ENVIRONMENTAL PROTECTION AGENCY
OFFICE OF ENFORCEMENT
EPA-33C/2-77-007-A
TECHNICAL ADDENDUM
Coke Plant Evaluation
Kaiser Steel Corporation
Eontana. California
(JANUARY 2 5 - 2 7, 1 9 7 7)
NATIONAL ENFORCEMENT INVESTIGATIONS CENTER
DENVER COLORADO
AND
DIVISION OF STAT'CNARY SOURCE ENFORCEMENT
W ASHINGTON D C
sp
I *
U3Z2I
MARCH 1 9 7 7
-------
Page Intentionally Blank
-------
Environmental Protection Agency
Office of Enforcement
EPA-230/2-77-007-A
TECHNICAL ADDENDUM
COKE PLANT EVALUATION
KAISER STEEL CORPORATION
FONTANA, CALIFORNIA
(January 25-27, 1977)
March 1977
National Enforcement Investigations Center - Denver, Colorado
and
Division of Stationary Source Enforcement - Washington, D.C.
-------
TECHNICAL ADDENDUM
BACKGROUND
At the request of EPA Region IX, personnel from the NEIC and EPA
Division of Stationary Source Enforcement (DSSE) conducted an inspection
of the Kaiser Steel Corporation coke plant on January 25-27, 1977. The
objective was to determine what specific steps the Company could take,
but has not, to meet the terms of the April 26, 1976 Consent Decree or
to minimize visible emissions. The results of the NEIC-DSSE inspection
are contained in Coke Plant Evaluation3 Kaiser Steel Corporations Fontana,
California.
As an adjunct to the primary objective of the January 25-27, 1977
inspection, visible emissions observations (VEO's) were conducted. The
purpose of the VEO's was to obtain a VEO data base comparable to that
obtained by the NEIC at other coke batteries. These data, along with
process data gathered at Kaiser, were then compared with other coke
plant VEO and process observation data to support conclusions drawn
about the operational practices employed by Kaiser.
VISIBLE EMISSION OBSERVATION RESULTS
The methods which were used to conduct visible emission observations
(VEO's) at Kaiser are identical to those employed by the NEIC at other
coke batteries. Method A was used for charging, Method C for doors, and
Method H for tops ides; these methods are described in Appendix A.
Appendix B contains copies of all the field data forms.
-------
On January 25 and 26, only door emission observations were conducted.
For each of the three operating units, all doors were observed five to
six times each. Battery C was read with batteries A and B and with
batteries D and E. The results of the door emission observations are
contained in Table 1.
On January 27, one observer read charging emissions while the other
made topside emission observations. Ten charges were observed on each
operating unit. Topsides of each battery were observed at least twice.
The results of the charging emission observations are presented in
Table 2; the results of the topsides emission observations are found in
Table 3.
-------
Table 1
DOOR EMISSIONS
0-
Batteries
Time
Inspection
Completed
/% Learl
cinc\ Door^
Push
Side
Ay'g. for/
Speratinfg
)/ Unit I
CAke A>g. for
Sitte Operating
\ Unit
r
ABC
11:31
11.5 12. c.
12.9
21.5 g*-
19.9
ABC
14:13
17,0 17,3
12.9
17.8 otL
19.9
ABC
14:50
©*.14.4 /*.*
12.9
23 **5
19.9
ABC
15:40
10.4
12.9
18.5 o*
19.9
ABC
16:50
11.1
*3.7
12.9
18.5 OZ
19.9
CDE
7:47
8.5
B4
9.3
18.5
20.6
CDE
9:04
9.6
io>f
9.3
20.0 OIL
20.6
CDE
10:03
13.3
1*4
9.3
16.3 ot
20.6
FG
10:40
11.1
13-5
8.9
0£5.5
9.2
FG
11:06
13.3
#3.S
8.9
o*-8.8 $,f
9.2
FG
11:30
7.2
e-3
8.9
€>*Q. 8 8>1
9.2
FG
12:01
6.6
72
8.9
12,2 ot.
9.2
CDE
14:05
ot7.7
7-0
9.3
28.0 26.1
20.6
CDE
14:41
7.4
78
9.3
20.0 ©it
20.6
FG
15:24
7.7
s.s
8.9
10.0 ot.
9.2
FG
16:32
OK7.7
70
8.9
10.0 H.j
9.2
t Each push side door was counted as two to include the chuck doors.
-------
Table 2
CHABGING EMISSIONS
Battery Oven Time (seconds >20% opacity)
Number By Oven Average Average
for for
Battery Operating
Unit
A
27
111
43.7
38.1
A
37
15
43.7
38.1
A
47
5
43.7
38.1
B
57
10
47.4
38.1
B
67
23
47.4
38.1
B
77
160
47.4
38.1
B
87
27
47.4
38.1
B
97
17
47.4
38.1
C
107
6
5.5
38.1
C
117
7
5.5
38.1
E
225
22
13.2
8.3
C
127
2
5.5
8.3
C
137
7
5.5
8.3
D
157
7
6.9
8.3
D
167
6
6.9
8.3
D
177
4.5
6.9
8.3
D
187
7
6.9
8.3
D
197
10
6.9
8.3
E
207
8.5
13.2
8.3
E
217
9
13.2
8.3
F
263
17
19
24.0
F
273
43
19
24.0
F
283
9
19
24.0
F
293
12
19
24.0
G
303
65
29.1
24.0
G
313
32.5
29.1
24.0
G
323
24
29.1
24.0
G
333
5.5
29.1
24.0
G
343
18.5
29.1
24.0
F
255
14
19
24.0
-------
Table 3
TOPSIDE EMISSIONS
Battery Time Inspection
Completed
A
8:26
B
8:44
C
9:30
A
10:01
B
10:11
E
10:45
D
10:57
C
11:10
D
11:24
E
11:44
F
14:01
G
14:19
F
15:06
G
15:23
F
15:34
G
15:42
% Leaking % Offtake
Lids System Leaks
1.5
13.3
1.5
21.1
0.7
10.1
0
16.7
5.2
12.2
2.2
12.2
0
7.8
2.2
7.8
0
5.6
2.2
13.3
2.2
13.3
0.7
3.3
3.7
11.1
10.4
7.8
0.7
5.6
13.3
8.9
-------
APPENDIX A
VISIBLE EMISSION OBSERVATION METHODS
-------
32
METHOD A
The inspector will observe charging emissions from the topside of
the battery. The inspector may observe charging emissions from either
side of the larry car and from a location which permits a clear view of
possible emission points, i.e., charging ports and hoppers.
The charging cycle begins when the coal is first introduced into
the oven and ends when the last charging lid is replaced on an oven.
During the charging cycle, the inspector will observe emissions
from the charging ports as well as all emission points on the larry car.
The heaviest emission occurring at any given time during the charging
cycle will be observed and an opacity determination will be made at the
densest point of the emission as read against any contrasting back-
ground. All such emissions which equal or exceed 20% opacity (equiva-
lent to No. 1 Ringelmann) will be timed with a stopwatch and recorded.
The maximum "opacity observed during the charging cycle will also be
recorded.
-------
33
METHOD C
The .inspector will make his observations of door emissions from a
location as close to the battery as safety and visibility conditions
permit, but generally outside of the pusher machine or hot car tracks.
The inspector may move to a closer observation point to determine the
source of an emission.
The inspector will start the observation with an oven at either end
of the battery and on either the push side or the coke side of the
battery. The inspector will observe and record any visible emission
from a door. Visible emission from the sealing edge around the per-
imeter of a door, or, in the case of the pusher side, from the door and
the chuck door will be considered as door emissions. After the in-
spector has made a visible inspection of the door perimeter for door
emissions, a single determination of the opacity of the door emissions
shall be made at a point above the door, using the battery as a back-
ground. This area is commonly referred to as the lintel. Visible emis-
sions from structural leaks, such as buckstay or lintel leaks, will not
be considered as door emissions.
The inspector will then move to the adjacent door, if possible, and
check for door emissions in a like manner. The inspector will continue
this procedure down the entire length of the battery. If a temporary
machine obstruction occurs blocking his view of a series of ovens he may
bypass those ovens and continue down the remainder of the battery,
returning to check the bypassed ovens when he has completed that side of
the battery.
-------
METHOD H
The visible emissions produced from leaking offtake systems, top-
side lids, and collector mains are determined visually by an observer
who is familiar with coke oven battery operations. Two runs (inspec-
tions) of the coke oven battery are required for determining compliance
with any one of the separate emission standards for topside port lids,
offtake systems and stationary jumper pipes.
The observer "inspects" the coke oven battery by traveling the
length of the battery at a steady pace, pausing only to make appro-
priate entries on the topside inspection sheet. Each time the ob-
server travels one length of the coke oven battery a run is completed.
He should travel at a normal walking pace and should take approxi-
mately four minutes (70 oven battery) to complete each run. A rate of
six seconds per oven for each run is the maximum amount of time per-
mitted. In performing a run, the observer walks down the centerline
of the battery looking far enough ahead (two to four ovens) of his
travel to easily see the oven lids, stationary jumper pipes, or offtake
systems. If the emissions to be inspected cannot be observed from the
battery centerline, an alternate location may be used (e.g., a catwalk).
During any one run, the observer may record total visible emissions
from around oven lids, or may record total emissions from offtake sys-
tems and stationary jumper pipes.
Oven lids, with visible emissions are recorded as appropriate on
the topside inspection data sheet. Offtake systems and stationary
jumper pipes with visible emissions are recorded as appropriate on the
topside inspection data sheet; both total and significant emissions
are recorded. Both total and significant leaks are recorded during a
-------
35
single traverse. Upon noting and recording a leak from an offtake or
stationary jumper, the observer determines whether or not the leak is
"significant;" if the leak is "significant," the observer records this
in the appropriate column on the topside inspection data sheet. For
purposes of this method, all leaks greater than one (1) meter in length
are considered significant; all leaks less than one (1) meter in length
are considered insignificant and are not counted or recorded as signif-
icant leaks. In addition, the following emissions are not recorded:
Visible emissions from oven lids and standpipe caps that are
opened during a decarbonization period or charging period.
Visible emissions caused by maintenance work in progress at an
oven.
Steam emissions: this includes steam caused by the vaporization
of wet luting material.
Regardless of the number of points from which visible emissions
are observed from any one oven lid, offtake system, or stationary
jumper pipe, a single entry is to be made; i.e., the maximum entry
for an oven with a single offtake system is "1" and for a double main
oven "2". The maximum lid leaks recorded for an oven with four oven
ports is "4". A stationary jumper pipe connecting two ovens is
counted as one unit; i.e., there are about one-half as many jumper
pipes as ovens. For any one jumper pipe, the maximum entry will be
"1", even though the pipe could be leaking at the junction to two ovens.
-------
APPENDIX B
FIELD DATA FORMS
-------
5
tfage
J—°< JL
PROCESS DATA
PERSONNEL ACTIVITIES
COMPANY
l.OCATON
t
INSPECTOR
datf //*2-~<^/77
Larry car Inspectoi
Topside Inspector
Coke Side Inbpoctoi
PlIS1* Sid" 'n^pcCOF
BATTrRV
o
Indicntc worker job title, number of persons working at this iob an^ brief
Job description, at the beginning of each day an^ when pe^son^ek change* are
nt2dc. Indicate spells provided by relief man.
TliE
Worker
Title
Dest-riptior» 9^ Operations Performed
' ' / * '
/57C
F'Tl OJXAC&.
* f
u — AsJfe&s? yfc/? s'&/A
C +j fZ " V Cs\ CL4 r* <,
p/?? f-aJpu
— 'stA*"
10,10
-it*'){¦
I
1
t
0&&£" '~C<3zcoe* C'yS y
1
\
-------
lx»:i !'iutu!>.> List
Observer
Date / - %-">
Plant- &\.f {
Ba t te ry <¦->/ ctf-^s ;r ,
^ Latching Seq.
Cleaning
on Removal
Knife Edge
Clean
Gas Channel
Chuck Door
Jamb
Oven
No.
^cfrac
-nite
rda<->
Dcpos
Remairu
Both
@Once
Depos
Remain
~epos
ClearfRemair
Bot.
Time
Finisl
mam
tnrv
m
/fc
fi
*
/- yes
X - no
r- which applies
Enter:
1-N'o damage on door, knife edge (no
dents, cracks, nussmq sect.)
2-Physical damage (cracks, deforma-
tions, missing sect.)
-3-Carbon deposits
a4-Tr door is replaced with a fresh
door in this cycle
-------
Observer
Date
PKnne jO ^AtW"
w (9
Door Machine Push Si
Door Machine Coke Side
Condition of Door
Removal
Cleaning
Adjustments
Latching Seq.
Chuck
Knife
Gas Channel
Time of
Removal
cfrac
torv
Knife
Cdos
Depos
Both
@Once
Depos
Remain
Depos
Remain
Depos
Cleanhemn
Time
Finisl
Clean
Scmaiaciean
Clean
Sect.
B
f
I
J
}Ul*
Enter:
1-No damage on door, knife cd
-------
Uoi;i I'O-ice:
Li;, I.
Observer
n* <• f -—
Plant__^kl^V
r Cr-
Batj^AtyO-
w •
o
o
n
m
JS
in o
O OJ
n h u
n rr
H* 3*
O
,
D
N)
f
H*
3
Os rr
P
Door Machine Push Side,
Door Machine Coke Side
^3
Condition of Door
Adjustments
Time of
Renova1
Cleaning
Latching Seq.
Knife Edge
Gas Channel
Chuck Door
Oven
iOufe
Cdrr£
Depo
Remain
Both
@Once
Depos
Remain
pepos
CleanJReirair
Time
Finisl
RemairvClean
Clean
Clean
Sect.
V
¥
I
Enter:
/- yes
X - no
7- which applies
1-N'o damage on door, knife edge (np
dent?, cracks, missing sect.)
2-Physical damage (cracks, deforma-
tions, missing sect.)
,3-Carbon deposits . ,
l4-Jf door is replaced with a fresh
door in this cycle
-------
Page / of (_
PROCESS DATA
PUSHER MACHINE INSPECTOR
COMPANY
LOCATION
fboblA* INSPECTOR sA^fi V
N DATE —l£s-fn
OVEN
o*D,
lilh^
APPEARANCE OF COKC FACE
Check Yes (/) or No (X)
Partial (P) or Whole(W)
TIME OF
PUSH
ELAfSED
PUSH
PERIOD
(see)
CHUCK DOOR OPERATION
Check Yes ("/) or No (/)
comment
NUMBER
CLOSED | LATCHED
1 lGliTENED
LIAXIMG
ELAPSED TIME
DOOR OPEN
ELFORE LEVEL
BAR STARTS
/V(sec) ^
SMOKE
FLAME
ft/it
. ¦
\
l/
/
/
9
*¦'17
Ate
tfD
N3>
\
1/
y
y
/j.si-'y
%X%
3:f7
1!
/'
\
v/
y
Af'jw
hio
fi-b
¦t
If
~
y
y
9
147
5,k
ft
n
y
y^.
\j(£&
8
/:S4
4i
H
u
i
~
y
s*
8,
/••/?
M
i<
Hmz.
X
sk
It
it
/
1/
y
/I
231
(
t>ki
/•
1/
COMMENTS:
(pt)" cJCDr &p*A\$A -j-J fjwke boof" 'i
fOD - no^cf&U rtuftdttj* 40 ijtf&AAiwml ofd&M p/^
N
<1
-------
PROCESS DATA
COKE OVEN CONDITION
COMPANY
LOCATION
(2> - Vo-
INSPECTOR _
DATE 1/^/77
{hz2{&r~\
Page / of
Coke Side Inspector
rush Side Inspector
(
UVEN jBROKEN REFRACTORY AT
DOOR AREA
Check:
Yes(»^)
No (x)
Indicate
Location:(X)
(End View)
DARK. (ClU)) SPOTS ON SIDE WALLS
Che ck:
¥es(^)
No (x)
Indicate Location: (X)
(Top View)
OVEN ROOF
Ul
CARBON BUILDUP
ustate:
End View
Side View (best estimate)
(Indicate standpipe and oven holes)
cs
ps
f+frf—f~i—rHi
cs 2>f-&K4 ps
p/
4$-
% i
-------
COMPANY
PROCESS DATA
COK.E OVEN CONDITION
INSPECTOR
LOCATION
DATE
//z%/77
3 CsSXff\,
Page 2*. of
Coke Side Inspector
rush Side Inspector
i
OVEN 1 BROKEN REFRACTORY AT
DOUR AREA
Check:
Yes(/)
No (x)
Indicste
Location:(X)
(End View)
DARK (COlD) SPOTS ON SIDE WALLS
Check:
Yes {/) ¦
ifc*. (x)
Indicate Location: (X)
(Top View)
OVEN ROOF CARBON BUILDUP
Illustate:
End View
Side View (best estimate)
(Indicate standpipe and oven holes)
8i
t
cs
T/-2^
%
I
if
Y
OK-
COMMENTS:
-------
zr
*age
1
of
PROCESS DATA
PERSONNEL ACTIVITIES
Larry car Inspcctoi
Topside I nspeccur
Coke Side Inspcctoi
Pusu Sid" 1nspec"o1
COMPANY l5t.fC INSPECTOR \) A 0/ ^
I.OCATION /v'1 / C^l DATP ^/ /
/7y
Indi cato worker job title, number of per sons wording at this iob an^ brief
Job description, at the beginning of each day an^ when personnel change* are
made. Indicate soells provided by relief man.
3ATTPRV /,
IBs
TltlE
Worker
Title
DesrnpLion o* Operations Performed
•
//,*56
{
rS-7 -/C-. -
,
I
J
<8
-------
Observer
Date
Plant
Battery.
¦SM±
in o
"
D CJ
O ri W
rt rr
h* y*
0
p
N>
t-*
3
0>> rr
O
Door Macnir.c Push Sluo
Door Machine Coke Sida
Condition of Door
APPEARANCE OF CO:
-------
CTi rt
Observer
Date
Plant
Battery—
APPEARANCE UF COKE FACE
Condition of Door
on Removal
Partial (P) or Uhole(W)
SMOKE
Jamb
Knife Edge Gas Channel Chuck Door
Depot. Dcpoi;
tcinamciean Kcm.ni Clean
Time of
Removal
Oven
No.
Cas
Chan
Clean
Cleariiveipair
Sect.
LS
Enter:
1-Ko damage on door, knifo edge (nq
dents, cracks, missing sect.)
2-Physical .dax.age (cracks, deforma-
tions, missing sect.)
al-Ttr^opr
-------
7
.0Kc.
Jamb
Knife Edge
Gar, Channel
Chuck Door
;cfrac
:nife
DCpOo
nopo
'icinni t
Dcpo
Remain
Clean
tcinni njClran
Clean
Sect.
tnr
h
?
* & ~ yes
02-no
Enter:
1-No damage on door, kmfo edgo (nq
dents, cracks, nusmq sect.)
2-Physical danage (cracks, deforma-
tions, msSing soct.)
,3-Carbon deposits ,
a4-7r door is replaced with a fresh
* door in this cycle
-------
Observer
Dato L
Plant
Battery_
ftfl.Oi
1-<1 ,nl
Lxj \
M O
o p
O 1
n rr
h* :r
o
p
V/1
-
N>
M
r
p-
ri-
ft
M
Door Machine Push Sido
Door Machine Coke Sice
Condition of Door
APPEARANCE OF COXE FACE
Chock Yes U) or No (p)
1 Partial (P) or Vhole(w)
Time of
Removal
Cleaning
s>:oke
FLANr.
Chuck Door
Jamb
Knife Edge
Gas Channel
Oven
;cfrac
Knife
ucpo
iJcin.nn
Oopo
Remain
pepos
Clcatjivcnnin
CJ can
icmi n,Cl^oii
Clean
Sect.
rrlno
k
* £jf~ yes
Q%- 0°
Enter:
1-No damage on door, knifo edge (nq
dent?, cracks, musing sect.)
2-Physical damage (cracks, deforma-
tions, nissmg sect.)
,3-Carbon deposits , , ,
a<-Tr dopr is replaced with a fresh
' door in this cycle
-------
Page / of
PROCESS DATA
COKE OVEN CONDITION Coke Side Inspector
rush Side Inspector
in c/r
LOCATION j'
BATTERY
INSPECTOR
COMPANY
c- /
DATE
-------
^ of f
PROCESS DATA
COKE OVEN CONDITION Coke Side Inspector
CO! IP ANY jf/? INSPECTOR \/4 T) ////."X) BATTERY
location Tpwa vA DArE / / ^ y ~)n
Page
Cot
rush Side Inspector
OVEN ROOF CARBON BUILDUP
DARK (COlD) SPOTS ON SIDE WALLS
UVEN , BROKEN REFRACTORY AT
DOUR AREA
indicate Location: (X)
(Top View)
IIlustate:
Check:
Yes (>/)
No (x)
Indicate
Location:(X)
(End View)
Check:
Yes(/)
No (x)
Side View (best estimate)
End View
cs
cs
cs
ps
cs
cs
COMMENTS:
-------
PROCESS DATA
COK.E UVEN CONDITION
Page
3_of J=_
COMPANY
LOCATION
Coke Side Inspector
tush Side Inspector
BATTERY
INSPECTOR.
n -v <4
UVEN ROOF CARBON BUILDUP
Illustate:
DARK. (COlD) SPOTS ON SIDE WALLS
UVEN , BROKEN REFRACfORY AT
DOUR AREA
Indicate Location: (X)
(Top View)
Chcc'
Yes C^)
No (x)
Indicate
Location:(X)
(End View)
Check:
Yes(/)
No (x)
Side View (best estimate)
(Indicate standpipe and uven holes)
End View
CUMMENTS:
-------
PROCESS DATA
COKE OVEN CONDITION
COMPANY
LOCATION 1^/1 ft } / /I /V A-
INSPECTOR
DATE ±
sM Oc
Page ^ of
Coke Side Inspector
fush Side Inspector
BATTERY
OVEN ROOF CARBON BUILDUP
Lllustate:
DARK (COlD) SPOTS ON SIDE WALLS
OVEN BROKEN REFRACTORY AT
DOOR AREA
Indicate Location: (X)
(Top View)
Check:
Yes(^)
s-^o (x)
Check:
Yes(/)
No (x)
Indica te
Location:(X)
(End View)
Side View (best estimate)
(Indicate standpipe and uven holes)
End View
COMMENTS:
-------
5-
TEAM LEADER
/C,-Q
INSPECTOR
DATE Ort^t.f t-ciA-isj / «
SPARE DOORS
Battery
T ime
6 (co^0
/,/•¦ w
tf.M
Number
PS
cs
/ ?
o
COMMENTS
^ U> A-'
/^s - 3cks^-s, - /
J j cJcU-v*,,
/-
p3 tLf-cn I Jf lo C > L. u. ' /t. /¦' 1 -^ ¦
,S£J[Z.
1.
lv0 3~
f? ?7
0
j/C36
0
&jy_
'j?M_
o
o_
/Wv~> ^ icy / ¦ ¦ , ....
.y^dSK, r CU1 Jjf&S/ ¦
n
-------
rage of
PROCESS DATA
CATWALK INSPECTOR
COMPANY KflU AJ.V
LOCATION j Q\
DtlTCDV A J"
DATE
^ . J5-; /97 7
! !m&.
^5^
uvc^r
Aspiration
Steam Pressure
¥5
Col lc
I 'a
Press
CS
cior
.1
u rc
\ Standpipo Carbon
Vllustrqte carbon buildup)
COMMEN r/
NUMBER
Static Liynannc
Punier Si do
Coke Side
10\ 0.1 ^
75"-
r j^r
\ \J
Q
J6"2V
/
5^
i
Oo
Oo
<^53 "O
5"
l-z.
I55S
3?
/&CTG
8
S-°t
o
\
1
COMMENTS:
/'
-------
;T
tfage
I of i
PROCESS DATA
PERSONNEL ACTIVITIES
COMPANY
T.OCATION f'eUTfiNk
INSPECTOR S
DATF Kh/»
Larry car InspccCot
Topside Inspector
idc inspec Cot
Pusu Sid" Tnspcc'o*
3ATTFRV /0 "g. 1 C
Indicate worker job title, number of persons working at this iob anH brief
Job dpscription, at the beginning of each day an^ when personnel change<= are
made. Indicate spells provided by relief man.
TIME
Wot ker
Title
Description pr Operations Performed
•
//• ^
/-Cl'tZCj (?>SCfs£
J
/r(C£f*rj* ; / J/!~f£c
31. oz.
CaKr
0/>£^r£r, TPjjsi . 5/ws &*£ , yf
7SZ>£?c ////;<
'Z^WS , TS'er/c/t
-------
Observer J ^ KorVifiS
n,-ifr> \j *-'//~>1
Plant
Battery.
7T77T
h
or
U1
en o
'
(0 fi)
n fi w
rt rr
p, 3*
O
3
N>
H-
3
0> PT
fD
(Door Machine Push Sidcj
Door Machine cone ^ilcfe
I
a
Time of
Removal
Oven
No.
Sect.
or
^efrac
to»-v
i Rerao1
Knife
rdar?
>/al
Gas
Chan
Knife
Clean
Edge
Dcpos
domain
Gas C
Gas
Clean
Clca
lannel
Dcpos
llcmair
ling
Chuck
Clean
Door
Dcpos
Remain
J
Clean
amb
Dcpos
'tamair
Late
Too
Bot.
hing S
Bot.
Top
sq.
Both
@0nce
Ad jus
Time
Start
tments
Time
Finis!
//.OS
r, 7
©
3
1
/
o
Q
(7
/
0
©
3
1
/
0
0
/'
0
0
©
3
1
I
0
/
0
0
*3
1
1
V
o
/
0
/
©
!
1
1
0
0
0
/
/
©
1
1 ' '
1
0
0
O
0
-
/
!/:ZS
9
m
©
I
/
0
0,
0
/
0
—
©
1
1
Q
0
/
5
-------
Observer <3-^ Hp'PKiMj
Da to _4Z^Z22_Z_Z
Plant _J<£lSlJi
Ba t tc ry AjE» £ c'
rc
co a>
Q D
o i w
rt rr
M 3"
0
P
ro
M
3
ON rt
to
(goor Machine Push Side)
Door Machine Coke Side
4*
a
Time of
Removal
Oven
No.
Sect.
or
?cfrac
t-orv
Remo1
Knife
/al
Ga s
Chan
Knife
Clean
Edge
Depoo
Kcinain
Gas CI
Gas
Clean
Cleai
lannel
Depos
ttoinair
ling
Chuck
Clean
Door
Depos
Remain
J
Clear
amb
Depos
Remain
Late
Top
Bot.
hing S
Bot.
Top
aq.
Both
@Once
Ad jus
Time
Start
tments
Tine
Finis!
M
0
a
0
/
0
/
0
/
©
1
1
3
0
a
/
a
0
©
1
1
O
0
o
/
/
0
1
i'
3
Q
0
0
/'
\
0
;/'Sir
39
©
?
i
3
(T
0
0
/
e
Q
/
©
/
i
i
a
$
/
Q
c
/
©
I
i
i
0
(f
/
-------
ui'«,i : lui_<
Ob s o r v o r
n.^„ l/zr,/m
Plant _t£]VLir_
o
11
x
(n a>
a 91
O ii Oj
rr rr
H. zf
O
9
fl a 11 c ry_5iLlIZ^
•C"
ro
opr Machine Push Side
Side
p
o> n
o
Door Mac
Condition of Door
on Removal
Cleaning
a
Time of
Removal
Oven
No.
Sect.
\efrac
COKV
'-Uaife
IMao
Gas
Chan
Knife
Clean
Edge
Depos
Ucmairt
Cas C
Gqs
Clean
iannel
Depos
Rcinair
Chuck
Clean
Door
Depos
Remain
Jamb
Depos
CleaiTrtcm.nn
Late
Top
Bot.
hing S
Bot.
Top
eq.
Both
@Once
Time
Start
Time
Finis!
A T2
97
o
1
fOl
3
0
0
0
/
G
O
i
©
/
o
0
/
Q
/
/
©
0
/
\
,
'
-'I
l
t
>
J
0
/
\
)
.
i'
z:n
/
0
0
0
©
3
\
J
0
a
0
V
I
\)
V
\
Enter:
1-No damage on door, knife edge (nq
dent?, cracks, missing sect.)
2-Physical damage (cracJts, deforma-
tions, missing soct.)
a4-lfr^oprdis°replaced with a fresh
door in this cycle
/- yes
fi)
/- which applies
Adjustments
J
-------
,r J. C
Observer
Da to
Plant.
f wV >*'*s
Ba t tc r y_£^5L4_i£;
0
n
tE
Ui
in rD
C) d>
o i-i
rr rr
h** ST
0
,
3
N>
J—
t-1
P
C* rr
Q
Joor Machine Push Si5^
Door^HaWrfrrnTToke Side
a
Time of
Removal
Oven
No.
Snct .
or
vcCrac
torv
Remo
"jiife
Tfldf
/al
Gas
Clian
Knife
Clean
Edge
Dopos
'ninaln
Gas C
Gas
Clean
Cleai
lannel
Depos
Ucimii-
ung
Chuck
Clean
Door
Dopos
Remain
J
ClCcU
amb
pepos
iJnrt.T l r
Late
Top
Bot.
hing S
Bot.
Top
eq.
Both
POnce
Ad jus
Time
Start
tments
Time
Finis!
i-?e,
z
0
1
1
?
0
0
0
J
(9
0
0
0
©
1
1
?
/
0
0
/
©
1
1
2
/
o
0
!?
0
1
/
3
/
J
/
/
©
J
i
/
0
o
0
/
©
1
/" "
,7
\
i
1
0
/
1
J
0
0
2747
JL
©
3,1-
f
\T3>
&
0
0
0
0
0{
0
©
~ V
b&
/
o
x'
©
1
' 6
/
0
©
)£3
<3,
/
O
©
1
j
o
0
©
'*5
S* *>
V.
0
(
)
J
©
©
©
©
©
©
Enter:
1-N'o damage on door, knifo edge (nq
dents, cracks, missing sect.)
2-Physical damage (cracfcs, deforma-
tions, mssing sect.)
a4-llr^oprdis°feplaced with a fresh
door in this cycle
/- yes
x - no
/- which applies
-------
Page 1 of
PROCESS DATA
COKE OVEN CONDITION Coke Side Inspsc.tyr
(rush Side Inspecto^
COMPANY KftlSTR. INSPECTOR J. Uop*INt BATTERY A fifv
LOCATION Ck DATE \f lc>j 1l
OVEN ROOF CARBOM BUILDUP
DARK (COlD) SPOTS ON SIDE WALL
OVEN , BROKEN REFRACTORY AT
DOUR AREA
Indicate Location/ (X)
(Top View) /
lllustate:
Check:
Yes(/)
No (x)
Indicate
Location:(X)
(End View)
Side View (best estimate)
(Indicate standpipe and uven holes)
End View
ps
cs
cs
cs
cs
ps
cs
cs
COMMENTS:
-------
Page 7- of ^
PROCESS DATA
COK.E OVEN CONDITION
Coke Side Inspector
p^ush Side Inspector,
J.
A ii¦ L.I
BATTERY
INSPECTOR
COMPANY
DATE
LOCATION
OVEN ROOF CARBON BUILDUP
DARK (COlD) SPOTS ON SIDE WALLS
UVEN ; BROKEN REFRACTORY AT
DOUR AREA
Indicate Locaty6n:(X)
(Top View)
Illustate:
Indicate
Location:(X)
(End View)
Check:
Yes(/)
No (x)
Side View (best estimate)
(Indicate standpipe and uven holes)
End View
cs
cs
cs
cs
cs
cs
COMMENTS:
-------
Page "3 of
PROCESS DATA
COKE OVEN CONDITION Coke Side Inspector
frush Side Inspector
COMPANY M'
LOCATION DATE j 77
I
OVEN ,BROKEN REFRACTORY AT
DOUR AREA
Check:
Yes(/)
No (x)
Indicate
Location:(X)
(End View)
DARK (COlD) SPOTS ON SIDE WALLS
Check:
Yes {/) ¦
No (x)
Indicate Location: (X)
(Top View)
OVEN ROOF CARBON BUILDUP
11 lustate:
End View
Side View (best estimate)
(Indicate standpipe and oven holes)
79
>
cs
ps
1
1
7<
/n
X
X
COMMENTS:
-------
COMPANY failed
LOCATION [*"o^7Ar^^ .
PROCESS DATA
COKE OVCN CONDITION
INSPECTOR i UofNirK
DATE
Page
4
of
4
BATTERY
Coke Side Inspector
(rush Side Inspector-^
>AV 77
T
UVEN
BROKEN RLFRACTORY AT
DOUR AREA
Check:
Yes(/>
No Cx)
Indicate
Location:(X)
{End View)
DARK (COlD) SPOTS ON SIDE WALLS
Chock:
*es(<6
No Cx)
Indicate Location: (X)
(Top View)
OVEN ROOF CARBON BUILDUP
Illustate:
End View
Side View (best estimate)
(Indicate standpipe and uven holes)
X
X
cs
ps
[L
cs
ps
COMMENTS;
-------
PROCLSS DATA
?ushi:r MACHINE INSPECTOR
Page | of _£
COMPANY
LOCATLON FOHTANfi .CsfiUFOf l>Jlh
INSPECTOR
DAI]
J. A 1-JopKi/Js
vii: \j V>!
77
BATTERY AKf,
OVEN'
C)
ParciaL (P) or Whole(W)
TIME OF
PUSH
ELAfSED
PUSH
PERIOD
(so c)
CHUCK DOOR OPERATION
Check Yes (/) or No (/)
COMMENT
NUt'SER
CLOSED | LATCHED
i
TIGHTENED
LEAKING
ELAPSED TIME
DOOR OPEN
BEFORE LEVEL
BAR STARTS
(sec)
SIKXE
>
FLAME
m
—
.—
/
/
/
X
±L
h
/
/
HrJ>
/
t
/
/
/
/
//• 75
>
fim«Q
(D 1st tit a
HoLs
to as*saw* j a**"*'r
?e -cxrwee A**™* *¦< ^ ******* <**'
/Zft-t /c ^ - Ai^fA /r 7*Wo*sc°
Cos-f <*"**? ttsrss-CB 7Z#* ^ &**»#>£.
¦ ^
i
-------
Pago 2- of
PROCESS DATA
PUSHER MACHINE INSPECTOR fg
COMPANY
K/l INSPECTOR BATTERY ^ ,'&i C-
LOCAnoN n>'^|/WAjOu. date l/z-;/77
OVEN
APPEARANCE Of COKE FACE
Cheet; Yes (/) or No (X>
Partial (P) or WholeCW)
TIME OF
PUSH
ELAfSED
PUSH
PERIOD
(sec)
CHUCK DOOR OPERATION
Check Yes (<7(?£. 7?cf>6
<1
-------
Observer
Date
P1 a n t
Battery.
J • K 0 .J K1 r-» S
AG
Ov
CO (D
O (J
r> >i u>
rr rr
h* rr
o
3
ro
M
c
H*
3
G\ n
ID
f~Uoor MacKine clokc
—— ^
Condition of Door
on Removal
Cleaning
appearance of coke face
CliocV. Yes (>/) or No (£5)
Partial (P) or WholctW)
a
Time of
Removal
Oven
No.
Sect.
lefrac
torv
Knife
rdnrw
Gas
Clian
Knife
Clean
Edge
Dcpoc i
{cm.l1 u
Gas CI
Crl *?
Clean
^annel
Dcpos
Kein.iii
Chuck
C^ean
Do of
Dcpos
Remain
Janib
pepos
Cleai'j.lomair
SXOKE
FLAME
y.ob
©
f
J
0
0
(
/
\
/
"
J)
/
n
\
0
V
3:23
At
©
1
I
0
Q
0
/
!
1
\
0
/
/
?
0
©
t
(
i
/
0
i
\
/
©
I.
1
3
/
1
)
e
0
1
(
1
/
0
I
\
/
©
1
1
-7
0
/
0
©
)
1
3
V
n
i /
f
i
i
I,-1
Q
3-1^-
5'2^
©
/
1
3
0
0
P
/
1
\
0
/
p
^h)
©
/
1
3
/
<2
1
\
©
/
i
/
/
;
©
)
i
l
/
0
1
1
\
©
1
)
0
,!
O
/
1
1
©
1
I
Z
&
0
/
1
I
J
Biter:
1-N'o damage on door, knifo edge (np
donts, cracks, missing sact.)
2-Physical danage (cracks, deforma-
tions, missing sect.)
-3-CarLjon deposits , . . .
a4-Tf Goor is replaced with a frosh
' door in this cycle
^ - yes
O^-no
-------
J . KcfKiHi
Observer
Date i/'7~>7
Plant.
rV>
B a 11 c r y __£rL_
u
n
in O
Q O
O rt U>
rr rr
h* zr
o
y
fs>
Door Machine Push Si&
r*
3
ON rr
O
oor Machine Coke Si£e
Time of
Removal
y.AlfJ
~Z7
.77'
Q>
Aw
Oven
No.
6t
o «¦»
o>
7^
Sect
_©
©
_©_
©
©
©
©_
©
©
©
©
Condition of Door
on Removal
lofrac-
tnry
©
©
©
©
©
0
/
rCjllfc
TV)ar>
I
X
Gas
Chan
3
3
3
•>
%
_u>_
JL
Enter:
1-N'o damage on door, knifo edge (nq
dc-nts, cracks, missing sect.)
2-Physical danage (cracJcs, deforma-
tions, missing soct.)
-3-Carbon deposits , , „
a4-Jf dopr is replaced with a frosh
• door in this cycle
Knife Edge
Dcpori
Clean
0
t
"¥
Cleaning
Gas Channel
n
0
V
0
t
0
J
0_
0
0
o
/
/
JL
/
o
7
jL
/
Dopo-:
Hcmnn
/
0
/
/
/
/
/
/
0
JL
0
o
Z
Chuck Door
Clean
Depos
Rema>n
Jamb
pepos
Cleanherrmi
z
o
a
/
T
o
/
/
o
T
a^pea^ce of coke face
Check \es (*/) or Mo CQ)
Partial (P) or WholeCW)
SMOKE
/
o
0
o
o
o
Q
Y
^ &- yes
O jX - ao
CD 14 "paWi? OUT or gcqoctfce *P>oqa. Usc?/?^
7Z r' , '' " /• tf/x
?
/
"iPiW'f
O&r.
-a*
FLAME
i)
/,
r
-------
Observer
Date I
Plant.
J l-lnPfi-iNS
t * /,< ft
C/i O
Q &>
O M LO
rt rr
H- sr
O
P
Battery
ro
t—
eaQrjj^cni no_to:au_ki<*o
(Door Machine Coke Siccft
On rr
ft
3kF FACE
APPEARANCE OF COX
Check Yes C/) or No IS3)
Condition of Door
Enter:
1-N'o damage on door, knifo edge (nq
dents, cracks, missing sect.)
2-Physical damage (cracks, deforma-
tions, mssing soct.)
with
- door in this cycle
/ yeS
o%.™
a fresh
a
Time of
Removal
Oven
NO.
Sort.
or
?ofrac
cory
Homo
"nife
All
Gas
Chan
Knife
Clean
Edge
DcJjOS
icinain
Cas Cl
Gai
Clean
iannel
DcpoT
Kcmair
•"i
Chuck
Clean
Door
Dcpos
Remain
Jamb
pepos
Clear!,^cmair
SKOnE
\
FLAME
4:Jo
0
/
/
3
/>
U>
0
0
/
~
\
j
a
/ •
fr
JF
©
/
/
"3
/
Q
\
0'
/ •
(3)
;
1
3
/
o
\
I
J
0
0
I
1
3
/
o
\
/
Q
(?
©
I
I
a
/
\
/
0
©
)
J
3
\
'
'
o
/
t
*
0
o
©
/
©
\
©
\
©
/
t
©
1
©
:
©
i
i
©
©~
1
©
©
©
*
-------
COMPANY KaiUT-
LOCATION fosTfirJA »
PROCESS DATA
COKE OVEN CONDITION
INSPECTOR J- t-lopjuMi
DATE
Page _J of J
[jCoke~Side Irtspectop)
rush Side Inspector
BATTERY
A.'Bf C
«/ 77
OVEN ROOF CARBON BUILDUP
111ustate:
UVEN BROKEN REFRACTORY AT
DOUR AREA
DARK (COlD} SPOTS ON SIDE WALLS
Check: Indicate
Indicate Location: (X)
(Top View)
/
Chckk:
Yes(/)
No (x)
Side View (best estimate)
(Indicate standpipe and oven holes)
End View
Location:(X)
(End View)
No (x)
CUMMENTS:
O VeCL UfiK'M MP FWC, /t/W- f?. Z?f~) SV
~X>00^ • 0?f,Q.
-------
Page 2- of "3
CCol
-------
Page ^ of ?>
PROCESS DATA
COKE OVEN CONDITION Coke Su)e Inspector^
fush Side Inspector
COMPANY M'S^- INSPECTOR J l~lw< it'S BATTERY ^ i >3 £ C
LOCATION , C*l DATE 1 / ~S/77
OVEN ROOF CARBON BUILDUP
DARK (COlD) SPOTS ON SIDE WALLS
UVEN BROKEN REFRACTORY AT
DOOR AREA
Indicate Location: (X)
(Top View)/
Che ck:
I]Instate:
Indicate
Location;(X)
(End View)
Check:
Yes(»/)
No (x)
Side View (best estimate)
(Indicate standpipe and uven holes)
End View
cs
ps
cs
ps
cs
cs
cs
-------
n» i pa JIV)
V I A IMif'Mhi
fir I A t
i!vC" «J
2/-?-
'>23 .
71 -? 7 I £:J23
a3-K^->-
jrC^$r Ti?
.tdfUA*:;? —
,7 QVJ _:17
^1'
! _jWi
—-J-'/.K1 =27
-------
f
J
INSPECTOR
DATE
R
/- 2-<--77
PLANT
TEAM LEADER
SPARE DOORS
Battery
T ime
r
PS
^ur.ber
CS
COMMENTS
C* BaHit'
03Z1-
O
f
CS -/ia -s /&*- *C*,-U '&C&A et~ns?<* <-&s '
£ cvr /
C$ c-ts'rrS
C &?{f
6?:rf
0
i
£c/ >js ti. T "7^ J7e'i-^
•?£~-u /-
t><7/£
0
O
hL efw-r
IS C«s/
c?//
Z-
/
0
C_S ij'i
C u)<5 /"
Cf/^'4
/l 2' /f cdcc>t^ 5 Sc'rs/*)* &.? /£,
c. Cisb
o?£Y~
/
/ X
jV^?s /"
on^l
/
/
tC*.4* -*,<)}<- furl S'*J 'v>* r* /,
t f X r+»/ //¦,,! t
CJ -rev. A„.{> /,./'/«-• c.^'J
)CiL
/
/
lfli.;//T] dc.},-\ for />¦>¦././/f*nc-. c < ,
1 i
£ £•->
(? &<>\
z.
/
5jj"> s *< z °^L
% £¦<&.
f tJsi
c &&
it u__
l\h^l
J&L
K>3>
0 _
./.
_ _c>_ __
z_
<>_ .
L—
/
/
frflS.. ^cen'X , , -w ^ -•- ,--- / - /
— s/tj)t,'y 1 -4&rji>-'/ i JT>" X'H J*.
Stjtff
S~ J &
/
f
!
f3} 5<:.»c J
Cf -f cv-/ n C-f *->r'/.
'•it
A:VH
W10
/6 / 6
/
fi S*.lnc/ cii ,s 0 *> t j
X*"t\ 11 ii>
•• - ....- - <
-------
rage /
of
PROCESS DATA
CATWALK INSPECTOR
COMPANY
location
/-^n /'t
¦*w t_
lNSrECTuP, ,
/-zi
date
Standpipe Carbon
COM^IENT
"llustratc carbon buildup)/! NUM3CR
Aspiration
Steam Pressure
Col lector
i'ain
pf$ssur
-------
rage <£- of
PROCESS DATA
CATWALK INSPECTOR
COMPANY A///<
LOCATION S^~7?/> 7^ft -fC-
INSf ECuR
¦¦
_^__p
DATE / ~~ ~ "? >
Standpipe Corbon
(vllustrate carbon buildup)
COMMLNf
NUMBER
Aspiration
Steam Pressure
Co 11cctor
J la in
^issiinrj"
Uven
Static Jyna'inc
Pusher Side
Coke Side
Cnarcjt.'d
/&&€>
/3* Z<
¦fl o
)f6S/f
1~Z 2
r9 >-#jVY0—//.
-------
Observer
jZA
t - fJ. f- "6»—
Pl.int-
Battery-
Condition of Door
in n
rc to
t
t. ^
oor"Tlaciune Coke STcS?
appearance of coke face
Check Yes U) or N'o ($J)
Partial (P) or Whole(W)
Time of
Removal
Cleaning
FLAME
SMOKE
Jamb
Dcpos
Clear!
-------
Observer
Date
¦ ^ ¦ 1
77
7-
P1 ri n t
Ba t ~-vt^- /¦' f^'i)
n
a:
W Q
O &}
O M
rr
Door raciiine push sico
Door Machine Coke Side
Condition of Door
APPEARANCE Of COKE FACE
Check Yes W) or No ($5)
Partial (E) or Vlhole(W)
Time of
Removal
Cleaning
FLAME
Chuck Door
Channel
Jamb
Knife rdgc
icfrnc
con,
KjiiIg
Pdnp
Dc no
licinn li
Dopos
Romaln
Clean
tcm.TirvClc.Tn
Clean
ClenriTcrrw i
7
P
?
r
f
F
P
Enter:
1-K'o damage on door, knife edgo (n<^
dents, cracks, missing sect.)
2-Physical, dar.age (cracks, deforma-
tions, missing sect.)
a4-Trrdoor
-------
Observer
Date f~ " 7 / *
P1 n n f j
B.^fcry f LCf
w n
ra n
ft u
n rr
H-
O
3
r
H-
3
ff> rr
n
Door Machine Coke Sida"
Condition of Door
ATPEA^NCE OF COKE F/iCE
Chock ^es (/) or No (R)
Partial (P) or WholeCWj
Time of
Removal
Cleaning
FLAME
SMOKE
Chuck Door
Jamb
Ocpos
ClcoiJ-'cm.T3
Knife Tdgc
s Channel
\Ci y*cic
KniCc
icpo:
DCpOT
Uemair
Do no 2
Rcma 1:1
Clean
:c.naliT(Clcan
Clean
Sect.
Olf
33.f
F
Enter:
1-No damage on door, knifo odgo (nq
dents, cracks, missing sect.)
2-Physical danage {craclts, deforma-
tions, missing soct.)
with a frash
* Goor in this cycle
^ P- yes
0#_rvo
— a £IguM~6 4o •Ji^&drsiJU'
¦eaj
-------
UW4 • iu • ww.. v
Door Machine Coke Side
cn ra
Observer __i5LL_Li~
n,n-o /-2-£>-7'7
Plnnr /Clt*-**
Ba t to r
IO
APPEAVNCE OF, COKE FACE
Condition of Door
on Removal
Cleaning
FLA>_IE
Knifp Edge Gas Channel Chuck Door
DepOS Crti DcpO'^
icra.Tiacicon Hcmnn Clean
Jamb
Time of
Renoval
Oven
NO.
Clean
Sect.
/Ijo
Enter: 1
1-N*o damage on door, knifa edge (nq
dents, cracks, missing sact.)
2-Physical damage (cracks4 deforma-
tions, missing soct.)
a4-Trrco^r
-------
server (*?• Yf'
r
Ob
Date _ ; _ j—
jEZhi
in q
m cj
o m u>
r» n
k =r
o
3
Battcry.
"
N>
M
H-
3
O* rr
Q
Door ;:acmno rusn siuo
Door Machine Coke Side
<<9
Condition of Door
APPEARANCE OF COKE FACE
Check Yes (/) or No ($)
Partial (P) or Whole(W)
Time of
Removal
Cleaning
FLAME
SKO.Nfc
Jamb
Chuck Door
Knife Hdyc!
Channel
Oven
;ef rac
hail fe
riVff
Dcpon
Ocpoo
iipira y
pepos
Cle.irUomai
Depo
Itema i n
Clean
{cin.Ttn,cii>an
Clean
Sect.
tnry
€)
/ €
¥
V
115/
P
I
£
CjbulS^
l\&
Ifil
\
Enter:
1-N'o damage or. door, knife edge (nQ
dents, cracks, missing sect.)
2-Physical damage (f.-rac
-------
PROCESS DATA
COKE OVSN CONDITION
Page
of
COMPANY
LOCATION
Jk
\L
Coke Side Inspector
rush Side Inspector
INSPECTOR
DATE /-Z&-77
BATTERY
I
UVEN BROKEN REFRACTORY AT
DOUR AREA
D/
$
Check:
Yes(/)
No (x)
Indicate
Location:(X)
(End View)
?k>
¦ \)$Z-
DARK (CUlD) SPOTS ON SIDE WALLS
Check:
Ycs(^)
No (x)
Indicatc Location: (X)
(Top View)
-1 rn
ps
OVEN ROOF CARBON BUILDUP
lllustate:
COMMENTS:
End Viev/
Side View (best estimate)
(Indicate standpipe and oven holes)
OK-
o<~
-------
Page of ^
PROCESS DATA
COKE OVEN CONDITION Coke Side Inspector
rush Side Inspector
COMPANY I INSPECTOR (jT - BATTERY ^ ^-c/o-6^
date f ' 7 *7
LOCATION
OVEN ROOF CARBON BUILDUP
DARK (COlD) SPOTS ON SIDE WALLS
OVEN BROKEN REFRACTORY AT
DOUR AREA
Indicate Location: (X)
(Top View)
111 us tate:
Check:
Yes(^)
Indicate
Location:(X)
(End View)
Check:
Yes(/)
No (x)
Side View (best estiirate)
(Indicate standpipe and uven holes)
End View
cs
cs
cs
ps
cs
cs
COMMENTS:
-------
COMPANY
LOCATION
^ /yy
PROCESS DATA
COKE OVLN CONDITION
INSPECTOR
DATE
ZL
J ft**
BATTERY
Page of
Coke Side Inspector
rush Side Inspector
f'd-Gr
i\rr()n iAun.auf frPS
P
5m
O-
J
L
331
X
0^
fP
CUMMENTS:
J
-------
Page _± of
FROCUSb DATA
COKE OVEN CONDITION Coke Side Inspector
rush Side Inspector
BATTERY
INSPECTOR
COMPANY
DATE
LOCATION
OVEN ROOF CARBON BUILDUP
DARK (COlD) SPOTS ON SIDE WALLS
OVEN .BROKEN REFRACTORY AT
• DOUR AREA
Indicate Location: (X)
(Top View)
II lustate:
Check: Indicate
Yes(fO Location:(X)
No (x) (End View)
Side View (best estimate)
(Indicate standpipe and uven holes)
End View
cs
cs
cs
cs
cs
CUMXENTS:
-------
CO.'iPANY
LOCATION
PROCFSS DATA
COKE OVEN CONDl'lION Coke Side Inspector
y \ J rush
INSPECTOR y \ BATTERY _ f=Ia
btyvl'lSw DATE I ~ 77
Page .5; of ^
;e Side Inspector
rush Side Inspector
OVEN ROOF CARBON BUILDUP
DARK (COl,D) SPOTS ON SIDE WALLS
OVEN ,BROKEN REFRACTORY AT
DOUR AREA
Indicate Location: (X)
(Top View)
Check:
YesC/)
Indies tc
Location:(X)
(End View)
Side View (best estimate)
(Indicate star.dpipe and uven holes)
End View
cs
cs
cs
cs
/\pnt
rSpt] p\
pn> )
cs
cs
COMMENTS:
-------
Observer
Plant__^I
Battery.
/I. Vot/nt)
(K,tr-/7
15
o
X
C/> Q
Q P
O ¦-<
rr rr
H-
O
3
c. - o'-g
U1
,
'
w
1—
3
ON ft
ft
h-
Door Machine Push Sidc^
Door Machine (ioke Side
//*
Condition of Door
Adjustments
Time of
Remova1
Cleaning
Latching Seq.
Knife
Chuck Door
Jamb
Gas Channel
vctrac
:nife
-CcV»q
Both
@Once
Dcpo
[ictnaii
Dcpo
Remain
pepos
Clean! ieman
Time
Finis;
Clean
-------
U(H<> r IUU
IJ I 'it
Gbsurvrr
Date
Plant
Battery.
twA-ft
7 7. .
Kepi's',a Fr>^.*(n-sSi
C -Qlg.
0
3!
co o>
o ca
o ft
a rr
H* rr
o
3
x>
Cn
r
-
ro
t-*
dfioor Machine Pu^i SluQ
Door Machine coke bide
D
Ox rr
Q
Time of
Removal
Oven
No.
Sect.
Condition of Door
ot Removal
^cfrac
tory
Knife
Gas
Chan
Cleaning
Knife Edge
Depos
iicinainj
Clean
Gas Channel
Gas
Clean
Dcpo
Uemair
Chuck Door
IDcpos
Clean iRcmain
Jamb
Clear
icpo:
Remain
Latching Seq.
Top
Bot.
Bot.
Top
Doth
@Once
Adjustments
Time
Start
Time
Finis!
©
©
©
©
©
©
f
7
t/
a
x
'4.
v
/
©
x
Y
©
'1
(p
9
©
©
©
©
f
y
"7
*
T7
i
t
4
D
©
©
4-
©
4
f
©
«/
©
7s
©
X
t
Jz
J
i)
/
7
t
X
*
T
a
v/
fJc
'6-^c
v
x
T
x
a
(/
¥-
' k
'Quju
¥
~
/
V
Enter:
1-No damage on door, knife edge (no
dents, cracks, missing sect.)
2-Physical danage (cracks, deforma-
tions, missing sect.)
with a fresh
door in this cycle
/- yes
X - ao
¦/- which applies
-------
Page
of
I
process data
PUSHER MACHINE INSPECTOR
COMPANY
LOCATION'
4
UM*-
(P. A
x
INSPECTOR
DATE _ t-Z,t*-73L
"h
BATTERY C'&~£-
OVEN
appearance of coke face
Check Yes (/) or No ()0
Partial (P) or Whole(W)
TIME OF
PUSH
ELArSED
PUSH
PERIOD
(sec)
CHUCK DOOR OPERATION
Check Yes (^) or No (>C)
COMMENT
NUMBER
CLOSED | LATCHED
i
I
I
1
t
TIGHTENED
LEAKING
ELAPSED TIME
DOOR OPEN
BEFORE LEVEL
BAR STA.1TS
/Usee) 6
SHOKE
FLAME
fzo;
• (J)
6)
\
l/
Zc>
(§?
^7.
V
\
l/
<20
r >
/>
/
I
/
\
/
\
/
\
|
c
COMMENTS:
0- UW4 r^AHc^d c*J> fw; ro^m > ,
(\ - T,^ ¦£#>» C- £> V^T7 'cvc' f
" " ££) cM&J
n n "
T^cot-
-------
PROCESS DATA
COKE OVEN CONDITION Coke Side Inspector
COMPANY
LOCATION
/ . / rush ilC
ICjC INSPECTOR t //#<¦*•—7 BATTERY C~ Q - ^
F^C^u^Cl DATE t'lLln / _
Page i of
Coke Side It
tush Side Inspector
OVEN
BROKEN REFRACTORY AT
DOUR AREA
DARK (COlD) SPOTS OU SIDE WALLS
OVEN ROOF CARBON BUILDUP
lilustate:
Check:
Yes(/)
No (x)
Indicate
Location;(X)
(End View)
Check:
Yes i/) ¦
No (x)
Indicate Location: (X)
(Top View)
End View
Side View (best estimate)
(Indicate standpipe and uven holes)
£
z
'?
I
X
cs ps
« ps
£
CS ps
iQfC, ps
1
it
\yz
T\
I
J
bo v
ow*-
1VAj&k. iQr&zJd-
*ct
(jlv
Wf i-'teo
CUMMEHTS:
-------
PROCESS DATA
COKE UVEN CONDITION
Page
of
V
COMPANY
i /\^VAlA
LOCATION I&^Cl
INSPECTOR
DATE
ifil
Coke Side Inspector
tush Side Inspector
^J/77
BATTERY
C-~b -0
1
UVEN BROKEN REFRACTORY AT
DOUR AREA
Check:
Yes(»/)
No (x)
Indicate
Location:(X)
(End View)
DARK (COlD) SPOTS ON SIDE WALLS
Check:
Yes(^) •
No (x)
Indicate Location: (X)
(Top View)
OVEN ROOF CARBON BUILDUP
11lustate:
End View
Side View (best estimate)
(Indicate standpipe and uven holes)
$
y
x
cs
ps
y" Uvo.
D
1
k
-------
/
COMPANY
I.OCATION
T-b^-Is,
PROCESS DATA
PERSONNEL ACTIVITIES
INSPECTOR
DATF
y—
Larry car InspccCoi
Topside Inspeccor
Coke Side Inspcccoi
Pusu Sid" 7nspoC"O1
/-Z& '7*7
BAT!VRV
C-£)-&
Indicate worker job title, nunber of persons working at this iob an^ brie£
Job d ascription, at the beginning of each day an^ when personnel change^ are
made. Indicate shells provided by relief man.
Description o~ Operations Perfomcd
TIME
worker
Title
cs
09/3
o.%pmr
CST>M (
H-&S i
PMcf*%
C.
D
t
GC&& slf.'Z'&Uc'C. //*- C+t>~<}
it &91 C.'tVl
/"' . 7~
/ / /
dfrl Cfi'tp *t&4*c£u.
1 .ff-
~ ¦ HI I ^
-r- ^ 0
MJSI — OirtC&&*
0-f
¦94 c
a o p ¦[". s-'''
£-Z^~ O-v
ci \ r-z&i&isri/ . Trc^e^
'¦—jc•(p'10 —
' i g.«3 c7
»/ / 7 ^ _ A /
A&ibe>.. <, <3 ^*u. £2>3 v
c& & 32- C&u* dejv&ut^, "'''aZ&z
fy^f£v c/i
JImuaO
"m* i-7
/ Q^?£rt.&/Lid
__ ft — n.4s *^\s ^ vri.oyt^u^ / /
Cfifrt- i AeU*. / ^
-------
tfage of
PROCESS DATA
PERSONNEL ACTIVITIES
T.OCATION /""
COMPANY
INSPECTOR
DATF
T, n,.j-
Larry car Inspector
Topside Inspector
Coke Side Inspector
Sid" 1nspCC-Or
7
^ / ?7
battery
Indicate worker job title, number of persons working at this iob anH brief
Job dfscnption, at the beginning of each day an^ when personnel change* are
made. Indicate spells provided by relief man.
TIME
Worker
Title
Description 9* Operations Performed
Y/
(frup/c /<
I - C ~-/l <=/ry-7 . /T? Lit
(\A-lud rZ
cM'
7~n ^
' S, '
- /. C-rc~. r- ->*
SLi.£-
//
I'.dt.
C'ttff; r.)fn^> — sJ'S?
(m si? c'tj/i,
f =3
£
Sr—ito. yL J.tt.fi
. c&ru*
JIM.
^0
(j^(J .-rb\.
£3^
cy
-------
|ji ¦¦ I . I • i* * • l.i -L
Observer
Date_
Plant
/ .1 i / s 7
O
H
cn o"
ft v
O »-l w
rr rr
p. p*
O
a
Battery-
I - O xz.
Ln
i
ro
M
^poorjda
chine Push
Sid^J
Door Machine (Juke iilue
p
on rr
(D
Time of
Removal
Oven
No.
lQ
Sect.
©
0
0)
©
©
©
©
©
©
©
©
©
Condition of Door
on Removal
Uifrac
tO'-V
A_
3
3
3
3
)
Kmfe
A
1_
/
/
z
Gas
Chan
1
3
Jl
2l
J-
b
1
Cleaning
Knife Edge
Clean
u~
Depoo
O
D
0
Depos
Keinair
0
D
O
O
-a
IL
O
c->
6
3
O
L
0
Chuck Door
Clean
Depos
Remain
Jamb
Depos
ClearRom,t ji
0
a
vr
w
¦/-
u
\
r
Latching Seq.
To
Bo'
Bot.
Top
Both
@0nce
Adjustments
Time
Start
Time
Finis
t
©
3
©
I
3>
©
©
I
J
1
©
©
Jl
11
0
a
0
t
M
T
I
z
o
A
0
o
b
Cnter:
1-No damage on door, knife edge (nq
dents, cracks, missing sect.)
2-Physical damage (cracJcs, deforma-
tions, missing soct.)
a4-T^rdopr(iil0replaced with a fresh
door in this cycle
/- yes.
X - a0
Y- which applies
-------
Door Machine Push Sitlo
Door Machine Coke Side
Observer
Date
Plant :
Battery.
/a'.C
/J J /,-/7 7
KJ
Condition of Door
on Removal
Cleaning
Adjustments
Latching Seq.
Jamb
Knife Edge
Gas Channel Chuck Door
Dcpos
Kemair Clean
Time of
Removal
Oven
No.
Gas
Chan
Depos Gas
temairucican
Dcpos
Remain
Toj
Bo'
Time
Start
Bot
Top
Time
Finis
Clean
Sect.
Clear.
Enter:
1-No damage on door, knife edge {nq
dents, cracks, missing sect.)
2-Physical damage (cracks, deforma-
tions, missing sect.)
l4-J^r^oprdis°replaced with a fresh
door in this cycle
/- yes
X -
which applies
-------
Page
of
PROCESS DATA
PUSHER MACHINE INSPECT
COMPANY
h ftC:
SJ\,
LOCATION
INSJ'ECrOR
DATE
J_ Of rK
BATTERY
^ Dei
OVEN
APPEARANCE of coke face
Check Yes (/) or No (X)
Partial (P) or Whole(W)
TIME OF
PUSH
ELArSED
PUSH
PERIOD
(sec)
chuck door operation
Check Yes C*') or No ()0
comment
NUMBER
CLOSED | LATCHED
i
t
1
!
i
1
TIGHTENED
L£AX.ING
ELAPSED TIME
DOOR OPEN
BEFORE LEVEL
BA1 STARTS^
A (-srr) J]'
SMOKE
FLAME
.0
X
X
>s
a<--
m
T
7^5"
P
0 1
vr
X
f?
t<"'
I i>L
P
p
v-
y-
N
/?5
y
><
5^
Pi
lt<
W
?
X
IX
COMMENTS:
h
-------
PROCESS DATA
COKE OVEN CONDITION
Page
of
COMPANY
INSPECTOR
LOCATION
| frN.
-t/-A i Cj.
^ _ a,
Coke Side Inspector
rush Side Inspector
BATTERY
0 ryp
DATE
/A
U>*
V-
UVEN ,BROKEN REFRACTORY AT
DOUR AREA
DARK (COlD) SPOTS ON SIDE WALLS OVEN ROOF CARBON BUILDUP
Check:
Yes(/)
No (x)
Indicate
Location:(X)
(End View)
Check:
Yes(^)
No (x)
Indicate Location: (X)
(Top View)
IIlustate:
End View Side View (best estimate)
(Indicate standpipe and uven holes)
0
4- -r
COMMENTS:
-------
Page of
PROCESS DATA
COKE OVEN CONDITION Coke Side Inspector
rush Side Inspector
C-0&-
BATTERY
INSPECTOR
DATE
LOCATION
OVEN ROOF CARBON BUILDUP
DARK (CUlD) SPOTS ON SIDE WALLS
UVEN ; BROKEN REFRACTORY AT
DOUR AREA
Indicate Location: (X)
(Top View)
Check:
Yes
No (x)
Indicate
Location:(X)
(End View)
Side View (best estimate)
(Indi_£Are standpipe and oven holes)
End View
cs
ps
cs
cs
ps
cs
COMMENTS:
-------
Gbservpr;
Datc_
Plant.
Battery.
—) c
tiffin
a-
u
o
rt
X
i/i ra
ID IU
r> i
rt rr
H 3*
O
3
in
3
CT> rt
O
Door Machine Push Side
Door Machine Coke Side
Time of
Removal
Oven
No.
Sect.
Condition of Door
on Removal
scfrac
tnry
Knife
Gas
Chan
Cleaning
Knife Edge
Dcpo
tamairi,
Clean
Gas Channel
Gas
Clean
Dcpos
Kcmair
Chuck Door
Clean
Dcpo.
Remain
Jamb
Dcpo
Cleanhemair
Latching Seq.
Tod
Bot.
Bot.
Top
Doth
@Once
Adjustments
Time
Start
Time
Finis
©
o-
©
4-
4
y
0
A
a7
IL
J2
o
0
_©_
_©_
©
%
J-
i
is
b
-y
z.
b
b
u
y
0
©
b
©
5Ae>
©
')
T
0
©
0
©
©
©
V
£l
b.
o
0
r
c>
D
3»)
©
0
©
©
©
©
©
a
it
0
p"
h
&
Enter:
1-Ko damage on door, knifo edge (nq
dent$, cracks, missing sect.)
2-Physical damage (cracxs, deforma-
tions, missing sect.)
with a frosh
door in this cycle
/- yes
x - no
/*- which applies
J
-------
Observer.
Date
Plant
flattory_
O.-I
ijwri
fyj. "
"•p- fo
u
O
X
tn q
fD &>
n
rr rr
H O*
O
3
to
J-*
H-
3
D
H
Door Machine Push SiCg
Door Machine Coke Side
Time of
Removal
A
Oven
No.
3/1
Sect.
©
©
©
©
©
©
©
©
0
©
©
Condition of Door
on Removal
AoCrac
tcr.Y
\i)
n>
w
Knife
Ldac.
3
5.
1
Gas
Chan
1>
L
J
Cleaning
Knife Edge
Clean
o
o
~U~
u
A
V
n
u
11
Depos
.temaini
II
H
U
Gas Channel
Gas
Clean
0
1>
Ll
u-
L--
u
T
Dopos
Roman
b
1L
0
~D
O
0
CS
Chuck Door
Clean
Dopos
Remain
Jamb
Depos
Cleanhemair
O
L-
Ls
is
V
u
T>
a
Latching Seq.
Top
Bot.
Bot.
Top
Both
@Or.ce
Adjustments
Time
Start
Time
Finis!
©
©
©
©
©
©
Enter:
1-No damage on door, knifo edge (nq
dents, cracks, missing sect.)
2-Physical damage {cracks, deforma-
tions, missing sect.)
oprdis°fepiaced with a fresh
/- yes
x - no
J-Carbi
1-Tt d
ioor in this cycle
/- which applies
-------
Page
of
PROCESS DATA
PUSHER MACHINE INSPECTOR
LOCATLON'
DATE
OVEN
CHUCK DOOR OPERATION
Check Yes (/) or No (~A)
CLOSED I LATCHED TIGHTENED LEAKING
APPEARANCE OF COKE FACE
Check Yes (/) or No ()0
Partial (?) or Uhole(W)
TIME OF
PUSH
ELArSED
PUSH
PERIOD
(sec)
ELAPSED TIME
DOOR OPEN
BETORE LEVEL
BAS STARTS.-,
SMOKE
COMMENTS
-------
Page of
PROCESS DATA
COKE OVEN CONDITION Coke Side Inspector
rush Side Inspector
BATTERY
INSPECTOR
COMPANY
DATE
LOCATION
OVEN ROOF CARBON BUILDUP
DARK (COlD) SPOTS ON SIDE WALLS
UVEN | BROKEN REFRACTORY AT
DOUR AREA
Indicate Location: (X)
(Top View)
Check:
Yes(^) •
^lo (x)
Indicate
Location:(X)
(End View)
Check:
Yes(/)
No (x)
^ Side View (best estimate)
(Indicate standpipe and oven holes)
End View
ps
cs
cs
ps
cs
cs
-------
Page of
PROCESS DATA
COKE OVEN CONDITION Coke Side Inspector
rush Side Inspector
BATTERY
INSPECTOR
COMPANY
DATE
LOCATION
OVEN ROOF CARBON BUILDU?
DARK. (COlD) SPOTS ON SIDE WALLS
UVEN ; BROKEN REFRACTORY AT
DOUR AREA
Indicate Location: (X)
(Top View)
Illustate:
Check:
Yes(^)
No (x)
Indicate
Location:(X)
(End View)
Side View (best estimate)
(Indicate standpipe and oven holes)
End View
cs
cs
PS
cs
ps
cs
CUMMENTS
-------
Page I of
PROCESS DATA
PERSONNEL ACTIVITIES
COMPANY k/MST A.
T.OCATION
/-"o.vJTa m A Cal
INSPECTOR J HqpkiMT
DATF i<^/n
Larry car Inspector
Topside Iir.pcctnr
4joko S ido Inspector
Pus1* SuP* rri •_> p (J C ""or
BATT'-'RV K p,r
Indicate vor'-.cr job title, number of persons working at this iob an<-< brie£
Jol> dfscription. at. the beginning of each day an^ when pc-son"el change- are
made. Indicate spells provided by relief pan-
Tit:t
Worlr.er
Title
Description o Operations L'ortorned
Co(Ci?tr
<^7p/^/irCo s" T^onfC
ATlfS.
s . }. -
-Umr ; /?r-/o T^vr//
/c;oo
d
/iff**
S~/?/££ fz.
-------
Door tlachir.o Push Sid
APPEARANCE OF COKE FACE
Check Yes (>/) or No (&)
Condition of Door
on Removal
FLAME
Knife Mgo Gas Channel Chuck Dooo
Dcpoc DopoT \
Clean f'cuatn.cienn Kcmnir ClKan
Oven
No.
Cas
Chan
Sect.
2B
u
Enter:
^$- yes
G> = ft0
. Csl. LO>j'r o&.
CoA~ fsw Q£we* CACArto
of
2-Physical dar.age (crac
tions, missing sect.)
,3-Carbort depositr
1<-Jt door is rep
- door in this cycle
-iaced with a frosh
-------
J •!-]
Observer
Date \ I 7.h/i 7
2? jUtii-
pi-int- k Arr r
(a a
a s>
O rj w
rr rr
t' 3"
0
E>
Battery F ^
Wl
N>
h-*
r1
3
rr
-------
COMPANY KaiSJ "v
LOCATION rOw T Af/A . C-Al.
1
PROCESS DATA
COKE OVEN CONDITION
INSPECrOR J i Ui
DATE
l/W'?
Page j_
of *2^
^oke Side Inspector*)
rush Side Inspector
BATTERY
C,P,E
ARK (COlD) SPOTS ON SIDE WALLS OVEN' ROOF CARBON BUILDUP
11 Instate:
Side View (best estimate)
(Indicate standpipe and uven holes)
DOUR AREA
Indicate Locatioiy (X)
(Top View)
Chtek:
Check:
Yes(»0
No (a)
Indicate
Location:(X)
(End View)
End view
CUMMEjNTS:
& - Mo
-------
Page 2. of ^
PROCESS DATA
COKE OVCN CONDITION <£ake Slde"Tnspeexyr
rush Side Inspector
COMPANY KfiiW- INSPECTOR J. MoPiPrtj; BATTERY C
LOCATION tQi-lTrHP - Cm DATE 7 7
OVEN ROOF CARBON BUILDUP
DARK (COlD) SPOTS ON SIDE WALLS
UVEN BROKEN REFRACIORY AT
DOUR AREA
Indicate LocatioiV:(X)
(Top View) /
Check:
Yes (A
No (x)
Indicate
Location:(X)
(End View)
Side View (best estimate)
(Indicate standpipe and uven holes)
End View
CJ1
ps
cs
cs
cs
cs
cs
cs
COMMENTS:
6) //loV'Co To
-------
Observer
Date.
J. Mo Pi- ,i-M
Pl.inr K /
Battery.
1L
¦zk
n
ac
in o
m w
o H
rt rr
H* ^
o
3
.
'A
ro
r«
D
^ rr
ft
uoor ;;jc/i:nc ^usa atug
<^Door Machine Coke Si<2a
iTl
Condition of Door
APPEARANCE Or COKE FACE
Check lies (i£
s>:o;
-------
Observer
Date
Plant
Battery.
J, HrfKlN i
'w.irp.
M. i rF-
Z£T
—r*
CO
Q*
o
Q
o
rt
rt
H*
3*
O
3~
ro
H*
r»
H*
3
On rt
fo
uoor (iJL'juuL' rubii a;uu
/Door liachlnc Coke Sida\
111 ^
Condition of Door
aipear^nce of co:
-------
COMPANY
LOCATLON Tbtrtf
PROCLSS DATA
COKE OVCN CONDITION
INSPECTOR J MoPf^/rJS
DATE
?££C
of ^
CCo^^-.^1^ Inspector?
fush Side Inspector
BATTERY CV£
to hi
UVEN ; BROKEN REFRACTORY AT
DOUR AREA
Check:
Yes<
(End View)
DARK (COlD) SPOTS ON SIDE WALLS
Check:
Yes {^>
No (x) '
Indicate Location: (X)
(Top View)
OVEN ROOF CARBON BUILDUP
11lustate:
End View
Side View (best estimate)
(Indicate standpipe and uven holes)
0
0
cs
ps
^7
0
IS1
0
g
COMMENTS:
-------
PROCESS DATA
Page 1> of
COKE OVEN CONDITION (Coke~Side Inspected?
fush Side inspector
COMPANY INSPEC'IOR ^ t-[">Fk|^Q BATTERY C V C
LOCATION Po^r DATE I/Z6//7
OVEN ROOF CARBON BUILDUP
DARK (COlD) SPOTS ON SIDE WALLS
UVEN BROKEN REFRACTORY AT
DOUR AREA
Indicate Location: (X)
(Top View")
111ustate:
Indicate
Location:(X)
(End View)
Yes
No (x)
Side View (best estimate)
(Indicate standpipe and oven holes)
End View
cs
/ 79
cs
cs.
ps
cs
cs
COMMENTS:
-------
filKrroor ¦Pi'-IAj J
Date
Plant.
Battery.
K* »i:~
in ra
o o
r> n
rt rr
H sr
O
V
U>
1= 6
Q\
to
H*
r1
P«
3
coor r.acnino fusii t>ico
(fpoor MacKiTre~egkff SiCi>
I CfL
Time of
Removal
Oven
No.
3u
Sect.
0)
_©_
©
0
©
(J)
&
©
©
©
(ft
©
_©_
©
©
©
©
Condition of Door
on Removal
torv
Knife
rrlrro
V
r
!
T
Gas
Chan
Enter:
1-No damage on door, knifa edge (n.q
dents, cracks, missing sect.)
2-Physical danage (cracks, deforma-
tions, missing soct.)
-3-Cq.rbon deposits . . .
a4-Ti coor is replaced with a xresh
door in this cycle
Cleaning
appearance of coke face
Check Ves (
-------
,Door M
G* rr
Observer
Date ]
APPEARANCE OF CDrlE FACE
Condition of Door
on Removal
FLAME
Jamb
Knife Edge Gao Channel Chuck Door
[Dcpoc Dcpos
Clean Jcmn itiClcM.i Kcinau Clean
Time of
Removal
Oven
No.
Gas
Chan
Scrt.
Enterr
donts, crocks, missing sect.)
2-Physical danage (cracks, deforma-
tions, rushing soct.J
-3-Carbon deposits . „
a4-Tt door is replaced with a frosh
* door in this cycle
-------
COMPANY
LOCATION rrulbtih ^ CfiL
PROCESS DATA
COKE OVEN CONDITION
INSrCCTOR .1
DATE \j lb/')7
Page 1 of
i
kCpke Side Inspector^
rush Side Inspector
BATTERY i_
iL
X
UVEN . BROKEN' REFRACTORY AT
DOUR AREA
Check:
Yes(/)
No (x)
Indicate
Location:(X)
(End View)
DARK (COlD) SPOTS ON SIDE WALLS
Check:
Yes(^)\
No (x) \
Indicate Location: (X)
(Top View)
OVEN ROOF CARBON BUILDUP
111ustate:
End View
Side View (best estimate)
(Indicate standpipe and oven holes)
22? I
0
0
KJl
s\j i' Vtcp
cs
ps
ill
o
CUMMENTS:
-------
Page ^ of ~~
PROCESS DATA ^ _
COKE CVGN CONDITION CCoke Side Inspector^*
rush Side Inspector
CO.'IP ANY Ka-STT. INSPECTOR J hjo^klM S. BATTERY * &
LOCATION j Opi DATE 1 / 1i> jl"^
OVEN ROOF CARBON BUILDUP
DARK (COlD) SPOTS ON SIDE WALLS
OVEN ! BROKEN REFRACrORY AT
DOuR AREA
Indicate Location: (X)
(Top View)
Indicate
Location:(X)
(End View)
Side View (best estimate)
(Indicate standpipe and oven holes)
End View
cs
cs
cs
cs
cs
ps
cs
-------
U<»;> :
nhcwpr ^
^•PtslKIS
riflt-o i IV>j
'77
I /
Plant j/./li
,r-.
Rarrory C.>
^
0
1
3S
on d
q a>
n n
rr a
H» 3*
O
5
•>
Ln
'
'
NJ
I-4
3
a* n
o
dtoor MagM-iv Push g,'fVi^
Door Machine Coke Side
I
a
Time of
Renoval
Oven
NO.
Sect.
or
?cfrac
torv
Rcmo
Knife
rda<*
i/al
Gas
Chan
Knife
Clean
Edge
Dcpos
Jeina i n
Gas C!
Clean
Cleai
lannel
Dcpos
Rcmair
ling
Chuck
Clean
Door
Dcpos
Remain
Jamb
Dcpos
CleanlRenvnr
Late
Top
Bot.
hing S
Bot.
Top
sq.
Both
@Once
Ad jus
Time
Start
tments
Time
Finis!
9:2*
/7S
©
/
/
i
Q
6
/
0
O
/.
0
/
»
/
"""7
/
O
/ •
0
/
/
"3
,/
o
0
0
/
/
/
0
/ •
©
/
/'
¦z
0
/
!
-------
J. 1-fnpf.lN.S'
Observer.
Date I j 1
Plant.
Battery Cry P; d
o
n
X
&
Ln
Crt o
'
O fci
n uj
rr rr
h» sr
0
„
3
to
M
r
H*
3
ON rr
(D
Door Machine Coke Side
0^
a
Time of
Removal
Oven
No.
Sect.
or
^cfrac
tnrv
Remoi
-Cnife
rdao
jal
Gas
Chan
Knife
Clean
Edge
Dcpos
Remain
Gas CI
Gas
Clean
Cleai
lannel
Dcpos
Rcinair
ung
Chuck
Clean
Door
Dcpos
Remain
J.
Clear
amb
Dcpos
Renair
Late
Top
Bot.
rtmg S<
Bot.
Top
2q.
Both
@Once
Ad jus
Time
Start
tments
Time
Finis)
J:^o
Z2f
©
1
1
1
o
0
0
/
0
0
0
0
/
/
V
n
V
(5)
/
0
X
X
0
©
\
/
/
/•
©
1
C
0
$ V
$1*
0
©
I
1
J-
5
\
0
/
\
1
vv ...
V
n
©
©
©
©
©
©
©
©
©
©
©
©
Enter:
1-No damage on door, knife edge (n^
donts, cracks, missing sect.)
2-Physical damage (cracks, deforma-
tions, missing sect.)
-3-C^.rbon deposits , . „
a4-?r aopr is replaced with a froah
door in this cycle
/- yes
X - no
/- which applies
-------
Page I of j_
PROCESS DATA
PUSHER MACHINE INSPECT
COMPANY
Kakul.
LOCATION t-Ojv/T/lMj ¦
INSPECTOR J ,
DATE
BATTERY
i/^/77
OVEN
APPEARANCE OF COKE FACE
Check Yes (/) or No ()0
Partial (P) or Whole(W)
SMOKE
FLAME
TIME OF
PUSH
ELAfSED
PUStI
PERIOI
(see/
CHUCK DOOR OPERATION
Check Yes C^) or No ftO
CLOSED ( LATCHED
TIGHTENED
LEAKING
ELAPSED TIME
DOOR OPEN
BEFORE LEVEL
BAR STARTS
(sec)
COMMENT
NUMBER
/X
/ UJ
/¦P
21
zrc
/?
A/
/
J
/
O
zc>
2: ^r
/>
/ F
L'.oO
COMMENTS
*1
-------
Page * of L
PROCESS DATA
COKE UVEN CONDITION Coke Side Inspector
^?ush Side Inspector^)
COMPANY KvAfSf INSPECTOR J ¦ BATTERY C , V> E
LOCATION DATE 1 / 1 fa/77
UVEN ROOF CARBON BUILDUP
DARK (COlD) SPOTS ON SIDE WALLS
UVEN i BROKEN REFRACTORY AT
DOUR AREA
Check: Indicate
Yes(^) Location:(X)
No (x) (End View)
Indicate Location!(X)
(Top Viewy'
Cftcck:
IIlustate:
Side View (best estimate)
(Indicate standpipe and oven holes)
End View
No (x1
ps
cs
cs
cs
cs
cs
COMMENTS:
-------
* c<-
Page ** of
PROCESS DATA
COKE OVEN CONDITION Coke Side Inspector
(gush Side Inspector
COMPANY INSPECTOR 4 BATTERY CjP, E
LOCATION DATE
V/J6/77
OVEN ROOF CARBON BUILDUP
DARK (COlD) SPOTS ON SIDE WALLS
OVEN ; BROKEN REFRACTORY AT
DOUR AREA
Indicate Locatiorl: (X)
(Top View)/
11 lustate:
Indicate
Location:(X)
(End View)
Side View (best estimate)
(Indicate standpipe and uven holes)
End View
cs
cs
cs
cs
cs
COMMENTS:
-------
Observer.
Date
J. l-|or*i^
\/v/n
Plant_Ji£l^r_
Battery.
o
:u
w o
fD P
O >i
rr rr
H. D*
O
o
Ul
u>
u*-
ro
f
H-
D
Cpoor.Machine Push Sido)
Door Machine Coke Side
I
a
Time of
Removal
Oven
No.
Sect.
or
?cfrac
fnrv
l Remo1
Km fe
rd
\
Q
/
\
/
'If
0
JW
/o;V
©
1
i
3
0
0
0
/
0
0
0
©
[
J
/
1
f)
©
/
O
/
©
/
/
0
©
1
0
/
1
1
o
©
\
V
V
1/
0
J
I
J
34*
©
1
1
»>
0
0
p
/
0
0
0
©
/
/
o
©
?
/
o
/
©
3
/
/
0
©
1
\
>
A
0
/
(
9
0
V
3
\
o
/
I
V
1-N'o damage on door, knife edge (nq
dents, cracks, missing sect.)
2-Physical damage (cracks, deforma-
tions, missing sect.)
»<-j|rferdtrSri|!aced vltl. a fresh
door in this cycle
/- yos
X - n0
/- which applies
j
-------
UOOI i'LUCl'lj ; III «L.
Observer J i-jor£'frl ^
"••"•" 1/^/7 7
Plant_JS^iliS
Battery.
EK
5
33
Ui
(/> rt>
¦
fU 03
n m u>
rt rr
P- p*
o
p
Ni
I-1
p*
h-
3
^Door Machine Push Sida^
Do5r-f!achrra coJse side
H1
.Condition of Door,
on Removal
Time of
Removal
Oven
NO.
Sect.
icfrac
tnry
iCnif e
Gas
Chan
Cleaning
Knife tdge
Clean
Depos
{emain
Gas Channel
Gas
Clean
~7~~
Dcpos
llcmau
Chuck Door
Clean
Depo
Remain
Jamb
Clean
Jcpos
Renin ]r
Latching Seq.
Top
Bot.
Bot.
Top
Both
QOnce
Adjustments
Time
Start
Tine
Finish
//;o&
?r<£
.0.
0
©
J
a
o
/
/
/
J
©
/
"7
/
/
o
t
/
/
*
o
0
0
T
/
/
o
r>.?
/>
1
c
0
o
J/i/r
Z£C
©
©
©
©
©
\!
4
JL
JL
o
o
/
0
r
o
L
r
/
Z
iL
/7
7T
©
//: ?!
©
Z7t
©
©
©
©
"3
9
0
/
t
f
A
/
0
/
7
o
/
£L
JL
0
0
0
o
Enter:
1-No damage on door, knifo edge (nq
dents, cracks, missing sect.)
2-Physical,damage (cracks, deforma-
tions, missing soct.)
a4-7tr^opr is°replaced with a fresh
door in this cycle
/o; CT ^
/- yes
x - no
- which applies
-------
j. MopkiNS
fibr.erucr
naho y" 6 fH
Plant:
Battery.
o
n
rt
CD Q
n> ti
r> »i
rt rr
H* Ef
O
9
r -. ^
Oi
M
M
c
H-
3
cj> rr
^Door Machlno Push sTj^
Door MachD
a
Time of
Removal
Oven
No.
Sect.
or
0
/
Q
/
0
/
0
:
©
t
i
3
/
a
/
U
/
/
©
1
1
/
/
d
/
0
I
1
$
/
0
/
©
1
1
sn
5
1
1
/
<0
r
/
i
©
1
I
V
/
)
r
/
8
J
©
-
I
]
1
1
©
©'
©
©
0
Enter:
1-No damage on door, knifo edge (nq
dents, cracks, missing sect.)
2-Physical damage (cracks, deforma-
tions, missing sect.)
-3-Carbon deposits . , ,
a4-If dopr is replaced with a frosh
door in this cycle
/- yes
X - no
which applies
I
t
W.
-------
Page f of /
PROCESS DATA
PUSHER MACHINE INSPECTOR
COMPANY INSPECTOR J , BATTERY /
——————— ' ¦¦¦¦¦ — ¦ ' lf
LOCATION fortVHr. Cal. DA1E ^ uM
OVEN
APPEARANCE Or COKE FACE
Chock Yes (/) or No (X)
Partial (P) or l.'hole(W)
TIME OF
PUSH
\
\
ELAPSED
PUSH
PERIOD
(see)
CHUCK DOOR OPERATION
Check Yes (^) or No ftO
comment
NUM3ER
CLOSED ! LATCHED
TIGHTENED
LEAKING
ELAPSED TIM-
DOOR OPEN'
BEFORE LEVEL
BAR STARTS
/"'jJ-Csec)
SMOKE
flam:
S#
/
/¦r
¦
/
/
/
/
//
U2
t
/
/
/
/
—
lA-
—
/ \
/
/
/
O
if
J.OS
1^6
/>
/A7
/
\
/
j
/
/
>
o
V
j.Ot?
—
— '
/
\
\
/
/
/
p
—
W
/
\
-7^1
—
'
/
1
/
/
/
&
/ IP'N
A D£
z:jv
1
COMMENTS:
-------
Page t of Z
PROCESS DATA
COKE OVEN CONDITION Coke Side Inspector
Crush Side inspector^
COMPANY K-A.^dk INSPECTOR J ¦ BATTERY f/6
LOCATION ToMTa^ DATE | j lt/l
77
OVEN ROOF CARBON BUILDUP
DARK (C(U,D) SPOTS ON SIDE WALLS
OVEN BROKEN REFRACTORY AT
DOUR AREA
Indicate LocationptX)
(Top View) /
11 lustate:
Check: Indicate
Yes(/) Location:(X)
No (x) (End View)
Side View (best estimate)
(Indicate standpipe and oven holes)
End View
cs 'fern
ps
cs
cs
cs
cs
COMMENTS:
-------
COMPANY
LOCATION
A.
/> C-f
PROCESS DATA
COKE OVEN CONDITION
INSPECTOR -J• /A/'S
DATE
Page
1- of
BATTERY
Coke Side Inspector
(fush Side 'lnspectojp>
//c/7V
I
OVEN
BROKEN REFRACTORY AT
DOUR AREA
Check:
Yes(
-------
COMPANY
KA !<:.(¦
LOCATION
PROCESS DATA
COKE OVEN CONDITION
INSPECTOR -1 U°Fkl*i
DATE
Page
? Of t
TnVn .S'rip Inspector^
y^ush Side Inspector
BATTERY
'?7
I
OVEN ; BROKEN REFRACTORY AT
DOUR AREA
Check:
Yes
-------
to*-f
| iui_<
' 1 ''<• ••
> - v/
1
-¦-.*¦
__L
¦>_
"0\
.0', 1
___
- -
1 1
J
1
. • L-£/
17
v ¦ i ?° i
^1Y>
?_5_
n
50
1
3
4
Yj--sL
/ .
/I
y'.'.G-". "¦ '•
•» 1'
—
/V-
L ¦ "> I.—. i ! 7
1/,
7
/ '> -
X \\
n
-
3:
. i .
13
27
i| 13
31
/ -
i 4
/.?
t /
< V
M
39
E "•
•',3
.¦•I /*;
55
.
'S
1 5
51
li >c.
\<\
t-
ie 1^
y/07
16
17
03
!i 1 '¦>
L/07
>-> /
CL-
0 ¦»
-/J-
IB
1 0
71
10
31
r- ¦
19
>-v
A3 1
39
51
10
^3
1
?0
? 1
_
0/,»
<
/32L
/V7
O'^n
—
-v>
_
22
26
22
1
23 1 V> > -
1,2
rjk
23
?8
|i 23
JL.
/i
/.?
1
7A
2.1
25
50
li
5/^.
/ 07
2 S
//
;oi
03
il 2i
'?/
?~*.
/J-'f
19
?S
15
!0^
L2_l
2fl
—1-9-
—
,
?°
/'•'<
—>i-.
27
77
'
z.
x-**-
11
/V V
a?
20
39
?0
X
56
20
5?
!3D
1
r/
r>6
30
/^,
JLOa
30
0/,
fi 3*
-V
-2l*3
Lr?ir
31
-V-
20
31
16
rr
—' iy
32
33
32
29
/-¦> V
^.3
OjL
24
-yy-
«r 1
^ — -
/ r _
~~ 57"
33
41
" 33
/6 ?
A 5
3-1
5 J
li 3t
Z.O-
/ » •" 1
e 1 /
>>1/
S?_
15_
?r,
?7
rfj.
.1 10
35
0(i
1
1
36
r37
—
/V >
s-~l~
—
??
3 f»
IB
•j /
- •*
37
30
¦3/
<2*-
—iM-
38
A?
3fl
3^
r2-/ i
A7
39
-
30
40
40
40
41
41
41
'?
<2
;i
-------
f ? u j fv£»l *> . » f »>-F ~\J'\ C C '
pJU/frj 2jQ5_j ¦_"___] ^sZ-,- JX5U'-
L
/^jj.
2Us 6-33_^_G_'i'!*
A v> A"/ iT~. i
My
3J-V:
?-r.f ,707
-------
rage
of
PROCESS DATA
CATWAlK INSPECTOR
COMPANY
LOCATION
BATTERY
INStrECTuR a..
1-17C77
DATE
L
A,
Standpipe Carbon
(illustrate carbon InnlrJu/i)
COMMENT
NUMBER
Aspiration
Steam Pressure
Collector
I'mri
2^5 su.CS
veil
Charged
tmi/
btatic Jynnnnc
Coke S/icle
usher Side
9.o yo
eof
8o$-
'T)ActZA.
C(A t n d f&A~
— -
"P&
&V3
O./Q
¦**" *7 1
J^nAi <*
c - $
Av/ r ^<(l d.
\;tl -ft o
t/0 c
COMMENTS:
Y
I i**\A cku.det)r (todh( /cO^jhh&r **» . nrM
° "jo
-------
fage . of 3
COMPANY kWje
f
PROCESS DATA
CATV.'A^K INSPECTOR
INSfECTuR
LOCATION
Zl.
DATE
/- ^ 7-77
BATTERY As/'/ ^J
Aspiration
Steam Pressure
Col lector
Standpipe Carbon
(illustrate carbon buildup)
COMMENT
NUMBER
Uven
Static Dynamic
Puslier Side
Coke Side
Cnarfjed
ll O-7
L
o., 7
COMMENTS:
-------
F
PROCESS DATA
CATWALK INSPECTOR
COMPANY fCg.rcY* <&rre /
LOCATION ?/~o,-7 £Jttr.
BATTERY A>'*£ 77r /., I
DATE
Standpipc Corbon
XiJlustraic carbon buildup)
^ I -m* ' '
Aspiration
Steaiii Pressure
Collcctor
I in i n
/c£~s li
Uven
Static dynamic
c,t2- a,:co
It®.
/o o
~
-------
PROCESS DATA
CATWALK INSPECTOR
rage I of '
COMPANY INSrECTuR J>. Mop«/tJ£
LOCATION . Cst . DATE // 7 7 /?7
~~ / /
BATTERY L> t
Standpipe Carbon
(illustrate carbon buildup)
"T.^c
¦Uveiv
Aspiration
Steam Pressure
Col lector
I1ni n
'PSssujeC
St3 tic Dynamic
Puslicr Side
Coke Side
12: K
COMMENTS:
-------
5^
Page / of /7
Larry car inspector
CHARGING TIME STUDY Topside Inspector
COMPANY" /y?/5YX- INSPECTOR *c<>/)sc/4
LOCATION /^/v/^a//^ DATE //-Z-7/T7 BATTERY Q_
t.
O/EN CHARGED
37 !
<*>?
•c
c
"—¦—^ Timnp
Process Operation —
Time
Start
E1 aps=d
Mi.n. | Sec. i
Time
Star t
Elapsed
Min.' Sec.
CQp\n».j |-| £
Number
Remove oven lids. I
I
1
'
'/ 5s~
t
Fill larry car ac coai oonKer.
1
! /
/
-7.2
\ (n)
'—
Lute standpipe cap.
Replace oven lids.
Damper oven, turn ofr steam.
Return car to bunKcr.
44
do
COMMENTS:
-------
COMPANY
PflEC ^ of
Larry car Inspector
CHARGING TIME STUDY Topside Inspector
fee INSPECTOR
LOCATION . DATE //?^7 /?"d |
Sec. I
Time
Star t
El at)
Min.
5ed , <~on"i>-pt
Sec. i Njnbor
Remove oven lids. I
I
Fiil larry car at coai bunker.
i
^V'V/
I
Move car to oven.
^
-------
5^
COMPANY _
LOCATION
Pa^e ^3 of
Larry car inspector
CHARGING TIME STUDY Topside Inspector
'/<£-€ C INSPECTOR .
f^£y\$P/. i. Q<—> date //,2'7/y7'l battery /L
OyEN DIARCED
Time | Elapsed j ron-Mii-j'it
Start I Mm,' Sec. | Nunoer
Titne | Elnps°d
Start :ia.n. Se
Process Operation >,
Remove oven lids.
i 4o
Fill larry car at coai bunf.er.
Move car to oven.
Spot car on uven,drop sleeves.
CS
Clean goosenecks,
standpipe caps ana seats.
Close Standpipe, damper oven, CS
turn on aspirating steam
PS
Charge-coal to oven:
Lute standpipe cap.
Replace oven tids.
Danper oven, turn o££ steam.
Return car to bunker.
COMMENTS:
-------
s*>
Page 4- of /7
Larry car inspector
CHARGING TIME STUDY Topside Inspector
COMPANY INSPECTOR /OlM, x .
LOCATION .. DATE / /"?'7 M'7 BATTERY
V-
OyEN CHARGED
1
X
l-
c
¦—— Timino j
Process Operation j
Titr>e | Elaos°d ij Time
Start i Mj.n.|Sec. ij Stare
El^p
! 11 n.
•
3°d I f*oni"wnt
Sec. 1 Nucioer
Remove oven lids. 1
1
i
Ful larry car at coai ounuer. |
1
^7.2
Move car to oven.
z
^ V
1
/
Spot car on oven,drop sleeves. |
1^1
t?
.
Clean goosenecks, /^^///.WZL. cs
4
standpipe caps and seats.
\
I
Close Standoipe, damper oven, CS l|
\
turn on aspirating steam. ES
i
1
'
CharRe^coal to oven:
&
/
z4
/
/f
/ \£¦
[ 03
/(-<
-------
Page
^ of / 7
Larry car inspector
CHARGING TIME STUDY Topside Inspector
COMPANY _ INSPECTOR /On,
LOCATION ^ DATE //W /'?'} BATTERY ^
V-
CX/EN CHARGED
//I 1
X
»-
c
- Ticunc
Process Operation
Tine
Start
Alaos
Mi.n.
°d i
Soc. !
Time | Elapsed ' fonc
Start | Mm. Sec. 1 Nur-ner
1
Remove oven lids. 1
\
1
I
1
f
Fill larry car ac coai bunker.
/C 0/
!
i ^
Move car to oven.
/o//
Spot car on uven,drop sleeves.
/z
Clean goosenecks, CS
1
standpipe caps and seats. fS
1
Close Standpipe, damper oven, CS
turn on aspirating stean. PS
Charee coal to oven:
/
Z'l
/
i
--7*+
I 03
/
/r>
cl'OX;
/^OC
1
Lute st/andpipe cap.
1
Replace oven nds.
Damper oven, turn off steam.
Return car to bunker.
£4
COMMENTS:
-------
5T&
Paee h of 11
Larry car inspector
CHARGING TIME STUDY Topside Inspector
COMPANY
INSPECTOR QtfK.
LOCATION fZcvjbuU.s.t DATE //&'//'7Q BATTERY P s'tZ>C
1-
tyEN CHARGED
*7.7.< ! n-7
"C
».
c
" — Timinc"
Process Operation
Tire
Start
ElaDj
Mj,n.
;°d |
Sec. 1
Time | Elaos^d ; foirpi-nc
Start | Min. Sec. ! Number
Remove oven lids.
1
1
i
i 1
Fill larry car at coai bunKer.
//> •?/
4?! 1
\44-
/o -V/ a.4. /y)
i
I
Move car to oven. t- '
/
*7 1
1
Spot car on oven,drop sleeves.
/
/o
\i<\
/
Clean goosenecks, CS
\
standpipe caps ana seats. PS
1
i
Close Standpipe, damper oven, CS I
turn on aspirating steam. PS
j
Charce coal to oven:
Ki
/
/7
/
/jfc
7
(*
Z
S£>
1
i
Lute standpipe cap.
i
i
I
Replace oven nds.
Damper oven, turn 01 r steam.
Return car to bunker.
/
*z
#Z
/
COMMENTS:
-------
Page
£
of
'7
CHARGING TIME STUDY
Larry car inspector
Topside Inspector
COMPANY
LOCATION
j&jh
INSPECTOR ^JSuTZU\f/>\,i_
BATTERY {Z-
DATE
O/EN CHARGED
Tmino
Time
Time \ Elaos^d
£•130 5 °d
f orptu.-»n
Process Operation
Start j Inn. Sec. Nunber
Start
Urn. See
Remove oven lids.
Fill larry car at coai bunKer.
4L.
,/A'f
/?+*,•/u_c<. //-v'/
-------
5^
p°Ee ^ of J7_
Larry car inspector
CHARGING TIt-E STUDY Topside Inspector
COMPANY ^"5"^ INSPECTOR
LOCATION £?\jfcKst^s-^ ^ DATE /A;/ A/ BATTERY J&.
»-
O/EN CHARGED
t*n
U1
•c
»-
c
_ Timinp
Process Operation —
T ime
Start
E '.'a p s
Mm.
°d '
See. !
* ^ t
Time | Elapsed , f~onn"j'it
Start i Mm. Sec. ! Number
Remove oven lids.
i
Fill larry car at coai bunker.
/
>love car to oven.
//\>4
f
¦?x
c //•
-
/ ' ,
Spot car on oven.orop sleeves.
//' 2/:
-------
3-fc
COMPANY _
LOCATION
Page of / 7
Larry car inspector
CHARGING TUE STUDY Topside Inspector
6 INSPECTOR ^ ^ £¦•
date / /-Z Q f'70 BATTERY
l
fl
•t
V
c
CVEN CHARGED
/T7
Ml
——- . Timing j
Process Operation ^ j
T ime
Start
E l'a p
Mm.
3°d 1
Sec. 1
Time j Elapsed j ("onm-int
Start 1 Mm. Sec. 1 Number
Remove oven lids. |
i i
" ¦ 1
i
1
1 !
Fill tarry car at coax bunker.
//'iv!
d-o 1
/¦:wj
/
Move car to oven.
&
&
'1
Spot car on uven,drop sleeves.
'1
$
//-*?<> / //'.A -/>
Clean goosenecks, ^
standpipe caps and seats. ^ fS
1
Close Standpipe, damper oven, CS
turn on aspirating steam. PS
i
Cbaree-coal to oven:
//
,/
/0
1 n
1
nj
1
1
/
Lute standpipe cap.
Replace oven nds.
Damper oven, turn off steam.
Return car to bunker.
/
COMMENTS:
-------
s*
COMPANY _
LOCATION
Page /O of /7
Larry car inspector
CHARGING TIME STUDY Topside Inspector
& INSPECTOR ^
DATE BATTERY /Q
»-
a
•c
o
OyEN CHARGED
fW !
. Timinp
Process Operation ¦—
Tinei' | Elaps
Start j Mm.
>°d t
Sec. f
T line
Star t
Ela^s°d ; ror,r,,i;'iC
Min.>Sec. ' Nunber
Remove oven lids. !
1
\
1
Fill tarry car at coai bunker. |
//. P/\
AW
/
Move car to oven.
Spot car on oven,drop sleeves.
/ft!
/n
i
!
Clean goosenecks, / CS
/
cr? i
standpipe caps and seats. f fS
/
trC I
\
1
Close Standpipe, damper oven, CSI
1
turn on aspirating steam. PS
1
Charge"coal to oven:
/
3/
/
/Sy~
I
rr**
I # 3
1Z
c4-
/
/I7
Lute standpipe cap.
Replace oven nds.
i
Damper oven, turn o£f steam.
Return car to bunker.
$'1
/
COMMENTS:
-------
5^
Page // of / 7
Larry car inspector
CHARGING TIME STUDY Topside Inspector
COMPANY C INSPECTOR
LOCATION ^ris^$7l'isU&-' DATE •/ 7^7 BATTERY
• / / f
V
OyEN CHARGED
1/1
X
»¦
c
Timno j
Process Operation 1—j
Tire
Star t
EI^ds
ilxn.
°d 1
Sec. |
i i
Time | Elapsed , foment
Stare 1 Min.' Sec. | Number
Remove oven lids.
I
Ful larry car at coai bunker.
n n
s/-0
Move car to oven.
do
Spot car on oven,drop sleeves.
4-
Clean goosenecks, CS
standpipe caps ana seats. i*S
Close Standpipe, damper oven, CS 1
turn on aspirating steam. PS j
Charge~coai to oven:
MYj.
f
/4
f$l}-
/o
-
Lute standpipe cap.
Replace oven nds.
Damper oven, turn orf scoatn.
*
Return car to bunker.
&
COMMENTS:
-------
Page of / 7
Larry car Inspector
CHARGING TIME STUDY Topside Inspector
£ INSPECTOR
&>\ DATE '/vp/V? BATTERY
t-
O/EN CHARGED
•^3 i
^6^
X
>-
c
Timinp
Process Operation
Time
Start
Elans
Mi.n.
>°d I
Sec. 1
Time
Start
El apsi=d
Mn. Sec.
romnietiL
Nurrbp r
Remove oven lids.
1
i
Fill tarry car at coai bunker.
S7 „ C
V <- ~
Move car to oven.
Spot car on oven,drop sleeves.
/&
$
Clear, goosenecks, CS
standpipe caps and seats. fS
t
i
Close Standpipe, damper oven, CS
1
1
1
turn on aspirating steam. PS
1
*
Charge. coal to oven:
/fa)
/
0*
/
/zfa.
6
/ hi*
i
i
=Sa H
w i
c
t
<2
L
|
\
Lute standpipe cap.
Replace oven nds.
Damper oven, turn off steam.
Return car to bunker.
COMMENTS:
-------
St
fage of
Larry car inspector
CHARGING TIME STUDY Topside Inspector
COMPANY
INSPECTOR 'S^&T-lJ^-crry
LOCATION DATE / /'?'? BATTERY f?
cven charged
*2<7& 1
if*
i-
C
Timinf
Process Operation
Time
Start
Elaps°d !
Min.|Sec. 1
T ime
Start
Elapsed | Copim-int
Min. Sec. | Number
Remove oven lids.
1
<
1
Fill tarry car at coai ounker.
^7 St St
Move car to oven.
4? 1
-ZG
-7
-------
Page of /7
Larry car Inspector
GIARGING TIME STUDY Topside Inspector
COMPANY
INSPECTOR pt>^
LOCATION — DATE /Vz7^ //^7 BATTERY ^
I-
OyEH CHARGED
T
»-
C
Tininp
Process Operation
Time
Start
Elaps°d
T ime
Star t
Elaps»d
i"or»^nc
Ninocr
M in.
Sec. 1
M i n.
Sec.
Remove oven lids.
1
1
Ful larry car at coai bunker.
7'-p!
£?0\
.
Move car to oven.
O'a. w^.
V r *
Spot car on uven,drop sleeves.
V 1
Clean goosenecks, CS
!
standpipe caps and seats. fS
i
1
Close Standpipe, damper oven, CS 1
turn on aspirating steam. PS
1
1
'
Charge coal to oven:
M\)
£0-
£
f
43
4
Lute standpipe cap.
Replace oven nds.
Damper oven, turn off steam.
Return car to bunker.
<2/
COMMENTS:
-------
5"2=
company
CHARGING TIME STUDY
*aee _ /C /7
Larry car inspector
Topsid c Inspector
LOCATION
INSPECTOR /Q? t. ^i^r^/^.7 ,
date / / 2^7 r7'7 battery
4-
t-
OyEN CHARGED
-c
»¦
o
_ Tijninc
Process Operation 1—-—___
Time
Start
Elapsed
T mie
Start
Elaos^d
f ontP'ent
Number
Mm.
Sec.
Min. Sec.
Remove oven lids.
J
1
1
I
1
Fill larry car at coai Dunker.
-z I ;?UV
Move car to oven.
Spot car on oven,drop sleeves.
f
/ 1
/
Clean goosenecks, CS
il
standpipe caps and seats. PS
it
!|
i
Close Standpipe, damper oven, CS
... il
turn on aspirating steam. PS
I|
'
Char^-^coal to oven:
/
O f
]t
t
*
>s-
o e
<2
//
\ ffj
i|
Lute standpipe cap.
|
il
Replace oven nds.
Damper oven, turn off steam.
Return car to bunker.
44
1
JZf
I
|
COMMENTS:
-------
COMPANY _
LOCATION
Pa8e /& of /7
Larry car inspector
CHARGING TIME STUDY Topside Inspector
C inspector /yki,
DATE / Z/1/? /y?/9 BATTERY '7
/
COMMENTS:
-------
5Tb
Page /*! of / 7
Larry car Inspector
OIARGINC. TIME STUDY Topside Inspector
COMPANY INSPECTOR _
LOCATION , /g DATE / / ^2^7 /^7 BATTERY /•
l-
0
X
»-
c
OyEN OlARCED
'— Timinc
Process Operation y
Time
Start
El 2D!
Mi.n.
"d 1
Sec. 1
Time | Elap;
Start | Jun.
-d
Sec.
COfl""!' t
Number
Remove oven lids. 1
1
I
Fill larry car at coai bunker.
.--7 ssl 1 \
s?C/ !
¦
/)Uf-r
,L
/
Move car to oven.
1
Spot car on <_>ven,drop sleeves.
id
Clean goosenecks, CS
1
standpipe caps and seats. fS \
1
1
i
Close Standpipe, damper oven, CS i|
|
turn on aspirating steam. PS
1
'
Charcp—coal to oven:
Ci\J _
<1
cM
IT~
/ 03
/
\c/Q
Lute standpipe cap.
Replace oven lids.
Damper oven, turn o££ steam.
Return car to bunker.
COMMENTS:
-------
Page of
PROCESS DATA
OVEN PORT^SEALING
COMPANY
/C
AaJ£> •S77^/=>/^Z
Cap =. c.
INSPECTOR
DATE
LOCATION . . _
Indicate clock time that any lid is either sealed cir resealed. Indicate
lid(s) sealed (i.e., lid closest to push side is II 1 lid).
BATTERY
OVEN
/
TIME
TIME
TIME
TIME
. TIME
TIME
TIME
TIME
m
(°7
jr. , f
f?
?? 1
'-9 '
-------
/S"~
Page J of j?
PROCESS DATA
OVEN PORT CARBON
COMPANY
LOCATION fr-Cl6 I / /
INSPECTOR
DATE
/
/*") BATTLRY
/. / <
Indicate carbon buildup for each oven port prior, to charging. If no carbon
is present indicate sane with (OK).
Oven
Tine
Carbon
CS PS
Comment
Number
AM
Q
M
O
%
t'P-
%
f-rr
o®oo
a!
m
O0O$O
%
id
©®o©o
i#
@®o®©
COMMENTS
•
1
1
-------
Page
of
PROCESS DATA
OVEN PORT CARBON
COMPANY
INSPECTOR
DATE
//^y?
LOCATION DATE X ^^ BATTI:RY
Indicate carbon buildup for each oven port prior to charging. If no carbor.
is present indicate same with (OiC) .
Carbon
Comment
Number
Oven
Time
7
>rb&>
COMMENTS:
-------
&r'n£.
P«Ce
3 of 3
PROCESS DATA
OVEN PORT CARBON
COMPANY
LOCATION
/7~ hszA
INSPECTOR
DATE
BATTLRY
—7 C/ > /'
Indicate carbon buildup for each oven port prior to charging. If no carbcr.
Is present indicate sar.e with (OK).
Oven
Time
Carbon
CS
PS
Comment
Number
£¦&>
®(306
to
0<&0i3
r\
D©r
?/jfl
!
2
0
©
£t(
o;
o
a
©
ooooo
ooooo
COMMENTS
*
1
I
-------
rage
of
PROCESS DATA
LARRY CAR INSPECTOR
COMPANY
LOCATION T~ONrA,N/\ . Cm .
inspector J. Hopkins
DATE
BATTERY A .B t £•
y/jJl
77
Oven
Charged
49-
37
Coal Hopper
Volurre Settings
1 2 3
Check Sheet - Indicate Yes (/} or Ho (x)
Stcain on
(Both
ends for
dual
mains)
4*
i/
/
8A and I
hoppers
dropped
first
?
IgZEti HZ
hopper*
dropped
individually
/
/
Slide 9ates
closed
after
discharging
hoppers
12 3 4
3>'
jn
///
Goosenecks
cleaned
k5
c<
t
O
/
/
P
/
i
Gooseneck Carbon I
(Illustrate Carbor Buildup
after cleani.nR)
PUjltilf STTi?
comments:
CD fVozzu r cY^/iA/!:
'fy.-.wC
C.S
5-r*rorv
©
j
-------
rage ^ of
PROCESS DATA
LARRY CAR INSPECTOR
COMPANY KAISf ft. INSPECTOR J ¦ MftPKf MS BATTERY A$
LOCATION FbMTAM A Cft(. ¦ DATE 1/11 ill
Oven
Coal Hopper
Gooseneck Carbon
(Illustrate Carbon Buildup
after cleaning)
Comment
Number
Check Sheet - Indicate Yes (/) or tlo (x)
Charged Volume Settings
-------
rage
of
COMPANY
K/\
LOCATION V OnTAnA
PROCESS DATA
LARRY CAR INSPECTOR
INSPECTOR J.HoPIMM*
DATE
yi7 77
BATTERY A ;C
Oven
Charqed
Coal Hopper
Volume Settinqs
Check Sheet - Indicate Yes {•O or No (x)
Gooseneck Carbon
(Illustrate Carbon Buildup
after cleaning)
Comment
Number
12 3 4
Steam on
(Both
ends for
dual
mains)
i
W and #1
hoppers
dropped
first
i'$*>sd ez
hoppers
dropped
individually
Slide gates
clascd
after
discharging
hoppers
1 2 3 i?
Goosenecks
cleaned
Pusher Side
Coke Side
57
y
b
/
/
///
/
o
/JjcT >\
Lr^'0')
C
97
/
J/J
jV
/
///
?" . y /
'£//
-------
rage ~ of
PROCESS DATA
LARRY CAR INSPECTOR
COMPANY INSPECTOR J • ViPPKl^S BATTERY A ^
LOCATION PpMTAMA ^ C&L. DATE \j 1 V'?
Oven
Charqed
Coal Hopper
Volume Settings
Check Sheet - Indicate Yes (»') or No (x)
Gooseneck Carbon
(Illustrate Carbor Buildup
after clearing)
Comment
Number
12 3 4
Steam on
(Both
ends for
dual
mains)
3
Iff and #1
hoppers
dropped
first
t&zzxt 8 2
hoppers
dropped
individually
SI ide gates
closed
after
discharging
hoppers
12 3^
Goosenecks
cleaned
Pusher Side
tJ- ft
i<
Coke Sid
y-r
r •
//7
i
/
i(J
1^)
/
I11
X
0
0
J11
0
0
O
0
0
0
COMMENTS:
-------
rage ^ of
PROCESS DATA
LARRY CAR INSPECTOR
COMPANY K/MSEP- INSPECTOR UoPMM\ BATTERY C Q £
LOCATION r date '/ W7?
Oven
Cliarqed
Coal Hopper
Volume Settlnas
Clieck Sheet - Indicate Yes {/) or No (*)
Gooseneck Carbon 1
(Illustrate Carbor Buildup
after cleaning)
Comment
Number
12 3 4
Steam on
(Both
erds for
dual
mains)
i^and i]
hoppers
dropped
first
rihrsHfl §2
hoppers
dropped
individually
Slide gates
closed
after
discharging
hoppers
1 2 3 A
Goosenecks
cleaned
Pusher Side
Coke Side
w
/
§
/
///
X
0
0
C
n?
/
/ 3?wv
3
/
f/{
/
0
0
M
/M
/
/
/
///
/
0
o
O
COMMENTS:
-------
rage
of
PROCESS DATA
LARRY CAR INSPECTOR
COMPANY l
-------
fage I of
PROCESS DATA
LARRY CAR INSPECTOR
COMPANY STi. INSPECTOR J HoPKims BATTERY ^ ^
LOCATION ToNTAf^ Ckl. d/vte 1/ Zl/ 77 TtiPwTA^ 0^ ^
Oven
Cliarqed
Coal Hopper
Volume Settles
Check Sheet - Indicate Yes (>0 or Ho (x)
Gooseneck Carbon
(Illustrate Carbor Buildup
after cleaning)
Comment
Number
12 3 1
Steam cn
(Both
ends for
dual
mains)
:i \
>rj> and #1
hoppers
dropped
f irst
i?2
hoppers
dropped
individually
Tr>'. i t.cv
closed
after
discharging
lioppcrs
1 2 3 d
Goosenecks
cleaned
Pusher Side
Coke Side
zrj
/
./©
n ^
/
///
X
0
0
C
/
)h
^(crhtr^
/
///
/
0
0
a
27?
/
rotnhcr.
/
///
/I
0
o
c
COMMENTS: ^ ^^ltY .
X£) All Of Thf S / /K.C /ycc*. f'/JCfiiOCr-tr,, y2?" ' L"
Tfe C.o*t o,vf?G Ui S-jr
-------
rage of
PROCESS DATA
LARRY CAR INSPECTOR
COMPANY Ka»S*R. INSPECTOR J ¦ BATTERY
LOCATION' Fotvi7Af/A . Ca*. DATE )/2-7/71 fffJ
I 1 LC
Oven
Ctiarqed
Coal Hopper
Volume SetHnos
Check Sheet - Indicate Yes (S) or Ho (x)
Gooseneck Carbon
(Illustrate Carbor Buildup
after cleaning)
Comment
Number
12 3 4
Steam on
(Goth
ends for
dual
mains)
r y
& and J1
hoppers
dropped
first
iicrfccd n
hoppers
dropped
individually
l-Ps
*5£f$z=?vX/ir
closed
after
discharging
hoppers
1.2.3 4
Goosenecks
cleaned
Pusher Side
CoVe Side
203
/
/
/
///
/
0
0
C
293
X (
<
(
Un.^c
^TUL'- 0f*
"c. s
/
/*//
X
0
0
0
>07
J
/
/
///
CP
X
0
0
c
COMMENTS: (2) ^OUlC CL£A**tc
-------
rage S) of
PROCESS DATA
LARRY CAR INSPECTOR
COMPANY K^ISCfc INSPECTOR J . S BATTERY f
YOtiT/i • DATE '/Z7/? ")
LOCATION
-t
Oven
Cliarqed
Coal Hopper
Volurce Settings
Check Sheet - Indicate Yes (-0 or No (x)
Gooseneck Carbon 1
(Illustrate Carbor Buildup
nfler cleaning)
Comment
Number
12 3 4
Stean on
(Both
ends for
dual
mains)
T 'j
•ftband #1
hoppers
dropped
first
ft-mA SZ
hoppers
dropped
Individually
¦S^trcrfratas
closed
after
discharging
liopptrs n
1 2 3 'ft
Goosenecks
cleaned
Pusher Side
Coke Side
"i'3»
/
/
/
/*/
/
0
0
O
32-^
/
/
/
///
>
0
0
0
333
/
/
/
A/
0
o
D
COMMENTS:
-------
rage ^ of 4*
PROCESS DATA
LARRY CAR INSPECTOR
COMPANY
KAlStR. INSPECTOR BATTERY _xk.
LOCATION fON'TAHfr \ CAt- ¦ DATE V 27/11
Oven
Charqed
Coal Hopper
Volume Settings
Check Sheet - Indicate Yes (/) or No (x)
Gooseneck Carbon 1
(Illustrate Carbor Buildup
after cleaning)
Comment
Number
1 2 3 \
Steam on
(Both
ends for
dual
mains)
¦st-3
"A and ff 1
hoppers
dropped
first
ra-^ssa #2
hoppers
dropped
individually
1 nf~l L 1
S^vtjr\.r " ' ¦¦ ¦1
closed
after
discharging
hoppers
1 2 3 ?a
Goosenecks
cleaned
Pusher Side
Coke Side
O
;43
/
/
/
0)
N
0
0
0
XT
/
/
J
>
0
0
0
0
0
o
comments : <^y ~pv#T //'ar o^r/i Oc/c~f /YSZ ' f^r^r (£) yfar
GTA'W 'rb/zrs
-------
r
i
fege
PROCESS DATA
PERSONNEL ACTIVITIES
COMPANY
xa
I.OCATION
/* u.
Cr> ' Sfi-
Larry car Inspector
~Jops id'.' InhiCSnr
Coke Side Inspector
Pusu Sid° T nspcc *"Or
INSPECTOR.
DATf _ /-SLP-77
T~
BATT^RV
<&¦
Indicate worker job title, number of persons working at this iob an^ brief
job dpscription, at the beginning of each day an^ when personnel change= are
made. Indicate spells provided by relief man.
TIME
Worker
Title
Desrnption 9' Operations Perfor^ea
•
i°e
— />'/¥ r£> cSzCsiaJL —
/ C^£cui-i6» — / //
- • t 1 f ^ * S • • « 4
*£ <£¦£<**<>f -r>4 C> eZJ&CxuzL.,'.?
f, / r '. J
si'tfZ&x&e. ^CtlAA. y (?-**. ^:<
' XjC- ryx-'t-u* i r> l-Vvy^ (^/ i^>?yv^ 1 <, j{/s$*Vs'M-'.P "—
tUKfhU / <>' &/ ^ bit siis* — C-^C-y^r^cJk
C^yyy. dy izsu. C^ w-t
& F
/ / /'(£<*(&»¦ •£ ~f~
t OcS'^lO
^ /*drytvt*'**.
T^^AAjA ^ 'Ci/ls¥w<£*y/ (j2&) c.
/ /
-------
r
rage
of
COMPANY
I.OCATIOM 7^7^~te^O
PROCESS DATA
PERSONNEL ACTIVITIES
INSPECTOR
DAT*
Larry car Inspector
Topside lnspeccor
Coke Side Inspector
Pu.S1" Sid" Tnspec*or
^ -l"*-—^
BATTFRV
Indicate worker job title, number of persons'working at this iob anH brief
Job d pscription, at the beginning of each day an<^ when personnel change^ are
made. Indicate spells provided by relief nan.
TIME
Worker
Title
Description 9C Operations Performed
K^(
r//•
v (
/
H- ~L \—1>
' /''-l'- y
>> -
\
' ^r/SVr/,'^
/
/
-------
CY !
* 1 1
"
I
/-iry 1 £>"'
X
< ¦_ *tr 1 or 1 "29"
3
25
•i
3
/ T'.r
29
«! ^ >
/.o
4
36
4
/s~s~
40
n52
5
V 7
r 52
5
48
. 5
e
J- ?
r/04
6
00
6
/ ^
L/b4
7
^ 7
15
7
11
. '
/9s-
15
e
^—
27
<*.//*< > > 1
6
23
B
/9S~
27
9
39
If ^
35
I g
2-oi"
39
10
L/ 7
/ 50
t 10
Lb
' 10
2 <>S~
iJQ-
1 1
/O 02
i ..
V
1 1
^ *>
^2
H
12
r>
U
3 12
10
1 2
n//6 2.
13
?
26
J 13
22
: 3
/??
26
/3 /~/' yr
t 4
/ 9
33
!i 14
34
1 4
/3?
3S
/-
15
z9
50
1 >5
46
' 15
/
36*
t !' ' 9
32
l o
36
20
> 9
57
!! 20
44
¦1 20
\/??
21
,/*? 09
21
5?
r 21
%<>?
/^o
22
y >
20
22
17
1 22
7
11"
r,y>^'7
23
)oL;
32
23
28
^ 23
^.2.7
32
24
¦z'
Q
. t
24
39
1' 24.
43
/3|//0 2 V >
25
/ 2-
/ 55
25
51
i: 25
tr/
,55
/
26
^-2.
/ 06
I' 26
02
26
y 06
27
3Z
' 18
27
H
27
'3L/
18
28
30
28
?6
i12s
/yy
30
29
¦s?-
41
29
37
ll 29
/.rL7
41
30
53
30
48
1) 30,
Y6j/
53
31
7 £
"*2.04
31
00
|i 31
?04
32
?r2
16
32
12
...
16
33_
34
9 2
27
33
23
33/
34
>yy
2-o9
27
38
38
34
. 35.
t / L
, ,5°
35
46
35
9
? y 9
S3?
v°-
^>01
13
36
/I 2-
'Joi
36
57
36
37
r
13
37
09
_37_
' _ 3 0 _
I 39
38
'
2A
30
20
I^JL
lyz
24
39
2- ^
3?
30
32
35
47
—
40
47
40
U
| 40
:
'.T2.
"
-------
£2 OYEB SCKEWJlf in mt «-i L2
TUC«
o^tnArii " "1
&*n
V t> TX
-WkVXS . (JtlATS. ITC
*•0
\
V'J
3Q
13
te
50
16 *
17
//o-
r
•fi
U? ;
19
2^
20
-
1) t 1
«
21
" 4~'
22
/JLt C
21
,*2-'
1 r> ,
24
J?/
9" ¦
25
3>y/
33 ' 1
20
^<>-J
49
1 '
£
27
rjDC
1
Z't
?£-
*7
^11
1
?e
»;
22 !
29
JO
iJ
20
31
9°J
'u. 1
31
32
~9rt
— 55 1
S2
33
vW
2_C6
33
34
17
35
f »*
35
41 {
ij-
47
«j
43
4.3 k
44
h
44 •
45 j
1
45 t
i
« 1
-------
-JloaS?/L'/4j-JZa /- Zy/22/jJ.
Ql/C.A/
Jit
^TAPfftGr
P'on-r
1
J
*
N
**3
¦—
9
Art at tCk'Ctjs*
\o
i
*
! I
I
2-oo_
_.25_3
OerV/zgZt'JCijt'-6
?o"
—
/O u
/ifrtA CtVcL ,*S6
/O "
//"
/? U
-------
METHOD C
DOOR OBSERVATIONS
*1
'A
Company
Location _
Company Rep
Inspector
Battery £~D-/£
No. of Ovens
Date /- ZC -77 ^
^-/l . Sky Condition
.J,x ' •) v,^ir|d Speed 3
D
>
/r
Oy/9
"Sl&As&e? G: //S* y<^0
/SB
, <3
£>
Z>
5"
072./
|
/ r fa
Z>
3>
if)
4 S'
/%&
Cs
5"
'J3-**/Z7 I
, fa
- / «v/
/d
— C»' —
J
ZO
y^7 7^C t ^ 1
< 7
,, 3
J/
Zo
— - r~r J
O
/
/o
07Z-S*
07ZC
/o £
/ 7
/
iO
z>« £ <*w-o!u. ^idntfOldv* \
/ f*
/2-7
-------
Company
Location
Company Rep.
Inspector
Battery
No. of Ovens
METHOD C
DOOR OBSERVATIONS
Date
z/z
/-2C- 77
JL
Sky Condition
Wind Speed _
Ambient Temp.
Background
<- <2.
f:n4*j
1>
[Indicate sun position, observation
traverse, and wind direction."!
VI NO
ID OF
LEAK*
PS or CS
/ i
OPACITYpf
%
•TIME:
START
FTNTSH
COMMENTS
3
JD
!>
/5"
P73?
1
/as
0
1
70
/5"
0Z3£T
%}Y*>G&S <3 /¦&€> J
"7
5"
1 - ^
zsr
?
ZZZ
~s-
to
2-3
**>
Zo
13
w
53*
I
f
. ^5
O
P2>
to
OI'H
I
-33
"5-3
O
O
o
0
Wtsps £?
/i ii "
2/5
n>
to
4S
/n' StaCc g/*>o
o<^
c
<
/r
\
1
\
C=chuck door, B=both door and chuck door
-------
Company
Location _
Company Rep
Inspector
Battery C-D~£.
No. of Ovens
METHOD C
DOOR OBSERVATIONS
Date
Sky Condition
Wind Speed _
Ambient Temp.
!
f
S-
OB 33
/7 ST
/2T5
> $
cz>
s-
60
oast-
V
hi
'*T
D
0
ZO
^5"
i >
tz7
c
c
to
,
3
&
zo
fO
. 7
•t *
C
T>
\
f
/6~*
IO
r?
D
V
CJ>
fO
OS38
OS^9
JO%
t 7
2
>
s
3S*
i.i
"Z_
10
g
^/Vk d/s^f 8
C»
117
/r
£s?Sr**4U. occ*xj j
plo^M. f
;3
/r
JO
' 1
-2>
10
iO
03 fS
. . Mf
1
V
' 3
1
*D=door, C=chuck door, B=both door and chuck door
-------
L_
Company
Location
Company Rep. ¦—
Inspector lA«^.g
Battery C,-D
No. of Ovens /j>«T ^
METHOD C.
DOOR OBSERVATIONS
Date
3^-2-
/-"2C-77
Sky Condition
Wind Speed _
/£/\rf?bient Temp.
g. J Ctc***.
«C 2lM-ygA
60^
^AS^&ckground /Vt )'>/
f
cs
— r~-
~j I
L
£
PS
I
ndicate sun position, observation
iraverse, and wind direction.1
VI NO
ID OF
LEAK*
PS or CS
OPACITY
%
TIME: i
START | COMMENTS
6
S
Oe>c^
VB'
rs
/o
'
ii/3
rfr
SO
/*r
i *
^ i
iO
S~
CSS2'
— -
s
/4-
C,
c*
•*s*
7)
tsr
zo
om
V
*D=door, C=chuck door, B=both door and chuck door
-------
Company
Location
METHOD C
DOOR OBSERVATIONS
te
&
/"ZC-77
Company Rep.
Inspector & .171,^
Battery C-^- ifc
No. of Ovens
7^r~'t /
1
Sky Condition
Wind Speed _
Ambient Temp.
Background
d.
^ 2.
6 o»f=-
.[Indicate sun position, observation
raverse, and wind direction.!
VI NO
ID OF
LEAK*
PS or CS
opaci/y
%
TIME:
START
FINISH
COMMENTS
J ?
-X>
<.£-
O^ot
Zp®
. >4.
~z>
1>
S"
5-
*>o%
>/
c
iT
/$¦"
0 4-
D
\
0*704-
*D=door. C=chuck door, B=both door and chuck door
-------
METHOD C
DOOR OBSERVATIONS
.Ccjl f
Company
Location
Company Rep.
Inspector (I. llvw,
Battery £&£* . '
No. of Ovens Q&
Date __
Sky Condition
Wind Speed _
Ambient Temp.
Background _
[Ind i cate
raverse,
/-<26-76
<5W
P
5
X>
to
if?
£73
77
2>
/<>
«r
273 -=> iAhS&i/W]
~5§
y%
d
c
to
to
... —
SI
c
V ¦
C3
zo
ten
/svf
....
*57
>
/r
.J.i
/5T
273> —^ 2£>f ()/cbs#uy j&ffl
72$
25
to
2S
/£/£
3 !&
U
1
fO
*-S*
*1*
~
V
P3
2e>
/S7
B
Za
IS
r^"Sf(Xc Gw&ti \
/
i eg
—^r-
O
<•5"
/O
1 I \
i
/
P h 11 /-1' rlnnv* R = Kn f h nnH r* h m r* tr
-------
Company
Location
Company Rep.
Inspector {X.
7-'c>+\4t*AAC^
METHOD C
DOOR OBSERVATIONS
//*-
Battery & /?£gJ
No. of Ovens
7-
Date
Sky Cond
Wind Speed
Ambient Temp
Background
\/zc,/-?g
ition ' t-EcrSc:
C. 2^ r vgj
t>oc,f
.
-.^*pTIndicate sun position, observation
¦:/ —Nj^verse, and wind direction.]
-{s-&u
5"""
/(s>/S
/jlcJz (Zp
?&r?
i >Z
C
->
£~
i
S
to
. ^
\r
£s
o
/(&{(&
fart
; 7
J
S-
ao
4
• V.
s
-5"
. 8
/o
g
Ifi!
s~
tu
Arise fca^lc $ b/tfA
"" 1 r »V~'
4 . r»
>
1
3S~
<
<270
zT
fbll
-------
Company
Location
Company Rep.
Inspector /£.
Battery f-LC-r I
No. of Ovenb
•s^znr
METHOD C
DOOR OBSERVATIONS
Date
£
Sky Condition
Wind Speed _
Ambient Temp.
Background
13^4- z/t-
IS /
/-£&-77
< "2.
t*ocF
icate sun position, observation
—^^oayerse, and v/ind direction.!
"7ka+rvux Oy 7^$ »V
IV_ NO
ID OF
LEAK*
PS or CS
OPACITY
%
TIME:
START
rElNISH_.
«
COMMENTS
:
&/
c
3£
j/
*n=r1nn>~ P srhnrle rfnnr R = hr»fh rlnn»~ an/~t rlnii-l'
-------
METHOD C
DOOR OBSERVATIONS
Company
Location
Company Rep.
Inspector
H
Battery .
No.'of Ovens
/ /-'3 s
Sky Condition
Wind Speed
Ambient Temp.
Background
ndicate sun positibn,
traverse, and wind
observation
di rection,]
fE NO
ID OF
LEAK*
PS or CS
4* —|
OPACITY
%
TIME:
START
.EUtLSU
COMMENTS
ll)
) ,
D
n
P
s
\
O
/J"
- ST7)$
't >
£
c.
30
f
C-'<7
o
JD
o
/>
" i
Ml
D
0
35"
0
I r
fy 7
o
h
O
J/
b^
J
Z16
)±r?
O '
c.
B
/l>
i ? •
a
8
c>
r^O
U
/!'
U
h
jr
O
h
10!)
O
n
1
/o
j
\
\
j
/
~*o
so
LT\
D=door, C=chuck door, B=both door and chuck door
-------
ibs
t irr\T. C
Company
Location
Company Rep.
Inspector <^J
Battery C O
No. of Ovens /3 f
METHOD C
DOOR OBSERVATIONS
Date
3^
J
Sky Condition,
Wind Speed
Ambient Temp
Background
2 6/7 7
- (¦/
GO '
idicate sun position, observation
traverse, and wind direction.1
iv NO
ID OF
LEAK*
PS or CS
—- m
OPACITY
%
^ " /V/
TIME: 1
START COMMENTS
FTNTSH 1
1^2 v—
/
vli
y^
f£-/T
j r
^r
ID
i-T
(' ^
/ 6
/7f - /yc/^6-C'U. 7/^.-..
i ,r
-
¦9 0
3t>
,, r
-3-S~
//
0
sr
/$'
oi/y
73
1
/
/
3D
/r
Z 3
S" S
JO
A
/o
b
2\t— X^(r y^CyJu'J L.r^-J,
. K
a/L
o
Lr £>
to
i
i
O
b
\
0
6
"> DS
D
\
£
*D=door, C=chuck door, B=both door and chuck door
-------
Company
Location
Company Rep.
Inspector
Battery
No. of Ovens
METHOD C.
DOOR OBSERVATIONS
Date
f
if cn
Sky Condition
Wind Speed
Ambient Temp.
Background
icate
erse,
U
\
sun position, observation
and wind direction.!
^aJ
(E NO
ID OF
LEAK*
PS or CS
¦
OPACITY
%
TIME:
START
FTNTSH
COMMENTS
C
c
l>
lb
3 h
hr
)r\
k>
f)
6
h
I1 >-
)0))
b
C
\
b
/6
f, '/
o
—3—
\
/
o
< L\
T'/1/
,SK''0 b
)=door» C=chuck door, B=both door and chuck door
-------
Company
location
Company Rep.
Inspector
Battery
No- of Ovens
012 A. ¦'
fo)U-u
METHOD C
TOR OBSERVATIONS
Date
CS
PS
Sky Condition
Wind Speed
Ambient Temp. C?
Background
¥?•
V
^ / ,'U L. C x t
[Indicate sun position, observation
Drse, and wind direction.]
VI NO
ID OF
LEAK*
PS Dr CS
OPACITY
%
TIME:
START COMMENTS
FINISH
z '¦(
D
6
P
j>D
S(\
fO'^t
vST"7! *7~
C*
h
&
cA G
a
&
c
'
35"
2 Y
*k C>Ll
ZJ
c
/o
' ^
&
0
£>
&
* ? (
c_
n
t
so
O
J
;
i
D
" 1 1 A
J
J J
i*r
-7i-j
9 ?f,
w
*3o
/-j /
3V?
s.
%
t
V/
9
V
F
/ ,
3
3>:T
O
2?^*) — 0 55 yp^CcT^y-cc^
3
D
a
a)o
'
¦1 — V 5 . sf/n-ZoJ
fx
0
0
0
&
" ^3
3
t?
yo
IfH
*D=door, C=chuck door, B=l>otih door anid ctac'k door
-------
Company
Location
Company Rep.
Inspector
Battery
No. of Ovens
K
METHOD C
DOOR OBSERVATIONS
Date
\T
u
Sky Conditi
Wind Speed
Ambient TempT
Background
dicate sun positior/, observatii
traver'se, and wind direction. 1
VI NO
ID OF
LEAK*
PS or CS
—^ b
OPACITY
%
TIME:
START
FTNTSH
' /w
COMMENTS
ZW
Ii ^
O
ft
PS
/*
/»
/a*/
r sr^r ,
,7 *V
i
* i
o
D
O
o
0.
O
36
/£>
^ >i|
2L9
C-
o
/d
L/71
ov^!T
o
h
O
AO
* >L(
O
t>
6
'2-55
9 rv
n
o
O
>\ J '
a "1
o
o
V
£
/
:\3
&
2 $¦ %
1
/S
A ^ IJ
i *
¦ #
J
t.
/
}
\
P
v
~Ji>
2 5"
zHl
b
D
\1/
/£)
*D=door, C=chuck door, B=both door and chuck door
-------
METHOD C
DOOR OBSERVATIONS
Company
Location
Company Rep/ 'Cj
Inspector ^ c~7
Battery
No. of Ovens
Date /
Sky Condition
Wind Speed _
Ambient Temp.
Background _
' /O J-* *4
Is L-
JskcC't
.[Indicate sun position, observation
reverse, and wind direction.]
ID OF
LEAK*
OPACITY
COMMENTS
PS or CS
C_
/6
-------
METHOD C
Company
Location
Company Rep.
Inspector
Battery
A
DOOR OBSERVATIONS
Date
Sky Condition
Wind Speed _
Ambient Temp.
No. of Ovens
kX-i'D-
/Ay-7 7
-a~' /G A.
(7 7
Background
J" T J J 1 _ • . • /
cs
h
F
—
Ldicate sun position, observation
se, and wind direction.]
VI NO
ID OF
LEAK*
PS or CS
OPACITY
%
TIME: I
START | COMMENTS
FT M T 1
* 7
O
h
/
/o
J? /S
///A
> T?)£sr~
2 J—
1?
$
/ V~
<0
O
0
ZK/./ -^-^r
* rj
>KL
£>
f)
V
CS
O
Id
~
J-6
"W>
•3. ^-"7 ~~ Si~? 1f h^./yiyA^:<=L
3 7
V
/<2>
——1—f "
r * 1
• > /
\
i
c?-
(b
'66 7
H
/
c.
V
<-
?5
do
to
D
/I
O
/t)
'S/b
- C-
£»
/£>
a
M— f -
p
/?
J
0
D
/o
ij P;a/J5M
\
*D=door, C=chuck door, B=both door and chuck door
-------
METHOD C
DOOR OBSERVATIONS
Company
Location _
Company Rep
Inspector
Battery
No. of Ovens
Sky Condition
Wind Speed
Ambient Temp.
Background
dicate sun position, observation
traverse, and wind direction.!
L
11 . NO
ID OF
LEAK*
PS or CS
^ Vjf-
OPACITY
%
TIME:
START
-EIMSHJ
COMMENTS
t~ -
s 7
£>
&
b
AT'
3d
^¦'1
/; £>"777f&f
a *
4?
C-
&
/
O r-
X 7«-f
** •
c
p
/O
/*>
/ / / /
3 r
4
/
/O
-3 0
-------
METHOD C
DOOR OBSERVATIONS
kJ^>
rz
r~itio^cZ.
Company
Location _
Company Rep
Inspector ^
Battery ( _ P)
Ho. of Ovens
7> Wp )fr5 cs
PS
6r-_
Date
Sky Cond
Wind Speed _
Ambient Temp.
Background
;2£
-—/
Dosi tion ,-'o
F
0
c
dicate sun posi ti on,-'observation
trav^nse, and wind direction.!
zii
VI NO
ID OF
LEAK*
PS or CS
OPACITY
%
TIME:
START
,EU5llSU
COMMENTS
/r- 7
'¦ 7
D
0
.3
Jb
/?.5~
/ ,'37
s~rA ft? 1
f 6 ^
/ If
r>
o
C>
f'il
/ r
Jo
ft
o
o
1
O
c.
o
3£>
I ^
c
Lp
/e>
Kv
/ /
/f -/
sj?
c
V
O
/O
/ ^
o
/
v3 O
D
ftO
I "<
0
I
c
s
3r
4 1 *¦
u->
/ 7
0
U
t-i
l/>
/¦?
i «
/%•>
* 0
t 5
V. ?
\
to
3o
/ "X- /
^ 9
( '3
V
/
~7o
P-O
/JlrcrQ: /- Ucp
*D=door, C=chuck door, B=both door and chuck door
-------
METHOD C
DOOR OBSERVATIONS
Company
Location _
Company Rep, _____
Inspector v-4
Battery
/s-
/
'7 3
/z?
I'""
/"y
If
.
Oi fjw^^yl- ^"/ xr^SSS,
/ /
/
3d
? r
0
.3T
^ y — D 7"7 c/
&
P
V5 '
JLT
# U 1
* i
c
C-
\
/
O
3o
*
1/
'oU>
*n=Hnr>r. f.=rhnrk Hftrtr. R=hnth Hnnr anrl rhnrle rfnnr
-------
METHOD C
DOOR OBSERVATIONS
"C. f f
SL
Company
Location
Company Rep.
Inspector
Battery - VP - rr -
No. of Ovens 5~"
CS
m
Date / /2
Sky Condi tioj/ /pA,tyy
~7
Sky
Wind Speed
Ambient Temp
Background ^ ^ ^
[Ind icate sun positfofT, observation
traverse, and wind direction.]
VI NO
ID OF
LEAK*
PS or CS
OPACITY
%
TIME:
START
FTNTSH
COMMENTS
/ ,7
0
/?
R5
/
O
H
£UO
5/7"?/3?
V 9
'' 7
'CL
/?
/ S~~
ss~
^3
'¦ L—
O
&
/o
36
n /
in
C.-
c
\
/
so
i T
1*1
o
V
V
c
/ ¦
5
/*>
Ya
- ?f
//I
V
R3
/o
(3
/'7
) 9
3-S-
/33
/ 7
/o
VT
t>Y
t 3
<]
3D
/ J
-#¦ / ¦
<7 S
/o
AX / / S ) ^^Crz^3^-j
/ '£
1 n 0
so
Y5~
A / / + -t '
L —
0
Cf H sAis'^C Sl//~ Lcr^\
*D=door, C=ciiuck door, B=both door and chuck door
-------
METHOD C
Company KrAAQy^\.'
Location i f.
Company Rep.
Inspector x\
Battery
No. of Ovens
DOOR OBSERVATIONS
Date
'7 c-
Sky Condition
Wind Speed _
Ambient Temp.
Background
£
/
7Q.
^Indicate sun position, observation
verse, and wind direction.1
x1
:n 0
ID OF
LEAK*
PS or CS
OPACITY
%
"TIME:
START
FTNTSH
COMMENTS
'i
i
V
c
-x$-
n
/
!>v
^6
)
3
so
I
/jr
~
'0
H*-
I
\
/
/s-
c^-/)
3
(p
c
3
PS
2>
I
c^
p
3T
n
2
0
/?
3d
A 6
U l
7
-------
Company
Location
Company Rep. »
Inspector
METHOD C
DOOR OBSERVATIONS
Date
/£.*/
7TLe*«
-ill
lition
Sky Condition
Wind Speed 2 -
/
/^<3s£-&Api c^e&ren.
2>
D
O
Z.O
ZS*
~Z)2ryi
2.0
to
fl&O
A
?/
j
£r
i^z_
/
/r
25-
D
S"
£>
/
u>
s
n
l
u
£>
f
JUL
jL
3S~
J2_
to
25-
//<96>
/— 4* &/ctbf£ JLis Psw
-£
-------
f~~
Company
Location
Company Rep. ~ '
Inspector &.
Battery f\~G—C.
No. of Ovens /
"cs
METHOD C.
DOOR OBSERVATIONS
Date
Sky Cond
V/i nd Speed
Ambient Temp
Background
7W77
i tn on '
f\t\$rtA
rv
B
A
j
Indicate sun position, observation
rse, and wind direction.!
ID OF
LEAK*
&
PS or CS
cs
OPACITY
TIME:
START
£JNlStL
COMMENTS
mo
'9*4
t
x>
32.
23"
't?
£>
2>
/o
to
(& oJzo toHp
Z>
CD
3>
30
to
3>
hog
x>
s
5-
2)
_£l
ZD
Zo
5"
a/>M^ f 'cUs
2>
j§ Ccr-iJk
— 5\4 &h ^
T22 6/»v», < /S©
iO.
///?
x>
Jl
c/evtS 5/ck
-------
METHOD C
DOOR OBSERVATIONS
M
/
Company
Location
Company Rep.
Inspector
Battery A -p> ^C.
No. of Ovens
Date
Sky Cond
Wind Speed
Ambient Temp
Background
y^/77
ition
2. ~
n .
fTs
-^k—
rTS
£
&
—^—
J\
[Indicate sun position, observation
traverse, and wind direction.!
V NO
ID OF
LEAK*
PS or CS
OPACITY
%
TIME:
START
FINISH
COMMENTS
>S"
tZ>
C.3
I
/.cg djp t&fO
£>
I
S~
/r
V
//Z"2-
I
u
F5
//2-S"
1
1
1
vZ>
/s~
2,5~
h
10
to
3kbJU 7*™
"5-3
2/
c*
fO
/o
7
"7
'3
c.
c~
70
to
*
7
:p
2&
A
>
/r*
UZ\
SrlxdUdf U)/ 0*tU* 76 1/
*D=door, C=chuck door, B=both door and chuck door
-------
METHOD C
DOOR OBSERVATIONS
Company
Location i^*^a
Company Rep.
Inspector <£. \/r.~.—V.
Battery /y.fo-c
No. of Ovens
Date 'As/77
Sky Condition '
£?g-
Sky
Wind Speed
Ambient Temp.
Background
4 7°P
///yVe-^
[Indicate sun position, observation
traverse, and wind direction.]
*«•<
PS /10/
C
VE (10
ID OF
LEAK*
PS or CS
a—
OPACITY
%
TIME- j iO-t C* ^>vvA*i ir w<*s
START M*&m± / 'COMMENTS
FT N TSH 1 . ,
s
JO
2o
/33&
%
[/
jJrC*
c-
i
3S-
/r
§&
C>
X>
to
7-
6
S-
=7
G&srt op/
3
/s~
f-7
. Jr
JD
x>
/s
/r
£3
. 1
£>
Z>
/o
to
to
ts~
<
* >
39
£
®/s~
/<
' ?
7>
ts~
/S~
"7
>
&
T>
/
zo
r
/
ID
5"
'S+8
W
C=chuck door, B=both door and chuck door
-------
METHOD C.
DOOR OBSERVATIONS
Company
Location _
Company Rep. —
Inspector Co.
Battery A- /3 - c/
No. of Ovens
y^/77
ltron a.
C^ht^ooah *jO 7e>
l-S-
Date
Sky Cond
Wind Speed
Ambient Temp
Background
[Indicate sun position, observation
raverse, and wind direction.]
VEn NO
ID OF
LEAK*
PS or CS
OPACITY
%
TIME:
START
.EINJSH
COMMENTS
. /
D
o
/r
/ 3
zo
5"
n
2>
j>
3-
r
m
D
\
/
to
5*
ZD
1
c
<-*T
/SS^
/3s3
1
,5
«]
>
to
S
r
S"
to
*7
i
to
37
S
to
-
5
5~
~ ^
tg
to
/35"S*
S
to
i , v/
'w<& &/>*. rf c/<*?
t. H — J A ^ Ul I **• D —U/\4* U iJ/S/MA mUi . A I. Jam..
-------
METHOD C
DOOR OBSERVATIONS
Company
Location _
Company Rep _
Inspector \!c+—u
Battery j-
2 - b
67°^
sun position, observation
and wind direction.]
IV NO
ID OF
LEAK*
PS or CS
OPACITY
%
TIME: j
START
FTMTSH
COMMENTS
y*
7
2>
c
•5
/S'
/3s©
1
7?
3iT
t$j?o
^ ^ ^ 7 6jLJLt*if 6,< I
, 3
"7
/5~
/O
/I
n
<37
.
/
7r
3
V
\
/
<-r
to
!4o%
1
7
a>
r
IS
r$°7
/,2S5»
t4^-
3
c.
D
10
5"
r$i
i3
2>
(L
5"
.2-3
C-
^7
//3
Cr
Cs
/-#-//
*?7
\
/
I
77
7)
\
!
zo
/5*
(4/3
C=chuck door, B=both door and chuck door
-------
METHOD C
A2L, *3
'A
Company
Location _
Company Rep,
IrgUA-fi
DOOR OBSERVATIONS
Date
Inspector
Battery 1
No. of Ovens /SS"
Sky Cond
Wind Speed _
Ambient Temp.
Background
/As/zz.
ifion 7 /
-A
Az^L
r cs
\ PS
C
bI A
uraverse
^^ u<
and wind direction.!
)V NO
ID OF
LEAK*
PS or CS
OPACITY
%
f -w 1 I
TIME:
START
FTNI9H
COMMENTS
->
J?
/=^
/O
£<*£»» 73^ e^Q /zCr
C
c
Zo
r
'»7
c.
zs
3
p
c
15
/r
/'
7
_7>
:z>
/£
T)
X>
:z>
5-
14VZ-
f6
7
T>
5~
"T
3
c*
T>
/o
f
*7
J>
-/O
K
'7
:e>
rz>
ZS
\ \
r9
3>
\
s~
7®
\
r<
o
n
1
ZJO
s-
iQTJio
\'
*D=door, C=chuck door, B=both door and chuck door
-------
METHOD C.
DOOR OBSERVATIONS
f&x
Company
Location
Company Rep.
Inspector . f/wvf
Battery
No. of Ovens
Date
Sky Cond
Wind Speed _
Ambient Temp.
Background
t/zs/77
ition £4%
z/^
t,
Z, ~ S"
A*
^Indicate sun position, observation
traverse, and wind direction.]
ID OF
LEAK*
PS or CS
OPACITY
%
TIME:
START
Ell
W
COMMENTS
ft- (o^/
&
V
/O
/€>
ML
C5"
X>
HW
s
to
Z£>
&S~
t<>
/5~
/S"
to
S~
'S~
s
to
10
to
to
7r
32-
to
1+&
l&cJ'St j oho
\
lo » C=chuck door, B=both door and chuck door
-------
METHOD C
DOOR OBSERVATIONS
#5
Company
Location
Company Rep
Inspector
Battery
No.
'hsh?
i 11 oiY #>% pi
" S~ if
A^aTcL '
Date
Sky Cond
Wind Speed _
Ambient Temp.
Background
ndicate sun position, observation
tr^erse, and wind direction.!
of Ovens
ID OF
LEAK*
J2_
PS or CS
OPACITY
%
TIME:
START
£1NLSH
COMMENTS
/5"
to
/£¦(, /5/ bibc? hf /cPI
/
to
<>£*
jSL
1
c*
Zo
JO_
c>
c-
>5"
31
rx>
T>
zo
to
\(
zo
ISL
/5~
/S"
14^
*D=door, C=chuck door, B=both door and chuck door
-------
t
METHOD C
DOOR OBSERVATIONS
Company . -----
Location , (_A
Company Rep. ;P
Inspector "T A
Battery /j ^
No. of Ovens
Date
Sky Condition
Wind Speed _
Ambient Temp.
J3£ckground
/ fee>/?~p
LS< . / /
Lr '
-^StJndicate sun posi tion ,*« observati
raverse, and wind direction.1
on
\
•'N
IVI NO
ID OF
LEAK*
PS or CS
OPACITY
%
TIME:
START
FINISH
COMMENTS
7^
?
C
r"
f
7
c
c
JO
3b
bp
o
•z-fc
/b
"n
>o
n
so
/r
—t
*- r
J f
&
C-
6K 0
. 7
wn
c
n
^ cs>
?S~
^ t? - 2* / A*
I4
/ ?
jQ
c.
3 O
vy
r
b
3o
£>lSrT>^ CP-' (&
—i-
o~
*\
£>
n
1
JO
o
Cr
i
B
0
\k
CS
35L
5^>
^JILvL J cC^O-i
r
I***
3 O
4 D
—*——
9^0
b
-> ~?
A
\
/
!)
/
20
10
*D=door, C=chuck door, B=both door and chuck door
-------
METHOD C
DOOR OBSERVATIONS
Company
Location
Company Rep.
Inspector
Battery Q, c
No. of Ovens
Date f/2S/ 77
Sky Conditi,on
lUl
.tr ^
Sky
Wind Speed _
Ambient Temp.
Background
' x r _ v
ZT£^[Indicate sun position, observation
raverse, and wind direction. 1
aJ
)V NO
ID OF
LEAK*
PS or CS
OPACITY
%
TIME:
START
FTNTSH
COMMENTS
7>7
-x 'i
r
3
Cli
1
(O
z <=r
<~112. ,yt/s^yf C A- ! h\
1
*¦ <¦
10
/r
to
>
°>i>
&t>
-7
10
-n>o
1 7
/ y
13-7
I t
y &
I '- 7
pi
c r
/c'f
\
1/
\
/
<£~0
*//>
/ ¥¦
/v 7
0
r
P
0
S-o
/a
/')-
7 f
C
o
o
/O
hi
I i
o
c~
/ z>
-j.
in
4 '
c
V?
Xo
it
*D=door, C=chuck door, B=both door and chuck door
-------
Km
i£bu
-------
METHOD C.
DOOR OBSERVATIONS
Company
Location
Company Rep
Inspector
Battery /
No. of Ovens
C /$r
-srz5
sEL
Date
Sky Cond
Wind Speed
Ambient Temp.
Background
^rri '/ (ir-r:j
[Ip^-icate sun position,/^observation
^averse, and wind di^ction.l
l«
IV NO
ID OF
LEAK*
PS or CS
OPACITY
%
i inn:
START
FINISH
COMMENTS
77
- V?
C
6
Pb
\
/[>
30
3 7/?/f]
-r
L> f
i 3
c.
J
.Jo
/&
I" i
7L
S'l
0
/ 0
,7r
p
b
yo
"X
n
CL-
0
.2 L->
to
X
6
8
3 &
*~/o
Of
7
c.
C
30
cR 0
^5"
C
ft
J5.0
3f>
-
0
£>
33"
•*r
7
g
o
n
4
/
90
30
i
*
3
D
e5
3S-
*iO
7-
L
'
Jr
/f
¦x~
\
/
4
jy
*D=door, C=chuck door, B=both door and chuck door
-------
METHOD C
DOOR OBSERVATIONS
Company
Location
Company Rep
Inspector
Battery ^
No. of Overis
/
~T~Z
w
JJl
s
Date
Sky Condition
Wind Speed _
Ambient Temp.
Background _
[indicate sun position, observation
.t^a^rse, and wind direction.]
/! NO
id or
LEAK*
PS or CS
J
OPACITY
%
TIME:
START
FTNTSH
COMMENTS
V/
0
\
c
J> 0
6^0
*
<75"
/b
3
30
/o
*¦ r
\f
\ —»
1 ^
yo
65~
/, '
/o
So
73
t »
^LO
'//.
6-6
/d 7
3
O S~
3<9
f] '
\
/
/
JS
/<"' f
/t -
3
c
i
yd
o
3
-------
METHOD C
DOOR OBSERVATIONS
Company
Location
s
Company Rep.
Inspector n~ TL<-
Battery ft* ^ Q
No. of Ovens "
V. )
Date f/z^A")
Sky Condi ti on / £>->/r, V,
Sky
Wind Speed
Ambient Temp. s~
Background ZT^
[Ind i_tate sun position, observation
cU'/S^se, and wind direction. 1
V NO
ID OF
LEAK*
PS or CS
OPACITY
%
TIME:
START 1 COMMENTS
FTNTSH 1
<%n
% ~
iO'
UnjLi
/V
/vii Agsdza 1
fyM
P&-
i^h^A crl crt ij^Oy? )
*D=door, C=chuck door, B=both door and chuck door
-------
METHOD A
CHARGING OBSERVATIONS
Company K aW/W
Location ~
Company Rep.
Inspector
r
Date
Sky Conditior
Wind Speed
//J7/-77
~ C/
Ambient Temp. ^ o '
Background —-
V
ttery/Cv.r, j ^ -n ^
tifne of Chargc: Start 7> 1\
A
-/ Tins - 21)2 fse««wJs)
' Opacity
Charge period
Seal period
End y ^7D Total"
Maximum opacity _ZX2j1/
Comments:
lridicate sun position, observation
)sition, and wind direction:
0
0
C if*
0
5^. ^
0
Mark dominant emission points:
(S=\ z-5-—'n
v y . y
^3
d W1T¥W, Q
tte:-y/0vtn_ 4- / "3>7
..re of Charge: Starx
End ,S~ i-
TinK — 202 (seconds)
Opaci ty
Charge period
Seal period
Total
Maximum opacity
Vl/vy^
TF
Com,r^nts :
Indicate sun position, observation
>sition, and wind direction:
Mark dominant emission points:
,&r
D
c •»
¦VI
\ Ay \ 7^1 ^
Q
© " LJ
,/ —\ Tine - 20* (seconds) / X? ^
A , W | Opacity t" ^
(Jjs^ i—¦ t. ^ j / m Charge period >
gc: Start X -7 M— Seal period ^2.
Comments:
_ jttery/Oven ^ ^
Tiiro of Charge: Start ,f-n P
End ^
Seal period
Total
Maximum opacity
ndicale sun position, observation
osition, and wind direction:
Mark dominant emission points:
%
V X A ) \S\
UrWdrwm
-------
Company
Location
Company Rep.
Inspector
METHOD A
CHARGING OBSERVATIONS
Date
10^'-
3HS
Sky Condition
Wind Speed
~ - **'
-6n
All
Ambient Temp.
Background ^
Tims20% (seccods) />">
Aery/Oven ^ / ^^2- ^^Charge period I LA
re of Charge: Start /Seal Pcr1o
-------
METHOD A.
CHARGING OBSERVATIONS
Company
Location __
Company Rep,
Inspector
/1
—
7 -jX u J , C i-
0ate / ^
Sky Conditror/ J r /f .-z /
=£-
Sky
Wind Speed
Ambient Temp. L 3 Total
' Haxinum opacity / C5C^—
Comments:
idicate sun position, observation
)sition, and wind direction:
Hark dominant emission points:
r\ f
vA/\M
^ - <&>)
ttery/Oven
z >1
Tine of Charge: Start V ^
End & *\
Tine — 202 (seccr.ds) /
Opaci t>f 4
Charge period jI.if
Seal period
Total
Maximum opacity
Comments:
£5' >
idicate sun position, observation
^sition, and wind direction:
o
/A
o
r- A
o
aft
o
>
L—J
Mark dominant emission points:
^ I
t?
yvg n
Battc rv/Oven /
ina of Charge: Start ^
-------
Company
Location
Company Rep
Inspector
2
O
METHOD A.
CHARGING OBSERVATIONS
Date
Sky Cond
Wind Speed _
Ambient Temp.
Background
ltion/ (n r,!
L . 6>
, 1
LO
CCo, h,
^ /
ittery/Oven
—j Hire- 20% (seconds)
Z9 / / / ' Opacity —7
(_ ///>')' Charge period ^
..tic of Charge: Start f U /O-J Seal period
. End (b t) (~> Total -
Maxinum opacity ft *3>
Comments:
Indicate sun position, observation
osition, and wind direction:
Mark dominant emission points:
fp, f
"A f ^ r q
v wi lA
lA-i±d
<=2
ittc ry/Oven
me of Charge: Start_
End
Tine- 202 (seconds)
Opaci ty
Charge period
Seal period
Total
Maximum opacity
Comments:
Indicate sun position, observation
osition, and wind direction:
Mark dominant emission points:
r^—^Y fs=\ <* ' ' "
k/\ a
ittcry/Oven.
Tin>2 of Charge: Start_
End
Tine — 20» (seconds)
Opacity
Charge period
Seal period
Total
Maximum opacity
Comments:
ndicate sun position, observation
osition, and wind direction:
O
0
O
3 J
O
Mark dominant emission points:
S rs=\ /
RA A A^
D W? W tl
-------
METHOD A-.
Company
Location
Company Rep.
Inspector
CHARGING OBSERVATIONS
Date
t- 27-77.
ll4
Gs 4
Sky Condition
Hind Speed
r
p-*1 ¦>*
Ambient Temp. .^^
Background
¦g
/
ttery/Oven_
. .ne of Charge: Start jOt^
¦ End !0 7/&
Tint; — 20% (seccr.ds)
Opacity
Charge period
Seal period
Total
Haxirium opacity
Corrcnents:
22
//
n •*?
>Jke£
(9Q7&
Indicate sun potion, observation
Dsition, and vrw
recti o
Mark dominant emission points:
a.
\ V ) \ 7
to i? i
WW EL
//:€>!
JaS-/O
Indicate sun position, observation
)sitio'i, and wind direction:
St
Mark dominant.emission points:
fScArri rs=\
k ttva ^
/XL*/ -
B h w Q
H %j ^ ps
itlery/0ven___ ^
Time of Charge: Start II
^ ^-9 T1m2 — 202 (seconds) l/> s\ . _
C I J 57 Opacity
v ' ¦-* Charo? period /
— Se*l period 'i
End t\Q~J Total _C ,» Q
tfaximura opacity
Comments:
IC-Of b
ndicate sun position, observation
osition, and wind direction:
J
\
k
Mark dominant emission points:
}\:n ,
2?
n wtto n
-------
Company
Location
Company Rep. /-
Inspector \/f
METHOD A.
CHARGING OBSERVATIONS
Date
1-1,7-7~7
&4¦
Sky Condition
Wind Speed
C.
S-7
Qu^l
Ambient Temp.
Background (zcZaZaas a
~T> / AT7
ttcry/Oven_
Tire of Charge: Start
End It 31
Tlrre - 20S (seccads) (
Opacity u -?*¦>.
Charge period
Seal period ^
Total . ^ ^^
Maximum opacity /op**^5
Comments:, , ~
(j/ C-G-ztz-C,
^flKrnta
Tndicate sun position, observation
osition, and wind direction:
2-3
T
—p5
Mark dominant emission points:) »«:
s\'JJ C_*_ ,n „ £
}f~)K rS~~\
£
O
O "
air
) W*i
17*
S4v
T
-^ ^ ^{r
WU Li
/ /&7
litre of Chargs: Start M
End I} t> €>
Tims — 20% (?eccnds)
Opacity
Charge period
Seal period
Total
Maximum opacity
Comnreni.
u
_Q_
2.)
—&— -f
Tndicate sun position, observation
)sition, and wind direction:
j]
Mark dominant emission points:
u
\ V M
¦tfi
W\n-f p
® ^ PS
;ttery/Ovcn_
,T) > f?7
""m* of Charge: Start_
End
I h '-"f
ji
-------
K/>..
Company
Location
Company Rep.
Inspector fl-
r
METHOD A.
CHARGING OBSERVATIONS
Date
3/d4_
Sky Condition
Wind Speed _
Ambient Temp.
Background
/-Z7-77 .
* ¦¦ i
ittcrv/Ovcn .
Tine of Charge: Start 4 fSC /
. End ii_££>
Tire 20% (seconds)
Opacity
Charge period
Seal period
Total
IP
Comments• t
l-o
Tndicate sun positio^/cbservation
osition, and wind election:
Haxinum opacity
Mark dominant .emission points:
a
WTT'7 \ /' Wi
CS
ttery/Oven_ T) / /?/
ume of Charge: Start /T
End
* ...Ai? A naxin
Tndicate sun positiojnJ^observati on
)siticn, and wind ^i^ection:
£3^
Tirre - 202 (soccnds)
Opacity
Charge psriod
Seal period
_ I Total
lir a Maximum opacity
ww n
° o - -
Comrcnts:
¦ ill- /
Mark dominant emission points/
<—•>
1Z±J?L
nm r ^ ^
7Ti' / \ /T^\
u
J
ttery/0ven_
> Zo~7
T
-------
METHOD A.
CHARGING OBSERVATIONS
Company
Location
Company Rep.
Inspector
Date __ /-V7-77
Sky Condition (LU^l
Wind Speed iv^/vA
*7
j,1
Ambient Temp. observation
osition, and wind direction:
.03
IZ%
Mark domi\ian/ emission points:
W)\ )\^A
ttery/Oven_
Time of Charga: Start_
End
Hits — 20% (seconds)
Opacity
Charge p2ricd
Seal parlod
Total
Maximum opacity
Comments
* idicate sun position, observation
isition, and wind direction:
7
Mark dominant emission points:
rS=\ f0' >°t]
k;\ a >x^\\ ^1
b
Battery/Ovcn_
"nc of Charge: Start_
End
T1ira^20S (seconds)
Opacity
Charge period
Seal period
. Total
Maximum opacity
Comments:
ndicate sun position, observation
position, and wind direction:
Mark dominant emission points:
rs==\ ^ri
) \ )\A
rt wy-T7w n
-------
METHOD A.
CHARGING OBSERVATIONS
Company
Location 7^'-,, ¦/
Company Rep.
Inspector __
A-
^ r>wTX
-3L O' <"
Date
Sky Cond
Wind Speed
Ambient Temp.
Background
iti/n '
.tery/Oven
12 of Charge: St«rt__^XX2_
End
Tire?: 202 (seconds) ^ ^ ^
Opacity /*-~7~ '
Charge parlod
Seal period
Total
Hanimum opacity
a
Comments
u
Indicate sun. position, observation
siticn, end wind direction:
Mark domirumt emission points:
v7 V V \ ) W^[ ^
tfW il
T
E tery/Oven
1 j of Charge: Start ^2 /O
End >:?
Tins- 20% (seconds)
Opacity d/
Charge period ' v—¦5
Seal period
Total
Haximux opacity
Coircnsnts
3
I2EZ
Indicate sun position, observation
p ition, and wind direction:
Mark dominar)
jd
OnV EW \,/1 / \ ^
D Wtr¥W &
t emission points:
zna
B, cry/Oven
Tire of Charge; Start
_ T1ira £201 (secon
Opacity
JL ——-^r— Ch2rce neri
conds)
Comtrents:
End fX
Ch2rge period
Seal period
Total
Maximum opacity
/
HI
,/^L
I-Jicatc sun position, observation
p ition, and wind direction
1n
Mark don^nant emission points:
1"
:7TV7T~7X^i
ry0
¥W 0
-------
METHOD A.
Company j/\ y
Location * \£~,
Company Rep. - \ X,—
Inspector M
CHARGING OBSERVATIONS
Date
Sky Condition
Wind Speed
Ambient Temp.
Background
/ /-7-1
- t ,» <
3—x
rltl
ims
¦ter.y/Ovgn r
VI of Ch&r^T: St
/
Time ^ 202 (seccads)
Opacity
y /--v
/ Charge period f ition, and wind direction:
Mark dominant emission points:
Jc
\ l\ )\J\
n w¥"Tw
-------
METHOD A.
CHARGING OBSERVATIONS
'/z.
Company
Location _
Company Rep.
Inspector Jl
Date
Sky Condition
Wind Speed
1-2.7-71
2^.
—J
Ambient Temp. .
Background 51a. tL
& / 3' S
aUery/Oven_
ins of Charge.: Start /'¦rcC'-.
End
i
Time- 20% (seconds)
Opacity
Charge ptriod
Seal perlc'd
Total
Maximum opacity
Comments:
MiGL
/¦p
?>«
Indicate sun position, tfbser
'osition, andi wind\h recti on:
ant emission points:
A )XSs
attery/Oven
Tire - 202 (seconds)
Opacity ~ -r>/?
Charge period _&£Sh
Seal period /
ire of Charge: Start S" , ~
End /?04 Total
Maximum opacity
Mark dominant remissicn
}Vt6"yo
Indicate sun ^osit4on , observatio,
n^"
sun *£os
osition, and \Vi d direction
id
Comments:
fl6Lca^.
1/ ts :
^¦¦ZA-j-ZaI / W^j -/?]
YWW w~vR" n
to rr Ms
¦t
A Time £202 (seconds)
(sr / 3p3 a-<
Comments:
attcry/0ven____=___J -
Tine of Charge: Start /S Z1 U
End 1
'ndicate sup posi^sa, observati
osilion, and wini.^/^recti
Charge period
Seal period
Toti
Maximum opacity
Z7€T
on
Hark dominant emission points:
i^Fa r—\
D:
SZDZZIZB^
ft
J
-------
Company
Location
Company Rep. — .
Inspector < <" Or*
Background «£¦
—
ttery/Ove
r'Oven £
'A
Tiir<2 of Charge: Start_
I5H?
Time — 202 (seccads)
Opacity .<5
Charge period lr~>* _
End
Seal period
* : '
idicate sun posT^oiT, observation
>sition, an/d wind *di r^TAi^Toi-
Total
Maximum opacity
O.-b
Comments:
"^2. I*d
iZ2> *
11-.
ission points:
Mark domin
vA'i/\ ,.-3
!'
to*
ttery/0ven_ /* / rr-?
Tine of Charge: Start /S^/'
End
¥W JJ
_ -Jr.., rS.
8
Tirre~ 202 (seccr.ds) IA ./\S\ . Comments:,
Opacity ~A / A
Charge period JQ
Seal period —<2*3
Total / Ap »< A* S^JfS.
Maximum opacity /A>>^ m_rt>K
idicate sun posi tiorK/'-rfservati on
>si lion, andj wind di r-^^on :
, ^3.
„ , / . ^ . cAa^
Mark jdomi aant^emi ssion p^nts:
^1
/' fJ
KAW A /W1
W~WW lL
" f f<5
Battery/0von_
rr? of Charge: Start_
End
Time ~ 202 (seconds)
Opacity
Charge period
Seal period
Total
Maximum opacity
Comments:
idicate sun position, observation
position, and wind direction:
Mark dominant emission points:
nf
^ r
\^x
Ol A )\^\
L?1
VTOV7 \ /xUn/ ff
-------
Company
Location
Company Rep.
Inspector &%\^cs
v/I_ * T
CS «--¦«"
METHOD H
TOPSIDE OBSERVATIONS
Da te
"ikf
i/f
Sky Condition
Wi nd Speed __
Ambient Tenip
t~ Z.7-J1
<¦? - jfr
Battery
number
[-.I^R^e^rte sun position, observation
traverse, and wind direction.]
Total
..... /=
Background 4in /'r/g. S&£
r~ 7 ' t*S /
10191 A j-j_- Offtake
number of: Ovens Htq Lids /3jS systems 7O
lime
li.section
Started/
C« )leted
Visible Emissions
Signifi
cant Leaks
Total Leaks
Collection? Number ; Number of Hum
1 Mains t 1 of Lids Offtake Off
IJumber of
take
LSyjs±£jns Sys t ems
Oven
Mumber
Comments
-\C3/£-
_
€? 'C.
&
c,.S.
Indicate location of leak:
I
Base
\-0 (Lj/f
= B, Can = C, Saddle = S, Fiance = F, OLher = 0 /
lecarbonizing indicate: Ignited = I, Ionited with Emissions = IE,
Emissions only = E
-------
METHOD M
TOPSIDE OBSERVATIONS
Company
Loco t ion
Company Rep. ——1
Inspector (X t )/,y.
Date t/^7/77
Cl/w C"AnH i ^ nn ' UTT/
Sky Condi In on
Wind Speed
Ambient Temp
2. **T t'.A'r*1*
Background h-Z&L. XL <> £7 £
ifinn Ahcrtv^i/.il iAn "
Battery
number
¦N^^indicate sun position, 'observation
\ jtr^verse, and wind direction.]
Total
number of:
Ovens
Lids
CM
/% systems
90
line
Ii ection
Visible Emissions
Total Leaks
j Signi fi -
cant Leaks!
Cc iletGu
Number
Ma "1 n s
of Lids
Offtake
..Systems
Offtake : Comments
Systems
s~z
, /
/
•*
C3^
7"! AJ ! ' \ 1 i
7~
/
s
fc
r.
t
/
/
£>
C
Q'C
3f
[>
t
i
tCb
&
c,
c-
V
7l
t
/
/
0
C-
7:r
7>
/
£
0
/
"6V
1
1
r
2-
0
c-
II lecarbonizing indicate
Ignited = I, Ignited with Emissions = IE,
Emissions only = E
w
-------
Company
Location
Company Rep.
Inspector
CS|
PS
Battery Total Offtake
number number of: Ovens Lids systems
ime
In .ection
Started/
Cc 'leted
Oven
Number
Visible Emissions i
Comments
I Signifi-
Total Leaks bant Leaks
Collection! Number Number of Number of
Mains !of Lids . Offtake Offtake
1 1 Svsf.pms Svsterns
si
k)
1
-
1
>
" » W1
%?£ Q
S?- T\
1 ' ; ° i C
/ ¦ o c.
, ^¥c
c
•
Indicate location of leak: Base = B, Can = C, Saddle = S, Flange = F, Other = 0
11 lecarbonizing indicate: Ignited = I, Ignited with Emissions = IE,
Emissions only = E
METHOD H
TOPSIDE OBSERVATIONS
Daty<7 ( -4-
-T/Z
*7 /Arjbicnt Temp.
yWjDicnt ier
Background
[Indicate sun position, observation
traverse, and wind direction.].
H
-------
*3 //,
METHOD H
TOPSIDE OBSERVATIONS
Company
Location
Company
Inspecto
-L;/-
CS
rjr. -J.
f f v»\ ^
/ > I /
^ -Vr> • y
Date /- £,7-7 7
Sky Condition c>ru*
*S . _ / *
Wind Speed
<»
Jattery
number
Ambient Temp. 35"^,g* ^
Background An/.5^££/'? /£w
I [Indicate sun position, observation
jS. traverse, and wind direction.] '
Ovens
Total
number of:
Lids
Offtake ^
systems V &
ime
[n ection
Started/
leted
I
nys.t ems L
Comments
O
i ?A
'B-.SL
/IS
tP&\
US
J1L
I I Z. C*
2~ I !Zf S^vy/^:/7W, ^V-&=rV-
y If ' I
2L
I
I
c.
c,
/G«3
i
/
/
/
I
Indicate location of leak: Base = B, Can = C, Saddle = S, Flange = F, Other
11 iecarbonizing indicate: Ignited = I, Ignited with Emissions = IE,
Emissions only = E .
= 0
-------
!^Ck » *?
Company
Location
Company Rep.
Inspec.tpr
CS /I—
METHOD H
TOPSIDE OBSERVATIONS
Date
^ //
/-Z7-77
5^/ps;
-rjHrTLfo'fcate sun position, 'qbservation
traverse, and wind direction.]
Sky Condition
Wind Speed _
Ambient Tenfp. _
Background /<>¦* /t^Crt f
Z ~ 5"
Battery
number
/I-
Total
number of: Ovens
#5"
Lids
c#t 5^'^ "~o? yiL^-f
/3S"
Offtake ^
systems / ^
Time
I' pection
Oven
Visible Emissions
Total Leaks
Signifi- .
:ant Leaks
Collection! Number i Number of Number of!
Cnm-Dl eted
Number
Mains
of Lids . Offtake , Offtake : Comments
! Sv<;t.pm^ Sv.trm*; '
>tvr?
/ 1 o
c_
.??
2- 1 Z- i 6'} O
2. ! t c.c.
\
£4
t
t
/
0
o
C-
O v
*7
2.5*
/
/
f
a
-------
///
METHOD H
TOPSIDE OBSERVATIONS
v* e%
Company
Location
Company Rep.
Inspector £>'>
Date
Sky Condition
Wind Speed
Ambient Temp.
/-Z7-77
si k'Qr's*
2 — ?T
Battery
number
S
[Indicate sun pos
traverse, and wind direction.]
I ll II U I I I I 111} J • ^ ^ m ^ ^
Background Acfs} /k*
ition, gbservation
Total
number of:
Ovens
4s
Lids
rfy***
Offtake
A3^ systems /O
Visible Emissions
Time
I pection
Sorted/
C™ple\.ed
Total Leaks
Signifi-
:ant Leaks:
Oven
Number
Collection! Number : Number of Number of
Mains of Lids , Offtake Gfftske
j_Sy^l em s iSysz ems.
Corrmant:
¦
\C
-------
g''
METHOD H
TOPSIDE OBSERVATIONS
Company
Location _
Company Rep.
ir
S?f'\
¦y .'t
r
Insp^ctpr
ft
//^ 7/7,
Sky Condition
pst:
Wind Speed _
Ambient Temp.
Background _
C\,
j ^ ,v
[Indicate sun position, 'observation
traverse, and wind direction.] ' ^
Batter/
number
£
Total
number of:
Ovens
^'/^) Lids /3 5~~
Offtake
systems
j
lime
Inspection
St av,ted/
C< ileted
Oven
dumber
Visible Emissions
Comments
j Signi fi-
Total Leaks cant Leaks
i
Collection
Mains
Number I Number of Number of
of Lids : Offtake ' Offtake
Sv^i.nms Svst.ems
>Xbt>
-
J
/
V 1 "
1
/ o >
-m j
*
/ | i j ^
; ! i 5771^0 f'rcJ
i
J
i *»
1
<3.1%
/ 1 7
2 !
cS
-XuJT
-
cL3&
>
/
/
CJ
C-
¦zr yx /
e^i
2/ T
/
/
C.
CI
-t-
c*Y3
„?r>-"
/
/
C.
C
't
£
-c 1
\ /
\J/
Indicate location of leak: Base = B, Can = C, Saddle = S, Flange - F, Other = 0
I lecarbonizing indicate: Ignited = I, Ignited with Emissions = IE,
Emissions only = E
-------
Company
Location
Company Rep..
Inspectori
AA~
Battery
number
METHOD H
TOPSIDE OBSERVATIONS
LJ-
KL
-J 7 -'IS A.
Date ^
Sky Condition /
Wind Speed _
Ambient Temp.
Background
t '
.[Indicate sun position, observation
averse, and wind direction.]
-
Total
number of:
Ovens
VI
/ 'g'r—Offtake
Lids / ? J systems
ime
Ir ection
Started/
Cc il eted
Oven
Number
Visible Emissions
Comments
Total Leaks
Signifi-
:ant Leaks
Collection
Mains
Number ¦ Number of dumber of
of Lids ; Offtake J Offtake
Systems Svst.pms
/bin?
/ 67l~(
/7«T
/
c.
/2>1
V i \
/ 1 / 1 c^.
u
/y>\ .
)5"V 1
/
2L
J
t:./=
"rs£
/Lo s-C?
-------
Company
Location _
Company Rep.
Inspector
CS
V/y
METHOD H
TOPSIDE OBSERVATIONS
Date
Sky Condi
Wind Speed
4ft
•1/
Ambient Temp.
Backaround
2
Battery
number
C.
[Indicate sun position, observation^^/,
traverse, and wind direction.] '
Total
number of: Ovens / J Lids
Offtake
systems
ime
Inspection
>t ted/
,o leted
Oven
number
Visible Emissions
Comments
j Signifi-
Total Leaks bant Leaks
Collection
Ma ins
Number 1 Number of Number of
of Lids ; Offtake : Offtake
Svst.ems Sv^f.ems
l 'Ol
f$
i
fO(
/
)
t
'p H.
/
/
rli)
T
Ir "cate location of leak: Base = B, Can = C, Saddle = S, Flange = F„ Other = 0
Ii Jecarbonizing indicate: Ignited = I, Ignited with Emissions = IE,
Emissions only = E
-------
Company
Location
Co
PS
Company Rep.
Inspec^o^^
/ £ \iC ~T
:t
vT f)rcL.
METHOD H
TOPSIDE OBSERVATIONS
Date
#f
d
>>
Sky Condition/
Wind Speed
Ambient Temp.
Background
/ /?7 A*7
si/..
/
[Indicate sun position, 'observation
-traverse, and wind direction.] 1
Battery
number
3X
Total
number of: Ovens
Offtake s--}
systems
ime
Ii icction
Started/
C( ileted
Oven
Number
Visible Emissions
Total Leaks
Signifi -
:ant Leaks
Collection
Ha ins
Number
of Lids
Number of Number of
Offtake | Offtake
Systems .Systems
Comments
1 i, L\
t^r
i
M> L //£> cesfA'/so/sj
I
I
i
i i
^\|
-/ 1 /
/
h'ib
/ 6 -/
/n %
/
/
-4—i ^^
-
W
-------
Company
Location _
Company Rep.
Inspectoryf
CS
METHOD H
TOPSIDE OBSERVATIONS
c4
~TJ7,
S. .
PS
Date %
Sky Condion
Wind Speed _
Ambient Temp.
Background
C >"
/ £
[Indicate sun position, 'observation
traverse, and wind direction.]
.3^>7 . -JiS/^tz'SLj
Battery
number
Total
number of:
Ovens
4
/—-Offtake
Lids / <--> J systems
, ime
Infection
it ted/
Ic . letcd
Oven
Number
Visible Emissions
Comments
Total Leaks
Signifi -
:ant Leaks
Collection j f,'umber Number of Number of
Mains of Lids ; Offtake j Offtake
1 ! Sv<;1-.pm<; ' Svstnms
7 "J 5
/ -
P\ f>"
A A -T
/
/
i" i
n n1
WCf
. ! '
! !
'/ ',$(*
't'.bc(
SL<\
-------
t/p
METHOD H
TOPSIDE OBSERVATIONS
Company
Location _
Company Rep
is nee tor*-.
tCufr*.
Date
Sky Cond
Wind Speed
/Ai/jl
111 on ' ^c
Ambient Temp. _
Background
-3jC^
[Indicate sun position, gbservation
traverse, and wind direction.]
>
Battery
number
Total
number of:
Ovens
Lids /3S
•fc~%
Offtakl
systems
Z*~ 1
, A°/
' , * *. ->
j
/
/ i ^
, > i'l"> it
2sn
Z-1*s
/
/
O
/=¦
O
Z£<7
...25?/
/
/
o
-------
Company
Location
Company Rep.
Inspector
CS
PS
Battery
number
METHOD H
TOPSIDE OBSERVAT
Da te . ^
Sky Condj-tfon
Wind Spfed / j
Ambi en t TenipS^T
Background A
[Indicate sun position, 'obierva_Li©fr
traverse j and win J fdireej:ion. ]
Total v*
number of: Ovens Lids
Offtake
systems
ime
Inspection
St" ted/
Cc >leted
Oven
Kumber
Visible Emissions
Comments
1 Signi fi-
Total Leaks cant Leaks
1
Collection'; Number • Number of Number of
Mains jof Lids : Offtake Offtake
i ! Svst.ems Svst.eir,?;
7J74- r
/ | / !<£•
t \ 0 \
£?7 !
253!
1
!
1 i
i
Ir-Hcate location of leak:
I
Base = B, Can = C, Saddle = S, Flanqe = F, Other = 0
iecarbonizing indicate: Ignited = I, Ignited with Emissions = IE,
Emissions only = E
-------
Company
Location
Company Rep.
Inspfr^tor,^ _
METHOD H
TOPSIDE OBSERVATIONS
Date
j,
/- -L7-77
¦ w
s* T7
Cr-» . \
Sky Condition
Wind Speed
Ambient Tenip.
Background X
"~r\
7 f __
[Indicate sun position, observation
traverse, and v/ind direction.] /
Cj>> 5
lme
Ir ection
Started/
Cc ileted
Visible Emissions
Total Leaks
Sigr.ifi- '
bant Leaks i
Oven j Collection' Number . Number of Number of
Mains j of Lids , Offtake ' Offtake
_LSy£±ejDS__j_Sy.s_tems ¦.
Number
Comments
^
v-jf j.—y-~- / / — / -
3 | f /
> 1
w/n^ss^
/-
Indicate location of leak: Base = B, Can = C, Saddle = S, Flange = F, Other = 0
Ii Iccarbonizing indicate: Ignited = I, Ignited v/ith Emissions = IE,
Emissions only - E
E-l
-------
Company
Location
Company Rep.
Inspector _
CS
METHOD H
TOPSIDE OBSERVATIONS
Date / /¦->-->/77
Sky Condition
Wind Speed Q'-~ yf ...V
6-
Ambient Temp.
Background :/,
Battery
number
indicate sun position, observation
iN\ttraverse, and wind direction.] J?
Total
number of: Ovens
Offtake
systems
Time
Inspection
St:,v"ted/
& dieted
Oven
"umber
Visible Emissions
Comments
1 Signi fi-
Total Leaks cant Leaks
!
Collection
i
14 _ ~ '
ria i ns
Number , Number of Number of
of Lids 1 Offtake Offtake
' Svsf.pms Svst.pms
3>7C
/
/
V;27
/
/
1 i
1 1
'* ~pt>
/
y ?f,bl
.2$r
*S7
1 1
C
r
2U-
/
/
C
fwy
d.y}
A-"7 /--
/
/
/
C-
? f"
A?^
? -7
rn / >
/
y
e~
o__-
/
/
/
/
&
O
Indicate location of leak: Base = B, Can = C, Saddle = S» Flange = F, Other = 0
I decarbonizing indicate: Ignited = I* Ignited with Emissions = IE,
Emissions only = E
I I
-------
Company _
Location
Company Rep.
Inspector
METHOD H
TOPSIDE OBSERVATIONS
Date
/ /27 /^>y
Sky ConditVor/ ^
CS
PS
Battery
number
E
'C--K
_3_
M7
>-t J '¦ ¦
Wind Speed
Ambient Temp.
Background
[Indicate sun position, 'observation 5/-^,
traverse, and v/ind direction.] ^
- L
Total
number of:
Ovens $5-
Lids
Offtake
systems
ime
Inspection
SI ted /
Cc >1 eted
Oven
Number
Visible Emissions
Comments
Total Leaks
Signifi-
cant Leaks
Col lection
Mains
Number j Number of Number of
of Lids ; Offtake _ Offtake
i Systems ' .Svst.pms
/
)
i
1
c>
-------
METHOD H
TOPSIDE OBSERVATIONS
Sky Conditio!
Wind Speed
SSZSZ.
Ambient Temp.
Background
Company
Location
Company Rep.
Inspector
icate sun position, 'observation
traverse, and wind direction.]
Battery
number
/* Total J'T A~2 < Offtake
number of: Ovens { J Lid^ ' ' systems e
ime
Inspection
Stated/
Cc listed
Oven 1
!\'jr.:ber :
Visible Emissions i
} Signifi-
Total Leaks cant Leaks
j
Comments
Col 1 ecLion
Mains
Number Number of fiumber of
of Lids ' Offtake Offtake
! Svstpms Sv<;1.pm<;
rz?
0/ |
J A3 1
j. \ ^
ZL ! *
1
I^L !
I / ! i c-
i / ! ' '
\ '} '
S<*U
/
/
' \c-
/ I r.
'? (/
1
-o;/f
Ol> o
"3n &
"Z-
/
3/7
^'X
/
z.
/
}lq
31"/
/
y
r\,
} 7 J
?^7
/
I'
Indicate location of leak: Base = B, Can = C, Saddle = S, Flange = F, Other = 0
11 lecarbonizinc] indicate: Ignited = I, Ignited with Emissions = IE,
Emissions only = E
i l
-------
Company
Location
Company Rep.
Inspector
METHOD H
TOPSIDE OBSERVATIONS
Date
II
j»-/ -i~y
-77^- ''
Sky Condition/
Wind Speed
Ambient Temp.
Background
z
-7
s* £
s
7
—/
[Indicate sun position, 'observation ^j/'
traverse, and wind direction.] cr
Battery
number
Total
number of:
Ovens
cf^ Lids /->s
Offtake
systems
1
/>
ime
nspection
>t" ted/
^0 leteu
Oven
Number
Visible Emissions
Total Leaks
Signifi -
:ant Leaks
Col lection1
Mains
Number ; Number of Number of
of Lids | Offtake ' Offtake
! Sv<;f.pmc; ' Sv<;f.pm<;
Comments
3X)
" /
/
¦3^ *
l.O
Z7=
y
/>
3 > I
y
cyc-
)
<
In^'cate location of leak: Base = B, Can = C, Saddle = S, Flange = F, Other = 0
If ecarbonizing indicate: Ignited = I, Ignited with Emissions = IE,
Emissions only = E
------- |