ABMA
American
Boiler Manufacturers
Association
1500 Wilson Boulevard
Arlington VA 22209
Dol
United States
Department
of Energy
Division of Power Systems
Energy Technology Branch
Washington DC 20545
EPA
United States
Environmental Protection
Agency
Industrial Environmental Research
Laboratory
Research Triangle Park NC 27711
EPA-600/7-80-137b
May 1980
Field Tests of Industrial
Stoker Coal-fired Boilers
for Emissions Control and
Efficiency Improvement
Site J (Data Supplement)
Interagency
Energy/Environment
R&D Program Report
-------
RESEARCH REPORTING SERIES
Research reports of the Office of Research and Development, U.S Environmental
Protection Agency, have been grouped into nine series These nine broad cate-
gories were established to facilitate further development and application of en-
vironmental technology. Elimination of traditional grouping was consciously
planned to foster technology transfer and a maximum interface in related fields.
The nine series are:
1. Environmental Health Effects Research
2, Environmental Protection Technology
3. Ecological Research
4. Environmental Monitoring
5. Socioeconomic Environmental Studies
6. Scientific and Technical Assessment Reports (STAR)
7. fnteragency Energy-Environment Research and Deve/opment
8. "Special" Reports
9. Miscellaneous Reports
This report has been assigned to the INTERAGENCV ENERGY-ENVIRONMENT
RESEARCH AND DEVELOPMENT series. Reports m this series result from the
effort funded under the 17-agency Federal Energy/Environment Research and
Development Program. These studies relate to EPA's mission to protect the public
health and welfare from adverse effects of pollutants associated with energy sys-
tems. The goal of the Program is to assure the rapid development of domestic
energy supplies in an environmentally-compatible manner by providing the nec-
essary environmental data and control technology. Investigations include analy-
ses of the transport of energy-related pollutants and their health and ecological
effects; assessments of, and development of, control technologies for energy
systems; and integrated assessments of a wide'range of energy-related environ-
mental issues.
EPA REVIEW NOTICE
This report has been reviewed by the participating Federal Agencies, and approved
for publication. Approval does not signify that the contents necessarily reflect
the views and policies of the Government, nor does mention of trade names or
commercial products constitute endorsement or recommendation for use.
This document is available to the public through the National Technical Informa-
tion Service, Springfield, Virginia 22161.
-------
EPA-600/7-80-137b
May 1980
Field Tests of Industrial Stoker Coal-fired
Boilers for Emissions Control and
Efficiency Improvement Site J
(Data Supplement)
by
J.O. Burlingame, R.A. Parker, W.M. Jackson,
and J.D. Demont
KVB, Inc.
6176 Olson Memorial Highway
Minneapolis, Minnesota 55422
JAG/Contract Nos. IAG-D7-E681 (EPA), EF-77-C-01-2609 (DoE)
Program Element No. EHE624
Project Officers: R. Hall (EPA) and W. Harvey, Jr. (DoE)
Industrial Environmental Research Laboratory
Office of Environmental Engineering and Technology
Research Triangle Park, NC 27711
Prepared for
U.S. ENVIRONMENTAL PROTECTION AGENCY
Office of Research and Development
Washington, DC 20460
U.S. DEPARTMENT OF ENERGY
Division of Power Systems/Energy Technology Branch
Washington, DC 20545
and
AMERICAN BOILER MANUFACTURERS ASSOCIATION
1500 Wilson Boulevard
Arlington, VA 22209
-------
ABSTRACT
The Data Supplement is a compilation of test data presented in greater
detail than was practical in the Final Technical Report. It is intended
to provide the necessary details to other researchers who are interested
in performing their own analysis. Readers are referred to the contract
final report for information as to objectives, description of facility
tested and coals fired, test equipment and procedures, interpretations
and conclusions. The Final Technical Report also contains data summaries
not found in this volume. The Supplement contains panel board data for
eact test, detailed particulate, O2, CO2, NO, SO2 and SO3 data, particle
size distribution data, chemical analysis of the coal, coal size con-
sistency data, combustible analysis and overfire air traverse data.
KVB 4-15900-545
ii
-------
TABLE OF CONTENTS
Section Page
Foreword iv
CONVERSION FACTORS V
1.0 PANEL BOARD DATA 1
1.1 Control Room Data Sheets 2
2.0 PARTICULATE DATA 31
2.1 Particulate Data Summary 32
2.2 Particulate Dat Sheets 34
2.3 Particulate Lab Worksheets 50
3.0 GASEOUS DATA 66
3.1 Gaseous Emission Summary 67
3.2 Gaseous Emission Data Sheets 68
3.3 SOx Data Sheets 81
4.0 PARTICLE SIZE DISTRIBUTION 83
4.1 Brink 84
4.2 SASS 90
5.0 FUEL AND ASH ANALYSIS 3J-
5.1 Commercial Testing Analysis 92
5.2 Combustibles Analysis 117
5.3 Coal Sieve Analysis 118
6.0 OVERFIRE AIR TRAVERSES 131
6.1 Overfire Air Data Sheets 132
111
-------
Foreword
The purpose of this Data Supplement Volume is to document data
in greater detail than was practical in the Final Technical Report.* it
is intended to provide the necessary details to other researchers who are
interested in performing their own analysis. Readers are referred to the
contract final report for information as to objectives, description of
facility tested and coals fired, test equipment and procedures, inter-
pretations and conclusions. The final Technical Report also contains data
summaries not found in this volume.
The data in this volume are arranged by type (i.e., Panel Board
Data, Particulate Data, etc.) and within each type by test number. Data
summaries where they exist are at the front of each section. The boiler
tested is referred to as Boiler J; as it is the tenth boiler tested under
the program entitled, "A Testing Program to Update Equipment Specifications
and Design Criteria for Stoker Fired Boilers".
KVB 4-15900-545
1 Langsjoen, P. L.,et al., "Field Tests of Industrial Stoker Coal-
Fired Boilers for Emissions Control and Efficiency Improvemenet - Site J.
IV
-------
CONVERSION FACTORS
ENGLISH AND METRIC UNITS TO SI UNITS
To Convert From
in
in
ft
ftj
Ib
IbAr
lb/106BTU
g/Mcal
BTU
BTU/lb
BTU Air
J/sec
JAr
BTU/ftAr
BTU/ftAr
BTU/ft2Ar
BTU/ft2/hr
BTU/ft3Ar
BTU/ft3Ar
psia
"H20
Rankine
Fahrenheit
Celsius
Rankine
FOR TYPICAL COAL FUEL
ppm @ 3% O2 (SO2)
ppm @ 3% 02 (S03)
ppm @ 3% 02 (NO)*
ppm @ 3% 02 (NO2)
ppm @ 3% 02 (CO)
ppm @ 3% 02 (CH4)
To
cm
cm2
m
m2
m3
Kg
Mg/s
ng/J
ng/J
J
JAg
W
w
w
W/m
J/hr/m
W/m2
JAr/m2
W/m3
Pa
Pa
Celsius
Celsius
Kelvin
Kelvin
ng/J (lb/106Btu)
ng/J (lb/!06Btu)
ng/J (lb/106Btu)
ng/J (lb/106Btu)
ng/J (lb/106Btu)
ng/J (lb/106Btu)
Multiply By
2.540
6.452
0.3048
0.09290
0.02832
0.4536
0.1260
430
239
1054
2324
0.2929
1.000
3600
0.9609
3459
3.152
11349
10.34
37234
6895
249.1
C
C
K
K
5/9R-273
5/9(F-32)
C+273
5/9 R
0.851
1.063
(1.98xlO~3)
(2.47xlO~3)
0.399 (9.28xlO~4)
0.611 (1.42xlO~3)
0.372 (8.65xlO~4)
0.213 (4.95xlO"4)
g/kg of fuel**
*Federal environmental regulations express NOx in terms of N02;
thus NO units should be converted using the NO2 conversion factor.
**Based on higher heating value of 10,000 Btu/lb. For a heating value
other than 10,000 Btu/lb, multiply the conversion factor by
10,OOO/(Btu/lb).
KVB 4-15900-545
-------
CONVERSION FACTORS
SI UNITS TO ENGLISH AND METRIC UNITS
To Convert From
To
Multiply By
cm
can
m
in
in2
ft
ft2
ft3
0.3937
0.1550
3.281
10.764
35.315
Kg
Mg/s
ng/J
ng/J
J
JAg
J/hr/a
j/hr/m2
J/hr/m3
W
W
W/m
W/m2
W/m3
Pa
Pa
Kelvin
Celsius
Fahrenheit
Kelvin
Ib
lb/hr
g/Mcal
BTU
BTU/lb
BTU/ft/hr
BTU/ft3/hr
J/hr
BTU/ft/hr
BTU/ft3/hr
psia
"H20
Fahrenheit
Fahrenheit
Rankine
Rankine
2.205
7.937
0.00233
0.00418
0.000948
0.000430
0.000289
0.0000881
0.0000269
3.414
0.000278
1.041
0.317
0.0967
0.000145
0.004014
F
F
R
R
1.8K-460
1.8C+32
F+460
1.8K
FOR TYPICAL COAL FUEL
ng/J
ng/J
ng/J
ng/J
ng/J
ng/J
ng/J
ppm @ 3% O2 (S02)
ppm @ 3% O2 (SO3)
ppm @ 3% 02 (NO)
ppm @ 3% 02 (N02)
ppm @ 3% 02 (CO)
ppm @ 3% O2 (CH4)
g/kg of fuel
1.18
0.941
2.51
1.64
2.69
4.69
0.000233
KVB 4-15900-545
vi
-------
SI PREFIXES
Multiplication
Factor Prefix SI Symbol
1018 exa E
1015 peta P
1012 tera T
10"! giga G
10 mega M
kilo k
10 hecto* h
101 deka* da
10 deci* d
10 centi* c
10~3 milli m
10~6 micro \i
10~9 nano n
10-12 pico p
10~15 femto f
10~18 atto a
*Not recommended but occasionally used
KVB 15900-545
-------
EMISSION UNITS CONVERSION FACTORS
FOR TYPICAL COAL FUEL (HV = 13,320 BTU/LB)
Multiply
Ib "V^ By
Obtain
% Weight in Fuel
S M
gr»ms/106Cal
SOj NO2
PPM
(Dry 3% 02)
SOx NOx
Cr«in»/SCT.
(Dry «12* CO2)
% weight
In Fuel
0.666
0.370
0.405
13.2x10 ~4
0.225
1.48
5.76X10"4
.903
Ibs/lO^tu
1.50
*°2
19.8x10"*
(2.23)
2.47
(.556)
14.2X10'4
(2.23)
SO,
2.70
U-8)
4.44
35.6xlO"4
(4.01)
(1.8)
25.6xlO~4
(4.01)
SOx
758
505
281
(DryC3%02>
NOX
1736
704
1127
391
1566
Grains/scr _
(Dry 112% C02)
.67«
(.448)
(.249)
8.87xlO'4
1.11
(.448)
(.249)
z
6.39xl(T4
WOTZ: 1. Value* In parenthesi* can b« used tor all flue gaa constituent* such as oxides of
oxides of nitrogen, oxides of sulfur, hydrocarbons, participates, etc.
2. Standard reference temperature of S30*R was used.
carbon.
viii
KVB 4-15900-545
-------
SECTION 1,0
PANEL BOARD DATA
PAGE
1,1 CONTROL ROOM DATA 2
-------
KVB
PANEL BOARD DATA
ABMA TEST SITE J
Steam Flow. Ibs/hr
Coal Flow, Ibs/hr
% Design Capacity
Ib steam/lb coal
TEST NO.
TEST DATE
TEST COAL ;
TEST CONDITIONS
COAL
TIME
POUNDS ADDED
STEAM " -n*ur
INTEGRATOR READING
CHART RECORDER
STEAM FLOW KlbS/hr
AIR FLOW, RELATIVE
' .
DRAFT GAUGES
WIND BOX "H2O
FURNACE "H-O
i 2
BOILER OUT "H2O
DUST COLLECTOR "H-O
STOKER ZONE #1
§2
#3
#4
#5
#6
Of
6-3-71
Ok*
3Z"*"fa
"*
A--S"
"/f/w
/3?7-sr-
^3*7*
36
5?
f.4
0,1,
-Q-\
-3-«
/^.'ZJ
&»m
36
5C-
2*
4>rZ-
-i?.r
-5^
-------
KVB
01
PPP.«TTPK RMlflES
STEAM PRESSURE psig
FEEDWATER psig
AIR PRESSURE psig
,
CONTROLS
BOILER MASTER
STOKER
FORCED DRAFT
OVERFIRE AIR
INDUCED DRAFT
STOKER
COAL GATE POSITION
WIND BOX POSITION #1
. "#2 .
#3
#4
... #5
-#6
OVERFIRE AIR PRESSURE "H20
TEMP. F.D. FAN °F
TEMP. F.W. °F
12&
fa?-
/ffO
/0fi
to
4
to-2-
s~
o
CS
0-
o-
o-
o
0'1<
(11
'/go
3
/6>°
l&r
'
-------
KVB
PANEL BOARD DATA
ABMA TEST SITE J
Steam Flow, Ibs/hr
Coal Flow, Ibs/hr
% Design Capacity jt.f
Ib steam/lb coal
TEST NO.
TEST DATE
TEST COAL ..
TEST CONDITIONS
COAL
TIME
POUNDS ADDED .
STEAM ^^MJer
INTEGRATOR READING
CHART RECORDER
STEAM FLOW Xlbs/hr
AIR FLOW, RELATIVE
.
DRAFT GAUGES
WIND BOX "H2O
FURNACE "H,0
BOILER OUT "H20 .
DUST COLLECTOR "HjO
STOKER ZONE #1
#2
#3
#4
#5
#6
2
6H-79
OMic-
5*«>o^
-
j>4*-
'ffUJ
i
»;47
xT/732-
^>
*3.
/v
tfrZ^
-^>
£>
O
-
,«| ^**v/
Z-'44
^7^4
^^
^
/3
«.*r~
-e»'5T
'33T
..
.3»41
^7ff6-j
^z-
^
/3
tf'*f
' o. r-
-3,X^
e-S~
I
*'C
o
£>
0
4>rs
t -30/0 pe*
I
4.'rr
4T/f3a
-
Jk
4
-------
KVB
PRESSURE RAUGES
STEAM PRESSURE psig
FEEDWATER ps.ig
AIR PRESSURE psig
CONTROLS
BOILER MASTER
STOKER
FORCED DRAFT
OVERFIRE AIR
INDUCED DRAFT
STOKER
COAL GATE POSITION
WIND BOX POSITION #1
#2 .
#3
#4
. . #5
-#6
OVERFIRE AIR PRESSURE "H20
TEMP. F.D. FAN °F
TEMP. F.W. °F
13 &
It4-
foo
fa
70
61
C^t-
7-2.
o-
<*"
cr
cf
fy-
G>-
3-«"
11*1-
\lo
/oo
/t>0
7o
&
-O.Z
77
o-
&
&
G>-
<&-
<&-
-
|Sb
W
4i
2
-------
KVB
PANEL BOARD DATA
ABMA TEST SITE J
Steam Flow, lbs/hr_
Coal Flow, Ibs/hr
% Design Capacity
Ib steam/lb coal
TEST NO.
TEST DATE
TEST COAL ;
TEST CONDITIONS
COAL
. TIME
POUNDS ADDED
STEAM T&&
INTEGRATOR READING
CHART RECORDER
STEAM FLOW Klbs/hr
AIR FLOW, RELATIVE
. .
DRAFT GAUGES
WIND BOX "H2O
FURNACE "H2O
BOILER OUT "H2O .
DUST COLLECTOR "S^
STOKER ZONE #1
12
#3
14
#5
! #6
03
6-5-- 79
Ohio
7ffi,CDO tyflt
-*.
(O.oo
'ftW
1
/ooo
&&*>
70
r1S^
o.r
I.-L
/>'
t>~1
6
. o
foto C>z.
gOlUFR
P0Hi-V
W«H»
^TA^TTtfb
TSA^ <*
^Tf^^e^
-SlV«o(ci^6
> TesTTW.
^
-
6
-------
KVB
PRESSUHEL GAUGED ,
STEAM PRESSURE psig
FEEDWATER ps.ig
AIR PRESSURE psig
CONTROLS
BOILER MASTER
STOKER
FORCED DRAFT
OVERFIRE AIR
INDUCED DRAFT
STOKER
COAL GATE POSITION
WIND BOX POSITION #1
#2 .
#3
#4
, . #5
#6
OVERFIRE AIR PRESSURE "H20
TEMP. F.D. FAN °F
TEMP. F.W. °F
/So
tv
/00
" -M
tf
^
~~&^
t-4
o-
*
Gf^
-------
KVB
PANEL BOARD DATA
ABMA TEST SITE J
Steam Flow. IbsAr 7^/3-2.
Coal Flow, lbs/hr_ £0do
% Design Capacity /Q1--
Ib steam/lb coal
TEST NO.
TEST DATE
TEST COAL
TEST CONDITIONS
COAL
. TIME
POUNDS ADDED .
STEAM T, '"*, e.
INTEGRATOR READING V
CHART RECORDER
STEAM FLOW Klbs/hr
AIR FLOW, RELATIVE
DRAFT GAUGES
WIND BOX "H2O
FURNACE '"H.O
BOILER OUT "H2O .
DUST COLLECTOR "H2O
STOKER ZONE f 1
§2
t3
*4
#5
#6
5
£-/>?f
.0ff?0
~>£>j Ot>O
V/J-
£a)
3H2-
^^775-
-73
61
2,0
-0. 2-
-0.f
-l,d
0,6
f,
7^
5"7
2- 2.
-^ Z-
-<&?
-7. 1-
0.1
/.&
0.*
0. '
o
^
.
-
5; zz.
5"^ ^y
-7V
cT/"
J2-3
'^, 2-
-^ 7
~-),o
#,->
/.$
f>/
0./
0
a
' .
5'Y5
-)'^-^r
5>37
5"^ ? ^7
.
-.
"
~~
~~
-------
KVB
PRRSSIJKE GAUGES ,
STEAM PRESSURE psig
FEEDWATER psig
AIR PRESSURE psig
CONTROLS
BOILER MASTER
STOKER
FORCED DRAFT
OVERFIRE AIR
INDUCED DRAFT
STOKER
COAL GATE POSITION
WIND BOX POSITION #1
#2
#3
#4
. - - . #5
' -#6
OVERFIRE AIR PRESSURE "HjO
TEMP. F.D. FAN °F
TEMP. F.W. °F
/!<>
n^
. $<}
/y 0
"Sod
/t>d
7^
0. 1-
/!,()
O-
cf
fr-
o-
Q-
$~
-7 7*'"
-7d
2 15
/^
/^ci
$3
/G C)
/Jt>
/C> £>
~73
-0.1^
/y. 7
o-
(^
o-
o-
o-
o~
-
J3l^
/4&
5~t>
/&Jc)
/OJ
/c>t>
9
£>-
a*
Cr-
o
&-
o-
"
-
-------
KVB
PANEL BOARD DATA
ABMA TEST SITE J
Steam Flow, Ibs/hr 6 'T,-^
Coal Flow, Ibs/hr <-/ fr
% Design Capacity ''''(_
Ib steam/lb coal / <-/
TEST NO.
TEST DATE
TEST COAL
TEST CONDITIONS
COAL
TIME
POUNDS ADDED
STEAM ~ris*t £~
INTEGRATOR READING
CHART RECORDER
STEAM FLOW Klbs/hr
AIR FLOW, RELATIVE
.
DRAFT GAUGES
WIND BOX "H2O
FURNACE "H2O
BOILER OUT "H2O
DUST COLLECTOR "H2O
STOKER ZONE #1
#2
#3
#4
#5
#6
'&
C-J~J*-7
/{£»&<£ £y
-?e? &G fj
*
//75
f *'//«;
jros
69; CIV
-jo
g<*
2-^
4-f
2.L
<^,2,S
-0,%
~~?.c
#
&<£-
/,o
0.3'
0
V
0
}:05"
~7 -/&<<*/
2:/o
5jl
-------
KVB
\
PRESSURE GAUGES
STEAM PRESSURE psig
FEEDWATER ps.ig
AIR PRESSURE psig
CONTROLS
BOILER MASTER
STOKER
FORCED DRAFT
OVERFIRE AIR
INDUCED DRAFT
STOKER
COAL GATE POSITION
WIND BOX POSITION #1
#2 .
#3
#4
. . . #5
-#6
OVERFIRE AIR PRESSURE "H20
TEMP. F.D. FAN °F
TEMP. F.W. °F
' ,40
/?S
.50
S-o
' ~ 50
3?
?S
#./
*a
o-
cf
er
o-
Cr
1"
1
/**
2-2-5
*<>
,00
/*>*
5*
6*
0, 2-^
f,5
o-
Cf
" '*<> '
&
£o
5*
^
O.-L*
*.i~
cr~
tf
cr
o-
V"
-?o
}^0
-
-
^
-------
KVB
PANEL BOARD DATA
ABMA TEST SITE J
Steam Flow. Ibs/hr g*^
Coal Flow, Ibs/hr ^-/^
% Design Capacity j" V-
Ib steam/lb
TEST CONDITIONS
POUNDS ADDED
INTEGRATOR READING
CHART RECORDER
STEAM PLOW Klbs/hr
AIR FLOW, RELATIVE
DOST COLLECTOR "HO
-------
KVB
\
PRESSURE RATIRES ,
Sl^AM PRESSURE psig
FEEDWATER ps.ig
AIR PRESSURE psig
CONTROLS
BOILER MASTER
STOKER
FORCED DRAFT
OVERFIRE AIR
INDUCED DRAFT
STOKER
COAL GATE POSITION
WIND BOX POSITION #1
#2 ,
#3
. #4
. . - . #5
-#6
OVERFIRE AIR PRESSURE "H20
TEMP. F.D. FAN °F
TEMP. F.W. °F
/
-0,2-
f<
-------
KVB
PANEL BOARD DATA
ABMA TEST SITE J
Steam Flow, lbs/hr
Coal Flow, Ibs/hr *-f f
% Design Capacity "7 ?. /
Ib steam/lb coal /z V
TEST NO.
TEST DATE
TEST COAL
TEST CONDITIONS
COAL
TIME
POUNDS ADDED
STEAM 7~J ^ c
INTEGRATOR READING
CHART RECORDER
STEAM FLOW Klbs/hr
AIR FLOW, RELATIVE
.
DRAFT GAUGES
WIND BOX "H20
FURKACE "H20
BOILER OUT "H20 .
DUST COLLECTOR "H2O
STOKER ZONE #1
#2
#3
#4
#5
#6
r
/-/JT-77
y^r^-AcX'y
5*<^ o^o
"
/o; 7.5
f/'/tJ
J4; 2-T-
6)S5o
53
t^4
/.^
-0. 2-
rO.r
-3,2-
# 2-
0.1
O
t)
0
.0
//2-(,
(,(62,4
5 3~
HI
/3
-a -^
-as"
-3,5
<7. 2-
^ 7
O.J
0
a
0
/7./i7
//6r~2-
Vi-
/-j
O.i'S'
-o.s
-3,S
&, T-
0,6
t> /
d
SI '-'Si.
6/?/0
.
.
_
-------
KVB
PRESSURE ci
STEAM PRESSURE psig
FEEDWATER ps.ig
AIR PRESSURE psig
BOILER MASTER
FORCED DRAFT
OVERFIRE AIR
INDUCED DRAFT
COAL GATE POSITION
WIND BOX POSITION #1
#2
OVERFIRE AIR PRESSURE "H_0
TEMP. F.D. FAN °F
TEMP. F.W. °F
-------
KVB
PANEL BOARD DATA
ABMA TEST SITE J
Steam Flow, Ibs/hr
Coal Flow, Ibs/hr
% Design Capacity
Ib steam/lb coal /I- 2_
TEST NO.
TEST DATE
TEST COAL
TEST CONDITIONS
COAL
TIME
POUNDS ADDED
STEAM 7/^» «^
INTEGRATOR READING y f^t)
CHART RECORDER
STEAM FLOW Klbs/hr
AIR FLOW, RELATIVE
DRAFT GAUGES
WIND BOX "H2O
FURNACE "H_O
BOILER OUT "HO .
DUST COLLECTOR "H2O
STOKER ZONE #1
#2
#3
#4
#5
#6
7
<£-/£-7*
fa /JM( Ay
56jO
#.3
o.-?
(}
<)
^
. 0
II *
6^1-6
ir
szr
2.6
-OJ $
-*
fivei.
3s
3H-
fit
-OJ-S
-&.<-/
'X2.
*-3
0.%
0J
&
e>
O
/5:;<>
7600
J1-/I
^zvf^
-
*
16
-------
KVB
PWRSRireR GAUGES .
STEAM PRESSURE psig
FEEDWATER psig
AIR PRESSURE psig
CONTROLS
BOILER MASTER
STOKER
FORCED DRAFT
OVERFIRE AIR
INDUCED DRAFT
STOKER
COAL GATE POSITION
WIND BOX POSITION #1
'#2 .
#3
14
. - - . #5
#6
OVERFIRE AIR PRESSURE "H20
TEMP. F.D. FAN °F
TEMP. F.W. °F
/HI-
lW
54
<-fc
y*
2~c>
37
-O.I
S:~l
&-
V
0-
0-
o-
0-
z.i-r
<$2-
/^()
/?5
&
6^
5"
Zo
H\/
-0,1
S-.*-
£>-
^
Cr-
Cr-
o-
o-
^
-
/y^
t$t
f*
*c>
5*
/f
LJT^
-0.1
5-7
o~
cS
-------
KVB
PANEL BOARD DATA
ABMA TEST SITE J
Steam Flow. Ibs/hr 7 / 7 ^
Coal Flow, Ibs/hr S"-//f
% Design Capacity /"-^S'
Ib steam/lb coal /J, 2^
TEST NO.
TEST DATE
TEST COAL
TEST CONDITIONS
COAL
TIME
POUNDS ADDED .
STEAM T~/m V
INTEGRATOR READING yft&d
CHART RECORDER
STEAM FLOW Klbs/hr
AIR FLOW, RELATIVE
-
DRAFT GAUGES
WIND BOX "H2O
FURNACE "H-O
BOILER OUT "HO .
DUST COLLECTOR "H2O
STOKER ZONE #1
#2
#3
#4
#5
#6
'/J
6-J1--M
.0W
-tyeJO'tt
tO' £5
£/W
tl'**
s
^,7
l.f
/r
0
' /
. o
iy.}&
-7Jv*s
/3/57
^V^/J
^r
^r
20
~of^
-o.~>
-C.e>
0.f
/,<>
0,1
O
£>
O
.
**»
.
~_
18
-------
KVB
I
PRESSURE fiAUGES ,
STEAM PRESSURE psig
FEEDWATER ps.ig
AIR PRESSURE psig
CONTROLS
BOILER MASTER
STOKER
FORCED DRAFT
OVERFIRE AIR
INDUCED DRAFT
STOKER
COAL GATE POSITION
WIND BOX POSITION #1
#2 .
#3
#4
, , - #5
-#6
OVERFIPE AIR PRESSURE "H^Q
TEMP. F-D. FAN °F
TEMP. F.W. °F
I~W
/0
0./
1,0
&-
-------
KVB
PANEL BOARD DATA
ABMA TEST SITE J
Steam Flow, lbs/hr
Coal Flow, lbs/hr
% Design Capacity
Ib steam/lb coal //.
TEST NO.
TEST DATE
TEST COAL
TEST CONDITIONS
COAL
TIME
POUNDS ADDED
STEAM fi'/nf^
INTEGRATOR READING
CHART RECORDER
STEAM FLOW Klbs/hr
AIR FLOW, RELATIVE
- .
DRAFT GAUGES
WIND BOX "H20
FURNACE "H20
BOILER OUT "H2O .
DUST COLLECTOR "I^O
STOKER ZONE #1
#2
#3
#4
#5
#6
H
Of/10
30, ooo
£jf*f>f
^1,0
d.t-l
//
0-1
J
0
a
/ *--y?
jzffr
63,030
5-5
/.*
~a if
-6. ?
^£.5-
t-t,
/jT
6.1
^>
a
j
*
/J'/s
£g)£>i)d
s?
//
-6
-o.->
-4-,S
0-7
',J
/,*>
0. -2-
4
0
/J-V7
^J-f^ty
->£>j0t>0
5~?
2-0
- e>. *5
-&.?
-f-S"
/,o
/ 7
Xc/
a. 3
C) '
o
£0
-------
KVB
PANEL BOARD DATA
ABMA TEST SITE J
Steam Flow. Ibs/hr
Coal Flow, lbs/hr
% Design Capacity
Ib steam/lb coal //.
TEST NO.
TEST DATE
TEST COAL
TEST CONDITIONS
COAL
TIME
POUNDS ADDED
STEAM 7/'"l-
INTEGRATOR READING YfrOtf
CHART RECORDER
STEAM FLOW Klbs/hr
AIR FLOW, RELATIVE
.
DRAFT GAUGES
WIND BOX "H2O
FURNACE "H_O
BOILER OUT "H20 .
DUST COLLECTOR "H2O
STOKER ZONE #1
#2
#3
#4
#5
#6
M
-4///0
-ie)jOt>i>
^
lH-fi
(,f/w°
Ft
}.0
'-.IS
-0. 1
-C.5
0-7
h*
J,l>
' 6. 1
0
o
/V--V7
&f0tr
£g£)CM
5-f
2-d
-,2-5"
-^?
<-5-
a.-)
t0
6
-0.1^
-0.10
-7.6
V.T>
l.o
07
G.I
0
i)
J
/5V?
L6/5*
(,700*
*6
l',o
-0,-Ls
-0.7
-(,.*
£.5
/.Is
t>.{
0
0
0
/&:*5
*>.*>*?, /
idMecS
/t: V7
LCi'SV
_
21
-------
KVB
PRESSURE BRUGES ......
STEAM PRESSURE psig
FEEDWATER psig
AIR PRESSURE psig
CONTROLS
BOILER MASTER
STOKER
FORCED DRAFT
OVERFIRE AIR
INDUCED DRAFT
STOKER
COAL GATE POSITION
WIND BOX POSITION #1
#2 .
#3
#4
... #5
'#6
OVERFIRE AIR PRESSURE "HjO
TEMP. F.D. FAN "F
TEMP. F.W. °F
'/-td
lt-1
6*
-11
-?/
f*
10*
-0.1-
10,1
o-
^
^5
ssr
to
-O.T-
/&-5
<^
o
or
o-
0-
Cr
7 ?/v"
e>
,00
56.
,00
-O. ~i-
/6>.S
>
cr'
or-
o-
o-
Cr-
~
/3f
/f-7
^
70
./
o-
o-
a-
_
^
*-
.
.
22
-------
KVB
\
PRRSSIIHE KAIJGE.S ,
STEAM PRESSURE psig
FEEDWATER ps.ig
AIR PRESSURE psig
CONTROLS
BOILER MASTER
STOKER
FORCED DRAFT
OVERFIRE AIR
INDUCED DRAFT
STOKER
COAL GATE POSITION
WIND BOX POSITION #1
. '#2 .
#3
#4
, . - . #5
' -16
OVERFIRE AIR PRESSURE "H20
TEMP. F.D. FAN °F
TEMP. F-W. °F
/Y6>
/45
5o
jCO
/Jj
?5
»<>
-0.1*
,o,f
. Cr
ff
(f
&-
o-
o~
-7*/>i
l.l-S'
/
-0. X'
lt>. 1
CT-
/
CT
cr'
o-
o~
-
}f 4
/fro
' 5'0
(O.f
£>-
(f
C/
cr~
o-
0-
/35
ite)
$0
&1-
8-(J
*5
/Oe)
-O.L.
/*'
fr-
S
0^
cr
O-
o-
Jfo
/t7
5~
-------
TEST NO:
KVB
NOTES
3. 6
TEST NO:
TEST NO:
TEST NO:
_ . CW v ' If**
TEST NO:
-------
KVB
PANEL BOARD DATA
ABMA TEST SITE J
Steam Flow, Ibs/hr 6$,
Coal Flow, Ibs/hr 51
% Design Capacity 33.
Ib steam/lb coal (i.j_
TEST NO.
TEST DATE
TEST COAL
TEST CONDITIONS
£*.xj - S&F
COAL
TIME
POUNDS ADDED
STEAM
INTEGRATOR READING
CHART RECORDER
STEAM FLOW Klbs/hr
AIR FLOW, RELATIVE
DRAFT GAUGES
WIND BOX "H2O
FURNACE "H2O
BOILER OUT "H20 .
DUST COLLECTOR "H2O
STOKER ZONE #1
"/J^O #2
#3
#4
#5
#6
'15
6-2* -7?
X'triTWcy
6-§ -£>**nJ
"*
li-Of)
£ 'iltd
-7/5/2_
££
^
2,*4
-0.^0
-0.?
-6-5
04
/,/
t.f
0
d
0
l$00
-11551-
65
ry
Z-t/
-#.2~0
-0.~7
-55
0.6
I.I
0.5~
0
0
0
.
"-
m:o4
-jltFf
£3
$3
2--L.
-0.1*5
-0.K
-CJ
o.£
J.L
*4>
0
O
6
/S-'OO
-ins*?
t?
£5
2--c/ -
-^Z-J
-o.?
~ £.-?
r&7
/
0.~)
/t:oo
->IS^~L^
-70
*Z
J.£
~O. 2.0
-o.(,
-5S
o.s-
'.
-------
KVB
PANEL BOARD DATA
ABMA TEST SITE J
Steam Flow, Lbs/hr^^
Coal Flow, Ibs/hr
% Design Capacity
Ib steam/lb coal
TEST NO.
TEST DATE
TEST COAL
TEST CONDITIONS
&,sf Sd x
COAL
. TIME
POUNDS ADDED
STEAM
INTEGRATOR READING
CHART RECORDER
STEAM FLOW Klbs/h*
AIR FLOW, RELATIVE
, - m
DRAFT GAUGES
WIND BOX "H2O
FURNACE "H2O
BOILER OUT "H5O
DUST COLLECTOR "HjO
STOKER ZONE fl
12
f3
14
§5
§6
AST
t'TX-W
f(w***cky
£&&*>'/
^
f):00
l&S ^^r
-7/^2-3
£^
s^t
l.t,
-0. 1 i'
~o.l>
~*M
0.5
JrO
*.5
' d
&
0
'-
,
26
-------
KVB
\
PRFRRTTKE GAUGES ,
STEAM PRESSURE psig
FEEDWATER ps.ig
AIR PRESSURE psig
CONTROLS
BOILER MASTER
STOKER
FORCED DRAFT
OVERFIRE AIR'
INDUCED DRAFT
STOKER
COAL GATE POSITION
WIND BOX POSITION #1
#2 .
#3
#4
.... #5
-#6
OVERFIRE AIR PRESSURE "H,0
^
TEMP. F.D. FAN °F
TEMP. F.W. °F
'MS
&o
5*
2-5*
2__r
Ze>
td
a. i>
&*-
o-
cr'
&-
Q
o-
Cr-
1 z^5
15*
5*
/£>&
66
^5
£5 \
-O,1~
f.o
O-
cf
&-
G-
Cr-
o-
6.5-
&
1t&
-
/J>J-
##
'&
/a 6
/0d
/oe>
&
-0.1-
1*3
a~
tf
cr
&-
o-
o-
ti-
--
/v
2-7
3-7
HS
fo
-a. 2..
-------
KVB
\
TJUPSRUHE GAUGES .........
STEAM PRESSURE psig
FEEDWATER psig
AIR PRESSURE psig
CONTROLS
BOILER MASTER
STOKER
FORCED DRAFT
OVERFIRE AIR"
INDUCED DRAFT
STOKER
COAL GATE POSITION
WIND BOX POSITION fl
. #2 .
13
- .- #4
. #5
" #6
OVERFIRE AIR PRESSURE "H,O
TEMP. F.D. FAN °F
TEMP. F.W. °F
1*5
*2^I0
£"t)
^5
" »
£>^
5*
-O.l;
1.5"
o-
c/
cr
o-
o-
o-
'
'"-
-------
KVB
PANEL BOARD DATA
ABMA TEST SITE J
Steam Flow. Ibs/hr 6Lfj gag
Coal Flow, Ibs/hr &1CO
% Design Capacity *??-£
Ib steam/lb coal /^.J"
TEST NO.
TEST DATE
TEST COAL
TEST CONDITIONS
-StfvSSV^^
COAL
TIME
POUNDS ADDED
STEAM
INTEGRATOR READING
CHART RECORDER
STEAM FLOW Klbs/h*
AIR FLOW, RELATIVE
DRAFT GAUGES
WIND BOX "H20
FURNACE "H20
BOILER OUT "HO
DUST COLLECTOR "H20
STOKER ZONE #1
#2
#3
#4
#5
#6
/z
£-3o-l^
-£. i-/
-a--)
-t.3
0.3
/,6
J.2-
4
4
a
}
W-50
6i-
SS
2-2-
- O, 2.0
-a--?
-6.6,
J.S~
/,o
0. 2-
d?
^
^
/C/f
;3i<«j
//./2-
-73633-
43-
r
-------
KVB
\
pRRKStTRE GAUGES ,
STEAM PRESSURE psig
FEEDWATER ps.ig
AIR PRESSURE psig
CONTROLS
BOILER MASTER
STOKER
FORCED DRAFT
OVERFIRE AIR"
INDUCED DRAFT
STOKER
COAL GATE POSITION
WIND BOX POSITION #1
#2 .
#3
#4
... #5
- #6
OVERFIRE AIR PRESSURE "H20
TEMP. F.D. FAN *F
TEMP. F.W. °F
A3?
/&^
5*
3£
£<7
1*
65
-# -^
s-.s-
&~
/ 54
/3S
S*
'
to
-VJ
&
fr
-O.I.
e.&
Q-
tf
&
G-
&-
'o-
/J^
/y?
s^
5-^5
*f
tr 5
-xF
-o.z.
f.3
O
(T
{y
o-
o-
<3-
6
75^
>/£
'"
/ 2-0
J50
5*
/^
6 &
2*
-?<>
-0.2-
V
0-
0'
O^
d-
<3-
<3-
/z- T
/-?*-
fo
^s-
35
~?a
/ 0&
-a. 2_
f.y
o-
cr'
e^r
o-
Ct~
&-
?'/*.
75
^/7
-
30
-------
SECTION 2,0
PARTICULATE DATA
PAGE
2,1 PARTICULATE DATA SUMMARY 32
2,2 PARTICULATE DATA 34
2,3 PARTICULATE LAB WORKSHEETS 50
31
-------
PARTICULATE DATA SUMMARY
PART I
LOCATION: f&Htr
TEST
NO.
Total
Mass
mgm.
Dry Gas
Volume
ft3
Liquid
Coll.
ml.
Baro.
Press.
"Hg
Static
Press .
"H20
Pitot
AP
"H20
Orifice
AH
"H20
Stack Gas
Temp.
°R
Excess
02
Sampling
Time
min .
Nozzle
Dia.
in.
Pitot
Factor
n.d.
Fuel Flue Gas
Factor MW
;CF/10%TU g/g mole
Ol
-0-lt
0-10?
A 372
01
0.0*) >i
TI±_
72-42.
963?
/?£
m,
24
370
^773
tr«-t
oi-
21.36
S2-C-
I2o
0.377
^775
^o_
0-61
60
05-
284-7
74
0-VT
/DO
/Wo
J^
tc.
60,101
Tfi
-0-26
O.Z1
46
/3I
ffc?
(*>
£3
-6.2I
JLL.
08(7
21
a*
f>
-ft 06
»7tf
772_
0,11
1**
121-
to
72.x
-ff.rt
763
72-
0-8/7
4L
2U7
17
_2i
#15900 rev.
-------
PARTICULATE DATA SUMMARY
PART II
Location
J" -
TEST
NO.
LOAD
02
CONDITIONS
EMISSIONS
lb/105BTU
GR/SCF
LB/HR
Moisture
Stack Gas
Velocity
Ft/sec
Stack Gas
Flow
SCF/sec
Isokin.
o;
AS
0.
Wl
5TVKK
01
O,tlf
70-Z3
toi
O-JT
02
0.779
O.Z7L
57?
Oi.
12
3o.il-
|oe>
ike cw
Of
3*7
a 4.7
JTAtfK
OS"
f-J
0 224
6-86
06
8-1
AS fbvJfO
O.bl'j
«7
ts"
T17
loZ
85"
fo.77
Si. 34
IOO
6-77
(01
~)oo
751
O. i
21
2*7
ou-r
at
S7
17- 7«
(02.
r
O.o f 4
24*
107.
i4
171
eg
COAL
17-i
to
17
103
w
#15900 Rev.
-------
Lea* Check Rate
ISCKJI.TTICS
Uf.if.
Sample
Point
/
! 2-
J
H
S
6
1
r
Time
+ 10
{,0.1
Average
RTTEJI vol..
t"
ti
Hr
37
cent
Sarapiing Time
7
U.
Vacr
Before
Afrei
KETER CONDITIONS
APS
.*2-
.1-1-
-15
t
/^
.2~~l
,1-3
.1*0
,7-0
0,2.05
START
- v
OLJ
& H Meter Reading
/.Y0
/ Ytf
w
4X''#jt-
^
fT/iA?^
5^
'2&.;
i5
5^33. 5/
5
I
f
DATE
/Tnin
OFER
FUIL
sirr
PROS
TErtPEJUi^URES. F
Stack
w
<,y^j
Wo
mjd
VL6>
5«c>
<^r^
Vf^
Probe
2$0
35^
35o
3^6
2-^d
,2_S4
Zaa
3.00
1
^_y ** ^J *£
Nomouraoh Setup
Oven
25o
7 2-,.37o »5
'*" ** m Sille*
r. -J/l r«l> otl
ir.oinoers u-t-_
In Out
J_
Vcl. lEnd)
///
3?
;c'o
/OL.
//ti
y/5
/L<>
110
I*"
5U?i
<-J- v#
ATQR "7" ^)
./) // / 0
J
E LOCATION ft.'l !-" O^t*-
°2'V
Voi. (Start) OVol. Iml!
/^-^
/^6>
4 . a
~$f~
Tciftl
II
d
~*45__
^ic: ams
/*/
Vac.
f-5"
^5"
^^
^.6
/?.tf
J--7
7 ?
7.?
=
Tot«] VoJ . H-,0 * I r.I
-------
PARTICULATE
DATA
Leak Check Rate
ISOKINETICS
TEST NUMBER
DATE
OPERATOR
FUEL
SITE
PROBE LOCATION
START
SAMPLE V01.
Stack Press.
Barometric
NomcxTraph Setup
- c
- T»tack
- AP .
- Nozddetl}-
- £. NoKActu.l).
imp. vol.lEnd) Vol. istart) Wol. (ml)
2
13
Silica
Gel
Total 38
g(Start) Agrams
Total Vol. HjO yP'
-------
DATA
Sample
Point
/
2-
3
*
5*
6"
7
(^ytf-^
5 ^t^
^Vt/
S ^
2.CO
2-&C.)
10*
2,0*
2-a^
2^)*i
/f«
Nomouraoh SctuD
C
£ /
Oven
?*£)
2-ftJ
Z-te
3-80
it*
3<>o
WO
310
ir.oinaers Hctcr
In Out MCtCr
//O
//J
/z-d
1^3
/d5
/^5
//o
/A5
1
" ' ' ,,^
=====
, f
Vac.
4.^
f.p
*r
^.d>
//J
t&*£)
f*Q
==«
- j
Imp. Vol.lEnd) Vol. (start) Mlol.liMl
12
//^ - /<^
J0% - /M
D . d
Total
6_
Vt:crnr 0; " I
« HjO
Total Vo;. H,o
£?*
-------
FAXTICULATE
DATA
a> Check Rat«
v.c
in. Hq IfV
ISOKINETICS
-, . J
TEST KOMBIR ./ /
DATE - V-
OPERATOR
FUEL
SITE
PROBE LOCATION
L7"
:/^/r
TE.TPERATURES, °F
Sample
Point
Time
METER CONDITIONS
Meter Reading
TO
Stack
Probe
Oven
Irr.oinaers
I n 0>ut^
Meter
Vac.
?
/.so
, 53
7J
,2-? /
if 5
2- -5-5
/,&<>
2-jo
2V
70
J3
7 5.71
7Z-
2-2-
*"''
2-
2-3
2-1, £>
T-'io
75
13
3.4 3*7.1 1
,2-3
/*(
,2-3 I. (.0
2,
2-8
72-
,7-1
SL
,14
11
c r Q e
t-5*
360
72-
2.64
3*5
.*?<>
30?$ '505
fa-3.
_1~_
7J
73
7/
1:11
z!!of3<).Hf- V&J
n V°L ^£^|~W
iAVniJ_yojAJT^^3
35
53
: :.. Hc-r.auae
L-1'2! '-^t-'^
VtTcerr- O* * L..
C
btac*:
t;p =
c- *C ., ,-jt,ix ^
t>/ J NOZ (j asaJ )= / O
HOI (A.CtUel > =
1"!!ELL v_o^l . jLn_d) VQ^I . (starO_
(il _' ~ _ /~y^
12 / 5^
35
*4 cUr.d1
37
-------
?~_RT ICULATE
DATA
ISOKIKFTICS
vac
in. Hq ftvnin
Trri Ki'-srn -5
DATE ^"/Z'~~?:
OPERATOR ^7 <£^
TUIL Of'11.'
SITE X
PROBE LOCAT!OI1 Xi-' /?*"
T2-0
3CHJ
5
.Co
£7
5.2,
-m.
-(,£>
Average
.(,5
.c/
KETEF VO1.
SAMPLT VOL.
3-7 »/.
cp a tot
,537
Stack Press.
In. HQ-Caua*
-7
Percent. 02 -
,0"#iO
ba r one- trie
Pressure
^^. 70
NomouraDh Setur-
p m C
"meter
Pst»ck " Tstack "
Tr>«t«r W
£H9 - NoiUdtdl).
Imp. Vol. llnd) Vcl. IStart) AVol.lir.1)
I _y*/i - _/£fL_ - ~^vl
,? /^,f - x^^' . .J^
0
o
»4 cIL^t!)
/^ .
Total Vcl. K->o
-------
PARTICUIATE
DATA
Imp. Vol.(End) Vol. (Start) flvol.dnll
Percent Oj
Total Vol. H20
-------
-ir
PARTICUIATE
DATA
Sample
Point
1 1
\ 2-
3
1 ^
A5'
&
7
F
Time
JO
/6
/?
;3
/3
/3
n
n
Leak Check Rite 1SO>:IKFT1CE
Sampling Time
Jo
After
vac
in. Hq ft ,'min
* TEST KL'MSEt ^
DATE
OPERATOR IT i)
FurL JCc*iJl___
SITt ,jr
PROBE LOCATION /?-" /*^ c,*, /
^'^TER CONDITIONS
A P5
,vT
/J~2_
.£1
,'H
-^
^/
.65
*>
\
~
Average
.51
AH JHeter Reading
/3/
/.A,-
I-L,
If
f?rr,2T
5 7 ?* , /5"
f7/?./J
57 f z-y/
*
^5,7^
JirtPERAlURb , F
Stack
/
£5>t>
\ __
/
{
/
i/
?S6
Probe
/^^
2-Z^
Oven
3,O&
%l-O
-.fr.Dinoers
1 n i Out
Meter
*v
l^o
°2'*
Vac.
*. y
£.2-
y-S
~^cT
75
~7. Z_.
Nrrv>urrtOh Setur.
KETrR VOL.
ZliDl
" 1
1 r:'D: ' -.-.. ec-r.auo
f .",)
J7T - '/ 45
e treasure j
^ 3-f
s/
r-
tos
«'
-
Vtrccr.t O^ « 1 1
lir.= .
c
Tst>ck
Noz(ldeal). *J
»<
Jltfk "liC*
r 4O ^]
Vol.lEr.d) Vol. (Start) avol (n,ll
/^/ . /#£)
/^ . /^^
t? - ^2
c 1 End 1
Total
o'Start)
- /3£> .
0
T _
jticrams
Total Vcl. H,o
'
-------
PARTICULATE
DATA
L«ak Cheek Bat«
V.c
in. Hq ft3/
ISOKINETICS -
O
TEST NUMBER
D*TE
OPERATOR
FUEL
SITE J""
PHCBE LOCATION JJ0
'
Total g '
14 glEndl glstartl Agrams
13
Total Vol. H20 g" ml
-------
DATA
L««k Check
ISOHIKETIC? -
vac
in. Hq
OFCEATOR
FUEL
FROEE LOC
Sample
Time
METER CONDITIONS
.3
A H |Meter Heading
TEKFERATURES.
Stack
5 tO
Probe
Oven
Ir.oinoers
n Out
Meter
Vac.
//
2-
.m
A'/
3
535
,t/0 I X/J
syz-f.-ss L<
i/e)
$.J
5, /
Ver ape
Mt
too
NozCdeaJ).
In?^ Vol.(End) Vol. (start) auol
» "//^ -'.
i: (2 -
olil Vol. H,o y r
-------
PARTICULATE
DATA
t«ak Check Rate
Vac
in. Hq ft3/
ISOKINETICS
TEST NUMBER "
DATE t>-Af-7l
OPERATOR _
FUEL _
SITE _
PROBE LOCATION
TElVERAtORJES, °F
ample
oint
Time
METER CONDITIONS
AP,
A H Meter Reading
Stack
Probe
Oven
Imoinqers
In
Out
Meter
Vac.
330
3/0
7o
2.3
./*
32°
.rt
33£-2i
'. 31
2g'\336~ \2&o
67
63
2.1
Z"?
y
__^
,57-
67
2.0
2*.
*L
22*
.2*
3/76 . 7?
3178. 6f
2-7°
66
/*&
27*
3.0
3/87.
27
2-7
2.70
1
.4*
27°
23
^1
Average
METER VOL.
START
SAMPLE VOL
cpitot
Stack Press.
In. Hq-a»ut,e
Barometric
Pressure^
Montograph Setup
C
" Titack
Noi(Actual).
Imp. Vol. (End) Vol. (Start) AVol.(ml)
12
13
yg? -
/
43
14 qlEndl
Silica
Gel
. Total _&L
g(Start) Agrams
.»»
ISO
Total Vol. H2o
-------
rAKTIC'JL.-.TE
DATA
Leak Check Rate
Vac
in. Hq ft'/rein
ISOr.INTTICS -
After
TEST NUMBER
DATE S
OPIRJITOR
FUEL ___
SITE ^J~
PROBE LOC*T10Hy&V '/{^G^L /
Sample
Point
Time
2-
hETER CONDITIONS
A PS AH |Heter Reading
.2*";
55
S/
5V 7
Stack
Probe
Oven
Iir.Dinoers
In i Out-
Meter
*
Vac.
,7.7
So
T-gO
*//
.74
Average
V«7era7o7.TZI_
Nomotjraoh
C
T
Vol. lE/id) Voi. (Start)
stock .
ir
to,
o
'«> ^y
olstjrt) iorans
Gtl
44
Total Vol. Hjo
-------
PARTICULATE
DATA
Leak Chech fate
3/
V»c
in. H
ISCBcrWETICS
TEST NUNBER_
OPERATOR
FUEL
SITE
PROBE
ample
oint
Time
METER CONDITIONS
AH
Mater Reading
TEWERATORES , *F
Stack
Probe
Oven
Imoinqers
In
Out
Meter
Vac.
.7
4*.
22*2. 3&3t*
<£*_
. 33
ZS&
7*
4.7
fo
32^0
2SST
7°
J2-
7.6*
f/
//g-
ztzr
10
32-17.
-7*
/0V
3/0
2-1*
.rz-
Zff*
tl*.
72-
t*
72-
2&S*
0
Zssr
72-
s&s
7?
>*<
$.*>
3. o
Average
START
SAMPLE VO'.
Nomograph Setup
p«ter - C
I"5tac)t T»tack "
Tmeter - » -
Imp. Vol.(End) Vol. IStart)
AH,
NozlJdeaD-
12
13
/ 6T&
\ H,0 -P'/ Hoz I Actual)-
45
(7
14 qtEndl
Silica
Gel
Total __._*_:_
qI Start) &9rams
;4^ . /Jtf
Total Vol. H20
it/mi
-------
DATA
Samplino Time
Per Point , Kir,
1 '/z.
B
A
Leak Check Rate
liOV.:M7ICS
vac
in. Hg ftVmin
efore
fter
' TEST
DATE
KL'-ffiEP /
f-/(,^7<
OPERATOR ^7 ^'
FUTL
S3TE
K.C* /.
CT
PROBE LOCATION &' tf &<* A
Sample
Point
*l
2-
3
«V
6 )
2_
1 3
<-/
|
I
|
1
Time
Average
KETER VOL.
SKMPL
p,.~
UP"
Percent
METER CONDITIONS
APS
,2V
,2,?
,2-T-
.2>/
.**
3/
*/l
-V
.1*
AH
Iheter Heading
W
n~>
,£^-
t,r
.it
--§1
I.M
/,*1
.93
START!
n
r voLfl
t"j^2"^
"^W"**"
°2 '
5V-»^-7?
5^^5"5
5%-?7.^i
Sfr?2--^
5"^ 2- /, ^
Pn,
ft' p'
*l*i.6ei
Jn
AH
«
J
7E«FEWvTU?JES . T
Stack
V^O
'/^^
WO
^dff
WO
1-liO
H6t>
L/<~/0
41 <->K
Probe
/50
Ito
Ito
IZG
1 6e>
/&d
IfrO
f$6
Kcmooraoh Serur.
C
«ter xj/
tack " stack * i
ip ' ^
g - Noziia»i)>
HjO Noz(ictual). ,
'--.tt
Oven
?Mt
l~>c
2-i
/J-2-
o,,%
Imr. Vol. ant!) Vol. IStart) AVol . (ml 1
i U
1
^J,,
»;
3/6
u
J£L
V7
- A»^ . 7J
. /'^ . "7
-
7,0
37
3.5"
a
s,ii« /y^ /,'J . /^
46
Total Vol.
-------
PARTICULATE
DATA
teak Check R»te
f!3/min
JSOr.INFTICS -
v.e
in. H
TEST NVMSEJ.
DATE
OPERATOR
FUEL /
SITT
rROBE LOCATION
/<
Sample
Point
Time
METER CONDITIONS
5 1 A"
Meter Heading
TEKPERATL'RZS , 'F
Stack
Probe
Oven
Ir.oxnaers
n I Out
Meter
Vac.
,05-
2.-S
32.51.37
32-4
47
H
5
n
300
2.65
f/
, 2.
11
Tt
-71
3*5
-71
-2-iT
r
3*5
z-o
.01
5°
£5
16
/I
2,15
2-45
.OS
-3C
Cf
11-
. 65
,o7
3*5
32.72--°°
2.54
/07-
.11
/£>!-
z-o
&*
3^5
3J
JO
-11
.11
77
2*70
fs
Jf,/
2-7J
33-97
3- 5V
/'
dl
.OS
t/t
3-J
Average
METER V01-.
cirol
START
SftMPLEVOL.
T»P. Vol. lEndl Vol. (Start) flvol. Imll
ft*
CFJtot
,%n
£t*ck Press.
Tn. Hq-Cauae
Kercent O5 «
.t*'HtO
barometric
Pressure
fif.^f
Moz (Ideal)-. ,
»oz(Artu«J>-
/
/J<)
6)
&
5-3
41?
c (Start) ^Zicrar.s
/£^_ . /c;
Tct«l Vol. H,o ^ 7 r.j
-------
PARTICULATE
DATA
-------
FARTICUIATE
DATA
aX Check Rate
v.c
in. Ho nj/
1SOKINETICS -
TEST Nl'«8ER_
DATE
OPERATOR
FUEL
SITE
FHOBE LOCATIO
"y
ample
Point
Time
METER CONDITIONS
A Ps I AH |Heter Reading
«
Stack
Probe
Oven
Imoinqer;
I n I Outl
Meter
Vac.
,2-1-
33 a /
2,7
-8-6)
2-65
,77
£<-/
25
-73
2-3*
f-V
-T.-1-
33' ^.-5
33/7,5-5-
3.7
Jo
3-5"
..53
3 S3
3.1-
to
(,55
C5
$.3
11
333-*- //
270
I
&.
o
ul
41
V)
..10
33^532.
.7*1
/of
34
^5_
,7-5
71
If
33V5.V/
f*
75
7/
,2-0
? 3 5"^ T5
J35~^
.51 \ 3
_^L
//
/^
Average
- 5V
3^5
IS
_U_J_/£..
,'tft-
fc
37
Vol. (?tart) AVo3 . frll
f^TTErv V01-.
SA^^ji l«=3
' ' tCt ^. L.^_r.aimw V?
\::r::i:.. TJ
- f
;/^5,
0
/;
7
f r
49
-------
PARTICULATE LAB WORKSHEET
TEST N0._
Date
(Inlet, Outlet)
Box No.
Test Description
LOCATION
Eng.
Dry Gas Meter Vol (ft3)
Final
Initial
A DgV
Final
Initial
A Vic
Impinger Water Vol (ml)
1
2
3
Total
CONTENT
BOTTLE NO.
BEAKER NO.
H20 RINSE
ACETONE
RINSE
DRY
FLASK
FILTER
NO.
BLANK
NO.
DATE WT.
TARE WT.
Y-
\
&S73
AVG.
\
POST TEST WTS
\
V
044-7
AVG.
\
0.
A WT.
0,
A Vic
A DgV
A Mn
ml
LOAD
klb/hr
mgro
REMARKS:
SO
8830-5
-------
PARTICIPATE LAB WORKSHEET
TEST NO. /
Date
(Inlefe, Outlet)
Box No-
Test Description
LOCATION_
Eng.
Dry Gas Meter Vol (ft3)
Final
Impinger Water Vol (ml)
Initial_
A DgV_
Final
Initial
A Vic
1
2
3
Total
CONTENT
BOTTLE NO.
BEAKER NO.
DATE WT.
TARE WT.
1
2
3
4
AVG.
H20 RINSE
\ /
\ /
\ /
V
A
/ \
/ \
/ \
ACETONE
RINSE
26
J7.02&/
TZeZAZ-
17. »26t>
47.076^
DRY
FLASK
\ /
\ /
\ /
V
A
/ \
/ \
/ \
FILTER
NO.
z.
-
. 7*?o
. 7*#2-
.-?eez
*n&8*-
BLANK
NO.
\
V
\
\
/
/
/
/
/
/
/
/
\
\
\
\
POST TEST WTS.
\
V
*:
^v
V
V
.0833
&KV^_
i WT.
0.
A Vic =
A DgV =
A Mn
ml
\
LOAD
kUD/hr
%
REMARKS:
51
8830-5 rev.
-------
PARTICULATE LAB WORKSHEET
TEST NO. 2-
Date 6V-
(Inlet, Outlet)
Box No.
LOCATION^
Eng.
7"
Test Description
Dry Gas Meter Vol (ft3)
Final
Initial
Impinger Water Vol (ml)
A DgV
Final
Initial
A Vic
1
2
3
Total
CONTENT
H2O RINSE
ACETONE
RINSE
DRY
FLASK
FILTER
NO.
BLANK
NO.
BOTTLE NO.
/
BEAKER NO.
\
e
\
DATE WT.
\
\
TARE WT.
\
.7373
\
\
AVG.
'7373
POST TEST WTS
\
,0 4.6 131
.0672.
7
AVG.
\
ffi'7
A WT.
\
A Vic =
A DgV =
A Mn
ml
mgm
LOAD
REMARKS:
klb/hr
%
52
8830-5 rev.
-------
PARTICULATE LAB WORKSHEET
TEST NO.
Date
et)
Box No.
LOCATION_
Eng.
Test Description_
Dry Gas Meter Vol (ft3)
Final
Initial_
Impinger Water Vol (ml)
A DgV_
Final
Initial
A Vic
1
2
3
Total
CONTENT
H2O RINSE
ACETONE
RINSE
DRY
FLASK
FILTER
NO.
BLANK
NO.
BOTTLE NO.
BEAKER NO.
m» 32.
\
DATE WT.
TARE WT.
i
2
Y
ZV
.-74-7**
. 7660
\
X
AVG.
7 7.
POST TEST WTS.
55
8830-5 rev.
-------
PARTICULATE LAB WORKSHEET
TEST NO._
Date
(Inlet, Outlet)
Box No.
Test Description
LOCATION_
Eng.
jr
Dry Gas Meter Vol (ft3)
Final
Initial
A DgV
Impinger Water Vol (ml)
Final
Initial
A Vic
1
2
3
Total
CONTENT
H20 RINSE
ACETONE
RINSE
DRY
FLASK
FILTER
NO.
BLANK
NO,
BOTTLE NO.
^
BEAKER NO.
S
3V
\
D~TE WT.
\
TARE WT.
\
f 5". f 773
\
AVG.
POST TEST WTS.
\
\
X
24 se
6337
J,
AVG.
\
A WT.
\
6.226*
A Vic =
A DgV =
A Mn
ml
mgm
LOAD
klb/hr
%
REMARKS:
56
883°-5 rev.
-------
PARTICULATE LAB WORKSHEET
/n&
TF-^T NO. &
cfr
( Tnlot i O"4"1 ~*-x
Date 6-J3-73 Bo:
Test Descr.
Dry Gas Me
Final
Initial
A DgV
CONTENT
BOTTLE NO
,.
BEAKER NO
DATE WT.
TARE WT.
AVG.
L
< No.
LOCATION £;Je. j~
Eng.
Lption
ber Vol (ft3)
i. i -
.
1
2
"
3
4
.i ' '
1
2
3
4
AVG.
A WT.
A Vic
A Dg\
A Mn
H2O RINSE
\ /
\ /
\ /
V
A
/ \
/ \
/ \
v /
\ /
\/
A
/ \
/ \
Impinge r Water Vol (ml)
1 2
Final
Initial
ACETONE
RINSE
33
/*4- 3&>9
/e>4- 357 /
J04- 357<{
/o 4. ££"//
A Vic
3 Total
DRY
FLASK
\ /
\ /
\7
Y
A
/ \
/ \
/ \
POST TEST WTS.
/ & IT ^t\S £~
/e>tf..4*°l>
/D^. 48 it
/*4.
O. /27*5~
\ /
\ /
V
A
/ \
/ \
FILTER
NO.
. ,
&
.-7£--Z^~
+ ~7^> £"*^
**l^~~TtJ
* ^J &§
*< 75~25"
BLANK
NO.
\
\
\
/
/
/
/
/
/
/
\
\
\
\
,*IZM
. ?2**
. f^72
.1z6J
0.i744
\
\
\
/
/
/
ml LOAD klb/hr
r = ft3 0? %
3o3. ^ mgm REMARKS:
/
/
/
\
\
\
57
8830-5 rev
-------
PARTICULATE LAB WORKSHEET
TEST N0._
Date
(Inlet, Outlet)
Box No.
Test Description
LOG ATI ON
Eng.
J~
Dry Gas Meter Vol (ft3)
Fi na1
Initial
A DgV
Final
Initial
A Vic
Impinger Water Vol (ml)
1
2
3
Total
CONTENT
H2O RINSE
ACETONE
RINSE
DRY
FLASK
FILTER
NO.
BLANK
NO.
BOTTLE NO.
\
BEAKER NO.
38
\
DATE WT.
TARE WT.
Y
,73*4
^
/o 4 -
\
\
AVG.
\
POST TEST WTS.
/
V
AVG.
\
A WT.
e.
A Vic =
A DgV =
A Mn
ml
LOAD
mgm
REMARKS
klb/hr
%
58
8830-5
-------
PARTICULATE LAB WORKSHEET
TEST NO. 7
Date
Test Description
(Inlet, Outlet)
Box No-
LOCATION
Eng.
Dry Gas Meter Vol (ft3)
Fi na1
Impinger Water Vol (ml)
Initial_
A DgV~
Final
Initial
A Vic
1
2
3
Total
CONTENT
BOTTLE NO.
BEAKER NO.
DATE WT.
TARE WT.
1
2
3
4
AVG.
H2O RINSE
\ /
\ /
\ /
V
A
/ \
/ \
/ \
ACETONE
RINSE
31
7 3 . ^-7-2^
?-.S7'/
f£~.S-?°3
-
i&.&Ul
DRY
FLASK
\ /
\ /
\ /
V
A
/ \
/ \
/ \
FILTER
NO.
/#
. -2S*/*
. ?s*e
7S*t>
. *7S&0
BLANK
NO.
\
\
\
\
/
/
/
/
/
/
/
/
\
\
\
\
J_
2
POST TEST WTS.
X
*
\
X
%
. §411
AVG.
46*. 6*88
A WT.
0,0377
\
A Vic =
A DgV =
A Mn
ml
mgm
LOAD
REMARKS:
59
8830-5 re-
-------
PARTICULATE LAB WORKSHEET
256P**/*"
TEST NO. 8 (Inlet,
Outlet) LOCATION *>fjt J"
Date Box No. Eng.
Test Description
Dry Gas Meter Vol (ft3)
Final
Initial
A DgV
CONTENT
BOTTLE NO.
BEAKER NO.
DATE WT. '
TARE WT. 1
2
3
4
AVG.
H20 RINSE
\ /
\ /
\ /
V
A
/ \
/ \
/ \
Impinger Water Vol (ml)
1 2 3 Total
Final
Initial
ACETONE
RINSE
-
4*
7?. e*44
*T f ^ 0 ^TrC?
17. o&44
"
41. oz4^
A Vic
DRY
FLASK
31
'
/*=r. :z//£
/&s: z//£-
/*^.&//8
/^57^/Xrf"
FILTER
NO.
/*
-
.7344
.734?-
-73S-7
.7341
\
BLANK
NO.
\
\
\
\
/
/
/
/
1
~~7_
/
/
/
^___
\
_\_
\
POST TEST WTS.
1
2
3
4
AVG.
A WT.
\ /
\ /
Y
/\
/ \
/ \
17. /618
11. /b13
47./W
fU^Hr
0-J4i>7
/ff&.SS/0
/0$:s&i
/*s~.s*t4
*
/*5",5*//
0. 3&1I
. es?fs-
.6^47
, 6S3~7
.0S~43
0- /2o2-
\
\
N.
/
/
/
A Vic = ml LOAD klb/hr
A DaV = ft3 Oj %
A Mn 432. . 9 mgm REMARKS :
S>
/
/*
\
S^
\
60
8830-5
rev
-------
PARTICULATE LAB WORKSHEET
TEST NO. P __
Date _
Test Description_
(Inlet, Outlet)
Box No.
LOCATION_
Eng.
Dry Gas Meter Vol (ft3)
Final_
Initial_
Impinger Water Vol (ml)
A DgV_
Final
Initial
A Vic
1
2
3
Total
CONTENT
_,
BOTTLE NO
.
BEAKER NO .
DATE WT.
TARE WT.
1
2
3
4
AVG.
H20 RINSE
\ /
\ /
\ /
V
A
/ \
/ \
/ \
ACETONE
RINSE
4*
*r.*»+f
1S~.0/*t>
*£ o*9 1
fST^?^
DRY
FLASK
\ /
\ /
\ /
y
A
/ \
/ \
/ \
FILTER
NO.
//
,:5^/2.
.Sj/°
.s*?0&
.f-y/e
BLANK
NO.
\
\
\
\
/I
/
/
/
/
/
/
/
\
\
\
\
POST TEST WTS.
\
S
/
2
r -
AVG.
.7*43
A WT.
a.
A Vic =
A DgV =
A Mn
ml
LOAD
Oo
mgm
REMARKS:
klb/hr
%
61
8830-5 rev
-------
PARTICULATE LAB WORKSHEET
TEST N0._
Date
(Inlet, Outlet)
Box No.
Test Description
LOCATION_
Eng.
Dry Gas Meter Vol (ft3)
Final
Initial
A DgV
Final
Initial
A Vic
Impinger Water Vol (ml)
1
2
3
Total
CONTENT
BOTTLE NO.
BEAKER NO.
DATE WT.
TARE WT.
1
2
3
4
AVG.
H20 RINSE
\ /
\ /
Y /
V
A
/ \
/ \
/ \
ACETONE
RINSE
£*>
/fV. 4-S7&
/0*J-> 4$T?
/£>4,e&7l>
/o 4. 4577
DRY
FLASK
41
so. 3/1
&>. 83/°
&>. 3^6
jD.eseq
FILTER
NO.
X-7
.-?e
.-7&1S
.7^7
,78
BLANK
NO.
\
\
\
\
/
/
/
/
/
/
^
\
V
N^
\
POST TEST WTS.
V
/\
crt>2£
002-6
\
\
AVG.
\
A WT.
0.
A Vic =
A DgV =
A Mn
ml
mgro
LOAD_
°2_
REMARKS:
62
8830-5
rev.
-------
PARTICULATE LAB WORKSHEET
TEST NO.
Date
Test Description_
(Inlet, Outlet)
Box No.
LOCATION_
Eng.
Dry Gas Meter Vol (ft3)
Final
Impinger Water Vol (ml)
Initial
A DgV_
Final
Initial
A Vic
1
2
3
Total
CONTENT
BOTTLE NO.
H2O RINSE
ACETONE
RINSE
DRY
FLASK
FILTER
NO.
BLANK
NO.
BEAKER NO.
DATE WT.
TARE WT.
1
IBli
2
\
V
\
I
X
K
AVG.
POST TEST WTS
AVG.
\
Y
o/ze
\
V
.7037
A_WT._
A Vic =
A DgV =
A Mn
ml
LOAD
klb/hr
%
mcjm
REMARKS:
63
8830-5
-------
PARTICULATE LAB WORKSHEET
TEST N0._
Date
(Inlet, Outlet)
Box No.
Test Description
LOCATION_
Eng.
Dry Gas Meter Vol (ft3)
Fi na1
Initial
A DgV
Final
Initial
A Vic
Impinger Water Vol (ml)
1
2
3
Total
CONTENT
H20 RINSE
ACETONE
RINSE
DRY
FLASK
FILTER
NO.
BLANK
NO.
BOTTLE NO.
BEAKER NO.
\
z/
DATE WT.
\
TARE WT.
V
.0 II 2,
\
\
16*.
63.3770
\
AVG.
\
POST TEST WTS.
\
A
\
V
A
%^y.2/gy
,
AVG.
A WT.
\
A vie
A DgV
A Mn
272^.7
ml
ft3
LOAD
klb/hr
REMARKS:
8830-5
rev.
-------
PARTICULATE LAB WORKSHEET
TEST NO.
Date
(Inlet, Outlet)
Box No.
LOCATION_
Eng.
JT
Test Description
Dry Gas Meter Vol (ft3)
Fi na1
Initial
A DgV
Final
Initial
A Vic
Impinger Water Vol (ml)
1
2
3
Total
CONTENT
H20 RINSE
ACETONE
RINSE
DRY
FLASK
FILTER
NO.
BLANK
NO.
BOTTLE NO.
\
BEAKER NO.
I
DATE WT.
X
X
\
TARE WT.
l
2
v
A
/^
-------
SECTION 3,0
GASEOUS DATA
PAGE
3,1 GASEOUS EMISSION SUMMARY 67
3,2 GASEOUS EMISSIONS DATA SHEETS 68
3,3 SOx DATA SHEETS 81
65
-------
GASEOUS EMISSION SUMMARY
Location:_
Fuel:
TEST
NO.
DATE
LOAD
CONDITIONS
02
%
Dry
co2
%
Dry
CO
ppm
Dry
NO
ppm
Dry
N02
ppm
Wet
HC
ppm
Wet
Dry
co
Dry
CO
ppm
Dry
NO
ppm
Dry
so2
ppm
Dry
so3
ppm
Dry
NOTES
01
Y&Z.
Ort'O
£7
ooS
7' 3
73-8
*/
151
f-/
7*
r
3S7
Z41
1-1
1-7
l
/
S
T1&
14
1.0
t^
7/1
7< a
i*
47-1
/
Z3I
V
r-?
V
NOTE: All parts per million (ppm) figures are corrected to a 3% 02 constant dilution factor
#15900
-------
KVB
GASEOUS EMISSIONS DATA
TEST SITE -J
TEST NO j_
DATE ^~
FUEL
LOAD_
CONDITIONS_
DATA TAKEN BY
-JOB
Probe
Position
Time
02
C02
CO
ppm(dry)
NO
ppra ( dry )
HOT LINE SAMPLES, PPM (WET)
NOx
NO
cor
NO?
HC
REMARKS
tsr
10 3
/o.
180
10.
I
n -re
13-
It*
^(t-
28*
AVERAGES
13
(0.1
w///,.
w///,
w///,
NOTE: Parts per million (ppm) figures are corrected to 3%
68
15900
-------
TEST SITE_
TEST NO
DATE
KVB
GASEOUS EMISSIONS DATA
FUEL
LOAD_
CONDITIONS_
DATA TAKEN BY
^J-
Probe
Time
02
%
(dry)
C02
%
(dry)
CO
ppm(dry)
NO
ppm ( dr y )
HOT LINE SAMPLES, PPM (WET)
NOx
NO
NOo
HC
REMARKS
w.r
oo
IS
80
iTQ.f
2.1
79
II 0
7-8
300
tt.S
1/8
XU8
o
JT
IOJ
ISO
HO
I/O
uu
M.
/O
/6
(0.
30.1
lO.o
180
8.H
lO.i
J8P
I'M
3IO
iro
ts.v
,0.7-
8.0
no
336
3VJ
II 0
307,1
liU
To
AVERAGES
zm,
NOTE- Parts per million (ppm) figures are corrected to 3% 02
69
15900
-------
KVB
GASEOUS EMISSIONS DATA
TEST SITE
TEST NO "
DATE
- 7
FUEL_
LOAD_
CONDITIONS_
DATA TAKEN BY
Probe
Posi tion
Time
(dry)
CO2
%
(dry
CO
pom (dry)
NO
ppm(dry)
HOT LINE SAMPLES, PPM (WET)
NOx
NO
NOi
HC
REMARKS
ttt)
+5
170
/o./
/f
H.3
8.0
II -a
7,3
/Vo
0
1LLO
'
>V
7.0
10.8
AVERAGES
NOTE: Parts per million (ppm) figures are corrected to 3% O2
70
15900
-------
KVB
GASEOUS EMISSIONS DATA
TEST SITE
TEST NO
DATE (
jr
f
1- L - 7T
FUEL (
LOAD 7^
CONDITIONS 4
«C-1
OK
r*
-------
KVB
GASEOUS EMISSIONS DATA
TEST SITE_
TEST NO =$
DATE
-------
KVB
GASEOUS EMISSIONS DATA
TEST SITE
FUEL
TEST NO fe
DATE L -/3 -7?
LOAD ?. *» o
CONDITIONS *
DATA TAKEN BY /T^T
AVERAGES
/0-I
.*!
^^
NOTE:
Parts per million (ppm) figures are corrected to 3% 02
73
15900
-------
TEST SITE_
TEST NO j
DATE d
KVB
GASEOUS EMISSIONS DATA
FUEL
LOAD (,!-. 00*
CONDITIONS_ ** fU^-i
DATA TAKEN BY
Probe
Position
Time
02
CO?
\
(dry
CO
ppm(dry)
unc cor
NO
pomldrv)
unc cor
HOT LINE SAMPLES, PPM (WET)
NOx
unc cor
NO
unc cor
NO?
unc cor
HC
unc cor
REMARKS
c*k
ail
1.Q
/BO
CqL
Tt
USJ
14
11*
ff!
11
I,1!
r
TV
Uo
^^l
mo
iirm
t.r
1.7
lio
I'-OO
IflJ
8.0
10.1,
AVERAGES
176
NOTE: Parts per million (ppm) figures are corrected to 3% o?
74
15900
-------
KVB
GASEOUS EMISSIONS DATA
TEST SITE
TEST NO
DATE
FUEL
LOAD .50
CONDITIONS_ 9
DATA TAKEN BY
Probe
Time
02
t
(dry)
C02
t
(dry)
CO
ppm (dry)
NO
ppm (dry)
IU
HOT LINE SAMPLES, PPM (WET)
NOx
fa
NO
NO?
HC
REMARKS
1.1
n
10
1.H
11
ni
air
it
IHL
j'.r
ao
iro
AVERAGES
W///,.
7'V
tLL-
wm
J
WM
NOTE" Parts per million (ppm) figures are corrected to 3%
75
15900
-------
KVB
GASEOUS EMISSIONS DATA
TEST SITE
TEST NO
DATE
FUEL
LOAD
CONDITIONS
DATA TAKEN BY
Probe
Position
Time
02
C02
t
(dry
CO
ppm(dry)
NO
ppm(dry)
HOT LINE SAMPLES, PPM (WET)
NOx
NO
NOo
HC
REMARKS
WO
u.x
(05- <5
r1-
$
1(30
1118
'1.0
urr
-f
rn:?t2i
IU
H.1
IV I
in
ur*
IfS
150
ort
nr
13,0
rs
AVERAGES
ILL
NOTE: Parts per ndllion (ppm) figxires are corrected to 3% 02
76
15900
-------
KVB
GASEOUS EMISSIONS DATA
TEST SITE ^
TEST NO )3
DATE &'>-,'', 'v
FUEL C'iui. Ct*l
LOAD *""v "7o fl^y^,^
CONDITIONS ,-,f V^,^?
Hk^M-r W '/>
DATA TAKEN BY
Probe
Time
02
%
(dry)
C02
%
(dry)
CO
ppm(dry)
line cor
NO
ppn ( dry )
HOT LINE SAMPLES, PPM (WET)
NOX
NO
NO-j
HC
REMARKS
Ki.
Md
not*
-7,5
Ml
224,
no
y/.z-
I 10
Ktile-^
*!
(O.d
f.lo
AVERAGES
Z17
NOTE:
Parts per million (ppm) figures are corrected to 3% 02
15900
-------
KVB
GASEOUS EMISSIONS DATA
TEST SITE_
TEST NO
DATE
FUEL_
LOAD_
CONDITIONS
DATA TAKEN BY
Probe
Position
Time
02
%
(dry
C02
%
(dry
CO
ppn(ary)
unc cor
NO
ppn(dry)
HOT LINE SAMPLES. PPM (MET)
NOx
NO
NOT
HC
REMARKS
>?.*
3:5
1-7
-**»&
AVERAGES
lii
-mm
NOTE: Parts per million (ppm) figures are corrected to 3% 02
76
15900
-------
KVB
GASEOUS EMISSIONS DATA
TEST SITE_
TEST NO
DATE
/r
*-??
FUEL_
LOAD_
CONDITIONS
6*.
DATA TAKEN BY
Probe
Time
02
%
(dry)
C02
%
(dry)
CO
ppm(dry)
NO
ppm(dry)
unc cor
HOT LINE SAMPLES, PPM (WET)
NOx
NO
NO-)
HC
REMARKS
rfoo
IT-*
fr'r
/*
(to
/£><
/?&>
AVERAGES
Jll
NOTE: Parts per million (ppm) figures are corrected to 3% 02
159OO
-------
KVB
GASEOUS EMISSIONS DATA
TEST SITE_
TEST NO
DATE
-J
FUEL_
LOAD_
CONDITIONS_
DATA TAKEN BY
Probe
Position
Time
02
\
(dry
C02
t
(dry
CO
ppm(dry)
unc cor
NO
ppm(dry)
HOT LINE SAMPLES, PPM (WET)
NOx
NO
NO->
HC
REMARKS
7-
.Sir
at*
AVERAGES
y-v
fin
T7
w///,
NOTE: Parts per million (ppm) figures are corrected to 3% 02
80
15900
-------
Local
SOx DATA SHEET
Date L ' Probe Location & Probe Length v3' - A/KJ /fcfi'T"
Unit « Fuel ^CtffJT^^f^y
I^oad _'-. V ' '
Test Description:
Test
NO.
/ /:-t
-,
Box
No.
-7
/
Sample
Time
/S'W
/6-5V
// -£*
^-3y
17:00
n /i-
Meter
Temp .CTy)
47
fy
f 3
ft
^
ft
Meter
- *<>
0 OCt)
/.00G
Press.
/
\
/
,
Port
5 -foe <:
f
/
Purge
Time
2# 0 '
/6 35'
*<>,U-
l?-/$
2^ ti
02
*
SAMPLED BY
Test #
Test
Normality N
Dilution
Factor F
Blank B
Averages
Ml- of
Titrant A
Averages
460 + T
Sample
vol. V
P + p
A - B
SO2
i /tt/
Glut
j.5
5.t/
N
CO
Q
u
H
(A-B) (N) (F)(460+T) (24)
SO2 ~ y (p^pj
1>O^ ( :) ( )
4^^"
SO2 = |_£*/'»J | SO3 *-'
( ) ( ) ( ) ( ) 24
( ) ( )
SO? 0 3% 02 = /^^ 'i
SO"? @ 3% 02 = ,,:,/
crw @ 3% 02 = <3 it,
^ \' )(''')"(**)(* )24
S02 = e;"7
.3 ()()()( )24
( ) ( )
S03 = 2.YS
S02 @ 3% 02 = / / 5'/ 5
S03 @ 3% 02 = "^ '
SOx @ 3% 02 ~= ' ? ^±
mi ,*
SO2 = £{i,r
~, ' ( ) ( ) ( ) ( ) 24
( ) ( )
£03 - 3 j"
SO2 @ 3% 02 = "ft'lS-'
S03 @ 3% 02 = 3V c/
SOx P 3% 02 = . ^ <;' C
-------
Date 6-30~'70l
Unit ft
SOx DATA SHEET
Probe Location s, Probe Length
Fuel
3
Load
Test Description:
Test
No.
/M.
/*«
,u
Box
No.
3
'
(
Sample
Time
/3: 3^
/a; V7
/
t.ffbe
/' "2-f°
Press.
*!.*,
\
4'.37
/v;a-7
/s: z-5"
ts-.So
02
m
o
S
en
Test #
Test # /^j
Test #
Normality N
Dilution
Factor F
Blank B
Averages
Ml. of
Titrant A
Averages
460 + T
Sample
Vol. V
P + p
A - B
SO2
.*/»$
2J>
-,
~
..
il.l
It-t
//.e
//.*
5^/
I.V*
Z1&
11.9
SO 3
/
At
Af
-7
-7
-»
A1
SOx
SO2
Z«»
ll.Z.
It. -3
//^
t/.T-
«3
/.*<*>
»r^
//.*-
S03
/
/»
/ *
»
Lr
r-^
/*
SOX
SO2
^"
/V.3
t4-3
14.1,
/v:3
rii
/. 20^
2-f.r^ -
/4.3
SO3
/
2/2-
2.2L,
?
»
2,*
SOx
I
S02
S02 "
S02 -
SO3 =
(A-B)(N)(F)(460+T)(24)
V(P-tp)
( ) ( ) ( ) ( ) 24
S03
( )( )24
SO2 @ 3% 02
S03 @ 3% 02
SOx @ 3* 02
SO2
SO2
)24
)24
S02 @ 3% 02 =
S03 @ 3% 02 =
SOx @ 3% 02 =
Jt-t
JiV
S02 = ( >< X X >24
( X )( )( )24
S02 =
S03
SO 3
S02 @ 3% 02 =
S03 @ 3% 02 =
SOx @ 3% 02 =
-------
SECTION 4','Q
PARTICLE SIZE DISTRIBUTION
EM
4,1 BRINK 84
4,2 SASS 90
83
-------
KVB
BRINK CASCADE IMPACTOR DATA SHEET
TEST NO.
TEST SITE
TEST DATE
/ **
T
t-it-71
LOAD "?£> O&& ^^ /f4K.
% 02 ?># (Q
FUEL OfatO
SAMPLE LOCATION
SPECIAL CONDITIONS
GAS VELOCITY DETERMINATION
PITOT TUBE AP
GAS TEMP. °R, Ts
BAROMETRIC PRESS in. Hg, Pbar
GAS STATIC PRESS in. H2O ^ /,-y
PITOT CORRECTION FACTOR, Cp
GAS STATIC PRESS in. Hg abs~Ps
MOLECULAR WT. FLOE GAS , MWS 2& .
Vs
85.48CP
MWs
ft/sec
IMPACTOR FLOW RATE DETERMINATION
NOZZLE DIAMETER inches, Dn
NOZZLE AREA ft2, An /
x/»"
Q9 = Vs An 60
Qc = Qs
An = 7T(Dn/24)2
at nozzle
ft3/min corrected to calibration conditions
PRESSURE DROP ACROSS IMPACTOR FROM CALIBRATION CURVE
OPERATING VACUUM (corrected for static pressure of duct)
ISOKINETICS DETERMINATION
2^
in . H o
INITIAL
FINAL
A
SAMPLE
TIME (6)
ffW
^/? '-
_. . ' <:*
METER
READING (Vm)
I.Cf-
METER
TEMP (Tm)
0*
84
%H20 =
1.667 Ts Vm
6 Tm Vs Ps
#15900
-------
KVB
BRINK CASCADE IMPACTOR LAB WORKSHEET
TEST No. /3
TEST DATE i~l^~79
^n.
LOCATION *&/'₯C. J~ gSt/Pffttr 8*
3. ^f&&5~
g.£O&4>
2
<3.*f*7
3.^f^7
3.o1°7
3
3.f7fZ-
3.771/
3*l
FINAL
FILTER
.~37*
.034*
.0371
POST TEST WEIGHTS (GRAMS)
DATE WT.
GROSS WT.
1
2
3
4
AVERAGE
./Z66
./^££
./Z*7
2. S/e*
3 4T/07
3.tr/o^2
a f»«
5. 7»cs-
^ f ^^r
3.18*4
3.-?7
-------
TEST NO.
TEST SITE
TEST DATE
SAMPLE LOCATION
KVB
BRINK CASCADE IMPACTOR DATA REDUCTION
/3> LOAD ?Q£>f>c. Llt//t4K.
^-r % o,
6-1^-7^ FUEL
Mf>j?
/*
<^^
SPECIAL CONDITIONS «riS
Pp - Density of particles 2-f
V - Viscosity of flue gas ^
g/can3
-V
£_ poise
Vm - Dry gas volume
Mn - Total particulate mass
SCP
- Molecular wt. flue gas ?f-" r g/g mole Cn - Total concentration
't-f inH2O I - Percent isokinetics
in. Hg Vs - Gas velocity
°R Dn - Nozzle diameter
O 070 ft
AP_ - Pressure drop across impactor
Ps - Absolute stack pressure
Ts - Absolute stack temperature
Qs - Actual flow rate at stack conditions
Stage Number
Dj - Jet Diameter, cm
Fj - Press, factor, n.d.
DS,J£ Stokes diameter, ura
D. ^ Aerodynamic
diameter, um
DAL^ Aerodynamic impac-
tion diameter, um
An - Particulate mass, mgm
% - percent of Total
Cumulative percent
Cn - Concentration,
grains/SCF
Cumulative concen-
tration, grains/SCF
CYCLONE
024*0
0-01/0
V-78
2.1
1*4
Mo
!*>
Zej
a
+&ST
Lit
f-4
0-1177
e.g.
FINAL
FILTER
#15900
-------
TEST NO.
TEST SITE
TEST DATE
SAMPLE LOCATION
KVB
BRINK CASCADE IMPACTOR DATA SHEET
LOAD 2
% ©2 1'
FUEL
SPECIAL CONDITIONS_
GAS VELOCITY DETERMINATION
PITOT TUBE AP
GAS TEMP. °R» Ts
PITOT CORRECTION FACTOR, Cp_
«=*«*
BAROMETRIC PRESS in. Hg,
GAS STATIC PRESS in. H2O
GAS STATIC PRESS in. Hg absyPs
MOLECULAR WT. FLUE GAS, MWS
ft/sec
. 97
IMPACTOR FLOW RATE DETERMINATION
NOZZLE DIAMETER inches, Dn
NOZZLE AREA ft2, An
An = ir(Dn/24)2
On
Vs An 60
!.3Ts
PRESSURE DROP ACROSS IMPACTOR FROM CALIBRATION CURVE
ft3/min at nozzle
corrected to calibration conditions
/*9 in. H0O
INITIAL
FINAL
A
SAMPLE
TIME (6)
4£>
METER
READING (Vm)
f>fflfi>
l.llf
METER
TEMP (Tm)
^fc
«7
"or static pressure
___ ^__ ^_^_____ ^
of duct) 1.° in. H^O
ISOKINETICS DETERMINATION
?ER
IG (Vm)
D
it
METER
TEMP (Tm)
8
-------
KVB
BRINK CASCADE IMPACTOR LAB WORKSHEET
TEST No.
TEST DATE
LOCATION
ENGINEER
TEST DESCRIPTION
PRE TEST WEIGHTS (GRAMS)
PLATE NO.
CYCLONE
FINAL
FILTER
DATE WT.
\
o
TARE WT.
j.jiyi'A
J.V?//
**&&
7u3»y
25
9.2.7*1
.0^76
AVERAGE
3.2-707
.0377
POST TEST WEIGHTS (GRAMS)
DATE WT.
GROSS WT.
3. 4132-
3. 27/y
3.417*
3.
.3.*7/t
3.417*
3.4641
3.302°
3.
V
3.
,0362.
AVERAGE
3.4132.
3.27/f
3. 3*2.0
NET TEST RESULTS (MILLIGRAMS)
NET WT.
PERCENT
TOTAL NET
*'«>£
/J.fr
**>/*
?2-7
WEIGHT "M mqm
^.««>//
2^
A^ff
'l-i
^.«»f>V
f'/
Ml conn
-------
KVB
BRINK CASCADE IMPACTOR DATA REDUCTION
TEST NO. /3
TEST SITE JT
TEST DATE ^-/f-7*/1
SAMPLE LOCATION 3TAf/<
PP
y
MWs
Ps
TS
Qs
- Density of particles 2 ^~
- Viscosity of flue gas 2 j2
- Molecular wt. flue gas 7f
g/cm3
vt/
*'o poise
6 T 9/g mole
LOAD ~7i',&GO *~ /t+fl
% O2 7^%
FUEL Chic, (^W
SPECIAL CONDITIONS AS fi*^t
Vm - Dry gas volume SCF
Mn - Total particulate mass mgm
grains
Cn - Total concentration ?
ov^r
- Pressure drop across impactor f5~ °R
conditions o '
Vs - Gas velocity ft/sec.
Dn - Nozzle diameter in.
--V7 ft3/min
Stage Number
Dj - Jet Diameter, cm
Fj-Press, factor, n.d.
Ds,?5 Stokes diameter, ym
DA,56 A61"0^"3111^0
^ diameter, ym
DAI.53 Aerodynamic impac-
tion diameter, ym
! f
£>,
t3
0-0
2 "if
331
il-l
£37
7
//v
<> 71
/.to
/t
27.3
J 41
Oil
18.1
FINAL
FILTER
c.4
f 1
89
#15900
-------
KTVOB
SITE J
SASS GRAVIMETRICS
Test 15
10y
3U
1U
Filters
Total
0.4739
0.1265
0.1979
0.6897
0.4249
1.9129
24.77
6.61
10.35
58.27
100.00
% Passing
75.23
68.62
58.27
0 -
Test 16
lOy
3VJ
1U
Filter
Total
0.2905
None
0.2358
0.9975
1.5238
19.06
80.94
80.94
65.47
0
90
A Research-Cottrell Company
-------
SECTION 5,0
FUEL AND ASH ANALYSIS
PAGE
5,1 COMMERCIAL TESTING ANALYSIS 92
5.2 COMBUSTIBLE ANALYSIS 117
5,3 COAL SIEVE ANALYSIS 118
91
-------
F 462
COMMERCIAL TESTING & ENGINEERING CO.
GENERAL OFFICES: 228 NORTH LA SALLE STREET, CHICAGO, ILLINOIS «oe01 AREA CODE 312 T2A-4434
PLEASE ADDRESS ALL CORRESPONDENCE
16130 VAN DRUNEN RD., SOUTH HOLLAND IL 60473
OFFICE TEL. (312) 264-1173
KVB
A Research-Cottrell Company
6176 Olson Memorial Highway
Minneapolis, MN 55422
June 28, 1979
Sample identification
by KVB
I'ind of sample
. eported to us
Sample taken at
Sample taken by
Date sampled
Date received
Coal
KVB
6/23/79
Test No. l
Sample: Ohio Coal
Test Site: J
Analysis report no. 71-34526
PROXIMATE ANALYSIS
As Received
Dry Basis
% Moisture
% Ash
% Volatile
% Fixed Carbon
Btu/lb.
% Sulfur
2.89
6.31
37.43
53.37
100.00
13572
1.06
xxxxx
6.50
38.54
54.96
100.00
13976
1.09
FUSION TEMPERATURE OF ASH
Reducing
Oxidizing
Initial Deformation
Softening (H = W)
Softening (H = ttW)
Fluid
Original Copy W«t*rnurk«d
For Your Protection
xxxx
xxxx
xxxx
.;xxx
xxxx °F
xxxx °F
xxxx "F
xxxx °F
Respectfully i
COMMEP
nltted,
H -- Ccn. Height
W Cone Width
NQINEERINQ CO.
R. A. HOUSER, Manager, Midwest Division
RAH/ br
SO. HOLLAND. IL WLLINO*. MT IMMINOHAM. AL CMAHLESTON. WV CLAMKWUNO. WV >CLCVtL*NO. OH DCHVIM, CO OOLOIN. CO
HI MOf MOM, KV MIOOLEHOHO. KV HKMILE. AL NIW ONLf ANf. LA NOD FOLK. VA PIKEVILLE. KV VANCOUVER. £. CAN.
-------
F 462
COMMERCIAL TESTING & ENGINEERING CO.
GENERAL OFFICES: 221 NORTH LA SALLE STREET, CHICAGO, ILLINOIS 60601 AREA CODE 312 726-8434
PLEASE ADDRESS ALL CORRESPONDENCE TO:
16130 VAN DRUNEN RD.. SOUTH HOLLAND, IL 60473
OFFICE TEL. (312) 264-1173
KVB
A Research-Cottrell Company
6176 Olson Memorial Highway
Minneapolis, MN 55422
June 28, 1979
Sample identification
by KVB
Kind of sample
reported to us
Sample taken at
Sample taken by
Date sampled
Date received
Coal
KVB
6/23/79
Test No. 2
Sample: Ohio Coal
Test Site: J
Analysis report no. 71-34530
PROXIMATE ANALYSIS
As Received
Dry Basis
% Moisture
% Ash
% Volatile
Fixed Carbon
3.12
7.06
37.62
52.20
TOO.00
XXXXX
7.29
38.83
53.88
100.00
Btu/lb,
% Sulfur
13405
1.52
13837
1.57
FUSION TEMPERATURE OF ASH
Reducing
Oxidizing
Initial Deformation
Softening (H = W)
Softening (H = 1/2W)
Fluid
xxxx °F
XXXX °F
XXXX °F
xxxx °F
xxxx C
XXXX °F
xxxx °f
xxxx °F
Cone Height
Cone w.dth
Original COPY Watermarked
For Your Protection
93
Respectfully submitted,
COMMERCIAL TESTING & ENGINEERING CO.
R. A
Charter Member
RAH/ br
SO HOLLAND. IL BILLINGS. MT BIRMINGHAM, AL CHARLESTON. WV CLARKSBURG VW CLEVELAND. OH DENVER. CO GOLDEN. CO
HENDERSON. KY MIDOLESBORO. KY MOBILE, AL NEW ORLEANS. LA NORFOLK. VA PIKEVILLE. KY VANCOUVER. B.C. CAN
-------
COMMERCIAL TESTING & ENGINEERING CO.
GENERAL OFFICES: 221 NORTH LA SALLE STREET, CHICAGO, ILLINOIS 60601 AREA CODE 312 726-8434
KVB, INC.
6176 Olson Memorial Highway
Minneapolis, MN 55422
PLEASE ADDRESS ALL CORRESPONDENCE TO-
16130 VAN DRUNEN RD., SOUTH HOLLAND IL 60473
OFFICE TEL. (312) 264-1173
July 17, 1979
Sample identification
by KVB, Inc.
Kind of sample
reported to us
Sample taken at
Sample taken by
Date sampled
Date received
Ohio Coal
Test site J
KVB, Inc.
6/12/79
7/12/79
Test No. 5
Analysis report no. 71- 35626
PROXIMATE ANALYSIS
As Received
Dry Basis
% Moisture
% Ash
% Volatile
% Fixed Carbon
Btu/lb.
% Sulfur
4.44
10.22
37.19
48.15
100.00
12570
2.18
xxxxx
10.69
38.92
50.39
100.00
13154
2.28
FUSION TEMPERATURE OF ASH
Initial Deformation
Softening
-------
F 462
COMMERCIAL TESTING & ENGINEERING CO.
GENERAL OFFICES: 228 NORTH LA SALLE STREET, CHICAGO, ILLINOIS 60601 AREA CODE 312 726-8434
PLEASE ADDRESS ALL CORRESPONDENCE TO:
16130 VAN DRUNEN RD., SOUTH HOLLAND, IL 60473
OFFICE TEL. (312) 264-1173
KVB, INC.
6176 Olson Memorial Highway
Minneapolis, MN 55422
July 17, 1979
Sample identification
fay KVB, Inc.
Kind of sample
reported to us
Sample taken at
Sample taken by
Date sampled
Date received
Kentucky Coal Test No. 6
Test site J
KVB, Inc.
6/13/79
7/12/79
Analysis report no. -j^_ 35532
PROXIMATE ANALYSIS
As Received Dry Basis
% Moisture
% Ash
% Volatile
% Fixed Carbon
Btu/lb.
% Sulfur
2.02
4.18
40.58
53.22
100.00
13966
1.30
xxxxx
4.27
41.42
54.31
100.00
14254
1.33
FUSION TEMPERATURE OF ASH
Reducing
Oxidizing
Initial Deformation
Softening (H = W)
Softening (H = VzW)
Fluid
Original Copy Watermarked
For Your Protection
XXX
XXX
XXX
XXX
°F
°F
°F
°F
XXX
XXX
XXX
XXX
°F
°F
°F
°F
H - Con* Height
W Cone Width
Respectfully submitted,
COMMERCIAL>W1NG & ENGINEERING CO.
95
R. A HOUSER, Manager, Midwest Division
RAH/dh
SO HOLLAND IL BILLINGS. MT BIRMINGHAM. AL CHARLESTON. WV CLARKSBURG. WV CLEVELAND. OH - DENVER. CO GOLDEN, CO
HENDERSON. KY MIOOLESBORO. KY MOBILE. AL NEW ORLEANS. LA NORFOLK. VA PIKEVILLE. KY VANCOUVER. B.C.CAN.
Charur Mgmtwr
-------
F 462
COMMERCIAL TESTING & ENGINEERING CO.
GENERAL OFFICES: 228 NORTH LA SALLE STREET, CHICAGO. ILLINOIS 60601
AREA CODE 312 726-8434
KVB, INC.
6176 Olson Memorial Highway
Minneapolis, HN 55422
PLEASE ADDRESS ALL CORRESPONDENCE TO-
16130 VAN DRUNEN RD., SOUTH HOLLAND IL 60473
OFFICE TEL (312)264-1173
July 17, 1979
Sample identification
bV KVB, Inc.
Kind of sample
reported to us
Sample taken at
Sample taken by
Date sampled
Date received
Ohio Coal
Test site J
KVB, Inc.
6/14/79
7/12/79
Test No. 7
Analysis report no. 71_ 35530
PROXIMATE ANALYSIS
As Received Dry Basis
% Moisture
% Ash
% Volatile
% Fixed Carbon
Btu/lb.
% Sulfur
2.93
7.11
38.89
51.07
100.00
13373
1.68
xxxxx
7.32
40.06
52.62
100.00
13777
1.73
FUSION TEMPERATURE OF ASH
Initial Deformation
Softening (H = W)
Softening (H = ViW)
Fluid
Original Copy Watermarked
For Your Protection
XXX
xxx
XXX
XX
Oxidizing
xxx
xxx
xxx
H =- Con* Htlght
W = Con* Width
Respectfully submitted,
COMMERCIALJ£STING & ENGINEERING CO.
96
R. A. HOUSER, Manager. Midwest Division
RAH/dh
SO HOLLAND IL BILLINGS MT BIRMINGHAM. AL CHARLESTON. WV CLARKSBURG. WV CLEVELAND. OH DENVER. CO GOLDEN. CO
HENDERSON. K V MIODLES8OHO, KV MOBILE. AL NEW ORLEANS. LA NORFOLK. VA PIKEVILLE. KY VANCOUVER. B.C.CAN.
Ch«rt»r Member
-------
F 462
COMMERCIAL TESTING & ENGINEERING CO.
GENERAL OFFICES: 228 NORTH LA SALLE STREET. CHICAGO. ILLINOIS 60601 AREA CODE 312 726-8434
zfe.
KVB, INC.
6176 Olson Memorial Highway
Minneapolis, MN 55422
PLEASE ADDRESS ALL CORRESPONDENCE TO:
16130 VAN DRUNEN RD., SOUTH HOLLAND. IL 60473
OFFICE TEL. (312) 264-1173
July 17, 1979
Sample identification
by KVB, Inc.
Kind of sample
reported to us
Sample taken at
Sample taken by
Date sampled
Date received
Kentucky Coal
Test site J
KVB, Inc.
6/15/79
7/12/79
Test No. 8
Analysis report no. 71 35628
PROXIMATE ANALYSIS
As Received
Dry Basis
% Moisture
% Ash
% Volatile
% Fixed Carbon
Btu/lb.
% Sulfur
1.94
5.31
40.35
52.40
100.00
13995
1.40
xxxxx
5.42
41.15
53.43
100.00
14272
1.43
FUSION TEMPERATURE OF ASH
Reducing
Oxidizing
Initial Deformation
Softening (H = W)
Softening (H = 1/2W)
Fluid
Original Copy Watermarked
For Your Protection
XXX °F
XXX °F
XXX "F
XXX °F
97
XXX °F
XXX °F
XXX °F
XXX CF
H -- Cone Height
W - Cone Wldm
Respectfully submitted.
COMMERCIALTESTING & ENGINEERING CO.
R. A. HOTJSErT Manager. Midwest Division
Charter M«nb«r
RAH/dh
SO. HOLLAND, IL BILLINGS. MT BIRMINGHAM, AL CHARLESTON. WV CLARKSBURG, VW CLEVELAND, OH DENVER. CO GOLDEN. CO
HENDERSON, KY MIDDLESBORO. KV MOBILE. AL NEW ORLEANS. LA NORFOLK, VA PIKEVILLE. KY VANCOUVER. B.C. CAN.
-------
F 462
\y
COMMERCIAL TESTING & ENGINEERING CO.
GENERAL OFFICES: 221 NORTH LA SALLE STREET, CHICAGO, ILLINOIS 60601
AREA CODE 312 726-8434
KVB, INC.
6176 Olson Memorial Highway
Minneapolis, MN 55422
PLEASE ADDRESS ALL CORRESPONDENCE TO-
16130 VAN DRUNEN RD., SOUTH HOLLAND, IL 60473
OFFICE TEL. (312) 264-1173
July 17, 1979
Sample identificat.cn
by KVB, Inc.
Kind of sample
reported to us
Sample taken at
Sample taken by
Date sampled
Date received
Kentucky Coal
Test site J
KVB, Inc.
6/16/79
7/12/79
Test No. 9
Analysis report no. 71- 35629
PROXIMATE ANALYSIS
% Moisture
% Ash
% Volatile
Fixed Carbon
Btu/lb.
% Sulfur
Initial Deformation
Softening (H=W)
Softening (H = V2W)
Fluid
Original Copy W»t«rm»rked
For Your ProMdion
As Received
Dry Basis
2.91
11.76
35.85
49.48
100.00
12511
2.57
xxxxx
12.11
36.92
50.97
100.00
12886
2.65
FUSION TEMPERATURE OF ASH
Reducing
XXX °F
XXX °F
XXX °F
XXX °F
Oxidizing
XXX
XXX
XXX
XXX
°F
°F
°F
°F
H - Cone Height
W Cone Width
Respectfully submitted,
COMMERCIALJ(ESTING & ENGINEERING CO.
R. A. flOUSER, Manager, Midwest Division
RAH/dh
SO. HOLLAND, IL BILLINGS, MT BIRMINGHAM. AL CHARLESTON, WV CLARKSBURG. VW CLEVELAND. OH DENVER. CO GOLDEN, CO
HENDERSON, KV MIDOLESBORO. KV MOBILE. AL NEW ORLEANS. LA NORFOLK. VA PIKEVILLE. K V VANCOUVER. B.C. CAN.
Ctitrwr M«mb*r
-------
F-462
ilj
X
COMMERCIAL TESTING & ENGINEERING CO.
GENERAL OFFICES: 22B NORTH LA SALLE STREET, CHICAGO. ILLINOIS 60601 AREA CODE 312 726-8434
2k
KVB, INC.
6176 Olson Memorial Highway
Minneapolis, MN 55422
PLEASE ADDRESS ALL CORRESPONDENCE TO:
16130 VAN DRUNEN RD., SOUTH HOLLAND, IL 60473
OFFICE TEL. (312) 264-1173
July 17, 1979
Sample identification
by KVB, Inc.
Kind of sample
reported to us
Sample taken at
Sample taken by
Ohio Coal
Test site J
KVB, Inc.
Test No. 13
Date sampled 6/19/79
Date received 7/12/79
Analysis report no. 7j__ 35531
PROXIMATE ANALYSIS
As Received Dry Basis
% Moisture
% Ash
% Volatile
% Fixed Carbon
Btu/lb.
% Sulfur
Initial Deformation
Softening (H = W)
Softening (H = VzW)
Fluid
Original Copy Watermarked
For Your Protection
4.85
8.23
36.71
50.21
100.00
12810
1.64
xxxxx
8.65
38.58
52.77
100.00
13463
1.72
FUSION TEMPERATURE OF ASH
Reducing
Oxidizing
XXX
XXX
XXX
XXX
°F
°F
°F
°F
XXX
XXX
XXX
XXX
°F
°F
°F
°F
99
H = Con» Height
W Cone Width
Respectfully submitted,
COMMERCIALJf STING & ENGINEERING CO.
R. A
!, Manager, Midwest Division
RAH/dh
SO. HOLLAND, IL BILLINGS. MT BIRMINGHAM. »L CHARLESTON. WV CLARKSBURG. IW CLEVELAND. OH DENVER. CO GOLDEN. CO
HENDERSON. KY MIDDLESBORO. KY MOBILE. AL NEW ORLEANS. LA NORFOLK. VA PIKEVILLE. KV VANCOUVER. B.C. CAN
-------
COMMERCIAL TESTING & ENGINEERING CO.
GENERAL OFFICES: 228 NORTH LA SALLE STREET, CHICAGO. ILLINOIS 60601 AREA CODE 312 726-8434*
PLEASE ADDRESS ALL CORRESPONDING* rn.
16130 VAN DRUNEN RD., SOUTH HOLLAND IL|()4?3
OFFICE TEL. (312) 264^173
KVB, INC.
6176 Olson Memorial Highway
Minneapolis, MN 55422
July 17, 1979
Sample identification
byKVB, Inc.
Kind of sample Ohio Coal
reported to us
Sample taken at Test site J
Sample taken by KVB, Inc.
Date sampled 6/2 0/79
Date received 7/12/79
Test No. 14
Analysis report no. 71- 35625
PROXIMATE ANALYSIS
As Received
Dry Basis
% Moisture
% Ash
% Volatile
% Fixed Carbon
3.18
8.23
38.91
49.68
xxxxx
8.50
40.19
51.31
100.00
100.00
Btu/lb.
% Sulfur
13101 13531
1.82 1.88
FUSION TEMPERATURE OF ASH
Oxidizing
Initial Deformation
Softening (H = W)
Softening (H = %W)
Fluid
Original Copy Watermarked
For Your Protection
XXX
XXX
XXX
J .*
°F
°F
°F
°F
XXX
XXX
XXX
XXX
°F
°F
°F
°F
H = Con» Height
W = Con. Width
Respectfully submitted,
COMMERCIAL TESTING & ENGINEERING CO.
100
R. A. HODSER, Manager, Midwest Division
RAH/dh
SO. HOLLAND. IL BILLtNGS, MT BIRMINGHAM, AL CHARLESTON. WV CLARKSBURG. WV CLEVELAND. OH DENVER, CO* GOLDEN CO
HENDERSON, K V MIDDLESBORO. K V MOBILE. AL NEW ORLEANS. LA NORFOLK. VA PIKEVILLE. KY VANCOUVER. BC. CAN.
Charter Mtinfaw
-------
F 464
COMMERCIAL TESTING & ENGINEERING CO.
GENERAL OFFICES: 228 NORTH LA SALLE STREET. CHICAGO. ILLINOIS 60601 AREA CODE 312 726-8434
PLEASE ADDRESS ALL CORRESPONDENCE TO:
16130 VAN DRUNEN RD., SOUTH HOLLAND, IL 60473
OFFICE TEL. (312) 264-1173
KVB
A Research-Cottrell Co.
6176 Olson Memorial Highway
Minneapolis, MN 55422
July 25, 1979
Sample identification
by KVB
Kind of sample
reported to us
Sample taken at
Sample taken by
Date sampled
Date received
Kent. Coal
KVB
6/28/79
7/12/79
Test #15
Test Site: J
Analysis report no. 71-35627
PROXIMATE ANALYSIS
%Moisture.
%Ash ,
%Volatile.... ,
%Fixed Carbon,
Btu/lb.
%Sulfur.
SULFUR FORMS
As Received Dry Basis
2.09
5.02
39.58
53.31
100.00
13954
1.03
14252
1.05
%Weight
As Received Dry Basis
%Pyritic Sulfur 0.26
%Sulfate Sulfur 0.02
%0rganic Sulfur(dif)... 0.75
0.27
0.02
0.76
Original Copy Watermarked
For Your Protection
101
Respectfully submitted,
COMMERCIAL TESTING & ENGINEERING CO.
R. A
nager, Midwest Division
Charter Member
RAH/br
SO HOLLAND, IL BILLINGS. MT BIRMINGHAM. AL CHARLESTON. WV CLARKSBURG. «V CLEVELAND. OH DENVER. CO GOLDEN, CO
HENDERSON. KY MIDDLESBORO, KY MOBILE, AL NEW ORLEANS. LA NORFOLK. VA PIKEVILLE. KY VANCOUVER. B.C. CAN.
-------
F 464
COMMERCIAL TESTING & ENGINEERING CO.
GENERAL OFFICES: 228 NORTH LA SALLE STREET. CHICAGO, ILLINOIS 60601
AREA CODE 312 726-8434
PLEASE ADDRESS ALL CORRESPONDENCE TO-
16130 VAN DRUNEN RD., SOUTH HOLLAND, IL 60473
OFFICE TEL. (312) 264-1173
KVB
A Research-Cottrell Co.
6176 Olson Memorial Highway
Minneapolis, MN 55422
July 21, 1979
Sample identification
b/KVB
Kind of sample
reported to us
Sample taken at
Sample taken by
Date sampled
Date received
Coal
KVB
6/30/79
7/12/79
Sample: Ohio coal
Test No. 16
Test site: J
Analysis report no.
PROXIMATE ANALYSIS
%Moisture
%Ash
%Volatile
%Fixed carbon
Btu/lb.
%Sulfur
%Pyritic sulfur
%Sulfate sulfur
%0rganic sulfur
As Received
3.73
7.77
38.06
50.44
100.00
12990
2.02
1.39
0.10
0.53
Dry Basis
xxxxx
8.07
39.53
52.40
100.00
13493
2.10
1.44
0.11
0.55
Original Copy Watermarked
For Your Protection
102
Respectfully submitted,
COMMERCIAL TESTING & ENGINEERING CO.
R. A. HOUSER, Manager, Midwest Division
,:*»»*';
Charter Member
RAH/br
SO HOLLAND. IL BILLINGS, MT BIRMINGHAM, AL CHARLESTON. WV CLARKSBURG. WV CLEVELAND, OH DENVER. CO GOLDEN, CO
HENDERSON. KV MIOOLESBORO. KV MOBILE. AL NEW ORLEANS. LA NORFOLK. VA PIKEVILLE. KV . VANCOUVER. B.C. CAN.
-------
F-467
COMMERCIAL TESTING & ENGINEERING CO.
GENERAL OFFICES: 228 NORTH LA SALLE STREET, CHICAGO, ILLINOIS 60601
AREA CODE 312 726-8434
^ KVB
A Research-Cottrell Co.
6176 Olson Memorial Highway
Minneapolis, MN 55422
Kind of sample
reported to us Ohio Coal
PLEASE ADDRESS ALL CORRESPONDENCE TO:
16130 VAN DRUNEN RD., SOUTH HOLLAND, IL 60473
OFFICE TEL. (312) 264-1173
July 25, 1979
Sample identification
by KVB
Sample taken at
Sample taken by KVB
Date sampled
Date received 7/12/79
PROXIMATE ANALYSIS
% Moisture
% Ash
% Volatile
% Fixed Carbon
Btu/lb.
% Sulfur
% Alk. as Na20
SULFUR FORMS
% Pyritic Sulfur
% Sulfate Sulfur
% Organic Sulfur
WATER SOLUBLE ALKALIES
% Na2O =
% K20 =
FUSION TEMPERATURE OF ASH
Initial Deformation
H is Cone Height Softening (H = W)
w is cone width Softening (H = Vz W)
Fluid
% EQUILIBRIUM MOISTURE =
HARDGROVE GRINDABILITY INDEX =
FREE SWELLING INDEX =
*These ignited basis results
Analysis
As received D
3.05
7.05
37.93
51.97
100.00
13368
1.75
xxxxx
0.97
0.05
0.73
xxxxx
xxxxx
report no
ry basis
xxxxx
7.27
39.12
53.61
100.00
13789
1.80
0.12
1.00
0.05
0.75
xxxxx
xxxxx
Reducing Oxidizing
°F
*M Art '
2100
oc
2250 /
2400 0;
2535 F
S3
4
T
were used
o
xxxxx
xxxxx 0
xxxxx 0
xxxxx
Test No.: Composite
Test Site: J
71-35635
ULTIMATE ANALYSIS As
Moisture
Carbon
Hydrogen
Nitrogen
Chlorine
Sulfur
Ash
Oxygen (diff)
MINERAL ANALYSIS OF ASH
Silica, Si05
Alumina, AI203
Titania, TiO2
Ferric oxide, Fe303
Lime, CaO
Magnesia, MgO
Potassium oxide, K5O
Sodium oxide, Na2O
F
F Sulfur trioxide, S03
F Phos. pentoxide, P2O5
F Undetermined
SILICA VALUE =
BASE: ACID RATIO
TSSO Temperature =
to calculate undetermined value above
%Manganese oxide , Mn-iO* ....
0.
0.
o.
00
08
05
% Weight
received Dry basis
3.05 xxxxx
74.74 77.09
5.13 5.29
"* ^«i* rj 1*J
1.66 1.71
0.19 0.20
1.75 1.80
7.05 7.27
6.43 6.64
^oMJveight igrnletnBasis
42.48
26.60
1.29
22.09
2.11
0.83
1.91
0.35
1.43
0.40
0.38*
100.00
62.92
0.39
2425°F
Respectfully submitted, »rTw"*^
COMMERCIALTESTING & ENGINEERING CO. ^C^@^'>
fj / . im^Fmti
MM
Original Copy Watermarked
For Your Protection
103
-^
R. A.
^ Manager, Midwest Division
RAH/br
SO HOLLAND. IL BILLINCS. MT BIRMINGHAM, AL CHARLESTON, WV CLARKSBURG. WV -CLEVELAND, OH DENVER. CO GOLDEN. CO
HENDERSON. KY MIDDLESBORO. KY MOBILE. AL NEW ORLEANS. LA NORFOLK, VA PIKEVILLE. KY VANCOUVER. B.C. CAN.
Charter Memtwr
-------
F-467
COMMERCIAL TESTING & ENGINEERING CO.
GENERAL OFFICES; 228 NORTH LA SALLE STREET, CHICAGO, ILLINOIS 60«01 AREA CODE 312 726-8434
PLEASE ADDRESS ALL CORRESPONDENCE TO-
16130 VAN DRUNEN RD.. SOUTH HOLLAND, IL 60473
OFFICE TEL. (312) 264-1173
SiNCf HOI
KVB
A Research-Cottrell Co.
6176 Olson Memorial Highway
Minneapolis, MN 55422
Kind of sample
reported to us Coal
July 26, 1979
Sample identification
by KVB
Sample taken at
Sample taKen by KVB
Date sampled
Date received 7/12/79
-Test Vo. Composite
Sample: Kent Coal
Test Site: J
Analysis report no.
PROXIMATE ANALYSIS As received Dry basis
71-35634
ULTIMATE ANALYSIS
% Moisture
% Ash
% Volatile
% Fixed Carbon
Btu/lb.
% Sulfur
% Alk. as Na2O
SULFUR FORMS
% Pyritic Sulfur
% Sulfate Sulfur
% Organic Sulfur
WATER SOLUBLE ALKALIES
% Na30 =
% K20 =
FUSION TEMPERATURE OF ASH
Initial Deformation
H.sConoHoigm Softening (H = W)
w is cono width Softening (H = VaW)
Fluid
% EQUILIBRIUM MOISTURE =
HARDGROVE GRINDABILITY INDEX =
FREE SWELLING INDEX =
1.96
6.14
39.08
52.82
100.00
13624
1.43
xxxxx
0.68
0.02
0.73
xxxxx
xxxxx
Reducing
2205 '
2335 '
2465 '
2580 '
2.07
49
6
% Weight
As received Dry basis
*These ignited basis results were us ,
to calculate undetermined value above
%Strontium oxide, SrO 0.14
%Barium oxide, BaO 0.30
%Manganese oxide,Mrvj04 0.02
Fouling index 0.26
Slagging index 0.48
xxxxx
6.26
39.86
53.88
100.00
13897
1.46
0.12
0.69
0.02
0.75
xxxxx
xxxxx
Oxidizing
Moisture
Carbon
Hydrogen
Nitrogen
Chlorine
Sulfur
Ash
Oxygen (diff)
MINERAL ANALYSIS OF ASH
Silica, SiO:
Alumina, AI2O3
Titania, TiO2
Ferric oxide, Fe,O3
Lime, CaO
Magnesia, MgO
Potassium oxide, K,O
Sodium oxide, Na,O
°F
°F Sulfur trioxide, S03
°F Phos. pentoxide, P2O5
°F Undetermined
SILICA VALUE =
BASE: ACID RATIO
T350 Temperature =
1.96
76.77
5.09
1.23
0.13
1.43
6.14
7.25
100.00
*
xxxxx
78.31
5.19
1.25
0.13
1.46
6.26
7.40
ion.nri
% Weight Ignited Basis
44.08
26.46
1.51
17.80
2.28
0.78
1.78
OOf\
.80
In f
»85
0.31
Ion
.89
100.00
67.88
OOO
JO
2515 °F
Respectfully submitted,
COMMERCIAL TESTING & ENGINEERING CO.
Original Copv Watermarked
For Your Protection
RAH/br
SO HOLLAND. IL BILLINGS. MT BIRMINGHAM. AL CHARLESTON. WV CLARKSBURG. WV CLEVELAND. OH DENVER. CO GOLDEN. CO
HENDERSON. KV MIDOLESBORO. KY MOBILE. AL NEW ORLEANS. LA NORFOLK. VA PIKEVILLE. KV VANCOUVER. B.C. CAN.
-------
F-464
COMMERCIAL TESTING & ENGINEERING CO.
GENERAL OFFICES: 228 NORTH LA SALLE STREET. CHICAGO, ILLINOIS 60601
AREA CODE 312 T26-M34
KVB
A Research-Cottrell Company
6176 Olson Memorial Highway
Minneapolis, MN 55422
PLEASE ADDRESS ALL CORRESPONDENCE TO:
16130 VAN DRUNEN RD., SOUTH HOLLAND, IL 60473
OFFICE TEL. (312) 264-1173
June 28, 1979
Sample identification
by KVB
Kind o1 sample
reported to us
Sample taken at
Sample taken by
Date sampled
Date received
Ash
KVB
6/23/79
Test No. 1
Sample : Bottom Ash
Site: J
Analysis report no. 71-34527
%Ash
%Combustible
Dry Basis
79.83
20.17
Respectfully submitted,
COMMERCIAL TESTING & ENGINEERING CO.
*s^ -^="-^ -
*,'f^»ol»'*o?V
n* I-TKV rl v-
Original Copy Watermarked
For Your Protection
anager,
Chartor Member
RAH/ br
SO. HOLLAND, IL BILLINGS. MT BIRMINGHAM. AL CHARLESTON. WV CLARKSBURG, «W CLEVELAND. OH DENVER. CO GOLDEN, CO
HENDERSON, KV MIDDLESBORO, KV -MOBILE AL -NEW ORLEANS. LA- NORFOLK VA PIKEVIVLE KY VANCOUVER B C CAN
-------
COMMERCIAL TESTING & ENGINEERING CO.
GENERAL OFFICES: 228 NORTH LA SALLE STREET. CHICAGO, ILLINOIS 60601
AREA CODE 312 726-8434
KVB
A Research-Cottrell Company
6176 Olson Memorial Highway
Minneapolis, MN 55422
PLEASE ADDRESS ALL CORRESPONDENCE TO-
16130 VAN DRUM EN RD.. SOUTH HOLLAND IL 60473
OFFICE TEL. (312) 264-1173
June 28, 1979
Sample identification
by KVB
Kind of sample
reported to us
Sample taken at
Sample taken by
Date sampled
Date received
Ash
KVB
6/23/79
Test No. 2
Sample: Bottom Ash
Site: J
Analysis report no. 71-34531
%Ash
%Combustible,
Dry Basis
84.53
15.47
Respectfully submitted,
COMMERCIAWESTING & ENGINEERING CO.
Original Copy Watermarked
For Your Protection
106
R. A. HOUSER. Manager, Midwest Division
RAH/ br
SO. HOLLAND. IL BILLING!. MT BIRMINGHAM, AL CHARLESTON. WV CLARKSBURG. WV CLEVELAND. OH DENVER. CO GOLDEN. CO
HENDERSON. KV MIODLESBORO. KY MOBILE. AL NEW ORLEANS, LA NORFOLK. VA PIKEVILLE. KY VANCOUVER. B.C CAN.
Charter Member
-------
F-464
COMMERCIAL TESTING & ENGINEERING CO.
GENERAL OFFICES: 228 NORTH LA SALLE STREET, CHICAGO, ILLINOIS 60601 AREA CODE 312 726-8434
PLEASE ADDRESS ALL CORRESPONDENCE TO:
16130 VAN DRUNEN RD.. SOUTH HOLLAND, IL 60473
OFFICE TEL. (312) 264-1173
KVB, INC.
6176 Olson Memorial Highway
Minneapolis, MN 55422
July 17, 1979
Sample identification
by KVB, inc.
Kind of sample
reported to us
Sample taken at
Sample taken by
Date sampled
Date received
Bottom Ash
Test site J
KVB, Inc.
6/13/79
7/12/79
Test No. 6
Analysis report no. 71- 35638
% Combustible, dry basis 20.26
Original Copy Watermarked
For Your Protection
Respectfully submitted,
COMMERCIALjrQSTING & ENGINEERING CO.
107
R. A. HOUSER, Manager, Midwest Division
RAH/dh
SO. HOLLAND. IL BILLINGS. MT BIRMINGHAM, AL CHARLESTON. WV CLARKSBURG, WV CLEVELAND. OH DENVER. CO GOLDEN CO
HENDERSON. KY MIDDLESBORO. KY MOBILE. AL NEW ORLEANS LA NORFOLK. VA PIKEVILLE. KY VANCOUVER. B.C. CAN
> ft
Charier Mtmtor
-------
COMMERCIAL TESTING & ENGINEERING CO.
GENERAL OFFICES; 228 NORTH LA SALLE STREET. CHICAGO, ILLINOIS 60601
AREA CODE 312 726-8434
KVB, INC.
6176 Olson Memorial Highway
Minneapolis, MN 55422
PLEASE ADDRESS ALL CORRESPONDENCE TO"
16130 VAN DRUNEN RD., SOUTH HOLLAND, IL 60473
OFFICE TEL. (312) 264-1173
July 17, 1979
Sample Identification
by KVB, Inc.
Kind of sample Bottom Ash
reported to us
Sample taken at Test site J
Sample taken by KVB, Inc.
Date sampled 6/14/79
Date received 7/12/79
Test No. 7
Analysis report no. 71- 35641
% Combustible, dry basis 19.57
Respectfully submitted,
COMMERCIALTESTING & ENGINEERING CO.
Original Copy Watermarked
For Your Protection
108
R. A'HOUSER, Manager, Midwest Division
RAH/dh
SO HOLLAND. IL BILLINGS. MT BIRMINGHAM. AL CHARLESTON. WV CLARKSBURG, WV CLEVELAND. OH DENVER,CO GOLDEN, CO
HENDERSON. KV MIOULESBORO. KV MOBILE. AL NEW ORLEANS. LA NORFOLK. VA PIKEVILLE. KY VANCOUVER. B.C. CAN.
Ch.rter Mimbcr
-------
F-464
COMMERCIAL TESTING & ENGINEERING CO.
GENERAL OFFICES: 228 NORTH LA SALLE STREET. CHICAGO, ILLINOIS 60601 AREA CODE 312 726-8434
PLEASE ADDRESS ALL CORRESPONDENCE TO:
16130 VAN DRUNEN RD., SOUTH HOLLAND, IL 60473
OFFICE TEL. (312) 264-1173
KVB, INC.
6176 Olson Memorial Highway
Minneapolis, MN 55422
July 17, 1979
Sample identification
by KVB, Inc.
Kind of sample Bottom Ash
reported to us
Sample taken at Test site J
Sample taken by KVB, Inc.
Date sampled 6/15/79
Date received 7/12/79
Test No. 8
Analysis report no. 71- 35640
% Combustible, dry basis 30.75
Respectfully submitted,
COMMERCIAWSTING & ENGINEERING CO.
Original COPV Watermarked
For Your Protection
109
R. A. HOUSER, Manager, Midwest Division
Charter Member
RAH/dh
SO, HOLLAND, IL BILLINGS, MT BIRMINGHAM. AL CHARLESTON. VW . CLARKSBURG. WV CLEVELAND. OH DENVER. CO GOLDEN. CO
HENDERSON. KV MIODLESBORO. KV MOBILE. AL NEW ORLEANS. LA NORFOLK. VA PIKEVILLE. KV . VANCOUVER. B.C CAN,
-------
F-464
COMMERCIAL TESTING & ENGINEERING CO. I
GENERAL OFFICES: 226 NORTH LA SALLE STREET, CHICAGO. ILLINOIS 60801 AREA CODE 312 726-8X34
PLEASE ADDRESS ALL CORRESPONDENCE TO-
16130 VAN DRUNEN RD., SOUTH HOLLAND IL 60473
OFFICE TEL. (312) 264-1173
KVB, INC.
6176 Olson Memorial Highway
Minneapolis, MN 55422
July 17, 1979
Sample identification
by KVB, Inc.
Kind of sample
reported to us
Bottom Ash
Sample taken at Test site J
Sample taken by KVB , Inc .
Date sampled 6/16/79
Date received 7/12/79
Test No. 9
Analysis report no. 71- 35637
% Combustible, dry basis
7.23
Original Copy Watermarked
For Your Protection
Respectfully submitted,
COMMERCIAL/TESTING & ENGINEERING CO.
110
R. A. HOUSER, Manager, Midwest Division
RAH/dh
SO. HOLLAND. IL BILLINGS. WT BIRMINGHAM. AL CHARLESTON. WV CLARKSBURG. WV CLEVELAND. OH DENVER.CO GOLDEN,CO
HENDERSON. KY MIDOLESBORO. KY MOBILE. AL > NEW ORLEANS. LA NORFOLK. VA PIKEVILLE, KV VANCOUVER. B.C. CAN.
Ch.rter MtmUr
-------
F-464
.it
COMMERCIAL TESTING & ENGINEERING CO.
GENERAL OFFICES: 228 NORTH LA SALLE STREET, CHICAGO, ILLINOIS 60601 AREA CODE 312 726-8434
PLEASE ADDRESS ALL CORRESPONDENCE TO:
16130 VAN DRUNEN RD., SOUTH HOLLAND, IL 60473
OFFICE TEL. (312) 264-1173
SING* <*oa
KVB, INC.
6176 Olson Memorial Highway
Minneapolis, MN 55422
July 17, 1979
Sample identification
by KVB, Inc.
Kind of sample Bottom Ash
reported to us
Sample taken at Test site J
Sample taken by KVB, Inc.
Date sampled 6/19/79
Date received 7/12/79
Test No. 13
Analysis report no. 71- 35639
% Combustible, dry basis 18.58
Respectfully submitted,
COMMERCIALIZING & ENGINEERING CO.
Original Copy Watermarked
For Your Protection
Ill
R. A. HOUSER. Manager, Midwest Division
ChirMr M«mb«r
RAH/dh
SO. HOLLAND, IL BILLINGS. MT BIRMINGHAM, AL CHARLESTON, WV CLARKSBURG. WV CLEVELAND. OH DENVER. CO GOLDEN. CO
HENDERSON. KY MIDDLESBORO, KV MOBILE. AL NEW ORLEANS. LA NORFOLK. VA PIKEVILLE. KY . VANCOUVER. B.C.CAN
-------
F-464
COMMERCIAL TESTING & ENGINEERING CO.
GENERAL OFFICES: 226 NORTH LA SALLE STREET, CHICAGO. ILLINOIS 80801 AREA CODE 312 726-8434
PLEASE ADDRESS ALL CORRESPONDENCE TO-
16130 VAN DRUNEN RD., SOUTH HOLLAND IL 60473
OFFICE TEL. (312) 264-1173
KVB, INC.
6176 Olson Memorial Highway
Minneapolis, MN 55422
July 17, 1979
Sample identification
», Inc.
Kind of sample Bottom Ash
reported to us
Sample taken at Test site J
Sample taken by KVB, Inc.
Date sampled 6/20/79
Date received 7/12/79
Test No. 14
Analysis report no. 71 _ 35535
% Combustible, dry basis 30.93
Original Copy Watermarked
For Your Protection
Respectfully submitted,
COMMERCIAL IRSTING & ENGINEERING CO.
112
R. A. HOUSER, Manager, Midwest Division
RAH/dh
SO. HOLLAND IL BILLINGS. MT BIRMINGHAM. AL CHARLESTON. «VV CLARKSBURG, WV CLEVELAND. OH DENVER. CO GOLDEN. CO
HENDERSON. KY MIDOLCSBORO. KY MOBILE, AL NEW ORLEANS. LA NORFOLK. VA PIKEVILLE. ICY VANCOUVER. B.C. CAN.
Chart.r Member
-------
COMMERCIAL TESTING & ENGINEERING CO.
GENERAL OFFICES: 226 NORTH LA SALLE STREET, CHICAGO, ILLINOIS 60601
AREA CODE 312 726-8434
KVB, INC.
6176 Olson Memorial Highway
Minneapolis, MN 55422
PLEASE ADDRESS ALL CORRESPONDENCE TO:
16130 VAN DRUM EN RD., SOUTH HOLLAND, IL 60473
OFFICE TEL (312) 264-1173
July 17, 1979
Sample identification
by KVB, Inc.
Kind of sample Bottom Ash
reported to us
Sample taken at Test site J
Sample taken by KVB, Inc.
Date sampled 6/28/79
Date received 7/12/79
Test No. 15
Analysis report no. 71- 35643
% Combustible, dry basis 24.09
% Sulfur, dry basis 0.51
Respectfully submitted.
COMMERCIAL J^TING & ENGINEERING CO.
113
Original Copy Watermarked
For Your Protection
R. A HOUSER, Manager, Midwest Division
Charter Member
RAH/dh
SO HOLLAND, IL BILLINGS, MT BIRMINGHAM, AL CHARLESTON, WV - CLARKSBURG. VW CLEVELAND, OH * DENVER, CO GOLDEN, CO
HENDERSON, KY MtODLESBOHO. KV MOBILE, AL NEW ORLEANS. LA NORFOLK. VA * PtKEVlLLE, KV VANCOUVER. B.C. CAN.
-------
F-464
COMMERCIAL TESTING & ENGINEERING CO.
GENERAL OFFICES: 228 NORTH LA SALLE STREET, CHICAGO. ILLINOIS 60601 AREA CODE 312 726-8434
PLEASE ADDRESS ALL CORRESPONDENCE TO-
16130 VAN DRUNEN RD., SOUTH HOLLAND IL 60473
OFFICE TEL. (312)264-1173
KVB, INC.
6176 Olson Memorial Highway
Minneapolis, MN 55422
Kind of sample
reported to us
Sample taken at
Sample taken by
Bottom Ash
Test site J
KVB, Inc.
July 17, 1979
Sample identification
by KVB, Inc.
Test No. 16
Date sampled 6/30/79
Date received 7/12/79
Analysis report no. 71- 35642
% Combustible, dry basis 18.97
% Sulfur, dry basis 0.31
Original Copy Watermarked
For Your Protection
Respectfully submitted,
COMMERCIAL-TESTING & ENGINEERING CO.
114
ft. A. HOUSER, Manager, Midwest Division
RAH/dh
tO HOLLAND. IL BILLINGS. MT SIRMINOHAM, AL CHARLESTON. NV CLARKSBURG. WV CLEVELAND, OH DENVER. CO GOLDEN. CO
N. K Y WDOLCSBORO, KV MOBILE, AL - NEW QUEANS, LA NORFOLK. I'A PIKEVILLE. KY VANCOUVER, B.C. CAN.
Ohirter Me~mta*V
-------
F-464
COMMERCIAL TESTING & ENGINEERING CO.
GENERAL OFFICES: 226 NORTH LA SALLE STREET, CHICAGO. ILLINOIS 60601
AREA CODE 312 726-B434
SlNCI '*OB
KVB
A Research-Cottrell Company
6176 Olson Memorial Highway
Minneapolis, MN 55422
PLEASE ADDRESS ALL CORRESPONDENCE TO:
16130 VAN DRUNEN RD., SOUTH HOLLAND, IL 60473
OFFICE TEL. (312) 264-1173
June 28, 1979
Sample identification
by KVB
Kind of sample
reported to us
Sample taken at
Sample taken by
Date sampled
Date received
Ash
KVB
6/23/79
Test No. 1
Sample: Multclone Ash
Test Site: J
Analysis report no. 71-34543
%Ash ,
%Combustible
Dry Basis
70.14
29.86
Respectfully submitted,
COMMERCIAL TESTING & ENGINEERING CO.
Original Copy Watermarked
For Your Protection
115
Charter Member
RAH/ br
SO. HOLLAND, IL BILLINGS. MT BIRMINGHAM. AL CHARLESTON. WV . CLARKSBURG, wv -CLEVELAND OH DENVER CO GOLDEN CO
HENDERSON, KY MIDDLESBORO. KY MOBILE. AL NEW ORLEANS. LA NORFOLK. VA (MKEVILLE. KV . VANCOUVER B.C.CAN '
-------
COMMERCIAL TESTING & ENGINEERING CO.
GENERAL OFFICES: 228 NORTH LA SALLE STREET. CHICAGO. ILLINOIS 60601 AREA CODE 312 726-8434
PLEASE ADDRESS ALL CORRESPONDENCE TO-
16130 VAN DRUNEN RD., SOUTH HOLLAND, IL 60473
OFFICE TEL. (312) 264-1173
KVB
A Research-Cottrell Company
6176 Olson Memorial Highway
Minneapolis, MN 55422
June 28, 1979
Sample identification
by KVB
Kind of sample
reported to us
Sample taken at
Sample taken by
Date sampled
Date received
Ash
KVB
6/23/79
Test No. 2
Sample: Multclone Ash
Site: J
Analysis report no. 71-34532
%Ash
%Combustible.
Dry Basis
87.91
12.09
Original Copy Watermarked
For Your Protection
116
Respectfully submitted,
COMMERCIAL TESTING & ENGINEERING CO.
R. A
ISER, Manager, Midwest Division
RAH/ br
SO. HOLLAND. IL BILLINGS MT BIRMINGHAM. AL CHARLESTON. WV- CLARKSBURG. WV CLEVELAND. OH ' DENVER. CO GOLDEN. CO
HENDERSON, KY MIDDLESBORO. KY MOBILE. AL NEW ORLEANS. LA NORFOLK, VA flKEVILLE, KY VANCOUVER. B.C.CAN.
Ctarter M*mtw,
-------
SITE
COMBUSTIBLES DATA SHEET
rucible
Number
Sample
Origin
Crucible
Weight
grams
Crucible &
Sample Weight
Post 110°C gms
Sample
Weight
grams
Post 750°C
grams
A Weight
grams
Combus
tibles
L-b
<
AVG.
. 6 3 25
?+
7-gg^P
/o, f //
/D.
/*>
AVG.
lf>- 23 4>1
2-7
52-
y
.
AVG.
**<»
/A -5;
AVG.
. 2,773
//. 2.1 in
jo.
AVG.
~ 2-3
/#.
37V7
.J^^/i
^7
/O. .2*72.
/£>. "2* 7 3
,0.374
AVG . I /o 2,° ~73
AVG.
AVG.
117
-------
KVB
SIEVE ANALYSIS TEST REPORT
TEST NO.
TEST SITE
SAMPLE IDENTIFICATION
DATE SAMPLE TAKEN
TEST PERFORMED BY
Screen
Size
Passing
TZf
r
1 it
i- *
-B
**
4J
.&~
y * &
|Q (1) yl
/.»s
1
I
4J
UJ £
8 -H "i
J-l ID &-
CS S
770,7
//S?
744.4-
3*71
,*<>.<>
***
4J -H "E
z s «~
Mil*
2olc,L
,2V.»
27^
*->
ZH.S
Percent
(%)
22
-------
KVB
SIEVE ANALYSIS TEST REPORT
TEST NO.
TEST SITE
J
DATE SAMPLE TAKEN
TEST PERFORMED BY
SAMPLE IDENTIFICATION
Screen
Size
Passing
-r«p
/f
/^"
ifl
^
^
4J
4) cri
u -H e
rt
E* B ^
M-1
\
4J
o j:
tn & *^
O -H E
VJ (11 &
O S ^
ft+}
&*.!
H3/. V
/2?V, o
11-*
f«7-V
34S~-?
4*.r
2***l-
2 S
f//5
2/5//^
/r**?'^
5"37 4
/v«V
2^-?
Percent
(%)
/-o
8?.
-------
KVB
SIEVE ANALYSIS TEST REPORT
TEST NO.
TEST SITE
SAMPLE IDENTIFICATION
DATE SAMPLE TAKEN &-/
TEST PERFORMED BY Obff
tn
c e
0) -H
111 41 U)
(J N M
0 -H 10
w w Q<
4J
£
fO
i- 60
in
U
5 M
.
UJ
>40
1-
«
-1 ,fi
3 S0
3
" 20
10
No. No. No. No. No. No. No. No. No. No. No. No
« 3'2H"2" IX" 1" «" V>" \" V 4 8 10 20 30 40 50 60 SO 100 200 325
^
\
v
V
\J
^
s
\v
\
\
\
\
N,
\
>
\
\
\i
\
N^
N
s^
\
s
'^
<^
-*
^
^ <
^s
-~-v
- .
--___
4' 3"2X"2" 1)4' 1- «' H" V V No. No. No. No. No. No. No. No. No. No. No. N.
4 (10 16 20 30 40 60 60 100 200 326
SIEVE OPENING
CUMULATIVE PERCENT RETAINED
0 2 8 * 3 S S S g 8 8
^
120
15900
-------
KVB
SIEVE ANALYSIS TEST REPORT
TEST NO.
TEST SITE
SAMPLE IDENTIFICATION
DATE SAMPLE TAKEN
TEST PERFORMED BY
C C
(U -H
0) (U W
1-1 N cn
O -H «
w w o*
0) CTl ,-.
^ * e
10 0) &
H S
tn £
to CT* ^^
o -^ e
M 0) &
o»
4J -H
(U (U
a »
g~
° i
<1>
JJ
m
Su,
g -H
3 a)
O S
en
c
H ^»
w E
01 &
10
4J 4_i tn
-------
KVB
SIEVE ANALYSIS TEST REPORT
TEST NO.
TEST SITE
SAMPLE IDENTIFICATION
DATE SAMPLE TAKEN
TEST PERFORMED BY
01
c c
0) -H
(u a) w
M N W
U -H A
W CQ ft
To?
/'
l'
*fc
it
4J
«) tF »
3 01 5>
H 5 ~
/**
1
4-)
(0 £
B) Oi/p
o -H e
M 0) &
C) U '
Sf.'Z
wi378*
2S
14^
2S4-*
4J
P -H 'B
flJ C) w^
Z S «"
/2^.7
2g«-.3
*72>8
/?'*
T). ,
(!)
^.«.
576
/W
; U) E
g -H U) &
U S ft
0^0
^/?J3
/Z ^g"/ »
Jf£72-
^f-7-
nf-s
-H
4J 4J tJ>
tec
H <1) -H ^-»
DOW*
§ 0) 10
U &, 0,
/*.*
>>*
23%
71
3.9
*3
o
0) (U 4J C
|| 2^
W W Q *~
y
r
,5-
.T
5-
^~
No.
No. No.
8 10
No. No. No. No. No. No. No.
20 30 40 50 60 SO 100
No.
200
No.
325
3"2H'Z" 1H" 1
No. No. No. No. No.
4 8 10 16 20
SIEVE OPENING
No. No. No.
30 40 BO
No. No.
80 100
No. No.
ZOO 32S
15900
-------
KVB
SIEVE ANALYSIS TEST REPORT
TEST NO.
TEST SITE
SAMPLE IDENTIFICATION
DATE SAMPLE TAKEN_
TEST PERFORMED BY
tn
c c
0) -rl
OJ 0) 10
H N TO
O -H «
01 W 0»
-fep
/''
z"1
/v"
*z
*«.
.p
,c
<1) CJ> *~*
ffl flJ o*
H S
/w
4-)
to r
o -H "i
H Q> D^
OS
/5?7
/«Z* -7
/zV^.T
'4S1
^3-4
/6^S
3»-)
4J
p -H "e
4) 0) &
a s --
>&ti
2^rs%-7
/e37.7
314.2-
5-A4
22~J.f
4->
C
0) ^
o *
ll ,_,
s
5 o
vJ2 T
^3.7
cr,s
*<1
4*
i
H
4J t7^
tn E
1 -H W O>
3 o « -^
u s &.
J-fQ.o
^ii^l'7
2^/o
013*
277. /
airr
S!
iH
4J 4J CTl
10 C C
H
3 O 01
1 M W
3 41 (0
U CM PI*
/* o
^7,0
ijl\itr
1*4
r,
^7.
c
0
W -H ^-
0) 0) 4J C
> .X <0 -H
(i) <3 n ^
W M Q
^
r
s-
r
4" 1* X" Vi" V ''.
No.
4
No. No.
8 10
No. No. No. No. No. No. No.
20 30 40 SO 60 80 100
No.
No.
326
10
4" 3"2H"2"
1" V"
V No. No. No. No. No. No. No. No.
4 8 10 16 » 30 40 SO
SIEVE OPENING
No. No.
80 100
No.
ZOO
No.
32S
100
123
15900
-------
KVB
SIEVE ANALYSIS TEST REPORT
TEST NO.
TEST SITE
SAMPLE IDENTIFICATION
DATE SAMPLE TAKEN
TEST PERFORMED BY
CP
c c
*
3 41 &
*f-7
X
(1) A
jjf?
f&>44
tOt,!."!
ti^ (,
<f
S6T14
2V.7
4KL
4-J
^§-
V tf) &
z a
3M.I
?»4A.«9
)§42.l
4+7-7
m*
?W
v
01 ~
O M>
I, ^^
HI
O.
*9
4*4
&i
1C
?.(
14
H
4J Ol
10 4-1 C
r-4 A -H -^
3 t7> W E
§ -H W &
9 0) IS
u f. a*
fi^l")
4°l J4r. 4«
27977
14{<*
W7.9
?«r.*
H
4J 4J O<
<0 C C
r-t 0) -H ~.
3 O U) *
E M ra
P
-------
KVB
SIEVE ANALYSIS TEST REPORT
TEST NO.
TEST SITE _J
SAMPLE IDENTIFICATION
DATE SAMPLE TAKEK
TEST PERFORMED BY
01 -H
01 (V to
^ N Ul
O -H 18
t/i Ui CU
X
H "H
^ CT*
5
10 £
8 51
3g5
4J
V
z
u
&
4-> CT
n) 4J c
X -H -=
U
Cn 1(1 6
-H tn O>
1) IT)
18 C C
rH 0) -H
3 O W
i s s
O PU fl.
n.!L
4) 4) 4J £
> ^ * -rt
4> ^ V4 E
H X 3
W W Q
ttoi
V; '2*-
774. '5
tt'2-2
*/*
100
4" 3"2H"2"
1" «" H" V
No. No. No.
'(" 4 8 10
No. No. No. No. No. No. No.
20 30 40 50 60 80 100
No. No.
200 32S
2- 154
No.
No. No. No. No. No. No. No.
8 10 16 20 30 40 SO
SIEVE OPENING
No. No.
80 100
No.
200
No.
325
100
125
15900
-------
TEST NO.
TEST SITE
KVB
SIEVE ANALYSIS TEST REPORT
SAMPLE IDENTIFICATION Okie.
DATE SAMPLE TAKEN
TEST PERFORMED BY
en
c c
fl) -H
01 0) 01
M N 01
O -H Id
W W ft
-fop
1"
?"
%f
V
vt
^J
a) o\ *^
M -H B
(^ {]) \j\
H S
M4
+j
SCT ~
H E
k (1) &>
O S ~
/zlfl"
^7?
2S^1
lt*3
?3I2-
4J
4J .S''i
tt) 0) &i
2 S
65-0.4
2*
y( fl «
?4X
+ 2-
i4
.H
JJ O\
Ifl 4J C
H ^| -H -^
3 CJi 10 E
g -rH U) &
3 a) (0
U S PJ
^/ 7/'S
3&2\4
t4tf.s
4S*-e
z*u7
Z-2.1 -8
0)
>
H
4J 4J tJ>
10 C C
H 0) -H -->
3 O Bl *>
e ^ ID
3 0) IB
U ft (X
/»*«
SVV
JS-,*
/fl-f
67
n
M -H ^
g) i <« -H
o; m V4 g
rt £ 3 ^
W W Q
s-
i-
s~
' g-
^~
5-
4" 3"2H"2
No.
4
No. No.
8 10
No. No. No. No. No. No. No.
20 30 40 50 60 80 100
No.
200
No.
325
No. No. No. No. No. No. No. No.
* 8 10 16 20 30 40 50
SIEVE OPENING
No. No.
BO 100
No.
200
No.
326
100
126
15900
-------
KVB
SIEVE ANALYSIS TEST REPORT
TEST NO.
TEST SITE
SAMPLE IDENTIFICATION
DATE SAMPLE TAKEN_
TEST PERFORMED BY
Screen
Size
Passing
v en 0
ITS!!
^
V -rl £
0) V &>
as
nt
Perce
(*)
ative
t
gh
ssi
gm)
Wei
Pa
(
Cumulative
Percent
Passing
Sieve
Shaker
Duration
(min)
-rsp
V27.7
i*
i-r
.3
2 'At
4" 3"2W2" IK"
K» V
No.
V 4
No. No. No. No. No. No. No. No. No.
8 10 20 30 40 SO 60 80 100
No.
200
No.
325
4" 3'2K"2" 1H" 1'
K" V
''." No. No. No. No. No. No. Mo. No.
4 8 10 16 20 30 40 SO
SIEVE OPENING
No. No.
BO 100
No. No.
200 32S
127
15900
-------
KVB
SIEVE ANALYSIS TEST REPORT
TEST NO.
TEST SITE
SAMPLE IDENTIFICATION
DATE SAMPLE TAKEN
TEST PERFORMED BY
p>
c c
01 -H
01 tt> U)
n M in
O -H <0
in t/j ou
'fflp
1"
i"
J.M
**
*K
4J
£
Q) O1 --*
5 o) &
/I o.3
W .C
0 -H 1
M Q) O"1
0 *
^4M>2^
M/S
^.T
66*.3
JS1.2.
af7
** "H 1>
z a
12184
21*2-*
I2*f
&~l D
22f-1
#14
4J
C
0>
U *
t, ^^ r
(U
M.i
4^
m
^'i
34
82-
(U
-rl
4J Cr>
« -P C
-i j: -H ~
3 tyi w 6
g -H W En
3^S^
a ITO
^s- is- 1
P4rrs
/3V~t1-5
7I*£
537,^
?
H
JJ *J Cr-
rt C C
rH 01 "H .
3 U in *
g M W
3 01 <0
u & a.
/t>0.0
«/
37 r-
/f £
//.I
PJ
o
M -H -^
01 0) 4-> C
> x m -H
a) (9 ti e
-H JS. P
w w a
s-
s-
^
$
^
r*
100
4' 3"2Vi'2"
No.
H" V '<" «
No. No. No. No. No. No. No. No. No.
8 10 16 20 30 40 SO 80 100
No.
200
No.
325
1- V M- V
V No. No. No. No. No. No. No. No.
4 8 10 16 20 30 40 SO
SIEVE OPENING
No. No.
80 100
No.
200
No.
325
100
128
15900
-------
KVB
SIEVE ANALYSIS TEST REPORT
TEST NO.
TEST SITE
DATE SAMPLE TAKEN
TEST PERFORMED BY
SAMPLE IDENTIFICATION
I7>
C C
£ -H
0> Q) Ul
H N W
0 -H ed
U) tO O<
*~Jbp
/''
a
V
*fc
^
fk
4J
o> en ^
M -rl E
fd o u^
H S
//«.?
4J
W £
B) D1
0 * g
^ 9) o>
S*±_
'f£;f»tf
lit 7/ ^"
j!/^7 6*1
v^v 2'J»
77?, t
4J
/
+J -H 6
o *
I, ^.^
UJ
Oi
If.t
4i.+
13*
r\
10
St
01
M
4J pv
ra jj c
rH X -^ --
3 tn tfi 6
E -H W O>
3 a) * ~-
u 2 d,
*fr**
^2J|
4»*i4
itto*
lt>*tf.O
SJfc-8
g
^t
4J V Cr>
« C C
iH 01 -H .
§O U> <»
V4 W ^
d) n)
u a a,
foo-o
#41
Vjr
/f-7
//c
^t
c
o
U -H ~
Ol tt) 4J C
> X * -d
0) 10 >-i E
-H X 3
w w Q
r
r
4"2" 1H- 1"
No.
V 4
No. No.
8 10
No. No. No. No. No. No. No.
16 20 30 40 SO 80 100
No.
ZOO
No.
325
3"2VS"Z" 1H" 1" X"
V No. No. No. No. No. No. No. No. No. No.
4 8 10 16 20 30 40 SO 80 100
SIEVE OPENING
No.
ZOO
129
No.
32S
15900
-------
KVB
SIEVE ANALYSIS TEST REPORT
TEST NO.
TEST SITE
SAMPLE IDENTIFICATION
DATE SAMPLE TAKEN
TEST PERFORMED BY
e e
0) -H
0) flj U)
k N U)
O -H *
co co cu
C) tT> *-^
3 'a) 5>
t^ U ^**
St7>
H
_ -H e
M 0) 5>
O S ~
QJ G> &
2 S <-
e
O
0)
a
p DI
(fl 4J C
3 CT" W "g
E 'rl W &>
3 <1) 19 '
O S 0.
JJ 4J tyi
ro c c
-( 01 -H ^«
3 O U) dP
§ d) ns
U O. ft,
c
01 4) 4J
CJ (0 V4
W W Q
/ot-o
5"
J4/3 3
(,6-Z-
117.
/O-l
5"
£
$7
2554
100
No.
4
No. No. No. No. No. No. No. No. No.
8 10 IE 20 30 40 SO 80 100
'(." No. No. No. No. No. No. No. No.
4 < 10 16 20 30 40 SO
SIEVE OPENING
No. No.
SO 100
130
No.
200
No.
325
No. No.
200 325
100
15900
-------
SECTION 6.0
OVERFIRE AND TRAVERSES
PAGE
6,1 OVERFIRE AIR DATA SHEETS 132
131
-------
SMOKESTACK FLOW PROFI
TEST NO.
LOCATION NO._
DATE "
SAMPLING LOCATION
INSIDE OF FAR WALL TO
OUTSIDE OF NIPPLE,
INSIDE OF NEAR WALL TO_
OUTSIDE OF NIPPLE, (DISTANCE B)_
STACK I.D. (DISTANCE A - DISTANCE B)/ffifrSTK.
NEAREST UPSTREAM DISTURBANCE
NEAREST DOWNSTREAM DISTURBANCE
(DISTANCE A)
3/g" '
BAROMETRIC PRESS, in.H
STACK PRESS. ,Ps , iwg
GAS SP. GRAVITY,Gs
TRAVERSE
POINT
NUMBER
1.
2.
3.
4.
5.
6.
7.
8.
9.
10.
11.
12.
13.
14.
15.
16.
17.
18.
Average
% OF STACK
DIAMETER
3T_
/&h
t?'0tf- 0>0C>? *
a. &i o*>t>g *
Average
VA P(T + 460) 407 1.00 '
<5p (GT^>
STACK
TEMPERATURE
(Ts, °F
110
5
/
/
)
$
OXYGEN
ft
STACK GAS
SPEED, Vs
ft/min
1
"
^ -Sl»*^»-«A pHtf -<\^«
0^4
0tv>o- K/tfe. "S t*|P«_
( C." o %*,7j
132
60-23
rev. 11/74
-------
SMOKESTACK FLOW PROFILE
TEST NO.
LOCATION NO.
DATE
?l
LOCATION
INSIDE OF FAR WALL TO /4%t''
OUTSIDE OF NIPPLE, (DISTANCE A)_
INSIDE OF NEAR WALL TO 3jfr"
OUTSIDE OF NIPPLE, (DISTANCE B),
STACK I.D. (DISTANCE A - DISTANCE
BAROMETRIC PRESS, in.I
NEAREST UPSTREAM DISTURBANCE
NEAREST DOWNSTREAM DISTURBANCE
STACK PRESS.,Ps, iwg
_STK. GAS SP. GRAVITY,GS
TRAVERSE
POINT
NUMBER
1.
2.
3.
4.
5.
6.
7.
8.
9.
10.
11.
12.
13.
14.
15.
16.
17.
ifl.
flypragp
% OF STACK
DIAMETER
31
AJ'S"
/7f
3* 3
^7-7
ff»-fe
«7-2T
^«
STACK GAS,VS - 174 F
SPEED
DISTANCE
FROM
INSIDE HALL
3'V
4%«
fe-VSr"
S/t"
f4^"
ffc».'
I i/ «
/'y %"
VELOCITY
HEAD
( Aps), in. HS0
^>P/ ^"S-
&
STACK
TEMPERATURE
fct
OS«*t
otUAt,cPc ^tiipc,
^<:* o-a^l
133
60-23
rev. 11/74
-------
SMOKESTACK FLOW PROFILE
TEST NO.
LOCATION NO._
DATE
SAMPLING LOCATION f?OMT
INSIDE OF FAR WALL TO
OUTSIDE OF NIPPLE, (DISTANCE A)
INSIDE OF NEAR WALL TO
OUTSIDE OF NIPPLE,
BAROMETRIC PRESS,in.H
(DISTANCE B)
STACK PRESS.,Ps, iwg
STACK I.D. (DISTANCE A - DISTANCE B)/6%STK. GAS SP. GRAVITY,GS
NEAREST UPSTREAM DISTURBANCE ~
NEAREST DOWNSTREAM DISTURBANCE
of*
TRAVERSE
POINT
NUMBER
1.
2.
3.
4.
5.
6.
7.
8.
9.
10.
11.
12.
13.
14.
15.
16.
17.
18.
Average
* OF STACK
DIAMETER
3-z
^T
n.+
32-3
67-7
**+*
tfsr
W-t
STACK GAS,VS - 174 FB
SPEED
DISTANCE
FROM
INSIDE WALL
J'/lfe "
^>/r "
^Vr"
f^'A"
14 rr
»t /z"
^
/^^r"
VELOCITY
HEAD
( Ap ), in. HO
0 9
^?- Ap,.
O"3t- d'ZS"
e-5< ^>^7
£><
7 0-^3
»-Vf *,* *
^3^ o>*L *-
£>>57 0,10 *
tf-Jo *>-e>8 *
Average
/)/ A P(T +460) 407 1.00 '
V s <5p (5^
STACK
TEMPERATURE
?
(c- 0-^7)
134
60-23
rev. 11/74
-------
TECHNICAL REPORT DATA
(Please read Instructions on the reverse before completing)
REPORT NO.
EPA-600/7-80-13 7b
2.
3. RECIPIENT'S ACCESSION NO.
. TITLE ANDSUBTITLE
Field Tests of Industrial Stoker Coal-fired Boilers for
Emissions Control and Efficiency Improvement--
Site J (Data Supplement)
5. REPORT DATE
May 1980
6. PERFORMING ORGANIZATION CODE
AUTHOR(S)
J. O. Burlingame, R.A.Parker, W.M. Jackson, and
J.D. Demont
8. PERFORMING ORGANIZATION REPORT NO.
PERFORMING ORGANIZATION NAME AND ADDRESS
KVB, Inc.
6176 Olson Memorial Highway
Minneapolis, Minnesota 55422
10. PROGRAM ELEMENT NO.
EHE-624
11. CONTRACT/GRANT NO.
EPA-IAG-D7-E681 and
DoE-EF-77-C-01-2609
2. SPONSORING AGENCY NAME AND ADDRESS
EPA, Office of Research and Development*
Industrial Environmental Research Laboratory
Research Triangle Park, NC 27711
13. TYPE OF REPORT AND PERIOD COVERED
Supplement; 6/79
14. SPONSORING AGENCY CODE
EPA/600/13
15. SUPPLEMENTARY NOTES (*)Cosponsors are DoE and the American Boiler Manufacturers
Assn. Project officers are R.Hall (EPA) and W.Harvey Jr. (DoE). The final tech -
nical report is
"a" of this same series.
16. ABSTRACT rp^ Qata Supplement is a compilation of test data presented in greater de-
tail than was practical in the fiii«j. technical report. It is intended to provide the
necessary details to other researchers who are interested in performing their own
analysis. Readers are referred to the contract final report for information as to
objectives, description of facility tested and coals fired, test equipment and proce-
dures, interpretations, and conclusions. The final technical report also contains
data summaries not found in this Supplement. The Supplement contains panel board
data for each test, detailed particulate, O2, CO2, NO, SO2, and SOS
data, particle size distribution data, chemical analysis of the coal, coal size consis-
tency data, and combustible analysis and overfire air traverse data.
17.
KEY WORDS AND DOCUMENT ANALYSIS
DESCRIPTORS
b.IDENTIFIERS/OPEN ENDED TERMS
c. COSATI Field/Group
Air Pollution
Boilers
Combustion
Coal
Field Tests
]>ast
Stokers
Improvement
Efficiency
Flue Gases
Fly Ash
Particle Size
Nitrogen Oxides
Sulfur Oxides
Air Pollution Control
Stationary Sources
Combustion Modification
Spreader Stokers
Particulate
Overfire Air
13B
13A
2 IB
2 ID
14B
11G
07B
T3~D"lSTRIBUTlON STATEMENT
Release to Public
19. SECURITY CLASS (This Report/
Unclassified
21. NO. Of PAGES
143
20 SECURITY CLASS (This page)
Unclassified
22. PRICE
EPA Form 2220-1 (9-73)
135
------- |