonitoHng for the O&G sheen is required 1/month. If, however, a visible sheen is observed a grab sample must be
obtained and analyzed according to prescribed procedures. Monitoring conditions are consistent with the previous
permit. ,=_==^==_=_=_=—=
in addition to the special monitoring requirements described above, the permit contains several other special^
condit ons? A requirement for monthly monitoring of metals and CN at two locations in the receiving stream is
spw f ed io evaluate the impact of the discharges. If results of chronic WET testing indicate toxic,ty a TRE wiU
Kqiircd in accordance with specific protocols established in the permit A requirement is included for daily
inspect on of the wastewater treatment facility. The inspection will include an eva uation of the discharge or
pStwtial for discharge, and operation and maintenance activities. A log of all activities must be maintained. The
facility must monthly report the quantity of phosphoric acid, sulfunc acid, and soda ash used. Other than
described above, the basis of these special conditions was not provided.
Effective Date: 10/01/9E
Expiration Date: 09/30/96
Abstract Date: 04/30/93
Page: 338
-------
Facility Name:
U.S. Airforce, Ellsworth Base
Facility Description:
Maintenance of airplanes and equipment, misc. industrial processes
Abstract Information:
Partial; Outfalls 001 (representing 002 and 003) and 005.
Receiving Water: Unamed trib. to Box Elder
Amount/Components;
Unspecified amount of treated runoff from southwest area of airfield
Parameter
Acute WET
BETX
BODS
Naphthalene
O&G
PH
Surfactants
Monthly
Average
N/A
N/A
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
N/A
N/A
N/A
N/A
N/A
Limitations
Daily
Maximum
N/A
N/A
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
10.000000 mg/l
N/A
N/A
N/A
1.000000 mg/l
. — .
Other
See below
See below
See below
Between 6.0 su and 9
.0 su
"
Monitoring Requirements
Frequency
once
1/quarter
1 /month
1/quarter
1 /month
1 /month
1 /month
Sample Type
grab
grab
grab
grab
grab
grab
grab
Limitations/Monitoring Basis:
^^^^^^^^^^^Jfff^"^^!^
Ss'!KE!li«^
Sa^sSwfc%5®TsSS^^i«LHsSx^
. The PN, OM,
Receiving Water; Unnamed tributary-Box Elder Cr
Amount/Components :
.O HGD of sewage treatment plant effluent.
Parameter
Acute WET
BODS
FC
Limitations
Monthly
Average
N/A
N/A
N/A
30.000000 mg/l
N/A
1000.000000
Daily
Maximum
N/A
N/A
N/A
N/A
N/A
2000.000000
Other
See below
45 mg/l weekly avg.
Units: #/100 ml
Frequency
1/quarter
3/week
3/week
Sample Type
6hr
6hr
fw composite
fw composite
grab
Page: 339
-------
Facility Nome: U.S. Airforce, Ellsworth Base
Permit Number: SD0000281
...«.«^
Flow
OSG
P«
TSS
N/A
999.000000 HGD
N/A
N/A
N/A
30.000000 mg/l
N/A
999.000000 HGD
N/A
10.000000 mg/l
N/A
N/A
N/A
N/A
See below
6.0 su-9.0 su; see b
elow
45 mg/l weekly avg.
continuous
1/month
continuous
3/week
SIC Code: 9711
5
record
grab
record
6hr fw composite
1/monti
is found.
required
In additon
for effluent
' «£•» ^sri-i-ssirtssi".; rs .s^'Si.- M
^^
2 "nse=utwe|^s^,?hbe taken and analyzed for Bc3D5, TSS and PH at the same frequency as
influent sa'Vle!IvlllJiHbL*^sa^s?atled (1/31/91), PH sampling may be performed by
monitoring. UntU a P^^^^^nc eased to a 3/weeV frequency to be consistent H,th other
h. ±inlng'maonnitoringncond^ons are consistent with^h
Snd^nalyzed0Iemi-a:r^aUynforeAs (T). cd (T) Cr "){,=" "^.["i^ViripA'twic Jollutan?"; <3) The permittee
C&rSaS Plant influent (Outfall 005) mus be evaluated annua ly fo all EWM: x^ ^ ^ ^
must inspect the treatment systems for outfalls 001 through ""? « l t (4) A TR| must be conducted if determined
sttus and operation and n«^t«««%lic!w'*'^e™???e5? and°«f Tte permittee must develop and implement and
necessary by EPA; the format and content are sPe^f^' «*e^of non-domestic wastes from the sewage treatment
' TSram must ?nc ude are provided. ?he basis of these conditions was not described.
plant;
IEffect ive Date: 10/01/90
Expiration Date: 09/30/95
Abstract Date: 04/30/93
Page: 340
-------
Facility Name: T & R Electric Supply Co.,Inc.
Facility Description: Rebuilding and reconditioning electric transformers
Permit Number: SD0025437
Limit
Basis:
Special
Conditions:
SIC Code: 4931
ELGs
BMPs
WQSs
J.
Storm
Water
BPJ
J.
Sediment
Monitoring
Only
WQ
Survey
WET
Bio
Survey
Abstract Information:
Complete: Outfall 001
WET Testing
Only
-
TRES
-
Multiple
Categories
-
MDLs
I
Tiered
Limits
z
Monitoring
.1
Other
J.
Other
I
Outfall: 001
Receiving Water: Unnamed trib. to Bachelor Cr.
Treatment: Sed
Amount/Components:
Unspecified amount of treated storm water runoff from transformer storage and rebuilding areas
Parameter
Flow
O&G
PCBs (T)
PH
TSS
Limitations
Daily
Average
N/A
Report MGD
N/A
N/A
N/A
0.010000 mg/l
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
Report MGD
N/A
10.000000 mg/l
N/A
0.015000 mg/l
N/A
N/A
N/A
45.000000 mg/l
Other
See below
See below
See below
Between 6.0 su and 9
.0 su
See below
Monitoring Require
Frequency
See below
See below
See below
See below
See below
Sam
tc
24hr f
24hr f
24hr f
totalizer
grab
Limitations/Monitoring Basis:
over from the previous permit and is ba
-------
Facility Hume: GE, Selmor _ — .
"Facility Description: Fabricates and assembles power distribution busway, switchboard manufa hu, uoae. oo,. ,
Monitoring
Limit ELGs WQSs BPJ only
Basis: J. J. - *
Storm WQ
Special BMPs Water Sediment Survey
Conditions: r. - - -
WET WET Testing
Limits Only
J. -
Bio
Survey TRES
Multiple Tiered
Categories Limits Other
- - *•
MDLs Monitoring Other
- - *
[Abstract Information:
— r -—. ~ r™" 0 nroot 1 Treatment: ChOx/Pt, Sed, Neut, Fil
Outfall: 001 | Receiving Water: Cypress Creek I
^""o'lT^ofindustrial vmstewater from electroplating lines not using cyanide and those using cyanide, metal prep line
B^id burn off OVen —
Parameter
Ag
Cd
Chronic WET
Cr
CU
Flow
HH3
Ni
Pb
PH
TRC
nos
Zn
,
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
0.750000 mg/l
N/A
Report MGD
N/A
Report mg/l
N/A
N/A
N/A
0.120000 mg/l
N/A
Report
N/A
N/A
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
0.030000 mg/l
N/A
0.150000 mgl
N/A
N/A
N/A
1.000000 mg/l
N/A
1.130000 mg/l
N/A
Report MGD
N/A
Report mg/l
N/A
3.980000 mg/l
N/A
0.690000 mg/l
N/A
Report
N/A
0.540000 mg/l
N/A
2.130000 mg/l
N/A
1.000000 mg/l
Other
See below
Between 6.0 su and 9
.0 su
See below
Monitoring Requirements
Frequency
1/week
1/quarter
1/quarter
1/quarter
1/week
cont i nuous
1/week
1/quarter
1/week
1/week
1/week
1/quarter
1/quarter
Sample Type
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
instantaneous
grab
24hr fw composite
24hr fw composite
grab
grab
24hr fw composite
24hr fw composite
Limitations/Monitoring Basis: the Cr daily max. The previous permit limits for
Previous permit limits are retained for Cd, Pb, ph. and Zn, and the cr erauy max. m p 433).HTTO liml-ts are also
cWern, the past permit monitoring "^itions of 1/week were ret a, ned "here they ar ^ ^.^
Page: 342
-------
Facility Name: GE, Selmer
Permit Number: TN0000353
Facility Description: Fabricates and assembles power distribution busway, switchboard manufa
SIC Code: 3613
specified to allow for the quantification of pollutant loads. Ammonia monitoring may be deleted in one year.
Outfall: 002
Receiving Water: Cypress Creek
Treatment: None
Amount/Components:
0.02 HGD of noncontact cooling water.
Parameter
Flow
PH
Temp.
TRC
Limitations
Monthly
Average
N/A
Report HGD
N/A
Report
N/A
Report
N/A
N/A
Daily
Maximum
N/A
Report MGD
N/A
Report
N/A
Report
N/A
0.540000' mg/l
Other
Between 6.0 su and 9
.0 su
See below
Monitoring Requirements
Frequency
1/week
1/week
1/week
1/week
Sample Type
instantaneous
grab
grab
grab
Limitations/Monitoring Basis:
The limit for TRC is WQ-based as calculated by a mass balance using EPA's instream protection value of 0.019 mg/l
TRC for fish and aquatic life. The pH limitations and monitoring requirements and the flow monitoring conditions
were retained from the previous permit. The discharge must not cause the temperature change in Cypress Creek to
exceed 3 degrees C relative to an upstream control point; the discharge must not cause the temperatureof the creek
to exceed 30.5 degrees C; and the maximum rate of temperature change in the creek due to the discharge must not
exceed 2 degrees C per hour.
Outfall: 01A
Receiving Water: Internal via Outfall 001
Treatment: See Outfall 001
Amount/Components:
Average 0.117 MGD consisting of wastewater from electroplating line using cyanide
Parameter
CN (T)
Limitations
Monthly
Average
N/A
0.650000 mg/l
Daily
Maximum
N/A
1.200000 mg/l
Other
Monitoring Requirements
Frequency
1/week
Sample Type
grab
Limitations/Monitoring Basis:
The CN (T) limitations are based on ELGs in 40 CFR Part 433 because they are more stringent than the WQSs.
Measurements must be taken immediately after treatment and before dilution with other streams, consistent with ELGs.
special Conditions Basis:
Schedules of compliance with Cu, Ag, TRC, and WET limits are specified which require the submission of plans within
3 months, beginning construction with in 6 months, and compliance within 18 monthsi; those compliance schedules are
provided because new limits are much more stringent than those in the previous permit. The compliance deadlline
was, according to the state, the most expeditious date by which compliance could be achieved and coincides with the
date by which the facility plans to begin routing their wastewater to the sanitary sewer. The permit also specifies
that signs containing specific outfall identification information must be installed.
Effective Date: 09/30/92
Expiration Date: 04/01/94
Abstract Date: 05/07/93
Page: 343
-------
Facility Name: Erwin National Fish Hatchery
Permit Number: TN0004677
Facility Description: Fish farm operation, rearing station for trout
SIC Code*. 0921
Limit
Basis:
ELGs
WQSs
I
BPJ
Monitoring
Only
J.
UET
Limits
WET Testing
Only
Multiple
Categories
Tiered
Limits
Other
I
Special
Conditions:
BHPs
Storm
Water
Sediment
WQ
Survey
Bio
Survey
TRES
MDLs
Monitoring
Other
I
Abstract Information:
Complete; Outfall 001.
Outfall: 001 | Receiving Water: Tate Spring Branch
Treatment: None specified.
Amount/Components:
1.73 HGO of industrial wastewater discharge from fish farm
Parameter
pH
SS
TSS
Limitations
Monthly
Average
N/A
N/A
N/A
Report mg/l
N/A
Report mg/l
Daily
Maximum
N/A
N/A
N/A
Report mg/l
N/A
Report mg/l
Other
Between 6.5 su and 8
.5 su
Monitoring Requirements
Frequency
1/month
1/month
1/month
Sample Type
grab
grab
grab
Limitations/Monitoring Basis:
Previous permit limits and monitoring conditions have been retained. The limit for pH has become more stringent
based on State WQSs.
Special Conditions Basis:
Within 90 days of permit issuance, the permittee is required to submit a report containing amounts and frequencies
of application of biocides or other chemical agents. This requirement is retained from the previous permit.
Additionally the report must include any water quality parameter monitoring. Pertinent data must also be reported
on a quarterly basis. The permit also specifies that signs containing specific outfall identificationinformation
must be installed. Other than noted above, the basis of these special conditions was not described.
Effective Date: 06/30/92
Expiration Date: 06/29/97
Abstract Date: 05/07/93
Page: 344
-------
Facility Name: TVA, Raccoon Mt Pumped-Storage
Permit Number: TN0031631
Facility Description: Hydroelectric power generating plant, capacity 1530 HW
SIC Code: 4911
Limit
Basis:
ELGs
WQSs
J.
BPJ
I
Monitoring
Only
J.
WET
Limits
WET Testing
Only
Multiple
Categories
Tiered
Limits
Other
I
Special
Conditions:
BMPs
I
Storm
Water
I
Sediment
WQ
Survey
Bio
Survey
TRES
MDLs
Monitoring
J.
Other
I
Abstract Information:
Partial; Outfall 003 is the only one of four outfalls with limitations.
Outfall: 003
Receiving Water: Nickajack Reservoir
Treatment: API
Amount/Components:
Average 1.584 MGD from station sump (oil interceptor and transformer cooling wastewater) and 0.0404 MGD from dewatering
of draft tubes and tunnel
Parameter
Flow
O&G
TSS
Limitations
Monthly
Average
N/A
Report MGD
N/A
15.000000 mg/l
N/A
30.000000 mg/l
Daily
Maximum
N/A
N/A
N/A
20.000000 mg/l
N/A
100.000000 mg/l
Other
Monitoring Requirements
Frequency
1 /quarter
1/quarter
1 /quarter
Sample Type
estimate
grab
grab
Limitations/Monitoring Basis:
Limts are retained from the previous permit based on anti-backsliding and BPJ of the impacts of these discharges on
the receiving stream. The state has identified potential for leaks and spills and cites a NOV concerningoil and
foam discharges.
Special Conditions Basis:
The permittee is required to develop and implement a BMP plan no later than one year after the effective date of the
permit; the plan must include baseline measure as well as specific measures for the environmentally sound control of
Zebra mussels. The BMP plan is being required due to concerns about the impacts of mussel control plans. The BMP
plan and its submittal date were based on an agreement with the facility. The permittee is also required to develop
and implement a SWPPP no later than one year after the permit effective date. This plan is being required due to
concerns of PCBs and oil and grease contamination from transformer yards and equipment storage. The permit has the
requirement to monitor for PCBs at least 1/year in storm water discharges from areas with PCB-containing equipment.
This frequency has been determined to be appropriate based on the permit writers judgement of the potential impacts
that PCBs may have on receiving streams.
Effective Date: 09/30/92
Expiration Date: 09/29/97
Abstract Date: 05/07/93
Page: 345
-------
Facility Home: AUCOA North Plant Permit Number: TN0067199
Facility Description: Aluminum fabrication with hot and cold rolling SIC Code: 3353
Monitoring
Limit ELGs WQSs BPJ Only
Basis: ; J. I I
Storm WQ
Special BHPs Water Sediment Survey
:ooditions: j. — — -
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
J. - - I J-
Bio
Survey TRES MDLs Monitoring Other
- - J. - J.
Abstract Information:
Partial; Outfalls 001 (001A and 001B for abstracting purposes), 01A, 01N (representing 01S and 01E) and 007.
Outfall: 001A | Receiving Water: Duncan Creek | Treatment: API + Sed
Amount/Components :
1.0 HOD of cooling water blowdown, boiler blowdown, softener backwash, once through noncontact cooling water and plant
site surface runoff.
Parameter
CB005
Chronic WET
DO
Flow
HH3-N
OSQ
PH
TRC
Limitations
Monthly
Average
N/A
32.500000 mg/l
N/A
N/A
N/A
N/A
N/A
Report HGD
N/A
0.760000 mg/l
N/A
Report mg/l
N/A
N/A
N/A
0.011000 mg/l
Daily
Maximum
N/A
52.000000 mg/l
N/A
N/A
N/A
N/A
N/A
Report HGD
N/A
1.500000 mg/l
N/A
Report mg/l
N/A
N/A
N/A
0.019000 mg/l
Other
See below
5.0 mg/l min
Between 6.5 su and 8
.0 su
Monitoring Requirements
Frequency
1/week
1/2 months
1/week
continuous
1/week
1/week
continuous
5/week
Sample Type
24hr fw composite
24hr fw composite
grab
recorder
grab
grab
recorder
grab
Limitations/Monitoring Basis:
Limits above apply from Hay 1 through Oct. 31. CBOD5, HH3, and DO limitations are seasonal WQ-based limits as
calculated from State modeling of the receiving stream. CBOD5 replaces BODS as a limited parameter in accordance
with revised modelling. TRC and pH limits are WQ-based; special conditions apply to TRC and pH as discussed below.
TRC monitoring is set at 5/week because of difficulties posecl by weekend sampling; this frequency is deemed
reasonable since fluctuations are not expected in production or operations. TSS, CN, tetrachloroethylene, and Cr
limits and monitoring requirements are discontinued because these parameters are either not containedin wastewaters,
or not present or present in in low levels in the discharge; TSS and Zn requirements are discontinued because these
parameters are categorical and are monitored at the internal Outfall 01A. The O&G limit has been discontinued
(monitoring is still required) because ELGs are being applied at 01A. Chronic WET requirements are described at
Outfall 007. Other than described above, monitoring conditions are based on the previous permit.
Outfall: 001B | Receiving Water: Duncan Creek | Treatment: API + Sed
Amount/Components: , ,
1.0 HGO of cooling water blowdown, boiler blowdown, softener backwash, once through noncontact cooling water and plant
site surface runoff.
Parameter
CBOD5
Chronic WET
Limitations
Monthly
Average
N/A
67.500000 mg/l
N/A
N/A
Daily
Maximum
N/A
108.000000 mg/l
N/A
N/A
Other
See below
Monitoring Requirements
Frequency
1/week
1/2 months
Sample Type
24hr fw composite
24hr fw composite
Page: 346
-------
Facility Name: ALCOA North Plant Permit Number: TN0067199
Facility Description: Aluminum fabrication with hot and cold rolling SIC Code: 3353
DO
Flow
NH3-N
O&G
pH
TRC
N/A
N/A
N/A
Report HGD
N/A
1.100000 mg/l
N/A
Report mg/l
N/A
N/A
N/A
0.011000 mg/l
N/A
N/A
N/A
Report MGD
N/A
2.200000 mg/l
N/A
Report mg/l
N/A
N/A
N/A
0.019000 mg/l
5.0 mg/l min
Between 6.5 su and 8
.0 su
1/week
continuous
1/week
1/week
continuous
5/week
grab
recorder
grab
grab
recorder
grab
Limitations/Monitoring Basis:
These limitations apply from November 1 through April 30. See limitations/monitoring basis for Outfall 001A.
Outfall: 007 Receiving Water: Ditch to Russell Branch j Treatment: Not specified.
Amount/Components:
Unspecified amount of landfill leachate and storm water.
Parameter
Chronic WET
Flow
NH3-N
O&G
PCBs (T)
pH
Limitations
Monthly
Average
N/A
N/A
N/A
Report MGD
N/A
0.760000 mg/l
N/A
N/A
N/A
0.000001 mg/l
N/A
N/A
Daily
Maximum
N/A
N/A
N/A
Report MGD
N/A
1.500000 mg/l
N/A
20.000000 mg/l
N/A
N/A
N/A
N/A
Other
See below
Seasonal; see below
Detection level 0.5
ug/l
Between 6.5 su and 8
.0 su
Monitoring Requirements
Frequency
1/2 months
continuous
1/ueek
1/week
1/week
continuous
Sample Type
24hr fw composite
recorder
grab
grab
grab
recorder
Limitations/Monitoring Basis:
NH3 limits are seasonal with the above limits being applicable from Hay 1 through Oct. 31. From Nov. 1 through Apr.
30, limits are 1.1 mg/l monthly avg. and 2.2 mg/l daily max. These limits are established based on state modelling"
of the receiving stream. PCBs and pH limits are based on State WQS. The O&G limit is based on the past permit
Chronic WET testing must be conducted to determine the LC50 and NOEL; testing is required in accordance with EPA
guidance manual procedures. Limits of no toxicity are based on no instream dilution or 100% effluent. Monitoring
may be reduced to 1/6 months after 1 year if no lethality is demonstrated.
Outfall: 01A Receiving Water: Internal to Outfall 001 | Treatment: None specified.
Amount/Components:
Unspecified amount of industrial wastewater from continuous sheet casting spent lubricant and solution heat treatment
contact cooling water.
Parameter
Al
COD
Limitations
Monthly
Average
N/A
Report mg/ I
N/A
Report mg/l
Daily
Maximum
N/A
Report mg/ I
N/A
Report mg/l
Other
Monitoring Requirements
Frequency
1/week
1/week
Sample Type
grab
grab
Page: 347
-------
Facility Name: ALCOA North Plant Permit Number: TN0067199
Facility Description: Aluminum fabrication with hot and cold rolling SIC Code: 3353
Fl
Flow
NH3
OSG
Pb
P«
TSS
Zn
N/A
Report mg/l
N/A
Report MGD
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report su
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report MGD
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report su
N/A
Report mg/l
N/A
Report mg/l
1/week
continuous
1/week
1/week
1/week
1/week
1/week
1/week
grab
recorder
grab
grab
grab
grab
grab
grab
Limitations/Monitoring Basis:
The State has determined that aluminum forming ELGs do not apply; rather, nonferrous metals manufacturing (40 CFR
Part 421; Subpart C) are more appropriate. However, application of limitations were determined to be inappropriate
because the "discharge is cooling tower mist condensate and blowdown water" which are part of recirculation, rather
than "process wastewater." Monitoring is set forth for the parameters contained in 40 CFR Part 421.
Outfall: 01H | Receiving Water: Duncan Creek | Treatment: None
Amount/Components :
Unspecified amount of discharges occurring only during certain rainfall events and containing less than 10% of the dry
Heather flows described for 001
Parameter
Acute WET
BOOS
Flow
NH3
OSG
pH
TRC
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
N/A
N/A
Report mg/l
N/A
Report MGD
N/A
Report mg/l
N/A
Report mg/l
N/A
N/A
N/A
Report mg/ 1
Other
See below
See below
See below
See below
See below
Report rain, and max.
s.u.
See below
Monitoring Requirements
Frequency
once
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
Sample Type
grab
grab
instantaneous
grab
grab
grab
grab
Limitations/Monitoring Basis:
Samples are to be collected within 30 minutes of initiation of flow during a storm event that is greater than 0.1
inch and that occurs at least 72 hours after any previous storm event of 0.1 inch or greater. The pH analyses are
to be performed within 24 hours of sample collection. This is because pH data shows no fluctuations outside the
allowable pH range either in the initial or 24hr reading; also cited are high costs of installing equipment,
infrequent discharges, and unlikely WQ impacts. Acute WET testing is to be conducted within 90 days of the
completion of the outfall monitoring program to establish the LC50 value. The permittee is required to conduct one
48-hr static toxicity test on two appropriate test species on samples of final effluent following a period of at
least 2 days of no discharge from the outfalls. If there is no toxicity found from this test, no further testing
will be required. No effluent limits are established at this time because this outfall has no dry weather flows;
TRC, NH3, and BODS monitoring requirements are included because process wastewaster and spills may contaminate the
storm water. Monitoring requirements are established consistent with State storm water regulations and is required
during periods of continuous discharge. The basis of the remaining monitoring conditions was not described.
Page: 348
-------
Facility Name: ALCOA North Plant
Permit Number: TN0067199
Facility Description: Aluminum fabrication with hot and cold rolling
SIC Code: 3353
Special Conditions Basis:
evaluation study, due 6 months
study. Compliance with DO limits at 001 are established to coincide 8 ° tate W°val of the
i^xsf'isn.-suy&f'iSzz&s,
•
£?*! * in? he NOEL at °07 was attributed to
"
"incl"d?s with Completion of the
l"0"^3 and ™^emsr* »t within
l6VfU ?f °'5 ug/l and °-1 m9/^ are
?S| leVe S are cons''d^ed compliant.
lnf°™at)0n must be installed.
ffective Date: 09/30/92
Page: 349
-------
FueiHtv Name: International Paper Company . —
I " SIC Code: 2611 J
Monitoring
Limit ELGs WQSs BPJ Only
Basts: J. J. - -
Storm UQ
Special BHPs Water Sediment Survey
Conditions: - J- - *
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
Survey TRES HDLs Monitoring Other
I - J- - ±
^Tiutar^tfalls 00! (designated A and B for abstracting purposes) and 101 . ,
Outfall* 001A | Receiving Water: Bakers Slough I Treatment. AL
AffloUnt/5C8
-------
Facility Name: International Paper Company
Permit Number: TX0000167
Facility Description: Pulp and paper mill
SIC Code: 2611
Flow
PH
TSS
N/A
Report MGD
N/A
N/A
N/A
60.000000 mg/l
N/A,
Report HGD
N/A
N/A
N/A
30.000000 mg/l
see below
Between 6.0 su and 9
.0 su
23598 Ib/d, annual a
vg.
cont.
1/day
1/day
record
grab
24hr fw comp
Limitations/Monitoring Basis:
This outfall established for abstracting purposes represents limitations effective from June 4, 1993 through the
expiration date. Annual avg. limits of 9456 Ib/d BODS, 23598 Ib/d TSS, and 7320 ug/d 2378-TCDD equivalents are
imposed, where the annual avg. is calculated as previously described. As with 001A, limitations are ELG- and WQ-
based as incorporporated from the past permit in accordance with anti-backsliding and consistent with the State
permit. Note that the 2378-TCDD annual avg. limitation was not established in the past permit and its basis was not
described. The remaining monitoring conditions and their basis are the same as described at 001A.
Outfall: 101
Receiving Water: Internal outfall via 001
Treatment: AL
Amount/Components:
Unspecified amount of treated process wastewater
Parameter
BOD5
Flow
TSS
Limitations
Average
N/A
Report mg/l
N/A
Report HGD
N/A
Report mg/l
Maximum
N/A
Report mg/l
N/A
Report HGD
N/A
Report mg/l
Other
Monitoring Requirements
Frequency
3/week
cont.
3/week
Sample Type
24hr fw comp
record
24hr fw comp
Limitations/Monitoring Basis:
Monitoring requirements are incorporated from the past permit.
Special Conditions Basis:
Storm water runoff (outfalls not identified) must meet limitations of 15 mg/l O&G, 200 mg/l COD, and a pH between
6.0 su and 9.0 su. Sludge monitoring via EPA method 1613 must be conducted within 90 days and 2/year thereafter for
the 2378-TCDD equivalents set forth in EPA guidance. The permit contains a 2,3,7,13-TCDD reopener clause, whereby
the permit may be reopened to update limits corresponding to changes in State WQSs or other conditions for 2,3,7,8-
TCDD. The permit also contains a ULA opener clause to'incorporate any changes necessary to comply with the Sulphur
River Basin Water Quality Management Plan or with the Texas WQSs. Specific MLs are provided for TCDD equivalents.
Stream monitoring 1/day for the dailyavg., daily min., and daily max. flow are required using USES data. Stream
monitoring for dialy max. and daily min. DO'is also required in accordance with specific locations and procedures.
DO and stream flow are to be reported on DMRs. Requirements are specified to develop and submit, within 60 days, a
fish tissue monitoring plan. A 1/year monitoring frequency, 3 specific species, and the analysis of 2,3,7,8-TCDD
equivalents for 5 adult fish/species are required plan components; the plan must be implemented within 1 year.
Other special requirements*involve discharge summary reports development and specific testing. The basis for these
conditions was not described.
Effective Date: 11/12/91
Expiration Date: 11/11/96
Abstract Date: 04/13/93
Page: 351
-------
Facility Name: Texas Eastman Company Permit Number: TX0000949
Factttty Description: Organic chemical manufacturing. SIC Code: 2869
Monitoring
Limit ELGs WQSs BPJ Only
Basis: i i i -
Storm WQ
Special BHPs Water Sediment Survey
Conditions: ; ; i _
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
- J. - - 1
Bio
Survey TRES MDLs Monitoring Other
— — - J. -
Abstract Information:
Partial; 001, 002 (A and B) created for abstract purposes, 003, 004.
Outfall: 001 | Receiving Water: Sabine River | Treatment: Not described.
Amount/Components:
19.6 MOO dally avg. of water intake, and misc low contamination potential plant and storm water runoff discharges.
Parameter
Flow
ptl
TOC
Limitations
Daily
Average
H/A
Report HGD
M/A
N/A
H/A
N/A
Daily
Maximum
H/A
Report MGD
N/A
N/A
N/A
50.000000 mg/l
Other
6.0 su inst. min, 9.
0 su
Monitoring Requirements
Frequency
1/day
1/day
1/day
Sample Type
• estimate
grab
grab
Limitations/Monitoring Basis:
According to the fact sheet, the bases of the limits were not changed from the previous permit. WET monitoring
requirements Include reporting endpoints of fecundity, lethality & growth, for Ceriodaphnia dubia and Pimephales
promelas in accordance with Method 1000.0 and 1002.0 and several other specifications outlined in the permit. The
permit recjuires accelerated WET testing in the instance of lethality or non-ethal effects at 16% or lesser effluent
concentrations. Permit provides WET reporting sheets.
Outfall: 002A | Receiving Water: Sabine River | Treatment: AS
Amount/Components:
Unspecified amount of process, storm water, sanitary sewage, and demineralizer wastewater.
Parameter
1,1,1-Trichloroet
hane
1,1,2-Trichloroet
hane
1,1-Dichloroethan
e
1,1-Dlchloroethyl
ene
1,2,4-Trlchlorobe
nzone
1,2-Dichtorobcnze
ne
1,2-Dichloroothan
e
1,2-Dlchloropropa
ne
1,2-Trans-Dlchlor
oothylono
Limitations
Dai ly
Average
0.760000 Ib/d
N/A
0.760000 Ib/d
M/A
0.790000 Ib/d
N/A
0.580000 Ib/d
N/A
2.450000 Ib/d
N/A
2.770000 Ib/d
N/A
2.450000 Ib/d
N/A
5.510000 Ib/d
N/A
0.760000 Ib/d
N/A
Daily
Maximum
1.950000 Ib/d
N/A
1.950000 Ib/d
N/A
2.130000 Ib/d
N/A
0.900000 Ib/d
N/A
5.040000 Ib/d
N/A
5.870000 Ib/d
N/A
7.600000 Ib/d
N/A
8.290000 Ib/d
N/A
1.950000 Ib/d
N/A
Other
Monitoring Requirements
Frequency
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
Sample Type
24hr fw comp
24hr fw comp
24hr fw comp
24hr fw comp
24hr fw comp
24hr fw comp
24hr fw comp
24hr fw comp
24hr fw comp
Page: 352
-------
[Facility Name: Texas Eastman Company " " ' — ——=——-———————-——«__
• PenillL Number; 'ixormnPIP
k [Facility Deseriptit
W 1,3-Dichlorobenze
ne
1,3-Dichloroprope
ne
1,4-Dichlorobenze
ne
2,4-Dichloropheno
2,4-Oimethylpheno
2,4-Dim'trophenol
2,4-Dinitrotoluen
e
2,6-Dinitrotoluen
e
2-Chlorophenol
2-Nitrophenol
3,4-Benzof luorant
hene
4,6-Dinitro-o-cre
sol
|4-Nitrophenol
Acenaphthene
Acenaphthylene
Acrylonitrile
Anthracene
Benzene
Benzo (a) anthrac
ene
Benzo (a) pyrene
Benzo (k) fluoran
thane
Bis (2-ethylhexyl
) phthalate
Carbon tetrachlor
ide
CBOD5
Chlorobenzene
m: Organic chemical
1.120000 Ib/d
N/A
1.040000 Ib/d
N/A
0.540000 Ib/d
N/A
1.410000 Ib/d
N/A
0.650000 Ib/d
N/A
2.560000 Ib/d
N/A
4.070000 Ib/d
N/A
9.190000 Ib/d
N/A
1.120000 Ib/d
N/A
1.480000 Ib/d
N/A
0.830000 Ib/d
N/A
2.810000 Ib/d
N/A
2.590000 Ib/d
N/A
0.790000 Ib/d
N/A
0.790000 Ib/d
N/A
3.460000 Ib/d
N/A
0.790000 Ib/d
N/A
1 .330000 Ib/d
N/A
0.790000 Ib/d
N/A
0.830000 Ib/d
N/A
0.790000 Ib/d
N/A
3.710000 Ib/d
N/A
0.650000 Ib/d
N/A
546.000000 Ib/d
N/A
0.540000 Ib/d
N/A
manufacturing.
1.590000 Ib/d
N/A
1.590000 Ib/d
N/A
1.010000 Ib/d
N/A
4.040000 Ib/d
N/A
1.300000 Ib/d
N/A
4.430000 Ib/d
N/A
10.270000 Ib/d
N/A
23.090000 Ib/d
N/A
3.530000 Ib/d
N/A
2.490000 Ib/d
N/A
2.200000 Ib/d
N/A
9.980000 Ib/d
N/A
4.470000 Ib/d
N/A
2.130000 Ib/d
N/A
2.130000 Ib/d
N/A
8.720000 Ib/d
N/A
2.130000 Ib/d
N/A
4.900000 Ib/d
N/A
2.130000 tb/d
N/A
2.200000 Ib/d
N/A
2.130000 Ib/d
N/A
10.050000 tb/d
N/A
1 .370000 Ib/d
N/A
1429.000000 Ib/d
N/A
1.010000 Ib/d
N/A
•— •— •— — i — ==^=,
Seasonal; see below
~^— • _
"
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/day
1/year
SIC Code: 2869
i.
24hr fw comp
24 hr fw composite
24hr fw comp
24hr fw comp
24hr fw comp
24hr fw composite
24hr fw comp
24hr fw comp
24hr fw comp
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
2'4hr fw comp
24hr fw composite
24hr fw comp
24hr fw composite
grab
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw comp
24hr fw composite
24hr fw comp
Page: 353
-------
Fac fifty Homo: Texas Eastman Company
Facility Description: Organic chemical man
Chloroethano
1 Chloroform
Chronic WET
Chryscn«
cu (T>
oi-n-butyl phthal
1 ate
Oicthyl phthalate
Dimethyl phthalat
1 c
DO
1 Ethylbcnzcne
Fluoranthcne
1 Fluorcno
HcxBchlorobonzcno
Hoxachlorobutadie
1 no
1 Hexachloroethane
Hethyl chloride
Hothylcne chlorid
1 ^
1 Naphthalene
NH3-H
1 Nitrobenzene
Phenanthrene
1 Phenol
1 Pyrene
Tetrachloroethyle
1 ne
1 Toluene
'
3.750000 Ib/d
N/A
0.760000 Ib/d
N/A
N/A
N/A
0.790000 Ib/d
N/A
Report Ib/d
Report ug/l
0.970000 Ib/d
N/A
Z.920000 Ib/d
N/A
0.680000 Ib/d
N/A
N/A
6.000000 mg/l
1.150000 Ib/d
N/A
0.900000 Ib/d
N/A
0.790000 Ib/d
N/A
0.540000 Ib/d
N/A
0.720000 Ib/d
N/A
0.760000 Ib/d
N/A
3.100000 Ib/d
N/A
1.440000 Ib/d
N/A
0.790000 Ib/d
N/A
N/A
0.500000 mg/l
0.970000 Ib/d
N/A
0.790000 Ib/d
N/A
0.540000 Ib/d
N/A
0.900000 Ib/d
N/A
0.790000 Ib/d
N/A
0.940000 Ib/d
N/A
ufacturing.
__^ — — •=— »
9.660000 Ib/d
N/A
1.660000 Ib/d
N/A
N/A
N/A
2.130000 Ib/d
N/A
Report Ib/d
Report ug/l
2.050000 Ib/d
N/A
7.310000 Ib/d
N/A
1.690000 Ib/d
N/A
N/A
N/A
3.890000 Ib/d
N/A
2.450000 Ib/d
N/A
2.130000 Ib/d
N/A
1.010000 Ib/d
N/A
1.770000 Ib/d
N/A
1 .950000 Ib/d
N/A
6.850000 Ib/d
N/A
3.210000 Ib/d
N/A
2.130000 Ib/d
N/A
N/A
N/A
2.450000 Ib/d
N/A
2.130000 Ib/d
N/A
0.940000 Ib/d
N/A
2.410000 Ib/d
N/A
2.020000 Ib/d
N/A
2.880000 Ib/d
N/A
See below
See below
'.. '
.
Seasonal; see below
•
Permit Number: TX0000949
SIC Code: 2869 ^
1/year
1/year
1 /month
1/year
1/year
1/year
1/year
1/year
1/day
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/day
1/year
1/year
1/year
1/year
1/year
1/year
24hr fw comp ^
24hr fw comp
24 hr composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
24hr fw comp
24hr fw comp
24hr fw composite
24hr fw comp ,
24hr fw composite
24hr fw comp
24hr fw composite
24hr fw comp
24hr fw composite
grab
24hf fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
-------
Facility Name: Texas Eastman Company
facility Description: Organic chemical manufacturing
Trichloroethylene
Vinyl chloride
Zn (T)
0.760000 Ib/d
N/A
3.750000 Ib/d
N/A
7.400000 Ib/d
176.000000 Ug/l
1.950000 Ib/d
N/A
9.660000 Ib/d
N/A
15.590000 Ib/d
371.000000 ug/l
Permit Number: TX0000949
—' :
_^______^__ SIC Cocle: 2869
1/year 24hr fw composite
1/Vear 24hr fw composite
1/year 24hr fw composite
Limitations/Monitoring Basis-
kiutfatl: 002B | Receiving
• .—
Amount/Components:
— •— "-n^m^g^ctt^aj
Treatment: AS
Parameter
1,1,1-Trichloroet
hane
1,1,2-Trichloroet
hane
1,1-Dichloroethan
e
1,1-Dichloroethyl
ene
1,2,4-Trichlorobe
nzene
1,2-Dichlorobenze
ne
1,2-Dichloroethan
e
1,2-D i chIoropropa
ne
1,2-Trans-Dichlor
oethylene
1,3-Dichlorobenze
ne
1,4-Dichlorobenze
ne
2,4-Dichloropheno
2,4-Dimethylpheno
2,4-Dinitrophenol
2,4-Dinitrotoluen
2,6-Dinitrotoluen
e
wastewater
r . "
Page: 355
-------
MM
Fa
Fa
2
.
1
iii
cility Homo: Texas E
. • • •
cility Description:
•Chlorophenol
'•Nitrophenol
j,4-Benzofluorant
4,6-Dinitro-o-cre
4-Hitrophcnol
Acenaphthene
Acenaphthytcne
Acryloni trite
Anthracene
Benzene
Bcnzo
Di-n-butyt phthal
Oicthyl phthalate
Dimethyl phthalat
Ethylbenzcne
Fluoranthenc
I,
astman Company
.
Organic chemical mam
•; —
1.120000 Ib/d
H/A
1.480000 Ib/d
N/A
0.830000 Ib/d
N/A
2.810000 Ib/d
H/A
2.590000 Ib/d
N/A
0.790000 Ib/d
N/A
0.790000 Ib/d
N/A
3.460000 Ib/d
N/A
0.790000 Ib/d
N/A
1.330000 Ib/d
N/A
0.790000 Ib/d
N/A
0.830000 Ib/d
N/A
0.790000 Ib/d
N/A
3.710000 Ib/d
N/A
0.650000 Ib/d
N/A
0.540000 Ib/d
N/A
3.750000 Ib/d
N/A
0.760000 Ib/d
N/A
0.790000 Ib/d
N/A
Report Ib/d
Report ug/l
0.970000 Ib/d
N/A
2.920000 Ib/d
N/A
0.680000 Ib/c
N/A
1.150000 Ib/c
N/A
0.900000 lb/
N/A
_ — _ — — =
ifacturing.
.
3.530000 Ib/d
N/A
2.490000 Ib/d
N/A
2.200000 Ib/d
N/A
9.980000 Ib/d
N/A
4.470000 Ib/d
N/A I
2.130000 Ib/d
N/A
2.130000 Ib/d
N/A
8.720000 Ib/d
N/A
2.130000 Ib/d
N/A
4.900000 Ib/d
N/A
2.130000 Ib/d
N/A
2.200000 Ib/d
N/A
2.130000 Ib/d
N/A
10.050000 Ib/d
N/A
1.370000 Ib/d
N/A
1.010000 Ib/d
N/A
9.660000 Ib/d
N/A
1 .660000 Ib/d
N/A
2.130000 Ib/d
N/A
Report Ib/d
Report ug/l
I 2. 050000 Ib/d
N/A
7.310000 Ib/d
N/A
1.690000 Ib/d
N/A
j 3.890000 Ib/c
N/A
J 2.450000 lb/<
N/A
~-.
• • — •
=_.
1
i
- • •
Perm!
—
__=^— ==— =•
1/year
1/year
1/year
1/year I
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
t Number: TX0000949
— \ 4\
SIC Code: 2869 Ml
H m\
24hr fw comp ^1
"
Page: 356
-------
Facility Name: Texas Eastman Company Permit Number: TX0000949
Facility Description: Organic chemical manufacturing. SIC Code: 2869
Ftuorene
Hexach lorobenzene
Hexach I orobutadi e
ne
Hexach I oroethane
Methyl chloride
Hethylene chlorid
e
Naphthalene
Nitrobenzene
Phenanthrene
Phenol
Pyrene
Tetrachloroethyle
ne
Toluene
Trichloroethylene
Vinyl chloride
Zn (T)
0.790000 Ib/d
N/A
0.540000 Ib/d
N/A
0.720000 Ib/d
N/A
0.760000 Ib/d
N/A
3.100000 Ib/d
N/A
1 .440000 Ib/d
N/A
0.790000 Ib/d
N/A
0.970000 Ib/d
N/A
0.790000 Ib/d
N/A
0.540000 Ib/d
N/A
0.900000 Ib/d
N/A
0.790000 Ib/d
N/A
0.940000 Ib/d
N/A
0.760000 Ib/d
N/A
3.750000 Ib/d
N/A
7.400000 Ib/d
176.000000 ug/l
2.130000 Ib/d
N/A
1.010000 Ib/d
N/A
1.770000 Ib/d
N/A
1.950000 Ib/d
N/A
6.850000 Ib/d
N/A
3.210000 Ib/d
N/A
2.130000 Ib/d
N/A
2.450000 Ib/d
N/A
2.130000 Ib/d
N/A
0.940000 Ib/d
N/A
2.410000 Ib/d
N/A
2.020000 Ib/d
N/A
2.880000 Ib/d
N/A
1 .950000 Ib/d
N/A
9.660000 Ib/d
N/A
15.590000 Ib/d
371.000000 ug/l
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
I/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
24hr fw composite
24hr fw comp
24hr fw composite
24hr fw comp
24hr fw composite
24hr fw comp
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fu composite
24hr fw composite
24hr fw composite
Limitations/Monitoring Basis:
The bases of the effluent limitations and monitoring conditions were not described. See limitations/monitoring
basis for Outfall 002A.
Outfall: 003 | Receiving Water: Discharge Channel 2 to Sabine | Treatment: Not described
Amount/Components :
4.7 MGD daily avg. of cooling tower blowdown.
Parameter
Cu (T)
Flow
pH
Limitations
Daily
Average
0.250000 Ib/d
21.000000 ug/l
N/A
Report MGD
N/A
N/A
Daily
Maximum
0.530000 Ib/d
45.000000 ug/l
N/A
Report MGD
N/A
N/A
Other
6.0 su inst. min., 9
.0 su
Monitoring Requirements
Frequency
1/week
continuous
1/day
Sample Type
24hr fw composite
record
grab
Page: 357
-------
Facility Name: Texas Eastman Company Permit Number: TX0000949
Facility Description: Organic chemical manufacturing. SIC Code: 2869
Zn (T)
2.050000 Ib/d
176.000000 ug/l
4.330000 Ib/d
371.000000 ug/l
3/week
24hr fw composite
Limitations/Monitoring Basis:
According to the fact sheet, with the exception of BODS, TSS, and TOC, the effluent limitations remain unchanged
from the previous permit; BOOS, TSS, and TOC are not regulated at this outfall in the permit. The bases of the
monitoring conditions were not described. '
Outfall: 004 | Receiving Water: Sabine River | Treatment: AS
Amount/Components :
Unspecified amount of process, storm water, sanitary sewage, and demineralizer wastewater.
Parameter
1,1,1-THchloroet
hane
1,1,2-Trichloroet
hano
1,1-Diehloroethan
e
1,1-Dichloroethyl
one
1,2,4-Trichlorobe
nzene
1,2-Dichlorobcnzc
ne
1,2-Dichloroethan
e
1,2-Dichloropropa
no
1,2-Trans-Dichlor
oethylcne
1,3-Dichlorobenze
ne
1,4-Dichlorobonze
ne
2,4-Dichloropheno
2,4-Dimethylpheno
I
2,4-Dinitrophenol
2,4-Dinitrotoluen
e
2,6-Dinitrotolucn
e
2-Chlorophcnol
2-Hitrophenol
3,4-Benzofluorant
hcno
Limitations
Daily
Average
1.450000 Ib/d
N/A
1.450000 Ib/d
N/A
1.520000 Ib/d
N/A
1.110000 Ib/d
H/A
4.710000 Ib/d
N/A
5.330000 Ib/d
N/A
4.710000 Ib/d
N/A
10.590000 Ib/d
N/A
1.450000 Ib/d
N/A
2.150000 Ib/d
N/A
1.040000 Ib/d
N/A
2.700000 Ib/d
N/A
1.250000 Ib/d
N/A
4.910000 Ib/d
N/A
7.820000 Ib/d
N/A
17.650000 Ib/d
N/A
2.150000 Ib/d
N/A
2.840000 Ib/d
N/A
1.590000 Ib/d
N/A
Daily
Maximum
3.740000 Ib/d
N/A
3.740000 Ib/d
N/A
4.080000 Ib/d
N/A
1.730000 Ib/d
N/A
9.690000 Ib/d
N/A
11.280000 Ib/d
N/A
14.760000 Ib/d
N/A
15.920000 Ib/d
N/A
3.740000 Ib/d
N/A
3.050000 Ib/d
N/A
1.940000 Ib/d
N/A
7.750000 Ib/d
N/A
2.490000 Ib/d
N/A
8.510000 Ib/d
N/A
19.730000 Ib/d
N/A
44.370000 Ib/d
N/A
6.780000 Lb/d
N/A
4.780000 Ib/d
N/A
4.220000 Ib/d
N/A
Other
Monitoring Requirements
Frequency
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
Sample Type
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
Page: 358
-------
Facility Name: Texas Eastman Company Permit Number: TX0000949
:acility Description: Organic chemical manufacturing. ... SIC Code: 2869
4,6-Dinitro-o-cre
sol
4-Nitrophenol
Acenaphthene
Acenaphthylene
Acrylonitrile
Anthracene
Benzene
Benzo (a) anthrac
ene
Benzo (a) pyrene •
Benzo (k) f luoran
thane
Bis (2-ethylhexyl
) phthalate
Carbon tetrachlor
ide
CBOD5 -
Chlorobenzene
Chloroethane
Chloroform
Chronic WET
Chrysene
Di-n-butyl phthal
ate
Diethyl phthalate
Dimethyl phthalat
e
DO
Ethylbenzene
Flow ,
Fluoranthene
5.400000 Ib/d
N/A
4.980000 Ib/d
N/A
1.520000 Ib/d
N/A
1.520000 Ib/d
N/A
6.650000 Ib/d
N/A
1.520000 Ib/d
N/A
2.560000 Ib/d
N/A
1 .520000 Ib/d
N/A
1.590000 Ib/d
N/A
1.520000 Ib/d
N/A
7.130000 Ib/d
N/A
1.250000 Ib/d
N/A
498.000000 Ib/d
N/A
1.040000 Ib/d
N/A
7.200000 tb/d
N/A
1.450000 Ib/d
N/A
N/A
N/A
1.520000 Ib/d
N/A
1 .870000 . Ib/d
N/A
5.610000 Ib/d
N/A
1.320000 Ib/d
N/A
N/A
5.000000 mg/l
2.220000 Ib/d
N/A
N/A
Report MGD
1.730000 Ib/d
N/A
19.170000 Ib/d
N/A
8.580000 Ib/d
N/A ,
4.080000 Ib/d
N/A
4.080000 Ib/d
N/A
16.750000 Ib/d
N/A
4.080000 Ib/d
N/A
9.410000 Ib/d
N/A
4.220000 Ib/d
N/A
4.220000 Ib/d
N/A
4.080000 Ib/d
N/A
19.310000 Ib/d
N/A
2.630000 Ib/d
N/A
1334.000000 Ib/d
N/A
1.940000 Ib/d
N/A
18.550000 Ib/d
N/A
3.180000 Ib/d
N/A
N/A
N/A
4.080000 Ib/d
N/A
3.950000 Ib/d
N/A
14.050000 Ib/d
N/A
3.250000 Ib/d
N/A
N/A
N/A
7.480000 Ib/d
N/A
N/A
Report MGD
4.710000 Ib/d
N/A
-
•
See below _,
I '
Limit:: >5 mg/l • . .
-
1/year
1/year
1/year
1/year
1/year
1/year
1/quarter
1/year
• 1/year
1/year
1/year
1/year
. 3/week
1/year
, 1/year
• 1/year
1 /month
1/year
• 1/year
1/year
1/year
3/week
1/year
continuous
1/year-
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24 hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
24hr fw composite
record
24hr fw composite
Page: 359
-------
Facility Name: Texas Eastman Company Permit Number: TX0000949
Facility Description: Organic chemical manufacturing. SIC Code: 2869
Ftuorcne
Hcxachlorobcnzcnc
Hexachtorobutadie
no
llcxochlorocchanc
Hothyt chloride
Methylene chlorid
e
Naphthalene
nitrobenzene
p«
Phcnanthrcne
Phenol
Pyrcnc
Tetrachloroethylo
ne
Toluene
Trichlorocthylene
TSS
Vinyl chloride
1.520000 Ib/d
H/A
1.040000 Ib/d
H/A
1.380000 Ib/d
H/A
1.450000 Ib/d
N/A
5.950000 Ib/d
N/A
2.770000 Ib/d
H/A
1.520000 Ib/d
H/A
1.870000 Ib/d
H/A
H/A
H/A
1.520000 Ib/d
H/A
1.040000 Ib/d
N/A
1.730000 Ib/d
H/A
1.520000 Ib/d
H/A
1.800000 Ib/d
H/A
1.450000 Ib/d
H/A
3205.000000 Ib/d
H/A
7.200000 Ib/d
N/A
4.080000 Ib/d
N/A
1.940000 Ib/d
H/A
3.390000 Ib/d
H/A
3.740000 Ib/d
H/A
13.150000 Ib/d
H/A
6.160000 Ib/d
N/A
4.080000 Ib/d
N/A
4.710000 Ib/d
H/A
H/A
H/A
4.080000 Ib/d
N/A
1.800000 Ib/d
N/A
4.640000 Ib/d
N/A
3.880000 Ib/d
H/A
5.540000 Ib/d
H/A
3.740000 Ib/d
N/A
8000.000000 Ib/d
N/A
18.500000 Ib/d
N/A
6.0 su inst. min., 9
.0 su
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/year
1/day
1/year
1/year
1/year
1/year
1/year
1/year
3/week
1/year
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
Limitations/Monitoring Basis:
The bases of the effluent limitations and monitoring conditions were not described. WET monitoring requirements
include reporting endpoints of fecundity, lethality, and growth for both Ceriodaphnia dubia and Pimephales promelas
in accordance with Method 1000.0 and 1002.0 and several other specifications outlined in the permit. The permit
requires accelerated HET testing in the instance of lethality or non-lethal effects at 17% or less effluent
concentration.
Special Conditions Basis:
Specific HLs are set forth for Cu and Zn. Other special conditions include CAS and Storet number listings; 24hr
reporting requirements for specific parameters; and volatile organic composite sampling protocal. A scheduleis also
set forth for the attainment of compliance with Cu and Zn WQ-based limits at outfalls 002, 003, and 005 by December
1, 1994; quarterly reports are required to be submitted. The basis of these special conditions was not described.
Effective Date: 12/01/91 Expiration Date: 11/30/96 Abstract Date: 04/16/93
Page: 360
-------
Facility Name: American Gilsonite Company
Permit Number: UT0000167
Facility Description: Gilsonite (hydrocarbon material) mining operation
SIC Code: 1499
Limit
Basis:
ELGs
WQSs
J.
BPJ
J.
Monitoring
Only
J.
WET
Limits
WET Testing
Only
Multiple
Categories
Tiered
Limits
Other
Special
Conditions:
BMPs
Storm
Water
Sediment
WQ
Survey
Bio
Survey
TRES
HDLs
Monitoring
Other
Abstract Information:
Partial; Outfall 007 is active and representative of the 19 mine discharges covered by the permit.
Outfall: 007
Receiving Water: Dry Wash/Coyote Wash/White R.
Treatment: Sed, Neut
Amount/Components:
0.36 HGD (total from all outfalls) treated groundwater generalted from mining operations.
Parameter
Flow
O&G
PH
TDS
TSS
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
25.000000 mg/l
Daily
Maximum
N/A
Report mgd
N/A
10.000000 mg/l
N/A
Report
N/A
3500.000000 mg/l
N/A
50.000000 mg/l
Other
Between 6.5 su and 9
.0 su
35 mg/l 7-day averag
e
Monitoring Requirements
Frequency
1/week
1/quarter
1/week
1/quarter
1 /month
Sample Type
• Measure
Grab
Grab
Grab
Grab
Limitations/Monitoring Basis:
This abstract was created using the permit statement of basis. There is a requirement that provides "the total of
all discharges shall not exceed an average of 2 tons of salt per day or 700 tons per year." Ther is also a
narrative requirement that states that "the salt discharge is to be minimized by using the largest possible amount
of saline water for process, dust control, etc." also a narrative requirement prohibiting the discharge of "process
water, floating solids or visible foam other than trace amounts" is included. The monthly average limits are based
on Utah Secondary Treatment Standards, UAC 317-1-3.2. The O&G and daily maximum TSS limits are based on BPJ. The
TDS limit and "salt per day" limit are based on the Colorado River Basin Salinity Control Forum's 1982 Intercepted
Groundwater Policy. Monitoring requirements are all developed in accordance with the 1991 Utah Monitoring, Recording
and Reporting Guidelines.
Special Conditions Basis:
The permit contains a reopener that allows for WET testing and limits to be required at a later date if found to be
appropriate in the future.
Effective Date: N/A
Expiration Date: N/A
Abstract Date: 04/27/93
Page: 361
-------
Facility Name: Springfield Electroplating Permit Number: VT0000272
Facility Description: Metal finishing/electroplating and electroless plating SIC Code: 3471
Monitoring
Limit ELGs WQSs BPJ Only
Basis: j, 2. - -
Storm UQ
Special BHPs Water Sediment Survey
Conditions: £ - „ -
VIET WET Testing Multiple Tiered
Limits Only Categories Limits
Bio
Survey TRES MDLs Monitoring
- - • • - , J.
Other
I
Other
Abstract Information:
Complete; 001
Outfall: 001 | Receiving Water: Black River , | "Treatment: ChPt
Amount/Components:
1500 GPO (max. allowable) treated electroplating wastewater including resin exchange regenerant.
Parameter
Cd
Cd
CH
CM
Or
Cr (T)
Cu
Cu
FloM
Hi
Hi
pH
pH
TSS
TSS
TTOs
TTOs
Zn
Limitations
Average
N/A
N/A
H/A
N/A
M/A
H/A
N/A
N/A
N/A
N/A
N/A
H/A
H/A
H/A
H/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
H/A
H/A
H/A
H/A
H/A
H/A
H/A
N/A
N/A
N/A
N/A
Maximum
N/A
0.300000 mg/l
H/A
0.300000 mg/l
H/A
0.300000 mg/l
N/A
0.300000 mg/l
N/A
0.500000 mg/l
N/A
0.500000 mg/l
N/A
0.500000 mg/l
N/A
0.500000 mg/l
N/A
1500.000000 GPD
N/A
1.000000 mg/l
N/A
1.000000 mg/l
H/A
N/A
N/A
N/A
N/A
30.000000 mg/l
N/A
30.000000 mg/l
N/A
2.130000 mg/l
N/A
2.130000 mg/l
H/A
1.480000 mg/l
Other
"X.
Between 6.5 su and 9
.0 su
Between 6.5 su and 9
.0 su
Metal treatment only
Monitoring Requirements
Frequency
1 /batch
1/batch
1 /batch
1/batch
1/batch
1/batch
1/batch
1/batch
1/day
1/batch
1/batch
1/batch
1/batch
1/batch
Sample Type
Grab
Grab
Grab
Grab
grab
Grab
' Grab
Grab
total
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Grab
Page: 362
-------
Facility Name: Springfield Electroplating
Permit Number: VT0000272
Facility Description: Metal finishing/electroplating and electroless plating
SIC Code: 3471
Zn
N/A
N/A
N/A
1.480000 mg/l
1 /batch
' Grab
Limitations/Monitoring Basis:
Limits for TSS and TTO are based on ELGs (40 CFR Part 433 - Metal Finishing Point Source Category Electroplating and
Electroless Plating). Limits for Cd(T), Cr(T), Cu(T), Ni(T), N(T), flow, and pH are based on the antibacksliding
clause of the CWA. Limits for Cd(T), Cr(T), Cu. CN
-------
Facility Homo: J.C. McNeil Generating Station Permit Number: VT0020401
Facility Description: Steam electric generating station (wood fired) SIC Code: 4931
Monitoring
Limit ELGs WQSs BPJ Only
Basis: J. J. - J.
Storm WQ
Special BHPs Water Sediment Survey
Conditions: Z Z z J.
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
— - - - J.
Bio
Survey TRES MDLs Monitoring Other
- - - J. I
Abstract Information:
Complete; Outfalls 001a, 001b, and 002.
Outfoll: 001A | Receiving Water: Winooski River | Treatment: 0/W Sep, Sed, pH adjustment, Co
Amount/Components :
0.365 HGO of cooling water, boiler blowdown, demineralizer regeneration reject, filter backwash, and floor drains.
Parameter
Cd
Cd
Cd
Cr+3
Cr+3
Cr+3
CU
cu
Cu
FAC
FAC
FAC
Fe
Fe
Fe
Flow
Flow
Flow
Limitations
Average
M/A
Report
M/A
Report
M/A
Report
N/A
Report
M/A
Report
H/A
Report
N/A
Report
H/A
Report
N/A
Report
N/A
N/A
N/A
N/A
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
0.365000 MGD
N/A
0.365000 MGD
N/A
0.365000 MGD
Maximum
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
H/A
N/A
Report
H/A
Report
H/A
Report
N/A
Report
N/A
0.500000 MGD
H/A
0.500000 MGD
H/A
0.500000 MGD
Other
Units not specified
Units not specified
Units not specified
See below
Units not specified
Monitoring Requirements
Frequency
1/quarter
1 /quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
i
1/quarter
1/day
1 /month
1 /month
1 /month
Continuous
Continuous
continuous
Sample Type
24hr fw composite
24hr fw composite
24 hr fw composite
24hr fw composite
24hr fw composite
24 hr fw composite
24hr fw composite
24hp fw composite
24 hr fw composite
grab
24hr fw composite
24hr fw composite
24 hr fw composite
Total
Total
total
Page: 364
-------
Fac,l,ty Name: J.C. McNeil Generating Station Permit Number: VT0020401
Facility Description: Steam electric generating station (wood fired) SIC Code. 4931
Ni
Ni
Ni
Pb
Pb
Pb
pH
PH
pH
IDS
IDS
TDS
Temp.
Temp..
Temp.
TRC
TRC
TRC
Zn
Zn
Zn
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
N/A
N/A
N/A
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
N/A
N/A
N/A
N/A
Report
N/A
N/A
N/A
N/A
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
Report '
N/A
Report
N/A
Report
N/A
Report
N/A
N/A
N/A
N/A
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
N/A
N/A
Report
N/A
Report
N/A
N/A
N/A
Report
N/A
Report
N/A
Report
N/A
Report
Units not specified
Units not specified
Between 6.0 su and 8
.5 su
Between 6.0 su and 8
.5 su
Between 6.0 su and 8
.5 su
Units not specified
See below
See below
Units not specified
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
continuous
1 /month
1 /month
1 /month
1/week
1/day
1/quarter
1/quarter
1/quarter
24hr fw composite
24hr fw composite
24 hr fw composite
24hr fw composite
24hr fw composite
24 hr fw composite
not given
24hr fw composite
24hr fw composite
24 hr fw composite
grab
grab
24hr fw composite
24hr fw composite
24 h'r fw composite
Limitations/Monitoring Basis: "
Flow limits are based on previous permit. Metals limits were dropped (monitoring still required) due to Inu
TRC limits are consistent with Vermont WQSs and remain unchanged from the previous permit The 2-hour ch lor i nation
discharge limit ,s consistent with 40 CFR Part 423. pH is based on Vermont WQSs («fcfR Part 401 1™ for continuous
u??h 2n Si P PH^ty pollutant scan, is required within 6 months of permit effective date. This is consist
and are I sted n the plrK" hmltat'°ns ^re dependent upon the background temperature of the rece7vng stream
Page: 365
-------
Foci Uty dame: J.C. McHeil Generating Station "•"" Number: VT0020401
Facility Description: Steam electric generating station (wood fired) SIC Code< wil
Outfall: 001B | Receiving Water: Winooski River Treatment: API, Sed, Neut. Floe
A^t/$?^nt4! -«'<",, uat«rr boiler blowdown. deraineralizer regeneration, filter backwash, and floor drains
Parameter
Cd
Cr+3
CU
FAC
Fe
Flow
Mi
Pb
pH
IDS
TctDp*
TRC
2n
Limitations
Monthly
Average
H/A
Report
H/A
Report
N/A
Report
N/A
Report
H/A
Report
H/A
0.365000 MGD
N/A
Report
N/A
Report
N/A
Report
N/A
Report
H/A
Report
H/A
Report
N/A
Report
Daily
Maximum
N/A
Report
N/A
Report
H/A
Report
N/A
Report
N/A
Report
N/A
0.500000 MGD
N/A
Report
N/A
Report
H/A
Report
N/A
Report
N/A
Report
N/A
Report
H/A
Report
Other
Units not specified
Units not specified
Units not specified
See below
Units not specified
Units not specified
Units not specified
Between 6.0 su and 8
.5 su
Units not specified
See below
See below
Units not specified
Monitoring Requirements
Frequency
1 /quarter
1 /quarter
1/quarter
1/day
1 /month
continuous
1/quarter
1/quarter
continuous
1 /month
1/week
1/day
1/quarter
Sample Type
24 hr fw composite
24 hr fw composite
24 hr fw composite
grab
24 hr fw composite
total
24 hr fw composite
24 hr fw composite
not given
24 hr fw composite
grab
grab
24 hr fw composite
Limit^iws/Honitoring Basis: ^ ^ ^^ Qf Jme through September. See the
Umitations/monitoring bas^ for Outfall 001A. During the summer, temperature I mutations are based on the
blSc^tl^eSl. The allowable increase in the temperature of the receiving water increases with an increase
in the receiving water, or background, temperature. This increase ranges from 1 to 5 degrees F.
Outfall: 002 | Receiving Water: Winooski River I Treatment: Not specified
Amount/Components :
Unspecified amount of treated low volume waste
Parameter
BOOS
Flow
O&G
Limitations
Monthly
Average
N/A
N/A
N/A
0.125000 MGD
10.400000 Ib/d
10.000000 mg/l
Daily
Maximum
N/A
Report
N/A
0.500000 MGD
15.600000 Ib/d
15.000000 mg/l
Other
units not provided
Monitoring Requirements
Frequency
1/quarter
continuous
1 /month
Sample Type
24 hr fw composite
total
grab
Page: 366
-------
*==^-_—
Facility Name: J.C. McNeil Generating Station
Facility Description: Steam electric generating station (wood fired)
Permit Number: VT0020401
P (T)
PH
TSS
Turbidity
0.100000 Ib/d
0.100000 mg/l
N/A
N/A
N/A
N/A
N/A
Report
0.730000 Ib/d
0.700000 mg/l
N/A
Report
31.300000 tb/d
30.000000 mg/l
N/A
Report
SIC Codes 4931
See below
Units not provided
Limitations/Monitoring Basis:
The permit requires that the pH not
limitations of a range 6.5 su and 8.j
formula for calculating UOD using the
and monitoring
1/month
not given
1/month
1/month
24 hr fw composite
not given
24 hr fw composite
24 hr.fw composite
discharge with outfall 001 to exceed the permitted
t D™c ie_,1s rec1uired to calculate UOD, ultimate oxygen demand A
1 CFR pL?^ N T't0-inVS P™"'d«d. The basis for ?he™r
i CFR Part 423 and previously issued permits.
Special Conditions Basis:
Thermal mixing zone
^ 01 ares anoyc, *v*.umw. tuoLjcam mm
d,?!u?2a!?d ™*!P? z°ne: pCi«»-ity pollutant monitoring (40 CFR part 4
operate at .. „
in cooling/boiler water
must not exceed-60'minutes-at-a-ny «»'^/'hSiS T*™!^."*' ^ fO™' °P
zonerfis
e and at the lower end of the
excursions
ffective Date: 08/05/91
Abstract Date: 09/15/83
Expiration Date: 06/30/96
Page: 367
-------
Facility Name: VT Whey Company . • — 4 A
Facility Description: Production of protein lactose powders from whey _ — . \
Monitoring
Limit ELGs WQSs BPJ only
Basis: z I *• ±
storm WQ
Special BHPs Water Sediment Survey
Conditions: j. - - -
UET WET Testing
Limits Only
Bio
Survey TRES
Multiple . Tiered
Categories Limits Other
— Z. J-
MDLs Monitoring Other
. I I
AtetTo^lcft°or-naOu!tfall 001 C001a, OOlb. and 001c created for abstracting purposes)
Outfall- 001A | Receiving Water: Percolation Ponds D & E I Treatment: EQ, AerL, Sed, CAC
^""^^SLmount of treated whey processing wastewater discharge.
Parameter
BOOS
COD
COD
Flow
Flow
H03
H03
P (T)
P (T>
pH
pH
SS
TSS
TSS
Limitations
Monthly
Average
12.500000 Ib/d
10.000000 mg/l
M/A
H/A
H/A
N/A
H/A
0.150000 HGD
N/A
H/A
N/A
H/A
N/A
H/A
H/A
H/A
H/A
H/A
H/A
H/A
N/A
N/A
H/A
H/A
12.500000 Ib/d
100.000000 mg/l
H/A
H/A
Daily
Maximum
18.800000 Ib/d
15.000000 mg/l
H/A
Report
H/A
H/A
H/A
0.150000 MGD
H/A
H/A
H/A
H/A
H/A
H/A
2.500000 Ib/d
2.000000 mg/l
H/A
N/A
H/A
N/A
N/A
H/A
H/A
1.000000 ml/l
18.800000 Ib/d
15.000000 mg/l
H/A
H/A
Other
Between 6.5 SU and 8
.5 SU
Monitoring Requirements
Frequency
1 /month
1/day
1/day
continuous
1/day
1/week
1/week
1/week
1/week
1/week
1/week
1/week
1/week
1/week
Sample Type
24hr fw composite
24hr fw composite
24hr fw composite
total
Meter
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
Grab
Grab
24 hr fw composite
24hr fw composite
24hr fw composite
Limitations/Monitoring Basis: Drm/inn* influent BOD and TSS limits were based on an
isa:^ £ -"^^ ^-™ts was provided-
Page: 368
-------
k Permit Number: VT0020702
| Facility Description: Production of protein lactose powders from whev ....... ..._ '
Outfall: 001B
Receiving Water: internal outfall | Treatment: Unspecif ied
Amount/components:
Unspecified amount of Step I clarifier effluent.
Parameter
Limitations
Monthly
Average
BODS N/A
N/A
BODS N/A
N/A
Other N/A
N/A
Other N/A
N/A
TSS N/A
N/A
TSS N/A
N/A
Daily
Maximum
N/A
Report
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Report
N/A
N/A
Other
Soluble BODS
Soluble BODS
Monitoring Requirements
Frequency
1/week
1/week
1/week
1/week
1/week
1/week
Sample Type
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
Limitations/Monitoring Basis: —
?h°ebamount0ofS"^tubreaBroDf5»" monitorin8 re^'>^nts was provided. The permittee is required to monitor and report
Outfall: 001C
K.CelV1ng water: Arrowhead Mtn Lake via wells | Treatment: EQ. AerL. Sed TAP. Pi,
Amount/Components: -.
Unspecified amount of treated whey processing wastewater discharge.
Parameter
BODS
BODS
Flow
Flow
N03
N03
Other
Other
P (T)
P (T)
PH
Limitations
Monthly
Average
35.000000 Ib/d
N/A
35.000000 Ib/d
N/A
N/A
0.425000 MGD
N/A
0.425000 MGD
N/A
N/A
N/A
N/A
83.000000 Ib/d
N/A
83.000000 Ib/d
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Daily
Maximum
57.000000 Ib/d
15.000000 mg/l
57.000000 Ib/d
15.000000 mg/l
N/A
0.460000 MGD
N/A
0.460000 MGD
N/A
99.000000 mg/l
N/A
99.000000 mg/l
N/A
N/A
N/A
N/A
3.000000 Ib/d
0.780000 mg/l
3.000000 Ib/d
0.780000 mg/l
N/A
Report
Other
Ultimate oxygen dema
nd
Ultimate oxygen dema
nd
Between 6.5 su and 8
.5 su
Monitoring Requirements
Frequency
1/week
1/week
Continuous
Continuous
1/week
1/week
1/week
1/week
1/week
1/week
1/day
Sample Type
24hr fw composite
24hr fw composite
Total
Total daily
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
Grab
Page: 369
-------
Facility Harae: VT Whey Company . . —
Facility neacHption: Production of protein lactose powders from whey
pH
SS
ss
TKH
TKN
TSS
TSS
N/A
N/A
H/A
N/A
35.000000 Ib/d
H/A
H/A
H/A
N/A
N/A
35.000000 Ib/d
N/A
35.000000 Ib/d
N/A
N/A
N/A
N/A
1.000000 ral/l
57.000000 Ib/d
15.000000 mg/l
N/A
Report
N/A
Report
57.000000 Ib/d
15.000000 mg/l
57.000000 Ib/d
15.000000 mg/l
Between 6.5 su and 8
.5 su
4
1/day
1/week
1/week
1/week
1/week
1/week
1/week
SIC Code: WdS
Grab
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
Limitations/Monitoring Basis: formula 1 43 Ub/d'BOD5) + 4.57 (Ib/d TKN) and applies from June
si ".=- - - - "-' -
Special Conditions E
A waste managet
updated once e
clarificr effl
is required to
Hater elevatio
at frequencies
'"
Effective Date: 12/
Srfrrw^
^gss^zF^fesm^^xw^.
Page: 370
-------
Facility Name; VT Dept. of Fish and Wildlife
Facility Description: Salmonids fish hatchery
Limit
Basis:
Special
Conditions:
Permit Number: VT0020966
SIC Code: 0921
ELGs
BMPs
WQSs
Storm
Water
BPJ
Sediment
Monitoring
Only
WQ
Survey
WET
Limits
Bio
Survey
Abstract Information:
Complete; outfall 001
WET Testing
Only
TRES
Multiple
Categories
MDLs
Tiered
Limits
Monitoring
Other
I
Other
J.
Outfall: 001
Receiving Water: Halnon Brook
Amount/Components:
Unspecified amount of fish culture station effluent.
Treatment: Sed
Parameter
BODS
BODS
Flow
Flow
HH3-N
NH3-N
P (T)
P (T)
PH
TSS
TSS
Limitations
Monthly
Average
N/A
Report
N/A
Report
N/A
1.300000 MGD
N/A
1.300000 MGD
N/A
Report
N/A
Report
N/A
Report
N/A
Report
N/A
N/A
N/A
N/A
N/A
5.000000 mg/l
N/A
5.000000 mg/l
Daily
Maximum
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
15.000000 mg/l
N/A
15.000000 mg/l
Other
See below
See below
Monitoring Requirements
See below
See below
See below
See below
See below
See below
Between 6.5 su and 8
.5 su
Between 6.5 su and 8
.5 su
See below
See below
Frequency
2/year
2/year
1/week
1/week
2/year
2/year
2/month
2/month
1/week
1/week
2/month
2/month
Sample Type
4hr fw composite
4hr fw composite
Instantaneous
Instantaneous
4hr fw composite
4hr fw composite
4hr fw composite
4hr fw composite
Grab
Grab
4hr fw composite
4hr fw composite
Limitations/Monitoring Basis:
psvff&z srs a <•
Special Conditions Basis:
and durations no greater than those used in 1989.
'
Terramycin at concentrations
Effective Date: 06/07/91
Expiration Date: 03/31/96
Abstract-Date: 09/22/93
Page: 371
-------
Facility Name: Daishowa America Co. - Pott An — . — .
Facility Description: Thermo-methanical pulp and paper mill with deinking •
Monitoring
tirait ELGs WQSs BPJ Only
Basis: J. 1 - -
Storm UQ
Special BMPs Water Sediment Survey
Conditions: 1 J. * -
UET WET Testing Multiple Tiered
Limits Only Categories Limits Other
1 I - - -
Survey TRES HDLs Monitoring Other
Abstract Information:
Complete; Outfall 001 •
Outfall- 001 | Receiving Water: St. of Juan de Fuca/Port Angel I Treatment. KU. «=>
Amount/Components :
A.49 HGO mill wastewater and stormwater.
Parameter
Acute UET
BOOS
Flow
OSG
Other
P«
TSS
—
Limitations
dai ly
Average
M/A
N/A
4534.000000 Ib/d
N/A
N/A
Report mgd
N/A
N/A
N/A
N/A
M/A
Report
6812.000000 Ib/d
N/A
dai ly
Maximum
N/A
Report
8637.000000 Ib/d
N/A
N/A
Report mgd
N/A
15.000000 mg/l
N/A
Report
N/A
Report
12703.000000 Ib/d
N/A
Other
See below
See below
Production (see belo
w)
Between 5.0 su and 6
.0 su
See below
Monitoring Requirements
Frequency
2/yr
1/day
continuous
1/week
1/day
Continuous
1/day
Sample Type
Grab
24Jir composite
Grab
24 hr composite
Limitations/Monitoring Basis: f deinking facilities. In addition, TSS
laras £s s IS.HS » s '^Suhs-i1 bsrvasr sastss"1"-
ssaa? a'SATSMS-Jis B~H"fe
a1 rrrS^SnXS'pis^^^^^^^^^
SSffAS S-STJSIVS SrStf A? » Fi- ° ^i; '-i-4»=S 5ST'"10
, , ,?
Special Conditions Basis: ^^ii^uina «r,prial studies- 1) paniculate monitoring study to look at the
Permittee required to perform the f o lowing specialrt^ es. 1) Par^ and effluent treatment plant to determine
participate fraction of the effluent; 2)chemical analysis or ootn in able metals; 3) dilution zone study
^eatment and removal efficiency for pH hardness ^^f^nd total recweranen_ ^ ^.^ ^.^ s^dy
-
establishing water quality limits; 6) storm water runoff |™°V r° farac todete^m1ne most sensitive species (must
permittee is required to conduct interim chrome toxicity *^ ^u^*ej^5 T°^d °™e NOEC. Effluent and water quality
Sust bein accordance wftt , EPA chronic tes ing methods and epo * ^he IC25 and the HOE^^ ^ ^ gre
in^ getl^
Permi«ee 'l'^c'S^ are £ used and
Page: 372
-------
Facility Name: Daishowa America Co. - Pott An
Facility Description: Thermo-methanical pulp and paper mill with deinking
Permit Number: WA0002925
si!
SIC Code: 2611
Effective Date: 11/26/90
Expiration Date: 11/27/95
Abstract Date: 09/09/93
Page: 373
-------
cftity N«ne: Occidental Chemical Corp.
Permit Number: WA0037265
acflity Description: Inorganic chemical and fertilizer manufacturer
SIC Code: 2812
raft
asis:
ELGs
J.
UQSs
BPJ
I
Monitoring
Only
WET
Limits
WET Testing
Only
I
Multiple
Categories
Tiered
Limits
Other
pecial
onditions:
BHPs
Storm
Water
Sediment
J.
WQ
Survey
J.
Bio
Survey
J.
TRES
J.
MDLs
Monitoring
I
Other
bstroct Information:
Cotqplete; Outfall 002
jtfall: 002 \ Receiving Water: Hylebos Waterway
| Treatment: Not described.
mount/Components:
24.5 HGO of process wastewater
and stormwater.
Parameter
Cu
Flow
HH3 (T)
Hi
Pb
PH
Tcrp.
TRC
TSS
Limitations
Monthly
Average
N/A
6.100000
ug/l
N/A
H/A
7.300000
H/A
Ib/d
1.400000
N/A
Ib/d
1.200000
N/A
Ib/d
N/A
Report
N/A
H/A
N/A
12.000000
ug/l
348.000000
N/A
Ib/d
Daily
Maximum
N/A
12.700000
N/A
24.500000
ug/l
mgd
12.500000
N/A
Ib/d
2.500000
N/A
Ib/d
2.500000
N/A
Ib/d
N/A
H/A
H/A
32.000000
H/A
35.000000
ug/l
697.000000
H/A
Ib/d
Other
See below
See below
See below
See below
See below
Between 6.0 su and 9
.0 su
Units: degrees Celci
us
See below
See below
Monitoring Requirements
Frequency
1/month
1/day
1/month
1/month
1/month
Continuous
Continuous
4/day
1/month
Sample Type
24hr composite
estimate
24Jir composite
24hr composite
24hr composite
Record
record
24hr composite
24hr composite
ongy be estimated. Within 2 years, all flows must be measured with direct flow monitoring methods.
FtM iTmoasured daily at the effluent outfall, weekly at the intake and monthly at the ammonia faciitypH
limitationis based on the general guideline at 40 CFR Part 401.17 for continuously monitored pH. Allowable
excursions are further limited to a min. of 3.5 and a max. of 11.0 with an exemption of a continuous excursion of
^mornhan 60 minutes not exceeding one percent of the operating time each month. pH imit was based on the fact
that the effluent at the facility is not defined enough to ensure that all known, available and reasonable methods
of treatment are being applied and that the limit will be sufficiently protective. Enforcement actions for
excursions to consider major power failures or mechanical breakdowns. Limitations for TSS TRC, Cu, Pb, and Hi are
S W BPT/BCT and BAT inde^O CFR Part 415 for chlor-alkali diaphragm cells Ammonia limits are based on BAT at
40CFR 418.23. Sampling for metals and anmonia must be conducted twice weekly for a total of. eight samplesCuring
February Hay August, and November for the first year of the permit to access the variability of the effluent and
the need for more frequent sampling. The TSS limit is measured by taking the net value of the discharge minus the
inlate value. Temperature isTequired to be monitored in the effluent and the receiving stream. Temperature is
limited at 32 dcgT^s celcius when the most recently measured receiving water temperature ,s ess than 18 5 degrees
celcius. Excursions above the limit will not be considered violations if they do not exceed 15 minutes in any 6
hour period and an instantaneous maximum of 34.5 degrees celcius isnot exceeded. A discussion of the basis for the
remaining parameters and monitoring conditions was not provided.
CcgitionsBasis.^ ^ ^ .^^ ^^ .ntemal Direct and treated
noncontactl and effluent is required. The analyses for all of the sources will include TSS, metals, volatiles,
SKolatilesT and PcSs. Analyses for the effluent and intakes will include NH3, PH, TRC, O&G, and temperature.
ladling for this study must coincide in the second year of the permit term with one sampling for the acute and
chronic biomonitoring study. Permittee must develop and implement a sediment baseline study plan to address both
Seal Sses and biological studies of the sediment. The plan is to be submitted within 18 months °f written
notice that CERCLA clean-up activities have been completed. After approval, the sampling must be conducted in the
month of March or April. If the chemical concentrations exceed interim sediment creitena, biological testing must
Page: 374
-------
Facility Description: Inorganic chemical and fertilizer manufacturer
Permit Number: WA0037265
SIC Code: 2812
procedureare soecifed ' - r^ul'rements, analyses to be performed and sampling and QA/QC
Claced in the Jfm?i ?*' rf 2 3 2 c°nd'V-onf such as a sediment impact and/or sediment recovery zones may be
placed in the permit if adopted for the discharge area. An effluent mixing study is required to determ ne the
thf nf °J ^fluent.fd receiving water mixing and the degree to which effluent, prior to complete Sg returns to
the plant through its intake. Results may be used to issue a regulatory order or to modify the permit ?o require a
Um^rwm°no?0v T?tSJiS ^l J^ ^ "?** mUSt include a "^ing waterbuffering study to verify that ihl pH
limit will not violate WQSs. A discharge reduction and elimination study is required to evaluate methods of
approaching or achieving a zero-contaminant discharge. The study must evaluate sources such as high temperature
cooling waters, chlorine stripping and cooling losses and sodium sulfate purge. The pollutants of concern for
reauireS ThlTutf h-nClU> °-' Pb; "J'-^ ?' B°th effluent acute an§ chronic biKo^stSiSSre
After one vlar ?ho mnl? ^'-n9 8tl^ lnc Vde^ acute toxicity testing every two months with ?hree organisms.
uith FPi ^h H 5 sensitive species will be used to conduct the testing on a quarterly basis in accordance
with EPA methods for measuring acute toxicity. If acute toxicity is found, the permitting author tv must
ss ss.'
of
.tor.
Effective Date: 12/15/91
Expiration Date: 11/15/96
Abstract Date: 04/12/93
Page: 375
-------
Facility Ham: Scott Paper Co at Oconto Falls P'nnit ^er: WI0000531
Facility Description: Deinks and pulps secondary fibers for shipment to paper mill SIC Code. 2611 j |
Monitoring
Limit ELGs WQSs BPJ Only
Basis: i J. I *-
Storm WQ
Special BHPs Water Sediment Survey
Conditions: ; -
WET WET Testing Multiple Tiered '
Limits Only Categories Limits Other
£ JL — *•
Survey TRES MDLs Monitoring Other
2. - I - J-
Abstract Information: . . n,n
Complete; Outfalls 001 (A and B for abstracting purposes), 004, 007, and 010.
OUtfall: 001 | Receiving Water: Oconto River Treatment: AS
A^Vis^nconsisting of treated deink process wastewater, stormwater runoff, lagoon underdrain, landfill leachate, and
belt filterpress filtrate.
Parameter
1,a,4,5-Tetrachlo
robcnzenc
2,3,7,8-TCOD
3,4,6-Trichloroph
cnol
3,3-Dichlorobenzi
dine
«, A '-DOT
Acrolein
Acute WET
Aldrin
Alphn-BHC
Beta-BHC
BI1C
BOOS
Chlordane
Chronic WET
Cr+6
Dioldrin
Endosulfan sulfat
e
Endrin
Limitations
Monthly
Average
N/A
N/A
H/A
N/A
H/A
H/A
N/A
H/A
H/A
N/A
H/A
N/A
N/A
N/A
N/A
N/A
H/A
N/A
N/A
N/A
N/A
H/A
1316.000000 Ib/d
N/A
N/A
N/A
N/A
H/A
H/A
N/A
N/A
N/A
N/A
H/A
N/A
H/A
Dai ly
Maximum
N/A
Report mg/l
H/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/ I
N/A
Report mg/l
N/A
Report mg/ I
N/A
Report
H/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
H/A
Report mg/l
2534.000000 Ib/d
N/A
N/A
Report mg/l
H/A
Report
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
Other
See below
See below
See below
See below
Monitoring Requirements
Frequency
1/year
1/year
1/year
1/year
1/year
1/year •
once
once
1/year
1/year
1/year
1/day
1/year
once
once
1/year
1/year
1/year
Sample Type
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
grab
24hr fw composite
24hr fw composite
24hr fw composite
Page: 376
-------
Facility Name: Scott Paper Co at Oconto Falls Permit Nuraber: ^^
Facility Description: Deinks and pulps secondary fibers for shipment to paper mill «.IC Codc. ^
Flow
Fluoranthene
Gamma-BHC
Heptachlor
Hexach I orobenzene
Hg (T)
P (T)
PCBs (T)
Pentach lorobenzen
e
Pentach lorophenol
pH
Temp.
Toxaphene
TRC
TSS
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
1813.000000 Ib/d
N/A
N/A
Report MGD
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/ 1
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report
N/A
Report F
N/A
Report mg/l
N/A
Report mg/l
3367.000000 Ib/d
N/A
See below
Between 5.0 su and 9
.0 su
See below
Continuous
1/year
1/year
1/year
1/year
1/year
1 /month
1/year
1/year
once
continuous
1 /month
1/year
once
1/day
Record
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
record
grab
24hr fw composite
grab
24hr fw composite
Limitations/Monitoring Basis: ' ' " • —
Page: 377
-------
1 — • .. Permit Number: WI0000531
Facility Homo: Scott Paper Co at Oconto Falls
Facility Description: Deinks and pulps secondary fibers for shipment to paper mil SIC Code- 2611 |
Outfall: 001A | Receiving Water: Oconto River I Treatment. AS ^
O.O^Hro" consisting of spent sulfite liquor lagoon discharges
Parameter
Al
Aldrin
BOOS
Cr+6
Flow
Pcntach 1 orophcnol
pH
TRC
TSS
Limitations
Monthly
Average
N/A
N/A
43.000000 ng/l
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
H/A
N/A
N/A
N/A
N/A
Dai ly
Maximum
1496.000000 ug/l
N/A
N/A
N/A
N/A
Report mg/l
N/A
28.400000 ug/l
N/A
Report MGD
27.800000 ug/l
N/A
N/A
Report
N/A
37.000000 mg/l
N/A
Report mg/l
Other
See below
See below
See below
Monitoring Requirements
Frequency
1/day
1/day
1/day
1/day
Continuous
1/day
1/day
1/day
1/day
Sample Type
24hr composite
24hr composite
24hr composite
grab
Total
grab
grab
grab
24hr composite
l" a^HS^^^r s^^-^-s «" "" « ~ -•» "- "a
limits Mere based on WRH water quality-based considerations. ____.
Outfall: 001B | Receiving Water: Oconto River I Treatment. AS
*^Y?TS^™-«tina Of wastewater treatment plant effluent and lagoon underdrain discharges.
Parameter
1,2,4,5-Tetrachlo
robonzcne
Z,3,7,8-TCDD
2,4,6-Trichloroph
cnol
3,3-Oichlorobenzi
dine
4, 4'-DOT
Acroloin
Acute WET
Aldrin
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Dai ly
Maximum
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report
N/A
Report mg/l
Other
See below
See below
Monitoring Requirements
Frequency
1/year
1/year
1/year
1/year
1/year
1/year
1/year
once
Sample Type
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
24hr fw composite
Page: 378
-------
Facility Name: Scott Paper Co at Oconto Falls D«,.m«* u.. u i,,™™,r,,, "
k [Facility Descriptlon: Deinks and pulps secondary fibers for shipment to paper mill SIC Code- 2611
w Alpha-BHC
Beta-BHC
BHC
BODS
Chlordane
Chronic WET
Dieldrin
Endosulfan sulfat
e
Endrin
Flow
Fluoranthene
Gamma-BHC
Heptachlor
Hexach I orobenzene
Hg (T)
Other
P (T)
PCBs (T)
Pentach I orobenzen
e
Pentach lorophenol
PH
Temp.
Toxaphene
TSS
N/A
N/A
N/A
N/A
N/A
N/A
1504.000000 Ib/d
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
1813.000000 Ib/d
N/A
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
2896.000000 Ib/d
N/A
N/A
Report mg/l
N/A
Report
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report HGD
N/A
Report mg/l
N/A
Report mg/ 1
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report
N/A
Report F
N/A
Report mg/ I
3367.000000 Ib/d
N/A
See below
Chlorine See below
See below
Between 5.0 su and 9
.0 su
1/year
1/year
1/year
1/day
1/year
1/year
1/year
I/year
1/year
Continuous
1/year
1/year
—
1/year
1/year
I/year
once
1 /month
1/year
1/year
once
continuous
1 /month
1/year
1/day
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
24hr fw composite
24hr fw composite
24hr fw composite
Record
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
grab
24hr fw composite
• 24hr fw composite
24hr fw composite
24hr fw composite
record
grab
24hr fw composite
24hr fw composite
Limitations/Monitoring Basis: "
• — » ,
Page: 379
-------
Facility Noroo: Scott Paper Co at Oconto Falls
Outfall: 004 | Receiving Water: Oconto River
Permit Number: UI0000531
Facility Description: Deinks and pulps secondary fibers for shipment to paper mill
SIC Code: 2611
| Treatment: AS
0.o'l95HGO consisting of spent sulfite liquor lagoon discharges
Parameter
Acute WET
Aldrin
BOOS
Chronic WET
CM (T)
Cr+6
Flow
Hitrobcnzene
Pentachlorophenol
pH
TRC
TSS
Limitations
Monthly
Average
N/A
N/A
A.980000 mg/d
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
Report
N/A
N/A
N/A
Report mg/l
N/A
Report
44.800000 ug/l
N/A
N/A
38.400000 ug/l
N/A
Report HGD
N/A
N/A
N/A
Report mg/l
27.800000 ug/l
N/A
N/A
Report
N/A
37.000000 ug/l
N/A
Report mg/l
Other
See below
See below
See below
See below
See below
See below
Between 5.0 su and 9
.0 su
See below
Monitoring Requirements
Frequency
once
1/quarter
1/month
once
1/quarter
1/quarter
Continuous
1/quarter
1/quarter
1/month
1/quarter
1/month
Sample Type
grab
grab
24hr composite
grab
grab
grab
Record
24hr composite
grab
grab
grab
24hr composite
procedures described for Outfall 001 apply. __=_==_==_=_=——=—=———=
Outfall: 007 | Receiving Water: Oconto River
Treatment: None
fUnounv/i.uwtx>iH.Mu.:>.
20,000 gpd noncontact cooling water
Parameter
Flow
•Limitations
Monthly
Average
N/A
N/A
Daily
Maximum
N/A
Report MGD
Other
Monitoring Requirements
Frequency
1/week
Sample Type
total
Page: 380
-------
Facility Name: Scott Paper Co at Oconto Falls " — " — " — '
Permit Number: WI0000531
Fac,l,ty Description: Deinks and pulps secondary fibers for shionent to paperm,-li -IC c d „.,,'
Temp.
N/A
N/A
N/A
Report oF
Limitations/Monitoring Basis:
The monitoring requirements were retained from the previous permit
1/week
grab
Outfall: 010 | Rece,V1ng Water: Oconto River , Treatraent: None
Imount /rompi-ii-ionf o .
0.154 MGD clarifier site groundwater
Parameter
BODS
Flow
PH
TSS
Limi tat ions/Mom" torin
The monitoring r
*=^=— =— ==»=^e==a
Special Conditions Ba
When the limits
calculate the li
instructions for
than 45 days bef
are provided, sp
testing. The pe
addressing the g
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
Report mg/l
N/A
Report MGD
N/A
Report su
N/A
Report ng.k
Other
g Basis:
equirements were retained from the previous permit.
Monitoring Requirements
Frequency
1 /month
1 /month
1 /quarter
1 /quarter
— •
Sample Type
grab
estimate
grab
grab
— .
LffeUive Uale: U4/U8/yi Expiration Date: 12/^1/97 " ., ,
t— —=—=—=—= __ _. >£-/3i/vr Abstract Date: 06/04/93
Page: 381
-------
FfflfiUty "«"»: Wise Elec Power Co - Oak Creek . ••
FacUity Dcscrf
,.11.11 .111 IIIL UIIHUIIULUIIUM* IHUBIH
Limit
[Basis:
Special
Conditions:
ption: Cc
MMBMMMM"^^
ELGs
BMPs
J.
al-fired steam electric power plant rated at 1045 MW _:
WQSs
I
Storm
Water
I
BPJ
Sediment
Monitoring
Only
1
WQ
Survey
WET
Limits
Bio
Survey
WET Testing
Only
J.
TRES
Multiple
Categories
MDLs
' ' I
Tiered
Limits
Monitoring
l • :
Other
J.
Other
J.
AtetTa«ia!°TtfaUs 001 002, 007 (representing 003, 004, 005, and 006), 008, 009, 012, 103, and. 303. ' __
Outfalls 001 | Receiving Water: Lake Michigan I Trea m . — :
of condenser cooling and hydrovactor waters, boiler blowdown diverted from Outfall 007, fire
protection water
Parameter
Flow
PH
Temp.
TRC
•, stormwater, and mis
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
;c
Limitations
Dai ly
Maximum
N/A
Report MGD
N/A
N/A
N/A
Report oF
N/A
Report mg/l
Other
Between 6.0 su and 9
.0 su
See below
•
Monitorin
Frequency
Continuous
1/day
Continuous
1/day
•
g Requirements
Sample Type
Record
grab
Record
grab
Limitations/Monitoring Basis:
While the limitations are ?lways.eff^we'
The pH limit is based °"w'f°
are based on State promulgated
Generating category. Because
effluent limitations guidelines for the
concentration is I mi ted to 0.2 mg/l for any day when s
generating unit. In accordance H1" 290, Wise. Adm in. . uoae wn chlorine is discharged for
Steam Electric Power Generating. The maximum TRC is "™tea *p ".uor quality standards. The permittee is
more than 120 min. per operating generating unit P^r day based on water ^ ^ he TRC Discharged is to be
required to develop a curve based on data collected on the TRC discharged ver ^ ^.^ ^
measured by taking a grab swple.during the P^^^lorine discharge of ^ch even ^ iff^ Durat,on of
days after commencement of chlorination. Temperature mon tonng ^s ™fg™ P d a^e recorded dal-ly/ they may
1 of floating solids or visible foam in
remittee is reauired to monitor only during periods of discharge.
Pe^2 S!(4 (c)) water quality standards. TRC monitoring conditions
fJ?u;°t guide nes Wise Admin. Code MR 290, Steam Electric Power
effluent guiaeiine facility was granted a variance from
maximum discharge of TRC. The maximum TRC
for less than 120 win/day per operating
Effluent Guideiines Limitations for
Outfall: 002 | Receiving Water: Lake Michigan
of fire protection water and stormwater runoff from roof drains
Parameter
Flow
OSG
pH
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
Limitations
Dai ly
Maximum
N/A
Report MGD
N/A
Report mg/l
N/A
Report
Other
Between 6.0 su and 9
.0 su
other than trace amounts.
Monitorin
Frequency
1/quarter
1/quarter
1/quarter
g Requirements
Sample Type
total daily
grab
grab
Page: 382
-------
• • . Permit Number: WI0000914
. racuny Descr,pt,on: Coal-fired steam electric power ptant rated at 1045 HW ,.„ „ . ._. '
f TSS
N/A
N/A
N/A
Report mg/l
1 /quarter
24hr fw composite
Liimtatlnns/Mnrn*-r,,-in,., Rail'-!- •
The pH limitation was water quality- based. The basis for the other monitoring requirements were not diseu^H
Outfall: 007 Receiving Water: Lake Michigan , Treatment: cfl— H"
1 Amount/Components: .
s?o?mCS aarcoarfpir^uno?f.treatment Plam efflU6nt «""»«'"• °f l« volume waste, noncontact cooling water.
Parameter
1,2,4,5-Tetrachlo
robenzene
2,3,7,8-TCDD
2,4,6-Trichloroph
enol
3,3-Dichlorobenzi
dine
4, 4' -DDT
Acrolein
Acute WET
Alpha-BHC
Beta-BHC
BHC
Chlordane
Cu (T)
Dieldrin
Endrin
Fe (T)
Flow
Fluoranthene
Gamma-BHC
Heptachlor
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Report
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Report mg/l
N/A
N/A
N/A
N/A
N/A
Report mg/l
N/A
Report MGD
N/A
N/A
N/A
N/A
N/A
N/A
Other
113 Ib/year
3.6 x 10(-6) Ib/year
113 Ib/year
5 Ib/year
0.006 Ib/year
113 Ib/year
See below
1.1 Ib/year
1.1 Ib/year
1.1 Ib/year
0.16 Ib/year
0.021 Ib/year
1.1 Ib/year
66 Ib/year
1.1 Ib/year
0.05 Ib/year
Monitoring Requirements
Frequency
1/year
1/year
1/year
1/year
1/year
1/year
2/year
1/year
1/year
1/year
1/year
1 /month
1/year
1/year
1 /month
continuous
1/year
1/year
1/year
Sample Type
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
24hr fw composite
H4hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hf fw composite
total daily
24hr fw composite
24hr fw composite
24hr fw composite
Page: 383
-------
(Facility Name: Wise Elec Power Co - Oak Creek .
Facility Description: Coal-fired steam electric power plant rs
Hexachlorobenzene
Ha
O&G
Other
PCBs (T)
Pentachlorobcnzen
e
PH
Toxaphene
TSS
j _
N/A
N/A
N/A
N/A
601.000000 Ib/d
15.000000 mg/l
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
1202.000000 Ib/d
30.000000 mg/l
N/A
N/A
N/A
N/A
1218.000000 Ib/d
20.000000 mg/l
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Report
N/A
N/A
6092.000000 Ib/d
100.000000 mg/l
ted at 1045 MW
________ ____——
0.2 Ib/year
0.25 Ib/year
Endosulfan: 1.1 lb/y
ear
0.019 Ib/year
113 Ib/year
Between 6.0 su and 9
.0 su
0.23 Ib/year
SIC code: tvai
1/year
1/year
1/week
1/year
1/year
1/year
1/day
1/year
1/day
24hr fw composite
24hr fw composite
grab
24hr fw composite
24hr fw composite
24hf fw composite
grab
24hr fw composite
24hr fw composite
. • • —
Limitations/Monitoring .Basis: nmmulaated techno logy- based effluent guidelines Wise. Admin. Code NR 290,
The TSS and O&G limits are based on State P"™«5*f^f JErthly average limits are fixed, the TSS- daily maximum and
Steam Electric Power Generating category, "b'l* "JV*5 m°n™^ t wastewater streams, with equations provided in
the O&G concentration limits are to be calculated using * u,, invertebrate and a vertebrate, is required
the permit. Based on URH reco ^f'™5' a?u** W" cies follow ng EPA methods, primary and secondary control
using at least 3 freshwater test, 48 and 96 hour, species touowuig monitoring and limitations for
Hater, and 2 dilutions. In conformance with Wise Adnnn Code ™ ^j'. %^ -t. DefauU concentrates are
bioaccumulating toxic substances to the Great Lakes have been inc "°ea i H poUutants are below detection
provided for some pollutants to determine "^a""twl^^™f normal or maximum levels of discharge. If first
levels. Sampling for b'°acFV™^tlV* ™SC» Lbstnaces then no additional monitoring is required. If substances
sailing reveals no detectable bioaccumulative substnaces ™e" "° ™, t de the EPA test methods, MDL, and
arVdetectcd, then frequency of 1/year applies. The table «* l«£|» ™c££s i|82 metal cleaning waste effluent
monitoring r^'r^jt%hHo™t°!jm"y°re water quality-based per Wise. Admin. Code NR 102.04(4) ><=".
ount of uncontaminated storm water runoff from the north yard and emergency overflow from Outfall 007
ff. —
• . • -^ *-_„„ Monitoring Requirements
Monthly
Average
N/A
N/A
Limitations/Monitoring Basis:
reported as a bypass.
Outfall: 009
Sum Other Frequency Sample Type
N/A Report as bypass
Report .
authorized to discharge untreated storm water runoff except under circumstances
of that generated by a 10-year, 24-hour rainfall event. Any discharge must be
Receiving Water: Lake Michigan
Treatment: None speuiiieu.
c
reserve coal pile runoff overflow
parameter
Flow
Monthly
Average
N/A
N/A
Limitations
Dai ly
Maximum
N/A
Report MGD
Other
•ZQ/.
Monitoring Requirements
Frequency
1 /month
Sample Type
total
-------
Facility Name: Wise Elec Power Co - Oak Creek Permit Number: WI 0000914
Facility Description: Coal-fired steam electric power plant rated at 1045 MW SIC Code: 4931
TSS
N/A
N/A
N/A
Report mg/l
1 /month
grab
•
Limitations/Monitoring Basis:
The basis for the monitoring conditions was not discussed.
Outfall: 012 Receiving Water: Lake Michigan Treatment: Scr
Amount/Components:
3.6 MGD consisting of intake screen backwash.
Parameter
Flow
Limitations
Monthly
Average
N/A
N/A
Dai ly
Maximum
N/A
Report MGD
Other
Monitoring Requirements
Frequency
1 /month
Sample Type
estimate
Limitations/Monitoring Basis:
The monitoring of flow from Outfall .012 was continued from the previous permit.
Outfall: 103 Receiving Water: Internal to Outfall 003 Treatment: None specified.
Amount/Components :
0.892 HGD discharge from the Unit 5 fly ash and bottom ash hydrovactors
Parameter
Flow
O&G
TSS
Limitations
Monthly
Average
N/A
N/A
15.000000 mg/l
N/A
30.000000 mg/l
N/A
Daily
Maximum
N/A
Report MGD
20.000000 mg/l
N/A
100.000000 mg/l
N/A
Other
Monitoring Requirements
Frequency
2/month
1/year
2/month
Sample Type
total
grab
24hr fw composite
Limitations/Monitoring Basis:
The limits for TSS and O&G are applied to the net discharge of pollutants (effluent concentration minus influent
concentration), in accordance with 40 CFR 122.45(g). Thus, the permittee is also required to monitor the influent
concentrations of TSS and O&G. The TSS and O&G limits are based on State promulagated techno logy- based effluent
guidelines Wise, Admin. Code NR 290, Steam Electric Power Generating category for low volume waste. The monitorinq
basis was not otherwise discussed.
Outfall: 303 | Receiving Water: Internal to Outfall 003 | Treatment: None specified.
Amount/Components :
Unspecified amount consisting of boiler blowdown
Parameter
Flow
O&G
Limitations
Monthly
Average
N/A
N/A
15.000000 mg/l
N/A
Daily
Maximum
N/A
Report MGD
20.000000 mg/l
N/A
Other
Monitoring Requirements
Frequency
2/month
1/year
Sample Type
total
grab
Page: 385
-------
Facility Home: Quaker State Oil Refining Corp
Permit Number: WV0004626
"acility Description: Manufactures finished oil products from Pennsylvania grade crude oil
SIC Code: 2911
Outfall: 003 | Receiving Water: Unnamed trib. to Congo Run
Treatment: Not described
Amount/Components:
Uncontominatcd storm water
Paromoter
Chloride
COD
Flow
O&G
P«
TOO
TSS
Limitations
Monthly
Average
Report
Report
Ib/d
mg/l
Report
Report
Ib/d
mg/l
N/A
Report
MGD
Report
Report
Ib/d
mg/l
N/A
N/A
Report
Report
Ib/d
mg/l
Report
Report
Ib/d
mg/l
Daily
Maximum
N/A
N/A
Report Ib/d
Report mg/l
N/A
Report MGD
Report Ib/d
10.000000 mg/l
N/A
N/A
Report Ib/d
Report mg/l
Report Ib/d
Report mg/l
Other
Monitor tnin. and max
. su
Monitoring Requirements
Frequency
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
Sample Type
grab
grab
estimate
grab
grab
grab
grab
Limitations/Monitoring Basis:
A discussion of limitations and monitoring requirements was not provided.
Special Conditions Basis:
Within 9 months, the BMP plan must be updated because of changes at the facility and changes to regulations.
Additionally, conditions considered good housekeeping practices are specified as important parts of a BMP plan and
are identified as having potential to minimize soil contamination, minimize pollutants discharged in storm water,
and protect the ground water. These include: 2/week inspection of the oily sewer and the maintenance of a log of
the same; 1/week inspection of manufacturing, storage, and loading areas for drippage/leakage and the remediation of
the same; inspection of all pumps, lines, and valves for drippage/leakage and the remediation of the same; proper
arid prompt removal of stained soil and gravel on the facility site; and prevention of overflows through precautions.
Schedules are set forth for compliance with 001B conditions by 3/21/94, compliance with the installation of a 1 mgd
holding tank, which will support a 10yr, 24hr rainfall event, by 3/21/93, and compliance with the implementation of
the groundwater monitoring plan (specific requirements are set out) by 3/21/92; compliance reports must be submitted
within 14 days of the milestone date. The facility must also submit, within 6 months, an As treatability and
economic analysis study. The latter two conditions are based on the facility's storm water management plan and
groundwater management plan as outlined in specifically cited correspondence. Other special conditions and
justifications include the following: 1) annual reporting of average daily crude oil processing; this is specified
because limits are based on fee raes and changes will dictate the need for permit modifications; 2) a prohibition of
bypassing; this is reiterated to emphasize bypass prohibitions; 3) quarterly reporting of removal efficiency of
BOOS, TOC, 08G, and COO because this information is needed to evaluate O&M based on specific removal rates cited
from the development document; 4) semi-annual monitoring of intake water from each well for COD, TOC, pH, Fe (T), Mn
(T>, and chloride and the submission of test results within 30 days; this condition is necessary since the facility
is using groundwater as makeup water and intake water pollutants must be identified so that they may be discharged;
5) within 60 days, the removal of stained soil and gravel in the unnamed tributary to the Congo Run and monthly
inspection of the weir prior to the unnamed tributary; these conditions result from oily sediment and solids build-
up which are problems noted in previous inspections; and 6) a prohibition of untreated cooling tower blowdown
-------
Facility Name: Wise Elec PoHer Co - Oak creek
~^
TSS
N/A
N/A
Limitations/Monitoring Basis
N/A
Report mg/l
1/month
Permit Number: WI0000914
• .
SIC Code: 4931
MaaEaBRBa
grab
uas not discussed.
^iiL^lIj^^EEEL^^^^
Amount/Components:
3.6 HGD consisting of intake screen backwash.
—-=^=«=«==«==1
Treatment: Scr
Parameter
Flow
.
Monthly
Average
N/A
N/A
. I i .
Daily
Maximum
N/A
Report MGD
— . .
Other
Basis-
Amount/Components .-
Parameter
Flow
O&G
TSS
012 was continued from the previous
Internal to Outfall 003
•
;it 5 fly ash and bottom ash hydrovactors
Limitations
Treatment: None specified.
I ' -^
Limitations/Monitoring Basis- .
Receiving Water: Internal to Outfall 003
[Outfall: 303
Amount/Components:
Unspecified amount consisting of boiler blowdown
Parameter
Treatment: None specified.
Flow
O&G
Page: 385
-------
acUfty Name; Wise Etec Power Co - Oak Creek
n^riotion: Coal-fired steam electric power plant
••WMM
TSS
30.000000 mg/l
N/A
100.000000 mg/l
N/A
2/month
Permit Number: WI0000914
'
SIC Code: 4931
^^=^o«
24hr fw composite
conditions was not^scusse^
prohibited. ~
(Effective Date: 09/30/91
Expiration Date: 06/30/96
Abstract'Date: 06/09/93 j
Page: 386
-------
Facility Name: Shawano Paper Hilts Permit Number: WI0001341
Facility Description: Produces lightweight specialty paper from purchased pulp SIC Code: 2647
Monitoring WET WET Testing Multiple
Limit ELGs WQSs BPJ Only Limits Only Categories
Basis: ^ J_ z 1 -_ I z
Storm WQ Bio
Special BMPs Water Sediment Survey Survey TRES MDLs
Conditions: ^ ^ ^ - - -
Tiered
Limits Other
- I
Monitoring Other
- . J.
Abstract Information:
Partial; Outfalls. 001, 002 (representative of 101) and 102.
Outfall: 001 | Receiving Water: Wolf River | Treatment: Floe, CAC
Amount/Components":
2.24 MGD consisting of excess intake water and process wastewater treatment systeir bypass
Parameter
Flow
Limitations
Monthly
Average
N/A
Report MGD
Daily
Maximum
N/A
Report MGD
Other
Monitoring Requirements
Frequency Sample Type
1/day .estimate
Limitations/Monitoring Basis:
Only flow monitoring is required at Outfall 001 because limitations apply at Internal Outfall 101. These
limitations are the same as those shown for Outfall 002. Monitoring is required at Outfall 101 during bypass
events. All outfalls contain a water quality-based prohibition of discharge of floating solids or visible foam in
other than trace amounts.
Outfall: 002 | Receiving Water: Wolf River | Treatment: Floe, CAC, PC
Amount/Components :
1.61 MGD consisting of treated process wastewater and groundwater
Parameter
1,2,4,5-Tetrachlo
robenzene
2,3,7,8-TCDD
2,4,6-Trichloroph
enol
3,3-Dichlorobenzi
dine
4, 4' -DDT
Acrolein
Acute WET
Alpha-BHC
Beta-BHC
BHC
BODS
Chlordane
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Report
N/A
N/A
N/A
N/A
N/A
N/A
1774.000000 Ib/d
N/A
N/A
N/A
Daily
Maximum
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
N/A
Report
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
3283.000000 Ik/d
N/A
Report mg/l
N/A
Other
See below
Monitoring Requirements
Frequency
1/year
1/year
1/year
1/year
1/year
1/year
4/year
1/year
1/year
1/year
1/day
1/year
Sample Type
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
grab
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
Page: 387
-------
FaciUty Hamc: Shawano Paper Hills Permit Number: WI0001341
Facility Description: Produces lightweight specialty paper from purchased pulp SIC Code: 2647
Chronic WET
Dioldrin
Endosulfan sulfat
e
Endrin
Flow
Fluornnthcno
Gactna-BHC
Hoptachlor
Hexachlorobcnzene
HB CT)
HH3-H
P (T)
PCBs (T)
Pcntachlorobcnzcn
c
P«
Tewp.
Toxaphcnc
TSS
M/A
Report
N/A
N/A
M/A
N/A
N/A
N/A
N/A
Report HGD
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Report mg/l
N/A
Report mg/l
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Report F
N/A
N/A
1163.000000 Ib/d
N/A
N/A
Report
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
N/A
Report MGD
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
N/A
Report mg/l
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
Report mg/l
N/A
N/A
Report
N/A
Report F
Report mg/l
N/A
2276.000000 Ib/d
N/A
See below
Between 5.0 su and 9
.0 su
2/year
1/year
1/year
1/year
1/day
1/year
1/year
1/year
1/year
1/year
1/quarter
1/quarter
1/year
1/year
1/day
1/week
1/year
1/day
grab
24hr fw composite
24hr fw composite
24hr fw composite
continuous
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
continuous
grab
24hr fw composite
24hr fw composite
•
Limitations/Monitoring Basis:
Limitations for BODS and TSS are based on state promulgated treatment technology based effluent limitations
(Wisconsin Admin. Code NR 284) and are the same as those in the previous permit. Limits for pH are based on State
WQSs. The pH values must not be outside the required range for more than 446 minutes in any calendar month.
Individual excursions from the required range must not exceed 60 minutes. No individual excursions are allowed
outside the ronge of 4.0 su to 11.0 su. The permittee is required to report any excursion from the limits.
Monitoring for temperature, ammonia, P (T), bioaccumulating toxic substances, acute WET and chronic WET are required
because toxic substances are known to be present, but are not expected to occur in amounts of significant concern.
Acute toxicity testing (48-hr and 96-hr tests) is required 4/year for 2 years and again once during the year prior
to permit expiration, following procedures provided in the permit. These procedures include 5 dilutions and 2
species. Control waters are required to be collected upstream from the discharge and within 72 hours of test
limitation grab samples. Secondary control waters must have water pH, hardness and alkalinity similar to the
receiving water, and must be approved by the Wisconsin DNR prior to use. Renewal frequencies are specified for each
test. Species are limited to Ceriodaphnia dubin and fathead minnows for chronic tests; Daphnia magna may be used in
place of Ceriodaphnia for acute tests. If one species demonstrates clear sensitivity it may be used alone instead
of two species. Additional testing is required if the test results are positive. While these limitations also
apply to Internal Outfall 101 to Outfall 001, monitoring for BODS, flow, TSS, temp, and pH at Outfall 101 is
required only during each bypass event using grab samples.
Page: 388
-------
Facility Name: Shawano Paper Hills
Permit Number: WI 0001341
Facility Description: Produces lightweight specialty paper from purchased pulp
SIC Code: 2647
Outfall: 102 | Receiving Water: Internal to Outfall 002 j Treatment: None specified.
Amount/Components :
Unspecified amount of discharge from
Parameter
COD
Flow
IDS
the groundwater collection lift station
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
Daily
Maximum Other
Report mg/l
N/A
N/A During discharge
Report MGD
Report mg/l
N/A
Monitoring Requirements
Frequency
4/year
1/day
4/year
Limitations/Monitoring Basis:
Monitoring at Internal Outfall 102 is established to reveal any contamination of the groundwater that
although it is not expected. Leachate would have to pass through a 4-foot clay liner of the landfill
happen.
Sample Type
grab
estimate
grab
may occur,
for this to
Special Conditions Basis:
The permittee is required to submit a QA/QC control plan on a schedule that sets milestones for approval of the
permittee's plan for standard operating procedures for laboratory toxicity testing as well as all aspects of
wastewater sampling, handling and transportation of the samples.
Effective Date: 11/01/92
Expiration Date: 10/31/97 Abstract Date: 06/03/93
Page: 389
-------
Facility Name: Grande Cheese Company
Facility Description: Processes milk into cheese, and processes whey
Limit ELGs UQSs BPJ
Basis: 2. J. -
Storm
Special BHPs Water Sediment
Conditions: J. - 4.
Monitoring
Only
4.
WQ
Survey
WET
Limits
Bio
Survey
Permit Number: WI 005 1764
SIC Code: 2022
WET Testing Multiple
Only Categories
J. r.
TRES MDLs
Tiered
Limits Other
- I
Monitoring Other
' I I,
Abstract Information:
Complete; Outfalls 001, 002, and 003.
Outfall: 001 | Receiving Water: Ridge and furrow system
| Treatment: Land
Amount/Components:
5500 gpd process wastewater discharged
Parameter
BOOS
Chloride
Flow
1C
P
-------
Facility Name: Grande Cheese Company Permit Number: WI0051764
Facility Description: Processes milk into cheese, and processes whey SIC Code: 2022
Chronic WET
Cu (T)
Flow
NH3
P (T)
PH
Temp.
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
1.000000 mg/l
N/A
N/A
N/A
N/A
N/A
Report
N/A
Report mg/l
N/A
Report gpd
N/A
Report mg/ I
0.720000 Ib/d
N/A
N/A
Report
N/A
120.000000 F
See below
Between 6.0 su and 9
.0 su
1/year
2/year
continuous
26/year
26/year
26/year
26/year
24hr fw composite
24hr fw composite
total
grab
24hc fw composite
grab
grab
L imi tat i ons/Moni tori ng Basi s :
Limitations and monitoring requirements were based on the previous permit, wi'th the following additions. BODS
monitoring on a 2/week basis was established to conform with other recently issued dairy permits. Chloride
monitoring was added to gather data on the water softner discharge. Cu(T) monitoring 2/year was included to gather
data for 99th percent!" le calculation made at permit reissuance. WET testing is required because "no toxicity data
on the effluent is on file." Chronic and acute WET testing is required during the first 24 months following
procedures provided. Acute WET testing is to be conducted following EPA methods, using primary and secondary
control water, 2 samples, 5 dilutions, and 3 species. Chronic WET testing, following EPA methods, is to include
primary and secondary control water, 3 samples, 5 dilutions, and 3 species.
Outfall: 003 | Receiving Water: land spreading near Duck Creek | treatment: Land
Amount/Components:
Unspecified amount consisting of process wastewater, high strength wastewater, waste slurry, whey, brine, permeate,
retenate, and contaminated milk.
Parameter
BODS
Chloride
Flow
K
P (T)
pH
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Dai ly
Maximum
N/A
Report mg/l
N/A
Report mg/l
N/A
Report gpd
N/A
Report mg/l
N/A
Report mg/l
N/A
Report su
Other
Monitoring Requirements
Frequency
1 /month
1 /month
continuous
1 /month
1 /month
1 /month
Sample Type
grab
grab
total
grab
grab
grab
Limitations/Monitoring Basis:
Thi,s outfall was not recognized in the previous permit, but is required with the promulgation of Wisconsin Adm. Code
NR 214. The basis for the monitoring conditions was not discussed. The permittee; is required to not exceed the
preventive action limits CPALs) derived from Wisconsin groundwater quality code (NR 140). If the PALs given in the
permit are exceeded, procedures also provided in the permit are to be implemented. The permit addresses the
possibility of a separate permit issued to an independent contractor who may lands.pread the process wastewater.
Special Conditions Basis:
The permittee is required to complete a wastewater study (on a schedule provided in the permit) to determine the
orgin of the high strength wastewater being discharged to the ridge and furrow sys.tem, as well as develop and
implement a plan to divert this flow. The permittee is required to maintain a daily log to track application of the
wastewater to the ridges, and the landspreading of wastewater and sludge. This information must be submitted in an
annual report which summarizes the application of wastewater, nitrogen, chloride, P, and K. The permit specifies
that the wastewater discharged to the land treatment system be applied in cycles of loading andresting. The^
management plan for monitoring the ridge and furrow system must be updated to reflect current management strategies
Page: 391
-------
Facility Name: Grande Cheese Company
Permit Number: WI0051764
Facility Description: Processes milk into cheese, and processes whey
SIC Code: 2022
and practices by 2/28/93. The permit specifies 8 components of the plan that must be updated. A management plan
for optimizing landspreading system performance is required prior to land spreading at any location, and any
londspreading site must be approved in advance and incorporated into this management plan. The permittee is required
to install an accurate flow measuring device. The permitte is also required to install a spill detector, alarm or
conductivity device to detect large fluxes in the system and divert excess wastewater to holding tank. BMPs such as
inspection and maintenance of tanks used to hold wastewater are detailed in the permit. Annual reports summarizing
site use and application rates pertaining to hydraulics, chloride, and nitrogen (fertilizer) use must be submitted.
The permittee is required to perform groundwater monitoring 4/year following procedures given in the permit. The
permittee is required to not exceed preventive action limits (PAALs) derived from Wisconsin groundwater quality code
(HR 140). If the PALs are exceeded, procedures provided in the permit are to be implemented. A report evaluating
the integrity of the groundwater wells must be submitted by May 31, 1993. Soil samples from the ridge and furrow
system must be tested annually for P, K, and pH. These results are to be submitted with the annual report. The
intent is to aid the permittee in maintaining a healthy cover crop. The permit requires that the volume of
wastewater landspread be limited to prevent runoff and ponding. Several site location criteria for landspreading
are included in the permit. The permittee is required to submit a QA/QC plan for conducting toxicity testing on a
schedule provided.
Effective Date: 12/28/92
Expiration Date: 09/30/97
Abstract Date: 06/09/93
Page: 392
-------
Facility Name: Quaker State Oil Refining Corp Permit Number: UV0004626
Facility Description: Manufactures finished oil products from Pennsylvania grade crudes oil SIC Code: 2911
Monitoring
Limit ELGs WQSs BPJ Only
iasis: J. J. J. J.
Storm WQ
Special BMPs Water Sediment Survey
Conditions: J. J. - -
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
J. - - - I
Bio
Survey TRES MDLs Monitoring Other
2. - - - J-
Abstract Information:
Complete; Outfalls 001 (A &B for abstracting purposes), 002, and 003.
Outfall: 001A | Receiving Water: Ohio River | Treatment: API, OAF, Aer, Fil, Dis
Amount/Components :
0.559 MGD avg. of crude oil processing and contaminated storm water.
Parameter
Acute WET
As (T)
BODS
Chloride
COD
Cr (T)
Cr+6
FC
Flow
Hardness
NH3-N
O&G
pH
Phenols
Priority pollutan
ts
S04
Sulfide
TOC
Limitations
Monthly
Average
N/A
N/A
Report Ib/d
Report mg/ 1
245.200000 Ib/d
Report mg/l
Report Ib/d
Report mg/l
1747.000000 Ib/d
Report mg/l
1.970000 Ib/d
Report ug/l
0.190000 Ib/d
Report ug/l
N/A
N/A
N/A
Report MGD
N/A
N/A
72.100000 Ib/d
Report mg/l
79.000000 Ib/d
Report mg/l
N/A
N/A
1 .640000 Ib/d
Report ug/l
Report Ib/d
Report ug/l
Report Ib/d
Report mg/l
1.010000 Ib/d
Report mg/l
Report Ib/d
Report mg/l
Daily
Maximum
N/A
2.500000 TUa
Report Ib/d
Report mg/l
461.600000 Ib/d
Report mg/l
Report Ib/d
Report mg/l
3399.200000 Ib/d
Report mg/l
5.590000 Ib/d
Report ug/l
0.420000 Ib/d
Report ug/l
200.000000
400.000000
N/A
0.763000 MGD
N/A
Report mg/l
157.500000 Ib/d
Report mg/l
151.000000 Ib/d
Report mg/l
N/A
N/A
5.810000 Ib/d
Report ug/l
Report Ib/d
Report ug/l
Report Ib/d
Report mg/l
2.240000 Ib/d
Report mg/l
Report Ib/d
Report mg/l
Other
See below
Units: #/100 ml
as CaC03
See below
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/quarter
1/week
2/week
1/week
2/week
1/quarter
1/quarter
1/week
continuous
1/quarter
2/week
2/week
1/day
2/week
1/6 months
1/week
2/week
1/week
Sample Type
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
recorded
24hr fw composite
24hr fw composite
grab
grab
grab
grab
24hr fw composite
grab
24hr fw composite
Page: 393
-------
Facility Name: Quaker State Oil Refining Corp Permit Number: UV0004626
Facility Description: Manufactures finished oil products from Pennsylvania grade crude oil SIC Code: 2911
TSS
211.200000 Ib/d
Report mg/l
329.500000 Ib/d
Report mg/ 1
2/week
24hr fw composite
Limitations/Monitoring Basis:
Outfall 001A Has created for abstracting purposes to represent the limitations which apply to Outfall 001 from the
period 9/21/91 through 3/20/94. The limits and monitoring requirements for flow, TOC, and As(T) are based on
ant (backsliding provisions. A discussion of the basis for the original requirements was not provided. The limits
for BOOS, COO, TSS, O&G, NH3-N, S, phenols, Cr(T), and Cr+6 are ELG-based, in accordance with petroleum refining
category (40 CFR Part 419; Subpart D) based on the 1990 annual throughput. Monitoring for BODS must occur after the
addition of H202. For OSG, 3 grab samples must be taken at equal time intervals over 24 hrs but no greater than 2
hrs apart and each sample analyzed; the avg. of these samples must be reported. The monitoring requirements for
chloride, S04, and hardness are deemed necessary to collect a data base. The limit for Fecal Coliforms is WQ-based
and fs equal to the water quality standard. The limit for pH is deemed appropriate to satisfy the water quality
standard. The limit for Acute WET is in accordance with the State's Toxic Pollutant Control Permitting Strategy.
WET monitoring must be conducted in accordance with procedures set forth in EPA guidance manuals. The basis of the
remaining monitoring requirements was not provided.
Outfall: 001B | Receiving Water: Ohio River | Treatment: API, DAF, Aer, Fit, Dis
Amount/Components :
0.559 HGO avg. of crude oil processing and contaminated storm water.
Paratneter
Acute WET
As
BOOS
Chloride
COO
Cr
Cr+6
FC
Flow
Hardness
HH3-H
OSG
pH
Phenols
Priority pollutan
ts
S04
Limitations
Monthly
Average
N/A
N/A
Report Ib/d
0.500000 mg/l
245.200000 Ib/d
Report mg/l
Report Ib/d
Report mg/l
1747.000000 Ib/d
Report mg/l
1.970000 Ib/d
Report ug/l
0.190000 Ib/d
Report ug/l
N/A
200.000000
N/A
Report mg/l
N/A
N/A
72.100000 Ib/d
Report mg/l
79.000000 Ib/d
Report mg/l
N/A
N/A
1.640000 Ib/d
Report ug/l
N/A
Report mg/l
Report Ib/d
Report mg/l
Daily
Maximum
N/A
2.500000 TUa
Report Ib/d
1.000000 mg/l
471.600000 Ib/d
Report mg/l
Report Ib/d
Report mg/l
3399.200000 Ib/d
Report mg/l
5.590000 Ib/d
Report ug/l
0.420000 Ib/d
Report ug/l
N/A
400.000000
N/A
Report MGD
N/A
Report mg/l
157.500000 Ib/d
Report mg/l
151.000000 Ib/d
Report mg/l
N/A
N/A
5.810000 Ib/d
Report ug/l
N/A
Report mg/l
Report Ib/d
Report mg/l
Other
See below
Units: #/100ml
as CaC03
See below
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/quarter
1/week
2/week
1/week
2/week
1/quarter
1/quarter
1/week
continuous
1/quarter
2/week
2/week
1/day
2/week
1/6 months
1/week
Sample Type
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
grab
record
24hr fw composite
24hr fw composite
grab
grab
grab
grab
24hr fw composite
Page: 394
-------
Facility Name: Quaker State Oil Refining Corp Permit Number: WV0004626
Facility Description: Manufactures finished oil products from Pennsylvania grade crude oil SIC Code: 2911
Sulfide
TOC
TSS
1.010000 Ib/d
Report mg/l
Report Ib/d
Report mg/l
211,200000 Ib/d
Report mg/l
2.240000 Ib/d
Report mg/l
Report Ib/d
Report mg/l
329.500000 Ib/d
Report mg/l
2/week
1/week
2/week
grab
24hr fw composite
24hr fw composite
Limitations/Monitoring Basis:
Outfall 001B was created for abstracting purposes to represent the limitations which apply at Outfall 001 from the
period of 3/21/94 through 8/20/96. The limitations and monitoring conditions basis is the same as described in
001A, except for As(T). As limits have been developed because past data indicates high levels of As attributed by
the facility to the crude oil and brine. The limit for As(T) is BPJ-based on chemical precipitation by lime and
settling technology transfer from the inorganic chemicals industry and non-ferrousi metal manufacturing industry.
Outfall: 002 | Receiving Water: Ohio River | Treatment: None
Amount/Components:
Unspecified amount of cooling tower blowdown
Parameter
Acute WET
Chloride
COD
Cu (T)
Flow
Hardness
O&G
PH
TOC
TRC
TSS
Zn (T)
Limitations
Monthly
Average
N/A
N/A
Report Ib/d
Report mg/l
Report Ib/d
Report mg/l
Report Ib/d
Report mg/l
N/A
Report MGD
N/A
N/A
Report Ib/d
Report mg/l
N/A
N/A
Report Ib/d
45.000000 mg/l
Report Ib/d
Report ug/l
Report Ib/d
30.000000 mg/l
Report Ib/d
Report mg/l
Daily
Maximum
N/A
2.500000 TUa
Report Ib/d
Report mg/l
Report Ib/d
Report mg/l
Report Ib/d
Report mg/l
N/A
Report MGD
N/A
Report mg/l
Report Ib/d
10.000000 mg/l
N/A
N/A
Report Ib/d
65.000000 mg/l
Report Ib/d
Report ug/l
Report Ib/d
45.000000 mg/l
Report Ib/d
Report mg/l
Other
Between 6.0 su and 9
..0 su
Monitoring Requirements
Frequency
1/quarter
1/week
1/week
1/week
continuous
1/quarter
1/week
1/day
1/week
1/week
1/week
1/week
Sample Type
24hr fw composite
24hr fw composite
24hr fw composite
24hr fw composite
recorded
24hr fw composite
grab
grab
24hr fw composite
grab
24hr fw composite
24hr fw composite
Limitations/Monitoring Basis:
The limits for TSS, O&G, and monitoring requirements for flow, Zn(T), and Cu(T) are based on the past permit. A
discussion of the basis for the original limits was not provided. The limit for TOC is BPJ-based in consideration
of the use of organic chemicals for cooling water. A description of the limits derivation was not provided,
however, these limits are intended to control process leaks and is consistent with an agreement with the permittee.
The limit for pH is based on satisfying the State water quality standard. The Acute WET limit is based on the
State's Toxic Pollutant Control Permitting Strategy. WET monitoring must be conducted in accordance with procedures
set out in EPA guidance manuals. Monitoring for COD, chloride, and hardness is specified to collect data. A
discussion of the remaining monitoring conditions was not provided.
Page: 395
-------
Facility Hamc: Quaker State Of I Refining Corp
Permit Number: UV0004626
Facility Description: Manufactures finished oil products from Pennsylvania grade crude oil
SIC Code: 2911
Outfall: 003 | Receiving Water: Unnamed trib. to Congo Run
Treatment: Not described
Amount/Components:
Uncontominatcd storm Water
Parameter
Chloride
COO
Flow
OSG
p«
TOC
TSS
Limitations
Monthly
Average
Report
Report
Ib/d
mg/l
Report
Report
Ib/d
mg/l
N/A
Report
MGD
Report
Report
Ib/d
mg/l
N/A
N/A
Report
Report
Ib/d
mg/l
Report
Report
Ib/d
mg/l
Daily
Maximum
N/A
N/A
Report Ib/d
Report mg/l
N/A
Report MGD
Report Ib/d
10.000000 mg/l
N/A
N/A
Report Ib/d
Report mg/l
Report Ib/d
Report mg/l
Other
Monitor min. and max
. su
Monitor in
Frequency
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
1 /month
g Requirements
Sample Type
grab
grab
estimate
grab
grab
grab
grab
Limitations/Monitoring Basis:
A discussion of limitations and monitoring requirements was not provided.
Special Conditions Basis:
Within 9 months, the BMP plan must be updated because of changes at the facility and changes to regulations.
Additionally, conditions considered good housekeeping practices are specified as important parts of a BMP plan and
arc identified as having potential to minimize soil contamination, minimize pollutants discharged in storm water,
and protect the ground water. These include: 2/week inspection of the oily sewer and the maintenance of a log of
the some; 1/week inspection of manufacturing, storage, and loading areas for drippage/leakage and the remediation of
the same; inspection of all pumps, lines, and valves for drippage/leakage and the remediation of the same; proper
and prompt removal of stained soil and gravel on the facility site; and prevention of overflows through precautions.
Schedules are set forth for compliance with 001B conditions by 3/21/94, compliance with the installation of a 1 mgd
holding tank, which will support a 10yr, 24hr rainfall event, by 3/21/93, and compliance with the implementation of
the groundwater monitoring plan (specific requirements are set out) by 3/21/92; compliance reports must be submitted
within 14 days of the milestone date. The facility must also submit, within 6 months, an As treatability and
economic analysis study. The latter two conditions are based on the facility's storm water management plan and
groiindHater management plan as outlined in specifically cited correspondence. Other special conditions and
justifications include the following: 1) annual reporting of average daily crude oil processing; this is specified
because limits are based on fee raes and changes will dictate the need for permit modifications; 2) a prohibition of
bypassing; this is reiterated to emphasize bypass prohibitions; 3) quarterly reporting of removal efficiency of
BOOS, TOC, OftG, and COO because this information is needed to evaluate O&M based on specific removal rates cited
from the development document; 4) semi-annual monitoring of intake water from each well for COD, TOC, pH, Fe (T), Mn
(T), and chloride and the submission of test results within 30 days; this condition is necessary since the facility
is using groundwater as makeup water and intake water pollutants must be identified so that they may be discharged;
5) Within 60 days, the removal of stained soil and gravel in the unnamed tributary to the Congo Run and monthly
inspection of the weir prior to the unnamed tributary; these conditions result from oily sediment and solids build-
up which are problems noted in previous inspections; and 6) a prohibition of untreated cooling tower blowdown (pH
outside 6-9 su); this condition is necessary due to high dissolved metals concentrations present in low pH blowdown
waters.
Effective Date:
09/21/91
Expiration Date:
08/20/96
Abstract Date:
05/24/93
Page: 396
-------
Facility Name: U CAR Carbon Co., Inc.
Permit Number: WV0004707
Facility Description: Production of carbon and graphite electrodes, anodes, and specialty pr
SIC Code: 3624
Limit
Basis:
ELGs
WQSs
J.
BPJ
J.
Monitoring
Only
J.
WET
Limits
WET Testing
Only
Multiple
Categories
Tiered
Limits
Other
J.
Special
Conditions:
BMPs
Storm
Water
Sediment
WQ
Survey
J.
Bio
Survey
J.
TRES
MDLs
Monitoring
Other
I
Abstract Information:
Partial; 003, 006, 009, 010 (representing 011, 013-048)
Outfall: 003
Receiving Water: Ann Moore Run
Treatment: Not described.
Amount/Components:
0.046 MGD daily avg. of contact cooling water, non-contact cooling water, water softener backwash, groundwater, and
storm water runoff.
Parameter
Chloride
COD
Fe (T)
Flow
O&G
pH
Temp.
TOC
TSS
Limitations
Monthly
Average
Report Ib/d
Report mg/l
Report Ib/d
Report mg/l
Report Ib/d
Report mg/l
N/A
Report mg/l
Report Ib/d
10.000000 mg/l
N/A
H/A
N/A
Report F
Report Ib/d
Report mg/l
Report Ib/d
30.000000 mg/l
Dai ly
Maximum
Report Ib/d
250.000000 mg/l
Report Ib/d
Report mg/l
Report Ib/d
1.500000 mg/l
N/A
Report MGD
Report Ib/d
15.000000 mg/l
N/A
N/A
N/A
Report F
Report Ib/d
Report mg/l
Report Ib/d
60.000000 mg/l
Other
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
2/month
2/month
2/month
2/month
2/month
2/month
2/month
2/month
2/month
Sample Type
grab
grab
grab
estimate
grab
in-situ
in-situ
grab
grab
imitations/Monitoring Basis:
conSnuhrh--Thnd1-e'??- 2re I?88*1 °n the past perml't; flow "'Coring requirements are also
consistent with 46 CSR 6.3.h.1.ii. The limits for TSS are BPJ-based, and constitute a performance standard for
sedimentation Limits for Fe(T) and chlorides are WQ-based, and are equal to the water quality standards The
choride limit was deemed achewable through controlled discharge of water softener backwash. The limit for O&G are
BPJ-based on treatment technology performance; these limits also ensure against violation of Series I Sect 3 of
the West Virginia legislative rules. The PH limits are that necessary to satisfy the applicable water quality
standard. The monitoring requirements for COD and TOC are deemed necessary to collect data The basis on the
remaining monitoring conditions was not described.
utfall: 006
Receiving Water: Unnamed trib. to Ann Moore Run
Treatment: Not described
mount/Components:
0.009 MGD daily max. of non-contact cooling water and groundwater from sump.
Parameter
COD
Fe (T)
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
Dai ly
Maximum
Report Ib/d
Report mg/l
Report Ib/d
1.500000 mg/l
Other
Monitoring Requirements
Frequency
1/month
1/month
Sample Type
grab
grab
Page: 397
-------
Ftcflfty Maox,: U CAR Carbon Co., Inc. <*»™t Mumber: WV0004707
F"1Mty (inscription: Production of carbon and graphite electrodes, anodes, and specialty pr SIC Code. 3624
Flow
pll
Tefpp.
TOC
TSS
N/A
M/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Report MGD
N/A
N/A
N/A
Report mg/l
Report Ib/d
Report mg/l
Report Ib/d
60.000000 mg/l
Between 6.0 su and 9
.0 su
1 /month
1 /month
1 /month
1 /month
1 /month
in- situ
instream
grab
grab
""SsEftrfei^^^^^
fflarTfor sediment-action. The limit for Fe is WQ-based and is set equal to the water quality standard. The
limits for pH are deemed appropriate to satisfy the water-quality standard.
Outfall: 009 | Receiving Water: Ann Moore Run 1 Treatment: Not described
/Mn°U%/42I^dtaUy avg. of non-contact cooling water, storm water runoff, water softener backwash, and wet scrubber water.
Parameter
Chloride
COO
Fc
Flow
OSG
P»
Temp.
TOC
TRC
TSS
Limitations
Monthly
Average
Report Ib/d
Report mg/l
Report Ib/d
Report mg/l
Report Ib/d
Report mg/l
N/A
Report MGO
Report Ib/d
10.000000 mg/l
N/A
N/A
N/A
Report F
Report Ib/d
Report mg/l
Report Ib/d
Report mg/l
Report Ib/d
30.000000 mg/l
Daily
Maximum
N/A
250.000000 MGD
Report Ib/d
Report mg/l
N/A
1.500000 mg/l
N/A
Report MGD
N/A
15.000000 mg/l
N/A
N/A
N/A
Report F
Report Ib/d
Report mg/l
Report Ib/d
Report mg/l
N/A
60.000000 mg/l
Other
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
2/month
2/month
2/month
2/month
2/month
2/month
2/month
2/month
2/month
2/months
Sample Type
grab
grab
grab
" estimate
grab
in- situ
in-situ
grab
grab
grab
Lfm'tT?«Cii^twirSirei"?««nt« for flow and temp, are based on the past permit; flow monitoring requirements are
cmfetcnt With «2 CSR 6.3.h.ii. The limits for COD, TRC, and TOC were deemed necessary to collect adequate data
TheliBits for TSS are BPJ-based, and constitute a performance standard for sedimentation. The limits for Fe(T) and
chlorde are WQ-based and are equal to the water quality standard; the chloride limit was deemed achievable through
controlled discharge of softene? backwash. The limits for O&G are BPJ-based on treatment technology performance
ThSse limits also ensure against violations of Series I, Section 3 of the WV Legislative Rules. The limits for PH
arc deemed necessary to satisfy the applicable water quality standard.
,
Page: 398
-------
Facility Name: U CAR Carbon Co., Inc. Permit Number: UV0004707
Facility Description: Production of carbon and graphite electrodes, anodes, and specialty pr SIC Code: 3624
Outfall: 010 | Receiving Water: Ann Moore Run | Treatment: Not described
Amount/Components :
0.029 HGD daily avg stormwater runoff from Green Carbon Storage Lot/Silo storage Area and road drains.
Parameter
Chloride
COD
Fe (T)
Flow
O&G
pH
TOC
TSS
Limitations
Dai ly
Average
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Dai ly
Maximum
Report Ib/d
Report mg/l
Report Ib/d
Report mg/l
Report Ib/d
Report mg/l
N/A
Report MGD
Report Ib/d
Report mg/l
N/A
N/A
Report Ib/d
Report mg/l
Report mg/l
Report mg/l
Other
Report min. and max.
su
Monitoring Requirements
Frequency
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
1/quarter
Sample Type
grab
grab
grab
estimate
grab
in-situ
grab
grab
Limitations/Monitoring Basis:
Since monitoring at 38 storm water discharges is expensive and cumbersome, monitoring is only required at 5
representative outfalls (including 010). The current permit requires monitoring at storm water outfalls for TSSand
flow only. The parameters above are designated since there is no data base for adequate characterization of storm
water discharges.
Special Conditions Basis:
The permit requires semi-annual grab sampling at specified upstream and downstream locations within the receiving
water reaches and analysis for pH, TSS, COD, TOC, O&G, DO, Fe (T), TRC, and PAHs, and visual inspection for and
recording of any oily sheen. Toxicity testing of Ann Moore Run is also specified. These conditions were required
to evaluate impacts of all discharges on the water quality of the stream. An annual benthic survey at specified
upstream and downstream reaches in Ann Moore Run is required; the survey must be conducted in accordance with .
procedures set forth in the permit and in a specific EPA guidance manual. This condition is designed to evaluate
any long term impacts of all discharges and is specified due to a past study showing an extremely stressed benthic
population. A potential reduction in monitoring is also provided as a special condition and is intended to allow
for the reduction of monitoring where no adverse water quality can be demonstrated. Semi-annual groundwater
monitoring for pH, chloride, COD, TOC, Fe (T), and PAHs is set forth; specific PAHs are listed in the permit. This
condition is justified since the facility is more than 85 years old. The permit prohibits the discharge of water
softener backwash (Outfall 009) as a slug; rather this discharge must be released ata controlled rate. This
condition is intended to prevent adverse impacts of high chloride concentrations. The permit also prohibits the
discharge of PCBs. This condition is set forth because of the potential for spills from electrical transformers
(containing less than 50 ppm PCBS) which are stored on site.
Effective Date: 09/13/90 Expiration Date: 08/12/95 Abstract Date: 05/24/93
Page: 399
-------
Facility Home: Wampler-Longacre Chicken, Inc. . Permit Number: WV0005495
Facility Description: Chicken processing, packaging, and shipping. SIC Code: 2019
Monitoring
Limit ELGs WQSs BPJ Only
Basis: - 1 J. I
Storm WQ
Special BHPs Water Sediment Survey
Conditions: i i. ; I
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
4 - - - I
Bio
Survey TRES MDLs Monitoring Other
- I -11
Abstract Information:
Complete; 001.
Outfall: 001 | Receiving Water: S.Fork of S. Branch of PotomacR | Treatment: Scr, Eq, DAF, Ftoc, AS, Dis, De
Amount/Components :
1.05 HGO of process boiler blowdown, sanitary, truck wash, and storm waters.
Parameter
Acute UET
Al
-------
Facility Name: Wampler-Longacre Chicken, Inc.
'
„
Permit Number: UV0005495
Facility Description: Chicken processing, packaging, and shipping.
S!c Code. 2019
Temp.
TKN
TOC
TRC
TSS
N/A
Report
Report Ib/d
Report mg/l
N/A
N/A
Report Ib/d
Report ug/l
305.200000 Ib/d
N/A
N/A
Report
Report Ib/d
Report mg/t
Report Ib/d
Report mg/l
Report Ib/d
53.000000 ug/l
610.300000 Ib/d
Report mg/l
1/week
I/week
1 /month
1/week
1/week
in-situ
grab
24hr composite
grab
24hr composite
Limitations/Monitoring Basis:
I™ oi'?Wkllmit '!! l?ased °n a°5u?L flow data and Performance of the treatment system. Limits for BODS O&G and T
Special Conditions Basis: =="^= -=— =^
/rS^*1"0!!! ^f0™3^01?,00 ^e number of chickens killed daily and the average daily weight of live
sulfide once adequate data ._ a .. „., otullllnatc
present, the permit may be modified to include monitoring
^^
n.l.tl.n. t
Effective Date: 07/28/91
Expiration Date: 06/27/96
Abstract Date: 04/14/93
Page: 401
-------
i ii • — .... Permit Number: UV0042641
Facility Hamc: Concast Metal Products Company - • ..
Facility Description: Manufactures metal bars, rods, tubes, and shapes from melted bronze SIC Code. 334^
Monitoring
Limit ELGs WQSs BPJ Only
Basis: 1 J. * *
Storm UQ
Special BMPs Water Sediment Survey
Conditions: r. .1 - -
WET WET Testing
Limits. • Only
Bio-,
Survey TRES
Multiple Tiered
Categories Limits Other
- • - *
, HDLs Monitoring Other
.- • •- *
Abstract Information:
Complete; Outfalls 001, and 003. .
Outfall: 001 | Receiving Water: Ditch to Tygart Valley River , I Treatment. Dis
Amount/Components: ' ' ,
1050 gpd of sanitary wastewater •
Parameter
BOOS
FC
Flow
P«
TO!
TSS
Limitations
Monthly
Average
0.260000 Ib/d
30.000000 mg/l
N/A
200.000000
M/A
N/A
N/A
N/A
0.160000 Ib/d
18.000000 mg/l
0.260000 Ib/d
30.000000 mg/l
Dai ly
Maximum
0.520000 Ib/d
60.000000 mg/l
N/A
400.000000
N/A
1050.000000 gpd
N/A
N/A
0.320000 Ib/d
36.000000 mg/l
0.520000 Ib/d
60.000000 mg/l
Other
See below
Units: #/100 ml
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/year
1/year
1/year
1/year
1/year
1/year
Sample Type
8hr fw composite
grab
measure
grab
8hr fw composite
8hr fw composite
lta'BSK!B€»^^^
The BOOS sampling location was specified as immediatedly preceding disinfection.
Outfall- 003 | Receiving Water: Ditch to Tygart Valley River I Treatment. None
^""un^^nmount of storm water from the NU facility downspout.
Parameter
Cu
Flow
OSG
Pb
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Daily
Maximum
N/A
Report mg/l
N/A
Report gpd
N/A
Report mg/ I
N/A
Report mg/l
Other
Monitoring Requirements
Frequency
1/6 months
1/6 months
1/6 months
1/6 months
Sample Type
grab
estimate
grab
grab
Page: 402
-------
Facility Name: Concast Metal Products Company
Facility Description: Manufactures metal
pH N/A
N/A
Permit Number: UV0042641
bars, rods, tubes, and shapes from melted bronze SIC Code: 3341
N/A Between 6.0 su and 9
N/A .0 su
1/6 months grab
Limitations/Monitoring Basis:
Monitoring requirements are based on the potential for pollutants form particulate air emissions to settle on the
roof particularly since air emission control are not currently in place, and thereby come into contact withrainfall
as the roof downspout discharges. The limits for pH are set to satisfy West Virginia Legislative Rules, Title 46,
Series I, Appendix E.
Special Conditions Basis:
The permit contains a requirement to remove and properly dispose of all contaminated soil on the property and all
graphite dust piles on the property. This requirement is based on the results of a field review during which
housekeeping problems were noted and an oily area of soil and piles of graphite dust were discovered. The facility
proceeded to remove and dispose of contaminated soil and graphite, but had not completed removal at the time the
permit was issued. Therefore the requirement was included to ensure completion.
Effective Date: 02/25/93
Expiration Date: 02/24/98
Abstract Date: 04/19/93
Page: 403
-------
Facility Home: Frontier Refining, Inc. Permit Number: WY0000442
Facility Description: Oil refinery SIC Code: 2911
Monitoring WET WET Testing Multiple Tiered
Limit ELGs WQSs BPJ Only Limits Only Categories Limits Other
Basis: J. - - J. J. - - - -
Storm WQ Bio
Special BMPs Water Sediment Survey Survey TRES MDLs Monitoring Other
Conditions: - 4 - z - - - i
Abstract Information:
Partial; Outfalls 003 and 005. Outfalls 001 and 002 are inactive; limits for 003 apply to the combined discharge from
003 and 004.
Outfall: 003 | Receiving Water: Crow Creek | Treatment: APl+EQ+DAF+BioR
Amount/Components :
Unspecified amount of treated process and storm water.
Parameter
Acute WET
BOOS
COO
Cr (T)
Cr+6
Flow
NH3-N
OSG
pH
Phenols
Sulfidc
Temp.
TSS
Limitations
Daily
Average
M/A
N/A
328.000000 Ib/d
N/A
2283.000000 lb/d'
N/A
2.600000 lb/d
N/A
0.230000 lb/d
N/A
N/A
Report MGO
157.000000 lb/d
N/A
96.000000 lb/d
N/A
N/A
N/A
2.200000 lb/d
N/A
1.500000 lb/d
N/A
N/A
N/A
263.000000 lb/d
N/A
Daily
Maximum
N/A
N/A
591.000000 lb/d
N/A
4419.000000 lb/d
N/A
7.300000 lb/d
N/A
0.500000 lb/d
N/A
N/A
Report MGD
345.000000 lb/d
N/A
181.000000 lb/d
N/A
N/A
N/A
4.400000 lb/d
N/A
3.400000 lb/d
N/A
N/A
N/A
412.000000 lb/d
N/A
Other
See below
10 mg/l inst. max.
Between 6.0 su and 9
.0 su
Monitoring Requirements
Frequency
1/quarter
1/week
1/month
1/month
1/month
continuous
1/week
1/week
1/day
2/month
2/month
1/day
1/week
Sample Type
8hr fw composite
8hr fw composite
8hr fw composite
8hr fw composite
8hr fw composite
total
8hr fw composite
grab
grab
grab
grab
instantaneous
8hr fw composite
Limitations/Monitoring Basis:
All limits apply to the total quantity of pollutants from outfalls 003 and 004. All numerical limits, with the
exception of the pH and inst. max. OSG limits, are based on ELGs (40 CFR Part 419). The inst. max. O&G timitapplies
individually to outfalls 003 and 004. The bases for the pH and inst. max. O&G limit are not provided. Monitoring
requirements must be performed separately at 003 and 004. In addition, effective July 1, 1992, there shall be no
acute toxicity in the discharge from outfall numbers 003 and 004. Because the discharges are to Class 4 waters, the
State requires only acute, rather than chronic, testing. WET testing must be conducted 1/quarter in accordance with
procedures set forth in EPA guidance manuals and regional policy. Retesting must be conducted within 4 weeks where
toxicity is evident; 1/month monitoring is required where 2 consecutive resultsshow toxicity. Monitoring
requirements may be reduced where no toxicity is found. The basis of the monitoring conditions was not described.
Page: 404
-------
Facility Name: Frontier Refining, Inc.
Permit Number: WY0000442
Facility Description: Oil refinery
Outfall: 005
Receiving Water: Crow Creek
SIC Code: 2911
| Treatment: None
Amount/Components:
Unspecified amount of overflow from storm retention basin.
Parameter
Flow
O&G
TOC
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
Maximum
N/A
N/A
N/A
N/A
N/A
N/A
Other
See below
shall not exceed 10
mg/l
shall not exeed 110
mg/l
Monitoring Requirements
Frequency
1/discharge
1/discharge
1/discharge
Sample Type
estimate
grab
grab
imitations/Monitoring Basis: ' ~
Discharge from outfall 005 is allowed only where runoff exceeds the quantity resuming from a 10yr 24hr
S^n?*""1 T^ (2n lnCUeS): Sh?uld such an event °ccur« the ^charge must be reported to the State
grabsamples must be collected and analyzed for O&G and TOC, an estimate of the flow must be provided and a report
^6 "™n 3° *"* *"* ™«~ aU °f th *
Special Conditions Basis: == =—=—=— =—
By August 1, 1994, 100% of the natural runoff which originates on the refinery property or which flows
si ^rThT^sTlO^ o?Uthee s5orm9w ?' "-t.«t«. colt«tlon and tr^J^^^^M
set rortn to address 100^ of the storm water discharge due to new regulations which cover storm water.
is
ffective Date: 07/31/91
Expiration Date: 07/31/96
Abstract Date: 04/27/93
Page: 405
-------
F^Uity Nan*: Union Oil Company Permit Nuraber: UYO°°1171
Facility Description: Oil extraction and recovery facility SIC Code- 1311
Monitoring
LMt ELGs WQSs BPJ Only
Basis: i ^ i -
Storm UQ
Special BHPs Water Sediment Survey
Conditions: i. z
WET WET Testing Multiple Tiered
Limits Only Categories Limits Other
•i - - - -
Bio .
Survey TRES MDLs Monitoring Other
Abstract Information:
Complete/Outfall 001
Outfall: 001 | Receiving Water: Little Popo Agie River Treatment: Not described.
Amount/Components:
1.5 MGO of formation and/or secondary recovery waters.
Parameter
Acute WST
Flow
OSG
PH
Radium (226)
Specific conducta
nee
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Dai ly
Maximum
N/A
N/A
1.500000 MGD
N/A
N/A
10.000000 mg/l
N/A
N/A
N/A
17.000000
N/A
7500.000000
Other
See below
Between 6.5 su and 8
.5 su
Units: pci/l
Units: umhos/cm
Monitoring Requirements
Frequency
1/year
1/6 months
1/month
1/year
Sample Type
grab
instantaneous
grab
grab
LimiTheT-m1tnforrRladiBi1mS2S26 is based on WQ criteria for the receiving stream. An acute WET limit of "° t«Jcift * t
Sled wVsme requirement to include some type of toxicity prohibition in permits of ^ist^ej "ET test ing must
be conducted in accordance with EPA guidance manuals and regional policy; 100/. ef f uent is specified. Retesting
within 4 weeks is required where toxicity is evident; 1/month testing is required if 2 consecutive tests show
?oxic?ty. The basis for the flow limitation was not provided. The permit did not specify monitoring requirements
for p« and specific conductance. Monitoring requirements for O&G are specified based on the discharge affecting the
water. The basis of the remaining conditions was not discussed.
Special Conditions Basis: /
Mo special conditions were included in the permit.
Effective Date: 07/01/92 Expiration Date: 06/30/97 Abstract Date: 04/23/93
Page: 406
-------
Facility Name:
Pacficorp dba Pacific P&L, Dav . perm,-t Number: WY0003115
Facility Description: Coal-fired steam electric power generation plant SIC Code: 4931
Limit
Basis:
Special
Conditions:
Monitoring WET WET Testing Multiple
ELGs WQSs BPJ only Limits Only Categories
± ± - : J. • J. 2. z.
Storm WQ Bio
BMPs Water Sediment Survey Survey TRES MDLs
J. J. - i. -. .1 , ^_
Tiered
Limits
Monitoring
I
Other
I
Other
I
Abstract Information:
Partial; Outfalls 001 (representing 001-006), 007 (representing 007-008), 011, and 020.
Outfall: 001
| Receiving Water: North Platte River . [Treatment: Not described.
Amount/Components: . .
200 MGD of condenser cooling water, and discharge from the recirculation canal.
Parameter
Flow
TROs
Limitations
Monthly
Average
N/A
N/A
N/A
N/A
Dai ly
Maximum
N/A
N/A
N/A
N/A
Other.
See below
See below
Monitoring Requirements
Frequency Sample Type
continuous record
see below see below
Limitations/Monitoring Basis:
Because the facility uses both chlorine and bromine as oxidants, a limit is established for TRO for the combination
of discharge points 001-006. The combined TRO shall not exceed 1.84 kg/d nor shall the flow weighted concentration
exceed 0.05 mg/l at any time. The discharge of oxidants is also limited to no more than 2 hours per day from any
single operating unit. Monitoring for total residual oxidant must be performed in accordance wit specified
procedures, and must be calculated from recordings on each day that bromine and/or chlorine is applied. Limitations
for flow and temp, were not included due to a 316(a) study conducted by the company. In addition, no monitoring of
effluent temp, is required due to a large volume of background data. However, monitoring of instream temp is
required. Monitoring for flow is required for the combined discharges of outfalls 001-006, and the max avg and
mm. values must be reported. The basis of the limitations -for TRO and the monitoring requirements for all
parameters was not described.
Outfall: 007
Receiving Water: North Platte River Treatment: FL
Amount/Components:
Unspecified amount of plant drains, coal pile runoff, low volume wastes. Outfall 0;>0 discharge, metal cleaning wastes
and scrubber blowdown. '
Parameter
Cu (T)
FC
Fe (T)
Flow
O&G
pH
TSS
Limitatfons
Monthly
Average
N/A
N/A
N/A
1000.000000
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
30.000000 mg/l
Dai ly
Maximum
N/A
1.000000 mg/l
N/A
4000.000000
N/A
1.000000 mg/l
N/A
N/A
N/A
10.000000 mg/l
N/A
N/A
N/A
100.000000 mg/l
Other
Units: #/100 ml;see
below
Between 6.0 and 9.0
su
Monitoring Requirements
Frequency
1 /month
1 /month
1 /month
1/week
continuous
1/week
1/week
Sample Type
grab
grab
grab
instantaneous
visual
grab
grab
Limitations/Monitoring Basis:
The weekly avg. FC limit is 2,000/100 ml. Limits are based on national "Best Available Treatment" and limits
carried over from the previous permit. The basis of the monitoring requirements was not described.
Page: 407
-------
Facility Nome: Pacficorp dba Pacific P&L, Dav
Permit Number: WY0003115
'aef Uty Description: Coal-fired steam electric power generation plant
SIC Code: 4931
Outfall: 011 | Receiving Water: North Platte River
Treatment: Not discussed.
Amount/Components:
Unspecified amount of emergency overflow from sump.
Parameter
Flow
OSG
PH
TSS
Limitations
Monthly
Average
N/A
Report MGD
N/A
Report mg/l
N/A
N/A
N/A
Report mg/l
Daily
Maximum
N/A
Report MGD
N/A
Report mg/l
N/A
N/A
N/A
Report mg/l
Other
Report min. and max.
su
Monitoring Requirements
Frequency
1/day
1/day
1/day
1/day
Sample Type
instantaneous
grab
grab
grab
Limitations/Monitoring Basis: .
Discharge at this outfall is permitted only under emergency situations. When a discharge occurs, monitoring must be
performed daily. In additon, the permittee must immediately notify the State and must submit a report and
mitigation plan. The basis of the monitoring requirements was not discribed.
Xitfall: 020 | Receiving Water: Internal via 007 or 008
| Treatment: Not discussed.
Amount/Components:
Unspecified amount of sewage treatment plant discharge
Parameter
BOOS
Limitations
Monthly
Average
N/A
30.000000 mg/l
Daily
Maximum
N/A
90.000000 mg/l
Other
45 mg/l weekly avg.
Monitoring Requirements
Frequency
1/month
Sample Type
grab
Limitations/Monitoring Basis:
Limits are intended to ensure that discharge meets "National Secondary Discharge Standards for BOD" prior to
discharge to the ponds. The basis of the monitoring requirements was not described.
Special Conditions Basis:
The permit includes 11 special conditions: (1) Cooling tower operational procedures to ensure instream water
temperature requirements are not exceeded; (2) dam operation requirements to ensure TSS and silt control; (3)
Exemption from State instream temp. WQS based on the results of a 316(a) study; (4) a requirement to continuously
monitor instream water temp.; (5) a requirement to notify the State when instream temp, reaches 78 degrees F;(6) a
prohibition of PCB discharge; (7) a prohibition of the discharge of any priority pollutants in accordance with ELGs
(40 CFR Part 423). (8) a prohibition of acute toxicity in the discharge of the combined outfalls 001-008; (9)
requirements to conduct acute WET testing at least 1/quarter on a flow weighted grab sample from outfalls 001-008
where samples must be collected when TRO concentrations are at their highest. Acute WET testingand reporting must
be conducted in accordance with EPA guidance manual procedures and regional policy. 100 effluent is specified.
Retcsting must be conducted within 4 weeks where toxicity is evident; 1/month monitoring is required if 2
consecutive tests show toxicity. Monitoring requirements may be reduced where no toxicity is found. (11)
Requirements to implement stormwater BMPs by 1/1/95 such that no violation of WQS occur; and 12) a phibition^of
discharge from cooling tower discharge.
Effective Date: 03/01/92
Expiration Date: 02/28/97
Abstract Date: 04/26/93
Page: 408
-------
Facility Name: Union Pacific RR, Laramie Tie
Permit Number: WY0032590
Facility Description: Remedial cleanup of a railroad tie treatment plant site SIC Code: 2491
Limit ' ELGs WQSs BPJ
Basis: L I J_
Storm
Special BMPs Water Sediment
Conditions: ^ 2. -
Monitoring
Only
WQ
Survey
WET WET Testing Multiple Tiered
Limits Only Categories Limits
J. - - -
Bio
Survey TRES MDLs Monitoring
- - L I
Other
Other
Abstract Information:
Partial; Outfall 001 only (abstract information applies to combined flow from 001 and 002).
Outfall: 001 Receiving Water: Laramie River Treatment: PC, Abs, GAC
Amount/Components:
Unspecified amount of treated wastewater from cleanup site, and uncontaminated water from outside drainlines.
Parameter
Acute WET
As (T)
Chronic WET
Cu (T)
Fe (T)
Flow
Pentachlorophenol
pH
Phenols
TDS
TPH
Zn (T)
Limitations
Monthly
Average
N/A
N/A
N/A
0.005000 mg/l
N/A
N/A
N/A
0.093000 mg/l
N/A
2.550000 mg/l
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
9600.000000 mg/l
N/A
N/A
N/A
0.650000 mg/l
Dai ly
Maximum
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
N/A
Report
N/A
0.126000 mg/l
N/A
N/A
N/A
25.400000 mg/l
N/A
N/A
N/A
10.000000 mg/l
N/A
N/A
Other
See below
See below
Between 6.0 and 9.0
su
Monitoring Requirements
Frequency
1 /quarter
1/month
1/quarter
1/month
1/month
continuous
1/month
1/month
1/month
1/month
1/month
1/month
Sample Type
8hr fw composite
8hr fw composite
8hr fw composite
8hr fw composite
8hr fw composite
total
grab
grab
grab
8hr fw composite
grab
8hr fw composite
Limitations/Monitoring Basis:
All limits and monitoring are based on the combined flow weighted discharges for points 001 and 002. The limit for
As (T) was developed based on WQ criteria; however, since the calculated limit was below the analytical detection
level, the limit was set at the detection level. The limits for Cu (T), Fe (T); Zn (T), phenols, and
pentachlorophenol are based on WQ criteria and were developed assuming that instream concentrations were equal to
one half of the analytical detection level and assuming a 1:9 dilution with the receiving stream. The TDS limit was
based on requirements for the use of the receiving stream for irrigation. The TPH and pH limits are based on BPJ;
TPH is considered a better indicator than O&G for non-crude oil such as that found onsite and the pH limits are used
for all discharges in the State. Chronic and acute WET limits of no toxicity were developed to prevent instream
tocicity based on the 1:9 dilution ratio. Specific protocols in accordance with EPA guidance manuals and regional
policy for chronic and acute WET testing are also provided. Retesting where acute o chronic toxicity is evident;
1/month acute WET testing is required if 2 consecutive acute WET tests show toxicity. WET monitoring requirements
may be reduced where no toxicity is found.
Special Conditions Basis:
Monitoring of the receiving stream flow on a
provided.
Effective Date: 06/28/91
weekly basis is required in order to ensure required dilution is
Expiration Date: 06/30/96 Abstract .Date:
04/23/93
Page: 409
-------
Facility Haute; Union Pacific RR, Laramie Tie
Permit Number: WY0032590
Facility Description: Remedial cleanup of a railroad tie treatment plant site
SIC Code: 2491
Page: 410
-------
APPENDIX A
TREATMENT TECHNOLOGY ABBREVIATIONS
-------
-------
TREATMENT TECHNOLOGY ABBREVIATIONS
AAS — Activated alumina sorption
Abs — Absorbent
Aer — Aeration
AerD — Aerobic digestion
AerL — Aerated lagoon
AFF — Aerobic fixed film
AirS — Air stripping
AnD — Anaerobic digestion
AnFF — Anaerobic fixed film
AnL — Anaerobic lagoon
API — Oil and water separator ,
AS — Activated sludge treatment (including sedimentation)
BGAC — Biological granular activated carbon
BiMaSe — Biomagnetic separation
BioR — Bioreactor
CAC — Chemically assisted clarification
ChOx — Chemical oxidation
ChOx/Pt — Chemical oxidation/precipitation
ChPt — Chemical precipitation
DAF — Dissolved air flotation
DeCl — Dechlorination
Def — Defoamer
Direct O2 Injec — Direct oxygen injection
Dis — Disinfection
Ele — Electrodialysis
EQ — Equalization
Fil — Filtration
FL — Facultative lagoon
A-l
-------
GAC — Granular activated carbon
HT — Heat treatment
IE — Ion exchange
KPEG — Dechlorination of toxics
Neut — Neutralization
PACT — Powdered activated carbon addition to AS
PC — Primary clarification
PF — Primary plus filtration
RBC — Rotating biological contactor
Red — Reduction
RO — Reverse osmosis
SBR — Sequential batch reactor
SCOx — Super critical oxidation
Scr — Screening
Sed '— Sedimentation
SExt — Solvent extraction
SS — Steam stripping
TF — Trickling filter
UF — Ultrafiltration
UV — Ultraviolet radiation
WOx — Wet air oxidation
A-2
-------
APPENDIX B
PARAMETERS PRESENT IN THE PERMITS
-------
-------
PARAMETERS PRESENT IN PERMITS
Conventional
Biochemical oxygen demand (5-day)
Fecal coliform
Oil and grease
pH
Total suspended solids
Non-conventional
Acidity
Alkalinity
Ammonia
Ammonia nitrogen (Total)
Ammonia nitrogen (un-ionized)
Ammonia as nitrogen
Ammonium ion
Boron
Boron (DS)
Bromide
Calcium
Carbon disulfide
Carbonaceous biochemical oxygen demand
Chemical oxygen demand
Chloride
Coliform (Total)
Color
Dissolved oxygen
Dissolved solids (Total)
Fecal Streptococci
Filterable residue (T)
Fluoride
Free available chlorine
Hardness
Nitrite nitrogen
Nitrite nitrogen as nitrogen
Nitrate nitrogen
Nitrate nitrogen as nitrogen
Nonfdterable residue (Total)
Organic nitrogen
Orthophosphate
Palladium
Phosphorous (Total)
Potassium
Salinity
Settleable solids
Silica
Sodium
Sodium nitrite
Sulfate (Total)
Conventional
BODS
FC
O&G
PH
TSS
Non-conventional
Acidity
Alkalinity
NH3
NH3(T)
NH3 (un-ionized)
NH3-N
NH4 +
B
B(DS)
Br
Ca
CS2
CBOD5
COD
Cl
Coliform (T)
Color
DO
TDS
FS
Filterable residue (T)
Fluoride
FAC
Hardness
N02
N02.N
N03
Nonfilterable residue (T)
Organic-N
Orthophosphate
Palladium
P(T)
K
Salinity
SS
Silica
Na
Sodium nitrite
S04
B-l
-------
PARAMETERS PRESENT IN PERMITS
Non-conventional (Continued)
Sulfate (dissolved)
Sulfides
Sulfite
Temperature
Total kjcldahl nitrogen (combined organic-N &
NH3-N)
Total nitrogen
Total organic carbon
Total oxidized nitrogen (combined NO2 & NO3)
Total residual chlorine
Turbidity
Organics
1,1,1-Trichloroethane
1,1,2-TrichIoroethane
1,1,2,2-Tetrachloroethane
1,1-Dichloroethane
1,1-Dichloroethylene
1,2,4-Trichlorobenzene
1,2,4,5-Tetrachlorobenzene
1,2-Cis-Dichloroethylene
1,2-Dichlorobenzene
1,2-Dichloroethane
1,2-Dichloropropane
1,2-Dichloropropylene
1,2-Diphenylhydrazine
1,2-Trans-Dichloroethylene
1,3-Dichlorobenzene
1,3-Dichloropropene
1,3-Trans-Dichloropropylene
1,4-Dichlorobenzene
2,2-Bis(4-hydroxy-phenyl) propane
2,4,6-Trichlorophenol
2,4-Dichlorophenol
2,4-Dimcthylphenol
2,4-Dinitrophenol
2,4-Dinitrotoluene
2,6-Dinitrotoluene
2-Chloroethyl vinyl ether
2-Chloronaphthalene
2-Chlorophenol
2-Nitrophenol
3,3-Dichlorobenzidine
4,6-D5nitro-o-cresol
4-Nitrophenol
Non-conventional (Continued)
SO4 (DS)
Sulfides
SO3
Temp.
TKN
N(T)
TOC
TON
TRC
Turbidity
Organics
1,1,1-Trichloroethane
1,1,2-Trichloroethane
1,1,2,2-Tetrachloroethane
1,1-Dichloroethane
1,1-Dichloroethylene
1,2,4-Trichlorobenzene
1,2,4,5-Tetrachlorobenzene
1,2-Cis-Dichloroethylene
1,2-Dichlorobenzene
1,2-Dichloroethane
1,2-Dichloropropane
1,2-Dichloropropylene
1,2-Diphenylhydrazine
1,2-Trans-Dichloroethylene
1,3-Dichlorobenzene
1,3-Dichloropropene
1,3-Trans-Dichloropropylene
1,4-Dichlorobenzene
2,2-Bis(4-hydroxy-phenyl) propane
2,4,6-Trichlorophenol
2,4-Dichlorophenol
2,4-Dimethylphenol
2,4-Dinitrophenol
2,4-Dinitrotoluene
2,6-Dinitrotoluene
2-Chloroethyl vinyl ether
2-Chloronaphthalene
2-Chlorophenol
2-Nitrophenol
3,3-Dichlorobenzidine
4,6-Dinitro-o-cresol
4-Nitrophenol
B-2
-------
PARAMETERS PRESENT IN PERMITS
Organics (Continued)
3,4-Benzofluoranthene
4,4'-DDT
4,4'-DDE
4,4'-DDD
4-Chlorophenyl phenyl ether
4-Bromophenyl phenyl ether
Acenaphthene
Acenaphthylene
Acrolein
Acrylonitrile
Aldrin
Alpha-endosulfan
Anthracene
Benzene
Benzidine
Benzo (a) anthracene
Benzo (a) pyrene
Benzo (ghi) perylene
Benzo (k) fluoranthane
Beta-endosulfan
BHC-Alpha
BHC-Beta
BHC-Gamma
BHC-Delta
Bis (2-chloroethyl) ether
Bis (2-chlorisopropyl) ether
Bis (2-chloroethoxy) methane
Bis (2-ethylhexyl) phthalate
Bromoform
Butyl benzyl phthalate
Carbon tetrachloride
Chlordane
Chlorobenzene
Chloroethane
Chloroform
Chlorodibromomethane
Chrysene
DDD
DDE
Dibenzo (a,h) anthracene
Dichlorobromomethane
Dichloropropene
Dieldrin
Diethyl phthalate
Dimethyl phthalate
Di-n-butyl phthalate
Organics (Continued)
3,4-Benzofluoranthene
4,4'-DDT
4,4'-DDE
4,4'-DDD
4-Chlorophenyl phenyl ether
4-Bromophenyl phenyl ether
Acenaphthene
Acenaphthylene
Acrolein
Acrylonitrile
Aldrin
Alpha-endosulfan
Anthracene
Benzene
Benzidine
Benzo (a) anthracene:
Benzo (a) pyrene
Benzo (ghi) perylene
Benzo (k) fluoranthane
Beta-endosulfan
Alpha-BHC
Beta-BHC
Gamma-BHC
Delta-BHC
Bis (2-chloroethyl) ether
Bis (2-chlorisopropyl) ether
Bis (2-chloroethoxy) methane
Bis (2-ethylhexyl) phthalate
Bromoform
Butyl benzyl phthalate
Carbon tetrachloride
Chlordane
Chlorobenzene
Chloroethane
Chloroform
Chlorodibromomethane
Chrysene
DDD
DDE
Dibenzo (a,h) anthracene
Dichlorobromomethane
D ichloropropene
Dieldrin
Diethyl phthalate
Dimethyl phthalate
Di-n-butyl phthalate
B-3
-------
PARAMETERS PRESENT IN PERMITS
Jprpanics (Continued)
Dinitrotoluene
Di-n-octyl phthalate
Endosulfan
Endosulfan sulfate
Endrin
Endrin aldehyde
Ethylbenzene
Fluoranthcnc
Fluorcne
Hcptachlor
Heptachlor epoxide
Hexachlorobenzene
Hcxachlorobutadiene
Hexachlorocyclopentadiene
Hcxachloroethane
Indcno (1,2,3-cd) pyrene
Isophorone
Methyl bromide
Methyl chloride
Mcthylene chloride
Naphthalene
Nitrobenzene
N-Nitrosodimethylamine
N-Nitrosodiphenylamine
N-Nitrosodi-n-propylamine
Parachlorometacresol
PCB-1242
PCB-1254
PCB-1221
PCB-1232
PCB-1248
PCB-1260
PCB-1016
Pcntachlorophenol
Phenol
Phenols
Phcnanthrene
Pyrcnc
Tctrachloroethylene
Toluene
Toxaphcne
Trichloroethylene
Vinyl chloride
Organics (Continued)
Dinitrotoluene
Di-n-octyl phthalate
Endosulfan
Endosulfan sulfate
Endrin
Endrin aldehyde
Ethylbenzene
Fluoranthene
Fluorene
Heptachlor
Heptachlor epoxide
Hexachlorobenzene
Hexachlorobutadiene
Hexachlorocyclopentadiene
Hexachloroethane
Indeno (1,2,3-cd) pyrene
Isophorone
Methyl bromide
Methyl chloride
Methylene chloride
Naphthalene
Nitrobenzene
N-Nitrosodimethylamine
N-Nitrosodiphenylamine
N-Nitrosodi-n-propylamine
Parachlorometacresol
PCB-1242
PCB-1254
PCB-1221
PCB-1232
PCB-1248
PCB-1260
PCB-1016
Pentachlorophenol
Phenol
Phenols
Phenanthrene
Pyrene
Tetrachloroethylene
Toluene
Toxaphene'
Trichloroethylene
Vinyl chloride
B-4
-------
PARAMETERS PRESENT IN PERMITS
Metals and Cyanide Metals and Cyanide
Aluminum (dissolved) Al (DS)
Aluminum (soluble) Al (S)
Aluminum (total recoverable) Al (TR)
Aluminum (total) Al (T)
Antimony (soluble) Sb (S)
Antimony (total recoverable) Sb (TR)
Antimony (total) Sb (T)
Antimony (dissolved) Sb (DS)
Arsenic (soluble) As (S)
Arsenic (total) As (T)
Arsenic (total recoverable) As (TR)
Arsenic (dissolved) As (DS)
Barium (dissolved) Ba (DS)
Barium (soluble) Ba (S)
Barium (total recoverable) Ba (TR)
Barium (total) Ba (T)
Beryllium (dissolved) Be (DS)
Beryllium (soluble) Be (S)
Beryllium (total recoverable) Be (TR)
Beryllium (total) Be (T)
Cadmium (soluble) Cd (S)
Cadmium (total recoverable) Cd (TR)
Cadmium (dissolved) Cd (DS)
Cadmium (total) Cd (T)
Chromium (total hexavalent) Cr"1"6
Chromium (dissolved hexavalent) Cr+6 (DS)
Chromium (soluble hexavalent) Cr+6 (S)
Chromium (trivalent) Cr+3
Chromium (soluble trivalent) Cr+3 (S)
Chromium (dissolved) Cr (DS)
Chromium (soluble) Cr (S)
Chromium (total recoverable) Cr (TR)
Chromium (total) Cr (T)
Cobalt (dissolved) Co (DS)
Cobalt (soluble) Co (S)
Cobalt (total) Co (T)
Cobalt (total recoverable) Co (TR)
Copper (soluble) Cu (S)
Copper (total) Cu (T)
Copper (total recoverable) Cu (TR)
Copper (dissolved) Cu (DS)
B-5
-------
PARAMETERS PRESENT IN PERMITS
Metals and Cvanide ("Continued)
Cyanide (amenable)
Cyanide (free)
Cyanide (total)
Cyanide (weak acid dissociable)
Gold (total)
Gold (soluble)
Gold (total recoverable)
Gold (dissolved)
Indium (total recoverable)
Indium (soluble)
Indium (total)
Iridium (dissolved)
Iron (dissolved)
Iron (soluble)
Iron (total)
Iron (total recoverable)
Lead (total recoverable)
Lead (soluble)
Lead (total)
Lead (dissolved)
Magnesium (dissolved)
Magnesium (soluble)
Magnesium (total recoverable)
Magnesium (total)
Manganese (dissolved)
Manganese (soluble)
Manganese (total)
Manganese (total recoverable)
Mercury (total)
Mercury (soluble)
Mercury (total recoverable)
Mercury (dissolved)
Molybdenum (dissolved)
Molybdenum (soluble)
Molybdenum (total)
Molybdenum (total recoverable)
Nickel (dissolved)
Nickel (soluble)
Nickel (total)
Nickel (total recoverable)
Osmium (total recoverable)
Osmium (soluble)
Osmium (dissolved)
Osmium (total)
Palladium (dissolved)
Palladium (soluble)
Metals and Cyanide (Continued)
CN(A)
CN(F)
CN (T)
CN (WAD)
Au(T)
Au (S)
Au (TR)
Au (DS)
Ir (TR)
Ir(S)
Ir (T)
Ir (DS)
Fe (DS)
Fe (S)
Fe (T)
Fe (TR)
Pb (TR)
Pb(S)
Pb(T)
Pb (DS)
Mg (DS)
Mg(S)
Mg (TR)
Mg(T)
Mn (DS)
Mn (S)
Mn (T)
Mn (TR)
Hg(T)
Hg(S)
Hg (TR)
Hg (DS)
Mo (DS)
Mo(S)
Mo (T)
Mo (TR)
Ni (DS)
Ni (S)
Ni (T)
Ni (TR)
Os (TR)
Os(S)
Os (DS)
Os(T)
Pd (DS)
Pd(S)
B-6
-------
PARAMETERS PRESENT IN PERMITS
Metals and Cvanide ("Continued)
Palladium (total recoverable)
Palladium (total)
Platinum (total)
Platinum (soluble)
Platinum (dissolved)
Platinum (total recoverable)
Rhodium (total)
Rhodium (soluble)
Rhodium (dissolved)
Rhodium (total recoverable)
Ruthenium (total recoverable)
Ruthenium (soluble)
Ruthenium (dissolved)
Ruthenium (total)
Selenium (dissolved)
Selenium (soluble)
Selenium (total recoverable)
Selenium (total)
Silver (total)
Silver (soluble)
Silver (total recoverable)
Silver (dissolved)
Thallium (total)
Thallium (soluble)
Thallium (dissolved)
Thallium (total recoverable)
Tin (dissolved)
Tin (soluble)
Tin (total)
Tin (total recoverable)
Titanium (dissolved)
Titanium (soluble)
Titanium (total recoverable)
Titanium (total)
Tungsten (total)
Tungsten (soluble)
Tungsten (total recoverable)
Tungsten (dissolved)
Vanadium (total recoverable)
Vanadium (soluble)
Vanadium (dissolved)
Vanadium (total)
Zinc (dissolved)
Zinc (soluble)
Zinc (total)
Zinc (total recoverable)
Metals and CyaniHp.
Pd (TR)
Pd (T)
Pt(T)
Pt(S)
Pt (DS)
Pt (TR)
Rh(T)
Rh(S)
Rh (DS)
Rh (TR)
Ru (TR)
Ru(S)
Ru (DS)
Ru(T)
Se (DS)
Se (S)
Se (TR)
Se(T)
Ag(T)
Ag(S)
Ag (TR)
Ag (DS)
Tl (T)
Tl (S)
Tl (DS)
Tl (TR)
Sn (DS)
Sn(S)
Sn(T)
Sn (TR)
Ti (DS)
Ti (S)
Ti (TR)
Ti (T)
W(T)
W (S)
W (DR)
W (DS)
V (TR)
V(S)
V(DS)
V(T)
Zn (DS)
Zn (S)
Zn (T)
Zn (TR)
B-7
-------
PARAMETERS PRESENT IN PERMITS
Miscellaneous
2,3,7,8-TCDD (dioxin)
2,3,7,8-TCDF (difuran)
Aldicarb
Amctryoe
Asbestos (fibrous)
Atrazine
Carbofuran
Chlorophyll
Chlorosyringaldehyde
Chlorpyrifos
Color
Dcmcton
Ethylcne glycol
Formaldehyde
Hydrazine
Isopropylbiphenyl
Lindane
Malathion
Methoxychlor
Methyl tert butyl ether
Mircx
Nitro-n-methyl phthalimide
Orthophosphate
Propylene glycol
Specific conductance
Tetrahydrofuran
Urea
Whole Effluent Toxicitv (WET).
Acute whole effluent toricity
Chronic whole effluent toxicity
Miscellaneous
2,3,7,8-TCDD
2,3,7,8-TCDF
Aldicarb
Ametryoe
Asbestos (fibrous)
Atrazine
Carbofuran
Chlorophyll
Chlorosyringaldehyde
Chlorpyrifos
Color
Demeton
Ethylene glycol
Formaldehyde
Hydrazine
Isopropylbiphenyl
Lindane
Malathion
Methoxychlor
Methyl tert butyl ether
Mirex
Nitro-n-methyl phthalimide
Orthosphosphate
Propylene glycol
Specific conductance
Tetrahydrofuran
Urea
Whole Efflne.nt Toxicitv (WET1
Acute WET
Chronic WET
B-8
-------
PARAMETERS PRESENT IN PERMITS
Aggregate Parameters
Adsorbable organic halogens
Aromatic hydrocarbons (total)
Aromatic hydrocarbons
Chlordane compounds
Clarifying agents
DDT and derivatives
Debris
Hydrocarbons (total)
Jet fuel
Metals (total)
Metals (rare earth)
PCBs (total)
Petroleum hydrocarbons (total)
Petroleum aromatic hydrocarbons
Polyaromatic hydrocarbons
Polynuclear aromatics
Priority pollutants
Purgeables (total)
Residual oxidents (total)
Surfactants
Thiocarbamates
Toxic pollutants
Toxic organics (total)
Trihalomethanes
Volatile organic compounds (total)
Xylenes
Radioactivity
Alpha (Total)
Alpha (Suspended)
Alpha (Dissolved)
Beta (Total)
Beta (Suspended)
Beta (Dissolved)
Gamma (Total)
Gamma (Suspended)
Gamma (Dissolved)
Radium (Total)
Radium 226
Aggregate Parameters
AOX
Aromatic hydrocarbons (total)
Aromatic hydrocarbons
Chlordane compounds
Clarifying agents
DDT and derivatives
Debris
Hydrocarbons (total)
Jet fuel
Metals (T)
Metals (rare earth)
PCBs (T)
TPH
PAHs
PAHs
PNAs (same as PAHs)
Priority pollutants
Purgeables (T)
TROs
Surfactants
Thiocarbamates
Toxic pollutants
TTOs
Trihalomethanes
VOCs (T)
Xylenes
Radioactivity
Alpha (T)
Alpha (SS)
Alpha (DS)
Beta (T)
Beta (SS)
Beta (DS)
Gamma (T)
Gamma (SS)
Gamma (DS) ,
Radium (T)
Radium (226)
B-9
-------
-------
APPENDIX C
LIST OF PERMITS
-------
-------
LIST OF PERMIT NUMBERS
AK 0000841
AK 0029840
AK 0043192
AK 0049786
AL 0002666
AL 0002968
AL 0003026
AL 0023272
AR 0000388
AR 0003018
AR 0035823
AR 0036544
CA 0004839
CA 0028797
CA 0048755
CA 0105139
CO 0000230
CO 0001121
CO 0026620
CO 0042064
CT 0000850
CT 0001180
CT 0001601
CT 0003263
GA 0001791
GA 0003620
GA 0003760
GA 0027707
HI 0000191
HI 0000281
HI 0020796
HI 0021148
IA 0000132
IA 0003395
IA 3126107
IA 7000102
ID 0000825
ID 0001163
ID 0001180
ID 0027154
IL 0000141
IL 0001643
IL 0003140
IL 0004073
IN 0002101
IN 0036447
IN 0038172
IN 0053384
KS 0000434
KS 0000817
KS 0001601
KS 0001635
KY 0004049
LA 0000418
LA 0004847
LA 0007501
LA 0007579
MA 0003557
MA 0004171
MA 0005011
MA 0005291
ME 0002054
ME 0002321
ME 0022314
ME 0022861
MN 0001422
MN 0001643
MN 0002011
MN 0002186
MN 0038962
MS 0000931
MS 0001783
MS 0035882
MS 0047759
NC 0004952
NC 0005274
NC 0005479
ND 0023809
ND 0024368
ND 0025038
ND 0025232
NH 0001261
NH 0001465
NH 0020788
NH 0021652
NJ 0003310
NJ 0031895
NJ 0070696
OH 0000621
OH 0002615
OH 0005282
OH 0009997
OK 0041629
OR 0000060
OR 0000141
OR 0000515
OR 0001635
RI 0000043
RI 0021920
RI 0021946
RI 0022021
SC 0000515
SC 0001368
SC 0003441
SC 0003557
SD 0000043
SD 0000281
SD 0025437
TN 0000353
TN 0004677
TN 0031631
TN 0067199
TX 0000167
TX 0000949
UT 0000167
VT 0000272
VT 0020401
VT 0020702
VT 0020966
WA 0002925
WA 0037265
WI 0000531
WI 0000914
WI 0001341
WI 0051764
WV 0004626
WV 0004707
WV 0005495
WV 0042641
WY 0000442
WY 0001171
WY 0003115
WY 0032590
C-l
-------
-------
APPENDIX D
LIMITATIONS/MONITORING BASIS INDEX
-------
-------
PERMITS CONTAINING
EFFLUENT LIMITATION GUIDELINES AS LIMITATIONS/MONITORING BASIS
AK 0000841
AK 0049786
AL 0002968
AL 0003026
AL 0023272
AR 0000388
CA 0004839
CO 0000230
CO 0001121
CT 0001180
CT 0001601
GA 0003760
GA 0027707
HI 0000191
HI 0000281
HI 0020796
ID 0001163
WATER
AK 0000841
AK 0029840
AK 0043192
AK 0049786
AL 0002666
AL 0002968
AL 0003026
AL 0023272
AR 0000388
AR 0003018
AR 0035823
AR 0036544
CA 0004839
CA 0028797
CA 0048755
CA 0105139
CO 0000230
CO 0001121
CO 0026620
CO 0042064
CT 0001180
CT 0001601
GA 0001791
GA 0003620
GA 0003760
HI 0000191
HI 0000281
ID 0001180
IL 0000141
IL 0001643
IL 0004073
IN 0002101
IN 0036447
KS 0000434
KS 0000817
KS 0001601
KS 0001635
LA 0000418
LA 0007501
LA 0007579
MA 0003557
MA 0004171
MA 0005011
MA 0005291
MN 0001422
PERMITS
MS 0000931
MS 0001783
MS 0035882
MS 0047759
NC 0004952
NC 0005274
NC 0005479
ND 0023809
ND 0024368
ND 0025232
NH 0001261
NH 0001465
OH 0005282
OK 0041629
OR 0000060
OR 0000141
OR 0000515
CONTAINING
QUALITY STANDARDS AS LIMITATIONS/MONITORING
HI 0020796
HI 0021148
ID 0001163
ID 0001180
ID 0027154
IL 0000141
IL 0001643
IL 0003140
IL 0004073
IN 0002101
IN 0036447
IN 0038172
IN 0053384
KS 0000434
KS 0000817
KS 0001601
KS 0001635
KY 0004049
LA 0004847
LA 0007501
LA 0007579
MA 0003557
MA 0004171
MA 0005011
MA 0005291
ME 0022314
MN 0001422
MS 0000931
MS 0001783
MS 0035882
MS 0047759
NC 0004952
NC 0005274
NC 0005479
ND 0023809
ND 0024368
ND 0025038
ND 0025232
NH 0001261
NH 0001465
NH 0020788
NH 0021652
OH 0000621
OH 0002615
OH 0005282
OH 0009997
OK 0041629
OR 0000141
OR 0000515
OR 0001635
RI 0000043
RI 0021946
RI 0022021
SC 0000515
RI 0000043
SC 0000515
SC 0001368
SC 0003441
SC 0003557
TN 0000353
TX 0000167
VT 0000272
VT 0020401
WA 0002925
WA 0037265
WV 0004626
WV 0042641
WY 0000442
WY 0003115
BASIS
SC 0001368
SC 0003441
SC 0003557
SD 0000043
SD 0000281
SD 0025437
TN 0000353
TN 0004677
TN 0031631
TN 0067199
TX 0000167
UT 0000167
VT 0020401
VT 0020702
WA 0002925
WI 0000531
WI 0000914
WI 0001341
WI 0051764
WV 0004626
WV 0004707
WV 0005495
WV 0042641
WY 0001171
WY 0003115
WY 0032590
D-l
-------
PERMITS CONTAINING
BEST PROFESSIONAL JUDGEMENT AS LIMITATIONS/MONITORING BASIS
AK 0000841
AK 0029840
AK 0043192
AK 0049786
AL 0002968
AL 0003026
AL 0023272
CA 0028797
CA 0105139
GO 0000230
CO 0001121
CO 0026620
CO 0042064
CT 0001601
GA 0001791
GA 0027707
HI 0020796
ID 0000825
ID 000ll63
ID 0027154
IL 0004073
IN 0002101
IN 0036447
KS 0000434
KS 0000817
KS 0001635
KY 0004049
LA 0004847
LA 0007501
MA 0003557
MA 0004171
MA 0005011
ME 0022314
MS 0047759
NC 0004952
ND 0023809
ND 0024368
ND 0025232
NH 0001465
NH 0020788
NH 0021652
OH 0000621
OH 0009997
OK 0041629
OR 0000060
OR 0000141
OR 0000515
OR 0001635
RI 0021946
SC 0003441
SD 0000043
SD 0000281
SD 0025437
TN 0031631
TN 0067199
UT 0000167
VT 0020702
WA 0037265
WI 0000531
WI 0000914
WV 0004626
WV 0004707
WV 0005495
WV 0042641
WY 0001171
WY 0032590
D-2
-------
PERMITS CONTAINING
MONITORING ONLY AS LIMITATIONS/MONITORING BASIS
AK 0000841
AK 0029840
AK 0043192
AK 0049786
AL 0002666
AL 0002968
AL 0003026
AL 0023272
AR 0000388
AR 0003018
AR 0035823
CA 0004839
CA 0028797
CA 0105139
CO 0000230
CO 0001121
CO 0026620
CO 0042064
CT 0000850
CT 0001180
CT 0001601
GA 0001791
GA 0003620
GA 0003760
GA 0027707
HI 0000191
HI 0000281
HI 0021148
IA 0003395
IA 3126107
ID 0000825
ID 0001163
ID 0027154
IL 0001643
IL 0003140
IL 0004073
IN 0002101
IN 0038172
IN 0053384
KS 0000434
KS 0000817
KS 0001601
KS 0001635
KY 0004049
LA 0000418
LA 0004847
LA 0007501
LA 0007579
MA 0005011
MA 0005291
ME 0022314
MN 0001422
MN 0002011
0035882
0047759
0004952
NC 0005274
NC 0005479
ND 0024368
ND 0025232
MS
MS
NC
NH 0001261
NH 0001465
NH 0020788
NH 0021652
NJ 0003310
NJ 0031895
OH 0000621
OH 0002615
OH 0005282
OH 0009997
OR 0000060
OR 0000141
OR 0000515
RI 0000043
RI 0021920
SC 0000515
SC 0001368
SC 0003441
SC 0003557
SD 0000043
SD 0000281
TN 0000353
TN 0004677
TN 0031631
TN 0067199
UT 0000167
VT 0020401
VT 0020702
WI 0000531
WI 0000914
WI 0001341
WI 0051764
WV 0004626
WV 0004707
WV 0005495
WV 0042641
WY 0000442
WY 0003115
D-3
-------
AL 0002666
AL 0002968
AL 0003026
AL 0023272
CA 0004839
CA 0028797
CO 0000230
CO 0026620
CO 0042064
CT 0000850
CT 0001180
CT 0001661
HI 0000191
PERMITS CONTAINING
WET LIMITS AS LIMITATIONS/MONITORING BASIS
HI 0000281
ID 0001163
IL 0001643
IL 0004073
KY 0004049
MA 0005291
MS 0000931
NC 0004952
NC 0005274
NH 0001261
OH 0009997
SD 0000043
SD 0000281
TN 0000353
TN 0067199
WA 0002925
WV 0004626
WV 0005495
WY 0000442
WY 0001171
WY 0003115
WY 0032590
PERMITS CONTAINING
WET TESTING ONLY AS LIMITATIONS/MONITORING BASIS
AK 0000841
AK 0029840
AR 0000388
AR 0003018
AR 0035823
AR 0036544
CA 0105139
CO 0000230
CO 0001121
IA 0000132
IA 3126107
IA 7000102
ID 0027154
IL 0000141
IL 0001643
IL 0003140
IL 0004073
IN 0002101
IN 0036447
IN 0038172
KS 0000817
KS 0001601
KY 0004049
LA 0000418
LA 0004847
LA 0007579
MA 0004171
MA 0005011
ME 0022314
NC 0005479
ND 0024368
ND 0025232
OH 0000621
OH 0002615
OH 0009997
OK 0041629
OR 0000060
OR 0000141
OR 0000515
OR 0001635
RI 0000043
SC 0000515
SC 0001368
SC 0003441
SC 0003557
SD 0000281
WA 0002925
WA 0037265
WI 0000531
WI 0000914
WI 0001341
WI 0051764
D-4
-------
PERMITS CONTAINING
MULTIPLE CATEGORIES AS LIMITATIONS/MONITORING BASIS
AL 0003026
AL 0023272
ID 0001163
KS 0001635
OH 0009997
AK 0049786
CA 0004839
HI 0020796
IL 0004073
IN 0036447
KS 0000817
LA 0000418
LA 0004847
AL 0002666
AL 0023272
AR 0000388
AR 0003018
AR 0035823
AR 0036544
CO 0000230
CO 0001121
CO 0026620
CO 0042064
GA 0003620
GA 0003760
GA 0027707
HI 0020796
ID 0001163
IL 0003140
IN 0002101
IN 0036447
IN 0038172
IN 0053384
KS 0000434
PERMITS CONTAINING
TIERED LIMITS AS LIMITATIONS/MONITORING BASIS
LA 0007501
MS 0000931
MS 0001783
MS 0035882
MS 0047759
NC 0004952
NC 0005274
NH 0001261
NH 0001465
OH 0000621
RI 0000043
SC 0000515
SC 0001368
SC 0003441
TN 0067199
TX 0000167
PERMITS CONTAINING
OTHER LIMITATIONS/MONITORING BASIS
KS 0000817
KS 0001601
LA 0004847
LA 0007501
LA 0007579
MA 0003557
MA 0004171
MA 0005011
MA 0005291
0000931
0035882
NC 0005274
ND 0024368
ND 0025038
ND 0025232
NH 0001465
NH 0020788
NH 0021652
NJ 0003310
0031895
0070696
MS
MS
NJ
NJ
OH 0000621
OH 0002615
OH 0005282
OR 0000060
OR 0001635
RI 0000043
RI 0021920
RI 0021946
RI 0022021
SC 0000515
SC 0001368
SC 0003441
SC 0003557
SD 0000043
SD 0000281
SD 0025437
TN 0000353
TN 0004677
TN 0031631
TN 0067199
TX 0000167
VT 0000272
VT 0020401
VT 0020702
VT 0020966
WI 0000531
WI 0000914
WI 0001341
WI 0051764
WV 0004626
WV 0004707
WV 0005495
WV 0042641
WY 0003115
D-5
-------
-------
APPENDIX E
SPECIAL CONDITIONS INDEX
-------
-------
PERMITS CONTAINING
SPECIAL CONDITIONS - BEST MANAGEMENT PRACTICES (BMPs)
AK 0029840
AK 0043192
AK 0049786
AL 0002666
AL 0002968
AL 0003026
AL 0023272
CO 0001121
CO 0042064
CT 0001180
GA 0001791
GA 0003620
GA 0003760
GA 0027707
ID 0000825
ID 0001163
IN 0002101
IN 0053384
KY 0004049
LA 0004847
MA 0003557
MA 0004171
MA 0005011
ME 0022314
ND 0025038
NH 0001465
NH 0020788
0021652
0031895
NH
NJ
OH 0002615
OH 0009997
OR 0000060
OR 0000141
OR 0000515
OR 0001635
SC 0000515
SC 0001368
SC 0003441
SC 0003557
TN 0031631
TN 0067199
VT 0000272
VT 0020702
WA 0002925
WI 0000914
WI 0051764
WV 0004626
WV 0005169
WY 0003115
PERMITS CONTAINING
SPECIAL CONDITIONS - STORM WATER POLLUTION PREVENTION PLAN
AL 0002666
AL 0003026
AL 0023272
CO 0001121
GA 0003620
GA 0003760
HI 0020796
LA 0004847
ME 0022314
NH 0020788
NH 0021652
OH 0002615
OH 0009997
TN 0031631
TX 0000167
WA 0002925
WI 0000914
WV 0004626
WV 0005169
WY 0000442
WY 0003115
E-l
-------
AK 0029840
AK 0043192
AK 0049786
CA 0048755
HI 0000191
ID 0001163
SC 0001368
WA 0002925
WA 0037265
WI 0051764
PERMITS CONTAINING
SPECIAL CONDITIONS - SEDIMENT TESTING
AK 0029840
AK 0043192
AK 0049786
AL 0023272
CO 0026620
GA 0003620
HI 0000191
HI 0000281
PERMITS CONTAINING
SPECIAL CONDITIONS - WATER QUALITY SURVEY
HI 0020796
HI 0021148
ID 0000825
ID 0001163
ID 0027154
IL 0003140
IL 0004073
ND 0025232
NH 0001465
OH 0005282
OH 0009997
OR 0001635
SD 0000043
TX 0000167
VT 0020401
WA 0037265
WV 0004707
WV 0005495
E-2
-------
PERMITS CONTAINING
SPECIAL CONDITIONS - TOXICITY REDUCTION EVALUATION (TRE)
AK 0029840
AK 0043192
AK 0049786
AL 0002666
AL 0003026
AL 0023272
CA 0004839
GA 0003620
HI 0000191
ID 0001163
IL 0001643
IL 0003140
NH 0001465
OH 0009997
OR 0000515
TX 0000167
WA 0037265
WV 0004707
AK 0000841
AR 0000388
AR 0003018
AR 0035823
AR 0036544
CO 0000230
CO 0001121
CO 0026620
CO 0042064
CT 0000850
CT 0001180
PERMITS CONTAINING
SPECIAL CONDITIONS - BIOMONITORING
CT 0001601
HI 0000191
HI 0000281
IA 7000102
ID 0001163
IL 0000141
IL 0001643
IL 0004073
IN 0002101
IN 0036447
IN 0038172
KY 0004049
LA 0000418
LA 0004847
LA 0007501
LA 0007579
0000931
0024368
0025232
OK 0041629
OR 0000060
OR 0000141
MS
ND
ND
OR 0000515
OR 0001635
RI 0000043
SD 0000043
SD 0000281
WA 0037265
WV 0005495
E-3
-------
PERMITS CONTAINING
SPECIAL CONDITIONS - METHOD DETECTION LEVELS (MDLs)
AK 0043192
AR 0035823
CO 0000230
CO 0001121
CO 0026620
CO 0042064
GA 0001791
ID 0001163
IL 0004073
AK 0000841
AK 0029840
AK 0043192
AK 0049786
AR 0003018
CA 0004839
CA 0048755
CA 0105139
CO 0000230
CO 0001121
CO 0026620
GA 0001791
GA 0003620
HI 0000191
HI 0000281
IN 0053384
KS 0000817
KY 0004049
LA 0004847
LA 0007501
LA 0007579
ME 0022314
MN 0001422
NH 0001465
OH 0009997
RI 0000043
SC 0000515
SD 0000043
SD 0025437
TN 0067199
TX 0000167
WI 0000531
WI 0000914
PERMITS CONTAINING
SPECIAL CONDITIONS
ID 0001163
ID 0027154
IL 0004073
IN 0002101
IN 0053384
KS 0000817
KS 0001635
KY 0004049
LA 0007579
MA 0003557
MA 0005291
ME 0022314
NC 0004952
NC 0005274
NC 0005479
- MONITORING
ND 0024368
ND 0025232
NH 0001465
NH 0021652
NJ 0003310
NJ 0070696
OH 0005282
OH 0009997
OR 0000060
OR 0000141
OR 0000515
OR 0001635
RI 0000043
RI 0021920
SC 0000515
SC 0001368
SD 0000043
SD 0000281
TN 0031631
VT 0000272
VT 0020401
VT 0020702
WA 0002925
WA 0037265
WI 0000914
WI 0051764
WV 0004707
WV 0005495
WY 0003115
WY 0032590
E-4
-------
PERMITS CONTAINING
OTHER SPECIAL CONDITIONS
AL 0002666
AL 0003026
AL 0023272
AR 0000388
AR 0003018
CA 0004839
CO 0000230
CO 0001121
CO 0026620
CO 0042064
CT 0001180
GA 0001791
GA 0003620
GA 0003760
GA 0027707
0000191
0021148
IA 0000132
IA 0003395
ID 0000825
ID 0001180
ID 0027154
HI
HI
KS
KS
IL 0001643
IL 0003140
IL 0004073
IN 0002101
IN 0036447
IN 0038172
IN 0053384
KS 0000434
0000817
0001601
KY 0004049
LA 0000418
LA 0004847
LA' 0007501
LA 0007579
MA 0003557
MA 0004171
MN 0001422
MN 0002011
0000931
0001783
0035882
MS
MS
MS
MS 0047759
NC 0005274
ND 0024368
NH 0001465
NJ 0003310
NJ 0031895
NJ 0070696
OH 0000621
OH 0002615
OH 0005282
OR 0000060
OR 0000515
OR 0001635
RI 0000043
0021920
0021946
RI 0022021
SC 0000515
SC 0001368
SD 0000043
SD 0000281
SD 0025437
RI
RI
TN 0000353
TN 0004677
TN 0031631
TN 0067199
TX 0000167
VT 0020401
VT 0020702
VT 0020966
WA 0002925
WI 0000531
WI 0000914
WI 0001341
WI 0051764
WV 0004626
WV 0004707
WV 0005169
WV 0005495
WV 0042641
WY 0000442
WY 0003115
E-5
-------
-------
APPENDIX F
EFFLUENT GUIDELINES INDEX
-------
-------
INDEX TO PERMITS CONTAINING
EFFLUENT LIMITATION GUIDELINES
40 GFR PART 405 - DAIRY PRODUCTS
OR 0000141
40 CFR PART 407 - CANNED AND PRESERVED FRUITS AND VEGETABLES
ID 0001180
40 CFR PART 408 - CANNED AND PRESERVED SEAFOOD PROCESSING
AK 0049786
40 CFR PART 409 - SUGAR PROCESSING
HI 0000191
HI 0000281
ND 0024368
40 CFR PART 410 - TEXTILE MILLS
AL 0002968
GA 0003760
MA 0004171
MS 0035882
MS 0047759
NC 0005479
RI 0000043
SC 0001368
40 CFR PART 414 - ORGANIC CHEMICALS, PLASTICS, AND SYNTHETIC FIBERS
AL 0003026
AL 0023272
IL 0000141
IL 0001643
IN 0002101
KS 0001635
LA 0007501
MA 0005291
MS 0004952
NC 0004952
NC 0005274
SC 0003441
SC 0003557
40 CFR PART 415 - INORGANIC CHEMICALS MANUFACTURING
WA 0037265
F-l
-------
40 GFR PART 416 - ORGANIC CHEMICALS, PLASTICS, AND SYNTHETIC FIBERS
SC 0003441
SC 0003557
40 CFR PART 418 - FERTILIZER MANUFACTURING , , , •
LA 0000418
40 CFR PART 419 - PETROLEUM REFINING
AK 0000841
IL 0004073
KS 0000434
WV 0004626 . .
WY 0000442
40 CFR PART 421 - NONFERROUS METALS MANUFACTURING
OR 0000060
40 CFR PART 423 - STEAM ELECTRIC
AR 0000388
CO 0001121
NH 0021652
KS 0001601
LA 0007579
MA 0003557
ND 0025232
NH 0001465
NH 0021652
OH 0005282
SC 0000515
VT 0020401
40 CFR PART 426 - GLASS MANUFACTURING
CA 0004839
40 CFR PART 430 - PULP AND PAPER
ID 0001163
IN 0036447
MA 0005011
ME 0002054
ME 0002321
MN 0001422
MN 0001643
NH 0001261
OK 0041629
OR 0000515
TX 0000167
WA 0002925
WI 0001341
WY 0003115
F-2
-------
40 CFR PART 432 - MEAT PRODUCTS
KS 0000817
MS 0001783
40 CFR PART 433 - METAL FINISHING
CT 0001180
GA 0027707
ME 0022861
MS 0000931
TN 0000353
VT 0000272
40 CFR PART 436 - MINERAL MINING AND PROCESSING
HI 0020796
ND 0023809
40 CFR PART 440 - ORE MINING AND DRESSING
CO 0000230
40 CFR PART 468 - COPPER FORMING
CT 0001601
F-3
-------
-------
APPENDIX G
POLLUTANT INDEX
-------
-------
LIST OF PARAMETERS
Parameter Name
1,1,1-Trichloroethane
1,1,1-Trichloroethane
1,1,1-Trichloroethane
1,1,1-Trichloroethane
1,1,1-Tri chloroethane
1,1,1-Trichloroethane
1,1,1-Trichloroethane
1,1,1-Trichloroethane
1,1,1-Trichloroethane
1,1,1-Trichloroethane
1,1,1-Trichloroethane
1,1,1-Trichloroethane
1,1,1-Trichloroethane
1,1,1-Trichloroethane
1,1,1-Trichloroethane
1,1,1-Trichloroethane
1,1,2,2-Tetrachloroethane
1,1,2,2-Tetrachloroethane
1,1,2-Trichloroethane
1,1,2-Trichloroethane
1,1,2-Trichloroethane
1,1,2-Trichloroethane
1,1,2-Tri chloroethane
1,1,2-Trichloroethane
1,1,2-Tri chloroethane
1,1,2-Trichloroethane
1,1,2-Trichloroethane
1,1,2-Trichloroethane
1,1,2-Trichloroethane
1,1,2-Trichloroethane
1,1,2-Trichloroethane
1,1,2-Trichloroethane
1,1,2-Trichloroethane
1,1-Dichloroethane
1,1-Dichloroethane
1,1-Dichloroethane
1,1-Dichloroethane
1,1-Dichloroethane
1,1-Dichloroethane
1,1-Dichloroethane
1,1-Dichloroethane
1,1-Dichloroethane
1,1-Dichloroethane
1,1-Dichloroethane
1,1-Dichloroethane
1,1-Dichloroethane
1,1-Dichloroethylene
1,1-Dichloroethylene
1,1-Dichloroethylene
1,1-Dichloroethylene
1,1-Dichloroethylene
1,1-Dichloroethylene
1,1-Dichloroethylene
1,1-Dichloroethylene
1,1-Dichloroethylene
1,1-Dichloroethylene
1,1-Dichloroethylene
1,1-Dichloroethylene
1,1-Dichloroethylene
1,1-Dichloroethylene
1,2,4,5-Tetrachlorobenzene
Permit
Number
AL 0003026
AL 0023272
CA 0028797
CO 0042064
GA 0027707
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
IX 0000949
CO 0042064
IA 7000102
AL 0003026
AL 0023272
CO 0042064
GA 0027707
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
IX 0000949
AL 0003026
AL 0023272
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
IX 0000949
AL 0003026
AL 0023272
CO 0042064
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
TX 0000949
CO 0042064
Parameter Name
1,2,4, 5-Tetr achlorobenzene
1,2,4, 5-Tetrachlorobenzene
1,2,4,5-Tetrachlorobenzene
1,2, 4-Trichlorobenzenei
1,2, 4-Trichlorobenzene
1,2, 4-Trichlorobenzenei
1,2, 4-Trichlorobenzene
1,2, 4-Trichlorobenzene
1,2, 4-Trichlorobenzene
1,2, 4-Trichlorobenzene
1,2, 4-Trichlorobenzene
1 , 2, 4-Trichlorobenzena
1,2, 4-Trichlorobenzene
1 , 2, 4-Trichlorobenzene
1,2, 4-Trichlorobenzene
1,2, 4-Trichlorobenzene
1,2-Cis-Dichloroethylene
1,2-Cis-Dichloroethylene
1 , 2-Dichlorobenzene
1 , 2-Dichlorobenzene
1,2-Dichlorobenzene
1,2-Dichlorobenzene
1,2-Dichlorobenzene
1,2-Dichlorobenzene
1 , 2-Dichlorobenzene
1,2-Dichlorobenzene
1 , 2-Dichlorobenzene
1,2-Dichlorobenzene
1,2-Dichlorobenzene
1,2-Dichlorobenzene
1,2-Dichlorobenzene
1 , 2-Dichlorobenzene
1, 2-Dichloroethane
1,2-Dichloroethane
1,2-Dichloroethane
1 , 2-Dichloroethane
1,2-Dichloroethane
1,2-Dichloroethane
1,2-Dichloroethane
1 , 2-Dichloroethane
1 , 2-Dichloroethane
1 , 2-Dichloroethane
1 , 2-Di chloro ethane
1,2-Dichloroethane
1,2-Dichloroethane
1 , 2-Dichloroethane
1 , 2-Dichloropropane
1,2-Dichloropropane
1 , 2-Dichloropropane
1,2-Dichloropropane
1 , 2-Dichloropropane
1,2-Dichloropropane
1 , 2-Dichloropropane
1 , 2-Dichloropropane
1,2-Dichloropropane
1, 2-Dichloropropane
1 , 2-Dichloropropane
1,2-Dichloropropane
1 , 2-Dichloropropane
1 , 2-Dichloropropane
1, 2-Diphenylhydrazine
Permit
Number
WI 0000531
WI 0000914
WI 0001341
AL 0003026
AL 0023272
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
TX 0000949
CA 0028797
CO 0042064
AL 0003026
AL 0023272
CO 0042064
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
TX 0000949
AL 0003026
AL 0023272
CO 0042064
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
TX 0000949
AL 0003026
AL 0023272
CO 0042064
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
TX 0000949
CO 0042064
G-l
-------
LIST OF PARAMETERS (cont.)
Parameter Mama
Permit
Number
Parameter Name
1,2-Trans-Dichloroethylene AL 0003026
1,2-Trans-Dichloroethylene AL 0023272
1,2-Trans-Dichloroethylene CA 0028797
1,2-Trans-Dichloroethylene CO 0042064
1,2-Trans-Diohloroathylene IA 7000102
1,2-Trans-Diohloroethylene IL 0000141
1.2-Trans-Dichloroethylene IL 0001643
1,2-Trans-Dichloroethylene IN 0002101
1,2-Trans-Dichloroethylene LA 0007501
1,2-Trans-Dichloroethylene MA 0005291
1,2-Trans-Dichloroethylene NC 0004952
1,2-Trans-Dichloroathylene NC 0005274
1,2-Trans-Dichloroethylene SC 0003441
1,2-Trans-Dichloroethylene SC 0003557
1,2-Trans-Dichloroathylene TX 0000949
1,3-Cis-Dichloropropylene AL 0003026
1,3-Cis-Dichloropropylene IN 0002101
1,3-Cis-Dichloropropylene LA 0007501
1,3-Cis-Dichloropropylene SC 0003441
1,3-Dichlorobenzene AL 0003026
1,3-Dichlorobenzene AL 0023272
1,3-Dichlorobenzene CO 0042064
1.3-Dichlorobenzene IA 7000102
1,3-Dichlorobenzena IL 0000141
1,3-Dichlorobenzene IL 0001643
1,3-Dichlorobenzene IN 0002101
1,3-Dichlorobenzene LA 0007501
1,3-Dichlorobenzene MA 0005291
1,3-Dichlorobenzene NC 0004952
1,3-Dichlorobenzane NC 0005274
1,3-Dichlorobanzene SC 0003441
1,3-Dichlorobanzene SC 0003557
1,3-Dichlorobenzene TX 0000949
1,3-Dichloropropene IA 7000102
1,3-Dichloropropene MA 0005291
1,3-Dichloropropena NC 0004952
1,3-Dichloropropene NC 0005274
1,3-Trans-Dichloropropylene IL 0001643
1.4-Dichlorobenzene AL 0003026
1,4-Dichlorobenzene AL 0023272
1,4-Dichlorobenzene CO 0042064
1,4-Dichlorobenzene IA 7000102
1,4-Dichlorobenzene IL 0000141
1,4-Dichlorobenzene IL 0001643
1,4-Dichlorobenzene IN 0002101
1,4-Dichlorobenzene LA 0007501
1,4-Dichlorobenzene MA 0005291
1,4-Dichlorobenzene NC 0004952
1,4-Dichlorobenzene NC 0005274
1,4-Dichlorobenzene SC 0003441
1,4-Dichlorobenzene SC 0003557
1,4-Dichlorobenzene TX 0000949
2,2-Bis (4-hydroxy-phenyl) pro IN 0002101
2,3,7,8-TCDD AR 0035823
2,3,7,8-TCDD CO 0042064
2,3,7,8-TCDD GA 0003620
2,3,7,8-TCDD ID 0001163
2,3,7,8-TCDD ME 0002054
2,3,7,8-TCDD ME 0002321
2,3,7,8-TCDD MN 0001643
2,3,7
2,3,7
2,3,7
2,3,7
2,3,7
2,3,7
2,3,7
8-TCDD
8-TCDD
8-TCDD
8-TCDD
8-TCDF
8-TCDF
,8-TCDF
2,3,7,8-TCDF
2,4,5-TP
2,4,5-TP
2,4,5-Trichlorophenol
2,4,6-Trichlorophenol
2,4,6-Trichlorophenol
2,4,6-Trichlorophenol
2,4,6-Trichlorophenol
2,4,6-Trichlorophenol
2,4-D
2,4-Dichlorophenol
2,4-Dichlorophenol
2,4-Dichlorophenol
2,4-Dichlorophenol
2,4-Dichlorophenol
2,4-Di chlorophenol
2,4-Dichlorophenol
2,4-Di chlorophenol
2,4-Dichlorophenol
2,4-Dichlorophenol
2,4-Dichlorophenol
2,4-Dichlorophenol
2,4-Dichlorophenol
2,4-Dichlorophenol
2,4-Dichlorophenol
2,4-Dimethylphenol
2,4-Dimethylphenol
2,4-Dimethylphenol
2,4-Dimethylphenol
2,4-Dimethylphenol
2,4-Dimathylphenol
2,4-Dimethylphenol
2, 4-Dimethylphenol
2,4-Dimethylphenol
2,4-Dimethylphenol
2,4-Dimethylphenol
2,4-Dimethylphenol
2,4-Dimethylphenol
2,4-Dimethylphenol
2,4-Dinitrophenol
2,4-Dinitrophenol
2,4-Dinitrophenol
2,4-Dinitrophenol
2,4-Dinitrophenol
2,4-Dinitrophenol
2,4-Dinitrophenol
2,4-Dinitrophenol
2,4-Dinitrophenol
2,4-Dinitrophenol
2,4-Dinitrophenol
2,4-Dinitrophenol
2,4-Dinitrophenol
2,4-Dinitrotoluene
TX 0000167
HI 0000531
WI 0000914
WI 0001341
ID 0001163
ME 0002054
ME 0002321
MN 0001643
BM 4444444
CO 0042064
CO 0042064
CO 0042064
MN 0001643
WI 0000531
WI 0000914
WI 0001341
CO 0042064
AL 0003026
AL 0023272
CO 0042064
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
MN 0001643
NC 0004952
NC 0005274
SC 0003441
SC 0003557
TX 0000949
AL 0003026
AL 0023272
CO 0042064
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
TX 0000949
AL 0003026
AL 0023272
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
TX 0000949
AL 0003026
G-2
-------
LIST OF PARAMETERS (cont.)
Parameter Name
Permit
Number
Parameter Name
2,4-Dinitrotoluene
2,4-Dinitrotoluene
2,4-Dinltrotoluene
2,4-Dinitrotoluene
2,4-Dinitrotoluene
2,4-Dinitrotoluene
2,4-Dinitrotoluene
2,4-Dinitrotoluene
2,4-Dinitrotoluene
2,4-Dinitrotoluene
2,4-Dinitrotoluene
2,4-Dinitrotoluene
2,6-Dinitrotoluene
2,6-Dinitrotoluene
2,6-Dinitrotoluene
2,6-Dinitrotoluene
2,6-Dinitrotoluene
2,6-Dinitrotoluene
2,6-Dinitrotoluene
2,6-Dinitrotoluene
2,6-Dinitrotoluene
2,6-Dinitrotoluene
2,6-Dinitrotoluene
2,6-Dinitrotoluene
2,6-Dinitrotoluene
2-Chlorophenol
2-Chlorophenol
2-Chlorophenol
2-Chlorophenol
2-Chlorophenol
2-Chlorophenol
2-Chlorophenol
2-Chlorophenol
2-Chlorophenol
2-Chlorophenol
2-Chlorophenol
2-Chlorophenol
2-Chlorophenol
2-Chlorophenol
2-Nitrophenol
2-Nitrophenol
2-Nitrophenol
2-Nitrophenol
2-Nitrophenol
2-Nitrophenol
2-Nitrophenol
2-Nitrophenol
2-Nitrophenol
2-Nitrophenol
2-Nitrophenol
2-Nitrophenol
2-Nitrophenol
3,3-Dichlorobenzidine
3,3-Dichlorobenzidine
3,3-Dichlorobenzidine
3,4-Benzofluoranthene
3,4-Benzofluoranthene
3,4-Benzofluoranthene
3,4-Benzofluoranthene
3,4-Benzofluoranthene
AL 0023272
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
IX 0000949
AL 0003026
AL 0023272
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
IX 0000949
AL 0003026
AL 0023272
CO 0042064
IA 7000102
IL 0000141
IL .0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
TX 0000949
AL 0003026
AL 0023272
IA 7000102
IL 0000141
IL 0001643
IN.0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
TX 0000949
WI 0000531
WI 0000914
WI 0001341
AL 0003026
AL 0023272
IA 7000102
IL 0000141
IL 0001643
3,4-Benzofluoranthene
3,4-Benzofluoranthene
3,4-Benzofluoranthene
3,4-Benzofluoranthene
3,4-Benzofluoranthene
3,4-Benzofluoranthene
3,4-Benzofluoranthene
3,4-Benzofluoranthene
4, 4--DDT
4, 4'-DDT
4, 4'-DDT
4,6-Dinitro-o-cresol
4,6-Dinitro-o-cresol
4,6-Dinitro-o-cresol
4,6-Dinitro-o-cresol
4,6-Dinitro-o-cresol
4,6-Dinitro-o-cresol
4,6-Dinitro-o-cresol
4,6-Dinitro-o-cresol
4,6-Dinitro-o-cresol
4,6-Dinitro-o-cresol
4,6-Dinitro-o-cresol
4,6-Dinitro-o-cresol
4,6-Dinitro-o-cresol
4-Nitrophenol
4-Nitrophenol
4-Nitrophenol
4-Nitrophenol
4-Nitrophenol
4-Nitrophenol
4-Nitrophenol
4-Nitrophenol
4-Nitrophenol
4-Nitrophenol
4-Nitrophenol
4-Nitrophenol
4-Nitrophenol
AOX
AOX
AOX
AOX
AOX
Acenaphthene
Acenaphthene
Acenaphthene
Acenaphthene
Acenaphthene
Acenaphthene
Acenaphthene
Acenaphthene
Acenaphthene
Acenaphthene
Acenaphthene
Acenaphthene
Acenaphthene
Acenaphthene
Acenaphthylene
Acenaphthylene
Ac enaphthylene
Ac enaphthylene
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
TX 0000949
WI 0000531
WI 0000914
WI 0001341
AL 0003026
AL 0023272
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
TX 0000949
AL 0003026
AL 0023272
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
TX 0000949
ID 0001163
ME 0002054
ME 0002321
MS 0001643
TX 0000167
AL 0003026
AL 0023272
CO 0042064
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
TX 0000949
AL 0003026
AL 0023272
IA 7000102
IL 0000141
G-3
-------
LIST OF PARAMETERS (cont.)
Parameter Kama
Permit
Number
Parameter Name
Aconophthylono
Acenaphthylene
Acenaphthylene
Aconnphthylono
Acenaphthylene
Acenaphthylona
Acenaphthylone
Acenaphthylene
Acenaphthylene
Acetonitrile
Acxoltin
Acrolein
Acrolein
Acrolain
Acrylonitrilo
Acrylonitrilo
Acrylonitrile
Acrylonltrilo
Acrylonitrile
Acrylonitrila
Acrylonitrile
Acrylonitrilo
Acrylonitrile
Acrylonitrile
Acrylonitrile
Acrylonitrile
Acrylonitrile
Acrylonitrile
Acrylonitrila
Acute HET
Acute WEI
Acute WET
Acute WET
Acute HET
Acute NET
Acute NET
Acute HEX
Acute WET
Acute VIET
Acute MET
Acute VIET
Acute VIET
Acute HET
Acute HET
Acute HET
Acuto HET
Acute HET
Acute HET
Acute HET
Acute HET
Acute HET
Acute HET
Acute HET
Acute HET
Acute HET
Acute HET
Acute HET
Acute HET
Acute HET
Acute HET
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
TX 0000949
OH 0002615
CO 0042064
HI 0000531
HI 0000914
HI 0001341
AL 0003026
AL 0023272
CO 0042064
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
OH 0002615
SC 0003441
SC 0003557
TX 0000949
AK 0000841
AL 0002666
AL 0002968
AL 0003026
AR 0000388
AR 0035823
AR 0036544
CA 0105139
CO 0000230
CO 0001121
CO 0026620
CO 0042064
CT 0000850
CT 0001180
CT 0001601
CT 0003263
HI 0000191
HI 0000281
IA 0000132
IA 3126107
IA 7000102
IL 0001643
IL 0003140
IN 0002101
IN 0036447
IN 0038172
KS 0000817
KS 0001601
LA 0000418
LA 0007579
MA 0004171
Acute HET
Acute HET1
Acute HET
Acute HET
Acute HET
Acute HET
Acute WET
Acute HET
Acute HET
Acute HET
Acute WET
Acute HET
Acute WET '
Acute HET
Acute WET
Acute HET
Acute WET
Acute WET
Acute WET
Acute HET
Acute WET
Acute WET
Acute WET
Acute WET
Acute WET
Acute WET
Acute HET
Acute WET
As
Ag
Ag
Ag
Ag
Ag CDS)
Ag (T)
Ag (T)
As (T)
Ag (T)
Ag (T)
Ag (T)
Ag (T)
Ag (T)
As (TR)
Ag (TR)
As (TR)
Al
Al
Al
Al
Al
Al
Al CDS)
Al (DS)
Al (S)
Al (T)
Al (T)
Al (T)
Al (T)
Al (T)
Al (T)
MA 0005011
MA 0005291
ME 0002054
ME 0002321
ME 0022314
MN 0001422
MN 0001643
MN 0038962
ND 0024368
ND 0025232
NH 0001261
OH 0009997
OK 0041629
OR 0000060
RI 0000043,
SC 0003557
SD 0000281
TN 0067199
WA 0002925
HI 0000531
WI 0000914
WI 0001341'
WI 0051764
WV 0004626
WV 0005495
WY 0000442
WY 0001171
WY 0032590
CT 0001180
GA 0027707
IN 0002101
SC 0000515
TN 0000353
CO 0000230
AR 0000388
IA 0003395
IA 3126107
LA 0004847
ME 0022861
MS 0000931
OH 0000621
OH 0009997
AL 0002666
CO 0042064
SD 0000043
CT 0001180
GA 0027707
OR 0000060
SC 0003441
TN 0067199
WI 0000531
CO 0000230
ID 0001163
MS 0000931
GA 0027707
IA 0003395
LA 0004847
MA 0004171
MS 0000931
NH 0020788
G-4
-------
LIST OF PARAMETERS (confe.)
Parameter Name
Parameter Name
Permit
Number
Al (T)
Al (TR)
Al (TR)
Al (TR)
Al (TR)
Al (TR)
Al (soluble)
Aldioarb ,
Aldrin '
Aldrin
Alkalinity
Alialinity
Alpha (DS)
Alpha (S3)
Alpha (T)
Alpha (T)
Alpha-BHC
Alpha-BHC
Alpha-BHC
Ametryoe
Anthracene
Anthracene
Anthracene
Anthracene
Anthracene
Anthracene
Anthracene
Anthracene
Anthracene
Anthracene
Anthracene
Anthracene
Anthracene
Aromatic hydrocarbons
As
As
As
As (DS)
As (DS)
As (T)
As (T)
As (T)
As (T)
As (T)
As (T)
As (T)
As (TR)
As (TR)
As (TR)
As (TR)
Asbestos (fibrous)
Atrazine
Au
B
B
B
BETX
BHC
BHC
BHC
WV 0005495
CO 0042064
ID 0001163
IN 0002101
IN 0053384
KY 0004049
MS 0000931,.
CO 0042064
CO 0042064
WI 0000531
AR 0035823
LA 0000418,
KY 0004049
KY 0004049
CO 0042064
LA 0004847
WI 0000531
WI 0000914
WI 0001341
HI 0021148
AL 0003026
AL 0023272
IA 7000102.
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
IX 0000949
AK OOQ0841
CA 0028797
SC 0000515
SC 0003441
CO 0000230
ID 0001163 .
AR 0000388
CO 0042064
IA 0003395
LA 0004847
OH 0009997
WV 0004626
WY 0032590
AK 0043192
ID 0001163
OH 0005282
SD 0000043
CO 0042064
HI 0021148
CT 0001180
CO 0042064
IL 0000141
SC 0000515
SD 0000281
CO 0042064
WI 0000531
WJ 0000914
BHC
BODS
BOD5
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BOD5
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BQD5
BODS
BODS
BODS
BODS
BODS
BODS
BOPS
BODS
BODS
BODS
BODS
BODS
BOD5
BODS
BODS
BODS
BOD5
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BOD5
BODS
BODS
BODS
BODS
WI 0001341
AK 0000841
AK 0029840
AK 0049786
AL 0002968
AL 0003026
AL 0023272
AR 0000388
AR 0003018
AR 0035823
AR 0036S44
CA 0004839
CA 0028797
CO 0000230
CO 0001121
CO 0026620
CO 0042064
CT 0000850
CT 0001180
GA 0001791 ,
6A 0003620
GA 0003760
GA 0027707
HI 0000191
HI 0000281
IA 3126107
IA 7000102
ID 0001163
ID 0001180
ID 0027154
IL 0000141,
IL 0001643
IL 0003140
IL 0004073
IN 0002101
IN 0036447
KS 0000434
KS 0000817
KS 0001635
KY 0004049
LA 0004847
LA 0007501
MA 0004171
MA 0005011
MA 0005291
ME 0002054
ME 0002321
MM 0001643
MS 0000931
MS 0001783
MS 0035882
MS 0047759
NC 0004952
NC 0005274
NC 0005479
ND 0024368
. ND 0025038
ND 0025232
NH 0001261 ,
OH 0000621
G-5
-------
LIST OF PARAMETERS (cont.)
Parameter Name
Permit
Number
Parameter Name
Permit
Number
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
BODS
Ba
Ba
Ba (T)
Ba (T)
Ba (!)
Ba (TR)
Be (T)
Ba (TR)
Ba (TR)
Benzene
Benzene
Benzene
Banzene
Banzana
Banzana
Banzana
Banzana
Banzene
Benzana
Benzane
Banzene
Benzene
Benzene
Benzene
Benzene
Benzene
Benzene
Benzidine
Benzo (a)
Benzo (a)
Benzo (a)
Banzo (a)
Benzo (a)
Benzo (a)
Benzo (a)
anthracene
anthracene
anthracene
anthracene
anthracene
anthracene
anthracene
OK 0041629
OR 0000060
OR 0000141
OR 0000515
RI 0000043
RI 0021920
SC 0000515
SC 0001368
SC 0003441
SC 0003557
SO 0000281
IN 0067199
TX 0000167
VI 0020401
VI 0020702
VI 0020966
HA 0002925
WI 0000531
HI 0001341
WI 0051764
WV 0004626
WV 0005495
WV 0042641
WY 0000442
WY 0003115
IA 0003395
SC 0000515
AL 0002666
HI 0021148
IL 0000141
CO 0042064
LA 0004847
CO 0042064
OH 0005282
AL 0003026
AL 0023272
CA 0105139
CO 0042064
IA 7000102
IL 0000141
IL 0001643
IL 0004073
IN 0002101
LA 0007501
MA 0005291
ME 0022314
NC 0004952
NC 0005274
RI 0021946
SC 0003441
SC 0003557
IX 0000949
CO 0042064
AL 0003026
AL 0023272
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
Benzo (a) anthracene MA 0005291
Benzo (a) anthracene NC 0004952
Benzo (a) anthracene NC 0005274
Benzo (a) anthracene SC 0003441
Benzo (a) anthracene SC 0003557
Benzo (a) anthracene TX 0000949
Benzo (a) pyrene AL 0003026
Benzo (a) pyrene AL 0023272
Benzo (a) pyrene IA 7000102
Benzo (a) pyrene IL 0000141
Benzo (a) pyrene IL 0001643
Benzo (a) pyrene LA 0007501
Benzo (a) pyrene MA 0005291
Benzo (a) pyrene NC 0004952
Benzo (a) pyrene NC 0005274
Benzo (a) pyrene OR 0000060
Benzo (a) pyrene SC 0003441
Benzo (a) pyrene SC 0003557
Benzo (a) pyrene TX 0000949
Benzo (d) pyrene IN 0002101
Benzo (k) fluoranthane AL 0003026
Benzo (k) fluoranthane AL 0023272
Benzo (k) fluoranthane IA 7000102
Benzo (k) fluoranthane IL 0000141
Benzo (k) fluoranthane IL 0001643
Benzo (k) fluoranthane IN 0002101
Benzo (k) fluoranthane LA 0007501
Benzo (k) fluoranthane MA 0005291
Benzo (k) fluoranthane NC 0004952
Benzo (k) fluoranthane NC 0005274
Benzo (k) fluoranthane SC 0003441
Benzo (k) fluoranthane SC 0003557
Benzo (k) fluoranthane TX 0000949
Beta (DS) KY 0004049
Beta (SS) KY 0004049
Beta (T) CO 0042064
Beta-BHC WI 0000531
Beta-BHC WI 0000914
Beta-BHC WI 0001341
Bis (2-chlorisopropyl) ether IA 7000102
Bis (2-chlorisopropyl) ether IN 0002101
Bis (2-chlorisopropyl) ether NC 0004952
Bis (2-chloroethyl) ether CO 0042064
Bis (2-ethylhexyl) phthalate AL 0003026
Bis (2-ethylhexyl) phthalate AL 0023272
Bis (2-ethylhexyl) phthalate IA 7000102
Bis (2-ethylhexyl) phthalate IL 0000141
Bis (2-ethylhexyl) phthalate IL 0001643
Bis (2-ethylhexyl) phthalate IN 0002101
Bis (2-ethylhexyl) phthalate LA 0007501
Bis (2-ethylhexyl) phthalate MA 0005291
Bis (2-ethylhexyl) phthalate NC 0004952
Bis (2-ethylhexyl) phthalate NC 0005274
Bis (2-ethylhexyl) phthalate NC 0005479
Bis (2-ethylhexyl) phthalate SC 0003441
Bis (2-ethylhexyl) phthalate SC 0003557
Bis (2-ethylhexyl) phthalate TX 0000949
Boron (B) MA 0003557
Br AL 0002666
Bromoform GA 0027707
G-6
-------
LIST OF PARAMETERS (cont.)
Parameter Name
Permit
Number
Parameter Name
Permit
Number
Bromoform
CBOD5
CBOD5
CBOD5
CBOD5
CBOD5
CBOD5
CBOD5
CBOD5
CBOD5
CN
CN
CN
CN
CN
CN (A)
CN (T)
CN (T)
CN (T)
CN (T)
CN (T)
CN (T)
CN (T)
CN (T)
CN (T)
CN (T)
CN (T)
CN (T)
CN (T)
CN (T)
CN (T)
CN (T)
CN (T)
CN (T)
CN (T)
CN (T)
CN (T)
CN (WAD)
CN (free)
CN (free)
COD
COD
COD
COD
COD
COD
COD
COD
COD
COD
COD
COD
COD
COD
COD
COD
COD
COD
COD
COD
MA 0005291
AR 0003018
IL 0001643
MN 0001422
MN 0038962
OH 0000621
OH 0002615
OH 0005282
TN 0067199
TX 0000949
IL 0003140
IN 0002101
IN 0053384
OR 0000060
VI 0000272
GA 0027707
AL 0003026
AL 0023272
CO 0000230
CT 0001180
GA 0027707
IA 0003395
IA 3126107
IA 7000102
IL 0000141
IL 0001643
IN 0038172
MA 0005291
ME 0022861
MS 0000931
NC 0004952
NC 0005274
OH 0002615
OH 0009997
SC 0003441
IN 0000353
WI 0000531
SD 0000043
CO 0042064
OH 0009997
AK 0000841
AL 0002968
AL 0003026
AR 0036544
GA 0001791
GA 0003760
IA 7000102
IL 0004073
IN 0002101
KS 0000434
KS 0001601
LA 0004847
LA 0007501
MA 0004171
MS 0047759
NC 0005479
ND 0024368
ND 0025232
NJ 0031895
NJ 0070696
COD
COD
COD
COD
COD
COD
COD
COD
COD
CS2
CS2
Carbofuran
Carbon tetraohloride
Carbon tetraohloride
Carbon tetrachloride
Carbon tetraohloride
Carbon tetraohloride
Carbon tetraohloride
Carbon tetraohloride
Carbon tetrachloride
Carbon tetraohloride
Carbon tetraohloride
Carbon tetraohloride
Carbon tetraohloride
Carbon tetrachloride
Carbon tetraohloride
Cd
Cd
Cd
Cd
Cd
Cd
Cd
Cd (DS)
Cd (T)
Cd (T)
Cd (T)
Cd (T)
Cd (T)
Cd (T)
Cd (T)
Cd (T)
Cd (T)
Cd (T)
Cd (T)
Cd (T)
Cd (T)
Cd (TR)
Cd (TR)
Cd (TR)
Cd (TR)
Cd (TR)
Chlordane
Chlordane
Chlordane
Chlordane
Chloride
Chloride
Chloride
Chloride
RI 0000043
SC 0001368
IN 0067199
VI 0020702
WI 0001341
WV 0004626
WV 0004707
WV 0005495
m 0000442
AL 0003026
CO 0042064
CO 0042064
AL 0003026
AL 0023272
CO 0042064
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
TX 0000949
CA 0028797
CT 0001180
GA 0027707
SC 0000515
IN 0000353
VI 0000272
VI 0020401
CO 0000230
AR 0000388
CO 0000230
GA 0027707
IA 0003395
IA 3126107
IL 0000141
LA 0004847
ME 0022861
MS 0000931
OH 0009997
OK 0041629
RI 0000043
SC 0000515
AL 0023272
CO 0042064
KY 0004049
OH 0005282
SD 0000043
CO 0042064
WI 0000531
WI 0000914
WI 0001341
AL 0002666
AL 0003026
AL 0023272
CO 0042064
G-7
-------
LIST OF PARAMETERS (cont.)
Pnrerooter Name
Permit
Number
Parameter Name
Permit
Number
Chloride
Chloride
Chloride
Chloride
Chloride
Chloride
Chloride
Chloride
Chloride
Chlorobonzone
Chlorobenzono
Chlorobonzono
Chlorobonzono
Chlorobonzono
Chlorobonzono
Chlorobonzene
Chlorobonzono
Chlorobonzono
Chlorobonzono
Chlorobonzono
Chlorobonzene
Chlorobonzano
Chlorobonzono
Chlorobonzona
Chlorodibromomethane
Chloroothnno
Chloroethane
Chloroethana
Chloroothnno
Chloroethane
Chloroebhane
Chloroothnno
Chloroathnno
Chloroothane
Chloroethane
Chloroethane
Chloroethane
Chloroethane
Chloroform
Chloroform
Chloroform
Chloroform
Chloroform
Chloroform
Chloroform
Chloroform
Chloroform
Chloroform
Chloroform
Chloroform
Chloroform
Chloroform
Chlorosyringaldehyde
Chronic WEI
Chronic WET
Chronic HEX
Chronic WET
Chronic WET
Chronic WET
Chronic WET
IL 0000141
IL 0004073
IN 0002101
IN 0038172
MS 0047759
WI 0051764
WV 0004626
WV 0004707
WV 0005495
AL 0003026
AL-0023272
CO 0042064
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
RI 0022021
SC 0003441
SC 0003557
TX 0000949
RI 0022021
AL 0003026
AL 0023272
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
TX 0000949
AL 0003026
AL 0023272
IA 7000102
ID 0001163
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
XX 0000949
MN 0001643
AK 0000841
AL 0023272
AR 0000388
AR 0003018
CA 0004839
CA 0028797
CO 0000230
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET•
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chronic WET
Chrysene
Chrysene
Chrysene
Chrysene
Chrysene
Chrysene
Chrysene
Chrysene
Chrysene
Chrysene
Chrysene
Chrysene
Chrysene
Cl
Cl
Clarifying agents
Clarifying agents
Clarifying agents
Co
CO 0001121
CO 0042064
CT 0000850
CT 0001180
CT 0001601
CT 0003263
HI 0000191
HI 0000281
ID 0001163
IL 0004073
IN 0038172
KY 0004049
LA 0004847
LA 0007579
MA 0005011
ME 0002321
ME 0022861
MS 0000931
NC 0004952
NC 0005274
NC 0005479
OH 0000621
OH 0002615
OH 0009997
OR 0000060
OR 0000141
OR 0000515
OR 0001635
SC 0000515
SC 0001368
SC 0003441
SD 0000043
TN 0000353
TN 0067199
TX 0000167
TX 0000949
WI 0000531
WI 0001341
WI 0051764
WV 0005495
WY 0032590
AL 0003026
AL 0023272
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
TX 0000949
AR 0003018
IL 0004073
AR 0035823
LA 0000418
LA 0004847
CA 0004839
G-8
-------
LIST OF PARAMETERS (cont.)
Parameter Name
Permit
Number
Parameter Name
Co (T)
Co (T)
Co (TR)
Coliform (T)
Coliform (T)
Coliform (T)
Coliform (T)
Coliform (T)
Color
Color
Color
Color
Color
Color
Color
Color
Color
Cr
Cr
Cr
Cr
Cr
Cr
Cr (T)
Cr (T)
Cr (T)
Cr (T)
Cr (T)
Cr (T)
Cr (T)
Cr (I)
Cr (T)
Cr (T)
Cr (T)
Cr (T)
Cr (T)
Cr (T)
Cr (T)
Cr (T)
Cr (T)
Cr (T)
Cr (T)
Cr (T)
Cr (T)
Cr (I)
Cr (I)
Cr (T)
Cr (T)
Cr (T)
Cr (T)
Cr (T)
Cr (T)
Cr (T)
Cr (T)
Cr (T)
Cr (T)
Cr (T)
Cr (1R)
Cr (TR)
Cr (TR)
AL 0002666
MA 0005291
CO 0042064
CA 0004839
CT 0000850
IN 0036447
ND 0025232
RI 0000043
AL 0002968
GA 0003620
MA 0004171
MA 0005291
ME 0002054
ME 0002321
OH 0000621
OH 0005282
OR 0000515
CA 0004839
GA 0027707
LA 0007579
SC 0000515
SC 0003441
IN 0000353
AK 0000841
AL 0002968
AL 0003026
AL 0023272
CO 0001121
CT 0001180
CT 0001601
GA 0001791
GA 0003760
GA 0027707
IA 0003395
IA 3126107
IA 7000102
IL 0000141
IL 0004073
IN 0002101
IN 0038172
KS 0000434
KY 0004049
LA 0004847
MA 0005291
ME 0022861
MN 0038962
MS 0000931
MS 0047759
NC 0004952
NC '0005274
OH 0000621
OH 0009997
RI 0000043
SC 0001368
VT 0000272
WV 0004626
WY 0000442
AL 0002666
CO 0042064 ,
IL 0001643
Cr (TR)
Cr (TR)
Cr (TR)
Cr+3
Cr+6
Cr+6
Cr+6
Cr+6
Cr+6
Cr+6
Cr+6
Cr+6
Cr+6
Cr+6
Cr+6
Cr+6
Cr+6
Cr+6
Cr+6
Cr+6
Cr+6
Cr+6 (DS)
Cr+6 (DS)
Cr+6 (S)
Cu
Cu
Cu
Cu
Cu
Cu
Cu
Cu
Cu
Cu
Cu
Cu
Cu
Cu
'Cu
Cu (DS)
Cu (DS)
Cu (DS)
Cu (T)
Cu (T)
Cu (T)
Cu (T)
Cu (T)
Cu (T)
Cu (T)
Cu (T)
Cu (T)
Cu (T)
Cu (T)
Cu (T)
Cu (T)
Cu (T)
Cu (T)
Cu (T)
Cu (T)
Cu (T)
KY 0004049
OH 0005282
SD 0000043
VT 0020401
AK 0000841
CA 0028797
CO 0000230
CO 0042064
CT 0001601
IA 3126107
IL 0004073
IN 0038172
KS 0000434
KY 0004049
ME 0022861
MN 0038962
MS 0000931
OH 0009997
WI 0000531
WV 0004626
WY 0000442
OH 0000621
OH 0009997
ID 0001163
AK 0043192
CA 0028797
CT 0001180
CT 0001601
GA 0001791
GA 0027707
LA 0007579
MS 0035882
SC 0001368
SC 0003441
TN 0000353
VT 0000272
VT 0020401
WA 0037265
WV 0042641
CO 0000230
CO 0042064
ID 0001163
AL 0003026
AL 0023272
AR 0000388
CO 0000230
CT 0003263
IA 0003395
IA 3126107
IA 7000102
IL 0000141
IL 0001643
LA 0004847
LA 0007501
MA 0004171
MA 0005291
ME 0022861
MN 0002011
MS 0000931
NC 0004952
G-9
-------
I
LIST OF PARAMETERS (cont.)
Pnrair.ator Naroa
Permit
Number
Parameter Name
Permit
Number
Cu (T)
Cu tT)
Cu (I)
Cu (I)
Cu (X)
Cu (I)
Cu (T)
Cu (T)
Cu (T)
Cu (T)
Cu (T)
Cu (T)
Cu (T)
Cu (I)
Cu (TR)
Cu (TR)
Cu (TR)
Cu (TR)
Cu (TR)
Cu (TR)
Cu (TR)
Cu (TR)
Cu (TR)
Cu (TR)
Cu (TR)
ODD
DDE
DDT and derivatives
DO
DO
DO
DO
DO
DO
DO
DO
DO
DO
DO
DO
DO
DO
DO
DO
DO
DO
DO
DO
DO
DO
DO
DO
Demabon
Di-n-butyl phthalate
Di-n-butyl phthalate
Di-n-butyl phthalate
Di-n-butyl phthalate
Di-n-butyl phthalate
Di-n-butyl phthalate
Di-n-butyl phthalate
HC 000527*
UD 0025232
HH 0001465
NH 0020788
OH 0000621
OH 0009997
RI 0000043
SC 0000515
TX 0000949
WI 0000914
WI 0051764
' WV 0004626
WX 0003115
WY 0032590
AK 0043192
AL 0002666
AL 0002968
AL 0003026
AL 0023272
ID 0001163
IN 0002101
IN 0038172
KX 0004049
OH 0005282
SD 0000043
CO 0042064
CO 0042064
CO 0042064
AL 0002968
AR 0003018
CA 0004839
CA 0028797
CO 0042064
HI 0000281
HI 0021148
IA 3126107
ID 0001180
ID 0027154
KS 0000434
MS 0035882
NC 0005274
NC 0005479
ND 0024368
NH 0001465
OH 0002615
OH 0005282
SC 0001368
SC 0003441
SC 0003557
TN 0067199
TX 0000949
WV 0005495
CO 0042064
AL 0003026
AL 0023272
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
Di-n-butyl phthalate
Di-n-butyl phthalate
Di-n-butyl phthalate
Di-n-butyl phthalate
Di-n-butyl phthalate
Di-n-butyl phthalate
Dichloropropene
Dieldrin
Dieldrin
Dieldrin
Dieldrin
Diethyl phthalate
Diethyl phthalate
Diethyl phthalate
Diethyl phthalate
Diethyl phthalate
Diethyl phthalate
Diethyl phthalate
Diethyl phthalate
Diethyl phthalate
Diethyl phthalate
Diethyl phthalate
Diethyl phthalate
Diethyl phthalate
Dimethyl phthalate
Dimethyl phthalate
Dimethyl phthalate
Dimethyl phthalate
Dimethyl phthalate
Dimethyl phthalate
Dimethyl phthalate
Dimethyl phthalate
Dimethyl phthalate
Dimethyl phthalate
Dimethyl phthalate
Dimethyl phthalate
Dimethyl phthalate
Dinitrotoluene
Endosulfan sulfate
Endosulfan sulfate
Endosulfan sulfate
Endrin
Endrin
Endrin
Endrin
Ethylbenzene
Ethylbenzene
Ethylbenzene
Ethylbenzene
Ethylbenzene
Ethylbenzene
Ethylbenzene
Ethylbenzene
Ethylbenzene
Ethylbenzene
Ethylbenzene
Ethylbenzene
Ethylbenzene
Ethylbenzene
Ethylbenzene
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
TX 0000949
CO 0042064
CO 0042064
WI 0000531
WI 0000914
WI 0001341
AL 0003026
AL 0023272
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
TX 0000949
AL 0003026
AL 0023272
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
TX 0000949
CO 0042064
CO 0042064
WI 0000531
WI 0001341
CO 0042064
WI 0000531
WI 0000914
WI 0001341
AL 0003026
AL 0023272
CA 0028797
CA 0105139
CO 0042064
IA 7000102
IL 0000141
IL 0001643
IL 0004073
IN 0002101
LA 0007501
MA 0005291
ME 0022314
NC 0004952
NC 0005274
G-10
-------
LIST OF PARAMETERS (cont.)
Parameter Nama
Permit
Number
Parameter Name
Permit
Number
Ethylbenzene
Ethylbenzene
Ethylbenzene
Ethylbenzene
Ethylbenzene
Ethylene glycol
FAC
FAC
FAC
FAC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
FC
Fe
Fe
Fe
Fe
Fe
Fe (DS)
Fe (T)
Fe (T)
Fe (T)
Fe (T)
RI 0021946
RI 0022021
SC 0003411
SC 0003557
TX 0000949
CO 0026620
CT 0003263
LA 0007579
NH 0021652
VI 0020401
AK 0029840
AR 0003018
CO 0000230
CO 0001121
CO 0026620
CO 0042064
CT 0000850
GA 0001791
GA 0027707
IA 3126107
ID 0001180
ID 0027154
IL 0000141
IL 0003140
IN 0002101
KS 0000817
KY 0004049
LA 0004847
MA 0004171
MN 0038962
MS 0001783
MS 0035882
MS 0047759
NC 0004952
NC 0005479
ND 0024368
OH 0000621
OH 0005282
OR 0000060
OR 0000141
RI 0000043
SC 0000515
SC 0001368
SC 0003441
SC 0003557
SD 0000281
WV 0004626
WV 0005495
WV 0042641
WY 0003115
CT 0001180
CT 0001601
GA 0027707
LA 0007579
VT 0020401
CO 0042064
AR 0000388
IL 0003140
MA 0005291
MN 0002011
Fe (T)
Fe (T)
Fe (T)
Fe CT)
Fe (T)
Fe (T)
Fe (T)
Fe (T)
Fe (T)
Fe (T)
Fe (T)
Fe (TR)
Fe (TR)
Fe (TR)
Fe (TR)
Fecal streptococci (FS)
Fecal streptococci (FS)
Filterable Residue (T)
Fl
Fl
Fl
Fl
Fl
Fl
Fl
Fl
Fl
Fl
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
ND 0025038
ND 0025232
NH 0001465
NH 0020788
NJ 0003310
OH 0009997
SC 0000515
WI 0000914
WV 0004707
WY 0003115
WY 0032590
CO 0000230
CO 0001121
CO 0042064
KY 0004049
AR 0003018
CT 0000850
OH 0000621
AL 0002666
CO 0042064
IA 0003395
IL 0000141
IL 0003140
LA 0004847
ME 0022861
OH 0009997
OR 0000060
TN 0067199
AK 0000841
AK 0029840
AK 0043192
AK 004*9786
AL 0002666
AL 0002968
AL 0003026
AL 0023272
AR 0000388
AR 0003018
AR 0035823
AR 0036544
CA 0004839
CA 0028797
CA 0048755
CA 0105139
CO 0000230
CO 0001121
CO 0026620
CO 0042064
CT 0000850
CT 0001180
CT 0001601
CT 0003263
GA 0001791
GA 0003620
GA 0003760
GA 0027707
HI 0000191
HI 0000281
HI 0020796
HI 0021148
G-ll
-------
LIST OF PARAMETERS (cont.)
Pnran-.ator Hamo
Permit
Number
Parameter Name
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
IA. 0000132
IA 0003395
IA 3126107
ID 0000825
ID 0001163
ID 0001180
ID 0027154
IL 0000141
IL 0001643
IL 0003140
IL 0004073
IN 0002101
IN 0036447
IN 0038172
IN 0053384
KS 0000434
KS 0000817
KS 0001601
KS 0001635
KY 0004049
LA 0000418
LA 0004847
LA 0007501
LA 0007579
MA 0003557
MA ,0004171
MA 0005011
MA 0005291
ME 0002054
ME 0002321
ME 0022314
ME 0022861
MN 0001422
MN 0001643
MN 0002011
MN 0002186
MN 0038962
MS 0000931
MS 0001783
MS 0035882
MS 0047759
NC 0004952
NC 0005274'
NC 0005479
ND 0023809
ND 0024368
ND 0025038
ND 0025232
NH 0001261
NH 0001465
NH 0020788
NH 0021652
NJ 0003310
NJ 0031895
NJ 0070696
OH 0000621
OH 0002615
OH 0005282
OH 0009997
OK 0041629
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Flow
Fluoranthene
Fluoranthene
Fluoranthene
Fluoranthene
Fluoranthene
Fluoranthene
Fluoranthene
Fluoranthene
Fluoranthene
Fluoranthene
Fluoranthene
Fluoranthene
Fluoranthene
Fluoranthene
Fluoranthene
Fluoranthene
Fluoranthene
Fluorene
Fluorene
Fluorene
Fluorene
Fluorene
OR 0000060
OR 0000141
OR 0000515
OR 0001635 ,
RI 0000043
RI 0021920
RI 0021946
RI 0022021
SC 0000515
SC 0001368
SC 0003441
SC 0003557
SD 0000043
SD 0000281
SD 0025437
TN 0000353
IN 0031631
TN 0067199
IX 0000167
IX 0000949
UT 0000167
VT 0020401
VI 0020702
VI 0020966
WA 0002925
WA 0037265
WI 0000531
WI 0000914
WI 0001341
WI 0051764
WV 0004626
WV 0004707
WV 0005495
WV 0042641
WY 0000442
WY 0001171
WY 0003115
WY 0032590
AL 0003026
AL 0023272
CO 0042064
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
TX 0000949
WI 0000531
WI 0000914
WI 0001341
AL 0003026
AL 0023272
IA 7000102
IL 0000141
IL 0001643
G-12
-------
LIST OF PARAMETERS (cont.)
Parameter Name
Parameter Name
Fluorene IN 0002101
Fluorene LA 0007501
Fluorene MA 0005291
Fluorene NC 0004952
Fluorene NC 0005274
Fluorene SC 0003441
Fluorene SC 0003557
Fluorene IX 0000949
Fluoride CA 0004839
Formaldehyde ID 0027154
Gamma-BHC WI 0000531
Gamma-BHC WI 0000914
Gamma-BHC WI 0001341
Hardness CO 0042064
Hardness KY 0004049
Hardness SD 0000043
Hardness WV 0004626
Heptachlor CO 0042064
Heptachlor WI 0000531
Heptaohlor WI 0000914
Heptaohlor WI 0001341
Heptaohlor epoxide CO 0042064
Hexachlorobenzene AL 0003026
Hexachlorobenzene AL 0023272
Hexachlorobenzene CO 0042064
Hexachlorobenzene IA 7000102
Hexachlorobenzene IL 0000141
Hexachlorobenzene IL 0001643
Hexachlorobenzene IN 0002101
Hexachlorobenzene LA 0007501
Hexachlorobenzene MA 0005291
Hexachlorobenzene NC 0004952
Hexachlorobenzene NC 0005274
Hexachlorobenzene OH 0000621
Hexachlorobenzene SC 0003441
Hexachlorobenzene SC 0003557
Hexachlorobenzene IX 0000949
Hexachlorobenzene WI 0000531
Hexachlorobenzene WI 0000914
Hexachlorobenzene WI 0001341
Hexachlorobutadiene AL 0003026
Hexachlorobutadiene AL 0023272
Hexachlorobutadiene CO 0042064
Hexachlorobutadiene IA 7000102
Hexachlorobutadiene IL 0000141
Hexachlorobutadiene IL 0001643
Hexachlorobutadiene IN 0002101
Hexachlorobutadiene LA 0007501
Hexachlorobutadiene MA 0005291
Hexachlorobutadiene NC 0004952
Hexachlorobutadiene NC 0005274
Hexachlorobutadiene SC 0003441
Hexachlorobutadiene SC 0003557
Hexachlorobutadiene IX 0000949
Hexachlorocyclopentadiene CO 0042064
Hexachloroethane AL 0003026
Hexachloroethane AL 0023272
Hexachloroethane CO 0042064
Hexachloroethane IA 7000102
Hexachloroethane IL 0000141
Hexachloroethane
Hexachloroethane
Hexachloroethane
Hexachloroethane
Hexachloroethane
Hexachloroethane
Hexachloroethane
Hexachloroethane
Hexachloroethane
Hg
Hg
HS
Hg
Hg
Hg (DS)
Hg (X)
Hg (T)
Hg (T)
Hg (T)
Hg (T)
Hg (T)
Hg (I)
Hg (T)
Hg (TR>
Hg
Hydrazine
Hydrazine
Isophorone
Isopropylbiphenyl
Jet fuel
K
Li (T)
Lindane
Malathion ;,
Metals (T)
Metals (T)
Metals (rare earth)
Methoxychlor
Methyl chloride
Methyl chloride
Methyl chloride
Methyl chloride
Methyl chloride
Methyl chloride
Methyl chloride
Methyl chloride
Methyl chloride
Methyl chloride
Methyl chloride
Methyl chloride
Methyl tert butyl ether
Methylene chloride
Methylene chloride
Methylene chloride
Methylene chloride
Methylene chloride
Methylene chloride
Methylene chloride
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
IX 0000949
AK 0043192
GA 0027707
IL 0003140
LA 0007579
SC 0000515
ID 0001163
AL 0003026
CO 0000230
CO 0042064
IA 0003395
LA 0004847
WI 0000531
WI 0000914
WI 0001341
AK 0043192
ID 0001163
OH 0005282
SD 0000043
CT 0003263
SC 0000515
CO 0042064
IN 0053384
CO 0026620
WI 0051764
CO 0042064
CO 0042064
CO 0042064
GA 0027707
ND 0025232
AL 0002666
CO 0042064
AL 0003026
AL 0023272
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0005274
SC 0003441
SC 0003557
TX 0000949
RI 0021946
AL 0003026
AL 0023272
CA 0028797
GA 0027707
IA 7000102
IL 0000141
IL 0001643
G-13
-------
LIST OF PARAMETERS (cont.)
Param«tor Name
Permit
Number
Parameter Name
Permit
Number
Mtthylor.o
Mtthylor.o
Hothylon.
Mothylona
M«thylono
M« thyIon*
Methylano
M«thylono
M«thyl«ne
Hlrex
to
to
to CDS)
to (I)
to (T)
to (T)
to (TR)
Mo
Mo (T)
Mo (TR)
M (I)
H
H (T)
H (T)
HH3
KH3
KH3
NH3
NH3
HH3
HB3
HB3
KH3
HH3
HH3
HH3 (T)
HH3 (T)
KH3 (I)
KH3 (T)
HH3 (T)
1IH3 (I)
NH3 (X)
NH3-N
HH3-N
HH3-H
HH3-M
HH3-H
HH3-H
NH3-H
HH3-M
HH3-N
HH3-H
HH3-H
KH3-H
HH3-H
NH3-N
HH3-H
NH3-N
HH3-H
HH3-H
chloride
chloride
chloride
chloride
chlorido
chloride
chloride
chloride
chloride
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
RI 0022021
SC 0003441
SC 0003557
IX 0000949
CO 0042064
IL 0001643
IL 0003140
CO 0042064
AL 0002666
NB 0020788
OH 0009997
CO 0000230
AL 0002666
CO 0000230
CO 0042064
AL 0002666
HI 0000191
HI 0021148
KS 0001601
CT 0000850
CT 0001180
IN 0036447
OH 0002615
OH 0005282
OH 0009997
SC 0003441
IN 0000353
TN 0067199
WI 0051764
WV 0005495
CO 0001121
CO 0042064
ID 0000825
ID 0027154
MN 0038962
RI 0000043
HA 0037265
AK 0000841
AL 0002666
AL 0002968
AL 0023272
AR 0003018
AR 0036544
CA 0028797
CT 0000850
CT 0003263
HI 0000191
HI 0000281
HI 0021148
IA 3126107
IA 7000102
ID 0001163
IL 0001643
IL 0003140
IL 0004073
NH3-N
NH3-N
NH3-N
NH3-N
HH3-N
NH3-N
NH3-N
NH3-N
NH3-N
NH3-N
NH3-N
NH3-N
NH3-N
NH3-N
NH3-N
NH3-N
NH3-N
NH3-N
NH3-N
NH3-N
NH3-N
NH3-N
N02
N02
N02
N02-N
N02-N
N03
N03
N03
N03
N03
N03
N03
N03-N
NO3-N
N03-N
N03-N
Na
Naphthalene
Naphthalene
Naphthalene
Naphthalene
Naphthalene
Naphthalene
Naphthalene
Naphthalene
Naphthalene
Naphthalene
Naphthalene
Naphthalene
Naphthalene
Naphthalene
Naphthalene
Naphthalene
Ni
Ni
Ni
Ni
Ni
KS 0000434
KS 0000817
KS 0001601
LA 0000418
MA 0004171
MA 0005291
MS 0001783
MS 0035882
NC 0005479
ND 0024368
OK 0041629
OR 0001635
RI 0021920
SC 0003557
SD 0000043
TN 0067199
IX 0000949
VI 0020966
WI 0001341
WV 0004626
WV 0005495
WY 0000442
CO 0042064
OH 0000621
WV 0005495
CT 0000850
OH 0002615
CO 0042064
ID 0027154
KS 0001601
OH 0002615
SC 0000515
VT 0020702
WV 0005495
CT 0000850
LA 0000418
OH 0002615
OR 0001635
NC 0005274
AL 0003026
AL 0023272
CO 0042064
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
OH 0009997
SC 0003441
SC 0003557
SD 0000281
TX 0000949
CA 0004839
CA 0028797
CT 0001180
CT 0001601
6A 0027707
G-14
-------
LIST OF PARAMETERS (cont.)
Parameter Name
Ni
Ni
Ni
Ni
Ni
Ni (DS)
Ni (DS)
Ni (T)
Ni (T)
Ni (T)
Ni (T)
Ni (T)
Ni (T)
Ni (T)
Ni (T)
Ni (T)
Ni (T)
Ni (T)
Ni (I)
Ni (T)
Ni (T)
Ni (T)
Ni (T)
Ni (T)
Ni (TR)
Ni (TR)
Ni (TR)
Ni (TR)
Ni (TR)
Ni (TR)
Nitro-n-methyl phthalimide
Ni fcr ob enz ene
Nitrobenzene
Nitrobenzene
Nitrobenzene
Nitrobenzene
Nitrobenzene
Nitrobenzene
Nitrobenzene
Nitrobenzene
Nitrobenzene
Nitrobenzene
Nitrobenzene
Nitrobenzene
Nitrobenzene
Nitrobenzene
Nonfilterable residue (T)
••Nonfilterable residue (T)
Nonfilterable residue (T)
Nonfilterable residue (T)
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
Permit
Number
OR 0000060
TN 0000353
VT 0000272
VT 0020401
WA 0037265
CO 0000230
CO 0042064
AL 0003026
AL 0023272
AR 0000388
CT 0000850
IA 0003395
IA 3126107
IA 7000102
IL 0000141
IL 0001643
IN 0002101
. LA 0004847
MA 0005291
ME 0022861
MS 0000931
NC 0004952
NC 0005274
OH 0009997
AK 0043192
AL 0002666
AL 0023272
KY 0004049
OH 0005282
SD 0000043
IN 0002101
AL 0003026
AL 0023272
CO 0042064
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
TX 0000949
WI 0000531
OH 0000621
OH 0002615
OH 0005282
OH 0009997
AK 0000841
AK 0049786
AL 0023272
AR 0000388
AR 0003018
AR 0035823
AR 0036544
CA 0004839
CO 0000230
CO 0001121
Parameter Name
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
O&G
Permit
Number
CO 0026620
CO 0042064
CT 0000850
CT 0001601
CT 0003263
GA 0027707
IA 0000132
IA 0003395
IA 3126107
IL 0000141
IL 0003140
IL 0004073
IN 0038172
IN 0053384
KS 0000434
KS 0000817
KY 0004049
LA 0004847
LA 0007579
MA 0003557
MA 0004171
ME 0022314
ME 0022861
MN 0002011
MN 0038962
MS 0001783
MS 0035882
NC 0004952
ND 0023809
ND 0025038
ND 0025232
NH 0001465
NH 0020788
NH 0021652
OH 0000621
OH 0002615
OH 0005282
OH 0009997
OK 0041629
OR 0000060
OR 0001635
RI 0021920
SC 0000515
SC 0001368
SC 0003441
SC 0003557
SD 0000043
SD 0000281
SD 0025437
TN 0031631
TN 0067199
UT 0000167
VT 0020401
WA 0002925
WI 0000914
WV 0004626
WV 0004707
WV 0005495
WV 0042641
WY 0000442
G-15
-------
LIST OF PARAMETERS (cont.)
Parameter Same
Permit
Number
Parameter Name
Permit
Number
osa
O&G
Organic-N
Organic-N
Organic-K
Organic-H
Othar
Other
Othar
Othar
Othar
Othar
Other
Other
Other
Othar
Other
Other
Othar
Other
Other
Other
Othar
Other
Othar
Other
Other
Other
Other
Othar
Other
Other
Other
(T)
CT)
(T)
(T)
(T)
(T)
(T)
P (T)
P (T)
P (T)
P (T)
P (T)
P
P (T)
(T)
(I)
(I)
(T)
(T)
(T)
(T)
(T)
(T)
P (T)
P (T)
P (T)
P (T)
P
P
P
P
P
P
P
P
P
WY 0001171
WY 0003115
CI 0000850
LA 0000418
OH 0002615
OR 0001635
AL 0003026
AL 0023272
CA 0004839
CA 0028797
CA 0105139
CT 0001180
IA 0000132
IA 7000102
IL 0000141
KS 0000434
KY 0004049
MA 0005291
MN 0002186
NC 0005274
KG 0005479
ND 0024368
NJ 0003310
NJ 0031895
NJ 0070696
OH 0005282
RI 0000043
RI 0021946
RI 0022021
VI 0020702
HA 0002925
HI 0000531
HI 0000914
AL 0002666
CO 0001121
CT 0000850
HI 0000191
HI 0000281
ID 0000825
ID 0001163
ID 0027154
KY 0004049
LA 0004847
MA 0004171
ME 0022861
MN 0001422
MN 0001643
MS 0000931
NC 0004952
NC 0005274
NC 0005479
ND 0025232
NH 0001261
OH 0000621
OH 0002615
OR 0000515
RI 0000043
VI 0020401
VT 0020702
VI 0020966
P (T)
P (T)
P (T)
P (T)
PAHs
PAHs
PAHs
PAHs
PAHs
FAHs
FCBs (T)
PCBs (T)
PCBs (T)
ECBs (T)
PCBs (T)
FCBs (T)
ECBs (T)
ECBs (T)
ECBs (T)
ECBs (T)
FCBs (T)
Farachlorometacresol
Parathion
Pb
Fb
Fb
Eb
Pb
Pb
Eb
Pb
Fb
Pb
Eb
Fb
Pb (DS)
Eb (DS)
Fb (DS)
Pb (T)
Fb (T)
Pb (T)
Fb (T)
Pb (T)
Pb (T)
Fb (T)
Pb (T)
Pb (T)
Pb (T)
Pb (T)
Pb (T)
Pb (T)
Fb (T)
Eb (T)
Fb (T)
Pb (T)
Pb (T)
Fb (T)
Pb (T)
Pb (T)
Eb (T)
HI 0000531
WI 0001341
HI 0051764
WV 0005495
AK 0000841
AL 0023272
IL 0004073
ME 0022314
NC 0005274
OH 0009997
CO 0042064
IA 0003395
IN 0053384
KY 0004049
OK 0041629
RI 0022021
SD 0025437
TN 0067199
WI 0000531
WI 0000914
WI 0001341
CO 0042064
CO 0042064
CA 0004839
CA 0028797
CA 0105139
CT 0001180
CT 0001601
GA 0027707
SC 0000515
TN 0000353
TN 0067199
VI 0020401
HA 0037265
WV 0042641
CO 0000230
CO 0042064
ID 0001163
AL 0003026
AL 0023272
AR 0000388
CO 0000230
CT 0000850
CT 0003263
IA 0003395
IA 3126107
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0004847
MA 0005291
ME 0022861
MS 0000931
NC 0004952
NC 0005274
OH 0000621
OH 0009997
RI 0000043
SC 0001368
G-16
-------
LIST OF PARAMETERS (cont.)
Parameter Name
Permit
Number
Parameter Name .;
Permit
Number
Pb (TR)
Pb (TR)
Pb (TR)
Pb (TR)
Pb (TR)
Pb (TR)
Pb (TR)
Pb (TR)
Pb (TR)
Pd (T)
Penfcachlorobenzene
Pentachlorobenzene
Pentaohlorobenzene
Pentaohlorobenzene
Pentachlorophenol
Pentachlorophenol
Pentachlorophenol
Phenanthrene
Phenanthrene
Phenanthrene
Phenanthrene
Phenanthrene
Phenanthrene
Phenanthrene
Phenanthrene
Phenanthrene
Phenanthrene
Phenanthrene
Phenanthrene
Phenanthrene
Phenol
Phenol
Phenol
Phenol
Phenol
Phenol
Phenol
Phenol
Phenol
Phenol
Phenol
Phenol
Phenol
Phenol
Phenol
Phenol
Phenols
Phenols
Phenols
Phenols
Phenols
Phenols
Phenols
Phenols
Phenols
Phenols
Phenols
Phenols
Phenols
Phenols
AK 0043192
AL 0002968
AL 0003026
AL 0023272
ID 0001163
IN 0038172
KY 0004049
OH 0005282
SD 0000043
AL 0002666
CO 0042064
WI 0000531
HI 0000914
WI 0001341
CO 0042064
WI 0000531
WY 0032590
AL 0003026
AL 0023272
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
TX 0000949
AL 0002968
AL 0003026
AL 0023272
CO 0042064
GA 0027707
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
IX 0000949
AK 0000841
AL 0002968
AR 0036544
GA 0001791
GA 0003760
IA 0003395
IL 0004073
IN 0002101
KS 0000434
LA 0007501
MN 0001643
MS 0047759
NC 0005274
OH 0009997
Phenols
Phenols
Phenols
Phenols
Phenols
Phenols
Priority pollutants
Priority pollutants
Priority pollutants
Propylene glycol
Pt
Pt (T)
Pyrene
Pyrene
Pyrene
Pyrene
Pyrene
Pyrene
Pyrene
Pyrene
Pyrene
Pyrene •
Pyrene
Pyrene
Pyrene
Radium (226)
Radium (226)
Radium (T)
Radium (T)
S
s
S
SOS
SOS
SO4
S04
SO4
SO4
SO4
S04
S04
S04
S04
S04
SS
ss
SS
ss .
ss
ss
ss
ss
ss
ss
ss
ss
Salinity
Sb
Sb (T)
Sb (T)
RI 0000043
SC 0001368
SC 0003441
WV 0004626
WY 0000442
WY 0032590
LA 0007579
RI 0000043
WV 0004626
CO 0026620
AL 0002666
AL 0002666
AL 0003026
AL 0023272
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
TX 0000949
LA 0004847
WY 0001171
CO 0000230
CO 0042064
AL 0002666
IL 0004073
SC 0001368
IL 0000141
KS 0000434
AL 0002666
AL 0003026
AR 0000388
AR 0003018
CO 0000230
CO 0042064
IN 0038172
LA 0004847
WV 0004626
WV 0005495
AK 0043192
CA 0004839
CA 0048755
HI 0000191
HI 0020796
IA 7000102
ID 0000825
ID 0027154
ND 0025038
OR 0001635
TN 0004677
VT 0020702
HI 0021148
OR 0000060
LA 0004847
RI 0000043
G-17
-------
LIST OF PARAMETERS (cont.)
Parair.ater Hame
Permit
Number
Parameter Name
Permit
Number
Sb (TR)
Se
Se
Se
Se (T)
Sa (I)
Sa (I)
Sa (I)
Sn
Sn
Sodium Nitrite
Specific conductance
Specific conductance
Specific conductance
Sul£ido
Sulfide
Sulfide
Sulfida
Sulfido
Sulfida
Sulfide
Sulfide
Sulfida
Surfactants
Surfactants
Surfactants
Surfactants
TDS
IDS
TDS
IDS
IDS
IDS
IDS
TDS
IDS
IDS
TDS
IDS
IDS
IDS
IDS
IDS
IDS
IDS
TDS
TKH
TKH
TKH
TKH
TKN
TKH
TKN
TK«
TKH
TOC
IOC
TOC
TOC
TOC
CO 0042064
CA 0004839
ID 0001163
SC 0000515
AR 0000388
CO 0042064
IA 0003395
LA 0004847
CA 0004839
CT 0001180
MA 0003557
CT 0003263
SC 0000515
WY 0001171
AK 0000841
AL 0002968
GA 0001791
GA 0003760
MS 0047759
RI 0000043
WV 0004626
WV 0005495
WY 0000442
CT 0000850
CT 0003263
RI 0000043
SD 0000281
AL 0002666
AL 0003026
AL 0023272
AR 0003018
CA 0004839
CA 0028797
CA 0105139
CO 0042064
CT 0000850
IL 0000141
IL 0004073
IN 0002101
MN 0002186
MS 0047759
ND 0025232
UT 0000167
VI 0020401
WI 0001341
WY 0032590
CO 0042064
ID 0000825
LA 0007501
NC 0005479
ND 0025232
VT 0020702
WI 0051764
WV 0005495
WV 0042641
AL 0023272
AR 0035823
AR 0036544
CO 0042064
HI 0021148
TOC
TOC
TOC
TOC
TOC
TOC
TOC
TOC
TOC
TOC
TOC
TOC
TOC
TOC
TOC
TON
TON
TON
TON
TON
TON-N
TON-N
TON-N
TPH
TPH
TPH
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
IL 0001643
IL 0004073
IN 0002101
KS 0000434
LA 0000418
NJ 0003310
OK 0041629
RI 0000043
SC 0000515
SC 0003441
TX 0000949
WV 0004626
WV 0004707
WV 0005495
WY 0000442
ID 0000825
KS 0001601
NC 0004952
NC 0005274
ND 0025232
HI 0000191
HI 0000281
HI 0021148
AK 0000841
CA 0028797
WY 0032590
AK 0029840
AK 0049786
AL 0023272
AR 0000388
AR 0003018
CA 0004839
CO 0000230
CO 0001121
CT 0000850
CT 0001180
CT 0003263
IA 0000132
IA 3126107
IA 7000102
ID 0027154
IN 0002101
KS 0000817
KY 0004049
LA 0007579
MN 0001422
MN 0002011
MN 0038962
MS 0001783
MS 0035882
MS 0047759
NC 0004952
NC 0005274
NC 0005479
ND 0025232
OH 0000621
OH 0005282
OR 0000060
OR 0000141
SC 0000515
G-18
-------
LIST OF PARAMETERS (cont.)
Parameter Name
Permit
Number
ParamQtar Nams
TRC
IRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TRC
TROs
TROs
TROs
TROs
TROs
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
SC 0001368
SC 0003441
SC 0003557
TN 0000353
TN 0067199
VI 0020401
WA 0037265
WI 0000531
WI 0000914
WV 0004626
WV 0004707
WV 0005495
IA 0000132
MA 0003557
MN 0002186
NH 0001465
WY 0003115
AK 0000841
AK 0029840
AK 0043192
AK 0049786
AL 0002666
AL 0002968
AL 0003026
AL 0023272
AR 0000388
AR 0003018
AR 0035823
AR 0036544
CA 0004839
CA 0048755
CO 0000230
CO 0001121
CO 0026620
CO 0042064
CT 0000850
CT 0001180
CT 0001601
CT 0003263
GA 0001791
GA 0003620
GA 0003760
GA 0027707
HI 0000191
HI 0000281
HI 0020796
IA 0000132
IA 0003395
IA 3126107
IA 7000102
ID 0000825
ID 0001163
ID 0001180
IL 0000141
IL 0001643
IL 0003140
IL 0004073
IN 0002101
IN 0036447
IN 0038172
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
• TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
KS 0000434
KS 0000817
KS 0001601
KS 0001635
KY 0004049
LA 0000418
LA 0004847
LA 0007501
LA 0007579
MA 0003557
MA 0004171
MA 0005011
MA 0005291
ME 0002054
ME 0002321
ME 0022314
ME 0022861
MN 0001422
MN 0001643
MN 0002011
MN 0002186
MN 0038962
MS 0000931
MS 0001783
MS 0035882
MS 0047759
NC 0004952
NC 0005274
NC 0005479
ND 0023809
ND 0024368
ND 0025038
ND 0025232
NH 0001261
NH 0001465
NH 0020788
NH 0021652
NJ 0003310
NJ 0031895
NJ 0070696
OH 0005282
OK 0041629
OR 0000060
OR 0000141
OR 0000515
RI 0000043
RI 0021920
SC 0000515
SC 0001368
SC 0003441
SC 0003557
SD 0000043
SD 0000281
SD 0025437
TN 0004677
TN 0031631
TN 0067199
TX 0000167
IX 0000949
UT 0000167
G-19
-------
LIST OF PARAMETERS (ccmt.)
Parameter Kama
Permit
Number
Parameter Name
Permit
Number
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
TSS
ISS
TSS
TSS
TSS
TSS
IIOs
ITOm
TTO«
TTO«
TIO«
TTOs
TTOs
ITOa
Temp.
Temp.
Temp.
Temp.
Torop.
Temp.
Temp.
Temp.
Temp.
Tamp.
Temp.
Temp.
Temp.
Temp.
Tump.
Temp.
Tamp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
VI 0000272
VT 0020401
VI 0020702
VT 0020966
WA 0002925
WA 0037265
HI 0000531
HI 0000914
HI 0001341
HI 0051764
HV 0004626
HV 0004707
HV 0005495
HV 0042641
HY 0000442
HY 0003115
CT 0001180
GA 0027707
IA 3126107
ME 0022861
MS 0000931
OH 0000621
OH 0009997
IN 0000353
VT 0000272
AK 0029840
AK 0043192
AL 0002968
AL 0023272
AR 0000388
CA 0004839
CA 0028797
CA 0105139
CO 0001121
CT 0000850
CT 0001180
CT 0001601
CT 0003263
HI 0000191
HI 0000281
IA 0000132
IA 0003395
IA 3126107
ID 0001163
IL 0003140
IL 0004073
IK 0002101
KS 0000817
KS 0001635
KY 0004049
LA 0000418
LA 0004847
LA 0007501
LA 0007579
MA 0003557
MA 0005291
ME 0002054
ME 0002321
ME 0022861
MN 0001422
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Temp.
Tetrachloroethylene
Tetrachloroethylene
Tetrachloroethylene
Tetraohloroethylene
Tetraohloroethylene
Tetrachloroethylene
Tetraohloroethylene
Tetraohloroethylene
Tetraohloroethylene
Tetraohloroethylene
Tetraohloroethylene
Tetrachloroethylene
Tetraohloroethylene
Tetrachloroethylene
Tetraohloroethylene
Tetrachloroethylene
Tetraohloroethylene
Tetrahydrofuran
Thiooarbamates
Tl (T)
II (T)
Tl (T)
Tl (TR)
Tl (TR)
Toluene
Toluene
Toluene
Toluene
Toluene
Toluene
Toluene
MN 0002011
MN 0002186
MN 0038962
MS 0035882
NC 0004952
NC 0005274
NC 0005479
ND 0024368
ND 0025232
NH 0021652
NJ 0070696
OH 0000621
OH 0005282
OR 0000141
OR 0000515
OR 0001635
SC 0000515
SC 0003557
SD 0000043
TN 0000353
VT 0020401
WA 0037265
HI 0000531
WI 0000914
HI 0001341
HI 0051764
HV 0004707
HV 0005495
HY 0000442
AL 0003026
AL 0023272
CO 0042064
IA 0003395
IL 0000141
IL 0001643
IN 0002101
IN 0053384
LA 0007501
MA 0005291
NC 0004952
NC 0005274
OH 0009997
RI 0022021
SC 0003441
SC 0003557
TX 0000949
IN 0002101
AL 0003026
AR 0000388
LA 0004847
OH 0002615
CO 0042064
OH 0005282
AL 0003026
AL 0023272
CA 0105139
CO 0042064
GA 0027707
IA 7000102
IL 0000141
G-20
-------
Parameter Name
LIST OF PARAMETERS (cont.)
Permit
Number
Parameter Name
Permit
Number
Toluene
Toluene
Toluene
Toluene
Toluene
Toluene
Toluene
Toluene
Toluene
Toluene
Toluene
Toluene
Toxaphene
Toxaphene
Toxaphene
Toxaphene
Trichloroethylene
Trichloroethylene
Trichloroethylene
Trichloroethylene
Trichloroethylene
Trichloroethylene
Trichloroethylene
Trichloroethylene
Trichloroethylene
Trichloroethylene
Trichloroethylene
Trichloroethylene
Trichloroethylene
Trichloroethylene
Trichloroethylene
Trichloroethylene
Trichloroethylene
Trichloroethylene
Trichloroethylene
Trichloroethylene
Trihalomethanes (I)
Turbidity
Turbidity
Turbidity
Turbidity
Turbidity
Turbidity
U (DS)
U (T)
U (T)
U CT)
Urea
V (T)
V (TR)
VOCs (T)
Vinyl chloride
Vinyl chloride
Vinyl chloride
Vinyl chloride
Vinyl chloride
Vinyl chloride
Vinyl chloride
Vinyl chloride
Vinyl chloride
IL 0001643
IL 0004073
IN 0002101
LA 0007501
MA 0005291
ME 0022314
NC 0004952
NC 0005274
HI 0021946
SC 0003441
SC 0003557
TX 0000949
CO 0042064
WI 0000531
WI 0000914
WI 0001341
AL 0003026
AL 0023272
CA 0028797
CO 0026620
CO 0042064
GA 0003760
GA 0027707
IA 7000102
IL 0000141
IL 0001643
IN 0002101
IN 0053384
KY 0004049
LA 0007501
MA 0005291
NC 0004952
NC 0005274
SC 0003441
SC 0003557
TX 0000949
CO 0042064
HI 0020796
HI 0021148
ID 0001163
OH 0005282
OR 0000515
VI 0020401
CO 0000230.
CO 0042064
KY 0004049
LA 0004847
OH 0002615
AL 0002666
CO 0042064
CA 0028797
AL 0003026
AL 0023272
CA 0028797
CO 0042064
IA 7000102
IL 0000141
IL 0001643
IN 0002101
LA 0007501
Vinyl chloride
Vinyl chloride
Vinyl chloride
Vinyl chloride
Vinyl chloride
Vinyl chloride
Vinyl chloride
W (T)
Xylenes
Xylenes
Xylenes
Zn
Zn
Zn
Zn
Zn
Zn
Zn
Zn
Zn
Zn
Zn
Zn
Zn
Zn
Zn
Zn
Zn (DS)
Zn (DS)
Zn (T)
Zn (T)
Zn (T)
Zn (T)
Zn (T)
Zn (T)
Zn (T)
Zn (T)
Zn (T)
Zn (T)
Zn (T)
Zn (T)
Zn (T)
Zn (T)
Zn (T)
Zn (T)
Zn (T)
Zn (T)
Zn (T)
Zn (T)
Zn (T)
Zn (T)
Zn (T)
Zn (T)
Zn (T)
Zn (T)
Zn (TR)
Zn (TR)
Zn (TR)
Zn (TR)
Zn (TR)
MA 0005291
NC 0004952
NC 0005274
RI 0022021
SC 0003441
SC 0003557
TX 0000949
AL 0002666
CA 0028797
CA 0105139
ME 0022314
CA 0028797
CT 0000850
CT 0001180
CT 0001601
GA 0001791
GA 0003760
GA 0027707
LA 0000418
LA 0007579
SC 0000515
SC 0001368
SC 0003441
TN 0000353
TN 0067199
VI 0000272
VI 0020401
CO 0000230
ID 0001163
AL 0003026
AL 0023272
AR 0000388
CO 0000230
CO 0001121
CT 0003263
IA 0003395
IA 3126107
IA 7000102
IL 0000141
IL 0001643
LA 0004847
LA 0007501
MA 0005291
ME 0022861
MS 0000931
NC 0004952
NC 0005274
NH 0020788
OH 0000621
OH 0009997
RI 0000043
SC 0003441
TX 0000949
WV 0004626
WY 0032590
AL 0002666
AL 0002968
AL 0003026
AL 0023272
CO 0042064
G-21
-------
LIST OF PARAMETERS (cont.)
Pornm»t»c Name
Permit
Number
Parameter Name
Permit
Number
Zn CTR)
Zn (TR)
Zn (TR)
Zn (TR)
Zn (TR)
Zn (TR)
Zn (TR)
Zn (TR)
asbistos
P8
pB
pH
pH
pH
pH
pB
pH
pH
PH
pH
pH
pH
pH
pH
p3
pa
pa
Pa
pa
pa
pa
pa
Pa
Pa
pa
pa
pa
Pa
PH
pH
PB
pa
pa
Pa
pa
pH
Pa
PH
pa
pa
pa
Pa
pa
pa
pH
pH
pH
pH
pH
pa
(fibrous)
ID 0001163
IN 0002101
IN 0038172
IN 0053384
KY 0004049
NH 0021652
OH 0005282
SO 0000043
SC 0000515
AK 0000841
AK 0029840
AK 0049786
AL 0002666
AL 0002968
AL 0003026
AL 0023272
AR 0000388
AR 0003018
AR 0035823
AR 0036544
CA 0004839
CA 0028797
CA 0105139
CO 0000230
CO 0001121
CO 0026620
CO 0042064
CT 0000850
CT 0001180
CT 0001601
CT 0003263
GA 0001791
GA 0003620
GA 0003760
GA 0027707
HI 0000191
HI 0000281
HI 0020796
HI 0021148
IA 0000132
IA 0003395
IA 3126107
IA 7000102
ID 0001163
ID 0001180
ID 0027154
IL 000014,1
IL 0001643
IL 0003140
IL 0004073
IN 0002101
IN 0036447
IN 0038172
IN 0053384
KS 0000434
KS 0000817
KS 0001601
KS 0001635
KY 0004049
LA 0004847
PH
pH
pH
pH
pH
PH
pH
pH
PH
pH
PH
PH
PH
PH
PH
pH
pH
pH
pH
pH
PH
pH
pH
pH
PH
pH
PH
pH
pH
pH
pH
PH
pH
pH
PH
pH
pH
PH
pH
pH
pH
pH
PH
pH
pH
PH
pH
pH
pH
PH
pH
PH
pH
pH
PH
pH
pH
pH
pH
pH
LA 0007501
LA 0007579
MA 0003557
MA 0004171
MA 0005011
MA 0005291
ME 0002054
ME 0002321
ME 0022314
ME 0022861
MN 0001422
MN 0001643
MN 0002011
MN 0002186
MN 0038962
MS 0000931
MS 0001783
MS 0035882
MS 0047759
NC 0004952
NC 0005274
NC 0005479
ND 0023809
ND 0024368
ND 0025038
ND 0025232
NH 0001261
NH 0001465
NH 0020788
NH 0021652
NJ 0003310
NJ 0031895
NJ 0070696
OH 0000621
OH 0002615
OH 0005282
OH 0009997
OK 0041629
OR 0000060
OR 0000141
OR 0000515
OR 0001635
RI 0000043
RI 0021920
RI 0021946
RI 0022021
SC 0000515
SC 0001368
SC 0003441
SC 0003557
SD 0000043
SD 0000281
SD 0025437
TN 0000353
TN 0004677
TN 0067199
TX 0000167
TX 0000949
UT 0000167
VI 0000272
G-22
-------
LIST OF PARAMETERS (cont.)
Permit Permit
Parameter Name Number Parameter Name Number
pH VT 0020401
pH VT 0020702
pH VT 0020966
pH WA 0002925
pH WA 0037265
pH WI 0000531
pH WI 0000914
pH WI 0001341 '
pH WI 0051764
pH WV 0004626
pH WV 0004707
pH WV 0005495
pH WV 0042641
pH WY 0000442
pH WY 0001171
pH WY 0003115
pH WY 0032590
G-23
-------
-------
APPENDIX H
RECEIVING WATER INDEX
-------
-------
Receiving Stream
LIST OF RECEIVING STREAMS
Permit
Number
Aeia Stream
Altamaha River
Ann Moore Run
Arkansas River
Arrowhead Mtn Lake via wells
Assumpink Greek
Back River
Bakers Slough
Balus Creek
Beaver Creek
Beulah Trench Creek
Big Bayou Creek
Black River
Blackstone River
Boquist Slough
Borrow Pit
Broad River
Brushy Creek
Buffalo Creek
Calabazas Creek
Canal 81
Cape Cod Bay
Captains Bay
Cedar River
Chickasaw Creek via Canal
City storm water system
Columbia River
Columbia River
Connecticut River
Contoocook River
Cook Inlet
Cooper River
Cottonwood River
Crow Creek
Cub River
Cypress Creek
Deer River via barge canal
Deer via canal
Des Plaines River
Dick's Creek
Discharge Channel 2 to Sabine
Ditch 2 mi. from Pacific Ocean
Ditch to Bayou des Acadiens
Ditch to Russell Branch
Ditch to Tygart Valley River
Dry Wash/Coyote Wash/White R.
HI 0000281
GA 0003620
WV 0004707
OK 0041629
VT 0020702
NJ 0031895
SC 0003441
TX 0000167
GA 0001791
CO 0042064
ND 0025038
KY 0004049
VT 0000272
RI 0022021
OR 0000141
AR 0035823
SC 0001368
LA 0007501
NC 0004952
CA 0028797
AR 0035823
MA 0003557
AK 0049786
IA 0000132
AL 0002666
OR 0000515
OR 0000060
OR 0001635
MA 0005011
NH 0021652
AK 0000841
SC 0003441
KS 0000817
WY 0000442
ID 0001180
TN 0000353
AL 0023272
AL 0023272
IL 0001643
OH 0009997
TX 0000949
HI 0021148
LA 0004847
TN 0067199
WV 0042641
UT 0000167
H-l
-------
ReceivinE Stream
LIST OE RECEIVING STREAMS (cont.)
Permit
Number
-------
LIST OF RECEIVING STREAMS (Cont.)
Receiving Stream
Missouri R via White Clay Crk.
Mobile River
Naugatuck River
Naugatuk R. via storm sewer
Neosho R./Cottonwood R./F°x Cr
Nickajack Reservoir
None
North Branch of Dicks Creek
North Platte River
Northeast Utilities Power Cana
Norton Sound
Oconee River
Oconto River
Ohio River
Ohio River
Ohio River
Opossum Fork Creek
Ottawa River
Otter Tail River
Ouachita River
Pacific Ocean
Paradise Creek
Pepperell Branch
Point Judith Pond
Potomac River
Prudhoe Bay
Quarry Cut
Red River
Redwine Creek
Ridge and furrow system
Riley Creek
S. Fork Catawba River
S.Fork of S.Branch of PotomacR
Sabine River
Saluda River
San Joaquin River
Sand Creek
Sheyenne River
Snake River
South Platte River
St Vrain Creek
St. of Juan de Fuca/Port Angel
Sugar River
Tate Spring Branch
Taunton R./Muddy Cove Brook
Taunton R./Muddy Cove Creek
Permit
.Number
KS 0001635
AL 0003026
CT 0001180
CT 0001601
KS 0000817
TN 0031631
WV 0042641
OH 0009997
WY; 0003115
MA '0005011
AK 0043192
GA 0003760
WI 0000531
IN 0002101
OH 0005282
WV 0004626
AR 0035823
OH 0002615
MN 0002011
LA 0007579
HI 0000191
ID 0027154
AL 0002968
RI 0021920
BM 4444444
AK 0029840
CT 0003263
ND 0024368
GA 0001791
WI 0051764
ID 0000825
NC 0005274
WV 0005495
TX 0000949
SC 0003557
CA 0004839
CO 0026620
ND 0023809
ID 0001163
CO 0001121
CO 0001121
WA 0002925
NH 0001261
TN 0004677
MA 0005291
MA 0005291
H-3
-------
LIST OF RECEIVING STREAMS (cont.)
Receiving Stream
Travis Ditch
Tributary to Garter Branch
Tributary to Cold Creek
Two tributaries to Stout Creek
Tyronza River
Unamed trib. to Box Elder
Unnamed ditch to Long Lake
Unnamed ditch to Ouachita Rive
Unnamed ditch to sinkhole
to Ann Moore Run
to Arkansas R.
to Bachelor Cr.
to Broad River
to Congo Run
to Rolling Fork
to Sugar Creek
to Town Creek
to Sevenmile Cr
Unnamed tributary-Box Elder Cr
Wabash River
Walnut River
Wetland Trib. to Crookfall Br.
Williams Fork River
Wilson River
Winooski River
Wolf River
Land spreading near Duck Creek
Unnamed trib.
Unnamed trib.
Unnamed trib.
Unnamed trib.
Unnamed trib.
Unnamed trib.
Unnamed trib.
Unnamed trib.
Unnamed tribs
Permit
Number
IN 0038172
AL 0003026
AL 0003026
IN 0053384
AR 0036544
SD 0000281
AR 0000388
LA 0007579
IN 0053384
WV 0004707
OK 0041629
SD 0025437
SC 0001368
WV 0004626
AR 0003018
IL 0004073
MS 0001783
MS 0035882
SD 0000281
IN 0036447
KS 0000434
RI 0021946
CO 0000230
OR 0000141
VT 0020401
WI 0001341
WI 0051764
H-4
-------
APPENDIX I
INDUSTRY TYPE (SIC CODE) INDEX
-------
-------
FACILITY TYPES (SIC CODE) AND NAMES
SIC
Code Industry Category
Facility Name
John Deere Dubuque Works
DOI, FWS Hagerraan Nat' 1 Fish.
Erwin National Fish Hatchery
VT Dept. of Fish and Wildlife
Homestake Mining Company
Western Gold Exploration & Kin
Climax Molybdenum Co.Henderson
Coteau Properties Co - Beulah
1311 Crude Oil & Nat Gas Ext Union Oil Company
1311 Crude Oil & Nat Gas Ext ARCO Alaska, Inc.- Prudhoe Bay
1411 Dimension Stone Extract Granite Construction Co-Felt.on
1442 Construct Sand & Gravel Gutzmer Construction - Lisbon
1492 Gypsum Extraction Ameron HC&D, LTD, Kappa Quarry
1499 Nonmetallic Minerals Ex American Gilsonite Company
Not provided
0921 Fish Hatcheries
0921 Fish Hatcheries
0921 Fish Hatcheries
1041 Gold Mining
1041 Gold Mining
1061 Ferroalloy Ore Mining
1221 Coal Mining
2011 Meat Packing Plant
2013 Sausages & Other Meat
2017 Poultry & Egg Process
2019 Food Processing
2022 Cheese, Natural & Proc
2023 Milk, Condensed & Evap
2026 Milk, Fluid
IBP, Inc.
Bryan Foods, Inc.
Tyson Foods, Grannis
Wampler-Longacre Chicken, Inc.
Grande Cheese Company
VT Whey Company
Tillamook County Creamery Assn
2032 Canned Specialties Food Del Monte Corp., Franklin, ::D
2061 Sugar, Raw Cane Hilo Coast Processing Company
2062 Sugar Refining, Cane California & Hawaiian Sugar Co
2063 Sugar, Beet Minn-Dak Farmers Cooperative
2085 Distilld & Blend Liquor Midwest Grain Products, Inc.,
2092 Fish, Fresh or Frozen Northeast Atlantic Seafood Ltd
2092 Fish, Fresh or Frozen Westward Seafoods, Inc., Dutch
2099 Food Preparations, nee FIDCO, Inc.
2221 Weaving Mills, Syntheti Forstmann & Company
2254 Knit Underwear Mills Greenville Manufacturing, Inc.
2262 Finishing Plant, Synthe West Point Pepperell Opelika
2269 Textile Finishing Plant Bradford Dyeing Assoc., Inc.
2269 Textile Finishing Plant Cone Mills Corp., Carlisle
2269 Textile Finishing Plant Worcester Spinning & Finishing
2271 Carpets, Rugs, Woven Fieldcrest Cannon, Inc.
2297 Fabrics, Nonwoven Kimberly-Clark, Corinth Mills
4931 Electric & Other Servic DOE-Paducah Gaseous Diffusion
2491 Wood Preserving
2611 Pulp Mills, Paper
2611 Pulp Mills, Paper
2611 Pulp Mills, Paper
2611 Pulp Mills, Paper
2611 Pulp Mills, Paper
2611 Pulp Mills, Paper
2611 Pulp Mills, Paper
2621 Paper Mills, Exc Bldng
2621 Paper Mills, Exc Bldng
2631 Paperboard Mills
Union Pacific RR, Laramie Tie
International Paper Company
Potlack Corporation
Potlatch Corp, Lewiston Fac.
Weyerhaeuser Company
ITT Rayonier, Inc
Scott Paper Co at Oconto Falls
Daishowa America Co. - Pott An
Coy Paper Company, Inc.
Potlatch Corp.
Muskogee Linerboard Mill
Inland Container Corporation
2631 Paperboard Mills
2647 Sanitary Paper Products Shawano Paper Mills
2679 Paper Products Strathmore Paper Company
2812 Alkalies, Chlorine Prod Occidental Chemical Corp.
2819 Industrial Inorg Chem UOP - Molecular Sieve Plant
2819 Industrial Inorg Chem Degussa Corporation, AL Group
Permit
Number
IA 3126107
ID 0000825
TN 0004677
VT 0020966
SD 0000043
AK 0043192
CO 0000230
ND 0025038
WY 0001171
AK 0029840
CA 0048755
ND 0023809
HI 0020796
UT 0000167
KS 0000817
MS 0001783
AR 0003018
WV 0005495
WI 0051764
VT 0020702
OR 0000141
ID 0001180
HI 0000191
HI 0000281
ND 0024368
KS 0001635
RI 0021920
AK 0049786
CT 0000850
GA 0003760
MS 0047759
AL 0002968
RI 0000043
SC 0001368
MA 0004171
NC 0005479
MS 0035882
KY 0004049
WY 0032590
TX 0000167
AR 0035823
ID 0001163
OR 0000515
GA 0003620
WI 0000531
WA 0002925
NH 0001261
MN 0001422
OK 0041629
IN 0036447
WI 0001341
MA 0005011
WA 0037265
AL 0002666
AL 0023272
1-1
-------
SIC
Code Industry Category
FACILITY TYPES (SIC CODE) AND NAMES
Facility Name
2821 Plastics Material
2821 Plastics Material
2821 Plastics Material
2821 Plastics Material
2821 Plastics Material
2823 Cellulosic Manmade Fib
2823 Cellulosic Manmade Fib
2824 Organic Fibers
2833 Medicinal, Bot Products
2851 Paint S Allied Products
2865 Cyclic Crudes S Interme
2865 Cyclic Crudes & Interme
2869 Industrial Org Chem
2869 Industrial Org Chem
2869 Industrial Org Chem
2869 Industrial Org Chem
2873 Fertilizers, Nitrogen
2873 Fertilizers, Nitrogen
2873 Fertilizers, Nitrogen
2873 Fertilizers, Nitrogen
2874 Fertilizers, Phosphatic
2899 Chemical Preparations
2911 Petroleum Refining
2911 Petroleum Refining
2911 Petroleum Refining
2911 Petroleum Refining
2911 Petroleum Refining
3086 Plastic Products
3211 Glass, Flat
3334 Aluminum, Primary
3341 Metals, Nonferrous, Sec
3351 Copper Rolling, Drawing
3353 Alum Sheet Plate Foil
3355 Alum Rolling & Drawing
3370 Foundries
3433 Heating Equip Exc Elec
3444 Steel Metal Work
3471 Metal Plating & Polish
3471 Metal Plating & Polish
3479 Metal Coating & Servic
3479 Metal Coating S Servic
3613 Switchgear & Switchboa
3624 Carbon S Graphite Prod
3674 Semiconductors
3679 Electronic Components
3996 Floor Cover, Hard Surf
4581 Air Transportation
4911 Electric Services
4911 Electric Services
4911 Electric Services
4931 Electric & Other Servic
4931 Electric S Other Servic
4931 Electric S Other Servic
4931 Electric & Other Servic
4931 Electric & Other Servic
4931 Electric S Other Servic
4931 Electric S Other Servic
Neste Resins Corporation
Miles Incorporated
Quantum-USI Division, Tuscola
Amoco Chemical Co. - Joliet
Hoechst Celanese Corp.
Viskase Corporation
Courtaulds Fibers, Inc
Allied Fibers, Columbia Plant
Johnson S Johnson Advanced Mat
The Glidden Company
Miles Inc., Bushy Park Plant
Crompton and Knowles Corp.
Texas Eastman Company
General Electric - Mt. Vernon
Monsanto Company - Muscatine
ICI Americas Inc.
Chevron Chemical Company
CF Industries, Inc.
BP Chemicals of America Inc.
Farmland Industries, Inc.
Agrico Chemical Company
3M-Cordova
Frontier Refining, Inc.
Quaker State Oil Refining Corp
Marathon Oil - Robinson
Tesoro Alaska Petroleum Co.
Total Petroleum - Ark. Refiner
Dart Industries, Inc
Libbey Owens Ford, Lathrop 10
Reynolds Metals Co., Troutdale
Concast Metal Products Company
Drawn Metal Tube Company
ALCOA North Plant
Aluminum Company of America
Armco Steel Company, L.P.
Process Engineering, Inc.
Atlantic Metal Products, Inc.
Summit Corp of America
Springfield Electroplating
Roll Coater, Inc.
Piper Impact, Inc.
GE, Selmer
U CAR Carbon Co., Inc.
Advanced Micro Devices, Inc.
ABB Power TSD Co., Inc.
American Biltrite, Inc.
Denver Stapleton Intl. Airport
Public Service of New Hamphire
TVA, Raccoon Mt Pumped-Storage
Ohio Valley Electric Corp.
Northeast Nuclear Energy Co.
Arkansas P&L, R.E. Ritchie PI.
Bio-Energy Corporation
Louisiana P&L, Sterlington
Pacficorp dba Pacific P&L, Dav
T & R Electric Supply Co.,Inc.
Fort St Vrain Electric Gen Sta
Permit
Number
LA 0007501
WV 0005169
IL 0000141
IL 0001643
NC 0004952
AR 0036544
AL 0003026
SC 0003557
GA 0001791
OH 0000621
SC 0003441
NC 0005274
TX 0000949
IN 0002101
IA 7000102
MA 0005291
OR 0001635
LA 0000418
OH 0002615
KS 0001601
LA 0004847
IL 0003140
WY 0000442
WV 0004626
IL 0004073
AK 0000841
KS 0000434
RI 0022021
CA 0004839
OR 0000060
WV 0042641
CT 0001601
TN 0067199
IA 0003395
OH 0009997
NH 0020788
NJ 0070696
CT 0001180
VT 0000272
IN 0038172
MS 0000931
TN 0000353
WV 0004707
CA 0028797
IN 0053384
NJ 0031895
CO 0026620
NH 0001465
TN 0031631
OH 0005282
CT 0003263
AR 0000388
NH 0021652
LA 0007579
WY 0003115
SD 0025437
CO 0001121
1-2
-------
FACILITY TYPES (SIC CODE) AND NAMES
SIC
Code Industry Category
4931
4931
4931
4931
4931
4931
4931
4941
4941
4971
5171
5983
8221
9711
9731
9999
& Other Servic
& Other Servic
S Other Servic
Other Servic
Other Servic
& Other Servic
& Other Servic
&
&
Electric
Electric
Electric
Electric
Electric
Electric
Electric
Water Supply
Water Supply
Irrigation Systems
Petroleum Bulk Stations
Fuel Oil Dealers
Colleges & Universities
National Security
National Security
Permit
Facility Name Number
Duke Power, Oconee Station SC 0000515
Wise Elec Power Co - Oak Creek WI 0000914
IELP 6th Street Station IA 0000132
Basin Electric Power Coop-Bism ND 0025232
Boston Edison Company MA 0003557
Otter Tail Power Co.-Hoot Lake MN 0002011
J.C. McNeil Generating Station VT 0020401
Dept. of Land & Nat. Resources HI 0021148
Hackensack Water Company NJ 0003310
Palo Verde Irrigation District CA 0105139
The Cumberland Farms, Inc. ME 0022314
Sun Refining and Marketing Co. RI 0021946
Univ.of Idaho Irrig. Lagoons ID 0027154
U.S. Airforce, Ellsworth Base SD 0000281
US Naval Submarine Base GA 0027707
Highway 36 Land Development Co CO 0042064
US. GOVERNMENT PRINTING OFFICE: 1994— 518-526/80773
1-3
-------
------- |